Musica Manual - Nuova Simonelli
Contents
1. AND HANDLING MACHINE ID When communicating with the manufacturer Nuova Simonelli always cite the machine ID number The machine is transported on pallets containing several machines inside cartons strapped to the pal let Operators performing any shipping or handling operations must wear gloves safety shoes and overalls with elasti cized cuffs Always move pallets using adequate equipment i e fork lift trucks A During handling the operator must make certain that there are no persons things or objects in the vicinity Slowly lift the pallet approximately 30 cm 11 8 in off the ground and drive to the loading zone After having made certain that there are no obstacles things or persons in the way proceed with loading Once the destination has been reached again using adequate lifting equipment i e fork lift truck and after having made certain that there is nothing and no one in the unloading area set the pallet on the ground and move it to the storage area always carry the load at a height of approx imately 30 cm 11 8 in from the ground CAUTION DANGER OF IMPACT OR PINCHING 20 MUSICA CAUTION DANGER OF IMPACT OR PINCHING Before performing the following operations make certain that the load is in stable and will not fall when the straps are cut Wearing gloves and safety shoes the operator must cut the straps and store the product During this operation see the product technical f2. cannot be held respon sible for any damages caused by improp er mistaken and unreasonable use The appliance is not to be used by chil dren or persons with reduced physical sensory or mental capabilities or lack of experience and knowledge unless they have been given supervision or instruc tion This appliance is for professional use only The operating temperature must be within the range of 5 35 C At the end of installation the device is switched on and taken to rated operating conditions leaving it in a state in which it is ready for operation The device is then switched off and the whole hydraulic circuit is bled of the first lot of water in order to remove any initial impurities The device is then refilled and taken to rated operating conditions MUSICA 17 SIMONELLI After reaching the ready for operation condition the following dispensing opera tions are carried out 100 of the coffee circuit through the coffee dispenser for more than one dispenser this is divided equally 100 of the hot water circuit through the water dispenser for more than one dispenser this is divided equally opening of each steam outlet for 1 minute At the end of installation it is good prac tice to draw up a report of the operations A WARNING Before using the machine read this manual in its entirety or at the very least read the safety and set up instructions IS There are some ba
3. milk preferably cone shaped Turn on the steam Before the milk starts to boil pull the nozzle slightly up and lightly move it vertically across the surface of the milk When you have completed the procedure clean the nozzle carefully with a soft cloth qe N Fig 17 HOT WATER SELECTION CAUTION RISK OF BURNS OR SCALDING While using the hot water nozzle pay careful attention not to place your hands beneath it or touch it just after it has been used This nozzle delivers hot water to make tea or herb teas Place a container under the hot water wand and press the hot water select key 26 MVSICA Make sure the button lights up Water will be delivered from the hot water nozzle for as long as the set time indicates NOTE Itis not possible to dispense hot water at the same time as coffee TANK FILLING When the tank no longer has any water the indicator light on the control panel will switch on To reset correct appliance operation proceed as fol lows Open the door and remove the tank Fill the tank with mineral water low lime con tent At the end of the operation it is sufficient to refit the tank inside its compartment and close the door to restore the machine to the correct operating status NOTE It is also possible to take out the tank when it is not empty at this point the liquid inside cannot come out from the bottom SWITCHING OFF THE MACHINE To switch o
