VPS Trampoline Installation Manual
Contents
1. dren danger of suffocation CONTINUED After installing the product according to the instruction manual please make Sure that all screws bolts and nuts are securely fastened and that all joints are tightly fixed Ensure the trampoline has proper clearance above and around the trampoline area We recommend at least 25ft above and 5ft around the trampoline to be free from any obstruction Ensure that the trampoline is set up properly before use The metal frame of the trampoline will conduct electricity Lightning extension cords and all electrical equioment must never be allowed to come in contact with the trampoline The trampoline must always be used In a well lit area Do not place any objects beneath the trampoline or allow children to play un der the trampoline as injury may result When assembling or disassembling please use gloves to protect your hands 1 5 ADDITIONAL TIPS We recommend installing your Trampoline at ground level using our TDU retaining wall system Not included But if you are using this trampoline above ground we recommend securing the trampoline to the ground in case of high wind scenarios that may cause damage to the trampoline Do not use during pregnancy Do not use when suffering from high blood pressure Jump with bare feet Do not wear shoes this will damage the jumping mat which is not covered by the warranty No smoking on or around the trampoline as damage to the Mat and Pads may r2. e that the packaging material is not suitable for children There is danger of suffocation This Trampoline is not recommended for children under 6 years of age Install ing this trampoline at ground level with additional TDU retaining wall kit not included will helo reduce the risk of injury from young children falling off of a trampoline above ground 1 3 ATTENTION PRODUCT DAMAGES Do not alter the product Only use TDU system approved components Repairs Should only be carried out by qualified TDU technicians Improper repairs can compromise the safety of your trampoline We recommend removing the Vented Pad springs and Mat during the winter months if you are in an area that gets consistent snow fall 1 4 ADVICE FOR THE ASSEMBLY The assembly of the product must be done carefully by at least two able bodied adults If in any doubt please contact your local dealer or a TDU representative Before you start assembling the trampoline read all the instructions in this man ual Remove all packaging materials and lay down all parts on a level open space This gives you an overview and simplifies the assembly procedure Check with the parts list that no parts are missing Dispose of the packaging material when the assembly is completed Beware that when using tools or doing technical work there is always a risk of Injury Store the packaging material in a way that cannot cause any danger Foils and plastic bags are dangerous for chil
3. esult Do not place pets sharp objects or any other foreign objects on the trampo line Do not use the trampoline while under the influence of alcohol or drugs Do not sit or lean on the vented safety pads while someone is jumping Do not allow children to pull themselves up on the trampoline by hanging on to the safety pad Do not remove warning safety Tags on the jumping mat Do not allow children to jump without proper training or instructions If the Trampoline is not going to be used IN GROUND ensure it is on a level Surface preferably grass and secured or anchored to the ground Do not expose the trampoline to direct contact with open flames and ensure that it is more than 10 away from any fire pit area to protect it from damage Secure the trampoline against unauthorized use Do not use if trampoline jumping mat is wet CONTINUED WARNING 1 Do not attempt or allow somersaults or flios Landing on your head or neck can Cause serious injury paralysis or even death 2 Do not allow more than one person on the trampoline at a time Use by more than one person at the same time increases the chance of injury 5 Use Trampoline only with adult or mature supervision SAFETY INSTRUCTIONS FOR TRAMPOLINE All users of the trampoline need a supervisor Regardless of the age and the experience of the user The safety instructions of the trampoline should always be considered and obeyed Examine and inspect the trampo
4. he parts list 5 Once the Top Rail Frame Pieces are secured insert the Leg Extension pieces into the Top Rail Frame Neck joints Connect the 8 Top rail Frame pieces together and secure them with the pro vided Frame Nuts bolts and washers Ensure that the Leg Exten sion piece is inserted with the Hole for the Leg Screws at the bottom facing inside towards the center of the trampoline NOTE Steps 5 9 are only necessary for those that have also purchased the optional TDU Retaining Wall System for IN GROUND installations only If you did not purchase the optional retaining wall system please skip to step 10 to complete your trampoline installation 5 At this step remove the TDU retaining wall panels and connect them individ Ually around the Frame of the Trampoline Insert Each interlocking panel together Surrounding the Frame of the Trampoline Once the kit is completely connected and is surround ing the Top Rail Frame raise the frame of the Trampoline until it is flush with the top of TDU retaining wall kit 7 Set the Provided Self Tapping Screws that come with the TDU Retaining wall system into the corner of the buckle joint as shown for each panel securing the panels to the frame of the Trampoline 5 16 Hex bit also provided 8 Once the Entire retaining wall system is secured insert the V shape Leg Bases into the Leg Exten sions and secure them with the provided Leg Bolts a
