CARE & USE/INSTALLATION
Contents
1. SE TUBING 24 Cull PROFESSIONAL SERIES 17016 WOK GRATE LPS Ya NOT SHOWN AGF SI ACCESORY SIDE BURNERS El OF CSS _ r Kik bese 31215 LSB2PC 1 GRATE K SA See E LSB2PC 1 LPB E WZ eo 32434 LPB MAIN GRATE m 32231 BRASS CAP W ALUM 32435 LPB CENTER RING GRATE NLY AN EA See BURNER BODY ONLY 70040 MAIN POWER HARNESS 33051 14014 ce FR KIT CAP NG ALL ACCESSORY BURNERS IGNITER Ses BRACKET 4 AN se a Sue ee a oo LPB E Se ORIFICE 5 185 P ee RIFICE ONLY LP 115 32582 VENTURI IGNITER chee Nk SE aks Be eae TOP PAN AND MAIN BODY e ASS Y NOT FIELD REPLACABLE D 4 R 4 11 32587 NG S N G BO 30781 R Ken T ELBOW 1 2 LP IFICE 35 onLy 30738 L P ORIFICE 57 32587 LP ORIFICE 50 g 3 E 1 14001 ADAPTER 1 8 FTP X 3 8 14024 LSB1 LSB LSB2PC 1 ONLY N NUT ETE 33340 BURNER VALVE Sieun N C 33339 LFP B ONLY IGNITION WIRE HARNESS ASS UTER2. you will find one located either on the underside of the drip tray if you have one on the heat shield behind the front panel or on the inside left panel wall LYNX PROFESSIONAI Ch AL GRILLS Bes MERCE CALI N ET For warranty service contact the Lynx Customer Care Department for an authorized service agent near you at 888 289 5969 www lynxgrills com 22800 R2 LYN Accessory Manual 33487 FINAL indd 13 Your satisfaction is of the utmost importance to us If a problem cannot be resolved to your satisfaction please write fax or email us Lynx Professional Grills 7300 Flores Street Downey CA 90242 Lynx Customer Care 888 289 5969 Tel 562 299 6900 Fax 562 299 6978 www lynxgrills com Contact Lynx for replacement parts Parts are shipped F O B Downey CA SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 13 3 17 2014 12 54 51 PM BEFORE YOU START A WARNING e Never install this product into a combustible enclosure Doing so could result in fire property damage and per sonal injury e Never locate the accessory under a roof or overhang in a building garage shed or other such enclosed area e Always maintain the required clearances from combustibles as detailed Accessories are designed for outdoor use only Never use in a garage building shed breezeway or other enclosed area Do not use this equipment under any overhead combustible construction e Installation must conform
3. CABINET LCB1 LCB2 ONLY SCREW OT FIELD REPLACABLE 33158 BURNER PART MODEL 170060 LSBIZLCBI 70061 CSB2 LCB2 bi 70059 LSBePC 1 70058 LPB gt gt U N DAAA 80281 MANIFOLD COMPLETE ASSY lt LSB1 80238 MANIFOLD COMPLETE ASSY LSB2 LCB2 80240 MANIFOLD COMPLETE ASSY L SB2PC 1 10001 BEZEI 80328 MANIFOLD COMPLETE ASSY LP LPB 31929 SCREW 8032 7 MANIF COMPLETE ASSY NG LPB BULLNOSE ASS Y Cd Q PARTH MODE 31773 BURNER KNOB METAD Z CS SOU Seles 31372 MANIFOLD PIPE Y LSBL 30155 MANIFOLD PIPE ONLY LSB2 LCB2 i 31289 MANIF LD PIPE Y EI Speer 7O075 MOUNTING BRACKET lt LCB2 gt 32432 MANIFOLD PIPE ONLY LPB 30 42 94 ONLY 70076 MOUNTING BRACKET LCB2 27 367 ONLY MODEL SPECIFIC BTU OUTPUTS MODEL INNER BURNER OUTER BUR
4. and workmanship when subjected to normal domestic use and service for a period of two 2 years from the original date of purchase This warranty is limited to the replacement of the defective parts with the owner paying all other costs including labor shipping and handling IV LIMITED ONE YEAR WARRANTY For a period of one 1 year from the original date of purchase Lynx will replace or repair parts found to be defective at no cost to the original purchaser This includes the cost of shipping replacement parts and where necessary service labor at prevailing local rates by a Lynx authorized service person Service will be provided during normal business hours and must be authorized in advance by Lynx IV LIMITATIONS amp EXCLUSIONS 1 This Warranty shall apply to products purchased and located in the United States and Canada Products must be purchased in the country where service is requested 2 Warranty applies only to the original purchaser and may not be transferred 3 Warranty is in lieu of all other warranties expressed or implied and all other obligations or liabilities related to the sale or use of its grill products 4 Warranty shall not apply and Lynx is not responsible for damage resulting from misuse abuse alteration of or tampering with the appliance accident hostile environment flare up fires improper installation or installation not in accordance with the instructions contained in this manual or the l
5. appliance and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressures in excess of 0 5 psi 3 5 kPa 2 The outdoor cooking gas appliance must be isolated from the gas supply piping system by closing its indi vidual manual shutoff valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 1 2 psi 3 5 kPa A STATE OF MASSACHUSETTS 1 Massachusetts requires all gas be installed using a plumber or gas fitter carrying the appropriate Massachu setts license 2 All permanently installed natural gas or propane installations require a T handle type manual gas valve be installed in the gas supply line to this appliance 3 This does not apply to portable propane installations using a 20 pound cylinder A WARNING ELECTRICAL GROUNDING e Product installation must meet local electric codes or in the absence of local codes the latest edition of the National Electrical Code ANSI NFPA No 70 or the Canadian Electrical Code CGA 1 662005 e Use only a Ground Fault Interrupter GFI protected circuit with this outdoor cooking gas appliance e This accessory is equipped with a three prong grounding electric plug for your protection against shock hazard and must be plugged directly into a properly grounded three prong outlet Never cut or remove the grounding prong from this plug e Use only extension
6. cords with a 3 prong grounding plug rated for the power of the equipment and approved for outdoor use with a WAT marking e To protect against electric shock do not immerse any part of the power cord an extension cord or any plugs in water or other liquid e Unplug the product from the outlet when not in use and before cleaning Allow it to cool before putting on or taking off parts e Do not let the cord hang over the edge of a table or touch hot surfaces e Do not operate any outdoor cooking gas appliance with a damaged cord plug or after the appliance malfunc tions or has been damaged in any manner Contact the manufacturer for repair 6 SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 22800 R2 LYN Accessory Manual 33487 FINAL indd 6 3 17 2014 12 54 41 PM IMPORTANT SAFETY PRECAUTIONS PLEASE REVIEW THESE IMPORTANT SAFETY PRECAUTIONS BEFORE YOU USE YOUR GRILL ACCESSORY 1 NEVER LEAVE THE GRILL ACCESSORY UNATTENDED 10 Never use charcoal or any other solid fuel in the grill WHILE COOKING accessory Ensure all tie down wires have been removed from the 11 Cooking excessively fatty meats and oils will cause flare burners ups Internal fires or damage caused by them or by the grill accessory being left unattended while cooking Always use caution when operating the grill accessory are not covered under the terms and conditions of our in a windy area See INDEX Grilling in Windy Condi warranty tions for furth
