User Manual
Contents
1. e Features A strong disinfecting amp deodorizing power NaoClean generates one of the three most powerful disinfecting waters where high oxidation potential causing radicals are created by electrolysis This disin fecting water can fully sterilize bacteria and deodorize in a shorter time at lower concentrations than traditional chemical disinfectants Safe for human NaOClean guarantees both the safety of users and a health risk free user experience NaOClean is safer on your skin than other chemical disinfectants It leaves almost no residual chlorine thanks to a quick dissolution of active chlorine Zero pollution Discharging untreated electrolyzed disinfecting water directly into the sewage system will not damage the environment or the system Nor is it a violation of any sewerage acts NaOClean generates safe and clean electrolyzed disinfect ing water without producing a toxic smells and ensures good working condi tions Cost effective The cost of using NaoClean is significantly lower than conventional disinfectants The cost of producing electrolyzed disinfecting water is also very low Since NaOClean can effectively kill a wide variety of bacteria it can replace expensive chemicals Workers may enjoy shorter working hours and procedures by using the machine www naoclean com PAGE 6 1 About product Components Specification amp Features Operation procedure e Operation procedure 01 02 03 042. If water supply is low due to low pressure the concentration of the solution may be high So supply appropriate amount of water www naoclean com PAGE 1 2 2 Using the machine App ns Installation e Pipe connection method 1 Remove the faucet 2 Connect the appropriate 3 Turn the faucet to close Close the water pipe water pipe connector before this m PT connector bushing e Note of caution when installing During winter open the drain cork to drain water and seek winter sowing prevention methods such as keeping the device warm If not being used remove the valve connector and completely remove water 2 Using the machine Applications Installation 4 Connect the hose with the water pipe connection nipple and the pressure reducing valve at the back Power plug Flow control valve Water input port Valve connector PE hose 1 4 Hose standard PE hose 1 4 Pipe bushing Water Purifier Fittings 1 4 Pipe P T connector Faucet adapter Valve 1 2 5 Once the work is complete open the water pipe and the valve Fuse Faucet adapter Signal connedtor Water output port Drainage hole pace 13 Piping materials PE hose 2M www naoclean com pace 14 2 Using the machine Applications Installation e Installation for example Fs OO Kitchen N ES Install the Na
3. Press the Power ON OFF Press the Disinfectant ON If you want to set the timer After using the disinfectant you switch The power lamp will OFF switch Then water will select the Time switch and have to press Cleaning switch turn on and be in standby be supplied and normal disin choose the time 10min 20min to clean inside the machine It mode fectant will be produced after or continuous will stop automatically after 2 20 seconds minutes X When it is not used for a long time fill the Saline tank with tap water and operate the device few times to rinse off the saline solution inside the device pump pace 7 2 Using the machine Applications Installation Disinfection for fruits amp vegetables e Fish e Fruits grape strawberry cherry apricot plum apple and etc Use Raw fish First rinse them with clean water and soak in Use disinfectant for 5minutes After that rinse them again with Wash the fruits thoroughly first fresh water Soak them in NaOClean water for about 2 to 3 min Storage amp Cooking later First rinse them with clean water and soak Take them out and rinse once with clean water in the disinfectant for about 5 to 10 minutes After that rinse again with water thoroughly and store them in the refrigerator Disinfect any fruits that you will eat with the skin on And even You just wash them again before cooking with the fruits that normall
4. Troubleshooting Electrode replacement amp Block diagram e Troubleshooting Do not touch voluntarily turn handles modify or repair the parts inside the device xeyavelhdkeyal Power lamp does not turn on Water and saline solution are normally supplied but the number of the power meter does not increase and display error Abnormally low available chlorine concentration Leaking water Micro electric shocks Xx In case of abnormal operation unplug the device and turn on the power again Cause Power cord is unplugged from the socket Burnt out fuse Abnormal SMPS power due to certain reasons or PCB circuit problem Refer to the electrodes replacement cycle Short circuit or piping problem Device is not grounded properly Action Check the cord and the fuse Request a repair by contacting the seller Request a repair by contacting the seller Request a repair by contacting the seller Ground the device X In case of water leak close the water supply valve push the drain button to discharge water and contact the A S center 4 Inspection gt Cat e Electrodes replacement cycle 1 When the consumption of saline solution is significantly increasing abnormally 2 If numbers on the front display panel inside the ma chine decreases during its normal operating process and Er error message keeps showing up 3 Significant decrease in the disinfectant smell X The lif
