Artizan™ Ortho-Pedo Bench Installation / User Manual
Contents
1. 5 8 1 6 cm O D Note A full size pre installation floor template is available upon request Finished Floor e PB250 Ortho Pedo Bench Cabinet P N 003 2142 00 GA1003 em 3 72 A 1 i c d N J mt 1 Na COLD 14 a VACUUM WATER 120VAC 4 roD FMPT 20A 12 2 a abaa TIAN X C pS O i j 4 VA e Pl dA si E l E 8 8 E T 379 WARNING If applicable electrical box must be installed under cabinet as far from water bottle as possible GA1006 Installation PB 250 Step 1 Remove the Pedo Bench from shipping pallet A Remove cabinet drawers see Drawer Removal Installation and Adjustment in this manual B Accessing under the cabinet through false bottom cutouts use a 3 8 socket to remove lag screws securing base clips and cabinet to shipping pallet Note Be sure to save base clips and lag screws to use later in the installation process to secure the cabinet to the floor of the building Step 2 Securing the cabinet A Set cabinet in desired location over the utility provisions B Using a level as necessary unscrew the leg levelers using a flat head screwdriver through the hollow leg bolt in the bottom of the cabinet see Adjustable Camar Leg Leveler or by hand throu2. between doors and 1 16 between accents and doors Hinge 1 amp 2 Removal E Press button at point E at the back of the hinge and pull away from cabinet Hinge 1 amp 2 Adjustment Direction Guide GA1044 Cleaning Maintenance Casework Disinfecting Procedures for External Surfaces Attention Midmark assumes no responsibility or liability for any result expressed or implied These are suggested practices based on the best information available at this time Equipment Alert e Users should not use cleaning or decontamination methods different from those recommended by the manufacturer without first checking with the manufacturer that the proposed methods will not damage the equipment e Midmark s dental equipment is manufactured from the most chemical resistant materials available However no material is impervious to every chemical Using protective barriers is the most effective method to prevent equipment damage e Use only moist cloth with appropriate cleaner for cleaning casework Cleaning and Disinfectant Procedures Use cleaners and disinfectants that are appropriate for the situation such as warm water and mild detergents or an ammonia based cleaner NOTE Every dental practice is different and no single disinfectant is the best choice for every facility Listed below are some organizations to assist you in choosing the best disinfectants available for your prac
3. MIDMARIX Artizan Ortho Pedo Bench Installation User Manual Applies to Models PB250 L PB250 R Special Tools Level 3 8 Masonry drill bit 9 32 Wood drill bit Language of origin English di Note If applicable Midmark casework unit must be connected to a dedicated circuit with disconnect rated at 10A 115V 60HZ Failure to comply could result in an overload of the electrical circuit and or components All wiring including disconnect and plumbing must be installed by a licensed electrician or plumbing contractor following applicable local city and national codes Equipment Alert o Inspect all components for shipping damages concealed damage report must be filed with the carrier by the person receiving the goods within 15 days of delivery r Note Refer to cabinet mounted Procenter Delivery Unit User Guide 003 2196 00 for information on the delivery unit installed in the Ortho Pedo Bench ia GA1045 E Midmark Corporation 2010 Style A 1 003 2203 00 Rev D Important Information and Symbols These symbols may appear on your equipment and or in the manuals WARNING Indicates a potentially hazardous situation which could result in serious injury if not avoided Proper Shipping Orientation 2 Pressure Limits i Humidity Limit q Caution nee A Indicates a potentially hazardous situation which may result in mino
4. eratory components are designed and built to minimize Disposal of Equipment Consumable Goods electromagnetic interference with other devices however if interference is At the end of this products life the unit accessories and other consumable goods may noticed between another device and this operatory remove the interfering de be contaminated from normal use Consult local codes and vice from the room and or plug the product into an isolated circuit ordinates for proper disposal of this equipment and other consumables Midmark Corporation 2010 Style A 2 Floor Layout PB 250 a Note 1 2 1 3 cm NPT Have licensed electrical and plumbing contractors position and install electrical outlet receptacles and related 2 5 6 4 cm 2 5 6 4 cm plumbing using the pre installation template or layout Assure floor is of such construction that the unit will be ees a adequately supported and anchored If necessary contact a licensed contractor to reinforce the flooring _ min F Note Electrical box to be provided in field if required by particular delivery system If equipment being supplied with the pedo bench is a Midmark Procenter Ortho amp Pedo delivery system then this option will only be required if delivery is equipped with Fiber Optic Handpieces
5. gh the false bottom cutout until cabinet is level C Use the lag screws if floor is made of composites and base clips that were used to secure the cabinet to the shipping pallet and secure the cabinet to floor of the building If the floor is concrete then utilize supplied floor anchors Note To make installation easier and to prevent damage to area surrounding screw hole in floor drill pilot holes Use a 3 8 masonry drill bit for concrete and a 9 32 wood drill bit for composite flooring GA1022 O Adjustable Camar Leg Leveler Cabinet Height Adjustment A Utilize a flat head screwdriver and place down into hollow bolt in bottom of cabinet Turn screw driver clockwise to extend leg to floor and turn counterclockwise to adjust leg off of floor GA1046 WARNING Cabinet weighs approximately 188 pounds Lift with two people on the bottom edge of the cabinet Only lift the cabinet in designated locations after drawers have been removed See above illustration for proper lifting points a Base Clip Removal Installation GA1010 Step 3 Utilities A Attach appropriate plumbing such as cold water air vacuum etc refer to the Technical Reference Guide for routing information B If the pedo bench is equipped with Fiber Optic Handpieces electrical provisions must be made and connections must be made at this time C Feed handpieces syr