4. or put 2 lots of coffee from the doser b4 into the double filter b0 Press the coffee with the provided coffee press er dust off any coffee residue from the rim of the filter this way the rubber gasket will last longer Fig 15 SIMONELLI Insert the filter in its unit Press the desired coffee button 1 coffee 2 coffees continued coffee By starting up the coffee brewing procedure the units pump is activated and the unit s solenoid valve is opened By pressing it the button will turn on and signal the operation NOTE when in pause leave the filter holder insert ed in the unit so that it will keep warm To guarantee the utmost thermic stability during use the delivery units are thermo compensated with complete hot water circu lation USING STEAM CAUTION DANGER OF BURNS While using the steam nozzle you must pay attention to not place your hands beneath it or touch just after it has been used To use the steam function simply push the relevant lever Fig 16 When pushed all the way the lever remains blocked in the maximum dispensing position when pulled the lever automatically returns to its place MUSICA 25 SIMONELLI NOTE Before using the steam wand always bleed out any condensation for at least 2 seconds or according to the manufacturer s instruc tions MAKING CAPPUCCINO To obtain the typical cappuccino foam immerse the nozzle all the way into a container 1 3 full of
5. 2V F N Nullleiter EV F LLSTAND EV AUSGUSS VAP H20 DAMPF WASSER PUMPE WIDERSTAND DRUCKSCHALTER 74 MUSICA LEGEND SL SP GND IMP 12V F N Common LEVEL ELECTROVALVE DELIVERY ELECTROVALVE STEAMIWATER PUMP ELEMENT PRESSURE SWITCH LEYENDA SL SP GND IMP 12V F EVNIVEL EV EROGACION VAP H20 BOMBA RESISTENCIA PRESOSTATO CENTRALINA CONTROL UNIT CENTRALE STEVERUNG CENTRALITA LEGENDE SL SP GND IMP 12V N Commun EV NIVEAU EV DISTRIBUTION VAP H20 POMPE RESISTANCE PRESSOSTAT C SIMONELLI IMPIANTO IDRAULICO PLUMBING SYSTEM INSTALLATION HYDRAULIQUE HYDRAULIKANLAGE INSTLACION HIDRAULICA 18 XE e m J gy M _ Q MUSICA 75 SIMONELLI IMPIANTO IDRAULICO PLUMBING SYSTEM INSTALLATION HYDRAULIQUE HYDRAULIKANLAGE INSTLACION HIDRAULICA LEGENDE LEGENDA SERBATOIO ACQUA SONDE SERBATOIO POMPA VALVOLA DI NON RITORNO ELETTROVALVOLA LIVELLO SCAMBIATORE DI CALORE BOILER ELEMENTO RISCALDANTE VALVOLA DI SISTEMA 10 VALVOLA DI SICUREZZA 11 PRESSOSTATO 12 VALVOLA ANTI VUOTO 13 SONDA DI LIVELLO 14 ELETTROVALVOLA EROGAZIONE 15 GRUPPO 16 VALVOLA DI ESPANSIONE 17 ELETTROVALVOLA ACQUA CALDA 18 MANOMETRO BOILER 19 MISURATORE DI PORTATA ioo poo gt LEGENDE WASSERTANK SONDEN TANK PUMPE R CKSCHLAGVENTIL MAGNETVENTIL F LLSTAND WARMEAUSTAUSCHER BOILER HEIZELEMENT SYSTEMVENTIL 10 SIC
6. FEEAUSGUSS LE MAGNETVENTIL FULLSTAND PR DRUCKSCHALTER T F SCHMELZSICHERUNG EL ELEMENT 72 MUSICA LEGEND A S AUTO LEVEL SENSOR M S MAIN SWITCH LS LIGHT SWITCH E U ELECTRONIC UNIT FM FLOW METER TL TANK LEVEL SENSOR PU PUMP H W HOT WATER ELECTROVALVE DE COFFEE DELIVERY ELECTROVALVE LE LEVEL ELECTROVALVE PR PRESSURE SWITCH TF THERMAL FUSE EL ELEMENT LEYENDA A S SENSOR AUTO NIVELADO M S INTERRUPTOR PRINCIPAL L S INTERRUPTOR LUZ E U UNIDAD ELECTR NICA FM MEDIDOR DE CAPACIDAD SENSOR NIVEL DEP SITO PU BOMBA H W ELECTROV LVULA AGUA CALIENTE DE ELECTROVALVULA EROGADOR CAF LE ELECTROVALVULA NIVEL PR PRESOSTATO TF FUSIBLE EL ELEMENTO LEGENDE A S CAPTEUR MISE A NIVEAU AUTOMATIQUE M S INTERRUPTEUR PRINCIPAL L S INTERRUPTEUR ECLAIRAGE E U UNITE ELECTRONIQUE F M MESUREUR DE DEBIT CAPTEUR NIVEAU RESERVOIR PU POMPE H W ELECTROVANNE EAU CHAUDE DE ELECTROVANNE DISTRIBUTEUR CAFE LE ELECTROVANNE NIVEAU PR PRESSOSTAT FUSIBLE EL ELEMENT SIMONELLI CENTRALINA CONTROL UNIT CENTRALE I STEUERUNG CENTRALITA SERIALE OSCARIV F N COMUNE SL EV LIVELLO SP EV EROGAZIONE GND VAP H20 POMPA GND RESISTENZA IMP PRESSOSTATO 12V MUSICA 73 SIMONELLI LEGENDA SL SP GND IMP 12V F N Comune EV LIVELLO EV EROGAZIONE VAP H20 POMPA RESISTENZA PRESSOSTATO LEGENDE SL SP GND IMP 1
