CARWASH - Bieffe
Contents
1. User s Manual Pz 1 In case of a mismatch you must immediately inform Bieffe srl For any contact with Bieffe srl with its service centers or dealers please refer to the type of machine serial number eg Mod CARWASH Cod BF310 n serial applied to the back of the machine CAUTION DO NOT REMOVE SAFETY DEVICE AND PROTECTIVE COVER BEFORE MAINTENANCE AND SERVICE MAKE SURE THAT APLLIANCE IS UNPLUGGED FROM ELECTRIC OUTLET AND BOILER IS COOL AND NOT UNDER PRESSURE CONSUMER NOTICE The BIEFFE product you have purchased is subject to Directive 2002 96 EC of the Euro pean Parliament and the Council of the European Union on waste electrical and electronic equipment WEEE and in jurisdictions adopting that Directive is marked as being put on the market after August 13 2005 and should not be disposed of as unsorted municipal waste Please utilize your local WEEE collection facilities in the disposition of this product and otherwise observe all applicable requirements 11 OPERATING AND SAFETY INSTRUCTIONS e After the removal of the package make sure of the appliance s integrity In case of doubt do not operate the appliance but take it to a qualified service person for examination and repair Plastic bags polystyrene etc must be kept out of the children s reach e Before connecting appliance make sure that data on the plate are the same as the power supply network The voltage appliance is of 230V monophasic with a2. If the boiler is empty a pump starts to load the boiler with water from the tank 5 e When the boiler is full and the pump does not work you can turn on the second heater switch 23 to get a better and long lasting steam performance DO NOT RUN THE SECOND resistance when the boiler is not FULL e Wait until the steam ready lamp 24 is active and or the pressure gauge 25 reaches 4 ATM to start working e To get steam with the steam gun 13 check that the tap 14 is open Press the button on the gun e To get steam with the Pratika Handle turn the lever 26 left to the steam position and press the lever 15 e To dispense hot water with the tube Pratika turn the lever 26 right to the hot turn on the switch 27 on the control panel and press the lever 15 e On Pratika handle press the switch 16 to operate the exhauster e For a good job you should loosen the dirt with steam and hot water Then suck the debris All the dirt will go into the steel drum Legenda Steel drum Cover floatholder Vacuum hose Gun support Boiler tank Hot water tank Vacuum inlet Vacuum outlet Steam water inlet 10 Steam water outlet 11 Draining tap 12 Power cord 13 Steam gun 14 Steam gun tap 15 Steam water lever 16 Vacuum switch OmMANDNMNFWNE 21 Safety cap 22 General power switch 23 I heater switch 24 Steam ready lamp 25 Pressure gauge 26 Steam water lever 27 Water switch 28 Vacuum switch 31 Flex hose inlet
3. 32 Hot air outlet 33 Flex hose terminal 34 Ozone outlet 35 Ozone timer Cod CVK21 Pratika Handle inject extrac 4mt Control Board
4. CARWASH Steam generator for cleaning and sanitizing the interior of vehicles PATENTNBO2005A 000507 BIES gt E FARINELLI GENERATORI DI VAPORE Bieffe Srl Via Levato 1 1 1 3 61100 Pesaro Tel 0039 0721281857 Fax 0039 0721281880 www bieffeitalia it info bieffeitalia it We have been creating and manufacturing steam generators and ironing boards for more than 20 years We apply our knowledge and experience to several fields sewing household catering cosmetics etc Mr Farinelli thanks you Sa SS BIESSE eS FARINELLI GENERATORI DI VAPORE td f f ET ae I aak MADE IN ITALY BIEFFE Company manufactures the whole range of its products Information descriptions and illustrations contained in this manual are not binding in Pesaro using components made in Italy as well as entirely recyclable materials BIEFFE maintains the right to introduce any necessary change Sept 2012 12 BEFORE USE At delivery The machine CARWASH cod BF310 is packed together with its standard accessories in a single carton box Upon receipt of the goods check that the package is intact and not damaged Verify that the product label on the side of the box and the contents of the package correspond with the quality and quantity as indicated in the delivery note Package contents Machine body complete with trolley and basket Pz 1 Steel drum Pz 1 Cover steel drum complete with floating Pz 1 Standard accessories Pz 14
5. MGLS for CVG1 PVC brush D 20 Bristles brush D 20 for MGK04 for MGK04 Cod MGK04 Konfort steam lance Cod CVG1 For steam gun Insert holder inject extrac 150mm Cod CVK32 Seat dry bag j w _ Cod CVK10 cee Flex hose hot air ane een Cod CVK55 3 5mt Bottles holder SETTING UP e Place the stell drum 1 in its housing on the machine Close the steel drum with the cover floatholder 2 lock the cover with the two hooks e Insert the vacuum hose 3 into the cover 2 Insert the gun support 4 in its housing on the handle e Open the door on the back of the machine Fill the tanks 5 and 6 of water WARNING DO NOT USE DISTILLED WATER The WATER SENSORS DO NOT WORK with water free of minerals Make sure that the charging hoses are in their tanks in contact with water Close the door If one of the tanks is empty or one of the tubes is not in contact with water the machine does not work Connect the injection extraction Pratika handle cod CVK21 to the machine Insert the vacuum inlet 7 to the vacuum outlet 8 Insert the steam water inlet 9 to the steam water outlet 10 Before plugging into groud outlet make sure that the draining tap 11 and the safety cap 21 are closed and all switches are off The general switch 22 must be set on o e Connect the power cord 12 to an electrical outlet INSTRUCTIONS INJECTION EXTRACTION e Turn the power switch 22 the 2
