Home

2015 Windsport Motorhomes Owner`s Manual by Thor

1. Donot allow children to operate the electric bed systems The lowering and raising ofthe electric beds should only be conducted by an adult No person should be on the electric bed when being lowered or raised f you have any questions about elevated beds electric bed lift systems or bed rails please contact Thor Motor Coach Customer Service at 877 500 1020 ENTRY DOOR When locking and unlocking the main door there is a dead bolt and a latch bolt which ASSIST HANDLE ELECTRIC STEP are keyed separately Unlock both pull the latch open and pull out on the door handle The main entry door is a two piece door You can use the screen door separately from the main door by unlatching it Slide the screen handle cover closed to keep insects out of your motorhome If the door needs adjustment see a Thor Motor Coach dealer for service The entry door consists of both an exterior door and a screen door used for ventilation when the motorhome is parked CAUTION DO NOT ATTEMPT TO DRIVE THE Motorhome WITH THE DOORS OPEN DO NOT DRIVE THE Motorhome WITH THE OUTER DOOR OPEN AND THE SCREEN DOOR CLOSED The doors may be damaged and it is a safety hazard When driving it is a good idea to keep the door locked to prevent uninvited entrance from the outside when stopped Two types of locks may be provided with the outer door The handle lock for normal security and a dead bolt lock for additional security The dead bolt must be loc
2. the sofa Damage will occur EXPANDING THE LOUNGE Expandable Lounge Pull up on the switch located on the inside of the sofa arm Pull the end of the sofa out until the expanable section is fully deployed Remove the seat cushion from the storage area and place it on the bars making sure that the brackets on the bottom of the cushions are hooked around the sofa seat bars Put the back cushion in place CLOSING THE LOUNGE Remove the back cushion Remove the seat cushion and return it to the storage area Pull up on the switch located on the in side of the sofa arm Push the end of the sofa back into its original position Sofa bed Controls and Operations DINETTE 72 CHAIRS Barrel Chair Euro Recliner Captain s Chairs Booth The dinette will seat four people Storage and or various systems components can be accessed from above by removing the seat cushions and lifting the seat supports Free Standing Since the free standing dinette chairs are not secured to the floor and not equipped with seat belts they should not be occupied while the motorhome is in motion These chairs should be stored securely while the vehicle is in motion Pedestal The dinette can also be converted into an additional bed if required To convert lift the table top off of the two support posts Remove the support posts from the floor and lay them down between the seats Insert the table top between the sea
3. JEWeIIIN 84 Entertainment AL 3dIs LAO Means WOOd SNINIT 0 09 c NOA CAD E ty xy 31897 JAL 1 DL YNNJLNY COFTIVLSNI ASWNOLSND ad3 I3234 195 AL OL inaina FIF ZITO 319719 dadd LYS Lage LOZE NO X703 GATWLISNI INL 371859 ANY HSIG TATWLINI ASWOLSNI JaBuayjeuy AOI 3LNI 1 85 Entertainment AL 1 AL Al 307479 QI311V LSNI 1 27 3185 JAINA LYS Add HOi THE AL OL o andino V iio 0 0 31574 HILIMS M43AV 1d CAI d3dd 195 AL NIVH 31H 2 CNY TATWILSNI 31918 a IHOLSNI 2008 Y SSe 86 Heating and Air Conditioning The air conditioning system contains refrigerant 134a under high pressure and should DASH PANEL be serviced by qualified personnel only Improper service methods could cause HEATER AND AIR serious personal injury CONDITIONER The motorhome is equipped with an integrated heating air conditioning system While this system is much more powerful than those used in passenger cars it is not capable of heating and cooling the entire motorhome This system is designed to provide windshield defrost as well as heating and cooling for the front seat occupants only By following the operating instructions and tips this heater air conditioner will provide many years of com
4. Must be returned to its travel position Pay special attention to this every time you move your unit Severe damage may result if not retracted during transit Levels at the monitor panel should be checked and gas line connections should be checked for leaks C Note Some states prohibit vehicles equipped with propane tanks from using tunnels A few other states prohibit traveling with the service valve open and the pilot lights lit Check the regulation of the states through which you intend to travel Should be closed and secured Loose items should be secured or stored away CAUTION Be sure all loose items are secured or properly stored while the vehicle is in motion Possible overlooked items may include canned goods small appliances on countertop cooking pans on range or free standing furniture These items could become dangerous projectiles during a sudden stop Storage and equipment should be closed and locked also making sure that loose items are secured or stored for transit Door should be secured with the travel latch and the items inside made ready for transit Should be closed and secured or adjusted as desired If the motorhome was properly and carefully prepared for storage taking it out of storage will not be difficult The following checklist assumes that you stored your RV with care If you didn t and extensive freeze damage or other serious deterioration has occurred consult your dealer or
5. Sanitizing the System Monitor Panel Waste Water System Heated Holding Tanks Dumping the Holding Tanks How to Prevent Blockage of Drain Lines Termination Compartment Components Toilet LP System Propane Gas Tank Propane Regulator Propane Gas Hoses Propane Gas Safety Care and Maintenance Batteries Water System Waste Water System Fresh Water System Electrical System Generator Power System Propane System ABS Plastic Parts Awning Chassis Exterior Lights Fiberglass Exterior Graphics Paint Extrusions and Aluminum Surfaces Roof Roof Vents Seals amp Adhesives Slide Out Tires amp Rims TV Antenna 6 88 88 89 90 93 93 94 97 97 98 98 100 100 102 107 107 109 110 110 111 111 111 112 112 113 115 115 116 118 118 119 119 120 120 120 120 120 121 121 121 122 122 123 124 125 122 126 126 127 127 127 Underbody Windows amp Doors Hydraulic Fluid Appliances Bath Fixtures Bathtub Seal Bedspread amp Draperies Carpet High Pressure Laminate Countertop Hardware Kitchen Fixtures Blinds amp Shades Sinks Solid Surface Countertop Upholstery amp Fabrics Wall Coverings Pre Finished Panels Mold Winter Use and Storage Tips for Winter Use Water System Food Storage Propane System Heating Condensation Winterization Procedure Water Heater Bypass Winterization Checklist Travel Preparation Checklist Maintenance Schedule Fuel Oil Record Notes
6. Travel Preparation Travel Preparation Checklist Turn Signal Lane Change TV Antenna TV Hook up Under Bed Storage Underbody Undercarriage Checks Upholstery amp Fabrics Use of Bed Rails Using the Firmness Control System Ventilation Video Switch Box Wall Coverings Warranty Waste Water System Water Fill Water Heater Bypass Water Heater Door Water Heater Switch Water Pump Water System Weighing Your Motorhome Weight Capacity Weight Distribution Weights Wheel Lugs Where to Weigh Your Motorhome Windows Windows amp Doors Windows amp Vents Windshields Windshields Winter Use and Storage Winterization Winterization Checklist Winterization Procedure 150 38 118 47 105 68 56 106 39 108 61 57 32 68 108 9 88 98 18 115 66 59 86 85 98 113 21 20 22 20 18 24 55 106 18 14 18 18 113 14 115 113 REV 5 21 2014 Viv MOTOR COACH PO BOX 1486 ELKHART IN 46515 Toll Free 877 855 2867 thormotorcoach com
7. Do not sleep in this area Failure to comply may result in death or serious injury NON SLIP TREAD your garage floor is equipped with a special non slip flooring This flooring is to help aid you in loading and unloading your vehicles safely STORAGE CABINET There is a storage cabinet located at the back wall of the garage You may use this cabinet for holding small tools first aid kits small components and some personal gear TV HOOK UP There are receptacles located in the garage for your convience There is also a convience tv hook up TIE DOWNS On the garage floor Thor Motor Coach provides vehicle tie downs These are helpful for keeping your vehicles secure in transit Please make sure that all your vehicles and accessories are secure before you put the vehicle into motion SIDE AIR VENTS Use the air vents to allow air to move through the garage Make sure that these vents are open during travel to allow proper ventilation 68 Controls and Operations DO NOT UTILIZE THIS RV UNLESS FULLY SET UP AWARNING WINDOWS BECAUSE A SECONDARY MEANS OF ESCAPE IS NOT AVAILABLE FAILURE TO COMPLY COULD RESULT IN SERIOUS INJURY OR DEATH TO AVOID EXHAUST GAS ENTRY INTO THE Motorhome A DANGER KEEP WINDOWS CLOSED WHEN THE CHASSIS OR GENERATOR ENGINES ARE RUNNING All the windows that open in the motorhome are operated by sliding them back and forth To operate pivot the latch to release it from the locked position and sl
8. Permits using the auxiliary battery power to aid in starting the motorhome engine if the vehicle battery has become discharged When the ignition key is turned to the start position and one or more clicking sounds are heard it may be necessary to use the auxiliary start system as follows Always set the parking brake prior to using the auxiliary start system 1 Press and hold the AUX START switch located on the dash 2 Turn the key and start the engine in the normal manner 3 Release the AUX START switch and operate motorhome in a normal manner E Note Do not hold the ignition key in the start position for more than 30 seconds c Note Be careful not to run down the auxiliary RV battery as this could leave you without any 12 Volt power DASH FANS Provide air flow in the cockpit area They can be of assistance to the defroster system during cold temperatures or circulate cool air from your air conditioner during hot weather This is a two speed switch for low and high speed operation GENERATOR START A switch on the dash in the bedroom or on the generator allows remote starting or shutdown of your power generator When the generator is running a light on the dash switch will be illuminated An hour meter shows the total amount of time the generator has been in operation 46 Controls and Operations The steering wheel can be moved to allow additional room for entering and exiting the driver s seat as well as for sel
9. The 120 Volt power may be provided by either connecting the motorhome to an outside power source when parked or by use of a motorhome generator When the 120 Volt system is operational power also passes through a system converter allowing the full use of all 12 Volt functions in the motorhome 120 Volt appliances in the motorhome include the refrigerator ice maker roof mounted air conditioner s TVs DVD player microwave oven converter and the water heater The refrigerator also has the option of running on propane gas when 120 Volt power is not available All other electrical functions in the motorhome are supplied with 12 Volt power When it is not possible to access 120 volt power the 12 Volt system functions can be supplied by the auxiliary batteries The chassis battery is protected by a battery isolator controller to prevent discharge from excessive electrical consumption when the motorhome is not running The auxiliary batteries are recharged by the power converter when the motorhome is attached to an outside 120 volt power source or by the generator when it is running and by the chassis alternator when the chassis engine is running E gt Note These three shore power outlets are most commonly used SHORE CORD throughout the United States 50 Amp 30 Amp 15 20 Amp CONNECTING THE SHORE CORD TO A NON GROUNDED A DANGER OR IMPROPERLY GROUNDED POWER SOURCE DANGER CAN RESULT IN DANGEROUS AND POSSIBLY FATAL ELECTRIC SHOC
10. must be kept free of debris to keep the drain holes clear Vinyl seals around windows should be checked every six months cleaned regularly and kept pliable by use of a silicone spray make sure to follow the directions of the product Make sure that windows remain operative by adjusting and lubricating latches and moving parts annually Also check the condition and operation of the door locks adjusting and lubricating as necessary Use powdered graphite or light oil to lubricate moving parts on doors and windows Keep screens and window slides clean and free of debris to maintain proper operation and to avoid component damage Test the operation of all windows occasionally to make sure they are working properly making sure that they close flush and that the locks hold tight Moving parts of the entrance door and lock should be adjusted and lubricated at least once a year or as needed depending on use Screws and fasteners should be checked and tightened periodically Check weather stripping seals to assure proper fit and seal Refer to the Owner s Manual from the door manufacturer for more in depth instructions for care and maintenance of the entrance door Note Be aware that moisture can accumulate in locks and hinges of os windows and doors causing damage or faulty operation Do not force the operation of these components in subfreezing weather Check with your dealer if you are unsure about the correct methods of lubrication and a
11. not cracked or dried out If the vent tubes are clogged cracked or dried out the vent system will not work correctly allowing condensation to build up in the lamp If the tube is cracked or dried out please replace it Replacement parts can be acquired from your motorhome Dealer Head lamp seals should not be directly sprayed with high pressure home or industrial wash systems Damage to the seal can occur causing the housing to leak water Composite head lamps have a polycarbonate lens which is very sensitive to a variety of chemicals Contact with certain chemicals can cause crazing softening or cracking of the lens which would require replacement of the entire lamp housing The following chemicals are suspected to cause similar results Mild soap and water is recommended for the cleaning of your lamps DO NOT USE THE FOLLOWING TO CLEAN THE HEAD LAMP LENS Acetone Liquid Cleaner 8211 Agitene Liquid Detergents Benzyl Lysol Carbon Tetrachloride Oils Chlorinated Pink Lux phosphate free Citrus Orange Cleaners Stanisol Naphtha Corrosive or Caustic Cleaners 2 8006 8129 8757 Diversol Tricholor Gasoline Triclene Kleenol Products Toluol Lemon Joy Phosphate Free Lestiol E gt Note Damage to the lamp assembly by these chemicals is not covered under the manufacturer s warranty To prevent injuries and damage comply with any instructions provided by the bulb manufacturer Whenever working on any
12. of slip on footwear when ascending or descending the ladder o Note The rear ladder maximum weight capacity is 250 Ibs CAUTION IF THREATENING WEATHER APPROACHES YOU NEED TO RETRACT ALL AWNINGS If the awnings are rolled up wet open them back up as soon as possible to allow them to dry Do not drive during periods of high winds Doing so may cause damage to the awning Any damage to the awning caused by driving under such conditions will not be covered under warranty IN THE EVENT OF POWER LOSS OR AWNING MOTOR FAILURE THE AUTOMATIC PATIO AWNING CAN BE RETRACTED AS EXPLAINED BELOW If you do not feel comfortable performing this procedure contact the nearest authorized service center for assistance Do not drive the motorhome with the awning in the extended position The Slide Out Topper will automatically open and close as the slide out room opens and closes Because the awning is level water may puddle on top of the canopy As the slide out room is closed and the awning rolls up these puddles may spill over the sides of the awning CS Note For detailed information regarding the Slide out Topper Awning refer to the Slide Topper Installation And Operating Instructions Manual Release both travel clamps one on each arm about midway up Using the provided awning rod rotate the Safe T Lock lever up to the UNLOCK Controls and Operations OPEN position e Hook the awning rod into the pull strap loop securely and pul
13. weigh the vehicle at a public scale Keep in mind the number of safety belts in a unit are there for the convenience and use of the owner Carrying the number of people equal to the number of seat belts may exceed the weight ratings A motorhome has the potential to be overloaded and removal or redistribution of weight may be necessary from time to time to stay within weight ratings Your motorhome includes a Weight Information Label This label provides specific weight information for your motorhome as a guideline so that you can determine the load carrying capabilities The Thor Motor Coach Motorhome WEIGHT SPECIFICATIONS yellow label concisely states the occupant and cargo carrying capacity of your motorhome per the requirements of 49 CFR part 571 120 as issued by the National Highway Traffic Safety Administration NHTSA The yellow Motorhome OCCUPANT AND CARGO CARRYING CAPACITY weight label is affixed to the interior side of the forward most door of your motorhome on the passenger side This label indicated how much weight you can safely carry within the vehicle and is affixed to the entrance door directly below the window screen for Class A units and on the front door jamb for Class C units Planning and Preparation OLL The total weight of passengers cargo trailer tongue weight and water should never exceed the value shown on the label A typical example of this label is shown below for reference purposes only The numbers sho
14. A 50 AMP SERVICE WHICH PROVIDES A COMBINED TOTAL OF 240 VOLTS The 240 Volts comes from two separate 120 Volt lines that are in the shore power cord The motorhome should never be connected to any power source that will provide anything more than 120 Volts on either line coming in Failure to follow this will result in serious damage to internal items that are plugged in A 50 amp shoreline power cord is provided to attach the motorhome to a grounded power source When connecting or disconnecting from a grounded external power Source always turn off the shore power breaker to the power supply outlet This will prevent accidental shock and flashing of electrical contacts The chassis and or auxiliary batteries of a motorhome may be located behind the front hood of the motorhome or in an exterior compartment Please note that Sprinter chassis batteries are located inside the cab area underneath the driver s seat It is important to make sure that batteries are kept charged Take time to turn off all lights or other 12 Volt conveniences when not in use Connect the motorhome to a 120 volt power supply when possible instead of draining the batteries The charge condition of the batteries can be checked with the monitor panel To check press and hold monitor test switch while reading the charge level on the battery gauge Charge levels indicated are divided into sections from weak through fully charged When shore power is unavailable the coach batt
15. Be sure to hold the button until the Iside is fully extended or retracted and 3 5 seconds after the motors have stopped running Controls and Operations Awning To extend or retract the awning press and hold the arrow buttons The left pointing arrow button will extend the awning The right pointing arrow button will retract the awning Be sure to hold the button until the awning is fully extended or retracted Leveling Press the Auto Level button to auto level the coach Generator Press the Start button to start the generator Press the Stop button to stop the generator E Start Stop Oe 57 Controls and Operations AUTOMATIC HYDRAULIC POWER LEVELERS Automatic Leveling 58 And Retraction Procedure A DANGER FAILURE TOACT INACCORDANCE WITH THE FOLLOWING MAY RESULT IN SERIOUS PERSONAL INJURY OR DEATH Read the entire operators manual and all precautions prior to operating this equipment Do not use the jacks to change the tires The system is designed as a leveling and stabilizing system and is not meant to lift the motorhome off the ground Do not operate any system functions while anyone is under the motorhome Make sure that people and pets are clear of the coach when operating the leveling system Do not attempt to operate the system while the motorhome is in motion Never place hands or other parts of the body near hydraulic leaks Oil may penetrate skin causing severe inju
16. FIRE EXTINGUISHER 1 Check Pressure monthly or more often Check the nozzle for obstruction Press the green pin below the nozzle If it returns and Sticks out from the extinguisher it is operable If the pin does not come back discard extinguisher Refillable models have a pressure gauge to check 2 Check the Tamper Tape to make sure it is intact DO NOT test the extinguisher Even a partial discharge may cause leakage 3 When checking the extinguisher for pressure enter the date checked on the Inspection Tag furnished with the motorhome Regular inspections will help insure the condition 4 Agitate Dry Chemical every six 6 months by inverting the bottle and lightly shaking for several seconds This will help prevent the dry chemical from settling due to in motion vibrations BOTH THE SMOKE ALARM AND THE CARBON CARBON MONOXIDE ALARM CANNOT OPERATE WITHOUT MONOXIDE AND A 9 VOLT BATTERY Removing the battery for any SMOKE reason or failing to replace the battery at the end of DETECTORS it S service life removes your protection Refer to the manufacturers owner s manual for proper replacement batteries Test smoke detector operation after vehicle has AWARNING been in storage before each trip and at least once per week during use Replace battery every six months 27 Identification and Safety 28 Testing Procedure AWARNING The motorhome should never be operated or occupied unless the smoke detector is present and f
17. H ae This manual describes many features of your motorhome and provides a guide to operating procedures so that you can obtain the best performance from those features Your motorhome has been designed to conform with or exceed the American National Standards Institute A 119 2 NFPA 1192 CANADIAN CAN CSA Z240 RV SERIES 99 Canadian built or units built for Canada and applicable motor vehicle safety standards These standards establish the plumbing heating electrical and other requirements for quality and safety The seal attached just outside the entry door indicates compliance with these standards This seal is the outward sign of internal quality Like all automotive equipment your motorhome will require care and regular maintenance in order to retain its maximum performance characteristics This manual along with the specific instructions provided by the leading appliance manufacturers are in your Owner s Information Kit The Chassis Operator s Manual outlines important areas of service and provides a maintenance schedule Please follow them carefully to ensure a safe trouble free service Study these instructions carefully A good working knowledge of your unit and how to care for it will help you enjoy many miles and years of recreational living If you have any questions regarding operation maintenance or service please contact your dealer immediately so they can assist you Your dealer s Service or Sales Department is equipped to ha
