warning - Medicaleshop.com
Contents
1. From the wheelchair chair to the Carendo shower and toilet chair with a passive lift 5 steps Follow the separate operating instructions regarding the passive lift 1 Apply the brakes on the Carendo shower and toilet chair 2 Place the passive lift with the patient as close as possible to the Carendo shower and toilet chair Position the patient in the sling directly over the seat of the Carendo shower and toilet chair See Fig 1 3 Raise the Carendo shower and toilet chair until the seat reaches the patient and there is slack in the sling straps Unhook and remove the sling See Fig 2 4 Secure the patient with the safety belt if needed 5 Transfer the patient to shower or toilet 17 Fig 1 From the bed to the Carendo shower and toilet chair with a ceiling lift 5 steps Follow the separate operating instructions regarding the ceiling lift 1 Place the Carendo shower and toilet chair under the ceiling lift with the patient in the sling See Fig 1 2 Apply the brakes on the Carendo shower and toilet chair 3 Lower the sling with the patient until he she reaches the seat of the Carendo shower and toilet chair Unhook and remove the sling 4 Secure the patient with the safety belt if needed 5 Transfer the patient to shower or toilet From the wheelchair chair to the Carendo shower and toilet chair with an active lift 6 steps Follow the separate operating instructions regarding the active lift2. max width 15 3 in 390mm max width 15 3 in 390mm 1 Place the Carendo shower and toilet chair with the patient close to the toilet Raise the chair in a sitting position to a comfortable height for the caregiver Activate the Care Raiser on the hand control Pull down the trousers to the knees See Fig 1 If the patient uses incontinence pads remove them by pulling from behind See Fig 2 Raise to a sitting position on the hand control WARNING To avoid entrapment or pinching of genitals make sure there is enough clearance during movement over the tub edge toilet bedpan or other furniture 6 Position the Carendo shower and toilet chair directly over the toilet bowl Lower the chair and apply the castor brakes See Fig 3 Continue with the steps on the next page 22 Fig 4 Fig 5 i 7 When the patient is ready release the brakes and remove the chair from the toilet 8 Raise the Carendo shower and toilet chair and clean the patient 9 Apply the castor brakes again 10 Activate the Care Raiser on the hand control See Fig 4 11 Put on the incontinence pads if used and pull up the trousers completely See Fig 5 12 Adjust the Carendo shower and toilet chair back to a sitting position and lower the chair WARNING To avoid entrapment make sure to keep the patient s hair arms and feet close to the body and use designated grab supports during an
3. 1 Apply the brakes on the Carendo shower and toilet chair 2 Place the active lift with the patient as close as possible to the Carendo shower and toilet chair Position the patient directly over the seat of the Carendo shower and toilet chair See Fig 2 3 Apply the brakes on the active lift 4 Lower the patient till he she reaches the seat of the Carendo shower and toilet chair Unhook sling and remove if present See Fig 3 5 Secure the patient with the safety belt if needed 6 Transfer the patient to shower or toilet 18 Intentionally left blank Transfer to the Shower Fig 3 18 steps 1 Place the Carendo shower and toilet chair with the patient in the shower room Apply the castor brakes Raise the chair in a sitting position to a comfortable height for the caregiver Activate the Care Raiser on the hand control Pull down the trousers to the knees See Fig 1 If the patient uses incontinence pads remove them by pulling from behind See Fig 2 Raise the Carendo shower and toilet chair to a sitting position with the hand control WARNING To avoid entrapment make sure to keep the patient s hair arms and feet close to the body and use designated grab supports during any movement 7 Undress the patient 8 Activate the reclined position on the hand control WARNING To avoid entrapment or pinching of genitals make sure there is enough clearance during mo
4. PREVENTIVE MAINTENANCE SCHEDULE Carendo shower and toilet chair CAREGIVER OBLIGATIONS Action Every Every Every Every 2 nd Check USE WEEK 6 MONTHS YEAR Clean Disinfect X Visually check safety belt Visually check all exposed parts Visually check mechanical attachments Check hand control and cable Check clean castors Check cushions pillows X XKX o o o o COX Visually check battery charger and battery Lubricate locking pins X Replace the safety belt X WARNING To avoid injury to both patient and caregiver never modify the equipment or use incompatible parts 30 Fig 1 Fig 2 Fig 3 Caregiver Obligations Caregiver obligations shall be carried out by personnel with sufficient Carendo knowledge following the instructions in this IFU Every day Disinfect The Carendo shower and toilet chair has to be disinfected immediately after every use ArjoHuntleigh disinfectants and shampoos should be used in recommended concentrations See section Cleaning and Disinfection Instructions on page 26 Every week Visually check the safety belt Check the complete length for fraying cuts crack tears that no inner fabric is showing and that no other damage is visible If the safety belt is found damaged replace it See Fig 1 Visually check all exposed parts especially where personal contact is made by either the patient or caregiver Make sure no cracks or sharp edges have developed t