5. accordance with the description on the quality warranty 82 1577 7544 A S A Quality Warranty gt shall be serviced free of charge as far as manufacturing defect is concerned e How to request for service If you find any abnormality or have a question while using this product please contact a nearby distributor or our head office In order to request for services you need to present this quality warranty duly filled out Therefore please keep it carefully In case you get charged services please make sure to keep the receipt carefully e Consumer damages compensation Free services For any failure related to the function and performance of the product that takes place in the course of normal operation within the warranty period Charged services 1 When the warranty period has expired 2 During the warranty period if failure was caused by Careless handling of the product Unauthorized repair or alteration of the product Damage during transportation due to mishandling Connection to a wrong power x Please fill out the quality warranty completely and keep it carefully DN DaD ELECTRONICS Anyang MegaValley No 207 799 Gwanyang 2 dong Dongan gu Anyang Gyeonggi do Korea tel 82 31 424 0100 web www dndele com fax 82 31 424 4036 e mail dndele dndele com This manual was written as of April 2014 The content is subject to changes due to conti
6. nylon acetate or leather clothes se Pour a small amount of NaOClean into the water bottle of the X Avoid using the product on clothes that can be discolored humidifier using a cup It will prevent the growth of bacteria inside because it has bleaching effect the bottle EE Cs Remove bad odor during laundry clothes Prevent athlete s foot and foot odor by soaking your feet into the e Sleeveless shirt underwear dress shirt towel handkerchief NaOClean water for several days gown bed sheet pillow case white sneakers and etc Helps treat bad breath stomatitis and mouth ulcer by gargling Use occasionally Removes Lingering odor after perm ST wanne Aler wasrina We Gales soak me clothes m It is effective in hemostasis of the wound or after exodontias NaOClean water for about 10 to 20 minutes rinse them with clean water and then dry them Washing machine Add NaOClean water while rinsing the clothes Before putting in fabric softener Disinfects your skin suffered from allergy atopy etc by misting or spraying with NaOClean water After washing the clothes with laundry detergent use the disinfectant for better results and superior disinfecting effects In particular people s clothes suffering from dermatitis X Rinse well with clean tap water after disinfecting virginities and other infectious diseases have to be disinfected Otherwise you can smell a weak disinfectant by soaking in the di
7. NaOClean Disinfectant Generator NaOClean Manual Strong Disinfecting Deodorizing Power Prevent Disease such as Food poisoning Harmless and Environment Friendly Product Safe to Human Body Almost No Residual Chlorine www naoclean com Please read the manual before installing or using the device PAGE 2 CONTENTS 3 7 15 16 e 1 About product 2 Using the machine 3 Making saline solution 4 Inspection Components Applications Cautions Specification amp Installation Error checking Features troubleshooting Operation procedure Electrode replacement amp Block diagram PAGE 3 1 About product Components Specification amp F e Model DES P450 oe A y poses J Main control panel 5 Rubber legs Flow control valve Water tap Faucet fixture Nut Handle 6 Fuse Electrical Signal connector 14 Power button 17 Salt measuring cup Saline tank Power cord 11 Water output port 15 Body of Faucet Electrical fuse Spare 4 Body STS tempered glass 8 Water input port Drainage hole www naoclean com pace 4 1 About product Y Components Specification amp Features Operation procedure e Control Panel If the saline solution is not supplied sufficiently it beeps and light
