MC ASN-GW Installation Manual, Ver.2.5.2
Contents
1. Installing the Mini Centralized ASN GW Unit Installing in an Indoor Rack AW T lt 2 0m CONNECTION DIAGRAM PIN NO COLOR AT WHITE A2 BLACK AS SHILD GREEN YELLOW Item Description 1 Cable 3X16 AWG Black or Gray 2 Connector Mixed D Type Female 3 Contact High Power Socket 4 Hood YI 5 Shrink Tube 6 Shrink Tube 7 Terminal Ring 7 8 Labe 9 Label 10 Label 11 Label GND IASLEUCTIONS Cover all solder point with shrink tube Figure 4 Power Cable Installing the Mini Centralized ASN GW Unit Installing in an Indoor Rack The location of the indoor equipment should take into account its connection to the power source and to the base station networking equipment To install the Mini Centralized ASN GW Unit in an indoor rack 1 Place the unit on a shelf desk or install it in a 19 cabinet For installation ina 21 cabinet attach suitable ETSI rack adapters to the chassis Connect one end of a grounding cable to the grounding screw located on the rear panel of the unit marked and firmly tighten the grounding screw Connect the opposite end of the grounding cable to a groun2. Alvarion Ltd shall not be liable for errors contained herein or for incidental or consequential damages in connection with the furnishing performance or use of this manual or equipment supplied with it Warranties and Disclaimers All Alvarion Ltd Alvarion products purchased from Alvarion or through any of Alvarion s authorized resellers are subject to the following warranty and product liability terms and conditions Exclusive Warranty a Alvarion warrants that the Product hardware it supplies and the tangible media on which any software is installed under normal use and conditions will be free from significant defects in materials and workmanship for a period of fourteen 14 months from the date of shipment of a given Product to Purchaser the Warranty Period Alvarion will at its sole option and as Purchaser s sole Mini Centralized ASN GW o Installation Manual Legal Rights remedy repair or replace any defective Product in accordance with Alvarion standard R amp R procedure b With respect to the Firmware Alvarion warrants the correct functionality according to the attached documentation for a period of fourteen 14 month from invoice date the Warranty Period During the Warranty Period Alvarion may release to its Customers firmware updates which include additional performance improvements and or bug fixes upon availability the Warranty Bug fixes temporary patches and or workarounds may be supplied
3. No part of its contents may be used for any other purpose disclosed to any person or firm or reproduced by any means electronic and mechanical without the express prior written permission of Alvarion Ltd The text and graphics are for the purpose of illustration and reference only The specifications on which they are based are subject to change without notice The software described in this document is furnished under a license The software may be used or copied only in accordance with the terms of that license Information in this document is subject to change without notice Corporate and individual names and data used in examples herein are fictitious unless otherwise noted Alvarion Ltd reserves the right to alter the equipment specifications and descriptions in this publication without prior notice No part of this publication shall be deemed to be part of any contract or warranty unless specifically incorporated by reference into such contract or warranty The information contained herein is merely descriptive in nature and does not constitute an offer for the sale of the product described herein Any changes or modifications of equipment including opening of the equipment not expressly approved by Alvarion Ltd will void equipment warranty and any repair thereafter shall be charged for It could also void the user s authority to operate the equipment Installation Manual Contents Contents 1 Mini Central