7. explode 17 If any burner does not light or goes out during opera Do not use aluminum foil to line grill accessory racks or drip pans This will alter the airflow or trap exces sive heat in the control area and can melt knobs and ignition modules Such damage is specifically excluded from your warranty 22800 R2 LYN Accessory Manual 33487 FINAL indd 7 SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 7 tion turn off all gas control knobs and wait five 5 minutes before attempting to re light 3 17 2014 12 54 41 PM TABLE OF CONTENTS A MESSAGE TO OUR CUSTOMERS 5 IMPORTANT SAFETY PRECAUTIONS 7 USING YOUR LYNX ACCESSORY 9 Accessories Covered in this Manual 9 USING THE LYNX POWER BURNER LPB 10 Smell of Gas While Cooking 10 Yellow Flames 10 LIGHTING INSTRUCTIONS FOR ALL ACCESSORIES 11 Safety Practices and Precautions 11 At Each New Season 11 Purging the Gas Lines 11 Match Lighting 11 Low Heat Flame Adjustment iz CONTACTING LYNX CUSTOMER CARE 13 BEFORE YOU START 14 If Shipment Arrives Damaged 14 Visible Loss or Damage 14 Concealed Loss or Damage 14 Important Notes 14 Where s the Wind 14 How Long is Your Run 14 Are You On the Level 14 Built in Installations 15 Clearance to Combustible Materials 15 GAS amp ELECTRIC CONNECTIONS 16 Gas Plumbing 16 Natural Gas 16 LP Gas 17 LP Conne
8. light inside the burner instead of outside Once lit if you hear a whooshing sound immediately turn the burner knob off to extinguish the flame and then immediately re light the burner 18 SIDE BURNER ACCESSORY CARE 8 USE INSTALLATION 22800 R2 LYN Accessory Manual 33487 FINAL indd 18 continued NATURAL GAS HOOK UP Natural Gas NG Qutlet Shuf Cff I Valve 1 27 Min Inter Connecting Pipe Work Regulator REAR VIEW 1 2 Clase Nipple 1 2 Union Coupler 1 2 Male Female Street Elbow 1 2 MIP Fitting 4 12 Close Nipple d 12 Tee k E 12 OD Stainless Stace Flexible Ha 1 2 FIP Fitting Side Burner or rll Extender MAXIMUM RUNS FOR ALL APPLIANCES ON SUPPLY LINE Run Length Max BTU for all 3 4 Pipe in feet Appliances on line 10 360 000 20 245 000 30 198 000 40 169 000 50 150 000 60 135 000 70 123 000 80 115 000 3 17 2014 12 54 53 PM ELECTRICAL CONNECTIONS OPTIONAL ELECTRICAL KITS Each accessory includes 6 feet of wiring coiled inside the back of the accessory to connect the accessory to a Lynx grill Additionally Lynx manufactures 2 specialized electrical kits that you may purchase for your accessory depending upon how it will be installed Each electrical kit ships with an instructional sheet for assembly Assembly instructions and sche matics drawings can also be found on our website at www lynxgrills com e LAS
9. only to the original location of installa tion and may not be transferred 3 Warranty is in lieu of all other warranties expressed or implied and all other obligations or liabilities related to the sale or use of its grill products 4 Warranty shall not apply and Lynx is not responsible for damage resulting from misuse abuse alteration of or tampering with the appliance accident hostile environ 22800 R2 LYN Accessory Manual 33487 FINAL indd 25 ment flare up fires improper installation or installation not in accordance with the instructions contained in this manual or the local codes 5 Lynx shall not be liable for incidental consequential special or contingent damages resulting from its breach of this written warranty or any implied warranty 6 Some states do not allow limitations on how long an implied warranty lasts or the exclusions of or limitations on consequential damages This warranty gives you specitic legal rights and you may have other rights which vary from state to state 7 No one has the authority to add to or vary Lynx s warranty or to create for Lynx any other obligation or liability in connection with the sale or use of its products 8 Limited to the replacement of defective parts with the owner paying all other costs including labor V What is not covered Lynx shall not be responsible for and shall not pay for the following 1 Installation or start up damages or problems caused by imp
10. pins INPUT CONNECTION LEAD WITH PIN 6 DEAD LEAD NO PIN FROM ACCESSORY Lynx Grill Lynx Side Burner 4pin PLUG 4 pin RECEPTACLE SIDE BURNER ACCESSORY CARE 8 USE INSTALLATION 21 22800 R2 LYN Accessory Manual 33487 FINAL indd 21 3 17 2014 12 54 57 PM SPECIFICATIONS amp INSTALLATION The guides measurements and dimensions detailed below are designated to assist you with planning your outdoor kitchen NOTE Due to continuing product innovation specifications are subject to change without notice IMPORTANT Please reference the Care amp Use Installation manual for details on gas plumbing requirements electrical specifications and the proper installation of your Lynx outdoor kitchen equipment This manual can be downloaded trom the Lynx website at www lynxgrills com GRILLS WITH INSULATED JACKET INSTALLED MODEL A B C MODEL A B C L27 26 00 10 88 22 00 LIJ27 35 00 11 63 24 00 L30 29 00 10 88 24 50 BR 36 00 11 63 26 50 L36 35 00 10 13 22 00 LIJ36 42 00 11 63 24 00 L42 41 00 10 88 24 50 LIJ42 48 00 11 63 26 50 L54 53 00 10 88 24 50 LIJ54 60 00 11 63 26 50 COMPLEMENTARY PRODUCTS ACCESS DOORS STORAGE SYSTEMS MODEL A B MODEL A B C LDR21 1 12723 19 00 LSA30 28 25 19 00 24 50 LDR27 1 25 25 19 00 LSA36 34 25 19 00 24 50 LDR30 1 28 295 19 00 LDR36 2 34 25 19 00 TRASH CENTERS LDR42 1 40 25 19 00 MODEL A B C LDR36T 31 69 19 00 LASTC 16 00 24 00 13 00 LDR42T 37 63 19 00 L2OTR
11. plunger to the side to snap it out of the cap turn the plunger so it reads the desired gas type on the bottom and push the plunger until it snaps back into place in the cap then replace the cap into the regulator NAT Position Pressure Regulator Gasket Plunger Never connect an unregulated gas line to the grill When exchanging your cylinder for a refill exchange only for a Type 1 20lb cylinder with an over fill protection device 22800 R2 LYN Accessory Manual 33487 FINAL indd 17 Never use a cylinder with a damaged valve A dented or rusty LP cylinder may be hazardous and should be avoided If in doubt have it checked by your LP supplier Always check for leaks after every LP cylinder change See INDEX Leak Testing for further details Always shut off the LP gas supply at the cylinder when the accessory is not in use Cylinders must be stored outdoors in a well ventilated area out of the reach of children If your accessory is stored indoors the LP cylinder must be stored outside LP CONNECTIONS Make sure the LP cylinder valve is fully closed It is possible for the valve to be open without releasing gas but as soon as you start connecting the regulator gas will leak from the connection Insert the regulator inlet into the cylinder valve and turn the black coupler clockwise until the coupler is hand tight Do not over tighten this connection To disconnect the coupler first