5. The battery needs charging Complete the patient transferring begin raised progress and change to a fully charged battery WARNING To avoid injury make sure that the patient is not left unattended at any time Only a few activities are carried out before the Replace the battery with a fully charged one Dalley a WELHLASILGEUNBOUIIGE If using a freshly charged battery and the battery indicator starts to flash and sound after only a few activities are carried out it is time to order a new battery 34 Intentionally left blank 35 Technical Specifications Carendo Lift and Shower Chair Model BIB2000 01 Safe Working Load SWL Maximum total load 136 kg 300 Ibs Weight 65 kg 143 Ibs Maximum total weight lift patient 200 kg 441 Ibs Chassis maximum width 640 mm 25 1 4 Width between legs 508 mm 20 Clearance under chassis 35 mm 1 3 8 Chassis maximum length 865 mm 34 Turning area 960 mm 37 3 4 Lifting stroke range seat 530 mm 20 7 8 Supply voltage 24 V DC Maximum power 150 VA Battery NiMH ArjoHuntleigh NEA 0100 Battery charger NEA 8000 Colors blue grey Operating forces of control 2 23 N Operating forces of brakes 115 N Degree of protection IPX4 IP Ingress Protection X The protection against contact and ingress of objects is not specified for this product 4 Water splashing against the product from any direction does not effect safety or essential per
6. accompanies this FU please note that the DVD does not replace the information in this FU The IFU contains additional important safety instructions Definitions in this FU WARNING Means Safety warning Failure to understand and obey this warning may result in injury to you or to others CAUTION Means Failure to follow these instructions may cause damage to all or parts of the system or equipment NOTE Means This is important information for the correct use of this system or equipment Means The name and address of the manufacturer Intended Use This equipment must be used in accordance with these safety instructions Anyone using the equipment must also have read and understood the instructions in this Instructions for Use IFU If there is anything you are not sure about contact your ArjoHuntleigh representative This equipment is intended for assisted hygiene care showering and toileting of adult residents in care environments similar to senior assisted living group home special care nursing homes hospitals and home care The equipment is intended for indoor use The Carendo must be used by appropriately trained caregivers with the adequate knowledge of the care environment it s common practices and procedures and in accordance with the guidelines in the Instructions for Use IFU Resident Assessment We recommend that facilities establish regular assessment routine
7. and or unsafe product the maintenance activities must be carried out at the correct frequency by qualified personnel using correct tools parts and knowledge of procedure Qualified personnel must have documented training in maintenance of this device QUALIFIED PERSONNEL Action Check Every YEAR Lubricate bearings Check function of emergency lowering Check the safety stop function Perform a safe working load test local requirements Check all vital parts for corrosion damage Perform full feature functionality test Check mechanical attachments Check that the latest updates have been implemented Check battery X XKX KK XKX XKX 5 5 5 OK Inspect castors NOTE All checkpoints in the table CAREGIVER OBLIGATIONS Action Check on page 30 are to be checked when performing the checkpoints in the table QUALIFIED PERSONNEL Action Check on page 33 33 Troubleshooting NOTE If the product does not work as intended immediately contact your local ArjoHuntleigh representative for support PROBLEM ACTION It is only possible to lower the lift The lifting device of this equipment is equipped with a a safety nut If the safety nut will be activated it will only be possible to lower the equipment into a safe position In case of this scenario stop using the equipment and contact qualified personnel for repair of the equipment ALARMS ACTION A beeping sound is heard as the hygiene chair is
8. driving direction in this IFU are shown below Parts Designation E Chassis Care Raiser Castors Lifting frame Backrest Neck pillow Transfer handles Manoeuvring handles O 00 NY OQ t A WN Storage net Safety belt E E Seat N Leg support Uo Armrests ER P Hand control Nn Battery On Battery charger Battery holder oo Seat cushion No Bed pan holder optional N Bed pan optional N Back pillow optional N N Emergency stop button N o2 Emergency lowering button N EN Hand control connector Applied part Type B Entire product protection against electric shock in accordance with IEC 60601 1 Product Description Functions Fig 1 Fig 2 Fig 3 Fig 4 Reclined Function A function which makes hygienic care of the patient easier From a sitting position a reclined position can be achieved by means of turning gears which makes the backrest move in backwards and upright directions Corresponding to this movement the leg rest is moving up and down See Fig 1 Lifting Function High Low The patient can in a sitting position be transferred and the chair can be adjusted to a suitable height over the toilet The lifting lowering movement is performed by a linear actuator driven by an electric motor See Fig 2 Care Raiser A function which makes
