Home

658k - Fairchild Engineering Ltd

1. FPM 3120TV Series Flat Panel Monitor with 12 Color TFT LCD Display User s Manual ii Copyright Notice This document is copyrighted by Advantech Co Ltd All rights are reserved Advantech Co Ltd reserves the right to make improvements to the products described in this manual at any time Specifications are thus subject to change without notice No part of this manual may be reproduced copied translated or transmitted in any form or by any means without the prior written permission of Advantech Co Ltd Information provided in this manual is intended to be accurate and reliable However Advantech Co Ltd assumes no responsibility for its use nor for any infringements upon the rights of third parties which may result from its use All brand and product names mentioned herein are trademarks or registered trademarks of their respective holders FPM 3120TV User s Manual FCC Class B This equipment has been tested and found to comply with the limits for a Class B digital device pursuant to Part 15 ofthe FCC Rules These limits are designed to provide reasonable protection against harmful interference when the equipment is operated in aresidential environment This equipment generates uses and can radiate radio frequency energy If not installed and used in accordance with this user s manual it may cause harmful interference to radio communica tions Note that even when this equipment is installed and used
2. Verwenden Sie Keine Fl ssig oder Aerosolreiniger Am besten dient ein angefeuchtetes Tuch zur Reinigung Die NetzanschluBsteckdose soll nahe dem Ger t angebracht und leicht zug nglich sein Das Ger t ist vor Feuchtigkeit zu sch tzen Bei der Aufstellung des Ger tes ist auf sicheren Stand zu achten Ein Kippen oder Fallen k nnte Verletzungen hervorrufen Die Bel ftungs ffnungen dienen zur Luftzirkulation die das Ger t vor berhitzung sch tzt Sorgen Sie daf r daB diese ffnungen nicht abgedeckt werden Beachten Sie beim AnschluB an das Stromnetz die AnschluBwerte Verlegen Sie die NetzanschluBleitung so daB niemand dar ber fallen kann Es sollte auch nichts auf der Leitung abgestellt werden Alle Hinweise und Warnungen die sich am Ger ten befinden sind zu beachten Wird das Ger t ber einen l ngeren Zeitraum nicht benutzt sollten Sie es vom Stromnetz trennen Somit wird im Falle einer berspan nung eine Besch digung vermieden Durch die L ftungs ffnungen d rfen niemals Gegenst nde oder Fl ssigkeiten in das Ger t gelangen Dies k nnte einen Brand bzw elektrischen Schlag ausl sen ffnen Sie niemals das Ger t Das Ger t darf aus Gr nden der elektrischen Sicherheit nur von authorisiertem Servicepersonal ge ffnet werden Wenn folgende Situationen auftreten ist das Ger t vom Stromnetz zu trennen und von einer qualifizierten Servicestelle zu berpr fen a Netzkabel oder Netzstecker sind besc
3. Windows NT 2000 MS DOS Life span 100 million touches LCD Specification 1 4 Display type SVGA TFT LCD Display size 12 1 Max colors 262 K Max resolution 800 x 600 View angle 80 H 30 V Luminance 200 cd m Storage temperature 20 60 C 4 140 F Operating temperature 0 50 C 32 122 F Contrast Ratio 150 1 typ Lamp Life Time MTBF 30 000 hrs Power Consumption e Max Output Power 48 Watts e AC input voltage 90 270 Vac Output voltage 12 V 5A e Safety Standards UL CSA TUV CB Chapter 1 Introduction 3 1 5 Connectors The following connectors are situated on the buttom of the FPM 3120 Series Qe Qe o a Oe of PS 2 PS 2 RS 232 Power Power switch VGA Touch screen VGA Port DB 15 This DB 15 connector can be connected to the system via the external 15 pin DB 15 connector locatd on the left side of the system unit Keyboard amp mouse Connector PS 2 There are two PS 2 connectors which can ne connected to keyboard or mouse Touchscreen Connector DB 9 optional This connector will be present only if a touchscreen is installed It must be connected to the RS 232 port of the PC The touchscreen cable is included with all orders which include the touchscreen option DC 12V Power In This connector will be connected to the DC 12V Switching Power Supply Extended Cable Transmission opti