6. inges etc through grommet at the head of the cabinet and hang on the appropriate holder bars on the doctors and assistants doors Compression Shutoff Valve Regulator Compression Fitting Regulator __ REGULATOR Step 4 Insert regulator into compression fitting of shutoff valve and tighten compression fitting T Valve DA2232i Installation PB 250 GA1048 q Equipment Alert o When changing water bottle container be sure door is fully opened so that the bottle is not above any part of the cabinet so that water damage does not occur a Caution 4 lt is imperative that the location of the water bottle mounted inside the cabinet not be moved from the location at which it was installed from the factory Note If a water bottle is not provided be sure to close the air regulator valve Step 5 Install Bench Top A Set the Pedo Bench top on the cabinet and align the 4 attachment holes B Using the 1 4 20 X 2 P N S19153 screws provided fasten the top to the cabinet X4 Installation PB 250 GA1009 Installation PB 250 Step 6 False Bottoms A Unwrap false bottoms and install into bottom of the cabinet to cover access points GA1011 aa D Equipment Alert Maximum recommended weight for contents in drawers is 5lbs for medium 3 15 HGT drawer boxes and 10lbs for large 5 9 HGT drawe
7. nstalled to ensure the drawer sides meet square with the drawer front Only available on large drawer boxes 4 Side Adjustment Adjusts the drawer front horizontally Turn in either direction Tension Removal For large drawers turn the screw toward the front of the drawer until the front detaches from the box Repeat this procedure on both sides of the drawer For small and medium drawer boxes turn the screw toward the back of the drawer to remove the front Drawer Member Installation 5 A Line up the drawer member to the cabinet member and push the drawer into its compartment GA1105 Door Removal Installation and Adjustment a f Hinge 1 amp 2 Adjustments Hinge 1 amp 2 Installation 180 Hinge Adjustments Use a phillips head screw driver for the following steps F Hook the hinge to the mounting block at D Loosen screw D and adjust door gap A Screw A adjusts the door in direction A seen in the point F and angle using a level Tighten screw D Adjustment Direction Guide G Latch at point G by pressing the hinge when positioned correctly B Screw B adjusts the door in direction B Equal against the hinge block adjustment must be made to all hinges on the door for it to move the desired distance C Screw C adjusts the door in the C direction Make adjustments to top and bottom hinge as necessary Note Use a level to ensure the door is level and plumb Preferred gaps are approximately 1 8
8. r boxes A WARNING Maximum patient load must not exceed 68kg 150lbs Step 7 Doors and Drawers A Re install cabinet drawers see Drawer Removal Installation and Adjustment in this manual and make adjustments as needed B Adjust doors accordingly see Door Removal Installation and Adjustment in this manual Equipment Alert Be sure to adjust drawer adjustments to the down position before re installing drawers GA1049 Drawer Removal Installation and Adjustment Drawer Removal A Open drawer completely B Lift up on the drawer front until the front of the box releases from the glide C Pull out on the drawer slightly D Lower the drawer back down while pulling out on the drawer Drawer Installation A Fully extend drawer glides from the cabinet Optional B Place the drawer on the glides C Push the drawer in completely D Cycle drawer a couple times to ensure that the drawer is securely attached to the glides Full Extension Glide Removal amp Installation Removal A Extend the glide to its outermost position Push the release levers in and remove the drawer member of the sides Cabinet Member Drawer Front Adjustment and Removal 1 Remove the cover caps on the drawer side by hand 2 Height Adjustment Rotate in either direction to adjust the drawer front vertically 3 Tilt Adjustment Adjust after the drawer front is i
9. r or moderate injury if not avoided It may also be used to alert against unsafe practices T Keep Dry emperature Limit Equipment Alert o Indicates a potentially hazardous situation which could result in equipment damage if not avoided Type B Applied Part Consult User Guide Note Amplifies a procedure practice or condition AC Alternating Current No Stacking Contact Information a Max Patient Weight L Corrugated Recycle i g va Midmark Corporation 150lbs 68kg 150 Ibs T 115 G L Comer Road Glasgow Kentucky 42141 Phone 1 800 643 6275 ext 88015 Fax 270 651 1732 Specifications Intended Use e Approved for indoor use only The Midmark Artizan Ortho Pedo Bench can be used as the primary Pediatric workstation for performing pediatric dental procedures providing the needed Transportation Storage Operating Conditions storage and support at the essential delivery positions Midmark delivery Transportation Storage Temperature Range 0 F to 140 F 18 C to 60 C systems are intended to provide dental professionals with air water and suction Relitive 1101411 0 LA PP eee 10 to 90 Non Condensing to operate dental handpieces syringes and Midmark authorized accessories Atmospheric Pressure 7 2 PSI to 15 3 PSI 50 kPa to 106 kPa during dental examinations and procedures Operating Temperature Range 59 F to 95 F 15 C to 35 C Electromagnetic Interference Midmark dental op
10. tice e Organization for Safety amp Asepsis Procedures http Avww osap org e American Dental Association http www ada org e Dept of Health amp Human Resources Centers for Disease Control amp Prevention CDC http www cdc gov When using disinfectants Carefully read the product label and directions for use Do not exceed the dilution rate Read carefully Read carefully SS GA1083 Read all labels carefully GA1084 10 Midmark Corporation 2010 Style A fa A Midmark Corporation For additional contact information go to www midmark com Midmark Corporation 2010 Style A 11 MIDMARIK Because we care
Download Pdf Manuals
Related Search