Heating System Manual
Contents
1. help you with any question so please do not hesitate to contact our customer service department SANTI sp z o o Tel 48 58 678 50 10 www store santidiving com ul Tadeusza Wendy 7 9 Fax 48 58 678 50 09 www santidiving com WTC Expo Area PL 81 341 Gdynia Poland 4 HEATING SYSTEM MANUAL Thermal protection The user is responsible for own thermal protection Isolation depends on the right undersuit and thermal underwear selection Lack of right thermal protection might cause thermoregulatory disorders The user must be aware of the risks of hyperthermia and hypothermia Thermal isolation and depth Thermal isolation is reduced due to hydrostatic pressure which is increasing with depth The user must be aware that thermal capacity of the product might be reduced Allergic reaction Every synthetic material might cause allergic reactions Before using the product please be aware of the potential risk of experiencing allergy towards the materials used in the construction of the product Fitting Correct fitting of the heated underwear gives much more comfort and satisfaction during use Fitting should be carried out when wearing suitable underwear and an appropriate undersuit Size should be based on the information in the size table Please follow the size chart respective for each specific product HEATING SYSTEM MANUAL 5 Paar e Read and follow the manual before use e Use only in dry suit while diving e Use with approp2. 40 C e 30 W power pair e Run time SANTI battery 6 Ah about 2 5h of heating 10 Ah battery about 4 hours of heating 20 Ah battery about 8 hours of heating e Made of breathable fabric e Keeps you warm even when the heating is off e Evenly distributed heating wiring that allows for freedom of movements in palms e Wires on fingers and outer side of palm e Waterproof plug compatible with other SANTI products e Works with power supply no higher than 12V HEATING SYSTEM MANUAL 11 Da Instruction for use e Connect the supplied wire to valve cable and put the gloves connecting cables into the sleeves e Let the wire ends out through the wrist seals mm 12 HEATING SYSTEM MANUAL e Conduct the cables of the gloves against your arms and to the connector and then connect the gloves e Put your drygloves on top of the heating gloves e Switch on the battery while in water e Make sure you note and follow all the warnings stated above Washing Instruction Hand or Machine wash in cold water at the temp of 40 C The gloves should be washed separately to avoid crowding in the machine and to maximize the cleaning action Warning Spinning is not recommended Cover and protect the plug while washing To dry lay the product flat or tumble dry using a delicate cycle very low temperature or air only HEATING SYSTEM MANUAL 13 7 SANTI Heated Vest Product type Diving Vest with electric heati
3. 5 hours of heating 10 Ah 2 2 5 hours of heating 20 Ah 4 5 hours of heating New more ergonomic nesting and wire layout inside Special vest bag included e Maximum heating temperature 45 C e Made of Thinsulate BZ200 210g m7 e Made of breathable fabric e Keeps you warm even when the heating is off e Safety switch preventing from overheating and too strong current e Evenly distributed heating wiring that allows for freedom of movements e Warms up the whole body corpus front and back e Extra pocket for the wire e Waterproof plug compatible with other SANTI products CE certified Sizes XS S M L XL XXL XXXL i 16 HEATING SYSTEM MANUAL Instruction for use e Put the vest on your thermal under wear and not directly on the naked body Wear it under your undersuit e Put the cable of the vest outside of your undersuit and connect it to a connector or thermovalve wire that will provide power from your battery e Make sure you note and follow all the warnings stated above Washing instruction Machine wash in cold water at the temp of 40 C Hand washing is not recommended since it is difficult to work the water into and through the vest to flush away dirt and it is also difficult to remove the water by hand without damaging the insulation and cables inside The vest should be washed separately to avoid crowding in the machine and to maximize the cleaning action Warning Spinning is not recommende
