ELECTRONIC TOY CAR
Contents
1. they are only to be charged under adult supervision Assembly Steps 2 Fender assembly Fender M5x25 w machine MTS machine screw p Screw Front axle Front wheel e Remove the front axle bush 2 10 nut from the handle bar e Fit the fender into the handle bar e Secure it with a M5x25 machine screw Repeat for the other side e Insert the front wheel into the handle bar e Place a bush on the hole in the middle of the front wheel repeat for the other side e Insert the front axle through the handle bar bush 2 and front wheel e Tighten a 210 nut do not over tighten Repeat for the other side e Remove the M8x140 bolt Iron bush 2 and 8 nut from the handle bar e Fit the handle bar into the vehicle body e Slide a iron bush onto the M8x140 bolt e Insert the M8x140 bolt into the hole on vehicle body e Slide another iron bush and tighten the 8 nut on downside Assembly Steps 5 Mirror assembly Mirror base front Mirror Mirror base back e Insert the mirror base front into the holes on handle bar e Fit the mirror into the mirror base front e Fit the mirror back into the mirror front e Use 4 3x8 screws to secure it e Repeat for the other side e Use a screwdriver to remove the M5x16 machine screw at the rear of the seat e Remove the seat e Plug the connector into the terminal on battery as shown e Use a screwdriver to replace the seat A2. handle parts or help in assembly of the vehicle e Please identify all parts before assembly and save all packaging material until assembly is complete to ensure that no parts are discarded Assembly tool for need screwdriver Not included and spanner Install the screw that the parts uses already with the tape glue to stick at correspond of install parts up 1 Battery assembly e Use a screwdriver to remove the battery cover and insert two dry AA batteries GPe svsz el Replace the battery cover NOTE The product does not included dry AA battery ofaneam e BATTERY INFORMATION Batteries may leak fluids that can cause chemical burn injury or ruin your product To avoid battery leakage Do not mix old and new batteries or batteries of different types alkaline standard carbon zinc or rechargeable nickel cadmium Insert batteries as indicated inside the battery compartment Remove batteries during long periods of non use Always remove exhausted batteries from the product Dispose of batteries safely Do not dispose of batteries in a fire The batteries may explode or leak e Never short circuit the battery terminals e Non rechargeable batteries are not to be recharged e Use only batteries of the same or equivalent type as recommended e Do not charge non rechargeable batteries e Remove rechargeable batteries from the product before charging e f removable rechargeable batteries are used
3. CHLIDREN S ELECTRONIC TOY CAR Gy e Suitable for 3 years e Maximum user weight 25kg e Adult assembly required OWNER S MANUAL Read and understand this entire manual before using Please keep this manual for future reference as it contains important information Before first time use charge the battery for at least 4 6 hours Table of Contents 1 About Your New Vehicle 2 Parts List 3 Parts Diagram 4 Assembly Steps 5 How To Operation Your Vehicle 6 Charging The Vehicle 7 Troubleshooting Guide 8 Maintaining Your Vehicle 9 Disposal Of Battery About Your New Vehicle Thank you for your purchasing our products we wants your child to enjoy this product for years to come Keep these points in mind as you read this guide Battery 6V 4 5AH 1 Load Capacity Under 25kg Size of car 95 50 63 CM 2 5KM H Charging type Input depend on local voltage Average Approximately Output DC 6V500mA battery life 300 times Charge time 8 12 Hours Fuse F10A FOR THE SAFETY OF YOUR CHILD PLEASE READ ALL WARNINGS AND ASSEMBLY USE INSTRUCTIONS KEEP THIS GUIDE FOR FUTURE REFERENCE ADULT ASSEMBLY REQUIRED The product contains small parts which are for adult assembly only Keep small children away when assembling Always remove protective material and poly bags and dispose before assembly Parts List JNU PART Q ty JNU PART Q ty WA NAME PICTURE
4. ash hands after Charging Your Vehicle handling Do not open the battery Battery contains lead acid and other materials that are toxic and corrosive Do not open the charger Exposed wiring and circuitry inside case may cause electric shock Only adults may handle or charge the battery NEVER allow child to handle or charge the battery Battery is heavy and contains lead acid electrolyte Do not drop the battery Permanent damage to the battery could occur or cause serious injury Before charging the battery check for wear or damage to the battery charger its supply cord and the connectors DO NOT charge the battery if any damage to parts has occurred Do not allow the battery to drain completely Recharge the battery after each use or once a month if not used regularly Do not charge battery upside down Always secure the battery with the bracket Battery can fall out and injure a child if vehicle tips over The charging input socket is ABOVE THE FOOT PEDAL The POWER SWITCH must be turned in OFF position when charging Before the first use you should charge the battery for 4 6 hours Do not recharge the battery for more than 10 hours to avoid overheating the charger When the vehicle begins to run slowly recharge the battery After each use or once a month minimum recharge time as 8 to 12 hours less than 20 hours at most 1 Open the cover of the socket the socket is above the foot pedal 2 Plug