7. HERHEITSVENTIL 11 DRUCKSCHALTER 12 ANTIVAKUUM VENTIL 13 F LLSTANDSONDE 14 MAGNETVENTIL AUSGUSS 15 GRUPPE 16 AUSDEHNUNGSVENTIL 17 MAGNETVENTIL HEISSWASSER 18 MANOMETER BOILER 19 DURCHFLUSSMESSER sh Ca UT gw ona 76 MVSIC LEGEND WATER TANK PROBES TANK PUMP RETAINING VALVE LEVEL SOLENOID HEAT EXCHANGER BOILER HEATING ELEMENT SYSTEM VALVE 10 SAFETY VALVE 11 PRESSOSTAT 12 ANTI VACUUM VALVE 13 LEVEL PROBE 14 DELIVERY SOLENOID 15 GROUP 16 EXPANSION VALVE 17 HOT WATER SOLENOID 18 BOILER PRESSURE METER 19 FLOW METER Ss LEYENDA DEP SITO AGUA SONDAS DEP SITO BOMBA V LVULA SIN RETORNO CALENTADOR ELEMENTO CALENTADOR V LVULA DE SISTEMA 10 V LVULA DE SEGURIDAD 11 _ 12 V LVULA ANTI VACIO 13 SONDA DE NIVEL 14 ELE ELECTROV LVULA EROGACI N 15 GRUPO 16 V LVULA DE EXPANSI N oo 10 Sx ceo gt 17 ELE ELECTROV LVULA AGUA CALIENTE 18 MAN METRO CALENTADOR 19 MEDIDOR DE CAPACIDAD ELE ELECTROV LVULA NIVEL INTERCAMBIADOR DE CALOR Vor nm gt RESERVOIR EAU SONDES RESERVOIR POMPE SOUPAPE DE NON RETOUR ELECTROVANNE NIVEAU ECHANGEUR DE CHALEUR CHAUFFE EAU ELEMENT DE RECHAUFFEMENT SOUPAPE DE SYSTEME SOUPAPE DE SURETE PRESSOSTAT SOUPAPE ANTI VIDE SONDE DE NIVEAU ELECTROVANNE DISTRIBUTION GROUPE SOUPAPE D EXPANSION ELECTROVANNE EAU CHAUDE MANOME
8. Pa and the maximum pressure for correct machine operation must not exceed 1 3MPa A CAUTION INFORMATION TO THE USERS Under the senses of art 13 of Law Decree 25th July 2005 n 151 Implementation of the Directives Guidelines 2002 95 CE 2002 96 CE HMI and 2003 108 CE concerning the reduction of the use of dangerous substances in electric and electronic equipment as well as the disposal of wastes The symbol of the crossed large rubbish container that is present on the machine points out that the product at the end of its life cycle must be collected separately from the other wastes The user for this reason will have to give the equipment that got to its life cycle to the suitable separate waste collection centres of electronic and electrotechnical wastes or to give it back to the seller or dealer when buying a new equipment of equivalent type in terms of one to one The suitable separate waste collection for the following sending of the disused equipment to recy cling the dealing or handling and compatible environ ment disposal contributes to avoid possible negative effects on the environment and on the people s health and helps the recycling of the materials the machine is composed of The user s illegal disposal of the product implies the application of administrative fines as stated in Law Decree n 22 1997 article 50 and followings of the Law Decree n 22 1997 SIMONELLI M SICA 19 SIMONELLI SHIPPING
9. TRE CHAUFFE EAU MESUREUR DE DEBIT nuove SIMONELLI eascoressoa coffee machines Nuova Distribution Centre LLC 6940Salashan PKWY BLDG A 98248 Ferdale WA Tel 1 360 3662226 Fax 1 3603664015 videoconf 1 360 3188595 www nuovasimonelli it info nuovasimonelli com Graphics by TYPE ENGINEERING S r l Codice 31000263 Edizione 01 del 11 2009 Nuova SIMONELLI coffee machines Via d Antegiano 6 62020 Belforte del Chienti Macerata Italy Tel 39 0733 9501 Fax 39 0733 950242 www nuovasimonelli it E mail n simonelli nuovasimonelli it La Nuova Simonelli si riserva di apportare tutte le modifiche ritenute necessarie