18. Index 128 128 128 128 128 129 129 129 129 129 129 129 129 129 129 130 130 130 135 135 135 135 135 135 135 135 137 137 140 141 144 146 148 Introduction How to Use This Manual Your motorhome has been thoroughly inspected before shipment to the dealer Your selling dealer is responsible for performing a complete pre delivery inspection of all motorhome components as specified in the pre delivery checklists supplied by the manufacturer You should receive a copy of these completed checklists from your dealer when the motorhome is delivered to you Should a problem arise your first step is to contact your selling Thor Motor Coach dealer who will be glad to handle your situation This Owner s Manual is not intended for use as a service manual but rather as a guide to help you become familiar with your motorhome This manual is not model specific which means that it is used for a variety of different models that Thor Motor Coach manufactures It is of a general nature so the illustrations and descriptions may not be exactly as they are in your particular motorhome If you are unclear or unfamiliar with any procedure that is described in this manual see your Thor Motor Coach dealer for further clarification before proceeding Thor Motor Coach uses the following notations to warn the user of possible safety concerns and to provide information that will prevent personal injury to the user and or damage to the m
19. LCD thermostat must be in the OFF Mode Press either the or button to display the Inside Temperature Vents are provided in the motorhome to circulate fresh air and exhaust odors The power vent includes a 12 VDC powered fan A hand crank controls opening and closing and adjustment of the vent cover while a push button turns the exhaust fan ON and OFF Make sure to turn the fan OFF before closing the vent Also be sure to remove any debris that falls into the vent that may restrict operation It is extremely important that you use the fans and vent every time you use the shower or tub to eliminate excess condensation Note For best results close all other roof vents and open one window or door the greatest distance from the exhaust vent gt Note The dome must be open prior to operating the fan motor Heating and Air Conditioning The fan is a three speed fan which can extract air from the motorhome To operate Manual the fan use the following guidelines Dome Operation the fan speed control dial to the desired performance level If the 0 setting is selected the fan acts as a vent only Slightly open a window for maximum air flow e Set your interior temperature on the wall mounted thermostat between 60 F and 90 F When the interior temperature is warmer than setting the dome opens automatically and the fan blade turns on to the pre selected speed e f your vent is supplied with a rai
20. REAR VISION SYSTEM VISION SYSTEM A SURE TO CHECK THE MIRRORS WHEN DRIVING AND BACKING FOR A MORE COMPLETE FIELD OF VISION The camera is equipped with a wide angle lens that can initially present an image that may be deceiving Make sure to practice backing in a safe place using the monitor to become accustomed to it s operation The monitor for the back up camera is located in or on the dash It will turn on when the gear selector is placed in reverse or when you engage its power button It will allow you to see behind your vehicle as you back up or park The camera is located on the rear cap of the coach This system gives a televised view of what is behind the motorhome It is used as an aid in backing the motorhome and can also be used for greater field of vision when driving in heavy traffic The picture is a representation only Your actual system may look different than that pictured Rear Vision Systems vary within our motorhomes Some motorhomes come equipped with a dash radio rear vision monitor combination and others have separate radios and rear vision systems Please consult the manuals that came with your coach for specific operating instructions 1 Power On Off 2 Menu 3 Select 4 5 Up Down 6 Day Night 7 8 Volume 12345678 Press once turns unit on Press again turns unit off When power applied and unit is off only the red power button is backlit When unit i
21. Rapid Camp Automatic Hydraulic Power Levelers Slide Outs Garage Non Slip Tread Storage Cabinet TV Hook up Tie Down Tracks Side Air Vents Windows Storage Above Cockpit Living Room Television Doors amp Drawers Under Bed Storage Furniture Dinette Chairs Bedroom Door amp Latch Blinds amp Shades Water Heater Switch Kitchen Cabinets Kitchen Drawers Kitchen Pantry Range Refrigerator Microwave Convection Oven Kitchen Sink Kitchen Faucet Shower Head amp Hose Elevated Beds Entry Door Assist Handle Electric Step Compartment Doors amp Storage Compartments Rear Ladder Awnings Cabel Hook Up Phone Jack Generator Compartment Furnace Door Water Heater Door Refrigerator Door Entertainment Television Home Theater System Exterior Entertainment Center Video Switch Box TV Hook up Sample A V Hook Up Diagrams Heating and Air Conditioning Dash Panel Heater and Air Conditioner 54 56 58 64 68 68 68 68 68 68 69 70 70 70 70 71 72 72 73 73 73 73 73 73 73 74 74 74 74 74 75 76 76 76 TT 78 78 80 80 80 80 80 82 82 82 82 82 82 82 87 87 5 Table of Contents Roof Mounted Air Conditioner Furnace Thermostats Ceiling Vents Electrical Systems Shore Cord Batteries Power Converter Ground Fault Circuit Interrupter 12V System Fuses Circuit Breakers Chassis Alternator Generator Inverter Water Systems Fresh Water System Low Point Drains
22. WHEN YOU TAKE DELIVERY OF THE MOTORHOME OR YOU USE YOUR MOTORHOME FOR COMMERCIAL OR BUSINESS PURPOSES OTHERTHAN FOR RENTAL PURPOSES ANY ACTION TO ENFORCE THIS LIMITED WARRANTY OR ANY IMPLIED WARRANTIES SHALL NOT BE COMMENCED MORE THAN ONE YEAR AFTER THE EXPIRATION OF THE WARRANTY COVERAGE PERIOD DESIGNATED ABOVE UNLESS PROHIBITED BY STATE LAW THE PERFORMANCE OF REPAIRS SHALL NOT SUSPEND THIS LIMITATIONS PERIOD FROM EXPIRING AND ANY LEGAL ACTION TO ENFORCE WARRANTY RIGHTS AGAINST WARRANTOR MUST BE BROUGHT WITHIN THE STATE OF INDIANA Some states do not allow the reduction in the statute of limitations so the above reduction in the statute of limitations may not apply to you Warrantor participates in the Consumer Arbitration Program for Recreational Vehicles CAP RV operated by DeMars amp Associates The CAP RV program operates as a certified mechanism under the review of the California Arbitration Certification Program You must utilize the arbitration program before claiming rights conferred by 15 USC section 2310 Uniform Commercial Code or Civil Code section 1793 22 b Tanner Act You are not required to use the program if you choose to seek redress by pursuing rights and remedies not created by those laws To find out more about the program orto request an application brochure please call the Arbitration Administrator Office toll free 800 279 5343 Members of the Armed Forces who purchased the vehicle in California or who were stationed in or
23. access the audio menu You can navigate through the audio menu items by pressing the AUDIO MENU button repeatedly 4 Mode Press to select a different mode of operation Available modes include Tuner SiriusXM CD iPod and AUX In 5 RPT Press during disc play to repeat play the current track Press 3 RPT again to stop repeat play 6 INT Press play the first 10 seconds of each track sequentially Press again to stop Intro Scan and resume normal play at the current track 7 RDM Press during disc play to play all tracks on a CD in random shuffled order Press 4 RDM again to stop random play 8 Pause Press to suspend disc play Press again to resume disc play 9 File Navigation Press the 5 button to move to the previous folder 10 File NAvigation Press the 6 button to advance to the next folder 11 Equalizer Press select one of the following equalization sound settings Flat Rock Classical Pop or User 12 Scroll When the information is too long to be displayed on the LCD press and hold to view the entire title The information will scroll twice and then return to abbreviated text 13 14 CAT CAT Press to change the category Each category title will be displayed in increments Press the CAT buttons again to view category names 15 AS PS Press and hold for more than three seconds to automatically select six strong stations and store them in the current band 52 Controls and Operations 16 BAND SEARCH Press to ch
24. an authorized service center for advice e Thoroughly inspect the outside of your RV Look for animal s nests in wheel wells in engine air cleaner or in other out of the way places Clean all appliance exhaust vents ceiling vents and air conditioning covers Planning and Preparation Changing the wiper blades on your motorhome is similar to your car Remove the screw take off the old blade and replace with a similar style and length blade Lubricating pivot points with thin lubricating oil is also recommended e Check that all furnace water heater and refrigerator openings are free of debris insect nests webs etc e Open all doors and compartments Check for animal or insect intrusion water damage or other deterioration e Check charge level in batteries Refill with distilled water and recharge if necessary Reinstall batteries if necessary Be sure cable ends and terminals are clean and free of corrosion Turn the Battery Disconnect Switch off if applicable e Check tire pressure Inflate to the specified cold pressure Remove coverings from windows if necessary e Open vents and windows for ventilation Drain flush and sanitize the fresh water system Inspect drain lines for leaks Replace if necessary Do not try to repair as this is usually ineffective Install a new water filter if your unit is equipped with this Operate all faucets and fixtures in the fresh water system Check for leaks at all join
25. and the alarm should sound Release the switch This is the only way you should test your detector The test feature checks the full operation of the detector If this detector does not test properly return it immediately for repair or replacement This test procedure should be repeated every week or every time the motorhome is taken on a trip Note Referto the detector manufacturer if you have any questions about the Propane Gas Detector Checking the ROAD VIBRATION CAN LOOSEN PROPANE FITTINGS It A WARNING Propane System for is important to check the Propane system for leaks at least every 5 000 miles and whenever the tank is filled It is also Leaks a good idea to have the entire Propane system checked annually by a qualified Propane service representative 31 Identification and Safety Causes of Apparent 32 Most Malfunction Use the following steps when checking the system for leaks 1 Open all the windows and vents 2 Open the gas tank service valve 3 Use non ammoniate non chlorinated soap solution or an approved leak detection solution on all line connections Ammoniate soap solutions can cause cracking on copper or brass lines and fittings 4 Ifa leak is detected tighten the connection with two open end wrenches until bubbling stops DO NOT over tighten or use excessive force If the leak continues contact the motorhome dealer or a qualified Propane service representative to have an
26. and warm interior temperatures will collide on wall surfaces thus creating condensation Use a fan to keep air circulation inside the vehicle so condensation and mildew cannot form in dead air spaces Allow air to circulate inside closets and cabinets leave doors partially open Please keep in mind that a closed cabinet full of stored goods prevents circulation and allow the exterior temperature to cause condensation The natural tendency would be to close the vehicle tightly during cold weather This will actually compound the problem Simply put you need to remove some of the warm air and allow some cool outside air to get inside the vehicle so the furnace will not recycle the humid interior air Use fluorescent ceiling lights and minimize prolonged use of incandescent lights which produce heat and contribute to condensation in the roof above the ceiling lights Cooler surface temperatures increase the potential for condensation and surface mold growth To minimize the opportunity for condensation to form on interior surfaces maintain a comfortable temperature in the motorhome and avoid nighttime setbacks of 10 or more Drastic setbacks that reduce the indoor air temperature quickly can increase the chance for airborne moisture to condense on cool surfaces such as windows If you are away from the motorhome for an extended number of days we recommend that you do not set the temperature back without taking other measures to manage rela
27. as necessary Remove the old worn seals first before reapplying the new seals Check with your dealer for the 125 Care and Maintenance 126 ROOF VENTS SEALS amp ADHESIVES type of caulking required for thermoplastic polyolefins TPO roofs and the correct methods of resealing Silicones and synthetic sealers cannot be used on the rubber roofs Special sealers are also required for the skylights Your Thor Motor Coach dealer may perform the periodic roof seals for you if desired It is especially important to check the seals before and after periods of extended storage or non use Fall and spring inspections are recommended Check the membrane for possible damage and check all accessories and fasteners The roof may be cut or punctured by sharp objects so care must be taken when parking and driving If damage does occur the roof may be patched Check with your dealer for additional information Parking in areas where fruits nuts or tree sap may stay on the roof for extended periods of time may result in irremovable stains For Normal Cleaning Usea mild laundry detergent e Rinse the complete roof with clean water to remove any loose dirt or debris Use a medium nylon bristle brush along with your selected cleanser mixed with water and scrub the entire roof Rinse thoroughly with clean water to avoid residue buildup on the roof or sidewall of the unit e For more difficult stains contact your Thor Motor Coach dealer for th
28. battery electrolyte solution is splashed in the eyes or on the skin immediately flush with clean water for 15 minutes In case of eye contact seek immediate medical treatment Never add acid to a battery once the battery has been placed in service Doing so may result in hazardous splattering of electrolyte solution Battery maintenance is important Checking the condition of a battery at regular intervals will help insure its proper operation Here are some recommendations for checking and servicing batteries 22 Note These instructions apply only to batteries which are not maintenance free batteries Do not open or break seals on maintenance free batteries 1 Keep the battery mounted securely Vibration causes early failure of many batteries 2 Check the electrolyte level of the auxiliary batteries at regular intervals Keep each cell filled to just above the plates with distilled water Once the plates have dried out they cannot be reactivated and the capacity of the battery is reduced in direct proportion to the area of plate surface that has become dry This kind of damage can occur quickly usually it can happen overnight If the fluid level is low simply add distilled water 3 Keep the battery clean Corroded terminals make poor contact and do not allow the chassis alternator or the converter to bring the battery up to full charge Battery sulfation occurs when the battery has been standing in a discharged condition over
29. dealer and we the manufacturer will continually strive to merit your confidence CAUTION Some equipment and features described or shown in this manual may be optional on your model This instructional manual is of a general nature only Because of the continuous process of product improvement conducted by Thor Motor Coach it is possible that recent product changes may not be included in this manual Specifications may change without notice This manual is accurate as of the date of publication The instructions included in this manual are intended as a guide and in no respect extend the responsibilities of the manufacturing subsidiary parent company or affiliates beyond the standard written warranty as presented in this manual C Note Photographs or illustrations in this manual are representative of function and may or may not be specific in their depiction of actual equipment fabrics interior or exterior decor or design options as installed on or in your motorhome CAUTION This product is designed to provide temporary living quarters for recreational camping or travel Use of this product for long term or permanent occupancy may lead to premature deterioration of interior finishes fabrics carpeting drapes or components Damage or deterioration due to long term occupancy may not be considered normal and may under the terms of the warranty constitute misuse abuse or neglect and may therefore reduce or void certain warranty p
30. electrical system switch off the electrical accessory you are working on or refer to the electrical system section of your owner s manual Failure to do this could result in short circuits When replacing the halogen bulb do not touch the glass portion of the bulb with your bare hands since even small amounts of impurities burn into the surface and reduce the service life of the bulb Use a clean cloth paper napkin or similar material to hold the bulb during installation With most bulbs you will not need to touch the glass part to install the bulb The exterior of your motorhome is made of pre finished aluminum and fiberglass Wash it frequently with a warm water mild detergent and a soft rag Take care to avoid spraying water directly into refrigerator and furnace vents when washing the motorhome FIBERGLASS 123 Care and Maintenance 124 EXTERIOR GRAPHICS PAINT If you travel roads that have been salted for ice wash your motorhome as soon as possible The most common causes of corrosion are accumulation of road salt dirt and moisture in hard to reach areas under the motorhome Make sure you wash the undercarriage and wheel wells as well as the exterior of the motorhome A good automotive cleaner may be used occasionally to remove tree sap road tar insects and industrial pollution that may damage surfaces Do not use naphtha or turpentine We recommend that you wash your motorhome about every three weeks It is impor
31. environment and time can both contribute to the deterioration of these components they must be inspected for wear at regular intervals Be sure to inspect the hose before each season and when having the tank refilled Look for signs of deterioration such as cracks or loss of flexibility When replacing the hose or other propane components always replace them with components of the same type and rating Check with your dealer regarding proper replacement components DO NOT STORE PROPANE GAS CONTAINERS INSIDE AWARNING THE Motorhome PROPANE GAS CONTAINERS ARE EQUIPPED WITH SAFETY DEVICES WHICH RELIEVE EXCESSIVE PRESSURE BY DISCHARGING GAS TO THE ATMOSPHERE FAILURE TO COMPLY COULD RESULT IN AN EXPLOSION RESULTING IN DEATH OR SERIOUS INJURY This vehicle is designed with a propane system to provide a safe and reliable fuel Source for your range furnace water heater and refrigerator As with any flammable and volatile material proper handling and precautions should be exercised at all times The following warnings must be reviewed and adhered to for safe and trouble free operation If you smell propane gas Extinguish any open flames pilot lights and all smoking materials DO NOT touch any electrical switches Shut off the gas supply at the tank valve s or gas supply connection Open all doors and other ventilating openings DO NOT USE THE RANGE HOOD 5 Leave the area until the odor clears 6 Have the system checked by a trai
32. function Switch locations may be different from model to model The dash radio can be played without turning the ignition key on provided that the battery disconnect is in the use position For units with the home theater the dash radio can only be played if the ignition is in the accessory or run position The cruise controls are on the turn signal lever You can set resume and disengage the cruise control from this location The gear selector is located on the right side of the steering wheel Pull the lever toward you to place into the desired gear Be sure the service brake is applied when making this selection See the Chassis Owner s Manual for more information Some models have an overdrive switch on the end Press the button to engage disengage to overdrive function Below are descriptions of the various controls on your dashboard Please keep in mind that these controls may be located in different positions styles or not available depending on the model of your particular vehicle SUNVISORS These switches control the sunvisors Each shade works separately with each assigned switch Lower the sunshade to desired level HEATED MIRRORS Use this switch to defrost your mirrors ICC Courtesy Flasher DOT Lights Flash after a semi truck passes you or as a thank you flasher when you are passing WIPERS This switch is for HIGH LOW or intermittent operation WASHER This switch located on to the wiper
33. if a charge comes on or if the alternator indicates neutral Then apply a drain on the system to see if a discharge returns If a discharge persists contact your dealer When stopped at a campsite that allows you use of the shoreline the 120 volt electrical system will recharge your auxiliary battery Under heavy usage in warm weather check the fluid level of those batteries that require attention to fluids quite often Low battery fluid level is very harmful to the battery s longevity CARBON MONOXIDE IS POISONOUS AND CAN CAUSE DANGER UNCONSCIOUSNESS AND DEATH TO AVOID EXHAUST GAS ENTRY INTO THE Motorhome A DANGER KEEP WINDOWS CLOSED WHEN THE CHASSIS OR GENERATOR ENGINES ARE RUNNING Note sure to read and understand the generator owner s manual before operating the generator Observe all operating instructions and warnings as well as all recommended maintenance schedules and procedures The onboard generator allows the motorhome to be fully self contained It provides access to 120 Volt A C when shore power is unavailable but keep in mind that when in use the generator exhausts deadly carbon monoxide gas NEVER sleep in the motorhome with the generator running Before you start and use the generator inspect Electrical Systems the exhaust system Do not use the generator if the exhaust system is damaged Test the carbon monoxide detector every time you use the motorhome Know what the symptoms of carbon monoxi
34. is a 50 Amp Reset Button in the Battery Control Center located under the hood Remove cover from the black box to access Note On a Class C gas motorhome there is a 50 amp reset button located behind the converter The automotive chassis 12 volt system alternator supplies power to both the automotive systems as well as any auxiliary battery if equipped and directly to the motorhome living quarters while the vehicle s motor is running The alternator compensates for electrical usage in the vehicle the power drawn by the appliances lights fans and other 12 volt powered items as well as the charging of the automotive and auxiliary batteries If the alternator isn t keeping pace with the draw on the unit s electrical system while driving down the road it means you re working in a negative mode more power is being used than the unit is putting out This means that you are taking power out of the batteries If you draw too much power from the batteries there may not be enough power left in the battery to start the motorhome or run any of the appliances when you stop for a break or for the night The alternator will charge at a higher rate right after the vehicle s been started replacing the power used to start the vehicle but the charging should quickly go back to normal and hold its own even when you turn on lights or appliances If the alternator shows a discharge while the motor is running turn off appliances and lights to see
