E120692 - Starcom Systems
Contents
1. 2222 222 0 2 0 8 41 Mode of Operation incu ti ccdieiiesinecs teen ites Goth ce AUG ended 8 4 2 Equipment Modi Catoms esccsccccsiecsssesctsestssedensstnesenstvenecendeteecsesteotbeebnonessabnaessorbedsoepsenaees 8 SUMMARY OF TEST RESULTS n neon nen e ne ne nen e ne nenees 9 EQUIPMENT UNDER TEST E U T DESCRIPTION 10 LIST OF TEST EQUIPMENT n ne nn nen nen n e 11 PA Em SS101 TESS soa vovesicisssiscarcvecstet cccseeacsenstendscssehncvenstade Socbubecspesantsvabebedncasuatedesbueenseevtees 11 8 RADIATED EMISSION 2 2 2 n nnn en en enn nen nnn nnn 12 8l Test Speci Cation x iu 2icseiece cssnseidessessentstdaceescttscsebeleossnctenedenbsdidoategsscauhbuisevenstensienitbes 12 8 amp 2 WESHIPROCE UPC areen eRe na E a aE ER aa EEEE IOR I EERE n a aSa 12 8 3 Test REs liS ee S50 a e eee E e Shan REAK EEA AENEAN REE Era EEK RE 13 9 SET UP PHOTOGRAPHS EE 15 10 SIGNATURES OF THE E U T S TEST ENGINEERS 16 11 APPENDIX A CORRECTION FACTORS 17 11 1 Correction factors for CARL 17 11 2 Correction factors for Amplifier 8447F 30M 1 3G GAIN 00 eceeeeeeceseeeeeees 18 11 3 Correction factors for Bilog ANTENNA AAA 192. The E U T met the requirements of the FCC Part 15 Subpart B Class B specification The margin between the emission level and the specification limit is 13 0 dB in the worst case at the frequency of 500 00 MHz vertical polarization The details of the highest emissions are given in Figure 2 Test Report E120692 00 Starcom GPS Systems Lid Page 13 of 24 ITL FCCMASVE 1 29 28 February 2011 ISRAEL TESTING LABORATORIES Radiated Emission E U T Description Personal Tracker Type RAINBOW Serial Number 310681 Specification FCC Part 15 Subpart B Class B Antenna Polarization Horizontal Vertical Frequency range 30 MHz to 1000 MHz Antenna 3 meters distance Detectors Peak Quasi peak Frequency Peak QP Antenna Limit Margin Amp Amp Polarization MHz dBuV m dBuV m Hor Ver dBuV m dB 150 32 22 9 13 1 X 43 5 30 4 240 00 23 6 18 1 X 46 0 27 6 350 00 23 3 21 9 X 46 0 24 1 400 00 30 4 23 9 X 46 0 22 4 430 00 38 5 32 4 X 46 0 13 6 500 00 36 4 30 0 X 46 0 13 0 550 00 36 5 30 5 X 46 0 15 5 600 00 38 2 31 2 X 46 0 14 8 Figure 2 Radiated Emission Antenna Polarization HORIZONTAL VERTICAL Detectors Peak Quasi peak Note Margin refers to the test results obtained minus specified requirement thus a positive number indicates failure and a negative result indicates that the product passes the test Test Report E120692 00 Starcom GPS Systems Ltd Page 14 of 2
3. 12 APPENDIX B MEASUREMENT UNCERTAINTY 20 121 R di ted E OG 20 13 APPENDIX C FCC VERIFICATION PROCESS INSTRUCTIONS 21 Test Report E120692 00 Starcom GPS Systems Lid Page 2 of 24 ITL FCCMASVE 1 29 28 February 2011 ISRAEL TESTING LABORATORIES 1 General Information 1 1 Administrative Information Test Report E120692 00 ITL FCCMASVE 1 29 28 February 2011 Manufacturer Manufacturer s Address Manufacturer s Representative Equipment Under Test E U T Equipment Model No Equipment Serial No Date of Receipt of E U T Start of Test End of Test Test Laboratory Location Test Specifications Starcom GPS Systems Ltd Starcom GPS Systems Ltd 33 Jabotinsky St Ramat Gan 52511 Israel Tel 972 3 619 9901 Fax 972 3 619 9954 Vadim Leitman Personal Tracker RAINBOW 310681 09 08 12 15 08 12 16 08 12 LTL Product Testing Ltd 1 Batsheva St Lod ISRAEL 71100 See Section 2 Page 3 of 24 ISRAEL TESTING LABORATORIES 1 2 Abbreviations and Symbols The following abbreviations and symbols are applicable to this test report AC alternating current ARA Antenna Research Associates Aux auxiliary Avg average CDN coupling decoupling network cm centimeter dB decibel dBm decibel referred to one milliwatt dbuV decibel referred to one microvolt dbuV m decibel referred to one microvolt per