10. e coffee in the filter has not been pressed correctly The coffee has not been ground fine enough The filter holder is cold The filter holder should always left inserted in the machine while the unit is heating up and during use so it remains hot The cups are cold The cups must be placed on the heated shelf or preheated with hot water prior to use The boiler safety thermostat has cut in contact the nearest service center The pump does not suck water from the tank Open the steam nozzle 2 and press the coffee key 18 repeatedly 28 MUSICA SIMONELLI IMPIANTO ELETTRICO ELECTRICAL SYSTEM INSTALLATION ELECTRIQUE ALEKTRISCHE ANLAGE INSTALACION ELECTRICA 120V 60Hz i GROUND 230V S0Hz N NEUTRAL D WATER TANK MUSICA 71 SIMONELLI IMPIANTO ELETTRICO ELECTRICAL SYSTEM INSTALLATION ELECTRIQUE ALEKTRISCHE ANLAGE INSTALACION ELECTRICA LEGENDA A S SENSORE AUTO LIVELLAMENTO M S INTERRUTTORE PRINCIPALE L S INTERRUTTORE LUCE E U UNITA ELETTRONICA F M MISURATORE DI PORTATA T L SENSORELIVELLO SERBATOIO PU POMPA H W ELETTROVALVOLA ACQUA CALDA DE ELETTROVALVOLA EROGATORE CAFFE LE ELETTROVALVOLA LIVELLO PR PRESSOSTATO TF FUSIBILE EL ELEMENTO LEGENDE A S SELBSTNIVELLIERUNGSSENSOR M S HAUPTSCHALTER L S SCHALTER BELEUCHTUNG E U ELEKTRONISCHE STEUREINHEIT F M DURCHFLUSSMESSER FULLSTANDSENSOR TANK PU PUMPE H W MAGNETVENTIL HEISSWASSER DE MAGNETVENTIL KAF
11. e steam nozzle Use a cloth dipped in hot water and or a neutral detergent Cleaning the filter and filter holder If necessary use a tool to pry the filter b0 b6 out of the filter holder b2 Rinse under a jet of water tap and dry If necessary use a small brush to clean out the filter Cleaning the outside of the machine Never use any sort of solvent to clean the out side of the machine use only a cloth dipped in hot water and a neutral soap Cleaning the grill Brush the grill clean with hot water and soap Cleaning the liquid tank Clean the liquid tank with hot water and soap if necessary using a brush NOTE the liquid tank can be washed in the dishwasher FREQUENCY immediately after use daily H H H H H a m a CAUTION never use any sort of solvent Cleaning the water reservoir Use soap and water and rinse thoroughly NOTE if for any reason the water has left unde sired scale wash out with a swab Cleaning the dispensing spout CAUTION DANGER OF BURNS this operation is performed with the unit on and for this reason requires utmost care Clean the holes in the dispensing spout using a brush with slightly stiff bristles Press the dispensing button 19 to unplug the holes Cleaning the gasket on the dispenser assem bly Use a small brush to clean away any scale or coffee residues from the gasket on the dispenser assembly Cleaning the dispenser assembly Use a small br
12. eatures for the weight of the machine being stored and proceed as necessary A CAUTION DANGER OF POLLUTION Once the machine has been released from the pallet or container do not pollute the environ ment with these items DESCRIPTION LEGEND b0 Two cup filter b1 Spring b2 Filter holder b3 Coffee nozzle b4 Coffee measure b5 Coffee press b6 Single cup filter LEGEND 1 Water reservoir The reservoir can hold 2 3 liters of water Although the unit can operate with any type of water the lower the water hardness the onger the unit will last Steam knob Turn the knob and adjust the jet of steam Control panel Insulating socket Moveable steam nozzle Delivers steam to heat liquids in containers 14 SIMONELLI Fig 11 Delivery assembly attachment Filter holder housing b1 Water drain tank Cup support grill Pressure gauge Machine power switch Light switch Hot water dispenser wand Cup warming shelf Water reservoir hatch MUSICA 21 SIMONELLI gee colta Pers rasa 4 1 DESCRIPTION OF CONTROL PANEL LEGEND 15 Boiler tank heating element indicator light 18 Continuous coffee dispensing button 16 Machine on off switch Press to dispense coffee Hold down for 2 seconds to switch the Press again to stop dispensing coffee machine on or off 19 1 coffee dispensing button 17 2 coffee dispensin