5. neration land filling or mixing of sealed lead acid batteries with household trash is prohibited by law e Return an exhausted battery to your local approved lead acid battery recycle such asa local seller of automotive batteries e Contact your local waste management officials for other information regarding the environmentally sound recycling and disposal of lead acid batteries Our products are suitable for ASTM F963 GB6675 EN71 and EN62115 standard
6. ose Make sure the battery connector and adapter connector are firmly plugged together POSSIBLE CAUSE Charger is not plugged in Make sure the charger is plugged into the wall outlet and the power flow to the outlet is on POSSIBLE CAUSE Charger is not working Is the charger warm while charging If not the charger may be broken and may need to be replaced Troubleshooting Guide H PROBLEM The vehicle does not run very long POSSIBLECAUSE Battery may be undercharged You may not be charging the battery long enough After each use or once a month minimum charge the battery for 8 to 10 hours Do not leave the battery on the charger for more than 20 hours POSSIBLE CAUSE Battery is old The battery will eventually lose the ability to hold a charge Depending on the amount of use and varying conditions the battery should operate for one to three years Replace the battery with a new one H PROBLEM Battery buzzes or gurgles when charging This is normal and not a cause for concern It may also be silent when charging which is also normal H PROBLEM Charger feels warm when recharging battery This is normal and not a cause for concern Maintaining Your Vehicle It is parents responsibility to checkt main parts of the toy before using Must regularly examine for potential hazard such as the battery charge cable or cord plug screws are fastening enclosure of other parts and that in the event of such damage the toy mu
7. pcs REMARK T NAME PICTURE pcs REMARKS Placed FA Vehicle 1 Seat V ss body body W Backrest IN 1 Mirror Q 2 oe Mirror 2 ase base front back y Zl Handlebar F 2 Fender CA 1 Placed Front 1 Front 1 na wheel axle handle bar Placed Placed SS a O 2 Pn 1 bar bar Placed Placed ASQ 2 on the M8X140 1 on the 13 10 nut N shi bolt da ler Parts List JNU PART Q ty JNU PART Q ty Ra PART PICTURE pcs REMARK M NAME PICTURE pcs RIN Iron ra 3x8 me 15 bush handle screw goe 8 Seo EY bar package M5x16 1 Placed I machine c mD r ET Charger I screw M5x25 2 19 machine mD v4 Spanner screw Bx MaJOS BXEY z uo4 aseq souy RH z yoeq seq Jou 2 Ca USNq uoa FE L HOC Or L X8IN fi Za JOLIN A L Apog apiyaa RP OQ I ge Ca MOOS SIYORW GZXGN SI L E S AH 1094M jUO14 FS E SS Le D N L Sxe Ju014 Kei C ysng A CxINUOLO G D Ws L J8pU34 FAR Lamu g MP L eq puey g Jeuueds papnjou you saaupmasog G w 2 Oe v i WS ayaew gpx EST 1ls noeg wejbeig spied Assembly Steps Your new vehicle requires adult assembly Please set aside at least 40 minutes for assembly Children can be harmed by small parts sharp edges and sharp points in the vehicle s unassembled state Care should be taken in unpacking and assembly of the vehicle Children should not
8. r bodies of water Use the toy only on flat surfaces such as inside your house garden or playground Never use in the dark A child could encounter unexpected obstacles and have an accident Operate the vehicle only in the daytime or a well lit area It is not recommended to drive the vehicle on wet surfaces or on lopes of greater than 15 degrees Do not use this vehicle outdoors when it is raining or snowing Make sure you come to a complete stop before changing directions from forward to back Please follow the correct weight and age limits allowed to drive this vehicle It is prohibited to change the circuit or add other electric parts Inspect wires and connections of the vehicle periodically In order to avoid accidents please ensure the vehicle is safe before riding Do not let any child touch the wheels or be near them when the car is moving How To Operate Your Vehicle Use Operation Ensure the power switch has been turned on Sounds button Headlight button IMPORTANT lt Always stop vehicle when changing the speed or direction to avoid damage to gear box and motor Puya backward switch FORWARD 1 Press the Forward backward switch on the Forward position 2 Press the Foot pedal the vehicle drives forward REVERSE The vehicle will brake automatically when your child s foot remove from the Foot pedal STOP 1 Press the Forward backward switch on the Backward posi