5. line for damage wearing or defective parts before each use Any damaged worn out or defective parts should be replaced immediately The trampoline must be set uo IN GROUND with the use of the TDU retaining wall system Not included or on flat ground on soft non sliopery surfaces If the trampoline is above ground Strong winds can blow the trampoline away If strong winds are predicted we recommend moving the trampoline to a safe place or securing the trampoline to the ground Try to avoid the moving the assembled trampoline Should it be necessary to move the trampoline please consider using 4 adults to lift at even spacing to ensure the trampoline is level while moving it Trampolines are jumping devices enabling the user to jump to unusual heights Jump only on the Jumping mat landing on the frame cover pads or off of the trampoline can lead to injury Users should be familiar with the user manual This manual contains assembly instructions selected precautionary measures as well as recommendations for servicing and maintenance of the trampoline Do not stick any foreign objects into the trampoline Do not allow anyone or any object to go under the trampoline while someone Is jumping Serious Injury may result The trampoline should only be used when the jumping mat is clean from debris and dry Jumping with dirt or items on the trampoline may cause injury or dam age to the trampoline It is the responsibility of the
6. nd washers Secure the Vented Safety Once the TDU retaining wall system and Trampoline Frame have been properly installed in the ground with proper backfill inside and outside you are now ready to complete the trampoline installation Once you Nave attached springs every fifth hole go back and attach springs to the right of each spring until you have once again gone all the way around Pad by slipping a spring through the Front Pad loop and then tie the rear pad ties around the Top Rail frame of the trampoline 10 IZ Lay out the Jumping mat in the center of the Trampoline Frame and begin to attach the Springs 1 at a time 5 Holes apart from each other Repeat this process until all springs are attached and the mat is fully stretched Once the Safety Pad Is Secured you are ready to enjoy your new Trampoline in ground or above Ground TRAMPOL GUIDELINES 1 INE GENERAL INSTRUCTIONS 1 1 PURPOSE The TDU systems Trampoline is intended for home domestic above or in ground use only and is not suitable for professional or medical uses The maximum weight is 450lbs overloading the trampoline above the recom mended user weight will cause damage to the trampoline which is not covered by the warranty 1 2 DANGER FOR CHILDREN Do not let unsupervised children near this product Carry out the necessary Safety precautions and supervise all trampoline activities Be awar
7. owner or the supervisor to guarantee that all users of the trampoline are informed and that there is sufficient space above and around the trampoline as a safety precaution WARRANTY amp CONTACT INFORMATION We stand behind our products 100 and offer the best warranty in the industry Should you have any product related defects please contact us directly For all warranty related issues be sure to go to our website and download amp submit the product registration form www tTrampolinesDownUnder com N For installation questions or issues please contact us TAUSYSTEMS Website www trampolinesdownunder com Email info tdul com Phone 801 796 7739
8. trampolines VPS Trampoline Installation Manual NS For installation questions or issues please contact us dU Website www trampolinesdownunder com Email info tdul com Phone 801 796 7739 CONTENTS Parts LIST ee csecceseeesseereeseseeeeseseeeeesseeeeeesteeeessenes 3 Installation INSTFUCTIONS uu es eceeseeeeeeen 4 6 Trampoline Guidelines ceeeeeeeeseeeeeeee 7 8 Warnings and DisclaimerS cesseeeeeeee 9 Warranty and Contact Information 10 PARTS LIST PART PART DESCRIPTION QTY OOFR 1 OOJM 1 OOLE 1 OOLB 1 OOT 1 OOVPS 1 OOSPR 1 OOSW 1 OOSW 2 Top Rail Frame Pieces Vented Safety Pad Jumping Mat Springs Leg Extensions V Shaped Leg Bases Leg screws and Washers each Spring tool Screw driver and wrench Frame nuts Bolts and Washers each 8 1 1 INSTALLATION INSTRUCTIONS Refer to PARTS LIST for identification of parts WARNING Two adults in good physical condition are required for the following assembly For your safety you should wear gloves Failure to follow these instructions and warnings may result in injury NOTE Picture may vary slightly with different trampoline models Please layout all parts and items and ensure you will be working on a level smooth surface Lay out all the trampoline parts In groups as shown above on a level installation Surface Ensure you Nave all necessary components by checking t
Download Pdf Manuals
Related Search