13. f accessories b0 Two cup filter b1 Filter spring b2 Filter holder b4 Coffee measure b5 Coffee press b Single cup filter 3 The machine and accessories are not damaged in any way In case of damage or missing pieces immediately contact the manufacturer or its sales agent in your area or its insurance company SAFETY INDICATIONS I The present manual is an integral and essential part of the product and is to be delivered to the user Carefully read all warnings in the manual as they provide important information required to install use and maintain the unit safely Keep this manual in a safe place for further consul tation gt gt After having removed the packaging make certain that the unit is not damaged in any way If you have any doubts do not use the unit and contact a professionally qualified person Always keep all packaging plastic bags polystyrene foam nails etc out of the reach of children as they are a potential source of danger and never loiter the environment with such materials A DANGER OF POLLUTION Fig 1 35 Before turning on the unit make certain that the rating indicated on the label matches the available power supply The label is located under the machine work base at the upper right Installation must be performed following the standards in force in the country where it is being installed and following the manufac turer s instructions Only skilled personnel can ins
14. ff the machine press the 16 key which will begin to flash It is also possible to switch the machine s main breaker 10 to off causing all of the indicator lights to switch off NOTE For long pauses and in the interests of safety it is advisable to unplug the machine from the power mains MAINTENANCE If the above mentioned cleaning operations are per formed no other maintenance is required Contact the dealer where you purchased the unit for any operations required During maintenance repairs the parts used must be able to guarantee compliance with the safety and hygiene requirements envisaged for the device Original replacement parts can offer this guarantee After repairs to replacement of a part that comes into contact with foods or water it is necessary to carry out a washing procedure or to follow the steps indi cated by the manufacturer CLEANING Except for cleaning of dispensing assembly 6 shown in the table below any other form of cleaning must be performed when the unit is in a condition of zero energy off and unplugged from the power sup ply and only after the hot parts have cooled to room temperature See the table below 4 3 Item to be cleaned Part 1 Steam nozzle 5 2 Filter and filter holder b2 b0 b6 3 Outside of the machine a 4 Grill 8 5 Liquid tank 7 6 Water reservoir 1 7 Dispensing spout 6 8 Gasket on the dispenser 6 assembly 9 Dispenser assembly 6 Cleaning th
15. g button 20 Hot water dispensing button 21 Water tank indicator light 22 MVSICA INSTALLATION Before installing the unit carefully read the safety instructions at the beginning of this manual 1 2 Once the machine has been withdrawn from the packaging follow the instructions given in the GENERAL DELIVERY NOTES Position the unit on a horizontal surface Arrange the accessories as follows 3 Insert the ring b1 inside the seat of the filter holder 4 Insert one of the two filters b0 or b6 Tank Model 5 Open the hatch 14 and take out the reservoir 1 6 Especially the first time wash the reservoir with soap and water 7 Fill the reservoir with water and make certain that the outside of the reservoir is dry 8 Return the reservoir 1 to its housing and close the hatch 14 Model for Direct connection to the water mains 5 Remove the tube from the hatch 14 on the top part of the machine Connect the shaped end of the Teflon tube to the union on the base of the machine Connect the other end of the tube with the 1 8 union to the mains water supply 8 Make certain that the water drain tank 7 has been inserted Make certain that the cup support grill 8 is posi tioned squarely and is level 9 Make sure that the steam knob 2 is closed facing down Make certain that the line voltage corresponds to the requirements indicated on the label Only insert t
