Electracool L
Contents
1. Inhalation Remove to fresh air If not breathing give artificial respiration If breathing is difficult give oxygen Call a physician Ingestion Induce vomiting immediately as directed by medical personnel Never give anything by mouth to an unconscious person Get medical attention Skin Contact Remove any contaminated clothing Wash skin with soap and water for ADVANCED THERMOELECTRIC For Information Call 1 800 250 2920 electracool com Nashua NH 03062 USA international Inquiries 603 888 2467 rev 7 03 ElectraCOOL LA550 Chiller July 2003 at least 15 minutes Get medical attention if irritation develops or persists Eye Contact Immediately flush eyes with plenty of water for at least 15 minutes lifting lower and upper eyelids occasionally Get medical attention immediately Note to Physician Give sodium bicarbonate intravenously to treat acidosis Urinalysis may show low specific gravity proteinuria pyuria cylindruria hematuria calcium oxide and hippuric acid crystals Ethanol can be used in antidotal treatment but monitor blood glucose when administering ethanol because it can cause hypoglycemia Consider infusion of a diuretic such as mannitol to help prevent or control brain edema and hemodialysis to remove ethylene glycol from circulation 5 Fire Fighting Measures Fire Flash point 111C 232F CC Auto ignition temperature 398C 748F Flammable limits in air by volume LEL 3 2 UEL 152. 3 Slight to moderate fire hazard when exposed to heat or flame Explosion Above flash point vapor air mixtures are explosive within flammable limits noted above Containers may explode when involved in a fire Fire Extinguishing Media Dry chemical foam or carbon dioxide Water or foam may cause frothing Water spray may be used to extinguish surrounding fire and cool exposed containers Water spray will also reduce fume and irritant gases Special I nformation In the event of a fire wear full protective clothing and NIOSH approved self contained breathing apparatus with full face piece operated in the pressure demand or other positive pressure mode Toxic gases and vapors may be released if involved in a fire 6 Accidental Release Measures Ventilate area of leak or spill Remove all sources of ignition Wear ADVANCED THERMOELECTRIC For Information Call 1 800 250 2920 electracool com Nashua NH 03062 USA international Inquiries 603 888 2467 rev 7 03 ElectraCOOL LA550 Chiller July 2003 appropriate personal protective equipment as specified in Section 8 Isolate hazard area Keep unnecessary and unprotected personnel from entering Contain and recover liquid when possible Use non Sparking tools and equipment Collect liquid in an appropriate container or absorb with an inert material e g vermiculite dry sand earth and place in a chemical waste container Do not use combustible materials such as sawdust Do not flu
3. ElectraCOOL LA550 Chiller July 2003 ElectraCOOL L A 550 ADVANCED THERMOELECTRIC LA 550 AIRBORNE CHILLER 550 Watt Rack Mountable Thermoelectric Chiller ADVANCED THERMOELECTRIC For Information Call 1 800 250 2920 electracool com Nashua NH 03062 USA international Inquiries 603 888 2467 rev 7 03 ElectraCOOL LA550 Chiller July 2003 MSDS for Coolant ETHYLENE GLYCOL MSDS Number E5125 Effective Date 02 25 99 1 Product I dentification Synonyms 1 2 Ethanediol glycol 1 2 Dihydroxyethane Ethylene Alcohol Ethylene Dihydrate CAS No 107 21 1 Molecular Weight 62 07 Chemical Formula CH2OHCH2OH Product Codes J T Baker 5387 5845 9140 9298 9300 9346 9349 9356 L715 Mallinckrodt 5001 5037 2 Composition Information on Ingredients Ingredient CAS No Percent Hazardous Ethylene Glycol 107 21 1 99 100 Yes 3 Hazards I dentification Emergency Overview WARNING HARMFUL OR FATAL IF SWALLOWED HARMFUL IF INHALED OR ABSORBED THROUGH SKIN MAY CAUSE ALLERGIC SKIN REACTION MAY CAUSE IRRITATION TO SKIN EYES AND RESPIRATORY TRACT AFFECTS CENTRAL NERVOUS SYSTEM J T Baker SAF T DATA Ratings Provided here for your convenience Health Rating 2 Moderate Flammability Rating 1 Slight Reactivity Rating 1 Slight Contact Rating 2 Moderate Lab Protective Equip GOGGLES LAB COAT VENT HOOD PROPER GLOVES Storage Color Code Orange General Storage ADVANCED THERMOELEC
4. TRIC For Information Call 1 800 250 2920 electracool com Nashua NH 03062 USA international Inquiries 603 888 2467 rev 7 03 ElectraCOOL LA550 Chiller July 2003 Potential Health Effects Inhalation Vapor inhalation is generally not a problem unless heated or misted Exposure to vapors over an extended time period has caused throat irritation and headache May cause nausea vomiting dizziness and drowsiness Pulmonary edema and central nervous system depression may also develop When heated or misted has produced rapid involuntary eye movement and coma Ingestion Initial symptoms in massive dosage parallel alcohol intoxication progressing to CNS depression vomiting headache rapid respiratory and heart rate lowered blood pressure stupor collapse and unconsciousness with convulsions Death from respiratory arrest or cardiovascular collapse may follow Lethal dose in humans 100 ml 3 4 ounces Skin Contact Minor skin irritation and penetration may occur Eye Contact Splashes may cause irritation pain eye damage Chronic Exposure Repeated small exposures by any route can cause severe kidney problems Brain damage may also occur Skin allergy can develop May damage the developing fetus Aggravation of Pre existing Conditions Persons with pre existing skin disorders eye problems or impaired liver kidney or respiratory function may be more susceptible to the effects of this substance 4 First Aid Measures
