Installation and Operation Manual TOM-50(B) TOM
Contents
1. Shipment date from manufacture whichever occurs first is limits to the repair or replacement including labor charges of defective parts or assemblies The labor Warranty shall include standard straight time labor charges only and reasonable travel time as determined by Turbo Air Additional Four Year compressor Warranty In addition to the one 1 year warranty stated above Turbo Air warrants its hermetically sealed compressor to be free from defects in both material and workmanship under normal and proper use and maintenance service for a period of four 4 additional years from the date of original installation but not to exceed five 5 years and three 3 months after shipment from the manufacturer Compressor determined by Turbo Air to have been defective within this extended period will at Turbo Air s option be either repaired or replaced with a compressor or compressor parts of similar design and capacity The four 4 year extended compressor warranty applies only to hermetically sealed parts of the compressor and does not apply to any other parts or components including but not limited to cabinet paint finish temperature control refrigerant metering device driers motor starting equipment fan assembly or and other electrical component etcetera 10 404a 134a Compressor warranty The four year compressor warranty detailed above will be voided if the following Procedure is not carefully adhered to 1 This system c2. 50 B LOCATION OF OPEN DISPLAY MERCHANDISER Dimension WxDxH 26 83x38 99x77 98 in 26 83x50 39x77 98 in Display is designed to be in an ambient 75 degrees Fahrenheit dry bulb or colder Electricity 120V 1Ph 60Hz and 55 percent relative humidity If unit is installed in a warm ambient Display Power Input 1 920 W 1 953 W will not cool effectively Move the display to the final location before removing Compressor CAJ9513Z shipping skid Allow 3 inches from back of Display to wall Condenser is in front Refrigerant R 404a of Display Do not block inlet Lighting 25Wx5 32Wx5 There are four bolts at bottom of display that secure it to shipping skid remove all Timed off defrost four Type of Defrosting Weight of Case 507 Ibs 573 Ibs LEVELING OF OPEN DISPLAY MERCHANDISER Four leveling legs are provided for leveling Display If you do not wish to use levelers they can be turned inwards INSTALLATION INSTRUCTIONS Bottom frame of unit will be on floor Use a leveler to make sure unit is leveled on all four corners INSPECTION FOR DAMAGE If unit is not leveled drainage of water will not drain properly Leveling legs can Customer is responsible for checking for damage First inspect crate as soon as it arrives be adjusted accordingly Prior to signing if crate is damaged make sure you note that on bill of lading If after uncrating there is concealed damage and crate was in good condition you must call Customer Service at Turbo Air Con
3. Turbo air Speeds UP the Pace of Innovation CONTENTS REFRIGERATOR MANUFACTURER Vurh O a 77 la INTRODUCTION 1 SPECIFICATIONS 3 INSTALLATION INSTRUCTIONS 3 4 OPEN DISPLAY MERCHANDISER Inspection for damage Installation and Operation Manual elaine of EE Leveling of Display Please read this manual completely before attempting OPERATING INSTRUCTIONS 5 to install or operate this equipment Controls Light Switch Temperature Control Thermometer How to place product MAINTENANCE amp CLEANING 6 7 Condenser coil TROUBLE SHOOTING 7 8 Display not working TOM 40 B Display case warm Lights not working TOM 50 B WIRING DIAGRAM 8 WARRANTY STATEMENT 9 13 INTRODUCTION This owner s manual has important information Please read the entire manual before WARNING Failure to read this manual completely can result in personal injury or damage installing your new Turbo Air Open Display Merchandiser After reading manual if you to the unit have any questions please fill free to call Keep manual in a safe place to refer to in the future CUSTOMER SERVICE DEPARTMENT WARNING TURBO AIR Display should be on dedicated outlet for 1250 VICTORIA ST proper operation CARSON CA 90746 1 800 381 7770 Please write down model and serial number for making any reference to this unit MODEL NUMBER SERIAL NUMBER Thank you for purchasing Turbo Air Ie SPECIFICATION Model TOM 40 B TOM
4. LAY CASE SHOULD BE CLEANED THOROUGHLY BEFORE FIRST USE a Do not clean with harsh detergents Use a mild soap b Remove all products c Remove shelves and bottom trays d Clean interior with warm water and mild detergent e Wipe with damp cloth Do not leave residue of soap CONDENSER COIL c Check power switch is on Condenser coil is located at bottom behind panel DISPLAY CASE WARM 1 Disconnect the electrical power a Check condenser to see if clean to the unit b Check that air flow inside of unit is not blocked with product 2 Remove the front cover and base cover with screwdriver LIGHTS NOT WORKING 3 Brush the dirt lint etc from the a Check that light switch is on finned condenser coil b Check that light is in lamp holder correctly 4 When finished be sure to replace the front cover and base cover WIRING DIAGRAM 5 Reconnect the electrical power to the unit TOM 40 TOM 50 6 Condenser should be cleaned every 3 months or as needed fe ve Power swicth Lamp swicth TROUBLE SHOOTING AC 120v 60HZ as ee m For any problems with Display please refer to following check list If still having a problem B D i j or need to ask a question please call Customer service at 1 800 381 7770 118 o F g Tosgerhture controtlar S p a Low pressure DISPLAY NOT WORKING il mit E a Check to see if breaker is not tripped EJ Sul ral b Check power going to