4. Heating System Manual Heated Undersuit Heated Vest Heated Gloves Our goal at SANTI is to keep the divers dry warm and comfortable in their diving equipment SANTI heated range was created to extend your diving time limits with the most innovative approach of keeping the warmth comfort at moderate level not to overheat you while diving but to keep your body temperature comfortable and safe for longer You will understand the difference when wearing it With SANTI heated range underneath your drysuit your diving can be longer and deeper than you could ever imagine without being cold Thank you for choosing SANTI Heating system These products provide better comfort for your diving Enjoy your diving Extend your limits and Stay Dry HEATING SYSTEM MANUAL 3 Pash General Information Manufacturer SANTI sp z 0 0 Tadeusza Wendy 7 9 81 341Gdynia POLAND WTC EXPO Industrial Area Please read the following manual carefully before using any product from the heated range and keep it for future reference The usage of diving equipment by untrained person may cause health damage and even life danger Along with an increase of depth the thickness of the insulating material may decrease due to hydrostatic pressure Effect of decreased thermal insulation may occur with increased depth The product should not be cleaned with solvents or strong detergents If any information or warning needs further explanation we are always available to
5. IGH CALF BODY TRUNK INNER LENGTH HEATING SYSTEM MANUAL 21 Fearn Technical info New generation of heating wire covered with ultra soft silicone isolation resistant to breaking Innovative synthetic power wire crust resistant to high temperatures and cuts New more ergonomic nesting and wire layout inside Special undersuit bag included e Maximum heating temperature 45 C e Heating power 110 W e Works with batteries 10 Ah battery about 1 2 1 5 hours of heating 20 Ah battery about 2 2 5 hours of heating e Works only with maximum 12V batteries Safety switch preventing from overheating and too strong current e Made of Thinsulate BZ400 420g m7 e Made of fully breathable materials e Keeps you warm even when the heating is off e Regularly distributed heating wiring that allows you freedom of movement e Warms up the whole body corpus thighs and arms e Extra pocket for the wire ends e Waterproof plug compatible with other SANTI products flexible and overheating resistant cables additional cables integrated to plug in the heating gloves in standard e P valve holes on both legs in standard e Napoleon pocket e Water resistant cuffs e Tapes which supply air to the dry gloves e Two way zip protected with a flap e CE certified el 22 HEATING SYSTEM MANUAL Washing instruction Machine wash in cold water at the temp of 40 C Hand washing is not recommended since it is difficult to work the water
6. aimed by the dealer where it was purchased SANTI heated products come with 12 month guarantee against defects in materials and workmanship The warranty does not cover damage due to abuse neglect improper usage lack of maintenance or normal wear and tear especially mechanical cut of the cables any change or modification made by the user or by the third parties use of incompatible accessories that are not part of SANTI product range SANTI shall not be responsible in any case for incidental or consequential damages without any limitation whatsoever to one or more persons resulting from non fulfillment of the obligations arising from this warranty when it comes to SANTI products If any defect covered by this limited warranty appears within 12 months from the date of purchase SANTI will repair exchange parts or replace the defective product Warranty repair can only be done at SANTI HQ service department Any changes or technical intrusion results in warranty loss This warranty is valid only if the enclosed warranty form is fully filled out with following information product name name of the authorized dealer product serial number product purchase date Serial number is stated on the inside label SANTI reserves the right not to carry out repairs under warranty if any original information is removed or modified on the product after the original date of purchase of the product from a dealer HEATING SYSTEM MANUAL 7 Fan Procedure of fo