9. is designed for use in a dry location and should not be installed in bathrooms etc a See NEA 8000 Battery Charger IFU Fig 2 Battery B The battery is placed at the left side of the chair See Fig 2 A B NOTE See to that the rounded ridge of the battery is turned f upwards O O M Seat Cushion A seat cushion that provides comfort and protection against pinching See Fig 3 A D Fig 1 Emergency Lowering In case of electrical malfunction the chair can be lowered by pushing the green button See Fig 1 NOTE This function should only be used in emergency Fig 2 Emergency Stop In any case of emergency all functions can be stopped by pushing the red button A To reset this function turn the red button clockwise B See Fig 2 Fig 3 Storage Net A net on the backside of the backrest where shampoo soap incontinence pads etc can be kept See Fig 3 14 Fig 1 Bedpan and Bedpan Holder WARNING To avoid entrapment or pinching of genitals make sure there is enough clearance during movement over the tub edge toilet bedpan or other furniture A bedpan holder can be mounted under the seat See Fig 1 2 See separate instruction Bedpan Holder Fig 2 Independent Patients WARNING To avoid entrapment or pinching of genitals and skin always use the seat cushion From a standing position
10. or using a walking frame 5 steps Place the Carendo shower and toilet chair and adjust the height so that the edge of the seat touches the back of the patient s knees 2 Activate the brake 3 Letthe patient hold on the armrest so that he she can lean on it See Fig 1 4 Help the patient to sit down 5 Raise the Carendo shower and toilet chair to a height which is convenient for moving the patient From a wheelchair 3 steps For the patient to be able to move from a wheelchair without lifting aids the individual must be strong enough to move himself herself sideways and or be able to stand up 1 Apply the castor brakes on the wheelchair 2 Lower the Carendo shower and toilet chair so that its seat is at the same level as the wheelchair seat or as close as possible 3 Apply the brakes on the Carendo shower and toilet chair The patient can now move himself herself from the wheelchair to the Carendo shower and toilet chair by placing his her hands on the hand rest of the Carendo shower and toilet chair See Fig 2 From a sitting to a standing position 3 steps 1 Lower the Carendo shower and toilet chair until the patient s feet are in contact with the floor 2 Activate the brake 3 Help the patient to stand up See Fig 3 16 Le WE v9 J EL we Dependent Patients WARNING To avoid entrapment or pinching of genitals and skin always use the seat cushion
11. ARJOHUNTLEIGH GETINGE GROUP Carendo INSTRUCTIONS FOR USE CE 04 CC 01_21US CA September 2014 With people in mind WARNING To avoid injury always read this Instructions for Use and accompanied documents before using the product Mandatory to read the Instructions for Use Design Policy and Copyright and are trademarks belonging to the ArjoHuntleigh group of companies ArjoHuntleigh AB 2014 As our policy is one of continuous improvement we reserve the right to modify designs without prior notice The content of this publication may not be copied either whole or in part without the consent of ArjoHuntleigh AB Contents Foreword cades oua en DU LEN RM REM recat iMd uM NE 4 Intended USE NN RE 5 Safety ISI ulODS seernes tetti Rx HRK E do dd 6 Preparations et 7 Parts RI ear MERE aa 8 Product Description Functions cuusedeu siot dante dades 10 Reclined Function ETE TT 10 Lifting Function High Low eeeeeeessssssss 10 STAR Gee S 10 Leg SUDDOfI Lise tiende qx nx dand eeeec t xe E Epi Durs dota is 10 Diving FRAN MN NR 11 Manoeuvre Handles 5 eros trap n kipa teret toca na tiu orent 11 Gastos ee EA A E E E 11 Safety Beli irer aea E 11 Hand Control M aaa 12 Back Pillow Accessory iausuuatoissse ceto tenes hot Ia ume RE RRE 12 Battery Charger M n 13 Batley een E A 13 Seat OISINOR a uit qu eaii T EE EARE EE 13 Emergency Loweri
12. RF disturbances are controlled The customer or the user of the Carendo shower and toilet chair can help prevent electromagnetic interference by maintaining a minimum distance between portable and mobile RF communications equipment transmitters and the Carendo shower and toilet chair by maintaining a distance of not less than 1 meter to any part of the Carendo shower and toilet chair including cables if the transmitters output power rating exceeds 1 W 41 Parts and Accessories LALI For disinfectant contact Back Pillow Neck Pillow the ArjoHuntleigh local representative A Battery and Charger Bed pan amp Holder 42
13. all parts dry NOTE The cushion and the foam inside of it is water repellent 27 Battery Instructions WARNING To avoid bodily injury do NOT crush puncture open dismantle or otherwise mechanically interfere with the battery Should the battery casing crack and cause contents to come in contact with skin or clothing rinse immediately with plenty of water e If contents come in contact with the eyes rinse immediately with plenty of water and seek medical attention Inhalation of the contents can cause respiratory irritation Provide fresh air and medical attention CAUTION To avoid the battery from overheating and exploding do NOT expose the battery to flames or excessive heat e Becareful not to drop the battery Contact the appropriate local authority for advice when disposing of batteries Check label on the battery Storage of Batteries e The battery is delivered charged but we recommend you recharge the battery when received due to a slow self discharge This battery will slowly self discharge when not used e A battery not in use should be stored in a temperature range of 0 C 32 F to 30 C 86 F For maximum battery performance do not store the battery above 50 C 122 F 28 Charging Intervals To prolong the life of the battery charge it at regular intervals i e every night e If the Carendo shower and toilet chair