35. is detected the GFCI will trip and shut off power to the outlet The GFCI also does not protect against short circuits or system overloads Circuit breakers in the main panel which supply power to the circuit will trip if either of these conditions exist Battery Charging POWER CONVERTER GROUND FAULT CIRCUIT INTERRUPTER TEST 1831 RESET 1353 97 Electrical Systems 12 VOLT SYSTEM FUSES To test the circuit use the following procedure 98 Interior Automotive CIRCUIT BREAKERS The GFCI receptacle should be tested initially when the motorhome is purchased and at least monthly thereafter 1 Make sure power is on to the circuit A test light or 120 volt lamp will work 2 Push the test button 3 The red reset button should pop out 4 All power should be interrupted to outlets protected by the GFCI 5 Verify by plugging in a light at these outlets and pushing in the reset button If the red reset button does not pop out after pushing the test button or GFCI circuit continues to trip or if the power is not interrupted to the test light immediately turn off power at the circuit breaker panel and have a qualified electrician check it out Note does not protect any circuit other than the one to which it is connected A 12 Volt DC distribution panel is located next to the 120 Volt circuit b
36. large commercial truck stops You can also look in the telephone book under weighers or weighing Allow adequate time since the entire weighing process can take up to 30 minutes There may be a small fee for each weight taken but the expense is a worth while investment toward the safe and economical operation of your motorhome Your motorhome must be weighed fully loaded That is with passengers food cloth How To Weigh Your ing fuel water propane supplies etc Any towed vehicle car pickup boat or Motorhome trailer or item loaded on brackets on the back of the motorhome should also be included in the weighing 1 The following steps are suggested when using a long platform scale a Pull onto the scale so that only the front axle is on the platform with the end of the scale midway between the front Reading a and rear axles and record the scaled weight b Pull forward until the full unit is on the scale and record the weight c Pull forward so that only the rear axle is on the scale and record the weight Reading c 21 Planning and Preparation 22 Weight Distribution gt gt Note Even though the weight of the total axle may be within the axle s rating it may be overloaded on one side This causes one wheel position to be overloaded Therefore side to side weighing should be done To obtain the individual wheel position weights repeat this process with only one side of the motorhome o
37. levels of formaldehyde are also released from smoking cooking use of soaps and detergents such as carpet shampoos cosmetics and many other household products Some people are very sensitive to formaldehyde while others may not have any reaction to the same levels of formaldehyde Amounts released decrease over time To reduce or lessen exposure to chemicals from off gassing it is of utmost importance Ventilation that you ventilate your motorhome Ventilation should occur frequently after purchase and at times when the temperatures and humidity are elevated Remember off gassing is accelerated by heat and humidity Open windows exhaust vents and doors Operate ceiling and or other fans roof air conditioners and furnaces and use a fan to force stale air out and bring fresh air in Decreasing the flow of air by sealing the motorhome increases the formaldehyde level in the indoor air Please also follow the recommendations contained in Care AND Maintenance section regarding tips to avoid condensation problems e Note We recommend that you do not smoke inside your motorhome In addition to causing damage to your motorhome tobacco smoke releases formaldehyde and other toxic chemicals Note f you have any questions regarding the health effects of formaldehyde please consult your doctor or local health department Note Chemical off gassing is not a defect in your motorhome and is not covered by the Limited Warranty Pleas
38. openings are not obstructed Reduce the ambient temperature E08 Red Over temperature shutdown Allow the unit to cool off Improve ventilation Make sure the inverters ventilation openings are not obstructed Electrical Systems gt gt Note The WFCO inverter is a dumb inverter This means that in order for WFCO shore power to pass through the inverter s power must be on On Off button Turns the inverter on and off LCD Display Indicates operation status LED Indicator Yellow Battery backup status Green AC input status Red Inverter failure 105 106 Water Systems The motorhome plumbing system has the dual ability to be self contained FRESH WATER with on board storage or use facilities provided by an external pressurized SYSTEM source In either case the components of the system operate like those in your home Components of the plumbing system consist of strong lightweight corrosion resistant materials that provide long life and easy cleaning By following the instructions outlined here you can expect efficient operation with a minimum of maintenance Motorhome plumbing can be divided into two separate systems The fresh water system consists of those items which are used to deliver water for your use while the waste water system is made up of the drains and tanks which store and remove water that has been used Water provided from outside the motorhome is pressurized by the system fro
39. products will keep them looking like new for many seasons of use Clean pre finished panels with a spray type furniture polish Avoid getting wood surfaces wet Wipe off and dry immediately if this occurs Do not use abrasive cleansers around wood finishes Clean regularly with a soft cloth and cleaner designed for wood products such as lemon oil or any oil based wood cleaning product Avoid constant exposure to direct sunlight which can cause fading and drying of wood surfaces Molds are microscopic organisms that naturally occur in virtually every environment indoors and out Outdoors mold growth is important in the decomposition of plants Indoors mold growth is unfavorable Left unchecked molds break down natural materials such as wood products and fabric Knowing the potential risks is important for an owner to protect their investment According to the Center for Disease Control exposure to damp and moldy environments may cause a variety of health effects or none at all Some people are sensitive to molds For these people molds can cause nasal stuffiness throat irritation coughing or wheezing eye irritation or in some cases skin irritation People with mold allergies may have more severe reactions Immune compromised people and those with chronic lung illnesses such as obstructive lung disease may get serious infections in their lungs when they are exposed to mold For mold growth to occur temperatures indoor or outdoors m
40. purchase your new motorhome and sometimes after it has been CHEMICAL closed up for an extended period of time you may notice a strong odor and chemical SENSITIVITY sensitivity This is not a defect in your motorhome Like your home there are many different products used in the construction of motorhomes such as carpet linoleum plywood insulation upholstery etc Formaldehyde is also the by product of combustion and numerous household products such as some paints coatings and cosmetics However motorhomes are much smaller than your home and therefore the exchange of air inside a motorhome is significantly less than a home These products when new or when exposed to elevated temperatures and or humidity may off gas different chemicals including formaldehyde This off gassing in combination with the minimal air exchange may cause you to experience irritation of the eyes nose and throat and sometimes headache nausea and a variety of asthma like symptoms Elderly persons and young children as well as anyone with a history of asthma allergies or lung problems may be more susceptible to the effects of off gassing Most of the attention regarding chemical off gassing surrounds formaldehyde Formaldehyde Formaldehyde is a naturally occurring substance It is also a key industrial chemical used in the manufacture of the numerous consumer products which we referred to above and used in the construction of motorhomes Trace
41. responsibility as normal maintenance HOW TO GET SERVICE The Acknowledgement of Receipt of Warranty Product Information form must be returned to Warrantor promptly upon purchase to assure proper part replacement and repair of your motorhome Failure to return the Acknowledgement of Receipt of Warranty Product Information form will not affect your rights under the Limited Warranty so long as you can furnish proof of purchase For warranty service simply contact one of Warrantor s authorized service centers for an appointment then deliver your motorhome at your expense to the service center If you need assistance in locating an authorized warranty service facility contact Warrantor s Warranty Department 877 855 2867 The mailing address is PO Box 1486 Elkhart Indiana 46515 1486 WHAT THE WARRANTY DOES NOT COVER This Limited Warranty does not cover any motorhome used for rental purposes and any motorhome sold or registered outside of the United States or Canada items which are added or changed after the motorhome leaves Warrantor s possession items that are working as designed but with which you are unhappy with because of the design normal wear and usage such as fading or discoloration of fabrics or the effects of moisture inside the motorhome defacing scratching dents and chips on any surface or fabric of the motorhome not caused by Warrantor owner maintenance including by way of example replacement of wiper blades bulb
42. run to clear all water from lines Turn off the water pump 6 Open all low point and water tank drains 7 Open the water heater cover and remove the water heater drain plug located on the lower front side of the water heater see photo MAKE SURE THAT THE WATER HEATER HAS COOLED DOWN BEFORE DRAINING 8 Hookanairhosetothe city waterconnection located in the termination compartment Blow out the water lines do not exceed 55 P S I until no more water can be seen coming out of the lines Pause for several seconds and repeat until clear 9 Put nontoxic RV antifreeze in the drains p traps and water tanks If you do not have access to an air compressor you may use the wet method of winterization After you have completely drained all the tanks water heater and lines by opening the low point drains and switching the water heater bypass valves to the bypass position close the low point water tank and the water heater drains Pour 4 6 gallons of RV antifreeze into the fresh water tank and let the water pump circulate the mixture Do not dilute Open the furthest faucet or water valve from the pump and work your way through the entire system Turn on one hot and cold at a time until the antifreeze solution is observed then close the valve Allow at least 2 cups to pass through for complete protection Make sure to include all water lines such as showers and tubs toilet washing machines dishwashers ice makers and outside shower f
43. sequentially Press again to stop Intro Scan and resume normal play at the current track 7 RDM Press during disc play to play all tracks in the current folder in random shuffled order Press again to stop random play 8 Preset button 9 Preset button 10 Preset button 11 EQUALIZER Press select one of the following equalization sound settings Flat Rock Classical Pop or User 12 USB port 13 PTY CAT MENU Press and hold for more than 3 seconds to enter the system menu 14 Info Scroll When in Sirius Satellite Radio USB or iPod mode press to switch between artist and title program information 15 AS PS FAV 49 Controls and Operations Press and hold for more than three seconds to automatically select eighteen strong stations for FM or twelve for AM and store them in all bands 16 BAND Press to change between three FM bands and two AM bands 17 WB In any mode press to access the weather band 18 Reset Use a ball point pen or thin metal object to press the RESET button 18 The reset button should be activated for the following reasons initial installation of the unit when all wiring is completed function buttons do not operate error symbol on the display 19 20 SEEK V SEEK Press to seek the next strong station 21 Auxiliary Input Connect the portable audio player to the 3 5mm stereo AUX IN connector on the front panel 22 TUNE ENTER Rotate to highlight the desired item or manually select a radio
44. station Press to select a value for the highlighted item 23 Eject button 24 Disc slot 26 Mute Pause Press mute the audio output or pause playback Press again to restore the audio output to the previous level or resume playback 27 Preset Buttons Can be used to store 6 channels per band allowing convenient access to your favorite channels 8 car Y MM A 2 IESSE 1 Sony Radio A Lal 27272727 207 1 ZAP button enter ZAPPIN mode 2 BROWSE button To enter the Quick BrowZer mode CD USB list the station Pandora via USB list the channels SiriusXM 3 Control dial ENTER MENU APP button Rotate to adjust volume Press to enter setup mode Press and hold for more than 2 seconds to establish App Remote 50 Controls and Operations After pressing Source Off rotate then press to change the source 4 SOURCE OFF button Press to turn on the power select the source Radio CD USB Pandora via USB AUX Press repeatedly to change to another source Press and hold for 1 second to turn off the power Press and hold for more than 2 seconds to turn off the power and the display disappears 5 DSPL Display SCRL Scroll button To change display items press scroll a display item press and hold 6 Disc slot Insert the disc label side up playback starts 7 Display window 8 Eject button To eject the disc 9 BACK MODE button Press to return to the previous display Sel
45. steel or aluminum frame structure only of the sidewalls excluding slide outs roof and rear and front walls for twenty four 24 months from the original retail purchase date or the first 24 000 miles of use whichever occurs first Warrantor s Limited Warranty is not transferable and only applies to the first retail owner of the motorhome If the motorhome is not of the current or prior model year when you take delivery of the motorhome OR you register your new motorhome in a business name or use your motorhome for any commercial or business purposes other than for rental purposes the duration of the limited warranty ends ninety 90 days after you first take delivery of the motorhome or after the odometer reaches 5 000 miles whichever occurs first The duration of the Limited Warranty covering the steel or aluminum frame structure only of the sidewalls excluding slide outs roof and rear and front walls ends twelve 12 months after you first take delivery of the motorhome or after the odometer reaches 15 000 miles whichever occurs first A conclusive presumption that your motorhome has been used for commercial and or business purposes arises if you have filed a federal or state tax form claiming any business tax benefit related to your ownership of the motorhome LIMITATION AND DISCLAIMER OF IMPLIED WARRANTIES IMPLIEDWARRANTIES IF ANY ARISING BY WAY OF STATELAW INCLUDING ANY IMPLIEDWARRANTY OF MERCHANTABILITY AND ANY IMPLIED WARRANTY
46. stronger cleaners but be sure to read the label to determine if the product is recommended for use on plastics Avoid abrasive cleansers even the liquid and cream types alcohol based products and solvents such as acetone and MEK Gasoline and kerosene should not be used because of the damaging effect they have on the plastic surface as well as the fire hazard they present Often the damage caused by solvents alcohol and oil based products may not be immediately noticeable but the plastic is made weaker and thus more prone to stress cracking AVOID ABRASIVE CLEANSERS even the liquid and CAUTION cream types alcohol based products and solvents such as acetone and MEK Gasoline and kerosene should not be used because of the damaging effect they have on the plastic surface as well as the fire hazard they present Often the damage caused by solvents alcohol citrus based and oil based products may not be immediately noticeable but the plastic is made weaker and prone to stress cracking The front suspension and steering system of this vehicle was factory aligned using ALIGNMENT highly accurate equipment prior to delivery to the dealership However we recommend that alignment be checked and if necessary adjusted after you have fully loaded the motorhome according to your personal needs Thereafter the alignment should be inspected annually to help prevent uneven tire wear All alignments and incurred costs are the respo
47. switch provides washer fluid to the windshield Check the washer fluid level prior to trips Some washer fluid can freeze so be aware of the temperature conditions where you will be traveling in order to add the proper type of fluid to your washer reservoir REMOTE MIRRORS This switch allows you to set the viewing angle of your mirrors from the convenience of the driver s seat To adjust the driver s side mirror move the lever to the left For the passenger s side move the lever to the right and adjust as needed AUTOMOTIVE DASH A GEAR SELECTOR DASH CONTROLS 0 DRIVER i SHADE PASS SHADE A ONIOFE SLOWER Y D CEA 45 Controls and Operations FOG LIGHTS DRIVING LIGHTS Are offered to provide more visibility Fog lights will function with low beams Driving lights will function with high beams 20 SIDE DOCK LIGHT This switch enables the side lights to turn on when the vehicle is FOG in reverse LIGHTS NIGHT LIGHTS Provide lighting in the aisle of the motorhome HEADLIGHTS Operates like the one in your automobile Turning the knob to the first position turns on the parking lights Turning the knob to the second position turns on the headlights Pulling up on the knob turns on the fog lights Rotating the knob controls the brightness of the dash lights Set this according to your preference SERVICE LIGHTS Provide under the hood lighting AUXILIARY START SYSTEM
48. the California Arbitration Certification Program You must utilize the arbitration program before claiming rights conferred by 15 USC section 2310 Uniform Commercial Code or Civ Code section 1793 22 b Tanner Act You are not required to use the program if you choose to seek redress by pursuing rights and remedies not created by those laws To find out more about the program or to request an application brochure please call the Arbitration Administrator Office toll free 800 279 5343 Members of the Armed Forces who purchased the vehicle in California or who were stationed in or a resident of California at the time of purchase regardless of state of purchase or who are stationed in California at the time of application to this program may utilize the CAP RV program THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE Julian Date 04 29 13 Warranty WHAT THE PERIOD OF COVERAGE IS This Limited Warranty provided by Thor Motor Coach Inc Warrantor covers those components assemblies and systems of your new motorhome not excluded under the section What is Not Covered when sold by an authorized dealer The duration of the limited warranty ends twelve 12 months after you first take delivery of the motorhome from an authorized dealership or after the odometer reaches 15 000 miles whichever occurs first However this Limited Warranty provided by Warrantor covers the
49. the filling process when the pump automatically shuts off Modern fuel systems may build up vapor pressure within CAUTION the tank as the fuel warms during use or in hot weather Under certain conditions sudden release of this pressure when removing the filler cap can spray fuel from the opening causing a possible hazard When removing the filler cap rotate it slowly only far enough to allow pressure to release After any hissing sounds die down complete the removal of the cap To protect the gasoline system from excessive pressure or vacuum or from sudden release of pressure replace lost caps with caps of the same design available from your motorhome dealer NO SMOKING BEFORE DISPENSING FUEL TURN OFF DANGER ALL ENGINE FUEL BURNING APPLIANCES AND THEIR DANGER IGNITERS DO NOT DISPENSE FUEL WITHIN 20FT 6 1m OF AN IGNITION SOURCE FAILURE TO COMPLY COULD RESULT IN FIRE DEATH OR SERIOUS INJURY When driving your motorhome you re driving a large vehicle and you should become DRIVING accustomed to the feel of the controls and the reference points from the driver s seat Become familiar with the position of the motorhome in traffic and be cautious while maneuvering to allow for the length and width of the vehicle Always allow extra room to corner and to change lanes Learn to use the side mirrors to view the road behind Check them often Drive with consideration on the highway observing all speed and sa
50. the water lines will vary depending on the model of your motorhome The low point drains for the Windsport model are the outside shower which is located in an exterior compartment below the floor LOW POINT DRAINS 109 Water Systems MONITOR PANEL SANITIZING THE SYSTEM 110 Tank Capacities You should sanitize and disinfect the fresh water system upon delivery of the unit and at least once per year or whenever the motorhome is unused for prolonged periods of time This will help keep your water system fresh and discourage the growth of viral and bacterial contamination which may be contained in your water supply Use a chlorine and fresh water rinse as follows 1 Drain the fresh water tank by opening the drain valve All of the faucets should be in the closed or off position 2 Prepare a solution of 1 4 cup household liquid chlorine bleach 5 sodium hypochlorite to one gallon of water for every 15 gallons of tank capacity Do not pour bleach straight into tank Bleach must be diluted in water prior to filling Example Add four 2 3 gallons solution to a 70 gallon tank Add five 1 3 gallons solution to a 80 gallon tank Add six 1 gallon solution to a 90 gallon tank Add six 2 3 gallons solution to a 100 gallon tank This mixture puts a 50 PPM parts per million residual chlorine concentration in the motorhome s water tank This will act as quick kill dosage for some harmful bacteria viruses and slime forming organ
51. to properly clean inside and out Clean with hot soapy water or a good liquid cleaner Avoid using abrasive cleaners Never use steel wool on stainless steel since the steel particles left in the sink can rust and become unsightly Also when cleaning stainless steel with a mild cleanser rub gently with the grain and rinse well Rinse after each use and wipe dry Preserve the luster by cleaning with a damp cloth and any household detergent designed for that purpose To remove most stains hard water deposits cigarette burns and minor scratches use an abrasive cleanser or an abrasive pad such as 3M ScotchBrite brand green Kitchen Scrub pads To remove deep stains and scratches use fine sandpaper 120 220 grit then sand using in the following order 320 400 and 600 grit sandpaper to restore the standard finish A satin sheen or high polish can be obtained with polishing compounds Certain chemical substances can seriously mar surfaces even during brief periods of contact If spilling occurs wipe area off immediately and then rinse with water Potentially harmful compositions include Toilet bowl cleaners rust removers contact adhesive solvent ceramic cook top cleaners paint or varnish removers drain cleaners metal cleaners tile cleaners lacquer thinners or oven cleaners Contact the manufacturer should you need further assistance Your RV is a small living area so soiling may occur more frequently and items will need more