7. d Cover and protect the plug while washing To dry lay the product flat or tumble dry using a delicate cycle very low temperature or air only HEATING SYSTEM MANUAL 17 men SANTI Heated Undersuit Product type Diving undersuit with electric heating EU Norm CE PN EN 14058 2007 PN EN 60945 2004 il 18 HEATING SYSTEM MANUAL Product Specification The SANTI innovative Heating undersuit is designed as a part of the complex heating system consisting of at least an undersuit thermovalve connector and an external battery canister This configuration allows a diver to wear the undersuit under the drysuit without additional valve and dangers associated with internal batteries The heating undersuit outer shell is made of abrasion and tear resistant polyester inside the Thinsulate 3M BZ 400 layer and micro fleece layer inside The Heating undersuit is designed to be worn over thin form fitting thermal wear It is not recommended to wear on in the naked body In this configuration the majority of the heat output is transferred directly on diver s torso back and thighs The breathable fabric allows the undersuit to heat and keep the warmth of your body and vapor the sweat if any The undersuit keeps you warm even when the batteries are low or completely drained The heated undersuit is adjusted to use together with heating gloves as a set It is equipped with integrated glove plugs in sleeves that might be covered or put out wh
8. en you use heated gloves in your diving set 16 sizes in standard men MTM Custom offer 12 sizes in standard ladies MTM Custom offer HEATING SYSTEM MANUAL 19 Paar Mens Undersuits Size Chart ARM LENGHT Measurement Size HEIGHT CHEST EE BICEPS FOREARM WAIST HIPS INNER LEG THIGH CALF BODY TRUNK XS 162 166 84 88 51 28 26 70 74 84 88 74 50 34 155 S 168 172 90 94 52 29 27 76 80 90 94 76 52 36 160 SL 174 178 92 96 53 30 27 78 82 92 96 80 52 38 165 M 172 176 96 100 53 32 28 82 86 96 100 79 55 39 165 ML 176 180 96 100 55 32 29 82 86 96 100 84 55 40 170 182 186 100 104 57 33 29 84 88 100 104 88 55 40 175 LS 172 176 106 110 52 35 30 92 96 106 110 79 62 43 165 L 180 184 106 110 54 35 29 92 96 106 110 83 60 41 170 LL 184 188 106 110 56 36 30 92 96 106 110 86 61 42 175 190 194 110 114 58 37 30 98 102 110 114 89 61 42 180 174 178 112 116 54 38 31 100 104 112 116 80 65 44 170 184 188 112 116 56 37 30 100 104 112 116 85 65 44 175 192 196 112 116 58 38 30 100 104 112 116 89 65 44 180 176 182 118 122 55 40 31 108 112 118 122 80 68 46 175 190 194 118 122 57 40 31 108 112 118 122 84 68 46 185 192 196 130 134 58 42 32 116 120 130 134 86 72 47 195 i 20 HEATING SYSTEM MANUAL Ladies Undersuits Size Chart ARM LENGHT Measurement Size HEIGHT CHEST BICEPS FOREARM WAIST HIPS INNER LEG TH
9. into and through the undersuit to flush away dirt and it is also difficult to remove the water by hand without damaging the insulation and cables inside The undersuit should be washed separately to avoid crowding in the machine and to maximize the cleaning action Warning Spinning is not recommended Cover and protect the plug while washing The plugs are water resistant To dry lay the product flat or tumble dry using a delicate cycle very low temperature or air only HEATING SYSTEM MANUAL 23 ga Possible combinations Heated Gloves Heated Vest a 24 Thermovalve Connector Battery 6Ah Manual Thermovalve Connector SANTI Battery 6Ah Thermovalve Connector Battery 6Ah Manual 25 i Heated Undersuit Heated Vest Heated Gloves Heated Undersuit Heated Gloves Heated Vest Heated Gloves Sy 26 HEATING SYSTEM MANUAL Possible combinations Thermovalve Connector 20Ah Battery 10Ah Battery HEATING SYSTEM MANUAL 27 Extend Your Limits SANTI sp z 0 0 Tadeusza Wendy 7 9 81 341Gdynia POLAND WTC EXPO Industrial Area store santidiving com santidiving com Ti 28 HEATING SYSTEM MANUAL
10. ng EU Norm CE PN EN 14058 2007 PN EN 60945 2004 il 14 HEATING SYSTEM MANUAL Product specification The Heating vest is designed as a part of the complex heating system consisting of a vest thermovalve connector and an external battery canister This configuration allows a diver to wear the vest under the drysuit without additional valve and dangers associated with internal batteries The heating vest outer shell is made of abrasion and tear resistant polyester inside the Thinsulate layer and micro fleece layer inside The Heating vest is designed to be worn over thin form fitting thermal underwear and under the diving undersuit In this configuration the majority of the heat output is transferred directly on divers torso and not on thick drysuit underwear The breathable fabric allows the vest to heat your torso and vapor the sweat if any 160 165 166 171 172 177 178 183 184 189 190 195 190 195 85 92 93 96 95 100 100 105 106 111 112 117 118 123 71 76 77 82 83 88 89 94 95 110 111 116 116 121 E 85 89 90 94 95599 100 105 106 111 112 117 118 123 HEATING SYSTEM MANUAL 15 Fan Technical info New generation of heating wire covered with ultra soft silicone isolation resistant to breaking Innovative synthetic power wire crust resistant to high temperatures and cuts Heating power of 55W Works with batteries 6 Ah SANTI battery 1 2 1