4. ech com where you can find the latest information about the product 2 Contact your distributor sales representative or Advantech s customer service center for technical support if you need additional assistance Please have the following information ready before you call Product name and serial number Description of your peripheral attachments Description of your software operating system version application software etc A complete description of the problem The exact wording of any error messages iv FPM 3120TV User s Manual Safety Instructions 1 10 11 12 13 14 15 Read these safety instructions carefully Keep this User s Manual for later reference Disconnect this equipment from any AC outlet before cleaning Use a damp cloth Do not use liquid or spray detergents for cleaning For plug in equipment the power outlet socket must be located near the equipment and must be easily accessible Keep this equipment away from humidity Put this equipment on a reliable surface during installation Dropping it or letting it fall may cause damage The openings on the enclosure are for air convection Protect the equipment from overheating DO NOT COVER THE OPENINGS Make sure the voltage of the power source is correct before connecting the equipment to the power outlet Position the power cord so that people cannot step on it Do not place anything over the power cord All cautions and warning
5. face The keypad interface provides driver for a dual color LED for status indication AUTO Press this button te execute auto adjustment process le Presses to show the OSD sereen or select an item for changing its setting aD To move between eas ar crease or Ananas iam ing EXIT To close the selected item or the whole OSD sereen OWOFF Tum the display backlight ON and OFF PS The green light means that the COMMON board detects the input signal and ends output signal to LCD panel 16 FPM 3120TV User s Manual B 2 OSD Function Each selected value is stored into LCD memory after SEL signal input or time out The stored values are not affected if the power is turned off But the selected value is not available in case a selected mode is changed before time out or power is turned off before time out The default definition of input keys is shown as following Main Mem Sub Mens oo Eu skin flock Hd chock fron YESA Ppt rme of chock per landlard ina EL Portion j0 pal from VEGA sland efi one a Posten 0 nae from TESA Move the inp iaga caplina standard window up or down Configuration All Reset All Regat egies Be Appendix B OSD Selection 17 18 FPM 3120TV User s Manual
6. h digt b Fl ssigkeit ist in das Ger t eingedrungen c Das Ger t war Feuchtigkeit ausgesetzt d Wenn das Ger t nicht der Bedienungsanleitung entsprechend funktioniert oder Sie mit Hilfe dieser Anleitung keine Verbesserung erzielen e Das Ger t ist gefallen und oder das Geh use ist besch digt f Wenn das Ger t deutliche Anzeichen eines Defektes aufweist Der arbeitsplatzbezogene Schalldruckpegel nach DIN 45 635 Teil 1000 betr gt 70dB A oder weiger DISCLAIMER This set of instructions is given according to IEC704 1 Advantech disclaims all responsibility for the accuracy of any statements contained herein vi FPM 3120TV User s Manual CHAPTER Introduction This chapter includes e Introduction e Specifications e LCD Specification e Power Consumption e Connectors e Dimensions 1 1 Introduction 1 2 Advantech s FPM 3120TV Series is a 12 color TFT LCD flat panel monitor built specifically for industrial applications With the optional touchscreen the FPM 3120TV Series is an excellent and user friendly system control interface In addition to its usual application as an LCD panel monitor the FPM 3120TV comes standard with direct VGA control signal input making it compatible with Industrial PCs and Workstations With the FPM 3120TV Advantech is taking a more aggressive initiative to penetrate the industrial HMI market Its OSD On Screen Display function allows you to adjust the display fact
