G8 Cooler User Manual
Contents
1. dispenser For best results you can purchase a brush designed specifically for this purpose from your local appliance store This will improve cooling and efficiency Draining the Reservoirs Drain the reservoirs before and after cleaning when going on long vacations or if not using the dispenser for long periods of time IMPORTANT Unplug the dispenser before performing this procedure Dispense hot water until temperature drops to a safe level to avoid the risk of scalding 1 Press faucets until water no longer comes out 2 Place a bucket beneath the drain valve on the back of the dispenser 3 Remove the cap and plug from the drain valve and let the water flow into the bucket 4 Replace the cap and plug IMPORTANT Collect the water in a container not the drip tray Going Away on Vacation When not using the dispenser for long periods of time or when going on vacation con serve energy unplug the dispenser and drain the reservoirs see Draining the Reser voirs Follow Initial Product Cleaning Procedures upon return and startup of the dispenser 6 Kool Tek G8 Hot and Cold Water Cooler Manual TROUBLESHOOTING Possible Cause Suggested Solution Water Drain cap and silicone Ensure seal is secure in drain plug and dispenser is seal are not secure tighten cap leaking Water is not The unit is unplugged Plug into the outlet hot or cold enough The circuit breaker is Reset the breaker or replace the fuse tripped or a fuse is bl2. User Manual FG8 Hot and Cold Cooler cus LISTED www KoolTekCoolers com Please read the enclosed operating instructions carefully and retain this booklet for future reference We have carefully engineered your Water Dispenser to give you years of enjoyment and trouble free operation IMPORTANT SAFEGUARDS WARNING Unit must remain in upright stationary position for no less than 24 hours before operating e Never turn the dispenser upside down or tilt more than 45 degrees If the unit has been resting on its side for a long period of time place the water dispenser in the upright position for approximately 12 hours before turning it on e This water dispenser is equipped with a grounded power cord plug for your safety Keep your water dispenser in a dry place away from direct sunlight e Never put anything flammable close to the dispenser e Leave a minimum of 2 5 cm around the back and sides of the dispenser for proper ventilation e Always install your water dispenser on a level floor Wait 3 minutes before restarting machine after shutting it down Always unplug the water dispenser before servicing Regular cleaning of your water dispenser is required for your warranty Please follow the cleaning instructions outlined in this manual and clean the dispenser every 4 months GROUNDING INSTRUCTIONS Improper use of the grounding plug can result in a risk of electric shock causing serious injury even death This
3. appliance must be grounded In the event of an electrical short circuit grounding reduces the risk of electric shock by providing an escape wire for the electric current This appliance is equipped with a power cord having a grounding wire with a grounding plug and must be connected into a properly grounded polarized outlet Consult a qualified electrician if the grounding instructions are not completely understood or if doubt exists as to whether the appliance is properly grounded If the wall outlet is a standard 2 prong outlet it is your personal responsibility and obligation to have it replaced with a properly grounded 3 prong wall outlet Do not under any circumstances cut or remove the third ground prong from the power cord plug Do not use an adapter plug with this appliance e Do not use an extension cord with this appliance If the power cord is too short have a qualified electrician install an electrical outlet near the appliance 2 Kool Tek G8 Hot and Cold Water Cooler Manual PLUMBING GUIDELINES 1 Make sure cooler is upright for at least an hour before installation Ensure all pieces of the cooler are attached properly 2 Plug cooler into electrical outlet 3 Make sure hot tank switch is in the OFF position 4 Attach the 1 4 water line to the inlet port of the cooler 5 Turn water on and wait 5 minutes to allow tanks to fill 6 Once tanks have filled test each faucet to ensure steady stream 7 Turn on hot swit