4. 29 28 February 2011 ISRAEL TESTING LABORATORIES 7 List of Test Equipment 7 1 Emission Tests The equipment indicated below by an X was used for testing Conducted Emission CE and Radiated Emission RE Test equipment calibration is in accordance with ITL Q A Procedure PM 110 Calibration Control Procedure which complies with ISO 9002 and ISO IEC Guide 17025 Instrument pore ES Manufacturer Model Serial No ge E pe Les Te EMI Receiver eee E Receiver RF Filter Section e fe se A Mast amp Table Controller ETS EMCO 2090 9608 1456 X Test Report E120692 00 Starcom GPS Systems Lid Page 11 of 24 ITL FCCMASVE 1 29 28 February 2011 ISRAEL TESTING LABORATORIES 8 Radiated Emission 8 1 Test Specification 30 1000 MHz FCC Part 15 Subpart B CLASS B 8 2 Test Procedure The E U T operation mode and test set up are as described in section 4 1 A preliminary measurement to characterize the E U T was performed inside the shielded room at a distance of 3 meters using peak detection mode and broadband antennas The preliminary measurements produced a list of the highest emissions The E U T was then transferred to the open site and placed on a remote controlled turntable The E U T was placed on a non metallic table 0 8 meters above the ground The effect of varying the position of the cables was investigated to find the configuration that produces maximum emission The configuration tested is shown in Figure 3
5. February 2011 ISRAEL TESTING LABORATORIES 13 Appendix C FCC Verification Process Instructions e Label Prepare Label e Design a FCC compliance label that will be affixed to all units marketed e The label must include the compliance statement below Example of Label This device complies with Part 15 of the FCC Rules Operation is subject to the following two conditions 1 This device may not cause harmful interference and 2 This device must accept any interference received including interference that may cause undesired operation Note The label may also contain other information such as the model number the country of origin etc The country of origin information is required by Customs and the Federal Trade Commission for imports to the U S Small Products If the product is too small for a label containing the statement above the information paragraph required must be placed in a prominent location in the instruction manual or alternatively the information can be placed on the container in which the product is marketed Test Report E120692 00 Starcom GPS Systems Lid Page 21 of 24 ITL FCCMASVE 1 29 28 February 2011 ISRAEL TESTING LABORATORIES e Label The FCC requires that the compliance statement above be placed in a conspicuous location on the device The following are the FCC Rules about how the label will be permanently attached The label is expected to last the life of th
6. 4 ITL FCCMASVE 1 29 28 February 2011 ISRAEL TESTING LABORATORIES Global Certifications You Can Trust 9 Set Up Photographs We ad Figure 3 Radiated Emission Test Test Report E120692 00 Starcom GPS Systems Lid Page 15 of 24 ITL FCCMASVE 1 29 28 February 2011 ISRAEL TESTING LABORATORIES 10 Signatures of the E U T s Test Engineers Test Engineer Signature Date Name Radiated Emissions Y Mordukhovitch 03 10 12 Test Report E120692 00 Starcom GPS Systems Lid Page 16 of 24 ITL FCCMASVE 1 29 28 February 2011 ISRAEL TESTING LABORATORIES 11 APPENDIX A CORRECTION FACTORS 11 1Correction factors for CABLE from EMI receiver to test antenna at 3 AND 10 meter range FREQUENCY CORRECTION FREQUENCY CORRECTION FACTOR FACTOR MHz dB MHz dB 30 1 96 700 11 25 35 2 08 800 12 53 40 2 26 900 13 86 45 2 43 1000 14 86 50 2 59 1200 15 7 55 2 65 1400 17 05 60 2 86 1600 18 2 65 2 96 1800 19 4 70 3 04 2000 21 3 75 3 27 80 3 41 85 3 54 90 3 68 95 3 77 100 3 93 110 4 19 120 4 41 130 4 6 140 4 83 150 5 06 160 5 35 170 5 57 180 5 7 190 5 84 200 6 02 250 6 86 300 7 59 350 8 09 400 8 7 450 9 15 500 9 53 550 9 82 600 10 24 650 10 74 NOTES 1 The cable type is RG 214 U Test Report E120692 00 Starcom GPS Systems Ltd Page 17
7. CC Wants You to Know This equipment has been tested and found to comply with the limits for a Class A digital device pursuant to Part 15 of the FCC rules These limits are designed to provide reasonable protection against harmful interference when the equipment is operated in a commercial environment This equipment generates uses and can radiate radio frequency energy and if not installed and used in accordance with the instructions may cause harmful interference to radio communications Operation of this equipment in a residential area is likely to cause harmful interference in which case the user will be required to