M48 GT User Manual
Contents
1. POWERED VEHICLE ELECTROMAGNETIC INTERFERENCE EMI Because EM energy rapidly becomes more intense as one moves closer to the source the EM fields from hand held radio wave sources transceivers are of special concern It is possible to unintentionally bring high levels of EM energy very close to the powered vehicle s control system while using these devices This can affect vehicle movement and braking The warnings listed below are recommended to prevent possible interference with the control system of the vehicle Wheeltech M48 GT electric scooter Part Code Z40962 00 Owner s Handbook Page 6 of 6 Warnings EMI from sources such as radio and TV stations amateur radio HAM transmitters two way radios and mobile phones can affect your vehicle Following the warnings listed below should reduce the chance of unintended brake release or powered vehicle movement which could result in serious injury 1 Do not operate hand held transceivers such as CB radios or turn on personal communication device such as mobile phones while the scooter is switched on 2 Be aware of nearby transmitters such as radio or TV station and try to avoid coming close to them 3 If unintended movement or brake release occurs switch the scooter off as soon as it is safe 4 Be aware that adding accessories or components or modifying the scooter may make it more susceptible to EMI Note There is no easy way to evaluate their effect on the overall immunit2. Owner s Handbook Page 21 of 21
3. Wheeltech M48 GT electric scooter Owners Handbook Part Code 240962 00 Page 5 of 5 2 4 EMI This section will provide the user with basic information that describes the problems with EMI known sources of EMI protective measures either to lessen the possibility or exposure or to minimize the degree of exposure and suggested action should unexpected or erratic movement occur Caution It is very important that you read this information regarding the possible effects of electromagnetic interference on your electric scooter ELECTROMAGNETIC INTERFERENCE EMI FROM RADIO WAVE SOURCES Powered vehicles may be susceptible to electromagnetic interference EMI which is interfering electromagnetic energy EM emitted from sources such as radio stations TV stations amateur radio HAM transmitters two way radios and cellular phones The interference from radio wave sources can cause the powered vehicle to release its brakes move by itself or move in unintended directions It can also permanently damage the powered vehicle s control system The intensity of the interfering EM energy can be measured in volts per metre V m Each powered vehicle can resist EMI up to a certain intensity This is called it s immunity level The higher the immunity level the greater the protection At this time current technology is capable of achieving at least a 20 V m immunity level which would provide useful protection from the more common sources
4. and forwards for a comfortable driving position To slide the seat pull the lever at the front of the seat and reposition as required Tiller Adjustment e The tiller can be adjusted in to several positions by the following steps 1 Loosen the knob to adjust the tiller to the position you want 2 Once you have selected the required position tighten the knob to secure the tiller amp Warning Please hold the tiller before loosening the tiller adjustment knob Otherwise the tiller may drop causing damage and or injury Never attempt to adjust the tiller whilst the scooter is in motion How to set freewheel mode e The freewheel lever is shown by the arrow in photo right e To put the scooter in to freewheel mode pull out the freewheel lever e To put the scooter in to drive mode push the freewheel lever in amp Warning When on a gradient NEVER switch the vehicle to the freewheel mode The electromagnetic brakes will not be applied This may result in damage or injury Main circuit breaker reset button When your batteries are drained or if the scooter is heavily worked because of excessive loads steep inclines or because the scooter is stuck etc the main circuit breaker may trip to protect the scooter from damage The circuit breaker button will pop out if it has tripped To reset the circuit breaker push the button back in There are two main circuit breakers to check They are located at the front of the rear shro
