Sanli LSPR48 Self Propelled Petrol Rotary Lawn - Tooled
Contents
1. 3 Throttle control 10 Oil filter and dipstick 4 Rear deflector 11 Roller 5 Height adjustment lever 12 Starter rope 6 Fuel tank 13 Grass collection bag 7 User s manual 5 Tips on mower safety WARNING The information contained within this safety section is extremely important Personal injury to the user and to others may result if this section is not read and acted upon at all times 1 Before starting your mower inspect it carefully to ensure that there are no loose parts and that it is in good working order 2 Be sure of your footing Always walk never run when operating the lawnmower 3 Clear the area to be mowed of any stones sticks wire and debris before beginning and always ensure that you mow a safe distance away over 14 metres from adults children and animals 4 Keep hands feet and clothing away from the mower s moving parts and always wear appropriate footwear avoid sandals or open shoes 5 Never put your hands or feet underneath the chassis of the lawnmower while the engine is running 6 Be aware that the machine s exhaust area and other parts of the lawnmower get very hot during and right after use 7 Turn off the engine and disconnect the spark plug cap before cleaning transporting or making adjustments and never leave the mower unattended 8 Mow across the face of slopes not up amp down and avoid mowing on very steep slopes We recommend you avoid mowing when2. approved containers and you must ensure that you use fresh petrol that is less than three months old Do not mix oil with petrol To put petrol in the fuel tank firstly remove the warning label from under the petrol cap It s best to fill the tank using a clean funnel but never fill it completely Instead leave at least 13mm from the bottom of the filler neck to allow for expansion Ensure that you securely tighten the petrol cap after filling 3 Attach the grass catcher The grass catcher attaches easily by lifting the mower s rear flap and inserting it Just lift the rear flap with one hand and then gently slide the catcher into position as shown in photo on right User s manual 9 Cutting height adjustment WARNING Turn mower off before adjusting cutting height lever Your lawnmower s height adjustment is positioned on the rear left side There is a single 7 position lever that adjusts all four wheels at the same time The lower the level the shorter the cut For very thick or moist grass you should select a higher setting than usual to avoid clogging and stalling the lawnmower under the extra cutting load 10 User s manual Starting the engine WARNING Keep hands feet and clothing well away from moving parts the exhaust and the engine cowling Refer to Tips on mower safety on pages 6 and 7 for more information 1 Make sure that your mower is on a safe flat area a paved area o
3. it is raining or after nightfall 9 Do not operate the machine by pulling it towards you as you risk pulling it on to your feet Instead always push and walk behind your lawnmower 10 Do not fill the tank or start the lawnmower indoors or in a poorly ventilated area as exhaust gases contain poisonous substances and petrol fumes are flammable and dangerous 11 Always use unleaded petrol not more than 3 months old Fill the tank using a funnel but never completely Clean up any overflow or splashes before starting 6 User s manual 12 13 14 15 16 17 18 19 20 To inspect the underside of your mower only tilt the lawnmower to your right when standing behind it this is the side where the exhaust is near the ground otherwise oil may leak into inappropriate areas of the engine Never tilt the lawnmower when the engine is running Turn off the engine before emptying the grass catcher and before clearing any grass caught in the rear flap where the catcher fits Do not alter engine governing settings or over rev the engine as excessive speed is dangerous and can reduce engine life Never open the fuel filler cap or fill the tank if the engine is still hot after use And please ensure that you securely tighten the petrol cap after filling Do not transport the mower in a vehicle if there is any petrol in the tank Store fuel and oil in a cool well ventilated place away from direct sunlight and
