Waterwise 1600™ - Everything Kitchens
Contents
1. 3 11 WISE USE amp CARE GUIDE Waterwise 1600 Non Electric Steam D istiller Purifier MEMBER we SAG See important safeguards on pages 2 and 3 j An exclamation point within an equilateral triangle is intended to alert user to the presence of important operating and maintenance instructions in the literature accompanying the appliance Flame and steam vapor within an equilateral triangle is intended to alert user to risk of injury from boiling water and or escaping steam rr A IMPORTANT SAFEGUARDS A person who has not read and understood all operating and safety instructions is not qualified to operate this appliance W hen using this appliance always adhere to basic safety precautions including 10 READ ALL INSTRUCTIONS BEFORE USE FOR HOUSEHOLD USE ONLY O perate on a flat level well supported stable heating surface DO NOT operate in a moving vehicle DO NOT allow children to be near Distiller without close supervi sion Boiling water will scald if spilled on skin Warn other users of possible dangers from boiling water and or escaping steam DO NOT change postion or location of Distiller while it is operating or cooling Wait at least one hour after a cycleis finished or interrupted before moving Distiller Water in the boiler assembly is heated to boil ing 212 F and can cause severe burns DO NOT remove water coolant tray assembly fig B while Distiller is operating or coo2. NING DO NOT change postion or location of Distiller or remove water coolant tray assembly fig B while D istiller is operating or cooling Boiling water or steam can cause severe burns Let cool at least one hour after a cycleis finished or interrupted before removing water coolant tray assembly W hen timer is correctly set alarm will sound at completion of cycle To prevent vacuum buildup in collector storage container place collection plug loosely into opening while cooling Insert plug securely after cooling At the end of the cycle DO NOT handle Distiller or collector storage container until completely cooled at least one hour D uring continu ous operation caution should be taken when removing fill spout cap fig B to refill boiler or check boiler water level If continued operation is desired refill boiler through fill spout refill the three water coolant trays exchange collector storage container and reset timer Always use potholder or insulated oven mitt when handling hot components If no further operation is desired let cool at least one hour Discard remaining water from coolant trays and boiler Rinse and dry carefully prior to storage T his ensures efficient operation and reduces mineral deposit buildup and possible corrosion DO NOT remove collection cup assembly from boiler as this may cause the grommet to become damaged or it may cause the collection cup assembly to become bent so that distillate will not flow int
3. Stove Burner H ot Plate W hen operated on atypical large stove burner 2600 watt electric at 240 volts or 8900 Btu hr gas burner the Distiller will produce a 3 liter 3 18 qt batch in 72 minutes W hen operated continuously the Distiller will produce about 60 liters 16 gal in 24 hours W ith lower voltage or lower gas Btu output the cycle time will increase accordingly Natural LP Gas W hen using an extremely large natural or propane gas burner it is possible that a high flame setting may hinder performance or cause an open flame to come up around the side of the boiler and damage the boiler handles In this case the gas can simply be turned down see Troubleshooting on page 11 Wood C oal W hen operating on a wood coal or open fire Distiller must sit on a flat level well supported stable surface Close monitoring is recommended during operation Be sure boiler and water coolant tray assembly are prop erly filled especially during continuous production IMPORTANT Unit WILL NOT perform on induction type heat sources WARNING To prevent personal injury burn and or scalding DO NOT change position or location of Distiller or remove water coolant tray assembly fig B while D istiller is operating or cooling Boiling water or steam can cause severe burns Let cool at least one hour after a cycle is finished or interrupted before renoving water coolant tray assembly Wat erwise 1600 Steam Distiller Purifier Use amp Care G
4. Tray Assembly Coolant Tray Baffle Vent Cap z B Collection Tube Flexible Connector Fill Spout and Maximum Fill Level n Boiler Assembly Boiler Handle 4 Waterwise 1600 Steam D istiller Purifier Use amp CareGuide A FigureC USING THE DISTILLER Discard the first two cycles of purified water as it may contain some harmless matter from manufacturing and or packaging 1 2 Collection Cup Assembly Connector Collection Place boiler assembly on a flat level well supported stable heating surface Be sure to center on heat source Place floating stainless steel screen in bottom of boiler carefully to prevent bending the collection cup assembly fig C Fill boiler with approximately 4 liters slightly more than 1 gallon of ordinary wate DO NOT exceed MAXIMUM FILL level the hori zontal edge at the top of the opening inside of the fill spout fig C M ake sure fill spout cap isin place fig B Securely position water coolant tray assembly onto top of boiler Vent cap should always be loosely in place not jammed down during operation fig B Pour approximately 1 liter slightly more than 1 quart of water into each of the three water coolant trays T his amount of water will totally submerge the tray baffles at the outer diameter but not near the center of the tray DO NOT overfill trays Place collector storage container beside boiler with dispensing plug securel