8. OClean in a kitchen for washing the vegetables fruits and all sort of utensils a S if SY T i N r OL BX Asse Bathroom Install the NaOClean in a bathroom for disinfecting the bacteria and the dirty things Also it can remove all kinds of bad odors pS S A a n pace 15 3 Making saline solution e Cautions before using salt e How to create saline solution Please the stipulated ratio when created the saline solution 1 Pour tap water and salt inside the tank Stir water and salt well to dissolve them completely 2 Stir water and salt well to dissolve them completely Use only salt with more than 88 salinity that is refined and devoid of any impurities Never use table salt processed by adding citric acid or amino e Mix ratio acid or roasted salt o 3 x May vary upon water quality Never use the salt for picking or bay salt that have high amount Category Mix ratio and temperature of impurities Water 40 20 Salt 400g 200g 1 If the filter inside the saline tank becomes dirty remove it and clean it 2 Hose being inside of saline tank should be placed down of the bottle 3 Please the stipulated ratio when creating the saline solution 4 Use only tap water or drinking water Cautions X Do not discard the disinfect
9. amics O stainless steel oO plating copper Ea X The weak corrosion resistance of the right side of the table can be corrosive phosphor bronze Do not use the disinfectant in cooking and drinking water brass _ O aluminium alloy steel pace 17 4 Inspection Cautions Error checking Troubleshooting Electrode replacement amp Block diagram e Precautions for safe operation Please observe the following instructions which are precautions for safe and correct A Cautions operation to prevent unexpected hazards of damage and injury Do not use a damaged power cord or a loose socket Electric shock or fire may result Do not connect more than one power plug to a single socket The receptacle may overheat and result in fire lIf you must use an extension cord inevitably make sure that the rated capacity is not exceeded Keep the product away from such undesired use by child or the old man Do not attempt to disassemble repair or alter the product You may suffer from electric shock or injury 5 Do not attempt to bend the power cord by applying excessive force or put a heavy stuff on the cord Never use the product with any chemical not described in this manual Physical injury or damage to the product may result Do not install this device in the area where ventilation does not function properly or in oily smoky humid dusty and water splashing places lts d
10. ant after using once You can reuse it to sterilize hygiene tools or floor Xx NaOClean water can also be used in various applications to disinfect or to remove odors www naoclean com pace 16 4 Inspection Cautions Error checking Troubleshooting Electrode replacement amp Block diagram e Cautions when using A cautions 1 Never mix disinfecting water with other disinfectant abstergent and chemicals e An analysis table for corrosion resistant material But it can be used with kitchen detergent in some case 2 If you have sensitive skin wear personal protective equipment such as rubber gloves Materials Cais SINS EINES 3 Do not use this disinfectant in the cultivation of plants animals fish and shellfish etc EE nomal aon x 3 resin 4 Be cautious as the solution may bleach eater textiles _ ENRE O 5 Disinfectant has the alteration about the right side of the table so please wash it with tap acrylic O water after sterilizing with NaOClean polypropylene O 6 Do not immerse aluminum containers steel knives in the disinfectant for a long time Q 7 Be sure to wash the metal pipe with tap water after the drainage of the large disinfectant s esn O that may cause corrosion urea resin O 8 Chlorine concentration may be degraded by heat or ultraviolet rays high temperature Butyl rubbe NBR O heating or long period of time so don t do that natural urethane rubber O titanium glass cer
11. er Use Sink Spray the disinfectant on the sink or brush with a kitchen Do not use this solution for silverware or copperware If you use towel soaked in disinfectant the solution on these materials it may discolor Refrigerator amp pantry Every 2 to 3 days soak a kitchen towel If so clean them with soda or toothpaste using a cloth in the disinfectant and clean the refrigerator or pantry thoroughly e Chopping board knife sponge brush amp kitchen towel NaOClean water disinfects them and gets rid of odors Use First wash them with clean water and soak in the disinfectant for about 5 to 10 minutes and then dry them If the product is too big House cleaning Disinfection Odor removal to soak in damp a kitchen towel or brush with the disinfectant e Odor removal for bathroom amp tiles and rub the products with it Use x There are many kinds of bacteria on chopping boards and Dampen a rag and brush with NaOClean water Also you can use the hilt of knives You can keep them hygienic with NaOClean a spray bottle spray gun to spray the solution thoroughly water 2 Using the machine Applications Installation x NaOClean water removes unpleasant odors and an ammonia smell in the bathroom In particular molds grow and increase during the rainy season So get rid of odors with NaOClean water e Sterilization and deodorization for sewer rubbish bin amp gar bage disposal Use Sewer Pour in the disi