5. f the information required by the CPR 16 Other Information NFPA Ratings Health 1 Flammability 1 Reactivity 0 Label Hazard Warning WARNING HARMFUL OR FATAL IF SWALLOWED HARMFUL IF INHALED OR ABSORBED THROUGH SKIN MAY CAUSE ALLERGIC SKIN REACTION MAY CAUSE IRRITATION TO SKIN EYES AND RESPIRATORY TRACT AFFECTS CENTRAL NERVOUS SYSTEM Label Precautions Do not breathe vapor or mist Use only with adequate ventilation Keep container closed Avoid contact with eyes skin and clothing Wash thoroughly after handling Label First Aid If inhaled remove to fresh air If not breathing give artificial respiration If breathing is difficult give oxygen In case of contact immediately flush skin or eyes with plenty of water for at least 15 minutes Call a physician if irritation develops or persists If swallowed give water or milk to drink and induce vomiting Never give anything by mouth to an unconscious person In all cases call a physician Product Use Laboratory Reagent Revision Information MSDS Section s changed since last revision of document include 8 Disclaimer 2K 2K OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK OK KK Mallinckrodt Baker Inc provides the information contained herein in good faith but makes no representation as to its comprehensiveness or accuracy This document is intended only a
6. ral disposal regulations Dispose of container and unused contents in accordance with federal state and local requirements 14 Transport Information Not regulated 15 Regulatory Information Chemical Inventory Status Part 1 Ingredient TSCA EC Japan Australia Ethylene Glycol 107 21 1 Yes Yes Yes Yes Chemical Inventory Status Part 2 Canada Ingredient Korea DSL NDSL Phil Ethylene Glycol 107 21 1 Yes Yes No Yes Federal State amp International Regulations Part 1 SARA 302 SARA 313 Ingredient RQ TPQ List Chemical Catg Ethylene Glycol 107 21 1 No No Yes No Federal State amp International Regulations Part 2 RCRA TSCA Ingredient CERCLA 261 33 8 d Ethylene Glycol 107 21 1 5000 No No Chemical Weapons Convention No TSCA 12 b No CDTA No SARA 311 312 Acute Yes Chronic Yes Fire No Pressure No Reactivity No Pure Liquid Australian Hazchem Code No information found Poison Schedule No information found WHMIS This MSDS has been prepared according to the hazard criteria of the 33 ADVANCED THERMOELECTRIC For Information Call 1 800 250 2920 electracool com Nashua NH 03062 USA international Inquiries 603 888 2467 rev 7 03 ElectraCOOL LA550 Chiller July 2003 Controlled Products Regulations CPR and the MSDS contains all o
7. ration specified by the appropriate regulatory agency or respirator supplier whichever is lowest A full face piece respirator with an organic vapor cartridge and particulate filter NIOSH P100 or R100 filter may be worn up to 50 times the exposure limit or the maximum use concentration specified by the appropriate regulatory agency or respirator supplier whichever is lowest Please note that N ADVANCED THERMOELECTRIC For Information Call 1 800 250 2920 electracool com Nashua NH 03062 USA international Inquiries 603 888 2467 rev 7 03 ElectraCOOL LA550 Chiller July 2003 series filters are not recommended for this material For emergencies or instances where the exposure levels are not known use a full face piece positive pressure air supplied respirator WARNING Air purifying respirators do not protect workers in oxygen deficient atmospheres Skin Protection Wear protective gloves and clean body covering clothing Eye Protection Use chemical safety goggles Maintain eye wash fountain and quick drench facilities in work area 9 Physical and Chemical Properties Appearance Clear oily liquid Odor Odorless Solubility Miscible in water Specific Gravity 1 1 20C 4C pH No information found Volatiles by volume 21C 70F 100 Boiling Point 197 6C 388F Melting Point 13C 9F Vapor Density Air 1 2 14 Vapor Pressure mm Hg 0 06 20C 68F Evaporation Rate BuAc 1 No info