5. note that the key cannot be removed whilst the scooter is switched on e Forward Reverse and Braking e Push the wigwag paddle forwards with your right thumb and the vehicle will move forward e Push the wigwag paddle forwards with your left thumb and the vehicle will move backward e The horn will sound when the vehicle is reversing e Release the wigwag paddle freely while moving and the electromagnetic brake in the motor will be activated The rear brake lights will also illuminate when the electromagnetic brake is operating e The controls can be reversed for left handed people or those who do not have full use of their right arm Please enquire with your dealer about this setting e Manual Brake As well as an electromagnetic brake the M48 GT has a manual cable brake Squeeze the brake le ver to apply the brake then release the lever to release the brake e Speed Dial e The position of this dial determines the maximum attainable speed of the scooter e Turn the dial clockwise to increase the maximum speed or turn the dial anticlockwise to reduce the maximum speed attainable Wheeltech M48 GT electric scooter Part Code Z40962 00 Owner s Handbook Page 9 of 9 e Indicator switch e This switch flashes the right hand side or left hand side indicators intermittently e To use the indicators push the switch in the required direction of travel i e left or right and release the switch To switch the indicators off push the switch in
6. the street Engage the indoor setting if you are driving on the pavement amp WARNING Do not set in the freewheel mode when driving on a gradient Always re engage the freewheel device to DRIVE before use Failure to do so may result in injury Maximum user weight limit The maximum user weight for the scooter is 250kg 39 stone Overloading past this weight limit may lead to damage of your scooter or cause it to malfunction and will endanger your safety The warranty does not cover this type of damage ATTENTION 1 Do not push both RH and LH sides of the speed control lever simultaneously This might leave you unable to control your scooter Do not turn the ignition off whilst driving as this will lead to an emergency stop and possible risk of accident and injury Do not set to the outdoor speed setting whilst driving indoors Do not adjust the speed dial while driving a sudden change in speed may cause danger to you and others and may cause damage to your scooter Do not place magnetic devices near the controller and tiller areas as this could affect the safe operation of your scooter Do be careful while driving in heavy traffic or crowded areas While reversing the vehicle beware of people and or objects behind you Wheeltech M48 GT electric scooter Part Code Z40962 00 Owner s Handbook Page 4 of 4 e Stopping 1 Release the speed control lever completely The vehicle will naturally bra
7. weight capacity of this scooter is 250kg 39 stone as stated in the Specification section Wheeltech M48 GT electric scooter Part Code Z40962 00 Owner s Handbook Page 2 of 2 e Maximum loading weight for front basket is 5kg 111b 2 2 WHILST DRIVING e Carry out daily inspections Refer to the section entitled Daily Checking e Do not move your body out of the vehicle while moving e Pay attention that your clothes do not get caught in the wheels e Such action may cause you to lose balance and risk injury from falling e Do not use your vehicle under the circumstances below e On roads with heavy traffic or roads that are muddy gravely bumpy narrow snowed over icy or canal towpaths not guarded by any fence or hedge Keep away from places where you might get the wheels stuck e Do not drive at night or when it is raining snowing misty or windy e Do not drive your vehicle in an S pattern or make erratic turns e Do not take the scooter onto escalators e UNDER NO CIRCUMSTANCES SHOULD THE SCOOTER BE USED AS A SEAT IN A MOTOR VEHICLE E G CARS BUSES TRAINS ETC e About mobile phone and other electrical equipment e Do not use a mobile phone or other long range wireless communication devices while driving e Always switch off the scooter and remove the ignition key before using a mobile phone e Do not charge the mobile phone or any other electrical devices from your scooter s battery e Automatic Power Shut Dow
8. Feel tree to enjoy lite SCOOTER RANGE mp Vitesse Medicare Technology Limited Ainleys Industrial Estate Elland West Yorkshire HX5 9JP Tel 44 0 1422 314488 Fax 44 0 1422 314489 Email enquiries medicaretechnology com Web www medicaretechnology com Part No Z40962 The team ot Medicare Technology develops its products to give our customers the freedom to live independently This encompasses their daily home life and provides them with the opportunity to enjoy an outing with family and friends Our goal is to develop a range that will provide individuals with a chance to enjoy every doy life OWNERS MANUAL medicaretechnology LIMITED MERC URY M48 GT OWNER S HANDBOOK TABLE OF CONTENTS 1 PREFACE AND INTRODUCTION 6 BATTERY CHARGING AND CARE 2 SAFETY NOTICE 7 INSPECTION AND MAINTENANCE 3 PARTS DESCRIPTION 8 TROUBLESHOOTING amp SPECIFICATION 4 OPERATION 9 WARRANTY 5 DRIVING ON THE ROAD 1 PREFACE AND INTRODUCTION Please carefully read this owner s manual before using the vehicle Improper use of the vehicle could result in harm injury or traffic accidents Therefore to get the most from the vehicle read this owner s manual e This owner s manual includes operation instructions for every aspect of the vehicle assembly instructions as well as instructions for how to deal with possible incidents e The symbols used in this manual are explained below Pay particular attention to the no