52. 11 Water Column Test performed Liquefied Petroleum Gas Propane is heavier than air and will settle to the lowest point which is generally the floor of the motorhome The detector is also sensitive to other fumes such as hair spray of which most contain butane as the propellant Butane like Propane is heavier than air and will settle to the floor level where it will be detected When this occurs press the reset button to stop the alert sound for 60 seconds The Propane Gas Detector is powered by the motorhome coach batteries and or the inverter The detector will operate properly until the battery is drained down to 10 volts a low battery condition is 10 4 volts If the power source battery and or inverter is disconnected or if the power is otherwise interrupted the detector will not operate The Propane Gas Detector has a self check circuit which runs at all times when the detector is powered In the event that the circuitry fails a failure alarm will sound It is a continuous series of short beep tones between long intervals and is distinctively different from the alert sound New Coach Odor The glues and other materials used in manufacturing the coach produce vapors which may be detected when the coach is closed up Air out the motorhome thoroughly Keeps Beeping The gas detector beeps about once every minute even when it is turned off The problem is a weak battery in the smoke detector similar to the alert sound of the Pro
53. 6 6743 www powergearus com Chassis amp Chassis Components Allison Transmission 800 524 2303 www allisontransmission com Caterpillar 877 777 3126 www cat com Cummins 800 343 7357 www cummins com Ford 800 392 3673 www ford com Freightliner 800 385 4357 www freightlinerchassis com GM 800 353 3867 www gmfleet com Mercedes Sprinter 877 762 8267 www mbsprinterusa com Workhorse 877 246 7731 www workhorse com Convertors Cheng USA 574 294 8997 www wfcoelectronics com Electrical Entry Steps Kwikee Products 800 736 9961 www kwikee com Lippert Components 574 534 0001 www lci1 com Fireplace Dimplex 877 362 1101 Www dimplax com Furnaces Atwood Mobile Products 800 825 4328 www atwoodmobile com Suburban 423 775 2131 www suburbanmanufacturing com Furniture Flair Interiors 574 534 2163 www flairinteriors com Kustom Fit 323 564 4481 www kustomfit com Generators Onan 800 888 6626 www onan com Hydronic Heat Aqua Hot 800 685 4298 www aquahot com Inverters Cheng USA 574 294 8997 www wfcoelectronics com Magnum Energy 425 353 8833 www magnumenergy com Xantrex 800 446 6180 www xantrex com Leveling Systems Lippert Components 574 534 0001 www lci1 com LP Gas Tanks Manchester Tank 800 877 8265 www mantank com Water Heaters Atwood Mobile Products 800 825 4328 www atwoodmobile com Suburban LP Regulators Manchester Tank 800 877 8265 www mantank com Mattresses Select Comfort 423 775 2131 888 580 9237 ww
54. 719 THOR MOTOR COACH Made to fit OWNER S MANUAL Class Class amp Class A Gas TAB U U RAEN b MOTOR COACH Congratulations on your recent purchase of a Thor Motor Coach Recreational Vehicle We sincerely thank you for choosing and putting your faith in Thor Motor Coach We want you to know that your satisfaction is of great importance to us Our major goal is to provide you with a quality recreational vehicle at a reasonable price This manual will help you better understand the features and operating performances of your recreational vehicle Please read it and keep it in your vehicle for future reference Our customers are extremely important to us and we want to assure you that we will always strive to do everything possible to continue to earn your trust and goodwill Welcome to the wonderful world of RVing and the Thor Motor Coach family Happy Travels This page intentionally left blank Registration And Acknowledgement of Receipt of Warranty and Product Information v122010a 1 THOR MOTOR COACH IMPORTANT THE PURCHASER IS REQUIRED TO READ THIS DOCUMENT BEFORE SIGNING IT We have listed several items which will help acquaint you with your new recreation vehicle You the purchaser should not submit this form until 1 you have received and reviewed the Limited Warranty and owner s manual 2 you have had the opportunity to inspect and operate the vehicle 3 all items have been demo
55. ACTIVATED AND OR EXTENDED Controls and Operations STEP OPERATION 1 With the entrance door open turn the override switch to the OFF position Close the door The step should retract and lock in the up position 2 Open the door The step should extend and lock in the down position with the under step light illuminated When the vehicle ignition is turned ON the step will always activate with the door movement regardless of the override switch position THE UNDER STEP LIGHT OPERATION 1 The light is ON when the step is extended 2 The light is OFF when the step is retracted 3 Turn the override switch to the ON position The step should remain in the extended position with the under step light OFF when the door is closed 4 With the override switch turned ON the step extended and the entrance door closed turn the vehicle ignition ON The ignition override system will go into effect and the step will automatically retract 5 Turn the vehicle ignition OFF and open the door The step will extend and lock in the down position This is the Auto Extend feature E gt Note Ifthe override switch is OFF and the step is extended and the door is left open the light will turn OFF after five minutes The under step light is not available on all step models E gt Note Ifthe yellow wire from the four way connector is not connected to an ignition power source the ignition safety system will be inoperative a
56. AFETY A DANGER IF YOU SMELL PROPANE 1 Extinguish any open flames pilot lights and all smoking materials 2 Do not touch electrical switches 3 Shut off the propane supply at the container valve s or propane supply connection 4 Open doors and other ventilating openings 5 Leave the area until odor clears 6 Have the propane system checked and leakage source corrected before unsing again FAILURE TO COMPLY COULD RESULT IN EXPLOSION RESULTING IN DEATH OR SERIOUS INJURY Over filling the Propane gas tank can result in uncontrolled gas flow which can cause fire or explosion A properly filled tank will contain approximately 80 of its volume as liquid Propane An 80 automatic shut off valve is installed on the Propane gas tank which will automatically prevent further filling when the gas volume has reached 80 of tank capacity CAUTION This tank is equipped with an automatic valve designed to close at 80 liquid full Always open 20 fixed liquid level bleeder gauge while filling Stop filling if liquid appears before valve shuts off A WARNING ALL PROPANE GAS IS CONTAINED UNDER PRESSURE DUE TO THE DANGEROUS POTENTIAL OF ANY COMPRESSED GAS IT IS MANDATORY THAT THE FOLLOWING REQUIREMENTS FOR THE USE OF THIS TANK BE FOLLOWED Tanks are to be installed fueled and maintained in accordance with the state and local codes rules regulations or laws and in accordance with the NFPA Pamphlet 58 division IV Only pers
57. Always use plenty of water when flushing Do not put facial tissue paper baby wipes or sanitary napkins into your holding tanks Do not put solid objects into the tank which could puncture or scratch your tanks Do not leave the termination valves in the open position or open them prior to having the sewer hose connected Do not remove the termination cap with the termination valves in the open position You may wish to add an approved deodorant chemical approved for your sewer system to aid in the breakdown of solid wastes as well as making your system more pleasant to use Prior to dumping make sure your tank is at least 1 3 full Fill and cover the bottom of the tank with water after dumping is complete and leave the water in the tank Use only approved biodegradable toilet tissue designed specifically for motorhome systems The termination compartment has many operations Please note that because of the various configurations of each individual motohome the items listed below may or may not pertain to your unit Listed below are the fixture call outs and functions 1 Exterior shower head For washing animals hands sewer hose or any exterior cleaning job Termination valve handle To open grab handle and pull outward Make sure that the drain hose is connected Termination cap Remove this to install the sewer hose Be sure that the termination valves are closed before removing this cap Sewer holding tank
58. C power Fault red indicates the XM Series Inverter has shut down because of a fault Select button When the XM Series Inverter is in inverter mode press the Select button to choose what appears in the three digit LED display Input Voltage Input Current or Output Power 103 Electrical Systems Checking Battery Status Checking Output Power Operating several loads at once Turning the Inverter off when not in use Fault Codes 104 You can check the battery status by pressing the Select button until the Input Voltage LED illuminates The battery voltage appears in the three digit LED display The normal operating battery voltage range is between 11 and 15 volts You can check how much power the XM Series Inverter is supplying to the connected loads by pressing the Select button until the Output Power LED illuminates If you are going to operate several loads from the XM Series Inverter turn them on one at a time after you have turned the inverter on Turning loads on separately helps to ensure that the inverter does not have to deliver the starting current for all the loads at once and will help prevent an overload shutdown The XM Series Inverter on average draws less than 0 7 A from the battery when the inverter is on with no load connected However when it is left in this state the XM Series Inverter will eventually discharge the battery To prevent unnecessary battery discharge turn the XM Series Inver
59. Determine the correct air pressure for the weight on each axle and adjust the pressure according to the Federal Certification Label when the tires are cool or have not been driven for more than one mile Never reduce the air pressure in a hot tire CAUTION Never let air out of a hot tire Now that you have found what the correct air pressure per axle needs to be for your motorhome when loaded you need to know when to check your air pressure You On the Road Safety should check the air pressure every two weeks or at least once a month and before any major trip Your motorhome s air pressure should be checked every morning on long trips On short trips of a day or less of driving each way your tires should be checked before you start your trip home If your vehicle is stored for any length of time the air pressure should be checked prior to storage but more importantly when it comes out of storage Check your tires when they are cold and have not been driven for more than one mile The stated load capacity for a given cold inflation pressure is based on ambient outside temperature To maintain the inflation pressure in your tires you will need the proper equipment It is recommended that you purchase a quality truck tire air gauge which has an angled dual head This type of gauge allows you to check inflation on the inner dual wheel which has the valve stem pointed away from you Nothing should restrict your ability to chec
60. IS EQUIPPED WITH AN ELECTRONIC IGNITION DEVICE WHICH AUTOMATICALLY LIGHTS THE BURNER DO NOT TRY TO LIGHT THE BURNER BY HAND CAUTION Heat registers can reach high temperatures when the furnace is running and can cause a burn if skin is in contact with the register Furnace Operation 1 The propane tank must be filled and the house batteries Instructions should be fully charged 2 The propane valve located on the propane tank must be in the open position The valve should only be opened or closed by hand If the valve cannot be turned by hand have the valve checked by a qualified service technician 3 All power to the appliance should be on Breaker and 12 Volt fuse locations vary depending on floor plan 4 Set the thermostat to the desired function and temperature setting ce Note For detailed information regarding the Furnace refer to the manufacturer s operating instructions manual 88 Heating and Air Conditioning Cc Note For detailed information regarding the thermostat refer to the WALL manufacturer s operating instruction manual THERMOSTATS gt Note Refer to the operation manual for proper long term storage Coleman Mach procedures iov Note Some thermostats are for cool only and will not have a heat Analog Model option 60 70 80 90 55 65 75 85 coo 4 pear mony t AUTO ON SYSTEM Choosing a Mode Use the System selector to select Fan Cool Heat or to turn the system off Fan Control U
61. K Due to the potential danger in failing to heed this warning the motorhome manufacturer cannot be responsible should damage injury or death result from failure to connect the power cord to a properly grounded power source 93 Electrical Systems 30 Amp Shore Power 50 Amp Shore Power 94 BATTERIES Battery Safety AWARNING DO NOT USE A STANDARD HOUSEHOLD EXTENSTION CORD TO CONNECT YOUR MOTORHOME TO ELECTRICAL SERVICE IF SHORE POWER SERVICE IS LIMITED TO 15 OR 20 AMPS USE OF LIGHT DUTY EXTENSION CORDS AND ELECTRICAL ADAPTERS WILL CREATE A VOLTAGE LOSS THROUGH THE CORD AND AT EACH ELECTRICAL CONNECTION Line voltage loss and the resistance at each electrical connection can be a hazardous combination Damage to sensitive electronic equipment may result A WARNING THE Motorhome IS DESIGNED TO BE CONNECTED TO A 30 AMP SERVICE WHICH PROVIDES 120 VOLTS The motorhome should never be connected to any power source that will provide anything more than 120 Volts Failure to follow this will result in serious damage to internal items that are plugged in A 30 amp shoreline power cord is provided to attach the motorhome to a grounded power source When connecting or disconnecting from a grounded external power Source always turn off the shore power breaker to the power supply outlet This will prevent accidental shock and flashing of electrical contacts WARNING THE Motorhome IS DESIGNED TO BE CONNECTED TO
62. K BRAKE excess aate LCI LEVELING o oec e OBO OS CAUTION OA VSE BNCE 2 Lowvocraoe ENGAGE PARK BRAKE excess anaue jd LCIELECTRONIC LEVELING o OSS OG o E tow vocrase ENGAGE PARK BRAKE excess ace Turn on power Press auto level touch pad Retracting the jacks 59 Controls and Operations Resetting the Zero Point LIT I IU LLL OL LI az CAUTION 57979 1 Turn the system by pressing the ON OFF button 1 The ON OFF button will illuminate 2 Press the MAN button 2 and hold for 2 3 seconds The indicator light will illuminate 3 Manually level the coach using a carpenter e level ON THE FLOOR of the coach Level front to rear and then left to right 4 Turn the panel off then turn it on again 5 With the coach leveled press FRONT 3 five times 6 Press REAR 4 five times All the lights on the panel will flash 7 The panel is now in idle mode If the coach has come out of its level condition it can be reset by pressing the directional buttons to get the coach level again If the coach is in level condition Press the RETRACT ALL button 5 three times Note Zero point is set at the time the unit leaves the production facility Resetting of the zero point is concidered owner maintenance and as such not covered under the TMC war
63. Kitchen Sink Laws of the Road Licenses Lights Living Room Television Loading and Weight Distribution Low Point Drains LP Detector How to Test LP Detector Most Common Causes of Apparent Malfunction LP Detector Maintenance LP Gas Detector LP Safety LP System Maintenance Schedule Major Equipment Suppliers Manual Dome Operation Manual Override Manual Patio Awning Manually Closing the Automatic Awning Microwave Mold Mold Factors Contributing to Mold Growth Mold Inhibiting Mold Growth Monitor Panel Monitor Panel Inaccurate Readings Monitor Panel Oversensitive Readings Monitor Panel Tank Capacities Monitor Panel Undersensitive Readings Notes On the Road Safety Opening Checklist Operational Checks Owner Responsibility Parking Planning and Preparation Potable Tank Power Converter Power Cord Pre Finished Panels Pre Travel Check Pre Trip Checklist Production Changes Propane Gas Hoses Propane Gas Safety Propane Gas Tank Propane Regulator Propane Regulator Freeze up Propane System Propane Tank Propane Tank Filling the Tank 25 126 17 17 55 60 60 61 107 60 60 25 17 18 56 17 87 30 31 30 30 29 93 119 15 73 55 65 66 60 108 108 109 88 88 88 88 88 124 41 18 39 13 41 17 13 79 18 108 17 39 13 96 96 93 94 95 99 113 18 93 Proper Load Balance Range Read the Book Rear Ladder Rear Vision System Rearview Mirror Re
64. NT OF AND SHALL SURVIVE ANY FAILURE OF THE ESSENTIAL PURPOSE OF ANY LIMITED REMEDY Some states do not allow the exclusion or limitation of consequential or incidental damages so the above exclusions may not apply to you LEGAL REMEDIES THIS LIMITED WARRANTY DOES NOT EXTEND TO FUTURE PERFORMANCE ANY ACTION TO ENFORCE THIS LIMITED WARRANTY OR ANY IMPLIED WARRANTIES SHALL NOT BE COMMENCED MORE THAN 90 DAYS AFTER THE EXPIRATION OF THE APPLICABLE WARRANTY COVERAGE PERIOD DESIGNATED ABOVE IF YOUR MOTORHOME IS NOT OF THE CURRENT OR PRIOR MODEL YEAR WHEN YOU TAKE DELIVERY OF THE MOTORHOME OR YOU USE YOUR MOTORHOME FOR COMMERCIAL OR BUSINESS PURPOSES OTHER THAN FOR RENTAL PURPOSES ANY ACTION TO ENFORCE THIS LIMITED WARRANTY OR ANY IMPLIED WARRANTIES SHALL NOT BE COMMENCED MORE THAN ONE YEAR AFTER THE EXPIRATION OF THE APPLICABLE WARRANTY COVERAGE PERIOD DESIGNATED ABOVE UNLESS PROHIBITED BY STATE LAW THE PERFORMANCE OF REPAIRS SHALL NOT SUSPEND THIS LIMITATIONS PERIOD FROM EXPIRING AND ANY LEGAL ACTION TO ENFORCE WARRANTY RIGHTS AGAINST WARRANTOR MUST BE BROUGHT WITHIN THE STATE OF INDIANA Some states do not allow the reduction in the statute of limitations so the above reduction in the statute of limitations may not apply to you Warrantor participates in the Consumer Arbitration Program for Recreational Vehicles CAP RV operated by DeMars amp Associates The CAP RV program operates as a certified mechanism under the review of
65. Never use any other tank than the one furnished with the motorhome If the tank must be replaced check with your dealer for correct tank specifications and replacement procedure PROPANE AWARNING NEVER ALTER THE POSITIONING OF THE REGULATOR REGULATOR PROPANE GAS REGULATORS MUST ALWAYS BE INSTALLED WITH THE DIAPHRAGM VENT FACING DOWNWARD ALSO MAKE SURE TO KEEP THE REGULATOR COVER IN PLACE TO MINIMIZE VENT BLOCKAGE WHICH COULD RESULT IN EXCESSIVE GAS PRESSURE CAUSING FIRE OR EXPLOSION DO NOT RELY UPON BEING ABLE TO SMELL PROPANE GAS LEAKS AS THE ODOR MAY NOT BE SUFFICIENTLY STRONG ENOUGH TO DETECT Tank Fill Main Shut Off Valve Regulator LP Tank Tank Gauge The regulator reduces the pressure of the propane gas vapor from the pressure in the tank to the pressure required for use at the appliances This reduction in pressure is performed by a two stage regulator Two regulators are used in the same body to reduce the pressure of the propane gas in the tank for use by the appliances in the motorhome The regulator seldom requires service but it should always be protected from the elements and extremes of hot and cold The high pressure regulator first stage is used to reduce the pressure to approximately 10 to 13 PSI before sending it along to the low pressure regulator second stage This second stage regulator reduces the pressure further to 11 inches water column or 6 35 ounces per square inch The two stages regulator doe
66. OCCC is how much weight in occupants cargo water and trailer tongue weight that can be added to the motorhome without exceeding the GVWR Gross Combined Weight Rating GCWR means the maximum allowable loaded weight of this recreation vehicle with its towed trailer or towed vehicle Gross Axle Weight Rating GAWR is the value specified as the load carrying capacity of a single axle system as measured at the tire ground interfaces If a boat trailer or other vehicle is being towed it should be weighed and combined with the towing vehicle s weight to ensure the total weight does not exceed the GCWR 23 identification and Safety It is advisable to contact the Department of Motor Vehicles in each respective state for up to date information regarding operation and licensing requirements for your particular motorhome The state of California currently requires operators of motorhomes over 40 feet in length to obtain a non commercial class B license California has also enacted legislation limiting use of motorhomes in excess of 40 feet to approved roadways You may contact Caltrans at www dot ca gov or 916 654 5741 for current information regarding these California statues The motorhome serial number label is mounted on the inside wall next to the driver s seat on a Class A motorhome and on the inside of the driver s door post on a Mini motorhome Refer to the chassis owner s manual for the location of the chassis vehi
67. OF FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED IN DURATION TO THE TERM OF THIS LIMITED WARRANTY AND ARE LIMITED IN SCOPE OF COVERAGE TO THOSE PORTIONS OF THE MOTORHOME COVERED BY THIS LIMITED WARRANTY WARRANTOR DISCLAIMS ALL IMPLIED AND EXPRESS WARRANTIES INCLUDING THE IMPLIED WARRANTY OF MERCHANTABILITY AND THE IMPLIED WARRANTY OF FITNESS FOR A PARTICULAR PURPOSE ON COMPONENTS AND APPLIANCES EXCLUDED FROM COVERAGE AS SET FORTH BELOW There is no warranty of any nature made by Warrantor beyond that contained in this Limited Warranty No person has authority to enlarge amend or modify this Limited Warranty The dealer is not the Warrantor s agent but is an independent entity Warrantor is not responsible for any undertaking representation or warranty made by any dealer or other person beyond those expressly set forth in this Limited Warranty Some states do not allow limitations on how long an implied warranty lasts so the above limitation may not apply to you WHAT THE WARRANTY COVERS Warrantor s Limited Warranty covers only defects in the workmanship performed and or materials used to assemble those portions of your motorhome covered by the limited warranty See also the section What the Warranty Does Not Cover set out below Defect means the failure of the workmanship performed and or materials used to conform to Warrantor s design and manufacturing specification and tolerances WHAT WE WILL DO TO CORRECT PROBLEMS Warranto
68. OR MICROWAVE CONVECTION OVEN 74 KITCHEN SINK KITCHEN FAUCET SHOWER HEAD amp HOSE The standard RV refrigerators in your motorhome runs on either propane gas or electric power The controls are at the top of the unit If you use the auto mode on your refrigerator the refrigerator will operate on 120 Volt power when available and automatically switch to propane when shoreline is removed You can control how cold you want your refrigerator to be with the thermostat control Your refrigerator is equipped for large capacities with plenty of storage shelves and a crisper The refrigerator requires normal cleaning and care Please refer to the Refrigerator Owner s Manual in your Owner s Information Kit for more information Some motorhomes may be equipped with a residential style refrigerator These refrigerators operate only on 120 Volt power Please refer to the Refrigerator Owner s Manual in your Owner s Information Kit for detailed operating instructions The microwave convection oven operates on 120 Volt power provided by the generator or shoreline It will de program when the power is discontinued and must be reprogrammed when power is restored For usage instructions please refer to the Microwave Convection Oven Owner s Manual in your Owner s Information Kit The kitchen sink is much like the one in your home It may be equipped with a sink cover board which when in place increases counter space Only waste water