16. he plug in the socket if the steam knob 2 is closed and the mains voltage is the correct one The preliminary operations have been completed and the machine is ready to be set up NOTE Atthe start of the day s activities and in any case if there are any pauses of more than 8 hours then it is necessary to change 100 of the water in the circuits using the relevant dispensers NOTE In case of use where service is continuous make the above changes at least once a week SIMONELLI MUSICA 23 SIMONELLI PROGRAMMING PROGRAMMING DOSES To enter the programming mode proceed as follows NOTE the procedure can be carried out with the machine on To enter the dose programming mode it is necessary to press and hold down the continu ous dispensing key for 5 sec e delivery keys will begin to flash COFFEE DOSE PROGRAMMING To programme the amount of water for each of the delivery keys proceed as follows e fill the filter holder with the right amount of cof fee the double or single filter holder can be used according to the key to be programmed e Place the filter holder in the group e Press one of the delivery keys Dispensing will commence once the required quantity has been poured press the same key again Press the mode key to duit the programming 24 MUSICA PROGRAMMING HOT WATER e the relevant procedure to enter the pro gramming function e Pre
17. lI LIOVO SIMONELLI espresso coffee machines MVYSICA LIBRETTO ISTRUZIONI USER HANDBOOK MANUEL D INSTRUCTIONS GEBRAUCHANWEISUNGEN INSTRUCCIONES DE MANEJO DICHIARAZIONE DI CONFORMITA CE EC DECLARATION OF CONFORMITY CE nuova simonelli espresso coffee machines Via M D Antegiano 6 62031 Belforte del Ghienti MC dichiariamo sotto la nostra responsabilit che il prodotto declare under vur responsability that the product MACCHINE PER CAFFE ESPRESSO MODELLO MUSICA ESPRESSO COFFEE MACHINES MODELS MUSICA al quale si riferisce questa dichiarazione costruito in conformit alle disposizioni to which this declaration relates following the provisions of the Directives EN 60335 2 75 2004 A1 2005 A11 2006 in combination with EM 60335 1 2002 A1 2004 A11 2004 A12 2006 A2 2006 EN 50366 2003 A1 2006 ed conforme alle direttive following the provisions of the Directives 2006 95 Low Voltage 2044 108 EMC data Novembre 2009 nuova simonelli s p a November 2009 Delegato Ottavi Nando TECHNICAL CHARACTERISTICS MODELS MUSICA NET GROSS WEIGHT WEIGHT 20KG 22 Kg 44 1 lb 48 5 Ib SIMONELLI Congratulations upon the wise choice you have made by purchasing the MUSICA model In fact you are now the owner of not just a simple coffee dispenser but a true espresso coffee making machine which is f
18. rightness setting as far as mini mum to then start again from the maximum value e Pressing the key will start the pre infu sion approx 3 sec for dispensing key lit or it will switch it off key off Pressing the key will quit the parameter set ting functions and return to the dose programming mode USE Before starting to use any functions the operator must first be sure to have read and understood the safety guidelines in this manual SWITCHING THE MACHINE ON OFF e Plug the machine into the mains socket the LED of the on switch Will begin to flash Hold down the on switch for 2 seconds fact that the machine is operating is shown by the LED of the on switch delivery keys which remain lit and all NOTE once the auto diagnosis has been complet ed all the keys are activated A WARNING For electronic card maintenance turn the machine off by means of the external main switch or disconnect the plug To switch off the machine hold down the on switch for 5 seconds the LEDs on the delivery keys will switch off and the on switch LED will flash MAKING COFFEE Unhitch the filter holder and fill it with one or two doses of ground coffee depending on the filter used Replace if necessary using the relevant tool Fig 14 The coffee doser b4 when filled to the brim pro vides the right amount for a single coffee Put the coffee in the doser b4 into the single filter b6