4. Off no traffic 4 3 LEDs Table 3 Mini Centralized ASN GW Unit LEDs Name Description Functionality PWR Power indication E Off Unit is not powered E Red Input power failure E Green Unit power is OK ALRM Alarm indication E Off No alarm E Red Unit failure E Blinking Red Unit powers up E E Mini Centralized ASN GW Port Integrity Green Ethernet PHY layer connectivity is OK M Off Ethernet not connected Installation Manual Preparing a DC Power Cable LEDs 5 Preparing a DC Power Cable The unit is supplied with a 2 5m DC power cable Additional DC cables can be ordered from Alvarion If necessary use the following instructions to prepare a DC cable gt To prepare the power cable 1 Usea cable capable of supporting a current of at least 2A Use a cable with 3 x 16AWG or thicker wires for the power and an additional 16AWG ground wire The matching power connector to be used is D type power with high power socket contacts 2 Connect the wires to the power connector as follows Pin 1 RTN White 2 AWG min wire Pin 2 48V Black 2 AWG min wire Pin 3 Ground shield green yellow 16AWG wire 3 Attach suitable terminal rings to the side that connects to the power source Not applicable to installation in an outdoor cabinet Mini Centralized ASN GW Installation Manual E
5. RONMENTS REQUIRING FAIL SAFE PERFORMANCE SUCH AS IN THE OPERATION OF NUCLEAR FACILITIES AIRCRAFT NAVIGATION OR COMMUNICATION SYSTEMS AIR TRAFFIC CONTROL LIFE SUPPORT MACHINES WEAPONS SYSTEMS OR OTHER APPLICATIONS REPRESENTING A SIMILAR DEGREE OF POTENTIAL HAZARD ALVARION SPECIFICALLY DISCLAIMS ANY EXPRESS OR IMPLIED WARRANTY OF FITNESS FOR HIGH RISK ACTIVITIES Mini Centralized ASN GW Installation Manual Legal Rights b PURCHASER S SOLE REMEDY FOR BREACH OF THE EXPRESS WARRANTIES ABOVE SHALL BE REPLACEMENT OR REFUND OF THE PURCHASE PRICE AS SPECIFIED ABOVE AT ALVARION S OPTION TO THE FULLEST EXTENT ALLOWED BY LAW THE WARRANTIES AND REMEDIES SET FORTH IN THIS AGREEMENT ARE EXCLUSIVE AND IN LIEU OF ALL OTHER WARRANTIES OR CONDITIONS EXPRESS OR IMPLIED EITHER IN FACT OR BY OPERATION OF LAW STATUTORY OR OTHERWISE INCLUDING BUT NOT LIMITED TO WARRANTIES TERMS OR CONDITIONS OF MERCHANTABILITY FITNESS FOR A PARTICULAR PURPOSE SATISFACTORY QUALITY CORRESPONDENCE WITH DESCRIPTION NON INFRINGEMENT AND ACCURACY OF INFORMATION GENERATED ALL OF WHICH ARE EXPRESSLY DISCLAIMED ALVARION WARRANTIES HEREIN RUN ONLY TO PURCHASER AND ARE NOT EXTENDED TO ANY THIRD PARTIES ALVARION NEITHER ASSUMES NOR AUTHORIZES ANY OTHER PERSON TO ASSUME FOR IT ANY OTHER LIABILITY IN CONNECTION WITH THE SALE INSTALLATION MAINTENANCE OR USE OF ITS PRODUCTS Limitation of Liability a ALVARION SHALL NOT BE LIABLE TO THE PURCHASER OR TO ANY THIRD PA
6. RTY FOR ANY LOSS OF PROFITS LOSS OF USE INTERRUPTION OF BUSINESS OR FOR ANY INDIRECT SPECIAL INCIDENTAL PUNITIVE OR CONSEQUENTIAL DAMAGES OF ANY KIND WHETHER ARISING UNDER BREACH OF CONTRACT TORT INCLUDING NEGLIGENCE STRICT LIABILITY OR OTHERWISE AND WHETHER BASED ON THIS AGREEMENT OR OTHERWISE EVEN IF ADVISED OF THE POSSIBILITY OF SUCH DAMAGES b TO THE EXTENT PERMITTED BY APPLICABLE LAW IN NO EVENT SHALL THE LIABILITY FOR DAMAGES HEREUNDER OF ALVARION OR ITS EMPLOYEES OR AGENTS EXCEED THE PURCHASE PRICE PAID FOR THE PRODUCT BY PURCHASER NOR SHALL THE AGGREGATE LIABILITY FOR DAMAGES TO ALL