7. ide then attach the FPM 3120 series onto the Swing ARM mount Figure 2 5 Swing ARM for the FPM 3120 series Chapter 2 System Setup 11 2 2 3 Power adapter The power adapter bracket is attached to the rear of the FPM 3120 Simply detach the small bracket at the rear side of the monitor by screwing the four screws 12 FPM 3120TVE User s Manual APPENDIX Standard Timing Set Serial Data for Expansion Appendix A Display Timing Mode and OSD A 1 Supported Input Timing Modes The nineteen kinds of timings below are already programmed in this module The input synchronous signals are automatically recognized Restoution Vertical Frequencies 60 Hz 70 Hz 72Hz 640 x 480 800 x 600 Table A 1 Supported Input Formats Note 1 Even if the preset timing is entered a little adjust ment of the functions such as Horizontal period CLK delay and display position are required The adjusted values are memorized in every preset num ber Note 2 This module recognizes the synchronous signals with near preset timing of the frequency of the HS and Vsync even in the case that the signals other than the preset timing that were entered Note 3 Because adjustments may not fit such as differing magnifying ratios or in the case that you use it except for the display timing that was preset 14 FPM 3120TV User s Manual APPENDIX e OSD Selection e Keypad Interface e OSD Function B 1 Keypad Inter
8. in accordance with this user s manual there is still no guarantee that interference will not occur Ifthis equipment is believed to be causeing harmful interference to radio or television reception this can be determined by turning the equipment on and off If the interference is occurring the user is encouraged to try to correct the interference by one or more of the following measures e Reorient or relocate the receiving antenna e Increase the separation between the equipment and the receiver e Connect the equipment to a power outlet on a circuit different from that to which the receiver is connected e Consult the dealer or an experienced radio TV technician for help Seka a CAPM HA gt REET RA gt THAR RAT AMIE EMRE RE RRM RL GOR iii Packing List Before installing your equipment make sure that the following materials have been received e FPM 3120TV Series flat panel monitor e Accessory pack including AC DC adapter Power Chord Video signal cable 1 8m Keyboard mouse Y cable AC DC power adapter bracket Hook wall mounted bracket in FPM 3120TV Four fixed panel mounted bracket Mounting bracket in FPM 3120TV RS 232 cable 1 8m FPM 3120TV T only Keyboard mouse 1 8m cable Driver manual CD ROM If any of these items are missing or damaged contact your distributor or sales representative immediately Additional Information and Assistance 1 Visit the Advantech web site at www advant
9. nsions 6 FPM 3120TV User s Manual CHAPTER System Setup e Mounting the Monitor Wall Panel mounting Desktop Stand Swing ARM Mounting 2 1 Mounting the Monitor The FPM 3120 Series can be placed as you require The versatility of the FPM 3120 mounts enable it to be mounted on your desk or anywhere else 2 1 1 Wall Mounting Please follow the steps to install FPM 3120TV in the wall 1 Screw the wall mount bracket in the wall 2 Put the FPM 3120TV in the bracket 3 Screw the second wall mount bracket in the FPM 3120TV Figure 2 2 Panel Mounting 8 FPM 3120TV User s Manual 2 1 2 Panel Mounting If you need to install the FPM 3120 series on a panel mount please release the mounting brackets by detaching screws on rear side and fix them on up and bottom side by screws Figure 2 2 Panel Mounting cut out dimension 303mm x 229mm Chapter 2 System Setup 9 2 2 Desktop Swing ARM for FPM 3120TV The FPM 3120 Series can be mounted in other ways You can place the desktop stand for desktop use or attach it on a swing arm bracket 2 2 1 Desktop Stand The desktop stand bracket is attached to the rear of the FPM 3120 Simply detach the small bracket at the rear side of the monitor by screwing the two screws The bracket now becomes the desktop stand bracket Figure 2 4 Desktop Stand for the FPM 3120 series 10 FPM 3120TV User s Manual 2 2 2 Swing ARM Detach the mounting brackets on the rear s
