lil` Boss & lil`Boss Deluxe
Contents
1. Coconut Carbon Block Filter Materials of Construction Carbon NSF listed 61 Coconut Shell PAC End Caps Polypropylene Inner Outer Wraps Polypropylene Nettings Polypropylene Gaskets NBR Temperature Ring 40 F to 180 F Filter Housings Housing Polypropylene Cap Reinforced Polypropylene O Ring Buna N Maximum Pressure 80psi PERCENT EFFICIENCY PARTICLE SIZE MICRONS OD X Length 2 3 4 X 9 3 4 Nominal UM Rating 10 Initial AP psi flow rate gpm 1 PSI 30 GPM Chlorine Taste Odor Reduction Capacity Flow gt 8 000 gallons 1 GPM GrowoniX Reverse Osmosis System Warranty For a period of one year from the date of original purchase we will replace or repair any part of the GrowoniX reverse osmosis water system that we find to be defective in operation due to faulty materials or workmanship with the exception of the replaceable filters and membranes GENERAL CONDITIONS Damage to any part of this reverse osmosis system because of misuse misapplication negligence alteration accident installation or operation contrary to our instructions incompatibility with accessories not installed by GrowoniX or damage caused by freezing flood fire or Act of God is not covered by this warranty In all such cases regular charges will apply This limited warranty does not include service to diagnose a claimed malfunction in this unit This warranty is void if the claimer is not the original purchaser of t2. RING COLLET TUBING INSERT TUBE INTO FITTING Push the tubing through the collet and dual o rings until it bottoms out against the tube stop The collet holds the tube in place and the dual o rings provide a leak resistant seal TEST AND INSPECT Push and pull the tubing toward and away from the fitting to ensure that it has been installed properly Test and inspect the installation for any leaks TUBE REMOVAL Relieve pressure from the tubing and fitting Push uniformly around the collet flange against the fitting body while pulling the tubing away from the fitting to release it PUSH COLLET IN PULL TUBE OUT Lil BOSS Lil BOSS Deluxe Component Diagram FEATURES SCRUB OUT 99 OF CHLORINE p p SCRUB OUT 9090 OF SEDIMENT FILTER CAPACITY OF 16 000 GALLONS 3 GALLONS PER MINUTE FLOW RATE 5 MICRON SEDIMENT FILTER p p GX Roller Chassis Input Pressure Gauge Output Pressure Gauge Sediment filter Carbon filter Supply water in Garden Hose Adapter Product water out Filter wrench 9 Garden hose adapter 10 Brass Garden Hose Coupler 11 5 length of 3 8 tubing ONAN BRWHN ECO COCONUT CARBON FILTER EZ HOOKUP KIT WALL MOUNTABLE BRASS GARDEN HOSE CONNECTION INCLUDED Setup Instructions Important Tips e The Lil BOSS Lil BOSS Deluxe de chlorinator is designed to be used between 40 80 psi of incoming water pressure e Do not exceed 80 psi of incoming water pressure If inc
3. UROWONIX TUNED FOR GROWING l LIL BOSS amp LIL BOSS DELUXE DE CHLORINATOR USER MANUAL GROWONIX _ GROWONIX nl GROWONIX WWW GROWONIX COM Our Mission Durability Reliability Efficiency Purity and Conservation form the foundation on which we design and build all of our products Consistent and superior quality sets us apart from other manufacturers and increases our value to you our customer Whether you are a hydroponics hobbyist serious enthusiast or large scale gardener Growonix is committed to bringing you the best solution for water purification systems Why use a GX Scrubber Chlorine Chloramine and Chloride are but a few of the chemicals added to municipal water sources to kill harmful bacteria in our drinking water This chlorine in low doses may not harm humans but will kill beneficial bacteria and micro organisms essential for healthy plant growth Our Lil BOSS Lil BOSS Deluxe de chlorinator will eliminate 95 of the chlorine in the water and 90 of the sediment Chloramine a mix of chlorine and ammonia used as a disinfectant is being applied more and more to local water supplies because of it inability to evaporate when left in the air Chloramine will not evapo rate To eliminate chloramine a special KDF filter is required for the Lil BOSS Lil BOSS Deluxe which Growonix or your local dealer can supply Ask for the GrowoniX KDF filter The GX Scrubber will not lower your parts per million or p