19. sic rules for the use of any electrical appliance In particular never touch the unit with wet hands or feet never use the unit with bare feet never use extension cords in areas equipped with baths or showers never pull on the power supply cord to unplug the unit never leave the unit exposed to atmos pheric agents rain direct sunlight etc never let children unauthorized per sonnel or anyone who has not read this manual operate the unit 18 MUSICA IS Before performing any sort of mainte nance the authorized technician must turn off the unit and unplug it from the mains Fig 5 35 Before cleaning the unit set it in a state of 0 energy that is MACHINE SWITCHED OFF AND UNPLUGGED Follow the instructions given in this manual carefully gt gt In case of breakdown or poor function turn off the unit Never tamper with the unit Contact only professionally qualified person nel Only the manufacturer or an authorized serv ice center can make repairs and only using original spare parts Non compliance with the above can compro mise machine safety I Upon installation the qualified electrician must arrange for an omnipolar switch as called for by the safety regulations in force when open the contacts must be 3 mm or more apart I To prevent dangerous overheating it is advisable to fully extend the power supply cord 35 Never block the intake and or heat di
20. ss the hot water selection key e water delivery will begin Decide the required amount of hot water and then press the key again Press the mode key to quit the programming PROGRAMMING STANDARD DOSES e It is possible to enter pre set values for the group doses and hot water To do this it is necessary to press the key and hold it down for at least 10 seconds until the flashing keys switch off The doses are 208 09 x 9 NOTE Setting a time of 0 seconds for the water causes it to operate in continuous mode ADDITIONAL FUNCTIONS The page for setting operating parameters is opened from the programming mode while no dispensing function is active by pressing the key and the key at the same time 1 Software block activation to enter the dose programming mode 2 Keypad brightness adjustment 3 Dose pre infusion activation The key serves to enable the software block to enter the dose programming mode key lit or disenable it key off To remove a soft ware block for programming it is necessary to quit the dose programming mode and follow these steps from OFF status switch the control unit to ON and as soon as the Lamp test begins release the key and press the and keys together holding them down until the Lamp test is complete key which flashes is used to choose the brightness of the keys from the 9 pre set levels Pressing the key will reduce the b
21. ssipa tion grills in particular those for the cup warmer I The user must never replace the unit s power supply cord If this cord is dam aged turn off the unit and have it replaced by a professionally qualified technician lt gt Should you decide to stop using this type of unit we suggest you render it inopera ble by unplugging it and cutting the power supply cord WARNING DANGER OF POLLUTION Fig 7 US Never dispose of the machine in the envi ronment to dispose of the machine con tact an authorized center or contact the manufacturer for pertinent indications IS To facilitate aeration of the unit position the aeration portion of the machine 15 cm 5 9 in from walls or other machinery US Once you have started washing the machine complete the job or residues of detergent could be left inside the dispens ing assembly A WARNING DANGER OF INTOXICATION gt gt Be extremely careful when using the steam nozzle Never place your hands under the nozzle and never touch it right after use N WARNING gt gt Remember that to install maintain unload and regulate the unit the qualified opera tor must always wear work gloves and safety shoes I When adding the coffee the operator must never put his hands into the con tainer S The noise level of the machine is less than TOdb gt gt For machines connected to the mains water supply the minimum pressure must be 0 6 M