correct the interference at his own expense FCC Warning Modifications not expressly approved by the manufacturer could void the user authority to operate the equipment under FCC Rules Test Report E120692 00 Starcom GPS Systems Ltd Page 23 of 24 ITL FCCMASVE 1 29 28 February 2011 ISRAEL TESTING LABORATORIES Sample User Information for a Class B digital device The FCC Wants You to Know This equipment has been tested and found to comply with the limits for a Class B digital device pursuant to Part 15 of the FCC rules These limits are designed to provide reasonable protection against harmful interference in a residential installation This equipment generates uses and can radiate radio frequency energy and if not installed and used in accordance with the instructions may cause harmful interf
8. NE NAY 1s Soe fee come SIS ACCREDITED a IC uta 5 of E Lu TESTING Cert No 1152 01 DATE 25 September 2012 Gi LTL PRODUCT TESTING LTD FCC EMC Test Report Equipment Authorization Under FCC Verification Process for Starcom GPS Systems Ltd Equipment under test Personal Tracker RAINBOW Written by Ge Shidlowsky Documentation Approved by a Mordukhovitch Test Engineer Approved by I Raz EMC Laboratory Manager This report must not be reproduced except in full without the written permission of LTL Product Testing Ltd This report relates only to items tested Test Report E120692 00 Starcom GPS Systems Lid Page 1 of 24 ITL FCCMASVE 1 29 28 February 2011 ISRAEL TESTING LABORATORIES 1 GENERAL INFORMATION 22 2 nn nn nn nn nn nnn eens enenenes 3 1 1 Administrative Information 0 0 0 cee eesceeececseceeeeeceseceeneeceaeceeneeceaeeeeneecaeeeeeeecseeeeneeee 3 1 2 Abbreviations and Symbols occ sscsssesscssesessdesstecossespenedesseetecsouedpedvense aiie 4 L Tis tof AceredtallonSs gt E EE EEEE EKSERE NE ar EE n ETE 5 APPLICABLE DOCUMENTS EE 6 TEST SITE DESCRIPTION eneen 7 Belin LQ Le EE 7 32 OPEN SM oorno Ra n aa E AE E nse eege eege eege 7 3 3 ue re H 34 Antenna Masti siine te EES REES EENS H SG Sa e H De SR DOT EE H 37 CHEN E D GE H 3 8 Test Equipments end EES EES Lae 7 4 SYSTEM TEST CONFIGURATION
9. Radiated Emission Test The E U T highest frequency source or used frequency is 12 MHz The frequency range 30 1000 MHz was scanned and the list of the highest emissions was verified and updated accordingly The emissions were measured using a computerized EMI receiver complying to CISPR 16 requirements The specification limits and applicable correction factors are loaded to the receiver via a 3 5 floppy disk The readings were maximized by adjusting the antenna height between 1 4 meters the turntable azimuth between 0 360 and the antenna polarization Verification of the E U T emissions was based on the following methods Turning the E U T on and off Using a frequency span less than 10 MHz Observation of the signal level during turntable rotation Background noise is not affected by the rotation of the E U T The emissions were measured at a distance of 3 meters The field strength is calculated directly by the EMI Receiver software and a Correction Factors data disk using the following equation FS RA AF CF Where FS Field strength dBu V m RA Receiver Amplitude dBuV AF Receiving Antenna Correction Factor dB m CF Cable attenuation Factor dB Example FS 30 7 dBuV RA 14 0 dB AF 0 9 dB CF 45 6 dBuV Test Report E120692 00 Starcom GPS Systems Lid Page 12 of 24 ITL FCCMASVE 1 29 28 February 2011 ISRAEL TESTING LABORATORIES Global Lertifications You Can trust 8 3 Test Results
10. com GPS Systems Lid Page 5 of 24 ITL FCCMASVE 1 29 28 February 2011 ISRAEL TESTING LABORATORIES Global Certifications You Can Trust 2 Applicable Documents 2 1 Code of Federal Regulations Title 47 Federal Communications Commission Unintentional Radiators Part 15 Subpart B Rev July 12 2012 GPO Access Web Site 2 2 ANSI 63 4 2003 American National Standards for Methods of Measurement of Radio Noise Emissions from Low Voltage Electrical and Electronic Equipment in the Range of 9 kHz to 40 GHz Test Report E120692 00 Starcom GPS Systems Lid Page 6 of 24 ITL FCCMASVE 1 29 28 February 2011 ISRAEL TESTING LABORATORIES 3 Test Site Description 3 1 Location The Electromagnetic Compatibility Test Facility