4. he unit or if the unit is not operated under normal municipal water or well water conditions GrowoniX assumes no liability in connection with this reverse osmosis system GrowoniX assumes no liability for any damages incurred through the use of this product It is the responsibility of the end user to gauge the safe use of this product in the environ ment where it is applied We do not authorize any person or representative to assume for us any other obligations on the sale of this reverse osmosis system The information given out in the manual we believe to be true but are offered to you in good faith without guarantee because each application of this product is different and beyond our control THE FOLLOWING STANDARD OPERATING CONDITIONS FOR RESIDENTIAL COMMERCIAL REVERSE OSMOSIS SYSTEMS MUST BE MET FOR WARRANTY TO BE VALID po Water Pressure pH Range Maximum TDs Standard System 40 80 psi 2000 ppm 40 100 F GrowoniX Return Policy Merchandise Return Details and Procedure If any merchandise was defective we will refund the full purchase price upon receiving and reviewing the merchandise returned in undamaged condition RMA Number You must first obtain a Return Merchandise Authorization RMA number from www GrowoniX com Any products sent to GrowoniX without an RMA number will not receive a refund and may be returned to the sender at their expense All refund amounts will be based on the manufacturer s warranty and Growonix ret
5. oming water pressure is too high in stall pressure regulator before unit Pressure regulators are available at www GrowoniX com e Always turn incoming water pressure on slowly allowing all air to be discharged before full water pressure is restored Connect the 3 8 tubing to the quick con Garden Hose Swivel connector on inlet nect fitting on the outlet side of your side of the Slim SCRUB Slim SCRUB Turn water on slowly Replacing Sediment and Carbon Pre Filters Important Tips e Pre filters should be changed when either brown discoloration occurs or system flow rates have significantly declined e Always turn incoming water pressure off before servicing the unit e Always turn incoming water pressure on slowly allowing all air to be discharged before full water pressure is restored Unscrew sediment and carbon filter hous Install new sediment and carbon filter ings using supplied filter wrench Wash making sure they go into the correct filter inside of filter housings to remove debris housings Tighten filter housings by hand do not use filter wrench Do not over tighten Specifications Charts Pleated Sediment Filter 2 5 Diameter Materials of Construction Filter Media End Caps Core Temperature Rating Non woven Polyester Vinyl Plastisol Polypropylene 40 F to 125 F 4 4 C to 51 7 C Size Description 2 5 X 9 7 8 Initial AP psi flow rate gpm 1 psi 10 gpm 01 bar B 38 L min Eco
6. pm Only a Reverse Osmosis membrane can eliminate those particles GrowoniX sells a complete line of Reverse Osmosis water filters from 100 gallons per day all the way up to 2000 gallons per day You can see our complete product line at www growonix com Flow rates and filter replacement The GX Scrubber can filter up to 8000 gallons of water before changing filters based on 2 gallons per minute with 1ppm of chlorine You may need to replace your filter more frequently if your water is heavily contaminated Precautions e Do not use unit with inlet water pressure exceeding 80 psi If inlet water pressure is too high install water pressure regulator before the unit Regulators and pressure limiters are available at www Growonix com or your local plumbing supply e Keep unit away from direct light Direct light can cause algae and other biologicals to grow inside of the filter housings e Donot install unit near electrical outlets or electrical devices Do not install in places where a leak can cause damage pas Grow gt GROWONI X Information on quick connect fittings Growonix RO water filters use quick connect fittings that allow for easy maintenance MAKE A CLEAN TUBE CUT Cut the tube squarely and if using plastic tubing ensure that the cut has not made the tube out of round Also ensure that the tube has a smooth outside diameter without any burrs or score marks prior to inserting it into the fitting O
7. urn policy Refunds will be issued back using the payment method you used when you placed your order Refunds take up to 3 5 business days to process once we receive the return Packaging Please kindly re pack the product in its original box or a box of equivalent strength The unit should be packed in the same manner as it came to prevent damage in shipping Please return everything that was in the original box including any free items if appli cable Be sure to drain out all water from wet systems and parts and wrap them in plastic bags before packing Return To We will provide you with an GrowoniX warehouse address for return merchandise when we issue the RMA number GROWONIX TUNED FOR GROWING To order visit us online at www growonix com or call directly 1 888 406 2521 Tech Support amp Contact supportegrowonix com
Download Pdf Manuals
Related Search