22. tall this unit The manufacturer cannot be held responsi ble for any damages incurred if the system is not grounded For electrical safety this machine requires a ground system Contact a technically certi fied electrician who must check that the line electrical capacity is adequate for the maxi mum capacity indicated on the unit label Fig 2 IS The electrician must also check that the line cables have adequate section to han dle the power absorbed by the unit Never use adapters multiple jacks or extension cords When such items prove absolutely necessary call in a qualified electrician SIMONELLI When installing the device it is necessary to use the parts and materials supplied with the device itself Should it be neces sary to use other parts the installation engineer needs to check their suitability for use in contact with water for human consumption The machine must be installed in compli ance with the local health standards in force for plumbing systems Therefore contact an authorized plumber The device needs to be supplied with water that is suitable for human consump tion and compliant with the regulations in force in the place of installation The installation engineer needs confirmation from the owner manager of the system that the water complies with the require ments and standards stated above This unit must only be used for the pur poses described in the present manual The manufacturer
23. ully automatic and completely controlled by a microprocessor This means absolute reliability and simple to use We are certain that our MUSICA model will increase your confidence in Nuova Simonelli and that you will undoubtedly recommend others to purchase this coffee making machine since the MUSICA model has been chosen to increase the profitability of the coffee shop thus fully opti mising running costs This machine has been manufactured in compliance with the EEC directives 89 392 89 336 73 23 89 109 and subsequent modifications With best wishes Nuova Simonelli S p a HEATING DIMENSION CAPACITY A B C MUSICA 15 1200W SIMONELLI CONTENTS TECHNICAL CHARACTERISTICS GENERAL DELIVERY NOTES SAFETY INDICATIONS SHIPPING AND HANDLING 3 1 Machine Id DESCRIPTION 4 1 Description of control panel INSTALLATION PROGRAMMING 6 1 programming doses 6 2 Coffee dose programming 6 3 Programming hot water 6 4 Programming standard doses 6 5 Additional functionse 7 USE 7 1 Switching the machine on off 7 2 Making coffee 7 3 Using steam 7 4 Making cappuccino 7 5 Hot water selection 7 6 Tank filling 8 SWITCHING OFF THE MACHINE 9 MAINTENANCE 10 CLEANING 11 TROUBLESHOOTING 16 MUSICA GENERAL DELIVERY NOTES The machine and all parts are generally delivered in palletized cartons Upon receipt check that 1 All packaging is intact 2 The contents are the a Machine b Box o
24. ush to clean away any scale or coffee residues from the dispenser assembly spout SIMONELLI weekly MUSICA 27 SIMONELLI TROUBLESHOOTING If your expresso coffee maker is not functioning properly see if you can find the problem in the troubleshooting list below Also reread the corresponding sections in the user s manual The machine does not prepare the expresso coffee The coffee comes out of the sides of the filter holder There is too little or no cream The cream is too dark and or the coffee has a burnt flavor The coffee is not hot enough Check whether the reservoir empty light is on no water in the reservoir or reservoir not inserted correctly The coffee has been ground too fine or has been pressed too hard The spout is plugged Scale must be removed from the machine The filter holder was not inserted correctly The filter holder was not tightened enough Clean coffee grinds away from the gasket see the section on cleaning Check the amount of coffee the measure must be filled level The machine is not hot is the heating element off The coffee has not been ground fine enough The coffee in the filter has not been pressed correctly The coffee is not fresh The water is not fresh The coffee has been ground too fine The coffee has been pressed too hard Too much coffee has been measured The hot water passes through the filter too quickly It takes 25 40 seconds to make 2 cups Th
Download Pdf Manuals
Related Search