69. T EXCEED THE GROSS COMBINED VEHICLE WEIGHT RATING OR OTHER TOW RATINGS OF THIS MOTORHOME THE DESIGNATED HITCH RATING MAY EXCEED THE GCWR OR OTHER TOWING CAPACITY LIMITS OF THE MOTORHOME It is your responsibility to properly load the motorhome while staying within the tow ratings gross combined and gross vehicle weight ratings Always use Safety chains between the motorhome and the towed trailer or vehicle Cross chains under the trailer tongue and allow slack for turning corners Connect safety chains to the trailer or vehicle frame or hook retainers Never attach chains to the bumper of a vehicle Tow bars or car dollies generally are made to travel in a forward direction only Most towing equipment of this type is not designed for backing Never attempt short back up distances with a tow bar or tow dolly Damage to the motorhome towed vehicle or towing device will result C Note Thor Motor Coach accepts no responsibility for damage to the chassis and other components resulting from towing loads greater than its designated class specifications Also consider the gross combined weight rating of the motorhome before towing a trailer or vehicle Towing an object such as a boat and trailer or a vehicle behind the motorhome results in added driving considerations that you must contend with Chassis 22 Note issues regarding the chassis warranty parts and service should b directed to the chassis manufacturer The followin
70. a long period of time or when the battery has been operated continually in a state of partial discharge Use a baking soda solution to neutralize the acid accumulations on the battery top Do not allow the soda solution to enter the battery Make sure the vent caps are secure Flush with water Thoroughly dry all cables and terminals reinstall and use a plastic ignition spray to protect the terminals 4 Check the outside condition of the battery Look for cracks in the case or vent plugs If the case is cracked the battery must be replaced If the Battery Maintenance 95 Electrical Systems vent plugs are cracked they must be replaced 5 Watch for overcharging Three indications of overcharging are a Active material on the vent cap heavy deposit of black lead like material on the underside of the vent cap b Excessive use of water c Voltage regulator output 6 Make sure the battery hold downs and carrier are kept clean and free of corrosion When removing a battery disconnect the ground battery clamp first When installing a battery always connect the grounded battery clamp last When a battery needs to be replaced make sure to replace it with a battery of the same characteristics as the original equipment Consult your dealer for advice on battery replacement AWARNING ALWAYS WEAR SPLASH PROOF SAFETY GLASSES WHEN WORKING WITH BATTERIES Battery Isolator When the motorhome engine is not running the chassis and auxi
71. a resident of California at the time of purchase regardless of state of purchase or who are stationed in California at the time of application to this program may utilize the CAP RV program THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE Julian Date 04 29 13 12 Warranty Thor Motor Coach reserves the right to make changes in Vehicles built and or sold by it at any time without incurring any obligations to make the same or similar changes on Vehicles previously built and or sold by Thor Motor Coach As the proud owner of a Thor Motor Coach you want to trust that your unit will continue to perform at its peak To ensure this Thor Motor Coach has provided you this checklist of the responsibilities of the Thor Motor Coach owner Please make sure that this list is carefully observed and adhered to in order to maintain your Limited Warranty Please refer to the Maintenance Schedule to determine when your inspections should take place Check both house batteries and chassis battery and tighten connections if necessary Clean the terminals if necessary Check to make sure that the batteries have the proper water levels in them and fill if necessary Check the charge and recharge if necessary Keep connections clean and covered with a light coat of grease Use only distilled water and be sure to where proper safelty equiptment when wrking with batteries There is a certain d
72. ace It is recommended that fresh water not be left in the storage tank for long periods of time The water should be drained when the unit is being stored or not in use Drains are located in a variety of compartments To drain the tank and lines simply open the low point drains and allow water to run out After water has drained close the valves to prevent pests from entering the system Check all hoses fittings and connections regularly for leaks and signs of wear Make sure to keep the system sanitized and take care to winterize during cold weather The electrical system requires minimal maintenance under normal circumstances Most electrical maintenance in the recreational vehicle involves the chassis and auxiliary batteries Keeping the batteries properly maintained will help to eliminate many frustrating electrical problems The generator is another area in which simple preventive maintenance can head off problems before they happen Read the manual supplied with the generator in the Owner s Information Kit for the care and maintenance required on a regular basis If you experience electrical problems with your recreational vehicle make sure to have it checked by an authorized Thor Motor Coach dealer or a qualified RV technician Generator power plant service recommended by the generator manufacturer should be performed at an authorized service center Routine or emergency service such as adding oil changing filters or replacin
73. ad range as the original tire DO NOT mix radial ply with bias or bias belted tires READ THE BOOK LICENSES INSURANCE INSPECT AND MAINTAIN LOADING AND WEIGHT DISTRIBUTION CONTROL OF THE MOTORHOME PRE TRAVEL CHECK Tires 17 Planning and Preparation Wheel Lugs Windshield Lights Rearview Mirror Power Cord Water Fill Sewage Entry Step Propane Tank Doors And Drawers Compartment Doors Refrigerator Door Windows And Vents OPENING CHECKLIST 18 Must be tightened to the specifications in the Chassis Manufacturer s Owner s Manual Should be clean wiper blades inspected and windshield washer reservoir filled Should be tested including brake lights warning flashers clearance lights tail lights turn signals and headlights Clean all lens covers Should be adjusted so the driver can see to the rear on both the right and left side of the unit 120 Volt shoreline must be unplugged from the external source and properly stored for transit also making sure the cord hatch is secured Hoses must be disconnected properly drained and stored and the caps and hatches secured Fill the fresh water tank as required prior to storing hoses Should be emptied from the holding tanks before traveling Termination valves must be closed and locked The sewer hose must be removed from the termination valve outlet and stored Termination cap must be securely fastened to the termination outlet
74. affect service timetables Driving in extreme conditions such as heavy dust continuous short trips or start and stop heavy traffic means that service durations will be shortened Discuss service timetables with both your dealer and chassis service representative Preventative maintenance will pay for itself many times over by catching or preventing problems before they occur Many repair costs are greatly increased due to the fact that a small problem can begin to affect other parts and systems of the motorhome if left unattended If a situation arises involving maintenance or cleaning activity for which you are not sure of the proper procedure do not hesitate to contact your dealer or chassis service representative for information E gt Note Performing periodic maintenance is not covered under the Thor Motor Coach Limited Warranty gt Note The following instructions are guidelines for the care and maintenance of your motorhome Please refer back to the products Owner s Manual for more information on the care and maintenance of that product The chassis batteries are 12 Volt automotive batteries which provide power for all vehicle requirements Have these batteries serviced when servicing other vehicle Systems Auxiliary batteries house batteries for motorhomes are dual auxiliary 6 Volt batteries to provide living area power requirements Have these batteries serviced when servicing other vehicle systems When operating proper
75. al Certification Label located in the driver s area to determine the safe load limits For safety s sake NEVER OVERLOAD THE MOTORHOME This chapter contains information about proper loading and weighing of your motorhome Know how to control your motorhome on the highway Be familiar with passing and stopping requirements and problems that can develop Know how to brake properly how to back up and how to turn Practice in a secluded place until you become familiar with the handling characteristics and techniques of your motorhome Don t overlook the laws of your state that govern driving a motorhome Your state Motor Vehicle Department office can provide you with the applicable vehicle codes that spell out your rights and responsibilities as a motorhome owner Whenever you depart be it from your home rest area or campsite You should perform these pre travel checks Should be inspected before each trip for uneven wear road damage foreign objects peeling or bulging and correct tire pressure Heat generated by surface friction will increase the tire s air pressure therefore do not bleed air out of a hot tire Check tire pressure after the vehicle has been parked for at least one hour Inflate tires to recommended pressure as indicated on the Federal Certification Label located above the Drivers area Proper tire inflation is extremely important When purchasing a new tire be certain it is the same size and has the same ply rating and lo
76. alking however these are surface cosmetic changes which do not affect the strength of your unit Simple maintenance through cleaning by washing and waxing will ensure lasting beauty The same fading may occur to carpeting and upholstering Be sure to keep your shades down in extremely sunny locations and maintain proper cleaning techniques for both carpet and upholstery The front suspension and steering system of this vehicle was factory aligned using highly accurate equipment prior to delivery to the dealership We recommend that the alignment is checked after you have fully loaded the motorhome according to your personal needs If necessary adjust alignment for the loaded motorhome Thereafter the alignment should be inspected yearly to help prevent uneven tire wear Potable water only Sanitize flush and drain before A WARNING using Failure to comply could result in death or serious injury PRODUCTION CHANGES OWNER RESPONSIBILITY CHECKLIST Batteries Battery Replacement Condensation Exterior Interior Alignment Potable Tank 13 Warranty Proper Load Balance Sealants Service Calls Slideout Lubrication 14 Step Lubrication Tire Pressure Travel Bars Windshields Winterization Sanitize the fresh water system at least once per year or whenever the motorhome is unused for prolonged periods of time This will help keep your water system fresh and discourage the growth of bacteria that can
77. alve on an empty tank closed 4 If freezing has occurred have your propane gas dealer purge the propane gas tank before refilling 5 Add a hydrous methanol or other approved propane gas antifreeze or de icing agent to the propane gas tank 6 Keep the regulator covered at all times 22 Note IF FREEZE UP DOES OCCUR shut off the propane gas at the tank A frozen regulator may permit propane gas to flow at high pressure resulting in leaks at appliances or in the lines If freeze up does occur NEVER attempt to thaw with an open flame Once thawed be sure to take the proper steps to prevent a reoccurrence Have the system checked by your propane gas supplier if freeze up continues Remember that as outside temperatures drop the BTU value of the propane gas is lessened since the colder liquid propane in the tanks requires the heat from the Regulator Freeze Up 117 LP System 118 PROPANE GAS HOSES PIPES TUBES AND FITTINGS PROPANE GAS SAFETY PRECAUTIONS surrounding air to vaporize This lowering of BTU value can significantly affect the performance of the system You can help insure proper performance by keeping the propane gas tank as full as possible in cold weather and reviewing the BTU hr plates on propane gas appliances for proper propane management Although the hoses pipes tubes and fittings used in the propane gas system are designed to withstand pressures far exceeding those of the propane system because
78. an automotive grade nonabrasive wax and cleaner Use Precautionary EXTREME care when waxing your vehicle and ALWAYS rub in horizontal motions Measures DO NOT use a pressure washer It is strongly recommended that you DO NOT use a rotating brush car wash as it can lift the ends of your vinyl graphic or scratch your paint finish DO NOT use alcohol strong solvents bug remover or tar remover on your painted or vinyl surface as it may leave a foggy appearance in that area gt Note If using tar and or insect remover is absolutely necessary insure it is safe for painted surfaces and decals Minimize any fuel contact with your paint finish or vinyl graphics Prolonged contact can damage the finish Power buffers ARE NOT recommended Avoid parking under trees or near ocean salt spray Ice or snow should not be scraped from the painted surface Brush off If the vehicle sits more than 24 hours remove any front protective covering bra while not being driven Commercial washes should be avoided Wash with cold water using a mild liquid soap Dry wiping with a dry cloth is not recommended When driving avoid gravel roads Anti freeze gasoline or window solvent spilled on painted surfaces should be rinsed off with water immediately Rinse off bugs and bird droppings daily with water Do not use petroleum solvents harsh abrasives or citric CAUTION based cleaners Any exterior finish will deteriorate with time Dulling an
79. and feel it latch Make sure the tongue is securely fastened in the buckle Adjust the belt to the proper position snug and as low as possible around the hips not around the waist To unfasten push the release button and remove the tongue from the buckle Maintenance A WARNING FAILURE TO INSPECT AND IF NECESSARY REPLACE Child Restraints THE SAFETY BELT UNDER THE ABOVE CONDITIONS COULD RESULT IN SEVERE PERSONAL INJURIES IN THE EVENT OF A COLLISION Inspect the safety belts periodically to make sure they work properly and are not damaged Inspect the safety belts to make sure there are no nicks tears or cuts Replace if necessary A qualified service technician should inspect all safety belt assemblies after a collision Thor Motor Coach recommends that all safety belt assemblies used in vehicles involved in a collision be replaced If your child requires a child safety restraint system seat Thor Motor Coach recommends installing the child safety seat in the forward facing booth dinette position For rear facing child seats and infant carriers the dinette table can be placed in the down position to allow adequate room for the rear facing child seat If your motorhome is not equipped with a forward facing booth dinette seat we recommend that small children that require a child seat not be transported in a motorhome Please Note Rear facing child seats or infant carriers should never be placed in the front seats Never let a passeng
80. andle you have and refer to the following illustrations for operation It is also marked as an EXIT The glass slider in the egress 9 window operates the same as all other 2 windows TO RELEASE EGRESS LATCHES TEST The egress window should be FOLEIHEHANDIES Ue opened twice a year to ensure proper operation Over time the rubber seal will tend to stick to the egress window Occasional operation will help prevent the rubber seal from sticking A SEPARATE FUNCTIONING BRAKE SYSTEM IS TRAILER TOWING REQUIRED FOR ANY TOWED VEHICLES OR TRAILERS WEIGHING MORE THAN 1000 LBS WHEN FULLY LOADED NEVER EXCEED THE GVWR OR THE GAWR SPECIFIED ON THE Motorhome CERTIFICATION LABEL Also never exceed the weight ratings of the trailer hitch installed on the motorhome Failure to heed any part of this warning could result in loss of control of the motorhome and towed vehicle or trailer and may cause an accident and serious injury For specific towed vehicle braking requirements consult the chassis owner s manual 35 36 THE Motorhome FULLY LOADED AND THE TRAILER OR TOWED VEHICLE MUST NOT EXCEED THE Motorhome CHASSIS GROSS COMBINED WEIGHT RATING GCWR Consult with your selling dealer to determine the GCWR of the motorhome Do not exceed the motorhome gross combined weight rating GCWR or the hitch rating The tongue weight the weight pushing down on the hitch must not exceed 10 of the hitch capacity DO NOT TOW LOADS THA
81. ange between three FM bands and two AM bands 17 Mute Press to mute the audio output Press again to restore the audio output to the previous level 18 Reset Use a ball point pin or thin metal object to press the RESET button 18 The reset button should be activated for the following reasons initial installation of the unit when all wiring is completed function buttons do not operate error symbol on the display 19 Auxiliary Input Connect the portable audio player to the 3 5mm stereo AUX IN connector on the front panel 20 21 TUNE TRK gt gt or lt lt Use to manually tune or select a track 22 Eject Button 23 Display 24 Disc Slot 25 USB Port 53 Controls and Operations DASH RADIO REAR VISION SYSTEM COMBO Pioneer 3 101709 5 1 Part Part D SRC OFF D eject VOLUME f D VOL 8 Disc loading slot Auto EQ micro phone input jack MUTE 9 Usetoconnect an auto EQ micro phone PAE a UE 4 i i 10 i o esi dc 00 open the USB con en nector lid AUX input jack MODE 3 5 mm stereo 5 Tuming the infor video jack mation display off Use to connect an auxiliary device lt gt TRK 54 Controls and Operations Koen mma 8 Jensen 17 hagr a 9 Cw 9 2 im Pa 40 3 NS z AN D RM EN AUX IN 5 Q 1 12 5 J ago A NC 13 7 1 Power On Off Press to turn t
82. anger involved when working with CAUTION batteries If you are unfamiliar with these dangers contact a Thor Motor Coach dealer Just as in your home itis the owner s responsibility to periodically check the batteries in the smoke detector propane detector and carbon monoxide detector when applicable We recommend that you change the batteries every six months to ensure proper working order The owner is responsible for checking to ensure that the vehicle has as little condensation in it as possible The condensation in a motorhome is much greater than in most houses because the insulated walls of the vehicle are much thinner than house walls and the small size and tight construction of the vehicle allow a quick buildup of high moisture levels in the inside air This can be reduced by always keeping the bathroom door closed and the window or vents open when bathing and for a period of time when you have finished bathing or cooking to allow for dissipation of all the moisture Use your vent hood and fan when cooking Don t hang wet clothes in your unit to dry When left for prolonged periods of time condensation can cause considerable damage to your vehicle Most exterior parts of your motorhome are made of fiberglass which is a very durable material but not indestructible Exposure to the elements can cause premature deterioration without routine maintenance especially in hotter climates The effects may be fading yellowing or ch
83. ap is located at the terminal outlet to help prevent leakage of materials The holding tanks are enclosed sewer systems and must be drained into an approved dump station Tanks should be thoroughly drained and rinsed to prevent any accumulation on the interior of the tanks 1 Twist off the termination cap counterclockwise Some liquid may be trapped between the valves 2 Connect the sewer hose by turning it clockwise making sure that the connection end levers are locked over the termination end Inaccurate Holding Tank Level Readings Oversensitive Readings Undersensitive Readings WASTE WATER SYSTEM HEATED HOLDING TANKS DUMPING THE HOLDING TANKS 111 Water Systems HOW TO PREVENT 112 BLOCKAGE OF DRAIN LINES TERMINATION COMPARTMENT COMPONENTS a BR 9 10 Deposit the other end of the sewer hose into an approved dump station inlet Open the black termination valve first and drain Open the gray smaller tank valve to drain and flush out the hose Rinse the tanks and hose thoroughly with fresh water before disconnecting Close the termination valves Rinse the sewer hose with the faucet provided in the termination compartment Replace the sewer hose to the storage location Replace the termination cap on the outlet making sure that it is secured and locked The most common holding tank problem is blocking the drain lines which can be minimized by following a few simple suggestions
84. ater tanks and flush TIPS FOR WINTER USE WATER SYSTEM FOOD STORAGE PROPANE SYSTEM HEATING CONDENSATION WINTERIZATION PROCEDURE 135 Winter Use and Storage Water Heater Drain Plug 136 out completely Drain the black tank first and allow the gray water tank to rinse out the flexible hose drain line You may now add a commercial holding tank chemical cleaner Driving the unit around for a few miles will allow the cleanser to circulate within the tanks and drains Drain and flush once more with fresh water 3 After all the tanks have been drained make sure that any water remaining in the lines is either blown out or replaced with a nontoxic RV antifreeze solution which will prevent any water that remains from freezing To blow out the water lines proceed as follows 4 Open all faucets including the toilet flushing device and the shower head sprayer Open any other water lines that are closed You will need access to an air compressor along with an adapter that will connect the air to your unit These adapters can be purchased at an RV supply store Do not exceed 55 psi when hooked up to the water lines to avoid damage If your vehicle is equipped with a water filter remove and drain it before proceeding Replace it with a diverter tube which will come with the unit This will create a bypass in the water line so that the antifreeze will not go into the filter assembly 5 Turn on the water pump and allow it to
85. ation at a rate that reflects the level of discharge When the battery is again fully charged the converter charger drops its charging level back to a maintenance level to keep the battery fully charged If for any reason you charge a battery with a source outside the motorhome make sure to follow the rules of battery maintenance and safety outlined in this section Also observe these additional safety precautions related to battery charging 1 Disconnect the battery from the motorhome Check electrolyte before charging Be sure each cell is properly filled with distilled water 3 Make sure to use care when connecting and disconnecting the cables from chargers A poor connection can cause an electrical arc which can result in an explosion 4 Remove the battery vent caps before charging and make sure that the electrolyte does not splash out as a result of charging too quickly 5 Check literature supplied by battery manufacturer and follow warnings or cautions outlined The converter is used to switch 120V electricity from an external supply or from the generator to 12 Volt electricity to power interior lights and 12 Volt accessories The converter requires no maintenance under normal circumstances If the converter does not have a 120V supply to convert to 12 Volt it automatically switches the batteries into the electrical circuit to power 12 Volt functions When reconnected to a 120V supply it will again operate from this power
