Super Deluxe Glass Door Refrigerators & Freezers Installation and
Contents
1. TOR TURER Turbo Air Speeds up the Pace of Innovation Super Deluxe Glass Door Refrigerators amp Freezers Installation and Operation Manual Please read this manual completely before attempting to install or operate this equipment REFRIGERATORS Cold Drinks TGM 7SD a TGM 10SD TGM 12SD TGM 15SD TGM 20SD TGM 23SD TGM 35SD TGM 47SD TGM 72SD FREEZERS TGF 5SD TGF 10SD TGF 15SD TGF 23SD TGF 35SD TGF 47SD TGF 72SD www turboairinc com CONTENTS 1 SERIAL NUMBER lt lt lt lt 2 2 ENERGY 2 3 INSTALLATION asit seti zd rinde da e ni Ea ani a aac n ra abc io 3 4 CLEANING HHHeHeHHm MH K K K K K K K K 4 5 BASIC OPERATION akut tegat retinet 5 9 6 TROUBLESHOOTING u aod i nnt d fecum nn 10 ERN 11 13 SERIAL NUMBER The serial number can be found on the data label located inside the unit Please retain the unit serial number for service purposes ENERGY STAR As an Energy Star Partner the following products meet the Energy Star guidelines for energy efficiency TGM 5SD TGM 7SD TGM 10SD TGM 12SD TGM 20SD TGM 23SD TGM 35SD 4750 TGM 7250 TGF 23SD TGF 35SD TGF 47SD TGF 72SD INSTALLATION 1 GOOD AIR CIRCULA2. The defrost cycle is automatically controlled by the D sensor and the PCB Push the temperature up button for higher temperatures and the temperature down button for lower temperatures Evaporator fan motor will run after all doors are completely closed Good air flow in freezer is critical Be careful when stationing the product so that it does not press against the back wall and is at least 4 inches away from the evaporator compartment DISPLAY PANEL OF FREEZERS TEMP CONTROL BUTTON LAMP SWITCH 1 INTERIOR TEMP INDICATOR LAMP SWITCH 2 POWER SWITCH TEMPERATURE o OFF TURBO FREEZE POWER LAMP 1 LAMP 2 TURBO FREEZE BUTTON TURBO FREEZE DOOR OPENING RUNNING DISPLAY PANEL OF REFRIGERATORS TEMP CONTROL BUTTON LAMP SWITCH 1 INTERIOR TEMP INDICATOR LAMP SWITCH 2 POWER SWITCH TEMPERATURE o orr Es TURBO COOLING POWER LAMP 1 LAMP 2 TURBO COOLING BUTTON TURBO COOLING DOOR OPENING FAN RUNNING TURBO FREEZE 1 If you push the T F Turbo Freeze button the compressor will run for 120 minutes to bring down the temperature more rapidly 2 f you push the T F button again during Turbo Freeze mode the compressor will return to the normal operation 3 During the Turbo Freeze mode the temperature Up Down button will not affect the compressor s operation UP DOWN BUTTON TEMPERATURE CONTROL BUTTON 1 By pushing the UP
3. 1 L when inside temperature is higher than 99 F the panel will show Hi Lis FAN RUNNING INDICATOR 1 If the fan motor is running fan running indicator will be turned on 2 Evaporator fan motor will stop when the door is opened DOOR OPENING INDICATOR 1 If the door is opened an indicator will be turned on 2 30 seconds after the door is opened it will sound beep three 3 times 3 1 minute after the door is left opened it will sound beep again five 5 times 4 After 5 minutes of staying open the beeping sound will ring continuously 5 Once the door is closed the beeping noise will stop TROUBLESHOOTING SYMPTOMS CAUSES SOLUTIONS The unit is freezing The temperature is set too high Push the temperature button to melting food or low to contain food fresh the suitable position The unit does not There is a power connection Check the power cord and plug refrigerate at all failure problem in it correctly The unit is in sunlight or neara Check the installation place heating device Check the condition of stored The unit contains hot food or food too much food unit door is opened too frequently or left open long condenser is clogged The unit does not refrigerate well floor is too weak or the Check the installation and leveling feet is set incorrectly adjust the tray position There ie a loud noise
4. Vinegar based products Citrus based cleaners 2 CLEANING THE CONDENSER FINS To maintain proper refrigeration performance the condenser coil must be free of dust dirt and grease This will require periodic cleaning condenser fins should be cleaned at least every three months 90 days or as needed CLEAN THE GASKET The door gasket should be cleaned frequently to maintain proper sealing 4 CHECK AFTER CLEANING Check the unit again for safety Check that the unit is operating properly CAUTION 1 POWER CORD Please make sure that the power cord is connected to the proper voltage The power cord must be connected to a protected circuit with the correct voltage and amperage Turn off the power switch before disconnecting the power cord whenever performing maintenance functions or cleaning the refrigerated cabinet Compressor warranties are void if compressor burns out due to improper voltage 2 RE STARTING If disconnected wait for 5 minutes before re starting 4 BASIC OPERATION 1 Plug in to turn on the power and lamp switch located to the right side of the bottom grille The display panel will light up and make a beeping noise The compressor will begin to run The default temperature setting is at 37 for the Refrigerators The default temperature setting is at 8 F for the Freezers The compressor is automatically cycled by the electronic controller PCB F Sensor