12. you Be sure to hold on to the container for inspection We cannot assume responsibility for damage or loss incurred in transit See INDEX Obtaining Service from Lynx for further details ARE YOU ON THE LEVEL Proper leveling during installation is critical An accessory that is out of level will cause erratic burner combustion and inefficient uneven heating A carpenter s spirit level should be used to level the accessory both front to back and side to side If the floor is uneven or has a decided slope re leveling may be required each time you move a freestanding unit 14 SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 22800 R2 LYN Accessory Manual 33487 FINAL indd 14 3 17 2014 12 54 51 PM BEFORE YOU START continued BUILT IN INSTALLATIONS Lynx built in accessories are intended for installation in a built in enclosure constructed of non combustible materials The accessory drops into the opening shown in the cutout detail drawing and hangs from its counter top trim A deck is not required to support it from the bottom Pay special attention to the provisions shown for gas line hook up See INDEX Cut out Dimensions for Built in Grills amp Accessories Installation provisions may be made for the Power Burner installation The Power Burner cooking height may be reduced to better accommodate large cooking pots Clearances to combustible material must be maintained as outlined below No combustibl
13. 16 81 24 00 24 75 LTA530 26 25 19 00 20 00 SIDE BURNERS MODEL A B C 3 CLEARANCE LSB1 3 1213 10 63 12 50 LSB2 12 13 10 63 24 50 ESBZPE 24 25 10 63 24 50 LPB 19 00 10 63 22 00 UTILITY DRAWERS MODEL A B C LUDE 12 13 19 25 24 00 LUDXL 17 25 18 57 24 25 LDW19 17 50 19 00 24 50 1 2 NPT LMD 21 75 5 63 23 38 V _ COUNTER TOP NOTCH DETAIL WARMING DRAWERS Only required if island counter top overhangs the face of the island MODEL A B C L30WD 28 50 10 00 20 50 5 L42CC 40 25 19 38 24 50 d 8 COCKTAIL PRO a Depth equals H nulted MODEL A c eme a C550 29 00 10 63 22 19 i 9 16 for Grills amp CS30 L 1 2 for Complementary Products 22 SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 22800 R2 LYN Accessory Manual 33487 FINAL indd 22 3 17 2014 12 54 58 PM SPECIFICATIONS amp INSTALLATION OUTDOOR REFRIGERATORS MODEL A B C D L24REF 24 25 33 00 26 00 32 00 L24BF 24 25 34 50 26 00 34 25 L24DWR 24 25 34 50 26 00 34 25 L15ICE 15 25 34 00 26 00 33 90 Trash Chute L18TS 2 Q or 2 square holes for manifold connection rear or bottom access Drop In gian Cooler LDC18 LA Gwan A 12 min n UJ L g van d Dispenser L16TWL 14 ve 3638 min 118 min for model LUDE 31 2 min for model LUDXL gd A DA 21 2 min for model LDR access door a Cocktail Pro should have an open bottom for plumbing
14. E BURNER ACCESSORY CARE amp USE INSTALLATION 11 22800 R2 LYN Accessory Manual 33487 FINAL indd 11 3 17 2014 12 54 50 PM LIGHTING INSTRUCTIONS FOR ALL ACCESSORIES continued LOW HEAT FLAME ADJUSTMENT The burners on your Lynx accessory feature an adjustable low setting Fluctuations in gas pressure gas conversion and even in the quality of the gas itself may affect burner performance at the LOW setting It could be either too high or too low To adjust the burner for low setting 1 Make sure the grill accessory is cool 2 Remove the grates so that you can see the flame while adjusting the burner 3 Light the burner and set it to LOW all the way coun ter clockwise 4 Pull off the control knob 5 While holding the valve shaft with pliers insert a thin flat blade screwdriver into the shaft and while watching the flame adjust it to a minimum stable setting Use a small screwdriver for low setting burner adjustment 12 SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 22800 R2 LYN Accessory Manual 33487 FINAL indd 12 3 17 2014 12 54 51 PM CONTACTING LYNX CUSTOMER CARE Before calling Lynx Customer Care please make sure you have the following information e Model number e Date of purchase e Proof of purchase by the original owner e Serial number The serial number can be located on the rating plate stick er You may have a sticker on the back page of this manual If not
15. EE Ee 13 Specifications Code K qui F MEN ES gt ancis tsobecinsadavncadseidesncteseinventsnsededeaanese 14 ee SS N sab k seers een t k pa yo en paris sip ian 16 K NT 18 Propane Hook UP aye estati kato st et bk eee eats 18 UO LES FNS cares ceca nee e E i 18 T Technical SUPPO kayo kaban ate eta rc ere pena ik ei eat 13 Testing Leak TO E 20 TAE NS FAN ENG FA f oton pan aa aie rpt REE i 20 W Warranty Beat aa ia at a pikan ke pa n sa it ey l E 24 COMMON Area Limited e wouj ane dw om tras at vl 25 SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 27 3 17 2014 12 54 59 PM PN 33487 Rev C 01 14 22800 R2 LYN Accessory Manual 33487 FINAL indd 28 Lynx Professional Grills 7300 Flores Street Downey CA 90242 Service 888 Buy Lynx 888 289 5969 Fax 562 299 6978 www lynxgrills com PROFESSIONAL GRILLS 3 17 2014 12 54 59 PM
16. INAL indd 4 3 17 2014 12 54 39 PM A MESSAGE TO OUR CUSTOMERS You ve just joined the world of Lynx cooks a discriminating collection of amateur and professional chefs that take outdoor cooking to a new level Lynx manufactures many accessory cooking appliances to compliment your Lynx grill and your desire for truly superior cooking results Your appliance has been designed and built with meticulous attention to detail and it offers some unique and powerful features You can achieve maximum pertormance and enjoyment of these features only by carefully reading this manual before your first cook out This manual includes important safety tips and great hints for better grill ing You should keep it handy for easy reference Also at Lynx we enjoy hearing from our customers We like to hear about your successes but also about any difficulties you are having Please feel free to contact us with any questions or problems or just to share a new recipe Please include the model number of your appliance in your corre spondence With the proper use and care this product will provide years of trouble free service Should your Lynx appliance change ownership please make sure that the new owner receives this manual Thanks again for your purchase Enjoy SIDE BURNER ACCESSORY CARE 8 USE INSTALLATION 5 22800 R2 LYN Accessory Manual 33487 FINAL indd 5 3 17 2014 12 54 40 PM WARNINGS 7 eRe 1 The outdoor cooking gas