PARTIES REGARDING ANY PRODUCT EXCEED THE PURCHASE PRICE PAID FOR THAT PRODUCT BY THAT PARTY EXCEPT IN THE CASE OF A BREACH OF A PARTY S CONFIDENTIALITY OBLIGATIONS Disposal of Electronic and Electrical Waste Disposal of Electronic and Electrical Waste X Pursuant to the WEEE EU Directive electronic and electrical waste must not be disposed of with unsorted waste Please contact your local recycling authority for disposal of this product Mini Centralized ASN GW Installation Manual Important Notice Important Notice This user manual is delivered subject to the following conditions and restrictions Mini Centralized ASN GW This manual contains proprietary information belonging to Alvarion Ltd Such information is supplied solely for the purpose of assisting properly authorized users of the respective Alvarion products
7. as Firmware updates Additional hardware if required to install or use Firmware updates must be purchased by the Customer Alvarion will be obligated to support solely the two 2 most recent Software major releases ALVARION SHALL NOT BE LIABLE UNDER THIS WARRANTY IF ITS TESTING AND EXAMINATION DISCLOSE THAT THE ALLEGED DEFECT IN THE PRODUCT DOES NOT EXIST OR WAS CAUSED BY PURCHASER S OR ANY THIRD PERSON S MISUSE NEGLIGENCE IMPROPER INSTALLATION OR IMPROPER TESTING UNAUTHORIZED ATTEMPTS TO REPAIR OR ANY OTHER CAUSE BEYOND THE RANGE OF THE INTENDED USE OR BY ACCIDENT FIRE LIGHTNING OR OTHER HAZARD Disclaimer a The Software is sold on an AS IS basis Alvarion its affiliates or its licensors MAKE NO WARRANTIES WHATSOEVER WHETHER EXPRESS OR IMPLIED WITH RESPECT TO THE SOFTWARE AND THE ACCOMPANYING DOCUMENTATION ALVARION SPECIFICALLY DISCLAIMS ALL IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE AND NON INFRINGEMENT WITH RESPECT TO THE SOFTWARE UNITS OF PRODUCT INCLUDING ALL THE SOFTWARE DELIVERED TO PURCHASER HEREUNDER ARE NOT FAULT TOLERANT AND ARE NOT DESIGNED MANUFACTURED OR INTENDED FOR USE OR RESALE IN APPLICATIONS WHERE THE FAILURE MALFUNCTION OR INACCURACY OF PRODUCTS CARRIES A RISK OF DEATH OR BODILY INJURY OR SEVERE PHYSICAL OR ENVIRONMENTAL DAMAGE HIGH RISK ACTIVITIES HIGH RISK ACTIVITIES MAY INCLUDE BUT ARE NOT LIMITED TO USE AS PART OF ON LINE CONTROL SYSTEMS IN HAZARDOUS ENVI
8. d earth connection or to the cabinet if applicable Connect the DATA port to the backbone data equipment use a straight Ethernet cable to connect to the provider s core network The maximum length of the Ethernet cable is 100m Mini Centralized ASN GW Installation Manual Installing the Mini Centralized ASN GW Unit Installing the MC ASN GW in an Outdoor Cabinet 4 Ifthe MGMT port will be used for remote management connect it to the appropriate data equipment use a straight Ethernet cable to connect to a hub switch router The maximum length of the Ethernet cable is 100m 5 Connect the power cord to the unit s DC socket located on the rear panel Connect the other end of the power cord to the 48 VDC power source NOTE x The color codes of the power cable are as follows Brown Phase da Blue Neutral 0 Yellow Green Ground L 6 Configure basic parameters using the Monitor program Refer to the Commissioning section in the System Manual 6 2 Installing the MC ASN GW in an Outdoor Cabinet The BreezeMAX Extreme and Macro Outdoor BTS outdoor solutions require the MC ASN GW to be outdoor gt To install the Mini Centralized ASN GW Unit in an Outdoor cabinet 1 To gain access for connecting the ASN GW power cable unlock the Smartpack controller in the top section of the cabinet and temporarily slide the controller out see Figure 5 _ Smartoack controller ii Battery Fuses ca Load MIC Bs irnigac