5. cealed damage must be reported within 24 hours of receiving unit Bill of lading will be requested faxed to claim department Pictures may be requested of unit and crating OPERATING INSTRUCTIONS After installing unit and all electrical to the Display Display is ready to start up CONTROLS LIGHT SWITCH It is located on top right hand side by display TEMPERATURE CONTROL 1 Temperature controller is located on the right side of intake grill and it s set at 38 40 F under the ambient temperature of 75 F amp humidity of 55RH 2 Initial setting of TOM SO is at level 2 and TOM 40 at level 1 If icing is seen adjust the level knob slightly to 3 to 4 counterclockwise 3 To raise the temperature of the cabinet turn the knob counterclockwise THERMOMETER Thermometer showing temperature is located on the right side of the back panel under the forth shelf NOTE Before placing products to the Display unit wait until the unit to reach desired temperature Do not place hot product in unit HOW TO PLACE PRODUCT Do not overload product on shelves Do not place product against back wall due to air flow will be blocked and cause the unit not to cool properly MAINTENANCE amp CLEANING Always before cleaning Display the unit should be turned off at power switch and lights should be turned off Remove product and allow the display unit to reach room temperature 1 Do not wet electrical components DISP
6. iai Outside U S and Canada Zarb o amr This warranty does not apply to and Turbo Air is not responsible for any warranty claims 1250 Victoria Street made on products sold or used outside the United States and Canada CARSON CA 90746 TEL 310 900 1000 FAX 310 900 1077 Toll Free 1 800 627 0032 U S A and Canada 13 htto www turboairinc com
7. ontains R404A or R134A refrigerant and polyolester lubricant The polyol ester lubricant has rapid moisture adsorbing qualities 2 Drier replacement is very important and must be changed when a system is opened for servicing A 032 drier or better is highly recommended 3 Micron level vacuums must be achieved to insure low moisture levels in the system 500 microns or lower must be obtained 4 When compressor is grounded suction filter drier and 620 drier or better must be replaced 5 Compressor must be obtained through Turbo Air inc unless otherwise specified in writing through Turbo Air s warranty department What is not covered by this warranty Turbo Air s sole obligation under this warranty is limited to either repair or replacement of parts subject to the additional limitations below This warranty neither assumes nor authorizes any person to assume obligations other than those expressly covered by this warranty 11 No consequential damages Turbo Air is not responsible for economic loss profit loss or special indirect or consequential damages including without limitation losses or damages arising from food or product spoilage claims whether or not on account of refrigeration failure Warranty is not transferable This warranty is not assignable and appliers only in favor of the original purchaser user to whom delivered Any such assignment or transfer shall void the warranties herein made and shall void all warranties e
8. unit WARRANTY STATEMENT Warranty claims All claims for labor or parts must be made directly through Turbo Air If unit was manufactured more than one year proof of purchase must be faxed in or sent with claim All claims should include model number of the unit the serial number of the cabinet and all pertinent information supporting the existence of the alleged defect If compressor is replaced under warranty Turbo Air either requests the compressor or compressor tag be returned Compressor or tag must be returned with all information related to the unit Any action or breach of these warranty provisions must be commenced within six months after said cause of action has occurred One Year Parts amp Labor Warranty Turbo Air warrants to the original purchaser of every new Turbo Air refrigerated unit the cabinet and all parts thereof to be free from defects in material or workmanship under normal and proper use and maintenance service as specified by Turbo Air and upon proper installation and start up in Accordance with the instruction packet supplied with each Turbo Air unit Turbo Air s obligation under this warranty is limited to a period of one 1 year from the date of original installation or 15 months after shipment date from Turbo Air whichever occurs first Any parts covered under this warranty that are determined by Turbo Air to have been defective within one 1 year of original installation or fifteen 15 months after
9. xpress or implied including any warranty of merchantability or fitness for a particular purpose Improper usage Turbo Air assumes no liability for parts or labor coverage for component failure or other damages resulting from improper usage or installation or failure to clean and or maintain product as set forth in the warranty packet provided with the unit Alteration neglect Abuse Misuse Accident Damage During Transit or Installation Fire Flood Acts of god Turbo Air is not responsible for the repair or replacement of any parts that TurboAir determines have been subjected after the date of manufacture to alteration neglect abuse misuse accident damage during transit or installation fire flood or act of God 12 Improper electrical Connections Turbo Air is not responsible for the repair or replacement of failed or damaged components resulting from electrical power failure the use of extension cords low voltage or voltage drops to the unit No Implied Warranty of Merchantability or fitness for a Particular purpose There are warranties express implied or statutory except the one 1 year warranty and the additional four 4 year compressor warranty no other as described above These warranties are exclusive and in lieu of all other warranties including implied warranty and merchantability or fitness for a particular purpose There are no warranties which extend beyond the description on the face hereof ar apyn
Download Pdf Manuals
Related Search