5. dvertently bent see Level Test on page 7 Periodically check vent cap on top of water coolant tray assembly Vent cap should be loose so it can rattle up and down a little it should not be jammed down tightly onto the top tray All components especially the boiler should dry out when not in operation Removal of fill spout cap during storage will allow the entire machine to dry out This Distiller is a precision built instrument and should be treated as such DO NOT stack heavy weights on it or otherwise bend or distort any of the components All parts must bein place for maximum operat ing efficiency and performance 10 Waterwise 1600 Steam Distiller Purifier Use amp Care Guide TROUBLESHOOTING Problem No water production Possible C ause H eat source not activated N ot on flat level well supported stable heating surface Little or no water in boiler No downhill slope from collection cup to collector storage container Solution Activate heat source Stabilize heating surface Fill boiler fig C Check collection cup and downward flow page 7 Slow water production Low cool heat source Inadequate downhill slope from collection cup to col lector storage container Turn up heat or move to larger burner or heat source Check collection cup and downward flow page 7 Slow water production Steam leaks from boiler or water coolant trays and or excessive steam from collection tub
6. e Too much heat Vent cap too tight Water coolant tray assembly not properly seated on boiler O ne or more water coolant trays out of water Turn down heat Allow unit to cool loosen vent cap Cool down unit seat evenly on boiler Fill the water coolant tray s Water has unusual taste The boiler has been overfilled Boiler screen not in place Boiler not thoroughly cleaned and rinsed C ollector storage contain er needs cleaning DO NOT overfill boiler fig C Place screen in boiler Clean and rinse page 8 Clean collector storage container page 8 Water or steam spurting from collection tube or between water coolant trays H eat source too high hot Vent cap jammed down tightly onto top of water coolant tray assembly Reduce heat to complete cycle W hen unit has cooled remove vent cap and replace it loosely C ontact qualified service personnel for repair if above troubleshooting tips fail Wat erwise 1600 Steam Distiller Purifier Use amp Care Guide 11 WARRANTY REGISTRATION CARD Please fill out and return the enclosed registration card or register online at http www waterwise com customers customers asp Registration will not affect warranty coverage but may expedite processing of your warranty Registration is the only way to guarantee you will be notified by Waterwise of any issues that arise concerning this product OWNER S LIMITED WARRANTY W aterwise warra
7. istiller Purifier Use amp Care Guide FigureA 11 12 13 14 15 16 17 18 19 DO NOT operate after a malfunction or if the D istiller has been damaged in any manner Return to an authorized dealer or authorized service facility for examination repair or replacement DO NOT operate without water in the boiler and in all three of the coolant trays Permanent damage may occur M ake sure all components are secure and that the collector storage container is properly positioned for operation with its dispensing plug in place collection plug removed and collection tube in place Vent cap should always be loosely in place not jammed down during operation fig B This Distiller requires no special care other than general cleaning page 8 If servicing becomes necessary contact an authorized dealer or authorized service facility DO NOT attempt to repair distiller yourself Except for boiler grommet there are NO user serviceable parts Unauthorized service or maintenance may void warranty See warranty for details DO NOT drop or insert any object into Distiller openings W hen collector storage container is cooling at the end of a cycle leave one plug loose to prevent vacuum buildup For best water quality DO NOT FILL BOILER ABOVE THE MAXIMUM FILL LEVEL fig C DO NOT OPERATE DISTILLER IF WARNING LABEL IS NOT AFFIXED fig A AX WARNING Boiling water or steam can cause severe burn
8. ling Boiling water or steam can cause severe burns Let cool at least one hour after a cycle is finished or interrupted before removing water coolant tray assembly DO NOT place near the edge of a surface where D istiller can be bump ed or pulled down on someone If continuous collection kit is used be sure collection tubing is positioned so that D istiller cannot be pulled down on someone Boiling water or steam can cause severe burns DO NOT touch hot surfaces Always use potholder or insulated oven mitt when handling hot components C ollector storage container gets very hot during use During continuous operation page 6 caution should be taken when removing the boiler fill spout cap fig B to refill boiler or check boiler water level U se potholder or insulated oven mitt to remove this cap Allow Distiller and collector storage container to cool at least one hour after a cycle is finished or interrupted Boiling water or steam can cause severe burns This Distiller is recommended for use with potable wate ONLY DO NOT attempt to make safe drinking water from non potable water sources DO NOT usesalt water as this will damage certain components and will void warranty O perate in a well ventilated area Provide adequate air space at least 6 8 inches from walls or cabinets when in use DO NOT placeina heated oven DO NOT place store or stack anything on top or against sides of D istiller while in operation Waterwise 1600 Steam D