10. onal A 5 20 30 50 meter VGA cable is provided for special applications Another longer cable is also available For more detailed information please contact our dealers Warning Before you connect VGA cable between FPM 3120TV amp PC please note the following issues 1 If you have intalled operation system in the PC make sure the verticle frequency falls within the range Refer to Appendix B 2 If you do not install operation system you have to adjust the verticle frequency to fall within the range 4 FPM 3120TV User s Manual 1 5 1 PS 2 connectors The FPM 3120TV provides two PS 2 connectors in the buttom side Please follow the steps to connect the keyboard mouse cable 1 Connect 1 8m keyboard mouse cable to one of the PS 2 port 2 Connect other side of Keyboard mouse 1 8m cable to PC 3 Connect Y cable to another PS 2 port in FPM 3120TV Note You MUST select one PS 2 port to connect 1 8m cable to PC Os Oo ER Oe on Ep aa Keyboard mouse 1 8m cable J A eyboard mouse Y cable Chapter 1 Introduction 5 1 6 Dimensions Unit mm Cut out dimension 303 X229 mm 11 93 X 9 02 I Tel 00 LEI O Oh AN N gt gt O N ja LL Figure 1 6 Dime
11. ors and turn the back light on and off for the behind view functions which become critical as more and more industrial HMI users become aware of the benefits of flat panel monitors The whole chassis is of steel and the front panel is of Al Mg with NEMA4 IP65 compliance The FPM 3120TV provides a touch screen version FPM 3120TV T for option With an 8 wire resistive type touchscreen the monitor can be immediately transformed into a remote control system For remote control application optional transmission cables are available for 5m 10m 20m 30m and 50m The Advantech FPM 3120TV is the ultimate HMI solution for your industrial application Specifications General Construction Heavy duty steel chassis Front panel Al Mg NEMA4 IP65 compliant Control OSD On Screen Display control pad on rear side Mounting Panel wallmount desktop or VESA Arm Dimensions W x Hx D 311 x 237 x 40 mm 12 2 x 9 3 x 1 6 Panel Mount Cut out Dimension W x H 303 x 229 mm 11 93 x 9 0 Weight 4 5 Kgs 8 lbs Vibration operating 5 17 Hz double amplitude displacement 17 500 Hz 1 0 G peak to peak CE FCC BSMI CCIB compliant FPM 3120TV User s Manual 1 3 Touchscreen Optional e Type 8 wire analog resistive Resolution continuous Light transmission 75 surface meets ASTM D 3363 92A Standard tabler abrasion test Controller RS 232 interface Power Consumption 5 V 200 mA OS support Windows 95 98
12. s on the equipment should be noted If the equipment is not used for a long time disconnect it from the power source to avoid damage by transient overvoltage Never pour any liquid into an opening This may cause fire or electrical shock Never open the equipment For safety reasons the equipment should be opened only by qualified service personnel If one of the following situations arises get the equipment checked by service personnel a The power cord or plug is damaged b Liquid has penetrated into the equipment c The equipment has been exposed to moisture d The equipment does not work well or you cannot get it to work according to the user s manual e The equipment has been dropped and damaged f The equipment has obvious signs of breakage DO NOT LEAVE THIS EQUIPMENT IN AN UNCONTROLLED ENVIRONMENT WHERE THE STORAGE TEMPERATURE IS BELOW 20 C 4 F OR ABOVE 60 C 140 F THIS MAY DAMAGE THE EQUIPMENT The sound pressure level at the operator s position according to IEC 704 1 1982 is no more than 70dB A DISCLAIMER This set of instructions is given according to IEC 704 1 Advantech disclaims all responsibility for the accuracy of any statements contained herein Wichtige Sicherheishinweise 10 11 12 13 14 Bitte lesen sie Sich diese Hinweise sorgf ltig durch Heben Sie diese Anleitung f r den sp teren Gebrauch auf Vor jedem Reinigen ist das Ger t vom Stromnetz zu trennen

658k - Fairchild Engineering Ltd

Contents

Download Pdf Manuals

Related Search

Related Contents