9. acturing or material defect Such items include among others upholstery tyres and batteries 7 The above warranty conditions apply to brand new scooter purchased at the full retail price If you are unsure whether your power chair is covered check with the service agent Scooters supplied as secondhand by Medicare Technology carry a six months warranty 8 Under normal circumstances no responsibility will be accepted where the scooter has failed as a direct result of a The scooter part not having been maintained in accordance with the manufacturer s recommendations b Failure to use the manufacturer s specified parts c The scooter or part having been damaged due to neglect accident or improper use d The scooter or part having been altered from the manufacturer s specifications or repairs having been attempted before the service agent is notified Please note your local service agent s contact details in the box above In the event of your scooter requiring attention contact them and give all relevant details so they can act quickly The manufacturer reserves the right to alter without notices any weights measurements or other technical data shown in this manual All figures measurements and capacities shown in this manual are approximate and do not constitute specifications Medicare Technology Ltd E enquiries medicaretechnology com W www medicaretechnology com Wheeltech M48 GT electric scooter Part Code Z40962 00
10. and release e Horn button e Press the horn button to sound the horn Release the button to stop the horn from sounding e Head light switch e Push the head light button to switch on the front and rear head lights Push the button again to turn the lights off e Battery Indicator e When the ignition is switched on the battery gauge will illuminate to indicate the remaining battery power by the number of segments lit on the battery gauge The remaining power indicated by the gauge will vary by the way you drive Driving up inclines and repeated stopping and starting will consume power more quickly e If the battery gauge flashes but the scooter will still drive then this indicates low battery power and the batteries should be recharged immediately If the battery gauge flashes and the scooter will not drive this indicates that a fault has been detected with the scooter In this case seek advise from your dealer Suggestion 1 You should recharge the batteries each time the vehicle is used to ensure maximum range and optimal battery performance If the scooter is stood idle the batteries should still be charged once a week to maintain battery performance After charging or replacing a new battery drive the vehicle for 2 to 3 minutes to ensure the battery capacity is sufficient Then charge the battery immediately if not recently charged In wintertime the battery may respond more slowly and battery range may be reduced Cold tem
11. any cracks in the tyres or other tyre damage evident Check the tread depth Other Are there any abnormal noises Is there any oil leaking from the transaxle Attention Contact your dealer regarding inspection and maintenance should you find anything wrong with the scooter 7 2 REGULAR CHECKING RECORD Ensure your scooter is correctly serviced take it to your dealer for annual maintenance checks We also recommend the scooter is inspected by the dealer after the first month Your dealer may charge a fee for this service Wheeltech M48 GT electric scooter Part Code Z40962 00 Owner s Handbook Page 16 of 16 YEAR 1 2 3 4 5 YEAR 1 2 3 4 5 Fsovco paes TL seepaes O T Controller Upholstery FOnatewicn set FGanvotCover ak oo wam J e as o Terasi _ _ _ age Bates Connections conaiton ee T T T o O O Connections f V M M e Dera es Wheels and Tyres Fes wa _ ra Pesse Mem Bears am weere J Mers Motors Over obstacles wo TT T T E ws _ Connections f f f T Brake Ooo ws _ Chassis eoten See 1 7 3 BATTERY AND TYRES e Battery Refer to section 6 entitled Battery Charging and Care e Battery Charger Refer to separate instruction manual supplied with the battery charger e Tyres The condition of the scooter s tyres will depend on how you drive and use the scooter Please inspect the tyre tread regularly Re