17. K Lynx Accessory Switch Kit This switch and transformer kit allows independent control of a Lynx accessory burner without connection to a grill The kit contains a transformer and mounting bracket as well as a switch assembly with a mounting plate The kit also contains a wiring harness to adapt an L series accessory to an M series switch and trans former e LPEK Lynx Power Extension Kit The Lynx Power Extension Kit provides 12 feet of additional wire between your Lynx Grill and accessory burner Installation requires an outdoor 120VAC 15A GFI Ground Fault Interrupter electrical outlet adjacent to the accessory The GFI outlet features an internal breaker that reduces shock hazard This type of outlet should be installed by a qualified electrician either inside the island enclosure for built in units or near the location where a free standing unit will be used For built in accessories the supplied 12V transformer is connected to the accessory during installation If the electrical system fails to operate a connection may have come loose in shipping or the GFI may have tripped requiring a reset See the Troubleshooting section for more details 22800 R2 LYN Accessory Manual 33487 FINAL indd 19 CONNECTING THE WIRING The accessory electrical harnesses are designed to provide power for both ignition and lighting While ignition is con trolled at the accessory lighting is controlled at the grill You can control ligh
18. MAKE THE MOST OF YOUR pit e ME ne mn eg e Hi ef CH e po la AT thea a di Y 7 NA SE H 4 SA UN SS a KON DON 22800 R2 LYN Accessory Manual 33487 FINAL indd 1 3 17 2014 12 54 38 PM WARNINGS A ue READ THIS MANUAL CAREFULLY and completely before using your grill to reduce the risk of Fire Burn hazard personal injury or property damage Ruined steaks or other unpleasant cooking experiences Unapproved installation or servicing SE EE THIS PRODUCT IS DESIGNED FOR OUTDOOR USE ONLY Improper installation adjustment alteration service or maintenance can cause property damage injury or death Read this manual thoroughly before installation use or servicing of this product A once ee IF YOU SMELL GAS S ILY A UNE ODEUR DE GAZ 1 Coupez l admission de gaz de l appariel teindre toute flamme nue 1 Shut off all gas supply lines to the grill accessory 2 Extinguish any open flames 2 i 3 Carefully open the lid Remember it may be 3 Si le couvercle extremely hot 4 a odeur persiste loignez vous de 4 If odor continues keep everyone away from the appareil et appelez loue L n le grill accessory and immediately call your gas fournisseur de gaz ou le service d incendie supplier or your fire department Ali A AVERTISSMENT 1 DO NOT store or use gasoline or other flam 1 Ne pas entreposer ni utiliser de l essence ni mable vapors and liquids in t
19. NER OPEN TOP BURNER TOTAL INPUT LPB 13 000 34 000 47 000 BTU Hr LSB2PC 2 15 000 30 000 BTU Hr LSB1 3 1 15 000 15 000 BTU Hr LSB2 2 2 15 000 30 000 BTU Hr 26 SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 22800 R2 LYN Accessory Manual 33487 FINAL indd 26 3 17 2014 12 54 59 PM INDEX A Adjusting Low Heat Adjustment Power Burner Air Shutter Air Shutter Adjustment C Code Requirements Cold Weather Use sassoc Connections Electrical senrose EE Optional Electrical Kits eent dE KE D Damage SAD EN coneyiaiancsttinettansoapneaten E Electrical Connections Exploded Parts View G Gas Connections Gas Leaks Testing for Gas Pressure EE gege Gas Requirements Gas Supply Line Runs Grilling in Windy Conditions L Leak testing cee eeeeeeeeeeeeeees Lighting the Burner Lighting with a March Locating Serial Number LPG OMMOCTIONS EEN M Manual Dobtng Maximum Supply Line Runs N Natural Gas Hook Up 22800 R2 LYN Accessory Manual 33487 FINAL indd 27 O iere 13 Optional ESC Wal NAS a onet pay panse san bes eko nigueti sa teasojab aje 19 P EFO DANE Hook Ie zona aawen oye asanblaj ay etan conan 18 Purging the Gas Lines ec ecccceeeeeeeeeeetteeeeeeeeeeeeeeeeeees 11 S Se E e EN Serial Number dee E 13 Service
20. and drain access 1 square hole must be located at rear of grill cutout 120V GFI outlet must be located within 6 of the 1 hole Warming Drawer Convenience Center SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 23 22800 R2 LYN Accessory Manual 33487 FINAL indd 23 3 17 2014 12 54 58 PM LYNX LIMITED WARRANTY l LIMITED LIFETIME WARRANTY The stainless steel grill body brass grill burners cooking grates ProSear burner and rotisserie infrared burner are warranted to be free from defects in material and workmanship when subjected to normal domestic use and service for the lifetime of the original purchaser This warranty excludes surface corrosion scratches and discoloration which may occur during normal use This warranty is limited to the replacement of the defective parts with the owner paying all other cost including labor shipping and handling ll LIMITED FIVE YEAR WARRANTY The following grill parts are warranted to be free from defects in material and workmanship when subjected to normal domestic use and service for a period of five 5 years from the original date of purchase warming racks spit rods briquette trays manifolds and gas valves This warranty is limited to the replacement of the defective parts with the owner paying all other costs including labor shipping and handling lll LIMITED TWO YEAR WARRANTY All other grill components are warranted to be free from defects in material
21. ctions 17 Gas Conversion Kits 17 Propane Hook Up 18 Natural Gas Hook Up 18 Maximum Runs for all appliances on supply line 18 Electrical Connections 19 Optional Electrical Kits 19 Connecting the Wiring 19 Testing the Installation 20 Leak Testing 20 Fixing a Gas Leak 20 SCHEMATICS 21 SPECIFICATIONS amp INSTALLATION 22 LYNX LIMITED WARRANTY 24 LYNX COMMON AREA LIMITED WARRANTY 25 SIDE BURNER EXPLODED PARTS VIEW 26 INDEX 27 8 SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 22800 R2 LYN Accessory Manual 33487 FINAL indd 8 3 17 2014 12 54 41 PM USING YOUR LYNX ACCESSORY This manual covers several Lynx accessory appliances and optional accessories for those appliances Except where noted the assembly installation and use of these Lynx accessories is identical ACCESSORIES COVERED IN THIS MANUAL POWER BURNER MODEL LBP The Lynx Power Burner is a dual ring commercial style burner with a range of 3 000 to 47 000 BTU s PREP CENTER MODEL LSB2PC 1 The LSB2PC 1 Prep Center Features two 15 000 BTU burn ers and an integral bamboo cutting board for food prep SIDE BURNER 1 amp 2 MODELS LSB1 3 amp LSB2 2 The LSB1 3 amp LSB2 2 Lynx Side Burner 1 amp 2 features either one or two 15 000 BTU burners for cooking smaller food items The LSB1 3 and LSB2 2 are designed for installation in a non combustible built in enclosure SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 9 22800 R2 LYN Accessory Ma