86. attention than your furniture at home Please follow these guidelines for cleaning BEDSPREAD amp DRAPERIES CARPET HIGH PRESSURE LAMINATE COUNTERTOP HARDWARE KITCHEN FIXTURES BLINDS amp SHADES SINKS SOLID SURFACE COUNTERTOP UPHOLSTERY amp FABRICS 129 Care and Maintenance WALL COVERINGS PRE FINISHED PANELS AND WOOD SURFACES MOLD Factors Contributing 130 to Mold Growth your upholstered fabrics e Clean with mild soap and water Air dry e Remove tougher stains with mild detergent or mild cleaning agent like Fantastic or Formula 409 G e Disinfect with 5 1 bleach solution Donotuse abrasive cleansers Your upholstery fabrics have been manufactured with the same quality you would expect to find in a furniture store However they are not completely resistant to possible damage Special care is needed when your motorhome is exposed to very humid or very hot climates or if it is closed up for an extended period of time If you know you are going to be away cover upholstery and make sure window coverings are closed to protect upholstery from any sun damage Your decorative wall coverings are not much different from wallpaper that you may have in your home They should be cleaned with mild soap and water They can easily be maintained with proper care Treat cabinetry and wood surfaces as you would any fine furniture product in your home Proper care and maintenance of wood
87. aucets The antifreeze should be left in the sink washer and shower p traps and toilets during storage to protect those lines Open all faucets one half way to relieve pressure on the valve seats during storage Wipe all fixtures clean to prevent staining A WARNING Antifreeze must be nontoxic in nature and must be flushed from the fresh water system before human use Automotive antifreeze is poisonous and SHOULD NOT be used in drinking water systems Winter Use and Storage Draining the tanks and water lines in your motorhome is half the battle of winterization Complete the Storage and Winterization Checklist to ensure protection of your motorhome An authorized Thor Motor Coach service dealer can help you in the winterization process for your convenience A water heater bypass valve system is located inside your motorhome usually behind the water heater When the system is closed water is shut off to the water heater This will eliminate circulating an additional six to ten gallons of antifreeze through the water heater system when winterizing the system Be sure to remove the drain plug from the outside of the water heater to drain the water heater tank VALVE OPEN FOR NORMAL USE CLOSED FOR WATER HEATER BYPASS HOT FROM WATER HEATER HOT OUTLET VALVE CLOSED FOR NORMAL USE OPEN FOR WATER HEATER BYPASS TO WATER COLD HEATER COLD INLET VALVE OPEN FOR NORMAL USE CLOSED FOR WATER HEATER BYPASS When s
88. base plate can restore operation Any spray type silicone lubricant may be used Elevate the antenna and remove the set screw from the rotating gear housing Spray lubricant into the hole and around the edges of the gear housing Rotate the gear housing until the lubricant coats the bearing surfaces and the antenna rotates freely Replace set screw Buildup of mud under the body can cause rust and can add unnecessary weight which contributes to the gross weight of the vehicle This effectively reduces the amount of SLIDE OUT TIRES amp RIMS 127 Care and Maintenance UNDERBODY WINDOWS amp DOORS HYDRAULIC FLUID 128 APPLIANCES BATH FIXTURES BATHTUB SEAL cargo you can still carry and remain within your GVWR and GAWR limits Check the condition of the frame regularly Keep it clean and repaint as necessary to help avoid rust Corrosive materials such as those used for ice and snow removal accumulate on the underside of the motorhome These materials should be removed by flushing the underbody regularly with water especially in areas where mud and other foreign materials collect Any glass will develop water spots if glass is not cleaned properly This spotting effect is magnified when glass has a reflective finish Use a squeegee immediately after washing to reduce water spotting To remove stubborn water stains from reflective glass there are several aftermarket specialty glass cleaners The inside window track
89. bout On safe surfaces use mold or mildew killing cleaning products Check sealants regularly and reseal when necessary to avoid water leaks Proper preventive maintenance to the motorhome and its accessories as described both in this manual and in accompanying Your motorhome was designed primarily for recreational use and short term occupancy Effects of Prolonged If you expect to occupy the motorhome for an extended period be prepared to deal Occupancy with condensation and the humid conditions that may be encountered The relatively small volume and tight compact construction of modern motorhomes mean that the normal living activities of even a few occupants will lead to rapid moisture saturation of the air contained in the motorhome and the appearance of visible moisture especially in cold weather Moisture can condense on the inside surfaces of the motorhome during cold weather when relative humidity of the interior air is high Insulated walls of a motorhome are much thinner than house walls Estimates indicate that a family of four can vaporize up to three gallons of water daily through breathing cooking bathing and washing Unless the water vapor is carried outside by ventilation or condensed by a dehumidifier it will condense on the inside of the windows and walls as moisture or in cold weather as frost or ice It may also condense out of sight within the walls or the ceiling where it will manifest itself as warped or stained
90. ccur at the factory during manufacture during delivery of the motorhome to the selling dealer or on the selling dealer s lot Normally any such defect or damage is detected and corrected at the factory or by the selling dealer during the inspection process performed by the Warrantor and the selling dealer If however you discover any such defect or damage when you take delivery of the motorhome you must notify your dealer or Warrantor within ten days of the date of purchase to have repairs performed to the defect at no cost to you as provided by this Limited Warranty If two unsuccessful repair attempts have been made to correct any covered defect that you believe substantially impairs the value use or safety of your motorhome or repairs to any covered defect s which you believe substantially impairs the value use or safety of your motorhome have taken 20 or more days to complete you must to the extent permitted by law notify Warrantor directly in writing of the failure to successfully repair the defect s so that Warrantor can become directly involved in exercising a final repair attempt for the purpose of performing a successful repair to the identified defect s Minor adjustments such as adjustments to the interior or exterior doors drawers latches by way of example and not by limitation will be performed by your selling dealer during the first ninety 90 days of warranty coverage Thereafter such adjustments are the owner s exclusive
91. cle identification number on all motorized motorhomes er Note Always give model year and the V I N number information when ordering parts Also we recommend that you keep a copy of this information separate from the motorhome in the event theft or vandalism requires you to supply a copy to the authorities Decals and data plates used throughout the motorhome aid in its safe and efficient operation others give service instructions Read all decals data and instruction plates before operating your motorhome er Note When any decal data or instruction plate is damaged painted over removed etc the item should be replaced immediately The following warnings are posted throughout the motorhome to provide information on Propane safety They have been installed not only because of the requirement to do so but also as a constant reminder to occupants of the motorhome to exercise proper caution when using or being around Propane appliances and equipment We are listing them here so you may study them and make sure that you and your family understand and follow them IT IS NOT SAFE TO USE COOKING APPLIANCES FOR AWARNING COMFORT HEATING COOKING APPLIANCES NEED FRESH AIR FOR SAFE OPERATION TO ENSURE PROPER VENTILATION BEFORE A WARNING OPERATING A PROPANE APPLIANCES YOU SHOULD OPEN OVERHEAD VENTS TURN ON THE EXHAUST FAN AND OPEN A WINDOW Warning labels are located in the cooking area to remind you to provide an adequate su
92. contaminate the water supply Make sure that the tanks are properly treated with the right chemicals for disinfection Your motorhome is built to withstand a certain maximum load Check the amount listed on the Federal Certification Label in the driver s area of your motorhome to determine safe load limits NEVER OVERLOAD THE MOTORHOME Reference pages 21 23 and 24 for proper loading and weight distribution Weatherproofing sealants are used around the doors windows vents and joints during construction of your motorhome These sealants are subject to deterioration from exposure and must be checked periodically to assure the weatherproof integrity of your unit If evidence of cracking or voids in the sealants is apparent have your dealer reseal these areas Proper sealant coverage should be checked and resealed at least once every six months Please see Chapter 10 Care and Maintenance for instructions on properly sealing the roof area Failure or neglect of proper sealant maintenance could result in leakage and may reduce or void your warranty protection It is important that the owner realize that Thor Motor Coach s Limited Warranty covers warrantable repairs that are performed by an authorized Thor Motor Coach dealer at their service center or facility only If you are unable to bring your unit in for repairs Thor Motor Coach is not responsible for the cost of the actual service call charged to come out to your unit If your sli
93. d fading can be increased by prolonged exposure to extreme sunlight air pollutants and excessive moisture Surface weathering of fiberglass will not diminish structural integrity Regular monthly washing and polishing of exterior surfaces is the best insurance against surface deterioration such as fading yellowing or chalking Take care to avoid spraying water directly into refrigerator and furnace vents when washing the motorhome If surface deterioration is apparent contact a Thor Motor Coach dealer for assistance with finish restoration Physical damage to the fiberglass such as cracks holes and chips must be attended to immediately to avoid moisture from entering and causing problems with interior walls and components Cover these areas with plastic sealing the edges with tape until proper repairs can be made Clean and wax all trim extrusions when waxing the recreational vehicle sidewalls EXTRUSIONS to help avoid surface pitting Special aluminum cleaners are available to restore the AND ALUMINUM original luster to aluminum surfaces Make sure to follow the instructions for use as SURFACES outlined on the product package Inspect the roof components at least twice a year to make sure that all the seals are ROOF not cracked or worn Proper maintenance of seals is necessary to keep moisture from entering and causing severe damage such as rot mold or mildew If you encounter drying cracked or weathered seals make sure to reseal
94. d re connecting components Please consult the user s guide that was provided in your unit packet for detailed operating instructions Your motorhome may have an exterior TV hook up located in a storage compartment There is a coax cable located in this area to hook your satellite or park cable up to The following pages contain examples of the audio visual hook ups used in Thor Motor Coach Units The charts shown may differ from that of your unit due to the differences in floor plan and options that may or may not be installed on your coach If you have questions about the audio visual hook ups for your unit you may contact Thor Motor Coach Customer Service at 877 855 2867 The basic color codes for A V wiring is as follows Orange Satellite Gray Front TV Black Bedroom TV Beige Antenna White Cable Entertainment ALl 3015110 AL ema T c wou MOF HOIIAS DMIA AL MWDDBI3H SLINA PNPIB NUN SLINA ANNA avd WDHJ 7 CTATIWLSNI ASWOLSND JJA 195 AL OL A inainp HOi NUM3 oL 319714 HOLIMS d3ed LVS 31Hv3 ONY HSIT Q3TIvLSNI a3MWDLSTIS NNN3INV 5009 83 Entertainment Al NIYH Al 30100 TAC 31919 318 WE TTD EAL WA NUI AL WODSI3E VNN3LNV 5005 CQ3TWISNI 43 015012 AJAJIA 195 AL OL p 31914 HOLIMS 359 195 J143 ONY HSIT I3TWLSNI aSWOLSN3
95. d to corrosion Component part and appliance manufacturers issue limited warranties covering those portions of the motorhome not covered by the Limited Warranty issued by Warrantor To learn more on what specific component parts and appliances are excluded from the Limited Warranty issued by Warrantor please contact your selling dealership or Warrantor directly or review the warranty packet inside the Motorhome EVENTS DISCHARGING WARRANTOR FROM OBLIGATION UNDER WARRANTY Misuse or neglect accidents unauthorized alteration failure to provide reasonable and necessary maintenance see Owner s Manual damage caused by off road use collision fire theft vandalism explosions overloading in excess of rated capacities and odometer tampering shall discharge Warrantor from any express or implied warranty obligation to repair any resulting defect DISCLAIMER OF CONSEQUENTIAL AND INCIDENTAL DAMAGES THE ORIGINAL PURCHASER OF THE MOTORHOME AND ANY PERSON TO WHOM THE MOTORHOME IS TRANSFERRED AND ANY PERSON WHO IS AN INTENDED OR UNINTENDED USER OR BENEFICIARY OF THE MOTORHOME SHALL NOT BE ENTITLED TO RECOVER FROM WARRANTOR ANY CONSEQUENTIAL OR INCIDENTAL DAMAGES RESULTING FROM ANY DEFECT IN THE MOTORHOME INCLUDING BY WAY OF EXAMPLE FUEL AND TRANSPORTATION EXPENSES TO DELIVER THE PRODUCT TO THE SERVICING DEALER HOTEL ROOMS LOST WAGES AND MOISTURE DAMAGE SUCH AS MOLD AND MILDEW THE EXCLUSION OF CONSEQUENTIAL AND INCIDENTAL DAMAGES SHALL BE DEEMED INDEPENDE
96. de out system becomes squeaky or makes any noises while operating it is permissible to apply a coat of lightweight oil to the drive shaft and roller areas located below the main floor Remove any excess oil so dirt and debris cannot build up To maintain the integrity of the retractable step in your motorhome you must periodically inspect it for rust or damage also see that it is lubricated to function safely and to ensure proper working order The owner is responsible for maintaining proper tire pressure in the vehicle s tires Check the tire specifications on the Federal Certification Label located in the driver s area for the proper pressure You will ensure optimum driving standards by keeping your vehicle maintained Never forget to remove your travel bars from your slide out prior to opening Failure to do so could result in severe damage to yourself and or your motorhome which will not be covered under the Limited Warranty Like most cars your motorhome s windshield is not covered under the Limited Warranty Items such as cracks stone chips and holes are regarded as normal wear and tear and will not be considered as a manufacturing defect Please make sure that your vehicle is properly winterized before long periods of storage To find a complete listing of the winterization procedures refer to this manual s section called Winterization Procedures Failure to properly winterize your vehicle may result in damage to your mot
97. de poisoning are e Dizziness Vomiting Nausea Muscular twitching Intense headache e Throbbing in the temples Weakness and sleepiness Inability to think coherently If you or anyone else experience any of these symptoms get to fresh air immediately Shut the generator down and do not operate it until it has been inspected and repaired by a professional If the symptoms persist seek medical attention As 10 DO NOT operate the generator while sleeping You would not be aware of exhaust entering the motorhome or alert to symptoms of carbon monoxide poisoning NEVER store anything in the generator compartment Always keep the compartment clean and dry DO NOT operate the generator in an enclosed building or in a partly enclosed area such as a garage REVIEW the safety precautions for fuel and exhaust fumes elsewhere in this manual DO NOT operate the generator when the motorhome is parked in high grass or brush Heat from the exhaust could cause a fire in dry conditions NEVER operate the chassis or generator engine or the engine of any vehicle longer than necessary when the vehicle is parked DO NOT simultaneously operate generator and a ventilator which could result in the entry of exhaust gas When parked position the motorhome so that the wind will carry the exhaust away from the motorhome DO NOT open nearby windows ventilators or doors into the passenger compartment part
98. djustment Check fluid levels If levels are low take to your dealer to have the motorhome serviced by a qualified RV technician Make sure to read all literature provided with each of the appliances and follow the maintenance instructions included Pay particular attention to any cautions or warnings included Each appliance in the motorhome is warranted by their respective manufacturer Be sure to remove all food and ice from the refrigerator at the end of each trip Prop the doors open slightly to keep the interior dry and free of mold mildew and odors Clean your tub shower sinks and toilets as you would at home A nonabrasive cleaner is recommended When cleaning mirrors or shower doors a vinegar and water solution works very well to remove hard water spots and stains Inspect every 90 days and reseal as necessary Use a clear silicone sealant Care and Maintenance We recommend dry cleaning for your bedspread and draperies just as you would for your draperies and comforters at home Although this is more expensive proper care of material will help ensure a longer life Care of headboard and bedroom valance fabric should be done with same instructions given for upholstery fabrics Laundering and improper cleaning may result in fabric shrinking fading or deteriorating prematurely Read the label on the bedspread for proper cleaning Professional cleaning is recommended for major cleaning Frequent vacuuming is recommended to
99. e correct heavy duty cleansers Do not use general purpose cleaners containing petroleum solvents harsh abrasives or citric based cleaners If your roof should somehow be punctured cover the puncture to seal out moisture and have it repaired as soon as possible check with your dealer The membranes used on the roof may have an extended warranty that is covered by the membrane manufacturer This is for manufacturing defects only and does not include leaks or punctures due to improper sealing normal wear and tear or owner damage See membrane manufacturer s warranty for details Check roof vents regularly for debris that may block air flow or jam the cranking mechanism Lubricate the cranking mechanism with light oil Failure to maintain seals through regular maintenance can lead to damage of motorhome components and may be considered abusive treatment under terms of your motorhome warranty It is important to maintain the seals and adhesives of your recreational vehicle to prevent moisture from entering and destroying the components When washing your recreational vehicle inspect the seals for signs of drying out cracking and wear You should inspect and reseal if necessary every six months at minimum Be aware that weather sun and road vibration will affect seals causing them to dry crack or separate If you are unsure what to look for have your dealer instruct you and also show you the correct method for renewing the seals I
100. e follow the recommendation in this section to address this concern 33 Identification and Safety SEAT BELTS A WARNING DO NOT OCCUPY BEDS OR ANY OTHER SEATS THAT Seat Belt Operation 34 ARE NOT EQUIPPED WITH SAFETY SEAT BELTS WHILE THE Motorhome IS IN MOTION DO NOT USE A SEAT BELT ON MORE THAN ONE PERSON A WARNING ALL OCCUPANTS MUST BE SEATED AT A DESIGNATED SEATING POSITION AND MUST WEAR A SEATBELT AT ALL TIMES WHILE THE VEHICLE IS IN MOTION Pilot and co pilot seats must be locked in a forward facing position with seat belts fastened while the motorhome is in motion Avoid seat rotation while in transit The sleeping accommodations in this vehicle are designed for occupancy only while the vehicle is parked All occupants in this vehicle must be seated at a designated seating position and must wear seat belts at all times while this vehicle is in motion Safety belts and seats can become hot in a vehicle that has been closed up in sunny weather they could burn a small child Check seat covers and buckles before you place a child anywhere near them All occupants must be furnished with and use seat belts while the motorhome is moving However it is not intended for all seats to be simultaneously occupied while the vehicle is in motion without regard to the total loaded weight of the vehicle Insert the belt tongue into the proper buckle the buckle closest to the direction the tongue is coming from until you hear a snap
101. e furnace in operation canned goods and other foods packed in water should be stored as high as possible since heat rises They might also be stored in the refrigerator as insulation against the cold Store dry foods and other items that are not damaged by freezing temperatures in the lower storage areas Make sure to use propane that will vaporize properly in the colder temperatures Check with your propane representative for the proper fuel Use only the furnace to heat the recreational vehicle It is properly vented to the outside Never use the range for heating as carbon monoxide may AWARNING build up inside the unit and asphyxiation could result Cooking produces large amounts of moisture not just as steam from pots and pans but also as a product of combustion Make sure to use the exhaust vents and open a window slightly to control the humidity At night leave a roof vent and or a window slightly open When a motorhome is exposed to freezing temperatures it could be severely damaged by ice expansion This is especially true of the water heater washer dryer ice maker holding tanks and faucets which are at risk for damage if not properly drained during the winter All water must be drained from the motorhome The procedure to do so is as follows 1 Drain the fresh water tank by opening the low point drain valve Let the water drain out until the tank is empty 2 Drain both the black waste water tank and the gray sink w
102. e regulators When an outside source of water is unavailable water can be drawn from the fresh Fresh Water Tank water storage tank for use in the motorhome The tank is filled through a gravity controlled water fill spout on the side of the motorhome 107 Water Systems Filling the Fresh Water Tank Using the Gravity Fill Filling the Fresh Water Tank Using a Swan Valve 108 Water Pump When traveling you may want to drain the tank or keep the quantity of water in it toa minimum This reduces the total weight of the motorhome for travel Make sure when draining the tank that the water pump has been turned off The fresh water tank drain valve is located below and near the fresh water fill spout Water in the tank can be drained by turning the drain cock perpendicular to the motorhome body To close the valve turn the lever parallel to the motorhome body Note Always fill the tank with clean potable water from a known safe source Make sure to close the fill spout when the tank is filled To fill the fresh water tank 1 Remove the water fill spout cap and fill directly to the tank 2 Use clean hose or bucket from a clean safe source of water 3 Be sure to replace the fill spout cap after the tank is filled gt Note Never leave the hose unattended while you are filling the fresh water tank Note Water will overflow through the vent located at the top of the fresh water tank if the tank