5. The back side of the unit is too Close to the wall tray is not in the correct position There dew drops High moisture air can produce Wipe with dry cloth on the unit exterior dewdrops during rainy season There are dew drops The door is opened too Keep the door closed to on the unit interior frequently or left open long remove dewdrops Damp food is stored he door is bent Level the unit again unit has a leveling issue e Reposition the gasket he door gasket has come out The door does not close tightly The following are not malfunctions A water flowing sound can be heard when the compressor stops This is the sound of REFRIGERANT flowing The compressor does not run against defrosting function 10 Bir MANUFACTURING COMPANY THREE YEAR WARRANTY Turbo Air warrants to the original purchaser of every new Turbo Air refrigerated unit the cabinet and all parts thereof to be free from defects in material or workmanship under normal use and service for a period of three 8 year from the date of original installation or 39 months after shipment date from Turbo Air whichever occurs first Any parts covered by this warranty that are examined and determined by Turbo Air to have been defective within three 3 year of original installation or thirty nine 39 months after shipment date from manufacturer whichever occurs first shall be repaired
6. WARRANTY CLAIMS All claims should include model number of the cooler the serial number of the cabinet proof of purchase date of installation and all pertinent information supporting the existence of the alleged defect Any action or breach of these warranty provisions must be commenced within three 3 year after that cause of action has accrued hurbe TOR PUN i TURER 4184 E Conant St Long Beach CA 90808 TEL 310 900 1000 FAX 310 900 1077 TOLL FREE 1 800 627 0032 U S A amp Canada Website www turboairinc com Warranty Claims All claims for parts or labor must be made directly thorough Turbo Air All claims should include model number of the unit the serial number of the cabinet proof of purchase date of installation and all pertinent information supporting the alleged defect In case of compressor replacement under warranty either compressor or compressor tag must be returned to Turbo Air along with above listed information Failure to comply with warranty policies will result in voiding claims Three Year Parts amp Labor Warranty Turbo Air warrants all new refrigerated components the cabinet and all parts to be free from defects in materials or workmanship under normal and proper use and maintenance service as specified by Turbo Air and upon proper installation and start up in accordance with the instruction packet supplied with each Turbo Air unit Turbo Air s obligation under this warranty
7. or replaced as stated below Turbo Air shall be deemed to have fully complied with its obligation under the foregoing warranties by electing either one of the following procedures at the sole discretion of Turbo Air 1 Furnishing a replacement part freight collect in even exchange for the returned part freight collect 2 Receiving the defective part freight collect repairing it and returning it freight collect ADDITIONAL TWO YEAR COMPRESSOR WARRANTY In addition to the three 3 year warranty stated above Turbo Air warrants its hermetically and semi hermetically sealed compressor to be free from defects in both material and workmanship under normal use and service for a period of two 2 additional years from the date of original installation but not to exceed five 5 years and three 3 months after shipment from manufacturer Compressors determined by Turbo Air have been defective within this extended time period will at Turbo Airs option be either repaired or replaced with a compressor or compressor parts of similar design and capacity The two 2 year extended compressor warranty applies only to hermetically and semi hermetically sealed parts of the compressor and does not apply to any other parts or components including but not limited to cabinet paint finish temperature control refrigerant metering device driers motor starting equipment fan assembly any other electrical component etcetera 134A 404A COMPRESSOR WARR