22. e material shall be used in the construction of a counter top using a recessed application The enclosure should have ventilation holes to prevent gas build up in the event of a leak The deck ledges and counter should be flat and level Refer to ANSI Z21 58 Standard for Outdoor Cooking Gas Appliances Section 1 7 Enclosures For Self Contained LP Gas Supply Systems or local codes for additional information The grill accessory may be powered from either a 120 volt 60 hertz 15 amp GFI certified outlet installed by a qualified electrician OR it may be powered directly from your Lynx Grill transformer power supply When a Lynx grill is not available or if the grill is not located close enough to the grill a Lynx LASK Lynx Accessory Switch Kit is available as an optional purchase 22800 R2 LYN Accessory Manual 33487 FINAL indd 15 CLEARANCE TO COMBUSTIBLE MATERIALS Minimum clearance from the sides and back of the accessory to adjacent combustible construction below the counter top is 12 from the sides and back D gagement minimal entre les parois lat rales et l arri re de l appariel et la construction combustible au dessous du panneau sup rieur de l appareil 30 cm a partir des parois lat rales et 30 cm a partir de l arri re Minimum clearance from sides and back of unit to adjacent combustible construction extending above the counter top is 18 from the sides and back D gagement horizontal minimal entre les parois
23. el drip pan 3 Ensure that the burner is seated correctly on the frame with the brass peg seated inside the positioning hole 4 Re light and check the flame 10 SIDE BURNER ACCESSORY CARE 8 USE INSTALLATION 22800 R2 LYN Accessory Manual 33487 FINAL indd 10 3 17 2014 12 54 49 PM LIGHTING INSTRUCTIONS FOR ALL ACCESSORIES SAFETY PRACTICES AND PRECAUTIONS Sach Read the User Manual Installation Instructions carefully and completely before using your grill or grill accessory to reduce the risk of fire burn hazard or other injury Ensure that burner ties and all packing materials are re moved before lighting any new accessory pon emove all S KAN WEE L kb on d ech ka e zan aaen Be ping Ties AT EACH NEW SEASON At the start of each new grilling season you should remove the cooking grates and check the burners venturis orifices and valves for obstructions Spiders and insects often nest in these areas of the acces sory and can disrupt air flow causing damage to the acces sory and personal injury Also check all hoses and fittings for damage abrasion wear and tear and repair if necessary before turning the gas on Replacement pressure regulators and hose assemblies must be the type specitied by Lynx The pressure regulator and hose assembly supplied with the unit must be used If the unit is LP screw the regulator into the tank and leak check the hose and regulator con
24. er details o 12 Never grill without a drip pan in place if your accessory Avoid Haa loose fitting Came or long sleeves utilizes a built in drip pan Always ensure the drip pan while grilling They could ignite is pushed all the way to the back of the grill accessory Never touch the grill accessory racks or immediate WE Ges page Ge SEN EE surrounding metal surfaces with your bare hands while Ye kn kk es es eee grilling 13 Grease is extremely flammable Let hot grease cool Use an insulated glove or mitt when opening and oper sou ai w AE A e The drip tray should be cleaned of grease on a regular ating the grill accessory basis The grill accessory covers must be fully removed or RE 14 Do not use the grill accessory unless a leak check has opened while lighting the grill accessory Releasing me been performed on all gas connections See INDEX fuel into a closed grill accessory before lighting will not oe a e an WE make it light sooner or more efficiently It will only risk eak Testing ror turther details explosion and personal injury or death Never lean over 15 Never operate the grill accessory while under the influ hot grill accessory surface or look directly into the grill ence of alcohol or drugs accessory when attempting to light 16 Do not lean on side shelves and never place a load Do not heat unopened food containers as pressure weighing more than 25 pounds on a side shelf build up will cause the container to
25. er to heat up 4 Turn the knob to the LITE position 5 After ignition set the knob to the desired setting CHECKLIST BEFORE EACH USE FOR YOUR SAFETY e Do you smell gas If yes shut off everything and call the gas company or a qualified plumber to check for leaks if not please continue e Are you prepared to stay with the side burner during the entire cooking process If not gather what you need be fore starting the lighting process If yes please continue els your cooking area free and clear of any combustibles besides your food that might ignite If no clear the area before starting the lighting process If yes please con tinue e Do all control knobs turn freely If not call for service if yes please continue PART NO 33487 REV C 01 14 22800 R2 LYN Accessory Manual 33487 FINAL indd 3 e f you are using a portable propane cylinder is it connect ed and leak tested If not check the connection before continuing If yes please continue e Do you know where your side burner s main gas supply shut off valve is located If not locate it before continu ing If yes please continue e Are all burners properly seated in the side burner If not seat the burners properly before continuing If yes please continue e Is the wind blowing just lightly and not blowing on the side burner If not wait until the wind subsides or turn your free standing grill so the wind goes into the front of the grill I
26. f yes please continue with the lighting process SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 3 3 17 2014 12 54 39 PM WARNINGS 7 eRe e Never use dented rusty or damaged propane cylinders Never store additional or empty propane cylinders in the cabinet or in the vicinity of this or any other appliance Do not store propane cylinders indoors or on their sides e Children should never be left alone or unattended in an area where an accessory is located Place your accessory well away from areas where children play Do not store items that may interest children in or around the area of your accessory in your accessory cart or in the masonry enclosure e Never move the accessory when hot When in use portions of the accessory are hot enough to cause severe burns e Always maintain the required clearances from combustibles as detailed Accessories are designed for out door use only Never use in a garage building shed breezeway or other enclosed area Do not use this equipment under any overhead combustible construction e Grill accessories are not designed or certified for and are not to be installed in or on recreational vehicles portable trailers boats or any other moving installation e Always have an ABC Fire Extinguisher accessible never attempt to extinguish a grease fire with water or other liquids e Storing your accessory Store your accessory in a well ventilated area If stored indoors detach and lea