14. at the knobs on either side of the backrest Adjust the length by pulling the safety belt end by the buckle Make sure the safety belt is close to the patients body When the safety belt is not in use don t let the safety belt hang over the floor See Fig 4 11 Fig 1 Fig 2 Fig 4 Fig 5 Hand Control Connect the connector of the hand control on the right side of the backrest See Fig 1 The hand control has a hook on the back making it easy to attach it to various parts of the chair See Fig 2 Hand control See Fig 3 e Arrow pointing upwards downwards for raising or lowering A e Reclined B and sitting position C Green LED flashing when the Care Raiser is possible to activate D e Care Raiser E and sitting position C NOTE A buzzing tone will be heard and the green LED is flashing when sitting position is reached NOTE Care raising can only be activated when the green LED is flashing Back Pillow Accessory An additional pillow to support the back An integrated easy glide function when the chair is adjusted to reclined position Easy to adjust according to the length of the patient See Fig 4 5 See separate instructions accompanying the product 12 Fig 1 Battery Charger The battery holder should be attached to a suitable wall and the charger connected to a properly grounded wall socket See Fig 1 NOTE The battery charger
15. e Material Safety Data Sheets MSDS available for the disinfectant being used WARNING EO SS To avoid eye and skin damage always use protective glasses and gloves If contact occurs rinse with plenty of water If eyes or skin becomes irritated contact a physician Always read the IFU and the Material Safety Data Sheet MSDS of the disinfectant A WARNING To prevent cross contamination always follow the disinfection instructions in this Instructions for Use WARNING To avoid eye or skin irritation never disinfect in the presence of a patient CAUTION To avoid damage on the equipment only use ArjoHuntleigh branded disinfectants 26 Allowed Disinfectants Arjo Clean Arjo General Purpose Disinfectant Arjo Disinfectant Cleanser IV Arjo All Purpose Disinfectant Arjo CenKleen IV Accessories for Disinfecting the Carendo Protective gloves Protective glasses Spray bottle with disinfectant or disinfection spray handle with disinfectant Spray bottle with water or shower handle with water Cloths wet and dry Disposable towels Soft bristle brush Long handled soft bristled brush Always Follow these 13 Steps for Cleaning and Disinfection If an ArjoHuntleigh shower panel will be used see respective FU Removing visual residue step 1 2 of 13 Detach pillow cushions and safety belt 2 Clean the Carendo shower and toilet chair start from the top and mo
16. formance Degree of protection Hand control IP X7 IP Ingress Protection X The protection against contact and ingress of objects is not specified for this product 7 Immersion up to 1m of the product does not effect safety or essential performance Medical equipment type B Sound level lt 58 dB Mode of operation ED maximum 10 Maximum 2 minutes ON Minimum 18 minutes OFF Pollution Degree 2 36 Carendo Positions Maximum length mm inches Width mm inches Maximum height mm inches Seat height mm inches Sitting lowest position Sitting highest position Reclined lowest position 875 34 1 2 880 34 5 8 1395 54 7 8 640 25 1 4 640 25 1 4 640 25 1 4 1220 48 1550 61 1020 40 1 8 510 20 1040 41 510 20 640 25 1 4 1225 48 1 4 Reclined highest position 1510 59 1 25 1050 41 3 8 Care Raise lowest position 1390 54 3 4 640 25 1 4 1020 40 1 8 765 30 1 4 Care Raise highest position 1510 59 1 2 640 25 1 4 1490 58 5 8 1260 49 5 8 Allowed Combination The Carendo integrate with the following ArjoHuntleigh products Sara Lite Sara Plus Sara 3000 Maxi Twin Maxi Move Maxi Sky No other combinations are allowed Recycling The device should be recycled according to national regulations Battery NiMH Recyclable Not for disposal Environment dan
17. ger Package Wood and corrugated cardboard recyclable The Liftand Charger Electric steel and plastic parts shall be separated and recycled according to WEEE Operating Transport and Storage Ambient temperature range 10 C 40 C 50 F 104 F Operation 20 C to 70 C 4 F to 158 F Transport 20 C to 70 C 4 F to 158 F Storage 30 75 Operation 10 to 80 including condensation Transport and Storage 800 1060 hPa Operation 500 1100 hPa Transport 500 1100 hPa Storage Relative humidity range Atmospheric pressure range Disposal of the Carendo Lift The device is marked with the WEEE symbol to indicate that it is electronic equipment covered by the Directive 2002 96 EC on waste electrical and electronic equipment In European countries the crossed out wheeled bin WEEE symbol reminds you that all the electrical and electronic products batteries and accumulators must be taken to separate collection at end of their working life This requirement applies in the European Union Do not dispose these products as unsorted municipal waste You can return your device and accessories to ArjoHuntleigh or you can contact your local authorities for advice on disposal 37 Labels Label explanation Attention Important user information for Label correct use Approval States approvals for the current Label product Battery Label States safet