8. ANTY The five year compressor warranty detailed above will be voided if the following procedure is not carefully adhered to 1 This system contains R134A refrigerant and polyol ester lubricant The Polyol ester lubricant has rapid moisture absorbing qualities If long exposure to the ambient conditions occur the lubricant must be removed and replaced with new Listed below are the approved lubricants for the Tecumseh compressors 1 ICl Emkarate RL 184 2 Emery 2927 A 3 Mobile Artic 22A Failure to comply with recommended lubricant specification will void the compressor warranty 2 Dryer replacement is very important and must be changed when a system is opened for servicing dryer must be used with XH 9 desiccant 3 Micron level vacuums must be achieved to insure low moisture levels in the system 500 microns or lower must obtained What is NOT covered by this warranty Turbo Air s sole obligation under this warranty is limited to either repair or replacement of parts subject to the additional limitations below This warranty neither assumes nor authorizes any person to assume obligations other than expressly covered by this warranty 1 WARRANTY IS NOT TRANSFERABLE This warranty is not assignable and applies only in favor of the original purchaser user to whom delivered ANY SUCH ASSIGNMENT OR TRANSFER SHALL VOID THE WARRANTIES HEREIN MADE AND SHALL VOID ALL WARRANTIES EXPRESS OR IMPLIED INCLUDING ANY WARRANTY OF MERCHANTABILITY OR
9. Down button you can set the inside temperature Refrigerators From 50 F to 30 F Freezers From 5 F to 17 F 2 To reduce the temperature push the Down button DEFROST 1 The electronic controller PCB features an intellectual algorithm which can recognize the defrost period that eliminates any icing on the evaporator which automatically adjusts to optimal energy saving temperatures For additional options this feature can be monitored and adjusted remotely by a wireless connection 2 f itis necessary to change the intervals of defrost due to unusual operating conditions it can be accomplished by adjusting the switch which is located on the inside the bottom grille 3 Once all frost is eliminated the temperature will continue to rise until it reachesH2 8 6 When this temperature is detected by the defrost limit control the defrost control changes to refrigeration mode 4 The panel displays during the defrost cycle HN T Ha umm IN ORDER TO SAFELY STORE FOOD ALARM This refrigerator will sound a warning alarm when temperatures fall outside of normal temperature ranges After pressing the temperature adjustment button and turning off the alarm please place a service call INNER TEMPERATURE DISPLAY 1 It displays inside temperature 2 Display range is 40 to 99 40 400 3 When inside temperature is lower than 40 the panel will display Q
10. EGARDLESS OF WHETHER OR NOT THEY RESULT FROM REFRIGERATION FAILURE WARRANTY IS NOT TRANSFERABLE This warranty is not assignable and applies only in favor of the original purchaser user to whom delivered ANY SUCH ASSIGNMENT OR TRANSFER SHALL VOID THE WARRANNTIES HEREIN AND SHALL VOID ALL WARRANTIES EXPRESS OR IMPLIED INCLUDING ANY WARRANTY OF MERCHANTABILITY OR LABOR COVERAGE FOR COMPONENT FAILURE OR OTHER THE WARRANTY PACKET PROVIDED WITH THE UNIT ALTERATION NEGLECT ABUSE MISUSE ACCIDENT DAMAGE DURING TRANSIT OR INSTALLATION FIRE FOOD ACTS OF GOD Turbo Air is not responsible for the repair or replacement of any parts that Turbo Air determines have been subjected after the date of manufacture to alteration neglect abuse misuse accident damage during transit or installation fire flood or act of GOD IMPROPER ELECTRICAL CONNECTIONS TURBO AIR IS NOT RESPONSIBLE FOR THE REPAIR OR REPLACEMENT OF FAILED OR DAMAGED COMPONENTS RESULTING FROM ELECTRICAL POWER FAILURE THE USE OF EXTENSION CORDS LOW VOLTAGE OR VOLTAGE DROPS TO THE UNIT NO IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE THERE ARE NO OTHER WARRANTIES EXPRESSED IMPLIED OR STATUTORY EXCEPT THE THREE 3 YEAR PARTS amp LABOR WARRANTY AND THE ADDITIONAL TWO 2 YEAR COMPRESSOR WARRANTY AS DESCRIBED ABOVE THESE WARRANTIES ARE EXCLUSIVE AND IN LIEU OF ALL OTHER WARRANTIES INCLUDING IMPLIED WARRANTY AND MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE
11. FITNESS FOR A PARTICULAR PURPOSE 2 NO CONSEQUENTIAL DAMAGES TURBO AIR IS NOT RESPONSIBLE FOR ECONOMIC LOSS PROFIT LOSS OR SPECIAL INDIRECT OR CONSEQUENTIAL DAMAGES INCLUDING WITHOUT LIMITATION LOSSES OR DAMAGES ARISING FROM FOOD OR PRODUCT SPOILAGE CLAIMS WHETHER OR NOT ON ACCOUNT OF REFRIGERATION FAILURE 3 ALTERATION NEGLECT ABUSE MISUSE ACCIDENT DAMAGE DURING TRANSIT OR INSTALLATION FIRE FLOOD ACTS OF GOD TURBO AIR is not responsible for the repair or replacement of any parts that Turbo Air determines have been subjected after the date of manufacture to alteration neglect abuse misuse accident damage during transit or installation fire flood or an Act of God 4 NO IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE THERE ARE NO OTHER WARRANTIES EXPRESS IMPLIED OR STATUTORY EXCEPT THE THREE 3 YEAR WARRANTY AND THE ADDITIONAL TWO 2 YEAR COMPRESSOR WARRANTY AS DESCRIBED ABOVE THESE WARRANTIES ARE EXCLUSIVE AND IN LIEU OF ALL OTHER WARRANTIES INCLUDING IMPLIED WARRANTY AND MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE THERE ARE NO WARRANTIES WHICH EXTEND BEYOND THE DESCRIPTION ON THE FACE HEREOF 5 TRANSPORTATION COSTS Turbo Air will accept parts covered under this warranty freight collect provided that shipment has received prior approval Turbo Air is not responsible for any other transporation costs but will ship freight collect pars either repaired or replaced under these warranties 6