9. ssembly Steps 8 Backrest assembly Fit the backrest into the holes on vehicle Backrest body Push until you hear this click into place NY Ge NN How To Operate Your Vehicle WARNING PREVENT INJURIES AND DEATHS NEVER LEAVE CHILD UNATTENDED DIRECT ADULT SUPERVISION IS REQUIRED Always keep child in view when child is in vehicle Never use in roadways near cars on or near steep inclines or steps swimming pools or other bodies of water Always wear shoes Always sit on the seat e Suitable for age 3 years Maximum user weight is 25kg Must confirm before using that following work which is already finished Important Before using the vehicle for the first time the battery needs to be charged for 4 to 6 hours no more than 10 hours Only an adult can charge or recharge the battery Finishing the complete car to assemble according to the steps that the manual described The plug in package of storage battery has already been inserted well the power has already been put through All places to need the screw guarantee the screw has already been locked Rules for Safe Riding READ THESE RULES ALOUD TO YOUR CHILD AND THEIR PLAYMATES AND MAKE SURE THEY UNDERSTAND THEM Always wear a helmet when riding Direct Adult Supervision Required Keep Children within Safe Riding Areas Never use in roadway near motor vehicles on lawn space on or near steep inclines or steps swimming pools or othe
10. st not be until that damage had been properly removed Make sure the plastic parts of the vehicle are not cracked or broken Occasionally use a lightweight oil to lubricate moving parts such as wheels Park the vehicle indoors or cover it with a tarp to protect it from wet weather Keep the vehicle away from sources of heat such as stoves and heaters Plastic parts may melt Recharge the battery after each use Only an adult can handle the battery Recharge the battery at least once a month when the vehicle Raider is not being used Do not wash the vehicle with a hose Do not wash the vehicle with soap and water Do not drive the vehicle in rainy or snowy weather Water will damage the motor electric system and battery Clean the vehicle with a soft dry cloth To restore shine to plastic parts use a non wax furniture polish Do not use car wax Do not use abrasive cleaners Do not drive the vehicle in loose dirt sand or fine gravel which could damage moving parts motors or the electric system When not using all the electrical source should be turn off Turn off the power switch and disconnect the battery connection Disposal Of Batte Disposal Of Battery x e Your sealed lead acid battery must be recycled or disposed of in an environmentally sound manner e Do not dispose of your lead acid battery in a fire The battery may explode or leak e Do not dispose of a lead acid battery in your regular household trash The inci
11. the charger port into the input socket 3 Plug the charger plug into a wall outlet The battery will begin charging Troubleshooting Guide H PROBLEM The vehicle does not run PROBLEM CAUSE The battery may low on power After each use or once a month minimum charge the battery for a full 10 hours Do not leave the battery on the charger for more than 20 hours POSSIBLE CAUSE Thermal fuse has tripped When the vehicle won t work or can not be charged please check the fuse first and see whether it is burnt out If the fuse is broken please change with a new one there is a spare fuse in the fuse package The fuse is under seat Spare fuse Fine Burnt out t Pay attention Fuse 10A POSSIBLE CAUSE Wheel nuts are loose If the nuts are not tight the wheels will not engage the forward gears Tighten the nut with the nut wrench POSSIBLE CAUSE Battery connector or wires are loose Make Sure the battery connectors are firmly plugged in to each other POSSIBLE CAUSE Battery is dead Have you properly maintained the battery according to the directions Is the battery old Your battery may need to be replaced POSSIBLE CAUSE Electric system is damaged Water may have corroded the system or loose dirt gravel or sand might have jammed the switch POSSIBLE CAUSE Motor is damaged The motor needs professional repair H PROBLEM The battery will not recharge POSSIBLE CAUSE Battery connector or adapter connector is lo
12. tion 2 Press the Foot pedal the vehicle drives backward SOUNDS BUTTON Press the buttons on the handle bar for sound playing HEADLIGHT BUTTON Press the button on the handle bar to turn on the headlight Press it again to turn the head light off Charging Your Vehicle ONLY AN ADULT CAN CHARGE AND RECHRGE THE BATTERY e PREVENT FIRE AND ELECTRIC SHOCK Use the only rechargeable battery and charger supplied with your vehicle NEVER substitute the battery or the charger with another brand Using another battery or charger my cause a fire or explosion Do not use the battery or charger for any other product Overheating fire or explosion could occur NEVER modify the electric circuit system Tampering with the electric system may cause a shock fire or explosion or my permanetly damage the system Do not allow direct contact between battery terminals Fire or explosion can occur Do not allow any type of liquid on the battery or its components Explosive gasses are created during charging Do not charge near heat or flammable materials Charge the battery in a well ventilated area ONLY NEVER pick up the battery by the wires or charger Damage can occur to the battery and may cause a fire Pick up the battery by the case ONLY Charge the battery in a dry area ONLY Battery posts terminals and related accessories contain lead and lead compounds chemicals known to the State of California to cause cancer and reproductive harm W
Download Pdf Manuals
Related Search