4. Advanced Engine powered Lawnmower O SANLI LSPR48 LSP 480 ABS LBP 480 ABS PLEASE KEEP THIS OPERATOR S MANUAL IN A SAFE PLACE DOMESTIC OFFICE OR LOCAL DEALERS United Kingdom Company Sanli UK Ltd Web site www sanli co uk Address Unit 200 Milton Park Estate Abingdon Oxfordshire OX14 4TB E mail info sanli co uk Tel 44 0 1235 861640 France Company Sanli France Sas Web site www sanli fr Address 10 rue Gutenberg 67610 LA WANTZENAU E mail mail sanli fr Tel 33 0 388 19 08 23 Australia Company Sanli Australia Development P L Web site www sanli com au Address 4 100 Belmore Road Riverwood NSW 2210 E mail support sanli com au Tel 61 0 2 9584 1078 2 User s manual Contents What you get with your Sanli roller MOWeT ce em ennnnnnzznsnzanzznnnznnnzinzarinzananranzznazaznanza 4 Mower features ieci uid cone Salada trace vonieniin iid den Sh ea ao Mein R 5 Tips On OWE Salty kiore ii besi see e b hau na ATA 6 7 Before you begins istiesscni een nae nana be aniein nie ELANO EAE 8 9 Cutting height adjustments assirian eraieeaeh ieai 10 Starting thesensine ssccn ss e ee ee eee ee ee I ee 11 Basic maintenance made tasyon a E E RE REEE EN 12 14 Technical specifications oiia e a a E b ana oea a a 14 Fasttr uble sho titi issir nest 15 Warranty onditi is 1631 58 ses A a L tag isa ete hee ee 16 EC Declaration of Conformity sasinen Sidi Fe a enii re Eeri ee la 17 I
5. NOUE Seis ri i e sapsaveauseysrasDledeeanduaseane 18 Wartantvre istrati ti Card cc ii i A A Ses 19 20 Sanli products are monitored and enhanced on an on going basis to complv with changing technical standards and requirements As a result Sanli reserves the right to alter design and specifications at anv time without prior notice User s manual 3 Congratulations on choosing a Sanli mower Thank you for purchasing a Sanli 4 stroke lawnmower We re sure that you ll enjoy many years of trouble free performance plus you have the reassurance of an industry leading 2 year domestic warranty as outlined on page 16 Inside this guide you will find out all you need to know to correctly operate your new Sanli mower To ensure that you use your new mower responsibly and get the best results possible please read all of the safety and operating instructions carefully before using your lawnmower What you get with your Sanli mower Name QTY Name QTY Petrol engine lawnmower Clamp bolt Rear grass catcher Air filter socket 10 Spark plug socket 21 Cable tie Wrench 13 15 Oil pipe connection Flashing nut with buttlefly bolt assby Flashing nut with square bolt assby NIN IN Re le ele le le le le Spanner lever 4 User s manual Mower features Air filter 1 Drive lever 8 Spark plug 2 Operator presence control lever 9 Exhaust
6. ain out into an appropriate container 5 Cleaning ABS deck often As the ABS material can be marked by petrol please clean the deck immediately whenever you find petrol on the deck or before storing User s manual 13 6 Blades and cutting system Extreme care should be taken with blades Ensure the mower is off and the spark plug lead disconnected from the spark plug to prevent accidental ignition Remove the catcher set the cutting height lever to the highest level and then hold up the rear flap in order to inspect your blades Check every few months to make sure they are not damaged loose or overly worn If loose tighten but not over tighten the nuts and bolts If you are planning to change the blades yourself use thick work gloves and take extreme care at all times A full range of parts is available from your Authorised Sanli Dealer Technical specifications Model LSP 480 ABS LSPR48 LBP 480 ABS Sanli 550 OHV single cylinder 4 Engine stroke air cooled Briggs amp Stratton DOV 750 series refer to separate engine manual Maximum power 2 8 kW 3600 rpm Spark plug NGK BPR 6ES CHAMPION QC12YC Engine oil SAE30 600ml SAE30 600ml Maximum torque 8 0 Nm 2500 rpm 9 5 Nm 3060 rpm Cutting width 48 cm 48 cm Adjustable cutting heights 7 7 Grass collection capacitv 70 litres 70 litres Noise level 96 dB A 96 dB A Weight incl
7. ect to conditions Repairs or adjustments required by failure to follow the manufacturer s instructions are chargeable to the owner This express warranty does not cover e Intentional or unintentional misuse abuse or breakages e Normal wear and tear e Oiled air cleaner or starting difficulty caused by mower incorrectly tipped on its side e Consumable items including oil blades and spark plugs e Defects or faults caused by an act or omission after leaving manufacture e Incorrect contaminated or poor quality fuel older than 3 months or oil e Incorrect maintenance or storage of the product e Water damage or environmental conditions e Failure to observe safetv requirements e Any loss or damage arising from faulty parts or workmanship The warranty will become void if any unauthorised person dismantles repairs or modies the product 16 User s manual EC DECLARATION OF CONFORMITY Fujian Jinjiang Sanli Engine Co Ltd Declares that the following equipment manufactured by Fujian Jinjiang Sanli Engine Co Ltd conforms to the following Directive s 2006 42 EC 2004 108 EC and 2000 14 EC of the European Parliament and of the council on the approximation of the laws of the Member States relating to the noise emission in the environment by equipment for use outdoors Equipment Category Lawn Mower Product Name Model Lawn Mower LSP480ABS LBP480ABS LSPR48 amp LBPR48 Type Serial No N A Cutting Width 48 cm Net installed p