11. riate battery source only and never over 12 V e Charge with supplied charger only Protect the plug before washing washing machine allowed e The power must be switched off when out of the water e Switch off immediately when drysuit is flooded or when malfunction is suspected e Do not disassemble or modify the product and the cable e Do not combine with other heating sources if they are not compatible with the product e Be careful not to cross the cables against each other make sure they are not banded or folded while using e The cables need to be well stretched under your suit e Before each dive inspect thoroughly all electrical cords and connections If you notice any mechanical break or cut do not use the product for diving as this might cause serious injury Once you notice any damage to the cables contact service for repair or replacement of the broken parts e The product is equipped with the necessary wiring to allow the connection to the external power supply through valve connector or thermo valve i 6 HEATING SYSTEM MANUAL Limited Warranty for SANTI heating system products With this limited warranty certificate SANTI declares that the product is free from defects in fabrics components and craftsmanship at the time of the purchase Please read all warnings and safety instructions before use and keep the original sales proof This must be shown when repair should be covered by warranty The product needs to be cl
12. rvice department is on the dealer client side After warranty repair confirmation all other costs are on SANTI side e Warranty card available on cover page mei 8 HEATING SYSTEM MANUAL Diving is potentially hazardous sport Before using any diving equipment you should be properly trained in the use of the equipment by a recognized club or organization Before each dive inspect thoroughly all the electrical cords and cables and make sure they are not damaged cut or broken in any place If you notice any mechanical break or cut do not use the product for diving as this might cause serious problems and injury Once you notice any damage to the cables contact SANTI service department for repair or replacement of the broken parts as soon as possible HEATING SYSTEM MANUAL 9 Forli SANTI Heated Gloves Product type Diving gloves with electric heating i 10 HEATING SYSTEM MANUAL EU Norm CE PN EN 14058 2007 PN EN 60945 2004 PN EN 420 Product specification The Heating gloves are designed as a part of the complex heating system consisting of the gloves thermo valve connector and an external battery canister This configuration allows a diver to wear the gloves under the dry gloves without additional valve and dangers associated with internal batteries MeasuremenvwvSize XS S M L XL XXL The product should be chosen according to the SANTI size chart above Technical info e Maximum heating temperature
13. rwarding the claims e To forward a claim covered by this warranty the buyer has to directly notify the dealer where the product was purchased with regards to the defect presenting at the same time the defective product a copy of the sales receipt and the Warranty registration form duly filled out as instructed above e Prior to contacting the dealer we recommend that you carefully read the user manual enclosed with the product After 12 months from the date of purchase this limited warranty is void for all effects and purposes e Repairs or maintenance under warranty do not extend the period of the warranty itself Therefore in case the product or one of its components is replaced this does not initiate a new warranty period as the purchase date of the original product shall be taken into account for warranty purposes e SANTI reserves at any time the right to modify without advance notice the product characteristics or functions Only for repairs or replacement of electric components in the event that SANTI proceeds to repairing or replacing the product said product shall enjoy a warranty period equal to the residual portion of the original warranty or ninety 90 days from the repair date the longer period being considered e This warranty does not affect the consumers rights provided by the law or the rights to which the buyer is entitled and which are expressly provided for by Directive 1999 44 CE e The cost of shipping to SANTI Se
Download Pdf Manuals
Related Search