12. arriageways e Be aware of traffic when crossing or using the road e Be extremely cautious when driving your scooter on busy streets or in shopping malls e Do not drive your scooter after consuming alcohol or when you are tired It is an offence to drive this scooter whilst under the influence of alcohol e Be careful when driving your scooter in low light It has not been designed for use at night e The scooter may only be used on the pavement or pedestrian areas at 4mph or less Use the indoor outdoor switch to ensure you keep within this limit The scooter may be used on single carriageways with the outdoor setting engaged e Practice operating your vehicle Before using the scooter in busy or potentially dangerous areas familiarize yourself with the operation of your scooter Practice in a wide and open area like a park In order to avoid accidents with your scooter whilst driving bear in mind driving motions such as accelerating stopping turning reversing and travelling on gradients e Turn the speed dial to 3 for your initial practice e Be sure somebody accompanies you for safety when driving on the road for the first time e Only use the higher speed setting when you are confident that you can easily operate and control your scooter e The scooter is only to be used by one person at a time Do not carry passengers on your scooter including children e Do not use this vehicle to carry or haul goods e The maximum
13. batteries are charged for Please note longer than 24 hours The scooter will be immobilized 7 After charging is complete switch off the mains at whilst the charger is connected the plug socket and remove the charger from the scooter and the mains Leaving the charger switched off but connected can drain the batteries Suggestion Do not disconnect the charger if charging is not complete Battery life and performance will be dramatically reduced if the battery is repeatedly used without being fully charged 2 Always charge the batteries until the Charge Complete LED is lit When fully charged the battery charger will still trickle charge the battery to ensure optimum battery range and performance If you scooter is stood idle you should still charge it every week to maintain battery performance Charging time will be affected by the ambient temperature Charging time is longer in cold periods such as winter After charging do not leave the charger socket plugged in to the scooter as this will cause a power drain on the scooter and temporarily reduce its range The batteries carry a twelve month manufacturer s warranty This warranty only covers issues relating to manufacturing faults and not faults relating to failure to recharge the batteries as instructed above If the scooter is going to be left for a period of one month or more we recommend disconnecting the grey battery connector Wheeltech M48 GT electr
14. e plate attached the to left hand side of the scooter frame below the shock absorber and behind the wheel Also note down the details of the Medicare Technology dealer who sold the scooter Medicare Technology Authorized Service Agent Details Name Tel Postcode m o 9 2 WARRANTY CONDITIONS There is a comprehensive twelve month warranty from the date on which your new scooter is delivered The warranty covers the scooter for repairs or replacement during this period For more detail please see the Warranty Conditions below Warranty Conditions 1 Any work or replacement part installation must be carried out by an authorized Medicare Technology dealer service agent 2 To apply the warranty should your scooter require attention please contact the designated service agent listed above 3 Should any part of the scooter require repair or full or part replacement as a result of a manufacturing or material defect within twelve months of receiving the scooter replacement parts will be supplied free of charge Note This guarantee is not transferable 4 Any repaired or replaced parts will be covered by this warranty for the balance of the warranty period on the scooter Parts replaced after the original warranty has expired will by covered by a three months warranty Consumable items supplied will not generally be covered during the normal warranty period unless such items require repair or replacement clearly asa direct result of a manuf
15. freeze or overheat This will damage the batteries and shorten their life e The batteries supplied are maintenance free and there is no need to refill with water e You are required to recharge the batteries on a regular basis Even if the scooter is stood idle you should charge the batteries at least once a week amp Warning Do not open the battery sealed cap at any time Wheeltech M48 GT electric scooter Part Code Z40962 00 Owner s Handbook Page 14 of 14 Installing the batteries The batteries procedure below is used to either install replace or gain access to clean the battery If the batteries are contaminated by water battery acid dust or other substances they will discharge quicker The batteries supplied with the scooter are sealed and as such are maintenance free with no risk of battery leakage Please follow the steps below to install the batteries 1 Turn the scooter off at the ignition 2 Remove the seat and shroud optional 3 Adjust the tiller so it is fully forward only required if the seat and shroud have not been removed 4 Remove the locking pins attaching the top of the two rear shock absorbers to the H frame 5 Tilt the H frame forward to gain access to the battery bays Tilt by lifting up the H frame from the rear if the shroud and seat are removed If the seat and shroud are still present tilt by lifting the handle at the back of the seat Ensure the elbow of the silver locking arm is pus