12. espan approx 10 000 hours of the electrode may vary depending on water quality X Request a repair in case of display of the above con ditions during a normal operation condition after a prolonged use e Piping and electric connection block diagram pace 21 voting Electrode replacement amp Block diagram Sink Water tap A Reducing valve gt Water supply solenoid valve Flow control Mixing tank Electrolyzer AC 220 FUSE CONTROL PCB POWER PCB SUB PCB TRANS A Check valve A Filter A Salt water pump SMPS Saline tank www naoclean com MEMO Product Name Disinfectant Generator NaOClean Model DES P450 Food Additive Production Approval NaOClean a license number No 2006 2 0001 Issue Warranty Period Date of purchase One 1 year from the date of purchase Purchaser address Point of purchase address e Regulations of Product Warranty This product was manufactured through strict quality control and inspection Services arising from failure that takes place after the expiry of the warranty period will be charged for During the warranty period one year from the date of purchase this product This product is warranted in
13. nfectant water into the sewer and ensure that it is applied thoroughly around the sewer Rubbish bin Put the disinfectant in a spray bottle or spray gun and spray thoroughly around the bin By spraying NaOClean into sewers and rubbish bins frequently you can have a sterilized hygienic and odor free environment It is a good idea to set specific dates for regular sterilization works e Remove bad smells of pet pet basket and bird cage Use Pet NaoClean will help to clean pet s fur and remove the bad smell by spraying it PAGE 9 e Plastic toys wooden toys amp baby products Use Soak the toys in the disinfectant for about 5 to 10 minutes and rinse with water Children can touch and put their toys into their mouths so it is important to clean and sterilize toys regularly Sterilization of water in vase amp humidifier e Water in vase Use Before putting flowers into the vase fill the vase with water and add in a small amount of electrolyzed disinfectant By adding in small amount of NaOClean into the vase you can keep the water fresher As the solution gets into the stems it inhibits the growth of molds blocking the stems So flowers can live longer and the water will smell less foul by disinfecting the water www naoclean com pace 10 2 Using the machine Applications Installa e Water in humidifier NaOClean water can be used for white clothes excluding wool U silk fabrics
14. nued research and development
15. s up m If the water is not supplied sufficiently it beeps and lights up Disinfectant Generator NaOClean CONTINUOUS 10MIN 20MIN CLEANING SAUNE CHECK WATER CHECK POWER HIGH O Disinfectant on off sre MEDIUM O Display When you press the on off switch Low O Normal Display numbers incomplete disinfectant will be supplied And after 20 seconds normal disinfectant will be produced Error Display Er Power switch on off Time When the machine is operating you can choose the time 40min 20min or continuation switch After that time it turned off automatically Cleaning When you press the cleaning switch water is supplied for 2 minutes and clean inside the machine automatically After cleaning the water will be stopped When cleaning any other switches except on the power switch is not operating PAGE 5 1 About product Components Specification amp Features Operation procedure e Specification Model DES P450 Dimentions W180 X D486 X H463mm Rated Voltage AC 100 240V free about 330W Weight About 17kg Saline tank 4L Generating About 3L min Automatic Electrolysis Without membrane method pH 7 0 7 5pH Additive Salt Condition of Ambient temperature 5 40 C use Water temperature 5 30 C Humidity less than 95 RH Accessories Faucet Hose 2m Measuring cup Faucet adaptor
16. sinfectant for at least 10 minutes i f pace 11 2 Using the machine Applications Installation e Note of caution when installing A cautions 1 Do not install this device in the area where ventilation does not function properly or in oily smoky humid dusty and water splashing places 2 Install the device in a place with flat floor so that the device can maintain level and devoid of danger of falling 3 Install the device in a place with surrounding temperature of 5 40 C humidity with less than 95 RH and protected from winter sowing 4 Do not connect more than one power plug to a single convenience receptacle X If a grounded socket is not available make sure to connect the ground wire to a grounding pole of the floor or grounding connectors metal pipes X Do not ground the device to a gas pipe or an antenna X Check the disinfectant is generated when the installation is finished e Water supply specifications 1 Only use clean water such as tap water or underground water that complies with the drinking water regulations 2 If hard water is being used install a water softener or a filter before use Contact the seller for the hardness of water 3 Install a water softer when hard underground water is used or install a filter for water with many impurities 4 Used water pressure more than 1 5kgf cm less than 7 0kgf cn 5 Adjust the amount of water by operating the device and set it to suit the capacity