103. e repair or replacement remedy fails to successfully cure a defect after Warrantor received a reasonable opportunity to cure the defect s your sole and exclusive remedy shall be limited to Warrantor paying you the cost of having an independent third party perform repairs to the defect s or diminution in value damages if defect s are incurable Warrantor may use new and or remanufactured parts and or components of substantially equal quality to complete any repair Defects and or damage to interior and exterior surfaces trim upholstery and other appearance items may occur at the factory during manufacture during delivery of the motorhome to the selling dealer or on the selling dealers lot Normally any such defect or damage is detected and corrected at the factory or by the selling dealer during the inspection process performed by the Warrantor and the selling dealer If however you discover any such defect or damage when you take delivery of the motorhome you must notify your dealer or Warrantor within ten days of the date of purchase to have repairs performed to the defect at no cost to you as provided by this Limited Warranty If two unsuccessful repair attempts have been made to correct any covered defect that you believe substantially impairs the value use or safety of your motorhome or repairs to any covered defect s which you believe substantially impairs the value use or safety of your motorhome have taken 20 or more days to complete you m
104. ect the radio band FM AM Press and hold to enter cancel the passenger control iPod Enter the bookmark mode Pandora via USB 10 SEEK buttons Radio Press to tune in stations automatically Press and hold to find a station manually CD USB Press to skip a track Press then press again within about 2 seconds and hold to skip tracks continuously Press and hold to reverse fast forward a track Pandora via USB Press Seek to skip a track App Remote Press to skip a track 11 PTY Program Type CAT Category button To select PTY in RDS To select the category in SiriusXM 12 Number buttons Radio Press to receive stored stations Press and hold to store stations CD USB 1 2 ALBUM during MP3 WMA AAC playback Press to skip an album Press and hold to skip albums continuously 3 Repeat 4 Shuffle 6 Pause Press to pause playback Press again to resume playback Pandora via USB 1 2 Press and hold for 1 second for thumbs down up 6 Pause Press to pause playback Press again to resume playback App Remote 6 Pause Press to pause playback Press again to resume playback 13 AUX input jack 14 USB port 51 Controls and Operations Jensen MSR3012012 8 1 Power On Off Press to turn the unit off Press any button on the front panel to turn the unit on 2a 2b Volume Control To increase the volume press the VOLUME button To decrease the volume press the VOLUME button 3 Audio Menu Press to
105. ected driving positions To tilt the steering wheel pull the adjustment lever toward you and move the steering wheel to where you want it Release the lever and the steering wheel will lock in the new position Never attempt to adjust the steering wheel while the vehicle is in motion Loss of vehicle control could result The lever on the left side of the steering column controls the turn signal with lane change feature as well as the Head lamp high low beam toggle as well as the windshield wiper and washer fluid dispersal The turn signal lever has two off center positions one positions upward for right and one downward for left To signal a turn move the lever all the way up or down These are latching positions The lever will stay in one of these positions until the steering wheel returns back to center as the turn is complete To change the head lamps from low to high beams pull the same lever used for turn signal operation up toward the driver and release the lever This is a self returning action Repeating this toggle action will return to the low beams The hazard flasher control button is located on the steering column just behind the steering wheel To activate your hazard flashers press the button To turn off the hazard flashers press the button again STEERING WHEEL ADJUSTMENT TURN SIGNAL LANE CHANGE HIGH LOW BEAM HAZARD FLASHER CONTROL LA 47 Controls and Operations STAND ALONE REAR 48
106. ed moisture vapor by expelling it through a vent system as the light warms up The vent system operates at all times however it is most effective when the lamps are on and the vehicle is in motion Since most motorhomes are parked for long periods of time they have a greater chance of condensation build up E gt Note Check head lamp regularly for condensed water drops This should be done daily in high humidity areas If small drops of condensed water are noted drive the motorhome with head lamps ON or just turn ON the head lamps This will evaporate the condensed water drops and will avoid water being accumulated Depending on the size shape and location of the lamp on the motorhome and the atmospheric conditions occurring the amount of time required to clear the lamp may vary Cleaning is the most effective maintenance that you can perform on your lights dirt and road grime build up can cut light output by 40 or more Care and Maintenance When cleaning your head lamps please observe the following do not rub them dry and never use abrasives or strong solvents Remove dirt and contamination such as insects by soaking with shampoo and then rinsing with plenty of water Always use a de icer spray to remove accumulated ice and snow never use a scraper Check the head lamp vent tubes this will be a small rubber hose or plastic cap located on the back of the light make sure that they are free of dirt and the rubber is
107. er hold a child on his or her lap while the vehicle is moving You are required by law to use safety restraints for children in the U S and Canada If small children generally children who are four years old or younger and who weigh 18 kg 40 Ibs or less ride in your vehicle you must put them in safety seats Made especially for children Identification and Safety QA Note Check your local and state or provincial laws for specific requirements regarding the safety of children in your vehicle CS Note Always follow the instructions and warnings that come with any infant or child restraint you might use If the child is the proper size restrain the child in a safety seat Children who are too large for child safety seats as specified by your child safety seat manufacturer should always wear safety belts If the shoulder belt portion of a combination lap and shoulder belt can be positioned so it does not cross or rest in front of the child s face or neck the child should wear the lap and shoulder belt Never use pillows books or other objects to boost a child TO RELEASE THE EGRESS LATCHES An egress window is designated for use EGRESS WINDOW PULL THE HANDLES TOWARDS ONE ANOTHER as an exit in the case of an emergency lan roO Gea Inside the motorhome the egress window is easily identified by the red locking handles There are two common styles of latches determine the style of locking h
108. ergency arise The following basic rules of fire prevention can help eliminate the possibility of a fire Never store flammable liquids within the motorhome Keep cooking surfaces clean Never clean with a flammable liquid Never leave cooking food unattended Never smoke in bed and always use an ashtray Never allow children to play with Propane gas or electrical equipment Never use an open flame as a flashlight Always repair faulty or damaged wiring and electrical components Never overload electrical circuits Locate and repair Propane gas leaks immediately Don t allow rubbish to accumulate Spray fabrics annually with a flame retardant If a fire does start make sure to follow these basic rules of safety 1 Have everyone evacuate the motorhome as quickly as possible 2 After everyone is clear check the fire to see if you can attempt to put it out If it is too large or the fire is fuel fed get clear of the motorhome and have the fire department handle the emergency 3 DO NOT attempt to use water to put out the fire Water can spread some types of fire and electrocution is possible with an electrical fire DO NOT STORE PROPANE CONTAINERS INSIDE THE Motorhome Propane containers are equipped with safety devices which relieve excessive pressure by discharging gas to the atmosphere Failure to comply could result in explosion resulting in death or serious injury Identification and Safety Portab
109. eries power all house 12 Volt devices The coach batteries are of the golf cart variety and are capable of being deeply discharged With a large reserve rating the batteries are able to provide limited use before needing to be recharged Because of the large power rating the batteries must be recharged for a minimum of 24 hours to reach a full charge Electrical Systems BATTERIES CAN EXPLODE Always wear splash proof A DANGER safety glasses when working near batteries Do not smoke or expose any battery to electric sparks or flame Batteries when charging or discharging generate hydrogen Hydrogen and air is a very explosive mixture DO NOT SHORT ACROSS THE BATTERY TERMINALS A WARNING The spark could ignite the gases Do not wear metal jewelry or a watch when working on a battery Before doing ANY work on electrical system disconnect battery cable and the 120 volt power cord Do not reconnect the cables until all work has been completed This will avoid the possibility of shorting or causing damage to electrical components or shock to the servicing person Battery electrolyte is a corrosive poisonous sulfuric acid Avoid contact with skin eyes clothing or any painted surface Sulfuric acid in the batteries can cause severe injury or WARNING death Sulfuric acid can cause permanent damage to eyes burn skin and eat holes in clothing Always wear splash proof safety goggles and gloves when working around the battery If
110. eriodically and recharge as needed Be sure that both the chassis and auxiliary house batteries have the proper electrolyte level and that they are fully charged A discharged battery will freeze and may crack the case causing severe damage to the battery and surrounding area In storage a battery will lose charge gradually over a 30 to 45 day period even when disconnected by the use of the Battery Disconnect Switch We recommend that the batteries be checked for charge at least monthly You may wish to remove the batteries from the motorhome and store them in a heated area However even when warm the battery charge level must still be maintained A warm battery accepts charge much more readily than a cold one A WARNING Keep the battery vent caps in place during storage and prohibit smoking welding and other work involving the Fuel Dash Air Conditioner Interior use of flames in the area Store with the tank full to prevent condensation buildup Run for a short period of time to assure the compressor seal is lubricated Check the interior of the motorhome monthly while in storage to make sure leaks have not developed or condensation has not formed that can cause damage to interior components Condensation can most readily be observed as moisture accumulation on windows and mirrors To reduce condensation make sure to air out the motorhome occasionally during storage 139 Travel Preparation Checklist CLOTHING Dr
111. esses Gloves Hat or Cap Jackets Coats Jeans Dress Pants Pajamas Shirts Blouses Shoes Sandals Shorts Socks Sweaters Swimsuits Undergarments TOOL CHEST Electrical Tape Step Ladder Furnace Duct Tape Hatchet Masking Tape Saw Shovel Rake Small Level Tire Pressure Gauge Various Tools HOUSEKEEPING Dish Cloths Dish Towels Dish washing Soap Disposable Gloves Garbage Trash Bag Mop Broom Dust Pan Paper Towels Surface Cleaner Degreaser Throw Rug Trash Cans Vacuum Cleaner SAFETY Compass First Aid Kit Flares Flashlights Reflectors 140 SLEEPING GEAR Blankets Pillows Pillow Cases Sheets Sleeping Bags PERSONAL COMFORT Anti Bacterial Wet Wipes Ash Tray Personal Medications Personal Toiletries Sewing Kit Scissors Soap Sunscreen Toilet Paper Toothbrush Toothpaste Towels Wash Cloths MEAL PREPARATION Baking Pans Bottle Opener Can Opener Coffee Maker Foil Plastic Wrap Glasses Cups Plastic Containers Plates Bowls Portable Grill Pots Pans Skillets Salt amp Pepper Seasonings Spices Silverware Spatulas etc Toaster ENTERTAINMENT Binoculars Books Magazines Camcorder Camera Film Memory Card Movies Music Cd s Toys Games Playing Cards VHS Player DVD Player Yard Games MISCELLANEOUS Alarm Clock Batteries Bucket Clothes Hangers Clothes Line Clothes Pins Electronics Chargers Fresh Water Hose Fuses Ground Extension Wire Umbrella Wheel Ch
112. f you prefer they will be able to perform seal maintenance for your convenience gt Note It is especially important to check the seals before and after periods of extended storage or non use Fall and spring inspections are recommended Check seals around doors windows vents and external seams If a seal is cracked or dried out it should be replaced to prevent leakage Care and Maintenance e Check roof seals every six months to see if they are cracked or peeling e Check engine covers and firewall every six months to see if they are cracked or peeled Your motorhome may be equipped with a slide out room for added space and comfort Proper care and maintenance is required to achieve the maximum performance Follow the guidelines listed below for your slide out It may be necessary to lubricate the slide assembly rollers slide tubes lever assembly once a month with light oil to prevent rust buildup This may be required more frequently due to road spray salt sand dirt etc If you park your unit for long periods of time run the room in and out 2 3 times to keep the moving parts lubricated and the seals moving more freely Keep the slide room away from tree branches Visually inspect the room and awning before retracting Branches rubbing against the room while retracting could cause damage to the seals Whenever possible wipe down the exterior walls before retracting the room to prevent water from draining ont
113. face e Because moisture is key to mold issues treat all signs of condensation and spills seriously and deal with promptly Failure to deal with a moisture issue promptly may cause more Severe issues where none initially existed or may make a small problem much worse Learn to recognize signs of mold don t paint over or cover up suspicious discoloration until you are sure it is not mold The affected surface must first be cleaned and dried residual staining may be painted e sure to understand and eliminate the source of moisture accumulation as a part of the clean up e Small amounts of mold should be cleaned as soon as it appears Small areas of mold should be cleaned using a detergent soapy solution or an appropriate household cleaner Gloves should be worn during cleaning The cleaned area should then be thoroughly dried Dispose of any sponges or rags used to clean mold Storage of the Motorhome 133 134 Winter Use and Storage Thor Motor Coach recommends that you winterize your unit before the ambiant temperature reaches 32 degrees however many people choose to use their motorhomes throughout the entire year Extensive usage is not recommended in severe cold weather However winter traveling can be safe for you and your motorhome if you follow the precautions outlined in this chapter For those who choose to use their motorhomes only during the warmer months winter storage is necessary This section will guide
114. fety regulations The best cruising speed of your motorhome will vary with road and weather conditions Remember that your motorhome is heavier than a car making it less maneuverable and harder to stop Brake pedal pressure and travel may vary significantly from that of a car Be prepared to brake earlier than you normally would a car Also because of its greater side surface area it is more easily affected by cross winds Allow extra distances for passing and stopping and drive at a moderate speed particularly in traffic and in gusty wind conditions Driving on winding or mountain roads is not difficult if done with reasonable care Observe proper vehicle speeds when ascending or descending hills and always operate in the proper transmission range Downshift on hills to avoid overheating or undue engine loads Downshift before descending grades Road conditions terrain weather and other driving factors are sometimes unpredictable and mountain driving or desert temperatures can put extreme demands on drive train components especially the transmission Under extreme heat conditions you may need to turn off the vehicle air conditioner to improve engine and transmission cooling Allow for the extra height of your motorhome and avoid areas having low overhead PARKING clearance Check for low hanging tree branches or other obstructions wherever you drive or park Avoid low roof heights when pulling in for service This may be particularly im
115. fic b Place the second 100 feet behind the motorhome in the center of the lane and toward approaching traffic c Place the third 100 feet in front of the motorhome in the center of the lane and away from the traffic approaching from behind 5 Always stand off the road Note Curves and or hills may effect the safe placement of warning indicators Full operating and service information may be obtained by consulting the engine and drive train operating and service manuals provided by the chassis manufacturer For maximum engine efficiency and long service life always follow recommendations as outlined by the chassis manufacturer Regular visual inspections can help detect minor adjustments and needed maintenance All other components of the chassis should be inspected regularly per the schedules set by the chassis manufacturer EMERGENCY STOPPING ENGINE AND DRIVE TRAIN 37 Chassis 38 Engine Access AWARNING IF THE ENGINE COVER IS NOT SEATED CORRECTLY FUELING THE MOTORHOME Ford Fuel Pump Collision Shut off Switch TRAVEL PREPARATION Chassis Checks EXHAUST GASES MAY LEAK INTO THE Motorhome CREATING A DANGEROUS AND POTENTIALLY LETHAL SITUATION The motorhome engine can be accessed for service from inside the motorhome The engine cover between the driver and passenger seats can be removed When reinstalling the engine cover make sure that it is seated correctly without obstruction from carpet floor
116. flush attachment Attach the city pressure hose and allow the water to flow for three minutes Be sure to open the termination valves and have the sewer hose attached and draining into an approved waste disposal system Water Systems 5 Hatch cover Open this and pass your city pressure hose through Close with hose passing through small opening in the cover 6 Exterior faucet For mixing the water temperature for the exterior shower head The toilet installed in the motorhome is connected to the pressurized fresh water TOILET system It uses a foot pedal to flush and add waiter to the bowl To flush the foot pedal style depress the pedal all the way until rinse clears the bowl Be sure to release the lever slowly Movement of the flush lever opens the waste valve and allows the water to pass into the holding tank To add water to the bowl depress the pedal half way This will open the water valve and leave the flush lever closed E gt Note Unnecessary frequent flushing of the stool will quickly deplete your fresh water supply and fill your holding tank If the black water tank becomes full you will no longer be able to flush the stool until the tank can be drained C Note Follow the toilet manufacturer s recommendations supplied with the toilet for cleaning and maintenance If you have a toilet that differs from the description given here make sure to follow the manufacturer s advice for operation 1 Connect sewer
117. fort and dependable service The heater air conditioner unit is located beneath the dash on the passenger side of the vehicle with heating and cooling coils located on the outside of the fire wall In most modes of operation the unit takes fresh air from outside and heats or cools it before discharging into the motorhome Only when operated in the MAX A C mode does the system take air from inside the motorhome The control panel enables the driver to control the temperature volume and direction Control Panel of the air discharged from the heating air conditioning system One of the best ways of controlling temperature is by changing the speed of the blower The blower knob left of center provides 4 speeds in any mode except OFF The center knob controls the temperature of the discharge air Turn the knob to the right red area for warmer air and to the left blue area for cooler air The air conditioning system is designed to operate in all modes except VENT Operating Features FLOOR and OFF This provides significant moisture dust and pollen removal for enhanced passenger comfort Use MAX A C and HI blower for quick cool down A lower blower speed produces cooler air To assist with cooling close all windows and vents to hot humid outside air Ce Note The A C will not function if the outside air temperature is below approximately 40 Fahrenheit ce Note n the event control vacuum is lost the system is designed to dischar
118. frigerator Refrigerator Doors Reporting Safety Defects Return Air Filters Roof Roof A C Performance Characteristics Roof Mounted Air Conditioner Roof Vents Sample A V Hook up Diagrams Sanitizing the System Sealants Seals amp Adhesives Seat Belt Maintenance Seat Belts Seatbelt Operation Service Calls Sewage Shore Cord Shower Head amp Hose Sinks Sleep Number Bed Slide Out Awning Slide Out Lubrication Slide Outs Smoke Detector Smoke Detector Choosing a Replacement Battery Smoke Detector Regular Maintenance Smoke Detector Testing Procedure Sofa Bed Sofa Hide A Bed Solid Surface Countertop Space Saver Sofa Steering Wheel Adjustment Step Lubrications Storage Above Cockpit Storage of the Motorhome System Panels System Panels 110V with 30 Amp System Panels 110V with 50 Amp System Panels BCC Fuse Panel System Panels Converter Fuse Panel Television Termination Compartment Components Thermostat Setbacks Thermostats Tips for Controlling Condensation Tips for Winter Use Tire Care Tire Pressure Tires Tires amp Rims Toilet Toilet Foot Pedal Toilet Hand Lever Trailer Towing Travel Bars Index 14 60 17 64 48 18 60 18 66 7 72 103 72 72 104 68 87 14 104 33 33 33 14 18 75 61 107 56 65 14 54 105 27 28 28 28 57 57 107 58 47 14 56 111 81 81 81 81 81 68 90 110 73 110 113 42 14 17 105 90 91 90 34 14 149 Index