18. hat could cause the patient or user injury or that has become unhygienic Replace damaged parts Visually check mechanical attachments Visually check that all screws and nuts are tightened and that there are no gaps contact your local ArjoHuntleigh representative if defects are found See Fig 2 Check hand control and cable Visually check the condition of the hand control and its cable if it is cut or damaged Also check the emergency stop see product functions Contact your local ArjoHuntleigh representative if defects are found See Fig 3 31 Fig 4 Check that the castors are properly fixed and are rolling and swivelling freely the function can be affected by soap hair dust and chemicals from floor cleaning If not contact your local ArjoHuntleigh representative See Fig 4 Check the cushions pillows to make sure there are no cracks or tears that would allow water to get into the filling If there is such damage replace the cushions pillows See Fig 5 Fig 5 Fig 6 e Visually check the condition of the battery charger its cable and the battery Withdraw immediately and replace if damaged See Fig 6 Every sixth months Lubricate the locking pins Use grease Wekem WS267 can be purchased from ArjoHuntleigh See Fig 7 Yearly The Carendo shower and toilet chair has to be serviced according to the table QUALIFIED PERSONNEL Action Check on page 33 32 WARNING To avoid injury
19. is used frequently it is recommended to use two batteries one in operation and one as a stand by in the charger tis recommended that a battery not in use is left in the charger There is no risk of overcharging the battery Battery Service Life Make sure to always have two well functional batteries one to use and one in storage If using a freshly charged battery and the battery indicator starts to flash and sound after only a few activities are carried out it is time to order a new battery Low Charge Warning A buzzer sound will go off when the battery reaches a low charge The battery should then be recharged as soon as possible Installation of Charger See NEA 8000 Battery Charger IFU How to Change the Battery See NEA 8000 Battery Charger IFU Intentionally left blank 29 Care and Preventive Maintenance Caregiver Obligations The Carendo shower and toilet chair is subject to wear and tear and the following actions must be performed when specified to make sure that the product remains within its original manufacturing specification WARNING To avoid malfunction resulting in injury make sure to conduct regular inspections and follow the recommended maintenance schedule In some cases due to heavy use of the product and exposure to aggressive environment more frequent inspections should be carried out Local regulations and standards may be more stringent than the recommended maintenance schedule
20. ith UL 60601 1 and CAN CSA C 22 2 No 601 1 M90 CE marking in accordance with the Medical Devices Directive 93 A2 EEC TUV marking The lift has been safety tested according to EN ISO 10535 xil NiMH Environmental danger Not for disposal uS Recyclable Approval Label Identification Label Attention Symbol Battery Label Emergency Lowering Label Data Label Approvals and List of Standards CERTIFICATE STANDARDS EN ISO IEC UL 60601 1 Medical electrical equipment Part 1 General requirements for basic safety and essential performance EN 60601 1 2 Electromagnetic Compatibility Requirements and Tests EN 60601 1 11 Requirements for medical electrical equipment and medical electrical systems used in the home healthcare environment CAN CSA C22 2 No 601 1 Medical equipment Certified for Canada Electromagnetic Compatibility Medical electrical equipment needs special precautions regarding EMC Electromagnetic compatibility and needs to be used according to the EMC information below The Carendo shower and toilet chair is intended for use in the electromagnetic environment specified below The customer or the user of the Carendo shower and toilet chair should assure that it is used in such an environment WARNING Stacking or placing other electrical equipment next to this device is not recommended it can interfere with
21. lied Compare with the product description in this FU If any part is missing or damaged do NOT use the product 4 Unpack the battery charger Select and attach the adapter correctly suited to your power outlet See Battery charger IFU 5 Charge each battery for a minimum of 14 hours Japan 3 5 hours 6 Disinfect the product according to section Cleaning and Disinfection Instructions on page 26 7 Prepare an area that is dry with good ventilation and out of direct sunlight for storage of the Carendo shower and toilet chair 8 Choose a designated area where the Instructions for Use should be kept and is accessible at all times for the users 9 Make sure to have a rescue plan in case of a patient emergency NOTE If you have any questions please contact your local ArjoHuntleigh representative for support and service See contact information according to ArjoHuntleigh Addresses on page 43 Action Before Every Use 4 steps Check that all parts of the Carendo shower and toilet chair are in place Compare to section Parts Designation on page 6 2 Check accessories and parts for damage If any part is missing or damaged do NOT use the product 3 WARNING To prevent cross contamination always follow the disinfection instructions in this nstructions for Use 4 Assess the patient whether the safety belt is needed Carendo Directions The directions right or left and intended
