ES-1402 Elite User Manual
Contents
1. bar 2 55 kg cm2 36 25 psi that is what we recommend It is necessary to check the tire pressure regularly under inflation and excessive inflation will cause unequal tire wear which influences comfort and mileage and shorten the life of tire under inflated tires also influence power saving Also check for cuts and splits which could cause the tire to deflate at a rapid rate causing injury to the rider 6 Appearance Cleaning It is necessary to keep the pedal and body of Esway clean Please clean the gravel soil and mud off after you re driving Don t use any corrosive chemical such as petrol to clean Esway you can clean Esway by using soft cloth and brush don t wash Esway with water Chapter VIII Notice 1 Balance Output of Esway Computer balance will start immediately after you press the pedal switch of Esway If you keep pressing the pedal switch the computer balance will always start the computer will keep balance for 5s even if the pedal switch is restored when at a low speed Please pay attention Esway will keep balance if the balance output function is ON That means putting this scooter on the road without driver on it will go all by itself 2 Esway Parking For temporary parking you can just turn on the balance output function and lean it against a wall or step that can stop it from moving forward for long time parking you can switch off the power and put the parking stand down This parking stand can be purchase2. car which means the driver can drive Esway according to his thoughts 6 Driving in Bad Weather Esway is not waterproof Please do not drive Esway on rainy days It is easy to damage the motherboard and the motor if water gets into the electrics Esway cannot be driven in the snow Esway does not have night lights so please do not drive Esway in the dark In China Esway is hard to define so please don t drive on public roads used for motor vehicles When driving on the sidewalk single driveway or public places please comply with local traffic regulations and the local bye laws Chapter VI Charging When you find the orange lamp and red indicator is continuously on it shows the battery needs to be charged First turn off the power switch and use the specialized 24 V battery charger Insert the plug into Esway s charge jack then connect the power When charger is connected the Red light will glow continuously showing Esway is in charge mode refer to picture 16 The charger has two indicators the red light means on charge Green light means fully charged pull out charger The input voltage of charger is 110 240v output voltage is 25 27v AC electric current is 1 2 1 5 A The charger takes 8 10 hours to fully charge When fully charged the green light will be on continuously the charging electric current will then decrease output The charger will become warm when charging so please keep in suitable place Please keep power s
3. drives the motor to balance the vehicle As a new transporter Esway is difficult to classify in the traditional way some people think that Esway should be a kind of double wheeled Unicycle while other people think it should be classed as a power stand up Scooter with its uniaxial double design which is different from the traditional biaxial double scooter for official road regulations this transporter is called Electric Personal Assistive Mobility Device EPAMD The vehicle is equipped with dual wheels its width is as narrow as a normal adult shoulder s width It is 43 kg and battery operated It is not necessary to have a brake or throttle during driving When the driver leans their body forward Esway will run forward when the body is upright it will stop It uses the dynamic balance principle as the body moves to change the center of gravity so as to keep balance Just as the human body stands and leans forwards it can lose balance but the body s natural instinct will maintain balance the dynamic stability replicates this Esway uses the wheels to replace the function of the feet reproducing the high precision balance action of a human it is also cheap and convenient to use The energy comes from two repeat charging BTM batteries which are free from maintenance If sufficient power is supplied to your battery the full charge capacity will last continuous for 5 hours driving the driving range depends on the way you drive and ground cond