17. t amp Block diagram e The cause Er message is displayed on the display panel and actions to be taken X If any of the follow situations occur check the cause of the problem and resolve it first and then push the power button Situation The display panel cannot display more than 17 digits Er message beeping sound The display panel displays more than 23 digits Er message beeping sound Other beeping sounds amp Er error message Cause Lack of salt Excessive amount of salt Excessive amount of water Action Turn off the power put in more refined salt into the saline tank dilute it and operate again Turn off the power discharge a bit of saline solution from the tank and fill in water instead Adjust the flow control valve at the back to adjust the amount of flowing water Water cut off lf water supply is insufficient due to foreign materials stuck inside the water supply valve turn off the power Abnormal water supply First check tap water flow and if there is no problem with it contact the A S center Abnormal water supply caused by reduced water pressure Open the water supply valve and fix it so that water can flow normally Abnormal water supply caused by foreign materials inside the water supply valve Contact the A S center to clean or replace your water supply solenoid valve www naoclean com pace 20 4 Inspection Cautions Error checking
18. urability can be compromised due to corrosion Do not use a non grounded receptacle or a non standard code Electric shock due to electric leakage may result www naoclean com pace 18 4 Inspection Cautions Error checking Troubleshooting Electrode replacement amp Block diagram e Precautions for safe operation Please observe the following instructions which are precautions for safe and correct A cautions operation to prevent unexpected hazards of damage and injury Do not storage the solution for long period Be careful to avoid direct contact with eyes Do not inhale the fine particles such as spray evaporation or gas f you have sensitive skin wear protective equipment such as rubber gloves Do not sell the disinfectant created from the devices Do not use the created solution directly when cooking or as drinking water f you exceed the available chlorine concentration rinse with tap water after disinfecting Dilute large drainage with water after using disinfectant Do not use the solution on sesame seeds Measures 1 When the disinfectant gets into the eyes hold eye open and rinse gently with tap water immediately 2 Move to the place with fresh air when you inhaled the fine particles 3 When consumed drink plenty of water or milk and contact the nearest hospital and get treatment from a doctor pace 19 4 Inspection Y Cautions Error checking Troubleshooting Electrode replacemen
19. y peel the skin off it is still hygienic to disinfect the fruits first and then peel the skin e Liver tripe and other innards e Vegetables lettuce radish Chinese cabbage carrot and etc Use Raw Immediately soak liver and tripe in NaOClean water for Use about 5 to 10 minutes After that rinse with fresh water and Trim the vegetables without leaving any foreign materials and cook rinse them with water Storage amp Cooking later Immediately soak liver tripe and Soak them in NaOClean water for about 1 to 3 min other innards in disinfectant for 5 to 10 minutes After that Rinse once with clean water store them in the refrigerator and rinse with fresh water again before cooking later It is always safe to sterilize the vegetables with NaOClean water XTo prevent food poisoning you must sterilize what you eat In fish and shellfish there are many kinds of bacteria such as Vibrio or Salmonella which are main causes of food poisoning www naoclean com PAGE 8 2 Using the machine Applications Installation Disinfection of tableware X This solution can corrode steel products so use it cautiously Wash out with tap water to prevent the corrosion e Bowl rice bowl spoon chopsticks folk teacup and etc Use When you wash dishes first wash them with detergent thoroughly e Sink refrigerator amp pantry and soak them in the disinfectant for about 5 minutes After that rinse with clean wat
Download Pdf Manuals
Related Search