22. ng ccccceeeeeeceeeeeeeeeeeeeeeeeeeeenneneees 14 Emergency Stop ccce a 14 Storage Net ae nme ee ee ee ere 14 Bedpan and Bedpan Holder 22 e tet et nebat 15 Independent Patients ccececcceeeeeeeeeseeeeeeeeeeeeneeeeeeeees 16 Dependent Patients creen retenu ostiis 17 Transfer toe S DOWOLD easet tidie tales tee EE ciebn tu enendues 20 Transfer to the Toilet 1 5 rere one aa ira 22 Home Care WISE TEC 24 Cleaning and Disinfection Instructions 26 Battery Instructions aH pP 28 Care and Preventive Maintenance uuussssss 30 Rise ie 34 Technical Specifications ioco rre tatu Eh erbe eve nee rhet uaE 36 Labels aeee AM eteteite Ee tua MM E Dre Ene ilb nid id 38 Approvals and List of Standards sre niin pasa diaucada nto ber n 40 Electromagnetic Compatibility sesseeeeeeeesssss 40 Parts and Accessories sseeeesssseeeenenenenneeennnnnn 42 ArjoHuntleigh Addresses sssssss Last page Foreword Thank You for Purchasing ArjoHuntleigh Equipment Your Carendo shower and toilet chair is part of a series of quality products designed especially for hospitals nursing homes and other health care use Please contact us if you have any questions about the operation or maintenance of your ArjoHuntleigh equipment Please Read these Instructions for Use Thoroughly Please read this In
23. quipment should be used no closer to any part of IE DIMUS ia di Reed s the Carendo shower and toilet chair including cables than 1 meter if the transmitters output power rating exceeds 1 W Field strengths from fixed RF transmitters as determined by an electromagnetic site survey should be less than the compliance level in each frequency range E Interference may occur in the vicinity of equipment marked with the following symbol Ga Field strengths from fixed transmitters such as base stations for radio cellular cordless telephones and land mobile radios amateur radio AM and FM radio broadcast and TV broadcast cannot be predicted theoretically with accuracy To assess the electromagnetic environment due to fixed RF transmitters an electromagnetic site survey should be considered If the measured field strength in the location in which the Carendo shower and toilet chair is used exceeds the applicable RF compliance level above the Carendo shower and toilet chair should be observed to verify normal operation If abnormal performance is observed additional measures may be necessary P Over the frequency range 150 kHz to 80 MHz field strengths should be less than 1 V m Recommended separation distances between portable and mobile RF communications equipment and the Carendo shower and toilet chair The Carendo shower and toilet chair is intended for use in an electromagnetic environment in which radiated
24. s Caregivers should assess each resident according to the following criteria prior to use e The residents weight should not exceed 136 kg 300 Ibs e The resident should understand and respond to instructions to stay seated in an upright position If a resident does not meet these criteria an alternative lift shall be used Lifetime of the Equipment The equipment must only be used for the purposes stated above The lifetime of this equipment is ten 10 years and the service life of the safety belt is two 2 years Depending on the storage of the battery the use frequency and the charging intervals the service life of the battery is 2 5 years The lifetime and service life are stated providing that the preventive maintenance are being carried out in accordance with the instructions for care and maintenance in this FU Depending on level of wear some equipment parts such as castors and hand control may need to be replaced during the equipment lifetime according to information in this ZFU Safety Instructions WARNING To avoid explosion or fire never use the equipment in oxygen rich environment in presence of heat source or flammable anaesthetic gases WARNING To avoid the device in use from tipping do not raise or lower other equipment close to it and be aware of stationary object when lowering WARNING To avoid entrapment make sure to keep the patient s hair arms and feet close to
25. structions for Use IF U in its entirety before using your Carendo shower and toilet chair Information in this FU is crucial to the proper operation and maintenance of the equipment It will help protect your product and make sure that the equipment performs to your satisfaction The information in this ZFU is important for your safety and must be read and understood to help prevent possible injury Unauthorized modifications on any ArjoHuntleigh equipment may affect its safety ArjoHuntleigh will not be held responsible for any accidents incidents or lack of performance that occur as a result of any unauthorized modification to its products Report Unexpected Operations or Events Contact your local ArjoHuntleigh representative if any unexpected operations or events occur The contact information appear on the last page of this ZFU Service and Support A service routine must be performed on your Carendo shower and toilet chair every year by qualified personnel to make sure the safety and operating procedures of your product See section Care and Preventive Maintenance on page 30 If you require further information please contact ArjoHuntleigh for comprehensive support and service programs to maximize the long term safety reliability and value of the product Contact your local ArjoHuntleigh representative for replacement parts The contact information appear on the last page of this ZFU Complementary Information If a DVD