8. he spark plug gap must be set to 0 75mm 2 Air filter Ensure the engine is cool unscrew the top air filter nut lift up the cover and remove the air filter element Put the cover back on the housing immediately to prevent any objects falling into the air intake Either carefully brush off any excess dirt particles or replace the air filter with a new one To protect your warranty only use a genuine Sanli air filter We recommend that you replace the air filter after every 12 months of regular usage When the air filter has been cleaned or replaced screw in the cover taking care not to over tighten 12 User s manual 3 Oil draining Befor draining oil you should lift up one deck side air filter near ground to be 45 angle with the floor using a spanner 13 to unscrew the oil shutoff bolt and assemble the oil pipe with the draining bolt showed as picture Put the lawnmower on the floor again the oil will run out 4 Using and storing petrol After three months unleaded petrol begins to break down and may make your lawnmower difficult to start If during the colder months you have not mowed in a while you should drain the remaining fuel and replace with fresh unleaded Remove the fuel cap then release the spring clip on the black hose leading into the fuel filter and then disconnect the hose ensuring you squeeze it together firmly Then release your grip on the hose to allow the fuel to dr
9. not near gas cylinders or hot water heater systems Do not smoke when filling the fuel tank using the machine or when petrol is in the immediate area And never use or store the mower near a naked flame Sanli recommends that you wear a safety helmet ear protectors safety goggles and safety boots when using a lawnmower All servicing and repair work under warranty must be carried out by an Authorised Sanli Dealer otherwise the 2 year warranty may be void User s manual f Before you begin WARNING The following procedures must be carried out before you start the engine of your lawnmower 1 Fill oil sump with oil The mower is NOT supplied with oil in the engine you have to add 600ml oil before starting the engine for the first time Firstly remove the warning label from under the dipstick then remove the dipstick and slowly pour 600ml oil into the engine via the oil filler Replace the dipstick and tighten Before you use the mower each time check the oil level and if necessary top up with SAE30 engine oil To check the oil level just unscrew the yellow dipstick wipe with a rag and replace into the oil filler but do not screw it back in place and remove again The oil level must be between the min and max marks on the dipstick 8 User s manual 2 Fill fuel tank with unleaded petrol Petrol is highly flammable so extreme caution must be taken when handling it Always store petrol in
10. ower 161cc 163cc 5 5HP The technical documentation is kept by Name Mr Liu Qingguo Company Fujian Jinjiang Sanli Engine Co Ltd Address Wuli Industrial Park Jinjiang Fujian 362263 P R China The conformity assessment procedure followed was in accordance with annex VI of the Directive 2000 14 EC and the Directive 2005 88 EC Notified Body TUV SUD Product Service GmbH Ridlerstrasse 65 80339 MUnchen Germany TUV SUD Product Service GmbH Westendstrasse 65 80686 MUnchen Germany Measured Sound Power Level 94dB A Guaranteed Sound Power Level 96dB A A copy of this certificate has been submitted to the European Commission and to EU Member State UK Place of Declaration Wuli Industrial Park Jinjiang Fujian 362263 P R China Date 11 11 2010 Hes Signed by Mr Hu Dingsheng Position in Company General Engineer Name and address of manufacturer or Authorised representative Fujian Jinjiang Sanli Engine Co Ltd Wuli Industrial Park Jinjiang Fujian 362263 P R China Notes 18 User s manual nw m M A o 23 aver aaa nwa l O SANLI Address WARRANTY CARD REGISTER YOUR MACHINE TO VALIDATE YOUR WARRANTY To validate your warranty register your equipment with SANLI after its purchase by returning the warranty card provided at the back of the user s manual or on the website