27. he vicinity of this d autres vapeurs ou liquides inflammables dans le or any other appliance voisinage de l appareil ni de tout autre appareil 2 An LP cylinder not connected for use shall 2 Une bouteille de propane qui n est pas raccord e not be stored in the vicinity of this or any en vue de son utilisation ne doit pas tre en other appliance trepos e dans le voisinage de cet appareil ou de tout autre appareil A WARNING CALIFORNIA PROPOSITION 65 1 The burning of gas cooking fuel generates some by products which are on the list of substances which are known by the State of California to cause cancer or reproductive harm 2 California law requires businesses to warn customers of potential exposure to such substances To minimize exposure to the substances always operate this unit according to the use and care instructions found in this manual Be certain to provide adequate ventilation when cooking 3 California Proposition 65 lists Silica crystalline which is used in one of the components of the IR burner as an agent known to the state of California to cause cancer 2 SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 22800 R2 LYN Accessory Manual 33487 FINAL indd 2 3 17 2014 12 54 39 PM HOW TO LIGHT YOUR GRILL ACCESSORY 1 Before each use complete the checklist below 2 Make sure all burner control knobs are in the OFF position 3 Push and hold the control knob for 2 5 seconds allowing the ignit
28. in Under Full Cam Ce Do onn Water Column Requirements Both the regulator and the manifold orifices have been tuned for the type of gas specified on the rating plate Converting to a different type of gas requires a conversion kit which is included with your side burner accessory and must be installed by a qualified technician All installation and all installation parts must conform to local codes with the National Electrical Code ANSI NFPA 70 1990 and the National Fuel Gas Code ANSI Z223 1 NFPA 54 in the U S and CGA B149 1 2 in Canada Canadian installations must conform to CGA B149 1 2 natural gas propane installation code Canada 16 SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 22800 R2 LYN Accessory Manual 33487 FINAL indd 16 NATURAL GAS Lynx recommends that only qualitied professionals perform the required plumbing on this product The gas supply line must be sized to accommodate the total BTU requirements of all the gas fired equipment that will be connected to that line In no case should pipe less than 3 4 inside diameter or 1 outside diameter be used e Calculate the total BTU output of all equipment and refer to INDEX Gas Supply Line Runs for allowable run distances Failure to meet these minimum requirements may reduce performance of the accessory and any other appliances running on that supply line e Always keep supply line runs as short as possible See INDEX Gas Supp
29. lat rales et l arri re de l appariel et la construction verticale combustible au dessus de l appareil 45 7 cm a partir des parois lat rales et 45 7 cma partir de l arri re Do not use this appliance under overhead combustible surfaces Ne pas utiliser cet appareil sous une surface combustible SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 15 3 17 2014 12 54 51 PM GAS amp ELECTRIC CONNECTIONS GAS PLUMBING A WARNING Never connect a gas line directly to the accessory A pressure regulator must be installed on all gas equipment All local codes require it and Lynx supplies the correct regulator with your accessory Removing or failing to install the pressure regulator can result in fire and serious personal injury and will void the warranty The accessory is factory set to use either propane LP or natural gas NAT It is critical that the gas you use matches that which the accessory was set up for You can verify that by checking the rating plate LYNX EROFESSIO NAL Douz LL ewan e ai L Fis 11 w c Rumen 14 000 Duch _X 16 000 ga OPEN TOP BURNER 15 000 Biu tir MODEL SERIAL EI GAS INPUT c lk 9700388 Pee iaa The rating plate is located on the heat shield behind the front panel Ensure that the gas supplied meets with the minimum pressure requirements Do not operate the accessory on any gas other than that for which the accessory has been set Fuel WC Max Inlet WC M
30. ly line runs e A gas shut off valve must be installed in an easily accessible location by a qualified plumber e Keep any threading compound off of the first two pipe threads to avoid having any small pieces of compound break loose and clog a burner valve or orifice Do not put sealant on any male end of flare fittings Keep last two man threads clean For built in installations it is recommended that any flexible pipe used be kept as short as possible See INDEX Gas Connections for typical permanent hook up 3 17 2014 12 54 52 PM GAS amp ELECTRIC CONNECTIONS continued LP GAS Accessories set up for LP gas come equipped with an LP hose regulator assembly for connection to a standard 20 lb LP cylinder Type 1 All fittings necessary to attach the assembly to the accessory are included LP cylinder with type 1 valve connection Permanently plumbed LP connections such as those in line with a bulk cylinder require a 4 11 regulator Lynx P N 30781 When using the 4 11 regulator you must ensure that it is set for the proper fuel type This is done by removing the regulator cap and gasket and looking at the bottom of the plunger to see what fuel type is visible This is the regulator fuel setting NAT is for natural gas and LP is for propane gas The LP setting can be further identified by the large diameter disk on the bottom of the plunger To change from one gas to the other simply push the
31. make sure the main cylinder valve is turned off Grasp the coupler and turn counter clockwise Always leak test the connection after refilling or exchanging LP cylinders See INDEX Leak Testing for further details GAS CONVERSION KITS Gas conversion kits are available from Lynx Grills to allow the grill to operate on either Natural Gas or LPG These kits should be installed by a qualitied technician These kits come with complete installation instructions These instructions should be read completely and fully understood before installing the conversion kit SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 17 3 17 2014 12 54 52 PM GAS amp ELECTRIC CONNECTIONS PROPANE HOOK UP High pressure flexible hose amp regulator existing on grill LP Gas L 1 2 FIF x VE MIF Flane Elbow or 1 27 FIP or 1 2 FIP 3 8 MIP Flare Fitting Use regulator here for hard plumbed L F hook up lynx PAM 30781 ei L Gi a Fr Fe NO MIIA dOL 1 REAR VIEW E E i r Cose Nipple 1 2 Tee i 1 2 Close Nipple KR 7 Union Coupler BAQ Manifold 5 1 2 Male Female _ Street Elbow 1 2 MIP Fitting 7 1 2 OD Stainless Steel Flexible Hose I Z 1 2 FIP Fitting s AM mi i 1 2 Male Female cr CI Seat Elbow Side Burger or Grill Extender y NAN COLD WEATHER WARNING PROPANE Extremely cold temperatures may cause your burner to