26. t on floor with recessed drains holes or slopes exceeding a ratio of 1 50 1 15 e All caregivers including relatives have read and understood the instructions in this ZFU e All carpets and rugs in the environment are removed e All thresholds in the environment are removed e All stairs and edges have a fence and safety gate to prevent the Carendo shower and toilet chair from rolling down There is room enough in the environment for use of the Carendo shower and toilet chair During Storage of the Carendo shower and toilet chair make sure that WARNING To avoid strangulation make sure to never leave children unattended near the equipment e No children can access the hygiene chair shower and toilet chair e No pets can come in contact with the Carendo shower and toilet chair e The storage environment fulfils the requirements specified according to section Technical Specifications on page 36 Fig 1 36 900 mm 36 900 mm ED 88 2200 mm 88 2200 mm 1000 950 900 850 800 750 39 37 36 33 31 30 25 Cleaning and Disinfection Instructions Only use ArjoHuntleigh branded disinfectant cleansers e g Arjo Clean V If you have any questions regarding disinfecting the Carendo shower and toilet chair or wish to order disinfectant contact ArjoHuntleigh Customer Service See section Parts and Accessories on page 42 Make sure to have th
27. the body and use designated grab supports during any movement NOTE All materials used in this product complies with established biocompatibility standards and have been tested accordingly ISO 10993 WARNING To avoid the device from tipping and the patient from falling do not use the equipment on floor with recessed drains holes or slopes exceeding a ratio of 1 50 1 15 NOTE Do not lift the Carendo shower and toilet chair using the armrests use the chassis Only one function movement e g reclined function can be done at a time Pushing on more than one button at a time will stop all movements WARNING To avoid falling make sure that the patient is positioned in accordance with this IFU WARNING To avoid falling during transfer always make sure that the brakes are applies on all equipment being used WARNING To avoid falling during patient transfer always make sure that the brakes on the equipment receiving the patient are applied WARNING To avoid entrapment of the patients or caregivers legs or feet make sure that they are kept clear of all obstacles Preparations Actions Before the First Use 9 steps Visually check the package for damage If the product looks damaged make a complaint to the transport agency 2 The packaging should be recycled according to local regulations 3 Check that all parts of the product are supp
28. the equipment s operation and safety Portable and mobile radio frequency RF communications equipment can interfere with this equipment operation and safety WARNING The equipment may cause radio interference or may disrupt the operation of nearby equipment It may be necessary to take action such as reorienting relocating the equipment or shielding the location 40 Guidance and manufacturer s declaration electromagnetic emissions Emissions test Compliance Electromagnetic environment guidance RF emissions Group 1 The Carendo shower and toilet chair uses RF energy only for its internal function Therefore its RF emissions are very low and are not likely to cause BONS any interference in nearby electronic equipment RF emissions Class B The Carendo shower and toilet chair is suitable for use in all establishments CISPR 11 those directly connected to the public low voltage power supply network that supplies buildings used for domestic purposes Guidance and manufacturer s declaration electromagnetic immunity Immunity test IEC 60601 test level penes Electromagnetic environment guidance Electrostatic 6 kV contact 6 kV contact Floors should be wood concrete or ceramic tile If discharge ESD floors are covered with synthetic material the IEC 61000 4 2 en POE relative humidity should be at least 30 Radiated RF 3 Vrms 10 Vrms Portable and mobile RF communications T e
29. undressing and changing of incontinence pads of the patient easier See Fig 3 From a sitting position a raising of the posterior parts of the patient and at the same time a backwards movement of the backrest is activated See Fig 4 These movements are synchronized to each other WARNING To avoid entrapment or pinching of genitals and skin always use the seat cushion Leg Support Supports the patient s legs and also prevents the legs from getting jammed under the seat Moves forward when the chair is adjusted to the reclined position 10 Fig 1 Fig 2 Fig 4 Driving Handles Driving handles on the backrest give correct driving position for the caregiver See Fig 1 Manoeuvre Handles The manoeuvring handles on the backrest help the caregiver to get the chair in the correct position over the toilet and in the shower See Fig 2 Castors The Carendo shower and toilet chair is equipped with lockable castors The castors will brake by pressing the castor lock tab down with your foot A See Fig 3 The castors are released by pressing up the centre tab B See Fig 3 Safety Belt WARNING To prevent the patient from falling make sure the safety belts are undamaged If damaged do NOT use the safety belts replace with new ones before use Secure the patient with the safety belt if needed The safety belt will secure the patient in the chair Fasten
