GAS LAVA ROCK CHARGRILL HOB TOP OPTION
Contents
1. le 08 10 2013 171172. HOB TOP OPTION INTEGRATED HOB ELEMENT GAS LAVA ROCK CHARGRILL LAG 010 CKG V NCANCH E ea p n de Y A CONTENTS GAS LAVA ROCK CHARGRILL TECHNICAL DATA SHEETS MEASUREMENTS AND DIMENSIONS 3 INSTALLER S MANUAL 5 SITTING 7 GAS CONNECTION 8 CHANGE OF GAS 9 ELECTRIC CONNECTION 11 REPARATIES 11 GAS LINE 12 USER S MANUAL 13 USE LAVA ROCK GRILL 15 CLEANING AND MAINTENANCE 17 LAG 010 Ft 126a GB Rev 02 Modifie le 08 10 2013 2 17 TECHNICAL DATA Charcoal Hop top gas lava rock chargrill left or right of central hob depending on model gt A 4 kW gas burner controlled by a thermocouple safety valve A 260 x 460 mm grill resting on pillars is located above the fire tray Electric push button ignition Pressures and hourly consumption The gas lava rock chargrill can oprate from a supply of either mains gas or LPG but it must be configured for either please refer to power plate and marking at the rear of the range CKG table 3 appendix 0 Accessories gt Cooking grill gt Grease trap gt Ash drawer Directives Gas appliances 2009 142 CEE Low Voltage 2006 95 CEE CEM 2004 108 CEE INSTALLER S MANUAL LAG 010 CKG Ft 126a GB R v 02 Modifi le 08 10 2013 3 17 HOB TOP OPTION GAS LAVAROCK CHARGRILL LAG 010 CKG INSTALLER S MANUAL Appliances must be installed in a workmanlike manner in accordance with the instr
3. as other than that for which the cooker was initially set up it is crucial to replace the injectors and modify the adjustments as defined below Changing Jet Remove the jet see figure and replace with the appropriate sized jet see table 6 appendix 0 in 1 100 mm AN EZ wl Adjusting the primary air Loosen the screw that secures the air ring figure 2 Adjust the airflow by moving the adjusting air ring Charcoal tabel 7 in appendix 0 Commissioning fine tunin as burners After connection or changing gas type it is imperative to adjust for a fine tuning gt Ignite the burner in MAX Wait for 10 minutes to reach temperature and then reduce to minimum setting and remove the control knob Using a flathead screwdriver adjust the simmer flame accordingly see figure 3 Note Flame is reduced to of you turn maximum to minimum Looking for a crisp flame without any yellow wich does not go out when turned from maximum to minimum Adjusting air ring INSTALLER S MANUAL CHANGE OF GAS og gt 1 o Fran Srnec de Ara Setting the safety thermocouple If the burner goes out having kept the control knob pushed in for approximately twenty seconds check that The magnetic head grips the valve moderately finger right The tipt of thermocouple see figure should be touched by the flame without coming into contact with the burner T
4. he thermocouples and magnetic heads are absolutely clean Looking for crisp blue flame without any yellow wich does not out when turned from maximum to minimum INSTALLER S MANUAL LAG 010 CKG Ft 126a GB Rev 02 Modifie le 08 10 2013 10 17 eS p 0 de c ja ELECTRIC CONNECTION See Electric Connection in Cooker Installer s manual REPARATIES All work on or repair of an appliance must be carried out by a qualified engineer INSTALLER S MANUAL LAG 010 CKG Ft 126a GB R v 02 Modifi le 08 10 2013 11 17 GAS CIRCUIT For references and descriptions of the various components refer to table 11 in appendix 0 65 062070 65 062011 A S 65 080012 N47 65 51764 4 screws for assembly INSTALLER S MANUAL LAG 010 CKG Ft 126a GB R v 02 Modifi le 08 10 2013 12 17 HOB TOP OPTION GAS LAVA ROCK CHARGRILL LAG 010 CKG USER S MANUAL IMPORTANT It must be installed in accordance with the applicable regulations and standards in an adequately ventilated room Any changeover to a gas other than that for which the cooker is set up must be carried out by a qualified installer Any changeover to a voltage other than that for which the cooker is set up must be carried out by a qualified engineer WARRANTY The warranty is stated on the sales contract Please contact your approved Dealer if any work has to be carried out under warranty This warrant
5. ning work isolate from the mains supply Do not use a steam cleaner to clean the range Wait until the fire tray has at least partially cooled Cooking grill After use scrub the grill on which the food has grilled with a metal brush whide still hot Ashes grease trap fall into the ash drawer A which may be pulled out completely for emptying Railing of recovery see O figure AM Drawer with juice see figure DL Drawer with residues see figure 3 These 3 elements clean themselves easily in the dishwasher Burner The deflector see figure 4 detachable removable protecting the distiller can clean itself easily in the dishwasher Use a metal brush to clean the burner after use Body panels You can use special purpose products for stainless steel e g SUMAINOX JOHNSON STAINLESS STEEL PPZ STAINLESS STEEL 6 Never use abrasive products CAUTION Use NO chlorinated cleasers to clean this unit Carefully read the precautions and recommendations for applying the products you use to clean and maintain the range Follow the instructions for use DANGER Wait for the cooling of the device before any manipulation of the drawer with residues see Q figure and to use an adequate protection so required by manipulation of the tub ferry high school diploma with juice see figure 2 during the service Warn users of the potential risks USER S MANUAL LAG 010 CKG Ft 126a GB Rev 02 Modifi