9. e rectifiere Figure 5 Front View of Outdoor Cabinet Top Section 2 Connect the three ends of the ASN power cable to power shelf as follows see Figure 6 Ground green yellow to DC Earth white to Common DC Output black to Common DC Output Mini Centralized ASN GW Installation Manual Installing the Mini Centralized ASN GW Unit Plastic Protective Covertol CANI AC Terminals Cable Fastening Plate s5 pin 1 AC Mains AC bins amp Earth PE Terminal Installing the MC ASN GW in an Outdoor Cabinet CAN bus communication with rectifier to Siwantgach rear CONS A Barintemal connections to Smarmtpack rear L vBD latching contactor Lv D latching contactor optional DC Earth XA Exchange Ground EG or system ground Link connected to chasse MEA Common DC Output Load terminal block HA Battery connections f j a n Common Battery Load terminal block all Y eee FbI Fb2 L Battery connections MBB nin 1 EES E Location of DC Output i Il Smarstpackcontraller Foward sliding drawer shelf Virigach Reotifier Figure 6 Top View of Outdoor Cabinet 3 Return the Minipack controller and lock it in its location 4 Insert the MC ASN GW into its location in the cabinet fasten the screws at both sides of the 19 cabinet rails 5 Connect the power connector to the unit s DC socket locat
10. ed at the rear panel 6 Connect the DATA port to the backbone data equipment in the cabinet use a straight Ethernet cable to connect to the provider s core network 7 If the MGMT port will be used for remote management connect it to the appropriate data equipment use a straight Ethernet cable to connect toa hub switch router 8 Make sure the breakers are off down and turn on the power to the shelf 9 Switch on the breakers and check that there is no short circuit 10 Check the ASN LEDs to verify correct operation 11 Configure basic parameters using the Monitor program Refer to the Commissioning section in the System Manual Mini Centralized ASN GW Installation Manual
11. ezeMAX Extreme systems while operating concurrently with integrated ASN GW instances Fn ENI Pe ESI n BUA ae z STA x T ora a CAST HI TETH x gt tael AA a ET 9 PASTORE EI waa DE Je X We La R et ae Vo sa A wie ae Leas gh be h es f y To A Milia li rasa a a A ai Sie ia i Ai ee a sro mimi wes Pe aA z ete ne h ra CESSO tt TE POI tar ES i Li Pa a ce ed alin ZL ll lt ee al Figure 1 Mini Centralized ASN GW aam a e a S i TEEN REESE ee E 2 PET erare ross p7 eS See ee A ei ae ces h x N Sl a ie n T hai Au pi p k Lia VET pA a i a a e a A ees ee hs el Da 2 Mechanical and Electrical specifications Table 1 1 Mechanical amp Electrical Specifications Item Description Dimensions 1U high ETSI type shelf 1U x 43 2 x 45 cm Weight 2 67 Kg Power Source 36 to 60 VDC typical 48 VDC Power Consumption 100W maximum Installation Requirements 3 1 Packing List MW Mini Centralized ASN GW Unit E DC power cable 2 5m Mini Centralized ASN GW Installation Manual Mechanical Interface Additional Installation Requirements M Monitor cable 3 2 Additional Installation Requirements MW Ethernet cable straight for connecting the unit to the backbone network E A grounding cable with appropriate terminations for connecting the unit s ground terminal to the rack or to a ground connection E For insta