11. r path is ideal avoid thick wet grass and gravel surfaces to make starting safe 2 Move the throttle control lever located on the handle to the Cold Start position 3 Slide the Red petrol tap lever to the left On position 4 Firmly hold the top handle with one hand and then with your other hand pull the cord slowly until you feel resistance Then pull vigorously 5 When the engine has been running for at least 15 seconds more time on cold days adjust the throttle control lever to the Run position 6 To re start a hot engine move the throttle control lever to the Hot Start position and then refer to Point 4 above 7 To turn off your mower slide the throttle control lever down to the Stop position After it has stopped slide the Red petrol tap lever to the right Off position User s manual 11 Basic maintenance made easy WARNING If your mower is not serviced correctly you could reduce your mower s ability to operate and void warranty 1 Spark plug Firstly wait until the engine has cooled before disconnecting the spark plug cover and then removing the spark plug with the box spanner supplied If it is dirty you can clean the plug with a wire brush For best results we advise you to replace the spark plug after 100 hours of use The replacement spark plug is NGK BPR 6ES When refitting the spark plug do not over tighten If adjusting yourself note t
12. sure the 3 holes in the fuel tank cap are clear Mower vibrates too much Loose cutting blade Bent or broken disc blades Excessive grass dirt build up Disc or blades worn damaged Check and tighten bolts and nuts Replace disc or blades Clean and ensure underside clear of build up Replace disc or blades Poor cutting catching Catcher not fitted correctly Incorrect cutting height set Blocked grass catcher vents Reattach carefully and also check for damage Adjust the cutting height Clear and clean the vents Reinsert carefully and also check for damage User s manual 15 Warranty conditions Please note that your warranty is affected by terms and conditions Read on to fully understand what is covered by the warranty and what is not covered Those items not covered by the warranty are the responsibility of the owner and any repairs will be at the owner s expense The warranty does not affect your statutory rights or remedies as outlined in applicable consumer legislation Sanli provides an express warranty for this product for a period of 2 years from your original purchase date with the exception of commercial use which is for a period of 90 days The warranty is not transferable and is only applicable to the original purchaser that can provide original proof of purchase Defective parts will be replaced or repaired by an Authorised Sanli Dealer without charge for labour or materials subj
13. uding catcher 39 kg 36 kg Chassis ABS ABS 14 User s manual Fast trouble shooting Often a depleted loose or dirty spark plug is responsible for a mower not being able to start but there can be a number of other reasons Refer below to the list of potential problems you may encounter along with suggested remedies For servicing and all warranty work contact your local Authorised Sanli Dealer Problem Likely cause Throttle lever not set properly Set to Cold Start for cold or a little lower when warm Engine does not start Out or almost out of fuel Spark plug depleted Spark plug dirty Spark plug not connected Flooded engine Old petrol in the tank Water in the fuel tank Fill tank with unleaded petrol Replace with a suitable new spark plug Clean or replace with a new spark plug Press firmly on the terminal cover Turn fuel off then zip until it starts then turn on Drain stale fuel and replace with new unleaded Contact an authorised Sanli dealer Engine stops often Blocked fuel supply Fuel cap is not venting Wrong type of fuel Ensure the fuel line is not pinched or blocked You may need to slightly loosen the fuel cap Drain petrol tank and fill with new unleaded Engine loses power Dirty air cleaner filter Incorrect height adjustment Blocked fuel cap vent holes Clean or replace with a new Sanli air filter Raise the mower s cutting height lever En
14. www sanli co uk register www sanli fr www sanli com au Serial Number S N Surname First name Address a Town E E Postcode Purchase date Customer No Imprint Company Name Address i www sanli co uk www sanli fr Postcode www sanli com au Purchase date Signature 7 Serial Number S N
Download Pdf Manuals
Related Search