30. ve downwards all removed parts from visible residue using a cloth soaked in water or if more suitable by spraying showering water using a brush and or wipe with a clean cloth Cleaning step 3 7 of 13 3 Puton protective gloves and eye wear 4 Spray disinfectant on the Carendo shower and toilet chair all removed parts Use a brush soaked in disinfectant and scrub thoroughly especially on handles and hand control 5 Rinse thoroughly with water approx 25 C 77 F until all the disinfectant has been removed 6 Soak a cloth in disinfectant and wipe all other areas such as chassis 7 Weta new cloth with water and remove all traces of disinfectant on other areas The cloth must occasionally be rinsed in running water when removing disinfectant Disinfection step 8 13 of 13 8 Spray disinfectant on the Carendo shower and toilet chair all removed parts 9 Soak a cloth in disinfectant and wipe all other areas such as chassis 10 Allow a disinfection time according to the instructions on the disinfectant bottle label 11 Spray or shower water approx 25 C 77 F and wipe with a clean cloth to remove all traces of the disinfectant The cloth should occasionally be rinsed in running water during removal of disinfectant 12 If disinfectant cannot be removed spray water on the affected part and wipe off with disposable towels Repeat until all of the disinfectant has been removed 13 Let
31. vement over the tub edge toilet bedpan or other furniture 9 Wash and shower the patient in this position See Fig 3 Continue with the steps on the next page 20 10 Adjust the height of the chair for a correct working posture during hair wash and pedicure See Fig 4 5 11 Dry the patient with a towel 12 Adjust the Carendo shower and toilet chair to a sitting position 13 Dry the back of the patient 14 Dress the upper part of the body and pull up the trousers to the knees See Fig 6 15 Activate the Care Raiser on the hand control 16 Put on the incontinence pads if used and pull up the trousers completely See Fig 7 17 Adjust the Carendo shower and toilet chair back to a sitting position and lower the chair Secure the patient with the safety belt if needed WARNING To avoid entrapment make sure to keep the patient s hair arms and feet close to the body and use designated grab supports during any movement 18 Release the brakes and start the transfer 21 Transfer to the Toilet Fig 1 Fig 2 A Vay s SN A 7 Fig 3 13 steps The Carendo shower and toilet chair can be used regardless of whether the toilet is attached to the wall or to the floor See the measurements below on matching toilet chairs min 5 5 in 16 9 in 430 min 140 13 7 in 350 11 4 in 290 min 5 5 in 140 16 9 in 430
32. y movement 13 Release the brakes and start the transfer 23 Home Care Use For Distributors and Renters When transporting the Carendo shower and toilet chair to the customer with a van e Make sure the lift is properly secured during transport e Avoid manoeuvring the Carendo shower and toilet chair in dirty ground when transporting it to and from the van No person is allowed to sit in the product during transport of the product in vehicles When delivering the Carendo shower and toilet chair make sure that e You read this ZFU together with the receiver including relatives and caregivers Show the features and intended usage described in the ZFU with help of the real product e The user has understood the cleaning and disinfection instructions e Read all the warnings to the receiver The environment fulfils all the requirements described in this ZFU Cleaning and disinfection e Make sure that the cleaning and disinfection procedure described in this FU always is carried out before the product reaches a new user Make sure that the cleaning and desinfection procedure described in this FU always is carried out before and after any type of service procedure 24 Using the Carendo Before using the Carendo shower and toilet chair in home environment make sure that See Fig 1 3 WARNING To avoid the device from tipping and the patient from falling do not use the equipmen
33. y and environmental information for the battery Data Label States technical performance and requirements e g Input Power Input Voltage and maximum Patient Weight etc Emergency States emergency information see Lowering section Emergency Lowering on Label page 14 Identification States the product identification Label serial number and year and month of manufacturing For example 1402XXXXX where 14 states manufacturing year 02 states manufacturing month and XXXXX states serial number Symbol explanation SWL Safe Working Load 4 Lifting stroke 550 mm 21 5 8 H 24V DC Supply voltage MAX 150VA Maximum power high low 150 VA Maximum power reclining 150 VA Fuse F1 T8AL 250 V Fuse F2 T6 3AL 250 V Fuse F3 T8AL 250 V IP X4 Protection class Protection against splashing water ED max 10 Mode of operation for Hi Lo function ED maximum 10 Maximum 2 minutes ON Minimum 18 minutes OFF 38 NEA0100 083 24 Vdc 2 5 Ah Product no of the battery Mandatory to read the Instructions for Use A battery is the power source of this equipment Separate electrical and electronic components for recycling in accordance with the European Directive 2002 96 EC WEEE Recognized by Underwriters Laboratories Inc with respect to electric shock fire mechanical hazards and other specified hazards only in accordance w
Download Pdf Manuals
Related Search