9. llection cup assembly Removal of this component may cause the rubber grommet to be cut or may cause collection cup assembly to become bent so that the purified water will not flow downward into the collector storage container The collection tube is sealed to the boiler with a grommet which may become damaged if the collection cup assembly is removed or if the boiler is inadvertently allowed to run dry A spare grommet is included MAINTENANCE Cleaning Water Coolant Tray Assembly Rinse water coolant tray assembly with warm water to remove any loose residue As scale deposits build up use an approved cleaner such as KLEEN WISE to remove mineral deposits W hite vinegar or automatic coffee pot cleaner can also be used DO NOT operate Distiller with clean ing solution in water coolant trays U se a soft plastic or nylon scouring pad if needed DO NOT use abrasive cleaners caustic acids steel wool pads or metal utensils Rinse thoroughly after cleaning and wipe trays with a clean soft cloth or sponge to dry Cleaning Boiler Assembly Rinse boiler with warm water to remove any loose residue DO NOT remove components As scale deposits build up inside use an approved cleaner such as KLEEN WISE to remove deposits W hite vinegar or au tomatic coffee pot cleaner can also be used DO NOT operate Distiller with cleaning solution in boiler U se a soft plastic or nylon scouring pad if needed DO NOT use abrasive cleaners caustic acids steel wo
10. nts to the original purchaser all stainless steel parts against defects in materials and workmanship for a period of three 3 years from the date of purchase D efects or failures due to shipping handling improper use or maintenance including abuse or neglect normal wear water conditions accidents alterations or modifica tions or unauthorized repair are specifically excluded from this warranty N o dealer distributor agent representative or other person is authorized to extend or expand this warranty Waterwise is not responsible or liable for personal injury property damage or inciden tal or consequential damages arising out of or in connection with the use or perfor mance of the product or other damages with respect to loss of use or costs of removal installation or reinstallation Waterwise will at its option replace or repair the defective part s without charge provided they are returned transportation prepaid by owner to an authorized service facility or to the address below Enclose a letter describing the problem copy of dated proof of purchase and your name address and daytime telephone number Thislimited warranty does not guarantee uninterrupted service Repair or replace ment as provided under this warranty is the exclusive remedy of the purchaser T his limited warranty isin lieu of all other warranties expressed or implied including but not limited to any implied warranty of merchantability or fitnes
11. o the collector storage container Collection Opening Timer Collector Storage Container Wat erwise 1600 Steam Distiller Purifier Use amp Care Guide Figure E Figure F LEVEL TEST To ensure maximum operating efficiency and optimum water quality always operate D istiller on a flat level well supported stable heating sur face If Distiller isnot level performance may be impaired If collection cup assembly has been inadvertently bent purified water will not flow out of the boiler Purified water will drip back into the boiler and not through collection tube as designed To Test Place Distiller on a flat level surface Remove water coolant tray assembly from boiler fig E Slowly pour water into collection cup fig F Water should flow evenly around collection cup and out of the collection tube without overflowing and running into the boiler If it does not adjust the collection cup so that the water can easily flow downward out of the cup to the collection tube fig F Collection cup assembly M U ST REMAIN LEVEL and collection tube must run at a downward slope gt gt gt gt 0 l ii gt gt gt gt Collection Tube ensure downward slope Collection Opening Collection Cup Di spensing Plug Waterwise 1600 Steam Distiller Purifier Use amp Care Guide 7 into the collector storage container fig F DO NOT remove co
12. ol pads or metal utensils Rinse thoroughly after cleaning and dry carefully IMPORTANT When cleaning boiler use special care NOT to bend or damage collection cup assembly or screen T he collection cup assembly must remain level so distillate can run into the collector storage container T he stainless steel screen is designed to prevent boiling water from splash ing into the collection cup and contaminating the distillate Screen must bein place for unit to function properly O perating Distiller with no screen or with a damaged screen will degrade effectiveness of Distiller and quality of distillate Cleaning C ollector Storage C ontainer Rinse thoroughly with purified water W ipe outside of collector storage container with clean soft cloth or sponge O perational maintenance is essential for this product to perform as advertised Wat erwise 1600 Steam Distiller Purifier Use amp Care Guide AN A HEAT SOURCE OPTIONS NOTE Altitude and ambient conditions may affect performance of Distiller on all energy sources R ead all instructions before use U se this Distiller only as intended and as described in thisUse amp Care Guide Energy Considerations In the U S the average cost per gallon to operate this D istiller is approxi mately 0 32 per gallon for electric burners and 0 10 per gallon for gas burners Cost will vary with local energy pricing and depending on the efficiency of your burner or hot plate Electric
