CIGARETTE LIGHTER KIT - Harley
Contents
1. eg to S CB connector P amp A accessory Auxiliary audio input AM FM radio antenna GPS antenna Left handlebar switches CB antenna Front fender tip lamp Main to fairing harness left Heated hand grip power if equipped not visible Run stop switch Right handlebar switches not visible Main to fairing harness right TGS Radio Power outlet Figure 1 Inner Fairing Harness Connectors SERVICE PARTS Table 1 Service Parts is07653 Item Description Quantity Part Number 1 Cigarette lighter element 91808 89 2 Cigarette lighter socket 91812 89A 3 Terminal 72290 94 Figure 2 Service Parts Cigarette Lighter Kit J05670 2 of 22. amps more current from the electrical system J05670 amp Many Harley Davidson Parts amp Accessories are made of plastics and metals which can be recycled REMOVAL WARNING To prevent accidental vehicle start up which could cause death or serious injury remove main fuse before pro ceeding 00251b 1 Follow the instructions in the service manual for the fol lowing procedures a Remove main fuse b Remove outer fairing c Remove right speaker enclosure 2 See Figure 1 Disconnect power outlet connector 132 16 3 Cut off 2 way connector as close to the connector as possible 4 Hold socket and loosen outer shell Remove the power outlet and cap from inner fairing INSTALLATION 1 Strip wires and crimp spade terminals to wires NOTE It may be necessary to shift the location of cable straps to provide additional length in wire harness 2 Connect violet blue wire to center lug Connect black wire to sleeve lug 3 Install cigarette lighter socket from inner fairing side and tighten securely 4 Insert lighter element 5 Install main fuse and check operation 6 Follow the instructions in the service manual for the fol lowing procedures a Install right speaker enclosure b Install outer fairing 1 of2 Please dispose of materials responsibly ONS OP OB Nes
3. cMOTOR HARLEY DAVIDSON WY J05670 INSTRUCTIONS REV 2013 06 01 CIGARETTE LIGHTER KIT GENERAL Kit Number 69200605 Models For model fitment information see the P amp A Retail Catalog or the Parts and Accessories section of www harley davidson com English only Additional Parts Required NOTE This instruction sheet references service manual information A service manual for your model motorcycle is required for this installation and is available from a Harley Davidson dealer Kit Contents See Figure 2 and Table 1 ELECTRICAL OVERLOAD NOTICE It is possible to overload your vehicle s charging system by adding too many electrical accessories If the combined electrical accessories operating at any one time consume more electrical current than the vehicle s charging system can produce the electrical consumption can discharge the battery and cause damage to the vehicle s electrical system See an authorized Harley Davidson dealer for advice about the amount of current consumed by addi tional electrical accessories or for necessary wiring changes 00211Cc WARNING When installing any electrical accessory be certain not to exceed the maximum amperage rating of the fuse or circuit breaker protecting the affected circuit being modi fied Exceeding the maximum amperage can lead to elec trical failures which could result in death or serious injury 00310a This cigarette lighter kit requires up to 5 0
Download Pdf Manuals
Related Search