16. hed forward to its furthest extent 6 Remove old batteries if necessary Insert a new battery in to each of the battery bays Connecting the batteries CUT OUT The batteries must be connected as shown in the black cable diagram left and photograph below It is important that the cables are routed as shown in the photograph as failure to do so could interfere with the H frame and other components when the rear of the scooter is being accessed for maintenance red cable black cable CTRL BOX RELAY Wheeltech M48 GT electric scooter Part Code 240962 00 Owner s Handbook Page 15 of 15 7 INSPECTION AND MAINTENANCE 7 1 INSPECTION Check the following items before driving If you find anything abnormal read this owners handbook then contact your dealer for further inspection or advice if required Handlebar Is there any looseness Can the handlebar turn left and right smoothly Can it be rotated freely and does it function correctly Wigwag paddle Does the scooter move when the paddle is operated Does the scooter completely stop when the paddle is released Motor Does the motor make any abnormal noises pr Does the electromagnetic brake work correctly Does the freewheel lever function correctly Battery gauge Does the gauge illuminate when the scooter is switched on Is there enough power remaining for your journey Does te om work Does the seat swivel correctly and smoothly Tyres Are there
17. ic scooter Part Code Z40962 00 Owner s Handbook Page 13 of 13 Attention Follow the rules below to avoid accidents while charging Use the charger supplied with the scooter only and recharge the battery to its full capacity every time You may damage the battery and the scooter if you use a charger which is not to the correct specification Never disassemble or modify the charger Charge in a well ventilated space where it is not directly exposed to sunlight Do not charge in surroundings where it is humid or susceptible to rainfall damp or morning dews Do not cover with a cloth or any other objects while charging Do not charge in temperatures less than 10 C or higher than 50 C as the charger may not work properly and the batteries may become damaged amp Warning Keep away from flammable objects while charging as this could lead to fire or explosion Do not smoke while charging as the battery may release hydrogen gas Always charge your battery in a well ventilated space Never connect or disconnect the plug or cord with wet hands while charging Do not connect or disconnect the plug or cord when they are wet Failure to observe this could result in electric shock 6 2 CHARGER e Please read the separate instruction manual included with the charger 6 3 BATTERY e Do not expose to temperature below 10 C or above 50 C when charging or storing the vehicle Temperatures outside this range can cause the battery to
18. ilst reversing the vehicle be aware of people or objects behind you Stopping Release the wigwag paddle completely The vehicle will automatically brake and stop If required use the hand brake to assist braking Attention Stopping distances will vary with your speed Therefore begin braking as early as you can While parking your scooter ensure you park on flat ground and then turn the power off at the ignition before disembarking Wheeltech M48 GT electric scooter Part Code Z40962 00 Owner s Handbook Page 12 of 12 6 BATTERY CHARGING AND CARE 6 1 CHARGING THE BATTERY Follow the procedure below step by step THE BATTERY IS 1 Turn off the scooter at the ignition BULK CHARGING 2 Connect the charger to the mains plug socket 3 Open the charging socket cap on the left hand side of the scooter tiller Then insert the 3 pin round plug in THE BATTERY IS to the charging socket on the scooter tiller TRICKLE CHARGING Switch on the mains to power the charger THE BATTERY HAS RECHED FULL VOLTAGE LEAVE CHARGER SWITCHED ON FOR AT LEAST 2 HOURS 5 An LED will illuminate on the charger to indicate it is connected to mains power Another LED will also light to indicate the charge status of the batteries The charge status of the batteries is described by the diagram on the right 6 The unit should be left on charge for at least 16 hours or until the charger shows charge complete We do not recommend that the