12. ized ASN GW OVErVIEW ssssssrrrrrrrrrrrrrrrrereesesssrsresrrrrnne 1 2 Mechanical and Electrical Specifications i i ir AA 1 Si AC ING furia 1 3 2 Additional Installation Requirements iii 2 II iii 2 4 COMES 2 4 2 UM RESO o aiar 3 AS EEDS aE EE E E EEO 3 5 Preparing a DC Power Cable ria ra 4 6 Installing the Mini Centralized ASN GW UNIt eee eeeeeeeeeees 5 6 1 Installing in an Indoor Rack i 5 6 2 Installing the MC ASN GW in an Outdoor Cabinet i 6 Mini Centralized ASN GW Installation Manual Mini Centralized ASN GW Overview Packing List l Mini Centralized ASN GW Overview The Mini Centralized ASN GW provides ASN GW functions in a small package simplifying implementation of various deployment scenarios where a single ASN GW serves several BTSs Specifically it targets high speed transport locations which wouldn t normally host BTSs allowing optimal flexible and scalable network design significantly raising traffic bandwidth and reducing CAPEX and OPEX In future releases the Mini Centralized ASN GW will support stackable solution with additional features such as load balancing and various redundancy configurations The stand alone ASN GW is a 1U ETSI unit that can be installed in a standard 19 cabinet It may complement both indoor and outdoor BTS systems i e BreezeMAX 4Motion Indoor and Outdoor systems and Bre
13. llation in a 21 ETSI rack two 21 ETSI rack adapters available from Alvarion E For installation in an outdoor cabinet data equipment installed in the cabinet E A portable PC for configuring parameters using the Monitor cable M Installation tools and materials 4 Mechanical Interface 4 1 Connectors LEDs Power DATA Management Cascade Reset button Monitor and ALRM Figure 2 Mini Centralized ASN GW Unit Front Panel Power connection Figure 3 Mini Centralized ASN GW Unit Rare Panel Mini Centralized ASN GW O Installation Manual Mechanical Interface Unit Reset Table 2 Mini Centralized ASN GW Unit Connectors Name Connector Functionality DATA 10 100 1000 Mbps channel Connection to the backbone RJ 45 shielded connector with 2 embedded LEDs MGMT 10 100Base T RJ 45 shielded Connection to out of band management connector with 2 embedded LEDs CSCD 10 100 1000 Mbps channel Connection to local management and to RJ 45shielded connector with cascaded ASN GW future option 2 embedded LEDs MON RS 232 interface Access for debugging and configuration Power rear panel D type Connection to DC power 4 2 Unit Reset Press the Reset button for a few seconds to perform hardware reboot The unit will reset to the latest saved configuration MGMT DATA CSCD LEDs on the RJ 45 connectors Port Activity Blinking Yellow Ethernet traffic activity
14. seen alvarionN Your Open WiMAX Choice Mini Centralized ASN GW Installation Manual Software Version 2 5 2 December 2009 P N 215486 Legal Rights Legal Rights Copyright 2009 Alvarion Ltd All rights reserved The material contained herein is proprietary privileged and confidential and owned by Alvarion or its third party licensors No disclosure thereof shall be made to third parties without the express written permission of Alvarion Ltd Alvarion Ltd reserves the right to alter the equipment specifications and descriptions in this publication without prior notice No part of this publication shall be deemed to be part of any contract or warranty unless specifically incorporated by reference into such contract or warranty Trade Names Alvarion BreezeCOM WALKair WALKnet BreezeNET Z BreezeACCESS BreezeLINK BreezeMAX BreezeLITE BreezePHONE 4MOTION BreezeCONFIG MGW eMGW and or other products and or services referenced here in are either registered trademarks trademarks or service marks of Alvarion Ltd All other names are or may be the trademarks of their respective owners WiMAX Forum is a registered trademark of the WiMAX Forum WiMAX the WiMAX Forum logo WiMAX Forum Certified and the WiMAX Forum Certified logo are trademarks of the WiMAX Forum Statement of Conditions The information contained in this manual is subject to change without notice
Download Pdf Manuals
Related Search