32. nections with a soap and water solution before operating the burner Turn all knobs to OFF then SLOWLY turn on the gas supply valve Do not use any grill accessory if you smell gas PURGING THE GAS LINES You should purge the gas line of air before attempting to light the grill accessory 1 Make sure all grill controls are in the OFF position 2 Slowly turn on the main gas supply 3 Push in the control knob for the burner furthest from the fuel source Using the burner furthest from the fuel source will completely purge the lines It will take sev eral seconds for the burner to light 4 Hold the knob ON for about 20 seconds to allow the air in the system to purge and the burner to light 5 Wait at least 5 minutes after shutting off the control before attempting to light the burners MATCH LIGHTING If a burner fails to light after several attempts it can be match lit If you ve just attempted to light the burner with the igniter allow 5 minutes for any accumulated gas to dis sipate before match lighting Make sure all knobs are in the OFF position Keep your face as far away from the burner as possible Using the manual lighting rod pass a lit match over the ports of the burner The LYNX Power Burner features a lighting rod as shown above Push and turn the control knob of the burner to Lite If the burner does not light in 4 seconds turn the knob off and wait 5 minutes before attempting again SID
33. nual 33487 FINAL indd 9 3 17 2014 12 54 44 PM USING THE LYNX POWER BURNER LPB The Lynx Power Burner incorporates a cast brass dual SMELL OF GAS WHILE COOKING ring burner A WARNING IF YOU SMELL GAS WHILE THE GRILL ACCES SORY IS OPERATING IMMEDIATELY TURN OFF ALL BURNERS AND SHUT OFF THE MAIN FUEL SUPPLY e Perform a leak test See INDEX Leak Testing for further Each ring can be independently operated for maximum heat details control Used together they can generate up to 47 000 BTUS e Check for blockages YELLOW FLAMES A yellow flame on the main burners indicates a lack of air But if the air around the grill is dusty or if heavy grease is present some orange tips on the burner flame are normal e ADJUST THE AIR SHUTTER The knob on the left controls the outer burner ring andthe ONLY DO THIS WHEN THE ACCESSORY HAS COOLED knob on the right controls the inner burner ring DOWN COMPLETELY Make sure all grill controls are in the OFF position The Hot Surface ignition system provides reliable ignition The main grate can easily handle oversized stock pots and i Y Oh jou TO A removing the center grate accommodates a commercial ki n LN eg style round bottom wok base 12 inch minimum 1 Remove the cooking grates 2 Reach under the drip guard and rotate the air shutters to adjust um SEA o Ze NN 3 The Lynx Power Burner also features a fully extendable stain less ste
34. ocal codes 5 Lynx shall not be liable for incidental consequential special or contingent damages resulting from its breach of this written warranty or any implied warranty 6 Some states do not allow limitations on how long an implied warranty lasts or the exclusions of or limitations on consequential damages This warranty gives you specific legal rights and you may have other rights which vary from state to state 24 SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 22800 R2 LYN Accessory Manual 33487 FINAL indd 24 No one has the authority to add to or vary Lynx s warranty or to create for Lynx any other obligation or liability in connection with the sale or use of its products Limited to the replacement of defective parts with the owner paying all other costs including labor WHAT IS NOT COVERED LYNX SHALL NOT BE RESPONSIBLE FOR AND SHALL NOT PAY FOR THE FOLLOWING Installation or start up damages or problems caused by improper installation or use Service by an unauthorized service provider Damage or repair due to service by an unauthorized service provider or use of unauthorized parts Warranty does not apply to products installed in any commercial or non residential application Examples of excluded applications include but are not limited to day care centers schools bed and breakfast centers churches private clubs fire stations club houses common areas in multi family dwellings restaurants hotel
35. re warranted to be free from defects in material and workmanship when subjected to normal use and service for a five year period from the original purchase date This war ranty excludes surface corrosion scratches and discoloration which may occur during regular use This warranty is limited to the replacement of the defective parts with the owner paying all other cost including shipping handling and labor Il Limited One Year Warranty The structural integrity of the interior grill parts exterior and drip pans are warranted to be free from defects in mate rial and workmanship when subjected to normal domestic use and service for a period of one year from the date of purchase This warranty is limited to the replacement of the defective parts with the owner paying all other costs includ ing labor IIl Limited Parts amp Labor Warranty All other grill components are warranted to be free from defects in material and workmanship for a period of 90 days from the original date of purchase Lynx will replace or repair parts found to be defective at no cost to the original purchaser After the 90 day period Lynx will sell parts to the holder of this warranty at Lynx contractor prices for an ad ditional 9 months IV Limitations amp Exclusions 1 This Warranty shall apply to products purchased and located in the United States and Canada Products must be purchased in the country where service is requested 2 Warranty applies
36. roper installation or use 2 Service by an unauthorized service provider 3 Damage or repair due to service by an unauthorized service provider or use of unauthorized parts 4 To correct normal adjustments or settings due to improper installation commissioning or local gas supply properties 5 Shipping and handling costs export duties installation removal or re installation cost 6 Display models are generally sold as is If you have purchased a display model please be advised that it is sold as is and that it is subject to the following warranty exclusions any exterior or cosmetic damage is non warrantable any missing components will be replaced at consumer s expense major handling damage to manifold valve and ignition system will be serviced at consumer s expense all other warranty s standard warranty will remain in effect 7 The cost of a service call to diagnose trouble SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 25 3 17 2014 12 54 58 PM SIDE BURNER EXPLODED PARTS VIEW REMOVABLE COVER PARTH 10044 LSB 10045 SBe LCBe For om mock 31298 LsBaPC L LPB 33177 CUTTING BOARD LSBePC 1 ONLY 31293 2212 LPB 32837 FLEX 17015 SPIDER GRATES 32836 FLE TUBING 97 Ava Aa