6. ressure reducer Use two cylinders and a 3 way valve ahead of the pressure regulator in case of prolonged continuous duty The use of 37 kg or external cryogenic tanks is both possible and recommended Before connection Check That the gas supply pressure matches the gas pressure for which the range is set Pipework is perfectly clean in order to prevent the injectors becoming blocked and malfunctioning of the magnetic heads The gas for which the appliance was set up rating plate and markings Cross sectional area of gas supply pipework is compatible with the appliance s thermal output Correct fresh air flowrate air supply sufficient to enable correct combustion to occur see appendix 1 Gas connection Male coupling 15 21 1 2 gas thread on see Q figure n After connection Check the mains pressure at see figure 2 Check your connection is gastight INSTALLER S MANUAL LAG 010 CKG Ft 126a GB Rev 02 Modifi le 08 10 2013 8 17 CHANGING GAS TYPE LAVAROCK LAG 010 CKG OX Se 197 aW Ara Lacanche ranges are supplied with the appropriate gas fitting for the gas type specified when the order is placed However the settings must be fine COMMISIONED when the cooker is installed The cooker is designed to operate with the gases in table 4 appendix 0 CAUTION Close the mains gas valve before carrying out any works IMPORTANT In case of use with a g
7. returns to its initial position the latching mechanism operates and the gas safety cut out is activated several seconds after the burner goes out After any use to close the valve of stopping gas Useful hint CAUTION Use no oils or fats when cooking over lava rock as these may burn and smoke Untrimmed fat may burn and smoke simply move the food away from the flame The grill can be fixed in a higher or lower position for fast or slow cooking Hight level Low level CAUTION Use oven gloves when taking hold of the grill brass handles to prevent burns USER S MANUAL LAG 010 CKG Ft 126a GB Rev 02 Modifi le 08 10 2013 15 17 USE Grlled meat tips Do not score or spear the cut or it will lose its juices Use tongs not a fork to turn and clean the grillwith a brush between each cooking to avoid the meat stiming to the griddle Recommended temperatures Very hot Use for thin pieces or for bleue and red pieces Hot For medium sized piece or medium thick cuts cooked medium Medium Thick pieces e g ribs of beef should not be seared too quickly to avoid a well browned outside and a raw inside Grilles lengthwise and crosswise Cuts can be grilled length and crosswise once or twice twice will more evenly distributed the juices and produce a better result USER S MANUAL CLEANING AND MAINTENANCE Og n am roten de c Before any clea
8. uctions in this manual and locally applicable regulations This manual should be handed over to the user after installation LAG 010 CKG Ft 126a GB Rev 02 Modifie le 08 10 2013 5 17 INSTALLATION POSITIONING A shut off valve must be install and accessible close to the appliance in order to isolate it from the gas applicable or to facilitate cutting the gas supply Please ensure that installation complies with local applicable regulations and standards Natural gas supply Mandatory to install an Automatic Shut off Valve since 1st July 1997 in France LPG supply butane propane Propane Class 1 Safety Expansion Valve Butane Butane safety expansion valve fitted to the cylinder connected to the range by a LPG approved hose maximum length 2 metres INSTALLER S MANUAL LAG 010 CKG Ft 126a GB R v 02 Modifi le 08 10 2013 7 17 GAS CONNECTION Oc e w rimar de Fy Recommendations 7 ensure that the oven is set to the type of gas used see label on the gas connector If the gas supply is not compatible with the gas setting of your range the setting must be modified Refer to the Changing gas type section of the present instructions Butane fuelled units Connect unit to 2 6 kg h pressure reducer Use two cylinders connected to a 3 way valve ahead of the pressure regulator in case of prolonged continuous duty Propane fuelled units Connect unit to a 3 0 kg h p
9. y excludes damage resulting from incorrect installation improper use or inadequate servicing LAG 010 CKG Ft 126a GB Rev 02 Modifie le 08 10 2013 13 17 USE OX n eE D w Srnec de Hua Before use it is imperative to remove all the internal and external plastic packaging amp coating failure to do so will cause irreversible damage to the steel body Initial usage will cause some smoke and is no cause for alarm CAUTION potential users that temperatures may exceed 300 C Installing Before use assemble your gas lava rock chargrill as follow Ensure the grease trap ash tray is in position Open the door below amp check see O figure 0 Place the black enemalled burner cover over the burner body see figure 2 Place the lava rock tray over the burner assembly Fill the stainless steel lava rock tray with lava rock Place the heat diffuser plate over the lava rock see figure G Place the grill over the heat diffuser mounting at the appropriate height as desired OO A ON Simultaneously press in and turn the burner dial anti clockwise to setting Press the ignition button while maintaining pressure on burner dial for about 20 seconds to ignite burner and initialise safety thermocouple Areduced flowrate position identified by the mark produces the preset minimum burner power low flame To turn off turn the control knob clockwise to the e position The control knob
Download Pdf Manuals
Related Search