19. ke and stop 2 Turn the power switch to OFF Then pull out the key 3 In an emergency braking distance will be halved if the throttle is shifted to full reverse whilst travelling forward 2 3 LABELLING Please carefully read all labels on the scooter before using For your future reference do not remove the labels A copy of the labels and their positions are shown below WARNING Radio wave sources may affect scooter or powerchair control Radio wave sources such as radio stations TV stations amateur radio HAM transmitters two way radios and cellular phones can affect powered motorized scooters WARNING NEVER LIFT THE SCOOTER OR Please hold the tiller before POWERCHAIR UP BY THE loosening the tiller adjustment FRONT OR REAR SHROUD 4 knob Otherwise a fall from the scooter could occur causing bodily injury and or damage to the scooter WARNING Never operate the freewheel lever while sat on the scooter or on an incline Operation of the FREEWHEEL LEVER e Always pull UP FIRMLY for freewheel mode e Always push DOWN FIRMLY for drive mode WARNING Before lifting up the rear shroud please make sure to adjust the T handlebar to the front most position After lifting the rear shroud please ensure that the prop levers are in the lock position before proceding on any operation When retreiving the rear shroud to the original position please make sure to hold the lift bar with one hand and lift down the shroud slowly I
20. ll not drive and the left e Ensure the wigwag paddle is released hand panel on the battery gauge switch the scooter off and on using the ignition key will flash a sequence code e Recharge the batteries e If the problem persists contact your dealer Mercury M48GT Specification Mercury M48GT Specification cont d Dimensions 1560 x 740 x 920mm Brake system Electromagnetic with Lx Wx H 61 x 29 x 3614 Secondary cable brake Weight With battery 168kg 370Ib Without battery 116kg 255Ib By wigwag paddle Climbing angle 10 1 in 6 maximum Drive system Direct drive to the rear wheels 30 mile 48km with transaxle Max user weight 250kg 39 stones Wheeltech M48 GT electric scooter Part Code Z40962 00 Owner s Handbook Page 19 of 19 Note e Maximum driving distance cruising range is based on an ambient temperature of 20 C a 100kg driver and a brand new fully charged battery and a constant driving speed of 4mph 6kph with 70 battery power discharged e The manufacturer reserves the right to modify the specification if necessary The final specification is subject to the individual scooter your purchase from your dealer Wheeltech M48 GT electric scooter Part Code Z40962 00 Owner s Handbook Page 20 of 20 9 WARRANTY 9 1 VIN VEHICLE IDENTIFICATION NUMBER To ensure the correct after sales service and warranty service support please write down the vehicle identification number on th
21. n In order to avoid accidental battery run down your scooter is equipped with an automatic power shut down facility If the scooter is switched on after remaining undisturbed for a period of thirty minutes it will automatically turn off Should this occur simply switch your scooter off and back on and it will be ready to use once again e Ramps Gradients and Drops e Do not drive onto gradient steeper than 10 1 in 6 e Always use a low speed setting when ascending or descending a gradient e Do not drive on roads with large drops or potholes e Do not cross water gutters where the width is too big and where there is a risk of getting the wheels stuck e Slow down when driving on roads with gradients Wheeltech M48 GT electric scooter Part Code Z40962 00 Owner s Handbook Page 3 of 3 e Starting and Driving te eee a o 2 Te SS Make sure the seat is installed properly Make sure the tiller has been secured properly Fold down the armrests so you can rest your arms on them Turn the ignition on If necessary turn on the headlights Check battery indicator to see whether there is enough power for your journey If you have any doubt about the remaining power recharge the batteries before departure Set the speed dial to a position you feel safe and comfortable with Check the forward reverse wigwag paddle works correctly Make sure the electromagnetic brake works correctly Make sure it is safe around you before you drive on
22. of radiated EMI This powered vehicle as shipped with no further modification has an immunity level of 20 V m without any accessories There are a number of sources of relatively intense electromagnetic fields in the everyday environment Some of these sources are obvious and easy to avoid Others are not apparent and exposure is unavoidable However we believe that by following the warnings listed below your risk to EMI will be minimized The sources of radiated EMI can be broadly classified into three types 1 Hand held portable transceivers transmitter receivers with the antenna mounted directly on the transmitting unit Examples include citizens band CB radios walkie talkies security fire police transceivers and mobile telephones Note Some mobile telephones and similar equipment transmit signal while they are ON even when not being used 2 Medium range mobile transceivers such as those used in police cars fire engines ambulances and taxis These usually have antennae mounted on the outside of the vehicle 3 Long range transmitters and transceivers such as commercial broadcast transmitters radio and TV broadcast towers and amateur HAM radios Note Other types of hand held devices such as cordless phones laptop computers AM FM radios TV sets CD and DVD players and small appliances such as electric shavers and hair dryers so far as we know are not likely to cause EMI problems to your powered vehicle