12. THERE ARE NO WARRANTIES WHICH EXTEND BEYOND THE DESCRIPTION ON THE FACE HEREOF Outside U S and Canada This warranty does not apply to and Turbo Air is not responsible for any warranty claims made on products sold or used outside the continent of the United States and Canada New Extended Warranty policy applies to all units sold by Turbo Air starting Dec 1 2012
13. TION Please make sure to avoid any partition or objects that may stop the air flow Please make sure there is enough space for air circulation to the rear of the unit Recommended space between the rear of the unit to the wall is at least 5 inches 2 PLACE ABOVE STRONG FOUNDATION Please make sure that the floor where the unit will be placed can support the total weight plus any other contents that it may hold 3 DO NOT PLACE NEAR HEAT Please make sure to avoid hot corners and locations near stoves High ambient temperature will significantly reduce cooling efficiency 4 INDOOR USAGE ONLY This unit is designed and tested for indoor use only Outdoor usage will void its warranty 5 STABILIZATION Turn leg levelers counter clockwise in order to level the unit properly 6 LEVELING Please make sure that the unit levels from the front to the back and side to side 7 UNIT NEEDS TO BE PLUGGED TO A DEDICATED OUTLET CLEANING 1 CLEANING STAINLESS STEEL INTERIOR AND EXTERIOR Damage to stainless steel finish due to improper use of cleaning products or non recommended products is NOT covered under this product s warranty Use warm soapy water and soft clean cloth or sponge Rinse surfaces with clean warm water and dry immediately to avoid water spots NOT USE Abrasive or harsh cleaners Ammonia Chlorine bleach Concentrated detergents or solvents Metal or plastic textured scouring pads
14. is limited to a period of three 3 year from the date of original installation or 39 months after shipment date from Turbo Air whichever occurs first Any part covered under this warranty that are by Turbo Air to have been defective within three 3 year of original installation or thirty nine 39 months after shipment date from manufacturer whichever occurs first is limited to the repair or replacement including labor charges of defective parts or assemblies The labor warranty shall include standard straight time labor charges only and reasonable travel time as determined by Turbo Air Additional Two Year Compressor Warranty In addition to the three 3 year warranty stated adove Turbo Air warrants its hermetically sealed compressor to be free from defects in both material and workmanship under normal and proper use and maintenance service for a period of two 2 additional years from the date of original installation but not to exceed five 5 years and three 3 months after shipment from the manufacturer Compressor determined by Turbo Air to have been defective within this extended period will at Turbo Air s discretion be either repaired or replaced with a compressor or compressor parts of similar design and capacity The two 2 year extended compressor warranty applies only to hermetically sealed parts of the compressor and does not apply to any other parts or components including but not limited to cabinet paint finish tempe
15. rature control refrigerant metering device driers motor starting equipment fan assembly or and other electrical components etcetera 404A 134a Compressor Warranty The five year compressor warranty detailed above will be void if the following procedure is not carefully adhered to 1 This system contains R404A or R134a refrigerant and polyol ester lubricant The polyol ester lubricant has rapid moisture absorbing qualities 2 Drier replacement is very important and must be changed when a system is opened for servicing A620 copper drier or better is highly recommended 3 Micron level vacuums must be achieved to insure low moisture levels in the system 500 microns or lower must be obtained When compressor is grounded suction drier and 620 drier or better must be replaced 5 Compressor must be obtained through Turbo Air unless otherwise specified in writing through Turbo Air s warranty department A 404A 134a Compressor Warranty Turbo Air s sole obligation under this warranty is limited to either repair or replacement of parts subject to the additional limitations below This warranty neither assumes nor authorizes any person to assume obligations other than those expressly covered by this warranty NO CONSEQUENTIAL DAMAGES TURBO AIR IS NOT RESPONSIBLE FOR ECONOMIC LOSS PROFIT LOSS OR SPECIAL INDIRECT OR CONSEQUENTIAL DAMAGES INCLUDING WITHOUT LIMITATION LOSSES OR DAMAGES ARISING FROM FOOD OR PRODUCT SPOILAGE R
Download Pdf Manuals
Related Search