37. s nursing homes food service locations and institutional food service locations To correct normal adjustments or settings due to improper installation commissioning or local gas supply properties Shipping and handling costs export duties installation removal or re installation cost Display models are sold as is If you have purchased a display model please be advised that it is sold as is and that it is subject to the following warranty exclusions any exterior or cosmetic damage is nonwarrantable any missing components will be replaced at consumers expense major handling damage to manifold valve and ignition system will be serviced at consumer s expense all other warranty s standard warranty will remain in effect The cost of a service call to diagnose trouble 3 17 2014 12 54 58 PM LYNX COMMON AREA LIMITED WARRANTY The Lynx Limited Warranty covers residential installations only and is non transferable to any other party This non residential warranty applies when the product is installed in common areas where more than a single party has rightful access to its use or in locations considered beyond normal residential use such as B amp B s and private clubs THIS PROVISION EXCLUDES ALL COMMERCIAL APPLICA TIONS INCLUDING BUT NOT LIMITED TO RESTAURANTS AND INSTITUTIONAL FOOD SERVICE LOCATIONS Limited Five Year Warranty The stainless steel body housings the solid brass grill burn ers a
38. ting at the accessory by installing the Lynx Accessory Light Switch LASK Disconnect the 4 pin connector on the grill and connect those plugs to the mating plugs on your accessory See Index Electrical Connections Important note If using multiple Lynx accessories with the Control Illumination Blue LED S a connector for this pur pose is built into the accessory wiring This will allow you to use the light switch on your Lynx grill to actuate the power on more than one accessory SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 19 3 17 2014 12 54 53 PM TESTING THE INSTALLATION Before turning the gas supply on check for proper installa tion using the following test 1 2 Plug the transformer back into the receptacle Push in the gas control knob on your accessory and watch the igniter It should glow bright and steady Turn on the light switch on the grill Both the grill and the grill accessory lights should operate together This indicates a proper assembly Turn the gas on to all appliances Perform a leak test if you have not done so since plumbing the unit Check all burners for proper ignition Refer to the Light ing Instructions for Side Burners LEAK TESTING y eee To prevent fire or explosion hazard DO NOT smoke or allow any potential source of ignition sparks electrical arcing etc in the area while performing a leak test Leak tests should be conducted outdoors only Never cond
39. uct a leak test using fire or flame Leak Test Procedure 1 Create a soapy solution of 1 part soap and 3 parts water Confirm that all control knobs are in the off position Turn on the fuel supply For natural gas turn the valve handle 1 4 turn to align with the gas flow For LP turn the cylinder valve knob counter clockwise one full rotation Apply the soap solution generously by paint brush or squirt bottle on all connections and fittings If bubbles appear to grow on any of the connections you have a gas leak IMMEDIATELY turn off the gas supply 20 SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 22800 R2 LYN Accessory Manual 33487 FINAL indd 20 FIXING A GAS LEAK 1 2 Shut off the gas supply Turn all grill controls to the ON position to purge the grill of any gas build up then turn the controls back OFF Wash off the soapy solution with cold water and dry Tighten the loose joint or replace the faulty part with manufacturer recommended replacement parts DO NOT attempt to repair the LP cylinder valve if it is damaged The only way to safely resolve a damaged cylinder is to REPLACE IT Repeat the leak test to ensure that no leaks are present 3 17 2014 12 54 53 PM SCHEMATICS Igniter WHITE LED LED a Igniter TO OP TO TRANSFORMER 1 e AT GRILL Molex Male Grean a n Female Pins i C an a MF a aa EE ma Molex Female wv TOGRILL l Male
40. ve LP cylinder outdoors in a well ventilated area away from heat and away from where children may tamper with it e Keep any electrical supply cord and the fuel supply hose away from any heated surfaces Electrical cords should be placed away from walkways to avoid tripping hazard e Do not repair or replace any part of the accessory unless specifically recommended in this manual Other service should be performed by a qualified technician e f the accessory is installed by a professional installer or technician be sure that he she shows you where your gas supply shut off is located All gas lines must have a shut off that is readily and easily accessible If you smell gas check for gas leaks immediately Check only with a soap and water solution See INDEX Leak Testing for further details Never check for gas leaks with an open flame e Inspect the LP gas supply hose prior to each use of the accessory If there is evidence of excessive abrasion or wear or the hose is cut it must be replaced before using the accessory e Never remove the grounding prong from the plug or use this product with an ungrounded 2 prong adapter THIS MANUAL MUST REMAIN WITH THE PRODUCT OWNER FOR FUTURE REFERENCE 1 6 latest edition and has been tested and approved by tertek Lynx Professional Grills 7300 Flores Street GID Downey CA 90242 888 289 5969 A SIDE BURNER ACCESSORY CARE amp USE INSTALLATION 22800 R2 LYN Accessory Manual 33487 F
41. with local codes or in the absence of local codes with either the National Fuel Gas Code ANSI Z223 1 NFPA 54 or Natural Gas and propane Installation Code CSA B149 1 or Propane Storage and Handling Code B149 2 in Canada IF SHIPMENT ARRIVES DAMAGED VISIBLE LOSS OR DAMAGE Be certain any visible damage to the carton is noted on freight bill or express receipt and signed by the person making delivery FILE CLAIM FOR DAMAGES IMMEDIATELY regardless of extent of damage IMPORTANT NOTES WHERE S THE WIND When selecting a suitable location consider important fac tors such as exposure to the wind and foot traffic patterns If you have a freestanding grill position it so the prevailing wind blows into the front control panel at your back when grilling supporting the proper front to rear airflow Built in accessories located in areas with prevailing winds should be protected by a wind barrier HOW LONG IS YOUR RUN Keep all gas supply lines as short as possible because gas lines lose pressure over distance and with each elbow and tee that is added This drop in pressure affects accessory performance See INDEX Gas Supply Line Runs for further details CONCEALED LOSS OR DAMAGE If damage is unnoticed until the accessory is unpacked no tify the transportation company or carrier immediately and file a concealed damage claim with them This should be done within 15 days of the date delivery is made to
Download Pdf Manuals
Related Search