4. ch 8 Check for leaks on all connections Kool Tek G8 Hot and Cold Water Cooler Manual 3 Switch functions for hot amp cold water Durable ABS top panel Durable ABS control panel coe Handle Water battler sm Type 304 stainless steel water cold reservior providing superior External copper refrigerant coil smunmmmnlll bam fsnmennnanne A Stai Adjustable cold thermostat Hot amp cold water functioning pilot lamps Drain valve ABS Front panelt fees Convection cooled condenser curved design to provide larger heat released area HOb Water E A Cold water tap Removable easily clean drip tray AN 3 Stainles steel left panel Stainless steel lower panel um Power cord has a grounded plug Durable ABS plastic absorbing base OPERATING INSTRUCTIONS Initial Product Cleaning Procedure Like most appliances your water dispenser requires periodic maintenance for maximum efficiency and performance and must be cleaned on a regular basis i e every 4 months To maintain a hygienic environment within your water dispenser and prevent potential formation growth of bacteria we strongly recommend regular cleaning 1 Make sure the power cord is unplugged 2 Mix 5 ounces of Hydrogen Peroxide into the cold tank Let sit for 30 minutes keeping cord unplugged 3 Place a jug container under the dispensing spigots and press both the hot and co
5. ld dis pensing buttons until the cleaning solution stops flowing Discard cleaning solution 4 Using a jug container drain the remaining cleaning solution from the internal reservoirs by unscrewing the drain cap and removing the drain plug from the drain valve located at the back of the unit Discard the cleaning solution 5 Re install the drain plug and drain cap on the unit and flush the system using 2L clean water only no cleaning solution following the same basic steps outlined above See step 3 Place jug container under drain valve and remove drain cap and drain plug al lowing rinse water to drain When the rinse water stops flowing re install the drain plug and drain cap and tighten The cleaning process is now complete 4 Kool Tek G8 Hot and Cold Water Cooler Manual Dispensing and Cold Water Place a glass under the dispensing spigot in the center of the water outlet panel For cold water hold faucet until the desired amount of water is dispensed and release For room temperature water press hold dispensing button 5 until the desired amount of water is dispensed and release Adjusting the Temperature Cold water only By turning the thermostat at the back of the unit the temperature can be adjusted by using a small flat screwdriver Turn the dial clockwise between the high cool and low colder levels until the desired temperature is reached If the water dispenser is not dispensing water there could be a possible ice bui
6. ld up due to the thermostat being set too cold If this happens unplug the dispenser overnight and then reset Set thermostat to a warmer setting slowly increasing based on your use and need for cold water Kool Tek G8 Hot and Cold Water Cooler Manual 5 CLEANING AND MAINTENANCE Like most appliances your water dispenser requires periodic maintenance for maxi mum efficiency and performance and must be cleaned on a regular basis i e every 4 months To maintain a hygienic environment within your water dispenser and prevent potential formation growth of bacteria we strongly recommend regular cleaning Cleaning the Outside of the Water Dispenser The outside of the dispenser can be wiped clean with clean solution or a mild soap and water mixture Never use harsh chemicals or abrasive cleaners Rinse thoroughly with clean water and then dry surfaces Cleaning the Drip Tray To remove the drip tray pull the tray forward dislodging it from the guides Drain and clean The drip tray should be emptied and cleaned regularly to remove spotting and any min eral deposits Clean with cleaning solution or a mild soap and water mixture For tough deposits add vinegar and let it soak until the deposits come loose Then wash rinse and dry thoroughly To replace put the grill back on the tray and slide the tray onto the guides not dishwasher safe Cleaning the Condenser Vacuum or sweep away the dust from the condenser coils at the back of the
7. own Temperature limit Allow the temperature of the hot tripped water tank to cool for approximately 15 30 minutes The tem perature limit thermostat will reset automatically once sufficiently cooled and the cooling system will reactivate automatically Thermostat needs to be Adjust thermostat between high cool adjusted colder and low colder levels to achieve desired temperature Water Mineral deposits clogging See Cleaning the Reservoirs dispenser is tanks not dispensing water Possible air pocket Push down on the dispenser buttons to prime the unit Slow or no water flow Inspect water tubing for kinks into cooler when using direct water hook up Unplug overnight then reset Adjust Possible ice build up due thermostat to high slowly increasing to thermostat set too based on desired use and need for high cold water Water Water dispenser is Make sure the dispenser is on an even dispenser is uneven surface that can support its weight noisy Kool Tek G8 Hot and Cold Water Cooler Manual 7 Kool Tek G8 Hot and Cold Water Cooler Manual
Download Pdf Manuals
Related Search