8. rmation found 10 Stability and Reactivity Stability Stable under ordinary conditions of use and storage Hazardous Decomposition Products Carbon dioxide and carbon monoxide may form when heated to decomposition May produce acrid smoke and irritating fumes when heated to decomposition Hazardous Polymerization gt 31 ADVANGED THERMOELECTRIC For Information Call 1 800 250 2920 electracool com Nashua NH 03062 USA international Inquiries 603 888 2467 rev 7 03 ElectraCOOL LA550 Chiller July 2003 Will not occur Incompatibilities Strong oxidizing agents Reacts violently with chlorosulfonic acid oleum sulfuric acid and perchloric acid Causes ignition at room temperature with chromium trioxide potassium permanganate and sodium peroxide causes ignition at 212F 100C with ammonium dichromate silver chlorate sodium chloride and uranyl nitrate Conditions to Avoid Heat flames ignition sources water absorbs readily and incompatibles 11 Toxicological I nformation Toxicological Data Oral rat LD50 4700 mg kg skin rabbit LD50 9530 mg kg Irritation skin rabbit 555mg open mild eye rabbit 500mg 24H mild Investigated as a tumorigen mutagen and reproductive effector Reproductive Toxicity Has shown teratogenic effects in laboratory animals NTP Carcinogen Ingredient Known Anticipated IARC Category Ethylene Glycol 107 21 1 No No None 12 Ecological nformation Environmen
9. s a guide to the appropriate precautionary handling of the material by a properly trained person using this product Individuals receiving the information must exercise their independent judgment in determining its appropriateness for a particular purpose MALLINCKRODT BAKER INC MAKES NO REPRESENTATIONS OR WARRANTIES EI THER EXPRESS OR IMPLIED INCLUDING WITHOUT LIMITATION ANY WARRANTIES OF MERCHANTABILITY FITNESS FOR A PARTICULAR PURPOSE WITH RESPECT TO THE INFORMATION SET FORTH HEREIN OR THE PRODUCT TO WHICH THE INFORMATION REFERS ACCORDINGLY MALLINCKRODT BAKER INC WILL NOT BE ADVANCED THERMOELECTRIC For Information Call 1 800 250 2920 electracool com Nashua NH 03062 USA international Inquiries 603 888 2467 rev 7 03 ElectraCOOL LA550 Chiller July 2003 RESPONSI BLE FOR DAMAGES RESULTING FROM USE OF OR RELI ANCE UPON THIS INFORMATION ADVANCED THERMOELECTRIC For Information Call 1 800 250 2920 electracool com Nashua NH 03062 USA international Inquiries 603 888 2467 rev 7 03
10. sh to sewer US Regulations CERCLA require reporting spills and releases to soil water and air in excess of reportable quantities The toll free number for the US Coast Guard National Response Center is 800 424 8802 7 Handling and Storage Keep in a tightly closed container stored in a cool dry ventilated area Protect against physical damage Separate from acids and oxidizing materials Containers of this material may be hazardous when empty since they retain product residues vapors liquid observe all warnings and precautions listed for the product 8 Exposure Controls Personal Protection Airborne Exposure Limits OSHA Permissible Exposure Limit PEL 50 ppm Ceiling ACGIH Threshold Limit Value TLV 50 ppm Ceiling vapor Ventilation System A system of local and or general exhaust Is recommended to keep employee exposures below the Airborne Exposure Limits Local exhaust ventilation is generally preferred because it can control the emissions of the contaminant at its source preventing dispersion of it into the general work area Please refer to the ACGIH document Industrial Ventilation A Manual of Recommended Practices most recent edition for details Personal Respirators NIOSH Approved If the exposure limit is exceeded a half face respirator with an organic vapor cartridge and particulate filter NIOSH type P95 or R95 filter may be worn for up to ten times the exposure limit or the maximum use concent
11. tal Fate When released into the soil this material is expected to readily biodegrade When released into the soil this material is expected to leach into groundwater When released into the soil this material is not expected to evaporate significantly When released into water this material is expected to readily biodegrade When released into the water this material is expected to have a half life between 1 and 10 days This material is not expected to significantly bioaccumulate This material has a log octanol water partition coefficient of less than 3 0 When released into water this material is not expected to evaporate Significantly When released into the air this material is expected to be readily degraded by reaction with photochemically produced hydroxyl radicals When released into the air this material is expected to have a half life between 1 and 10 days gt 32 ADVANGED THERMOELECTRIC For Information Call 1 800 250 2920 electracool com Nashua NH 03062 USA international Inquiries 603 888 2467 rev 7 03 ElectraCOOL LA550 Chiller July 2003 Environmental Toxicity The LC50 96 hour values for fish are over 100 mo l 13 Disposal Considerations Whatever cannot be saved for recovery or recycling should be managed in an appropriate and approved waste disposal facility Processing use or contamination of this product may change the waste management options State and local disposal regulations may differ from fede
Download Pdf Manuals
Related Search