13. s Do not touch during operation or while cooling See Use amp Care Guide for complete instructions SAVE THESE INSTRUCTIONS Waterwise 1600 Steam Distiller Purifier Use amp Care Guide PREPARING FOR FIRST TIME USE Cleaning C ollector Storage C ontainer Sanitize collector storage container by adding 6 ounces 180 ml of 3 per cent hydrogen peroxide and filling with hot water Seal collector storage container with both collection and dispensing plugs Shake vigorously Let stand twenty minutes and drain Rinse thoroughly with purified water W ipe outside of collector storage container with a clean soft cloth or sponge Cleaning Water Coolant Tray Assembly Rinse tray assembly thoroughly with warm water W ipe trays with a clean soft cloth or sponge to dry Cleaning Boiler Assembly Rinse thoroughly with warm water and dry carefully IMPORTANT Use special care NOT to bend or damage collection cup assembly or floating stainless steel screen T he collection cup assembly must remain level so distillate can flow into the collector storage container T he screen floats on the water in the boiling chamber preventing boiling water from splashing into the collection cup and contaminating the distillate O perating Distiller with no screen or with a damaged screen will degrade effectiveness of Distiller and quality of distillate Fi B Water Coolant Jure
14. s for a particular use or purpose T his warranty gives you specific legal rights and you may also have other rights which vary from state to state or province to province Outside the U nited States a different warranty may apply For details please contact your authorized W aterwise distributor Seen WISE 3608 Parkway Blvd Leesburg Florida 34748 9399 352 787 5008 Fax 352 787 8123 www waterwise com E mail service waterwise com 2001 Waterwise Inc Printed in USA Form 16801 Rev 07 06
15. uide 9 HELPFUL TIPS e Discard the first two cycles of water as they may contain some harmless matter from manufacturing and or packaging DO NOT usecollector storage container to store liquids other than puri fied water Liquids other than purified water may transfer a taste or odor If you have other tasks to perform while operating Distiller take the timer with you so that the alarm at the end of the cycle can be detected The boiler like other cookware should never be allowed to boil dry All cooking safety rules apply to this product and should be observed Close supervision is necessary when this or any appliance is used near children U sually the water coolant trays will have enough water to last a complete cycle In some cases depending on heat source the lower water coolant tray s may run out of water before the end of the cycle If that happens refill tray s as needed W hen using an electric stovetop with a shiny reflector under the burner there isa large loss of energy from the burner if the reflector is soiled or dull K eep these reflectors shiny or replace them to save energy and to get a higher burner output Periodically place the boiler on a flat surface and pour a little water into the collection cup at a slow rate to simulate distillate flow W ater should drain downhill out of the collection cup and to the outside of the boiler without overflowing cup If it doesn t the collection cup assembly has been ina
16. y in place fig F Securely attach collection tube to boiler using flexible connector Collection tube must run at a downward slope into collector storage container DO NOT place container directly on any heat source or on any surface easily damaged by heat or hot water If you have other tasks to perform while using the D istiller use the Digital Timer in cluded to alert you when cycle is com plete Timer counts up and down W hen you activate heat source at beginning of the first distilla tion cycle set the timer to count up to when the collector storage container is full about 72 min utes using a 2600 watt electric stovetop burner or 8900 Btu hr gas burner Use this time to deter mine correct starting Rubber Grommet time setting timer to Fill Spout and Maximum Fill Level Screen Flexible Tube Waterwise 1600 Steam Distiller Purifier Use amp Care Guide 5 Figure D 11 12 13 14 count down Distiller will produce distillate for a short time after heat source is turned off so recommended timer setting is about five min utes less than actual cycle time See D igital Timer O perating Instruc tions packaged with timer for details Activate heat source Close supervision is necessary when this or any appliance is used near children BOILING WATER CAN CAUSE SEVERE BURNS DO NOT touch hot surfaces Use potholder or insulated oven mitt when handling hot components WAR
Download Pdf Manuals
Related Search