4. E SWRA tk User Manual for ESWAY Shenzhen Ocam Electronic Technology Co Ltd Welcome Use The user manual comes with Esway for the users reference when Esway Smart Vehicle are sold The user s manual is applied to all the Smart vehicles Esway made by our factory You may find that some functions are different from what you ordered It is normal because of different series The content and technical specification in this manual are valid when permitted to be printed But Shenzhen Ocam Electronic Technology Co Ltd has the right to alter and change technical specification or design without prior notification And we will not assume any obligation To ensure our Esway brings you the best driving experience the best way is to read the user manual carefully you will learn how to drive this future transporter After reading please keep the user manual well so that you can refer to it any time when you need The warranty card will come with Esway You can find your warranty rights in the user manual Please read the user manual carefully so that you can know your rights and responsibilities well Please maintain Esway according to the user manual so that you can keep the scooter in the best condition We have professional people who will supply you good after service and answer any questions and problem you care Sincerely wish you a nice driving Safety Instructions For adults use only Please abide by your local traffic regulatio
5. an slowly or smoothly backward is helpful for slowing down and stopping safely refer to picture 13 Ts Picture 13 Tip Driving forward in a straight line you just simply push the handle forward then backward to slow down or stop 4 Turning in Original Place Turn Around and Rotate 360 Degrees It is easy to turn the Esway when driving Keep the turning pipe handle bar left forward or right forward to the end at the same time keep your body corresponding left forwarded or right forwarded as the trend of Esway refer to picture 14 and 15 Thus you can easily achieve various turns When the Esway faces the right position you only need return the pipe to the original position and stand straight Esway will stop T Picture 14 Picture 15 5 Turning in Driving Esway s turning range is calculated automatically according to the driving speed the speed is faster the turn range will be less to ensure safety of the driver and it is stopped by the turning pipe and body s corporation To turn left the turning pipe should be swung smoothly to the left at the same time as your body leans left The angle of Esway s turn is decided by the swinging angle of the turning pipe and the leaning of your body Tip the actual turning is finished by the above combination of actions driving the Esway is like a combination of riding horses and skiing or the movement is like Michael Jackson s dancing Esway also is called a thinking
6. d from 15 us independently 3 Accident Water Turn the power off immediately if Esway falls into water accidentally Do not drive it again if you are not sure of the default The Esway weighs 43kg You can pull it easily without power home and then contact us we will give you guide 4 Lock Switch Lock Esway to prevent running by accident Power off and then lock when you power on again red light will flash 5 times it means Esway is locked When you power on and Esway starts to initialize if you lock Esway at this time the locking will lead to pedal switch short circuit Esway will think that driver has stood on it and then start automatic balance Please do not drive under this situation Chapter IX Indicator and Sound Alarm 1 Indicator introduction 1 Green light operating light 1 Continually On no blinking System is normal Battery is full 2 Orange light warning light 2 Continually On no blinking battery is low it needs to be charged in time Blinking overload 3 Red light warning light 3 Continuous on no blinking battery run out and must be charged immediately Fast blinking during driving sound alarm continuously It means that you should adjust your body when moving forward at high speed At this time the Esway will upright itself automatically to stop the driver from leaning forward to limit the speed and keep the driver safe 2 Sound alarm fast The pedal switch is not in the correct posit
7. ion the pedal switch is 16 pressed down or the driver has left the Esway when driving which can make the pedal switch reset the pedal switch is pulled up In this situation if the pedal switch is still not in the correct position in 3s the pedal switch is pressed down Esway will think driver has fallen off and will stop automatically to keep the driver safe Please remember pedal switch must be in right position the pedal switch is pressed down or Esway will switch off power and the rider will lose balance 3 Sound alarm 5 times 1 Check whether Lock is locked After lock the indicator will not light when you power on Esway and sound alarm 5 times Esway is locked when in transportation to avoid accident So please unlock Esway before you drive it after you receive 2 Pedal problem also can lead red light to flash 5 times you can press pedal switch several times by using your hand to make pedal restore the pedal switch is pressed down Then power on Esway if red light still flash please contact us 4 Indicator light normal Esway Has No any Action After power on Esway green light orange ligjht and red light flash green light is continuous on normal starting ends Esway can t balance by using remote control or pressing pedal switch It means that there is some problem of gyroscope or accelerometer In above two situations please power off Esway and stop driving then contact us 5 Function of battery display and sou