6. afety cap to let the boiler depressurize e Do not remove safety device and protective cover e Do not service while appliance operates e Before servicing make sure that appliance is unplugged from electrical outlet e The non observance of the above OPERATING AND SAFETY INSTRUCTIONS could prejudice safety Have a good job MACHINE DETAILS Features Continuous steam Hot water 40 Hot air 70 Hot air seats to 50 Automatic recharge Ozonization Protective equipment Non return valve applied to the output of the steam outlet Protective guard on the safety cap 2 thermostats and 1 pressurestat for the safety of the boiler Safety thermostat of hot air Protection thermostat pump Floating protection rof vacuum motor Audible signal for low water TECHNICAL DATA Power 230 220V 50 60 Hz only for BF310 and BF310Z 380V 50 60 Hz only for BF310PL and BF310PLZ Boiler 3lt Boiler power 1000W 1000W 1000W Pressure switch SBAR Vacuum power 1400W Hot air power 1400W Fusto inox 20LT Water tanks 10LT 10LT Ozonization only for BF310Z and BF310PLZ Weight 55KG Carton box dimensions 83x59xh95cm TROUBLESHOOTING For any different anomaly not included in the enclosed list get in touch with the after sale service centre ANOMALY CAUSE ACTION No steam comes from the steam gun 13 The safety tap 13 is closed Turn the tap to open position No pressure in the boiler Wait for the
7. gauge to at least 4BAR the steam valve in the handle is broken Get in touch with a customer service center No steam comes from the gun Pratika CVK21 No pressure in the boiler Wait for the gauge to at least 4BAR the steam valve in the handle is broken Get in touch with a customer service center From the steam gun 13 steam is released without pressing the button the steam valve in the handle is broken Close the safety tap 14 and get in touch with a customer service center Tthe vacuum engine changes noise or begins to vibrate Water in stainless steel 1 exceeds the maximum level Turn off the machine and empty the steel drum 1 No water flows from the drain valve under the car The tap is blocked by limestone Insert a screwdriver into the tap to free it from impurities Leaks in the spine steam water 9 Water steam inlet badly inserted Place and lock the steam water inlet O ring seals consumed Replace the O ring Activating the switch 16 on the gun the engine vacuum will not turn on Water steam inlet badly inserted Place and lock the steam water inlet No hot air comes out thermostat is out of work Get in touch with a customer service center INSTRUCTIONS DRY SEAT e Cover the seat with the seat dry bag CVK32 e Insert the inlet 31 of the flex hose hot air CVK10 in the hot air outlet 32 e Turn the power swi
8. plug of 16A T e Plug appliance into grounded outlet of sufficient power as provided for by the safety regu lations in force e Do not touch appliance with wet or damp hands e Always disconnect appliance from electrical outlet when not in use e This appliance is only and exclusively for its intended use so the manufacturer can not be held responsible for any probable damage due to an illegitimate use e Never unscrew the safety valve cap during use e Before cleaning and maintenance make sure that appliance is disconnected from outlet Do not wash the appliance do not immerse in water Before filling the boiler make sure that appliance is unplugged e In case of failure or operational defect turn off appliance disconnect from electrical outlet Do not disassemble or attempt to repair the appliance Incorrect re assembly or repair could cause a risk of fire electric shock or injury to persons when the appliance is used Any repair must be executed by qualified service persons authorized by the manufacturer Ask for exclusive use of original spare parts e Installation must be executed according to manufacturer s instructions space for ventila tion room temperature e Do not operate appliance with damaged cord or hose but let it made replaced e Turn off the two boiler switches and unplug the boiler when finished operating It is not necessary to empty the boiler of remaining water it is important to unscrew for only 1 turn the s
9. tch 22 to position 1 e Insert the terminal 33 in the bag CVK32 e Turn on the switch 28 to operate the hot air or turn on the switch 15 on the Pratika handle CVK21 INSTRUCTIONS DETERGENT NEBULIZATION WITH HOT AIR e The detergent nebulization with hot air is the best way to cleanse the tissues before being washed with hot water and steam e Insert the inlet 31 of the flex hose hot air CVK10 in the hot air outlet 32 Cod CVK10 e Turn the power switch 22 to position 1 Flex hose for hot air e Fill the air nebulizer CVK53 with a detergent solution 3 5mt e Insert the terminal 33 in the air nebulizer CVK53 e Turn on the switch 28 to operate the hot air or turn on the switch 15 on the Pratika handle CVK21 e Allow the cleaning agent to work on the fabrics before washing with hot water and steam Cod CVK53 Air nebulizer INSTRUCTIONS OZONATION e Insert the inlet 31 of the flex hose hot air CVK10 in the ozone outlet 34 e Turn the power switch 22 to position 1 e Insert the terminal 33 inside the car e Turn the timer ozone 35 depending on the size of the car STANDARD ACCESSORIES Cod CVK21 Cod CVK20 Cod CVAC Pratika Handle Pratika nozzle Nozzle Chewing gum inject extrac 4mt inject extrac inject extrac for CVG1 Cod CVC Extraction nozzle 140mm Cod CVE Extraction lance fe Cod CVG3 kN PVC insert 4 Cod CVG2 Rubber insert Cod MGL Cod
Download Pdf Manuals
Related Search