of I T L Product testing Ltd Is located at Telrad Industrial Park Lod 71100 Israel Telephone 972 8 9153100 Fax 972 8 9153101 3 2 Open Site The OATS is located on a one floor building roof The OATS consists of 3 meter and 10 meter ranges using a 21 5m X 8 5m solid metal ground plane a remote controlled turntable and an antenna mast 3 3 Ground Plane The ground plane is made from steel plates which are welded continuously together The Ground plane is lies and welded on welded steel construction with vias to allow for water drainage All the power control and signal lines to the turntable and the 3 m and 10m antenna mast outlets are routed in shielded conduits under the plane to the control buildi
11. e product It must be permanently marked etched engraved indelibly printed etc either directly on the device or on a tag that is permanently affixed riveted welded etc to the device Example of Product with Label This device complies Bottom Front with Part 15 of the FCC Rules Operation is subject to the following two conditions 1 This device Label oe with FCC Se armful Com plian ce interference and Statement This device must accept any interference received including interference that may cause undesired operation Test Report E120692 00 Starcom GPS Systems Lid Page 22 of 24 ITL FCCMASVE 1 29 28 February 2011 ISRAEL TESTING LABORATORIES e FCC Compliance Statement FCC Compliance Statement in User s Manual For a Class A or Class B digital device or peripheral the instructions given to the user shall include the following or a similar statement that should be placed in a prominent location in the text of the manual from FCC Rules 15 105 The user s manual or instruction manual for an intentional or unintentional radiator shall caution the user that changes or modifications not expressly approved by the party responsible for compliance could void the user s authority to operate the equipment from FCC Rules 15 21 Information about any special accessories needed to ensure FCC compliance must also be included Sample User Information for a Class A digital device The F
12. erence to radio communications However there is no guarantee that interference will not occur in a particular installation If this equipment does cause harmful interference to radio or television reception which can be determined by turning the equipment off and on the user is encouraged to try to correct the interference by one or more of the following measures a Reorient or relocate the receiving antenna b Increase the separation between the equipment and receiver c Connect the equipment to an outlet on a circuit different from that to which the receiver is connected d Consult the dealer or an experienced radio TV technician FCC Warning Modifications not expressly approved by the manufacturer could void the user authority to operate the equipment under FCC Rules Test Report E120692 00 Starcom GPS Systems Lid Page 24 of 24 ITL FCCMASVE 1 29 28 February 2011
13. eve compliance Test Report E120692 00 Starcom GPS Systems Lid Page 8 of 24 ITL FCCMASVE 1 29 28 February 2011 ISRAEL TESTING LABORATORIES 5 Summary of Test Results Test Results Radiated Emissions The E U T met the FCC Part 15 Subpart B Class B performance requirements of the specification The margin between the emission level and the specification limit was 13 0 dB in the worst case at the frequency of 500 00 MHz vertical polarization Test Report E120692 00 Starcom GPS Systems Ltd Page 9 of 24 ITL FCCMASVE 1 29 28 February 2011 ISRAEL TESTING LABORATORIES 6 Equipment Under Test E U T Description RAINBOW is a unique personal tracker the only one which allows automatic long distance supervision You can define a variety of events suitable for each age health condition and characteristic of each carrier These events can automatically activate the emergency button in a number of situations such as leaving a pre defined geographical area geofence falling unusual walking pace unreasonable running not being in a certain place at a certain time such as the kindergarten senior center clinic etc lack of movement of the device and more In addition you can be alerted if the device is left behind or is not being worn The E U T includes and FCC approved modem FCC ID XPYLEONG100 manufactured by u blox AG Test Report E120692 00 Starcom GPS Systems Lid Page 10 of 24 ITL FCCMASVE 1