8. itch Chapter IV Getting Started 1 The Right Starting Operation Hold the turning pipe handle bar with one hand keeping the pedal upright turn on the power after green light orange light and red light flash at the same time the green light stay on continuous It means starting success refer to picture 3 4 5 Then hold the handlebar firmly with two hands refer to picture 6 Make sure the pedal is on horizontal level when power on Esway Because Esway cannot power on if it is not on horizontal level III MM F Picture 5 Picture 6 2 Wrong Starting Operation refer to picture 7 and 8 Esway cannot power on if it is not on horizontal level So we must make sure the pedal is on horizontal level then power on it Picture 7 Picture 8 3 Correct Starting Operation refer to picture 9 Make the pedal of Esway on horizontal level before power on it Picture 9 Chapter V Driving Driving the Esway 2 wheel self balance vehicle is totally different from anything you may have driven before Esway does not have a brake accelerator or gear system Please read the user manual or get instruction from an experienced person before your first ride Esway is very addictive once you enjoy the fun of driving you will not help yourself driving it whenever you get the chance following these instructions will be beneficial for your enjoyment Below description will be helpful to your driving Tip We s
9. itions driving on grass and slopes will consume more driving power Chapter II Parts Explanation 1 Cramp Y 3 Adjusting Screw 2 Handle Gri i 4 Turning Pipe D Indicator 9 Pedal 5 Steering Joint Shaft 10 Power Switch aX 6 Tire Fender lt gt W 11 Security Lock 7 Tire 12 Fuse Jack 13 Wheel 14 Charging Jack Picture 1 1 Handle Bar Turning Pipe 1 Used to control and make the Esway turn left or right turn around rotate 360 degrees It also has support function and can play a subsidiary role in keeping body balance 2 The height is adjustable The driver can adjust it according to his or her own height to make the handle bar comfortable 3 Lock the steering rod after adjustment then turn the handle bar to confirm that it has had been locked 4 Above adjustment of the handle bar turning pipe should be locked in position before driving 5 The turning pipe can be taken apart easily for carrying or storage 2 Power Switch 1 The power switch is used to turn on and off the power when the power switch is on the Esway will finish the initialization settings 2 It is dangerous to stand on Esway without turning on the power 3 Pedal Switch SAFE switch 1 The pedal can be active up or down it has a built in safety switch Esway can check whether someone on scooter by pedal switch 2 The pedal switch is safety insurance when driving if the driver leaves the Esway the pedal switch
10. nd alarm Green light continually On Display system working well and battery in normal state Orange light continually On battery is low it should be charged in time Red light continually On battery power run out and must be charged immediately Always keep battery charged before it is fully run out red light is continually on It is harmful to battery and will reduce battery s life Chapter X Technical Data Model Number ES1402 Dimension 68cm 43cm 43cm Net Weight 43 kg Power Brush DC motor max 1600W Tire 17 in vacuum smooth Black Aluminum Rim Height of handle 80 110 cm adjustable Max Load 150 kg Max Speed 18 km h Max Distance 35 km Height of Pedal 26 cm Max Height above 13 cm ground Turning Radius 0m ur 30 degree Standard Pressure 250 kpa Battery Display 3 state Charging time 8 10h Package Size 70cm 45cm 50cm
11. ns Please wear helmet knee and elbow guards for safety purposes Please read the relevant driving guidelines in this manual Our company is not responsible for the accident if you don not use it as the above request It is hard for us to list all associated dangers when driving and maintaining Esway therefore please be careful and pay attention to the safety of yourself and others when riding The user manual contains important safety information Please read carefully Contents Chapter I Introduction of Eswax 00 cece cence eee 4 Chapter II Parts Explained tutte 5 Chapter III Instruction of remote control of Esway 7 Chapter TV Getting Started ene re tette das 8 Chapter V Esway Driving 00 cece cece ete 10 Chapter V PC hare ee dee Stetit e Tata oov rebas 13 Chapter VII Maintenance 14 Chapter VIL Nee ee 15 Chapter IX Indicator and Sound Alarm 16 Chapter X Technical Data erc eet Meel Ae Eed Add 18 Chapter I Introduction of Esway The working principle of the two wheeled Scooter is based on the basic principle called dynamic stability which is the automatic balance ability of the vehicle itself After judging body posture position with a built in precision solid gyroscope the vehicles electronic brain works out proper instructions through a sophisticated and high speed central microprocessor the 24V 28Ah battery