23. peratures temporarily reduce battery performance When driving on a gradient the battery gauge reading might fluctuate This is a normal phenomenon and there is no cause for concern Even if a battery is used properly it is natural for the battery s capacity to reduce with time which results in reduced battery range The batteries should be replaced when you find the batteries range is about only half of the range of when the batteries were performing optimally Please see your dealer about replacement batteries and the safe disposal of your old batteries If you continue to use the batteries it is likely you will see a rapid decline in performance The battery range is reduced when driving frequently up gradients or on rough terrain as this causes greater power consumption Wheeltech M48 GT electric scooter Part Code Z40962 00 Owner s Handbook Page 10 of 10 e Seat The seat can rotate 360 and locks in 45 settings To rotate push the lever located underneath the right hand side of the seat and swivel seat Release the lever and carry on swivelling the seat until it locks in position Attention Return the seat to the forward position before driving How to adjust the arm rest width Loosen the knobs at the back of the seat frame then adjust the arm rest width by sliding the arm rest to the required width Re tighten the knob and repeat for the other arm rest How to re position the seat The seat can be slid backwards
24. place the tyres if there is any tyre damage or if the tread depth is less than 0 5mm 1 32 Attention 1 When the tyre tread depth is less than 0 5mm it can easily lead to vehicle slippage and braking distances will become longer Therefore when the tread depth is less than 0 5mm replace the tyres as soon as possible The tyre pressure should be around 26 PSI 1 8bar for the best ride and handling Wheeltech M48 GT electric scooter Part Code Z40962 00 Owner s Handbook Page 17 of 17 Attention When conducting maintenance of your vehicle turn the scooter off at the ignition and remove the charger cords Suggestion Use a damp cloth or a duster with a norabrasive polish to clean the scooter When cleaning the scooter do not splash water directly on it as this could lead to malfunction Do not use petrol solvents or vaporizing solution as these may deform or damage the shrouds Do not use wax 74 STORAGE Ensure the vehicle is stored with the seat set in the forward position and the ignition is switched off Suggestion Store the scooter in a location where it is away from direct sunlight rain or damp When storing for a long period of time charge the battery fully and then disconnect the battery terminals Contact your dealer for more details 7 5 MOVING ABOUT Before moving switch the scooter off at the ignition Lift the scooter by the chassis and not by the bumpers or the shroud as this co
25. tes marked with the symbols below Improper use could result in serious injury or death Improper use could lead to injury and or damage to your scooter Suggestion Follow these instructions to keep your vehicle in good working order e This manual includes a copy of the repair and maintenance record chart and warranty information Keep it in a safe place or with the scooter e If somebody else uses the scooter make sure that you provide them with this owner s manual for his or her consideration e As designs change some illustrations and pictures in the manual may not correspond to the vehicle that you purchased We reserve the right to make design modifications e Our scooters have been designed and manufactured to provide a comfortable and secure yet affordable solution for some mobility requirements Suggestion To optimise battery efficiency and longevity fully recharge your new batteries before use Wheeltech M48 GT electric scooter Part Code Z40962 00 Owner s Handbook Page 1 of 1 2 SAFETY NOTICE 2 1 BEFORE DRIVING The user needs to be familiar with the usage and operation of this vehicle before driving Therefore always keep the following safety notices in mind e The same traffic rules apply to the use of this vehicle as apply to pedestrians For your safety follow the rules that apply to pedestrians e Ride on the pavement single carriage roads or pedestrian areas only Never ride on motorways or dual c