14. meter DC direct current EMC electromagnetic compatibility E U T equipment under test GHz gigahertz HP Hewlett Packard Hz Hertz kHz kilohertz kV kilovolt LED light emitting diode LISN line impedance stabilization network m meter mHn millihenry MHz megahertz msec millisecond N A not applicable QP quasi peak PC personal computer RF radio frequency RE radiated emission sec second V volt Test Report E120692 00 Starcom GPS Systems Ltd Page 4 of 24 ITL FCCMASVE 1 29 28 February 2011 ISRAEL TESTING LABORATORIES 1 3 List of Accreditations The EMC laboratory of LTL is accredited by the following bodies l 2 3 The American Association for Laboratory Accreditation A2LA U S A Certificate No 1152 01 The Federal Communications Commission FCC U S A Registration No 861911 The Israel Ministry of the Environment Israel Registration No 1104 01 The Voluntary Control Council for Interference by Information Technology Equipment VCCI Japan Registration Numbers C 3006 R 2729 T 1877 G 245 Industry Canada Canada IC File No 46405 4025 Site No IC 4025A 1 TUV Product Services England ASLLAS No 97201 LTL Product Testing Ltd is accredited by the American Association for Laboratory Accreditation A2LA and the results shown in this test report have been determined in accordance with I T L s terms of accreditation unless stated otherwise in the report Test Report E120692 00 Star
15. ng 3 4 Antenna Mast ETS model 2070 2 The antenna position and polarization are remote controlled via Fiber Optical Link using ETS EMCO Dual Controller Type 2090 The antenna position is adjustable between 1 4 meters Pressurized air is used to power changing the polarity of the antenna 3 5 Turntable ETS model 2087 series The position of the turntable is remote controlled via Fiber Optic Link using ETS EMCO Dual Controller Type 2090 The turntable is mounted in a pit and its surface is flush with the Open Site Ground Plane Brushes near the periphery of the turntable ensure good conductive connection to the ground plane The Turntable maximum load is 1250 Kg 3 6 EMI Receiver Type HP8542E including HP85420E R F filter manufactured by Hewlett Packard being in full compliance with CISPR 16 requirements 3 7 E U T Support Table mounted E U T s are supported during testing on 80 cm high all wooden tables no metal nails or screws 3 8 Test Equipment See details in Section 6 Test Report E120692 00 Starcom GPS Systems Lid Page 7 of 24 ITL FCCMASVE 1 29 28 February 2011 ISRAEL TESTING LABORATORIES 4 System Test Configuration 4 1 Mode of Operation The E U T was operated in Ready mode with connection to the communication center via cellular module each 10 sec Internal battery Li Ion Figure 1 Configuration of Tested System 4 2 Equipment Modifications No modifications were required in order to achi
16. of 24 ITL FCCMASVE 1 29 28 February 2011 ISRAEL TESTING LABORATORIES 11 2Correction factors for GAIN Test Report E120692 00 ITL FCCMASVE 1 29 28 February 2011 Amplifier 8447F 30M 1 3G FREQUENCY GAIN dB MHz 20 27 16 30 27 18 50 27 15 100 27 01 200 26 48 500 27 54 1000 26 96 1100 26 69 1200 26 28 1300 25 85 Starcom GPS Systems Lid Page 18 of 24 ISRAEL TESTING LABORATORIES 11 3Correction factors for Bilog ANTENNA Model 3142 Antenna serial number 1250 3 meter range Test Report E120692 00 ITL FCCMASVE 1 29 28 February 2011 Starcom GPS Systems Lid FREQUENCY AFE FREQUENCY AFE MHz dB m MHz dB m 30 18 4 1100 25 40 13 7 1200 24 9 50 9 9 1300 26 60 8 1 1400 26 1 70 7 4 1500 27 1 80 7 2 1600 27 2 90 7 5 1700 28 3 100 8 5 1800 28 1 120 7 8 1900 28 5 140 8 5 2000 28 9 160 10 8 180 10 4 200 10 5 250 12 7 300 14 3 400 17 500 18 6 600 19 6 700 21 1 800 21 4 900 23 5 1000 24 3 Page 19 of 24 ISRAEL TESTING LABORATORIES 12 APPENDIX B MEASUREMENT UNCERTAINTY 12 1Radiated Emission Radiated Emission CISPR 11 EN 55011 CISPR 22 EN 55022 ANSI C63 4 for open site 30 1000MHz Expanded Uncertainty 95 Confidence K 2 4 96 dB Test Report E120692 00 Starcom GPS Systems Lid Page 20 of 24 ITL FCCMASVE 1 29 28
Download Pdf Manuals
Related Search