12. uggest you use Beginner Mode if you did not driver our Esway before 1 Standing on Esway After switching on hold the handlebar with left hand Meanwhile step on pedal with right foot refer to picture 10 or hold the handlebar with right hand meanwhile step on pedal with left foot The sequence is the left hand right foot left foot right hand or right hand left foot right foot left hand By this time you will have stood on the balanced scooter Stand upright without any body move just relax and keep your body balance then Ewing will still stay still refer to picture 11 10 Picture 10 Picture 11 2 Driving straight forward Lean your body forward slowly using the centre of gravity Esway will move forward refer to picture 12 The driving speed is controlled by the leaning angle of your body Lean forward more Esway will go faster and vice versa For a stable driving we suggest lean forward slowly It is dangerous for leaning forward suddenly This is just like a sudden acceleration when driving a car Picture 12 3 Braking Driving Backward Driving backward is not recommended for the driver s safety because it is hard for you to see behind when driving Turning radius of Esway is zero which you can easily 11 achieve in a continuous spin around 360 degrees on the spot When you drive forward in a straight line and you want to slow down or stop you can lean backward or squat down the center of gravity backward Le
13. will reset and then will stop after 3 seconds siren alarm 4 Indicator Lights on Pedal 1 Green light Operating light 1 Battery is full system is normal 2 Orange light warning light 2 Battery will run out soon 3 Red light warning light 3 Battery will run out completely Chapter III Instruction of remote control of Esway Picture 2 1 Function of Remote Control 1 Button 1 Open balance output Esway can keep self balance without driver on it 2 Button 2 Close balance output 3 Button 3 High Speed Mode Max speed 16 KM the turning is the most flexible and sensitive 4 Button 4 Beginner Mode Max speed 8 KM turning is slow 5 Function of recording pedal horizontal level Powering on Esway setting a suitable position pressing Button 3 and Button 4 at the same time after two beep sounds Esway will remember it as default position Attention 1 Keep Esway horizontal and power on it press pedal switch you can drive Esway without remote control 2 Default mode is Normal Mode Max speed 12 KM turning is flexible and sensitive 3 AII the function of remote control button is valid only after driver leave Esway 2 Function of Sound Alarm 1 One beep sound confirming reception of remote control 2 Fast and short sound after driver leave Esway It detect without driver on it 3 Continuous sound over max speed System limits the speed 4 Continuous five sounds lock system problem of pedal sw
14. witch of Esway off when on charge otherwise Esway will cause power consumption which is bad for charging Chapter VII Maintenance All other items that are not mentioned below should be done by a professional person or technician 1 The Maintenance of Battery Esway use BTM free maintenance battery When you find the orange lamp and red lamp light continuously on please charge Keep the charge time to no more than 15 hours If you are not using Esway for long periods keep it charged excessive discharge and re charge is bad for the battery s life and can even lead to having to scrap the battery Suggestion please keep it charged every month even you don t drive it 2 When not Drive Esway Please turn off the power switch then lock the switch in case of accidental starting 3 Replacing Fuse The fuse of Esway is 50A car fuse the fuse maybe burned after overload or crashed sharply when you find that there is no action and the indicator is off after switching on check the fuse if it is burnt out you need to replace fuse open the fuse cover at the back of body with screwdriver take out the fuse using clamp and replace with a new fuse 4 Fastening Nut of Tire Pay attention to the big nut on the wheel regularly check if it is loose tighten with a 21mm spanner to 108 torque 5 Maintenance of Tire The normal air pressure is the basic conditions to guarantee your safe driving The standard tire pressure is 250 kpa 2 5
Download Pdf Manuals
Related Search