26. tis dangerous and prohibited to put head or hands under the shroud in any circumstance Do not operate the scooter unless the handlebar is in the lock position Do not lean against or pull forward on or powerchairs Following the warnings listed below should reduce the chance of the handlebar while mounting or unintended brake release or powered scooter powerchair movement which could result in dismounting from the scooter Serious serious injury harm or injury can occur 1 Do not turn ON hand held personal communication devices such as citizens band CB radios and cellular phones while the powered scooter or powerchair is turned on The manufacturer disclaims all 2 Be aware of nearby transmitters such as radio or TV stations and try to avoid coming responsibility for any personal injury or close to them powerchair OFF as soon as itis safe property damage which may occur as a 3 If unintended movement or brake release occurs turn the powered scooter or result of improper or unsafe use 16 products 4 Be aware that adding accessories or components or modifying the powered scooter or powerchair may make it more susceptible to interference fro radio wave sources Note There is no easy way to evaluate their effect on the overll immunity of the powered scooter or powerchair 5 Report all incidents of unintended movement or brake release to the manufacturer and note whether there is a radio wave source nearby
27. ud near the users heels Wheeltech M48 GT electric scooter Part Code 240962 00 Owner s Handbook Page 11 of 11 5 DRIVING ON THE ROAD e Starting and Driving 1 Ensure the seat is installed properly Ensure the tiller has been secured properly Fold down the arm rests so you can rest your arms comfortably on them Turn the ignition on So i RD Check the battery gauge to see whether there is enough battery power for your journey If you have any doubt about the remaining power recharge your batteries before departure Set the speed dial to a position you feel safe and comfortable with Check the wigwag paddle works correctly Ensure the electromagnetic brake works correctly een nN Before driving ensure it is safe to do so in the environment around you Attention Do not push both right hand and left hand sides of the wigwag paddle simultaneously This might leave you unable to control your scooter Do not turn the ignition off while driving as this will lead an emergency stop and possible risk of accident injury and damage Do not set to the highest speed whilst driving indoors Do not adjust the speed dial whilst driving A sudden change in speed may cause damage to you and other and may cause damage to your scooter Do not place magnetic devices near the controller or tiller area as this could affect the safe operation of your scooter Do be careful whilst driving in heavy traffic or crowded areas Wh
28. uld cause damage or injury You will need 2 or 3 people to lift or move the vehicle It is recommended that you remove the batteries before lifting the vehicle 7 6 RIDE AND HANDLING e The M48 GT comes with all round adjustable suspension The suspension can be adjusted for a firm ride for better handling or a soft ride for user comfort For more information about adjusting this contact your dealer Wheeltech M48 GT electric scooter Part Code Z40962 00 Owner s Handbook Page 18 of 18 8 TROUBLESHOOTING AND SPECIFICATION TROUBLESHOOTING You can inspect the scooter using the checklist below before consulting your dealer If you cannot solve the problem by yourself contact your dealer Symptom The scooter will not switch on Recharge the batteries Check reset the circuit breaker in the scooter Check the battery and loom connections The scooter switches on but the Ensure there is enough power in the batteries If not recharge the scooter will not move batteries Ensure the freewheel lever is engaged in the DRIVE position The scooter appears slow Check the battery power level and recharge Check the speed dial is not set to slow and that indoor outdoor switch is set to the faster setting if applicable The seat turns when in operation e Slowly rotate the seat until it drops in to place and is secure The tiller handlebar appears loose e Tighten the tiller adjustment handle to secure the handlebar Scooter wi
29. y of the scooter 5 Report all incidents of unintended movement or brake release to the scooter manufacturer and note whether there is a source of EMI nearby IMPORTANT INFORMATION 1 20 V m is a generally achievable and useful immunity level against EMI the higher the level the greater the protection 2 This product has an immunity level of 20 V m without any accessories connected to it Wheeltech M48 GT electric scooter Part Code Z40962 00 Owner s Handbook Page 7 of 7 3 PARTS DESCRIPTION 6 PARTS DESCRIPTION 1 Tiller 7 2 Rear view mirror 3 Shopping basket 4 Tiller adjustment knob 5 Head lamp 6 Hand brake lever 7 Front indicator lamp 8 Arm rest 9 Seat 10 Reset switch circuit breaker 11 Side reflector 12 Rear indicator lamp 13 Rear lamp brake lamp 14 Rear reflector 15 Anti tip wheels Wheeltech M48 GT electric scooter Part Code 240962 00 Owner s Handbook Page 8 of 8 4 OPERATION 4 1 CONTROL PANEL 1 Wigwag paddle 5 Speed dial 2 Head light switch 6 Indicator switch 3 4mph 8mph switch 7 Hazard light switch 4 Battery gauge 8 Horn 4 2 HOW TO OPERATE YOUR SCOOTER e Ignition Switch e The ignition switch is operated by the key supplied and is located on the right hand side of the tiller below the front indicator lamp e To switch the scooter on insert the key and turn 90 clockwise e To switch the scooter off turn the key 90 anticlockwise and remove
Download Pdf Manuals
Related Search