119. from accidentally opening during travel Drawers throughout the motorhome have travel stops which keep them from sliding out when in motion under normal driving conditions When storing articles Always keep tools and equipment stored in areas where they will not shift while traveling Whenever possible place heavy articles in storage compartments which are low and near the axles for better weight distribution Pack articles carefully in the storage compartments to minimize shifting If necessary use straps to prevent movement Be sure liquid containers are capped and cannot tip or spill Secure all glass containers and dishes before traveling e Store items in the areas designated for storage DO NOT store anything in the area reserved for the converter and electrical panels or the water tank and pump CAUTION USE CAUTION WHEN LOWERING THE BED KEEP HANDS AND FINGERS AT THE END LEDGE PROVIDED and not on the side or further back than necessary where you may encounter pinch points Additional storage is accessible directly beneath the bed Simply unlatch and lift the foot of the bed The device is equipped with gas struts to assist with opening holding and closing the bed storage lid Controls and Operations DO NOT OCCUPY BEDS OR ANY OTHER SEATS THAT AWARNING SOFAS ARE NOT EQUIPPED WITH SAFETY SEAT BELTS WHILE THE Motorhome IS IN MOTION DO NOT USE A SEAT BELT ON MORE THAN ONE PERSON The sleeping accommodations
120. g section is for reference only For detailed information regarding product information and proper maintenance of the chassis refer to the chassis manufactures owner s manual You as the owner are responsible for taking the proper precautions when attempting any repair or maintenance If you are not sure what action to take or are uncomfortable with performing a maintenance or repair function contact your dealer or a designated chassis manufacturer servicing dealer Check information supplied by chassis manufacturer for a service dealer near you Special procedures or schedules for breaking in your new motorhome are minimal Make sure to follow the recommendations as outlined in the chassis owner s manual to ensure proper future performance and economy CS Note Make sure to read all chassis information supplied by the chassis manufacturer paying particular attention to precautionary notes and warnings as well as all maintenance procedures and schedules IF AN EMERGENCY EVER REQUIRES YOU TO BE STOPPED BE SURE TO FOLLOW THESE GUIDELINES 1 Pull off the road as far as possible 2 Select the Park position and apply the Parking Brake 3 Turn on the hazard warning flashers 4 Use three red warning indicators such as flares reflectors or lanterns as required by the Uniform Vehicle Code and Model Traffic Ordinance as follows a Place the first indicator on the traffic side of the vehicle directed at the nearest approaching traf
121. g spark plugs could be accomplished at an auto service center but must be done in accordance with the service instructions specified by the generator manufacturer Refer to the Generator Owner s Manual for further information Care and Maintenance All service procedures should be performed only by a CAUTION PROPANE SYSTEM certified propane service technician The propane system should be checked regularly for leaks and road damage Follow the lines looking for kinks or flattened spots that may have occurred during travel or maintenance on the recreational vehicle A qualified propane service technician using proper equipment should check the entire system annually or whenever you suspect a problem The line pressure for propane appliances should be checked at least every six months Most propane suppliers have this equipment to do the test for you Insects can build nests in the burners of the various appliances and equipment The burner and burner orifice of the propane appliances should be cleaned out by an authorized dealer or repair facility anytime circumstances or conditions warrant but no less frequently than on an annual basis Some components of the recreational vehicle are constructed of strong lightweight ABS PLASTIC PARTS ABS plastic Sometimes it may be necessary to remove stains or generally clean A mild solution of soap and water will clean many stains and should be used initially Tougher stains may require
122. ge through the defrost vents To achieve the maximum comfort in the motorhome the air must be directed where it is needed The mode switch right of center gives the driver the ability to select where the air will flow Keep the condenser and radiator free of bugs and debris During periods of little use operate the A C system monthly to keep the compressor lubricated Periodically inspect belts and hoses for wear and proper tension If repairs are necessary during the terms of the motorhome warranty please contact Warranty Service the nearest authorized Thor Motor Coach dealer for service In the event repairs are necessary during transit contact Thor Motor Coach Customer Service Certain individual parts of the Heating and Air Conditioning System such as the compressor dryer and condenser are covered under the chassis manufacturer warranty ce Note Components covered under the Thor Motor Coach Limited Warranty must be Original Equipment Manufacturer OEM parts The installation of after market components or unauthorized repairs may void the warranty 87 Heating and Air Conditioning The motorhome is equipped with a roof mounted air conditioner This air conditioner ROOF MOUNTED operates from 120 Volt AC only either from shore power or the on board generator AIR CONDITIONER Air conditioner functions are controlled by the comfort control panel You can expect to see up to 15 to 20 degree differences in temperature between
123. h Bedspread amp Draperies Blinds amp Shades Cable Hookup Phone Jack Camera Operation Carbon Monoxide Detector Carbon Monoxide Safety Precautions Care and Maintenance Carpet Carpet Care and Moisture Management Ceiling Vents Chairs Changing Tires Chassis Chassis Alternator Chassis Battery Chassis Checks Check Air Pressure Checking the Propane System for Leaks Chemical Sensitivity Child Restraints Circuit Breakers Comparment Doors amp Storage Compartments Compartment Doors Condensation Control of the Motorhome Controls and Operations Dash A C Control Panel Dash A C Operating Features Dash A C Warranty Service Dash Controls Dash Panel Heater and Air Conditioner Dash Radio Day Night Shades Dinette 148 80 80 80 76 76 99 58 13 99 106 62 74 73 50 50 65 45 97 65 99 58 106 107 13 76 97 79 78 13 76 59 107 107 66 48 27 29 97 107 110 73 59 42 37 100 82 97 38 42 30 32 33 80 64 18 13 113 17 45 71 71 71 45 71 49 59 58 Doors amp Drawers Driving Dumping the Holding Tanks Effects of Prolonged Occupancy Egress Window Electric Slide Out Electric Slide Out Manual Retraction Procedure Electric Step Electrical System Elevated Beds Elevated Beds Tips for Safe Usage Emergency Retraction Procedure Emergency Stopping Engine Access Engine and Drive Train Entertainment Entry Door Entry Step Exhaust Vent Exterior Care of the M
124. he Propane Gas system is designed to accept either Propane or Butane However since Butane vaporizes at about 32 F it can only be used in areas where you can be sure of higher temperatures Propane vaporizes at approximately 40 F There are blends of Propane and Butane available which will vary in the temperature at which it vaporizes When filling the tank select a Propane Gas that has a boiling point about 40 lower than temperatures you expect to travel in Consult with your dealer or local Propane Gas supplier about what you should be using The gas is stored under extreme pressure in the tank with space in the tank to allow for expansion into vapor This vapor is reduced in pressure by passing through a regulator This reduction in pressure is a two step process which assures consistent pressure for use regardless of outside temperatures weather or altitude E gt Note For detailed information regarding propane gas and it s use consult a qualified propane service representative MAKE SURE THAT THE TANK IS NOT FILLED BEYOND A WARNING THE 80 LIQUID LEVEL Even though the tank is equipped with an automatic 80 shut off which prevents over filling beyond 80 tank capacity it is a good idea to have the supplier monitor the 20 liquid gauge and stop the filling process if liquid does appear If the tank has been over filled make sure the propane supplier bleeds out the excess Over filling the propane gas container does n
125. he panel to check for insect nests you will need a Square or a Phillips head screwdriver For further information reference the furnace manufacturer s manual provided with your vehicle You can gain access to the water heater control panel to check for insect nests by turning the tab at the top and allowing the door to hinge down Due to the electronic ignition it is no longer necessary to access this compartment for lighting the pilot It has an electronic module board electronic ignition lighter and a safety pop off valve to relieve the pressure should it be necessary The refrigerator is an electronic ignition appliance and there is no need to access this panel except for service or checking for insect nests If a problem is encountered follow the guidelines for use as outlined in the Refrigerator Owner s Manual located in the Owner s Information Kit If the problem is not resolved contact an authorized Thor Motor Coach dealer 81 Entertainment TELEVISION HOME THEATER SYSTEM EXTERIOR ENTERTAINMENT CENTER VIDEO SWITCH BOX TV HOOK UP 2 SAMPLE A V HOOK UP DIAGRAMS 82 Your coach may be equipped with various audio visual components Due to the large variety of equipment and variation in installation this section should be considered a general overview of the entertainment equipment If you are having A V issues please refer to the component specific user s guides that were included in your unit pack If yo
126. he system will automatically level your vehicle The control panel will send out a series of beeps to let you know that AUTO LEVEL is operating When completed the panel will signal a successful Auto Level After ten minutes the panel will enter sleep mode 3 RETRACTING THE JACKS Your Lippert System provides you with the ability to retract the jacks using the Retract All Jacks Button feature Press and retract the Retract All Jacks Button All jacks will automatically retract The jacks are retracted when the Jacks Down light has gone out Depending on the vehicle full retraction may take up to 90 seconds Controls and Operations MANUAL OPERATION BUTTON PLACES CONTROL PANEL IN MANUAL OPERATION MODE SYSTEM RESUME OPERATION WHEN THE LED GOES OFF JACKS DOWN LED INDICATES JACKS ARE IN ANY VARIOUS STATE OF EXTENSION war ANO NOT FULLY RETRACTED BORE DOWN LOW VOLTAGE LED INDICATES EI 9 LOW VOLTAGE HAS DROPPED BELOW SAFE OPERABLE LEVEL NGAGE PARK BRAKE SOUD VOLTAGE TOO LOW TO OPERATE LEVELING SYSTEM EXCESS ANAKE Of CAUTION Sirise sro tee comme ovna ENGAGE PARK BRAKE LED FLASHES WHEN PARK BRAKE IS DISENGAGED OFF WHEN PARK BRAKE HAS BEEN ENGAGED EXCESS ANGLE LED COACH MAY NOT BE ABLE TO BE LEVELED IN CURRENT LOCATION AND MUST BE MOVED TOAMORE LEVEL LOCATION LCI ELECTRONIC LEVELING 2 OOS e Lo CAUTION 5 EST E SET ERE oj en JACKS DOWN towvourace ENGAGE PAR
127. he unit on off Press and hold to turn the touch screen backlighting off when driving at night Audio playback is not interrupted Touch any area of the screen to resume the previous display lighting and mode 1 Volume Control To increase the volume rotate the VOL control clockwise To decrease the volume rotate the VOL control counter clockwise 2 Reset Use a ball point pen or thin metal object to press the RESET button The reset button should be activated for the following reasons Initial installation of the unit when all wiring is completed Function buttons do not operate Error symbol on the display 3 Menu e Press the MENU button to access the System Menu 4 Audio Press the AUDIO button to access Audio Mode and select a source for playback Press and hold the AUDIO button to enter the Audio Menu menu 5 Camera CAM Press the CAM button to access camera mode Press and hold to view the System Menu Camera setup options 6 Mute Press the MUTE button on the control panel to mute the audio output MUTE will appear on the display Press MUTE again to restore the audio output to the previous level 7 Touch Screen Display 8 Disc Slot 9 Eject Press to stop disc play and eject the disc 10 Day Night button Press to toggle between dimming levels for day or nightime viewing 11 Remote Sensor Thor Motor Coach does not provide remote controls for this radio 12 Auxiliary Input Use to c
128. horted to ground Usually a wiring problem When an error code is present the board needs to be reset Energizing the extend retract switch resets the board Energize the extend retract switch again for normal operation 65 Controls and Operations 66 Electronic Manual Override Manually retract room Norco slide system 37KT only 1 Locate the circuit board 2 Press the mode button six times quickly then press a seventh time and hold for approximately five seconds 3 The red and green LED lights will begin to flash confirming the override mode 4 Release mode button 5 Back inside coach use the normal slide control switch to retract the room Locate the control board Unplug both motors from control board The room may now be pushed in or out as desired Larger rooms may require several people to push Try to keep both sides of the room even When room is completely in plug both motors back into the control board This applies the brake for the motors and will keep the room locked in posistion while the unit is traveling down the road Ww N gt DO NOT MOVE THE Motorhome UNLESS THE MOTORS ARE PLUGGED IN If you are unable to move the room after following the above procedure then both motors will need to be disengaged A DANGER Keep people and obstructions clear of room when operating CAUTION Operating the room with any room locking devices in place can cau
129. hose No Fuss Flush 2 Open dump valve let tank empty 3 Attach garden hose to water inlet labeled Sewer Valve Must be Open When Using This Inlet With faucet at full pressure flush for about 2 minutes or until water runs clear from discharge hose 4 Disconnect garden hose from faucet and lay on ground to allow water to drain from the system before detaching from water inlet DO NOT ALTER THIS SYSTEM IN ANY WAY SUCH AS BY CAUTION ADDING CHECK VALVES ETC DON T USE the same hose to fill your potable fresh water tank that is used for the No Fuss Flush 113 CAUTION Dump valve must be open any time there is a hose water supply connected to this system DO NOT LEAVE ANY HOSE WATERSUPPLY connected to this system when not in use 114 LP System PROPANE GAS IS HIGHLY VOLATILE AND EXTREMELY EXPLOSIVE DO NOT USE MATCHES OR A FLAME TO DANGER TEST FOR LEAKS USE ONLY APPROVED PROPANE GAS LEAK TESTING SOLUTIONS FOR LEAK DETECTION Unapproved solutions can damage copper tubing and brass fittings Never attempt to adjust propane gas regulators Only qualified personnel should perform any maintenance or repair to the propane gas system The propane gas system furnishes the fuel for cooking heating and hot water Propane gas can also be used as an alternate energy source for refrigeration Propane is a clean efficient safe form of energy when proper handling and safety precautions are observed T
130. icularly those which can be down wind even part of the time DO NOT operate the generator when parked in close proximity to vegetation snow buildings vehicles or any other object which could deflect the exhaust under or into the motorhome DO NOT touch the generator when running or immediately after shutting off Heat from the generator can cause burns Allow the generator to cool before attempting maintenance or service The generator draws fuel from the motorhome chassis fuel tank The fuel supply line for the generator is placed higher in the fuel tank than that of the fuel supply line for the chassis engine this prevents the generator from draining all the fuel from the fuel tank E gt Note Some models may require you to plug the 30 amp shoreline into the generator outlet provided in the shoreline storage compartment To start the generator locate the generator start switch which is located at one of the following locations Generator Control Panel Kitchen Base Cabinet Remote Dash Switch 101 Electrical Systems INVERTER Some Thor Motor Coach units are equipped with an inverter An inverter takes 12V DC power from the House batteries and changes it into 120V AC power that can be used by 120V appliances when an outside source of 120V power is not available Every inverter has a wattage rating that will indicate the maximum load the inverter can handle For example an 1800 watt inverter will be able t
131. ide the window to open When closing slide the window fully closed and pivot the latch back to the fully locked position The screens will also slide open and closed if required for an emergency exit Note Check window sealant during normal washing and per the Care And Maintenance section of this manual 69 Controls and Operations DOORS amp DRAWERS 70 STORAGE ABOVE COCKPIT LIVING ROOM TELEVISION UNDER BED STORAGE Some models are equipped with storage areas above the dash for the VCR DVD Global Positioning System Video Center CD Changer and Digital Broadcast System The TV antenna hookup with power booster switch is located here The light is illuminated when the booster is on The 120 Volt outlet for the TV is also located here The video center will allow you to switch the signal from the antenna VCR to the front or rear television sets Where equipped the front television will only operate when the vehicle ignition switch is turned off Once the engine ignition switch is on the television will automatically shut off This is a safety requirement A WARNING MAKE SURE BEFORE OPERATING THE Motorhome THAT ALL CABINET DOORS AND DRAWERS ARE CLOSED AND CABINET CONTENTS ARE SECURE RETRACT AND SECURE SLIDING DOORS IN THE BATH AREA AS WELL AS THE BATH DOOR TO PREVENT NOISE AND OR DAMAGE WHILE TRAVELING Cabinet and closet doors in the motorhome have door fasteners or pneumatic stops which prevent them
132. in this motorhome are designed for occupancy only while the motorhome is parked All occupants in this motorhome must be seated at a designated seating position and must wear seat belts at all times while this motorhome is in motion Failure to do so may result in serious injury Safety belts and seats can become hot in a vehicle that has been closed up in sunny weather they could burn a small child Check seat covers and buckles before you place a child anywhere near them SOFA TO SLEEPER Unlatch and remove sofa arms if equipped Raise the sofa seat base until the seat base and backrest form a V shape by lifting up from the center of the sofa just below the seat cushions Pull out and push down on the seat base until the seat base is flat Fold the seat belts out of the way SLEEPER TO SOFA Lift the seat base up until the seat and back rest from a V shape Push back and down on the seat base Position the seat belts for use Replace the back rest cushions SOFA TO SLEEPER Air Hide A Bed Sofa Remove back rest cushions ug e Pull seat cushion section up and out Rotate bottom of seat cushion out and fold legs down Fold back rest down to create platform tc Unfold air mattress plug in fill with air SLEEPER TO SOFA Deflate and remove air mattress Fold the back rest up Return the seat to its original position Replace back rest cushions Q2 Note not fold the air mattress up
133. ing will pay big dividends In addition to routine trip preparations such as having newspaper delivery stopped and mail held at the post office there are now more vehicle related preparations than there are with an automobile Fluid levels oil power steering radiator transmission windshield washer etc Belts tension and condition Battery electrolyte level if applicable connections charge e Hoses clamps tight condition leakage Seals gaskets leaks e Tire pressure condition and lug nut torque Headlights running and safety marker lights including brake and turn signal and also any trailer light connections Chassis e Security of any auxiliary equipment such as TV and awning etc e Windshield wiper blades Generator compartment e Fresh and waste water connections drains and supplies such as high pressure hose e Propane compartment tank Brakes including lines pads shoes seals Engine area for pan gasket or other leaks Anything unusual hanging or tangled with road debris such as tree limbs Tank condition gas fresh water waste water Check operation of all systems including Wipers windshield horn brakes steering transmission heater defroster air conditioner and seat adjustment e 1 engine long enough to check cooling system and alternator operation Be sure to turn on headlights and climate controls to see if alternator handles the additional drain on the electrical s
134. ir if chair is improperly positioned A DANGER Keep people and obstructions clear of room when operating Note Make sure that there is adequate clearance to fully extend the room 1 Apply the parking brake 2 Make sure ignition is in OFF position 3 To extend the room press and hold the ROOM CONTROL SWITCH in the OUT position When the room is fully extended release the ROOM CONTROL SWITCH Note Releasing the ROOM CONTROL SWITCH will halt the operation of the room 1 Make sure to clear any obstruction in the slide out area and set the parking brake 2 To retract the room press and hold the ROOM CONTROL SWITCH in the IN position When the room is fully retracted release the ROOM CONTROL SWITCH 3 Install the room locking devices if equipped 4 If the room will not retract refer to the Manual Retract Procedure Cc Note The Schwintek Slide outs are designed to be operated to full extension or full retraction during any one use Partial extension or retraction of the room may result in the slideout motors losing synchronous operation causing the slide to bind and stop prior to full extension or retraction during subsequent usage When extending or retracting the slide out room the switch should be held for 3 5 seconds after the slide out box stops extending or retracting You will be able to hear the motors amp out The switch needs to be held for 3 5 seconds even after the motors amp out Contr
135. ircuit load is too heavy or a short circuit occurs If a circuit breaker has been tripped do not reset the breaker until the cause of the problem is identified and corrected The generator also has one or two AC circuit breakers and a DC fuse on the generator control panel If an interruption in generator operations occurs check to see if any of these have been tripped Consult the manuals provided with the generator before attempting maintenance on the generator Electrical Systems E gt Note Some electrical appliances may have their own circuit breakers If there is an interruption in electrical service of an appliance consult the manual for that appliance to determine what action to take Note Please use this information as a guide Check your motor home for the sticker with the exact call outs The chassis battery is accessed through the passenger side dash on the Axis and ACCESSING THE Vegas units CHASSIS BATTERY 1 Remove the passenger side work station ON THE AXIS AND VEGAS UNITS 2 Remove the seal and wood access 3 The battery will be below and forward of the opening 4 Reinstall the wood access panel 5 Reseal the panel Failure to properly reseal the panel will allow air intrusion into the cab of the motorhome 6 Reinstall the passenger side work station 99 Electrical Systems 100 CHASSIS ALTERNATOR GENERATOR Note Should you lose 12 Volt power inside your Class A gas motor home there
136. is filled beyond capacity The handle should remain in the local supply position until you are ready to fill the fresh water tank To fill a fresh water tank 1 Attach a potable water hose to the inlet inside the water Systems panel area and an outside water supply 2 Turn the lever on the valve to the fresh water tank position and begin filling 3 When the tank is full turn off the water supply View reading on the monitor panel 4 Return the handle to the local supply position Note Never leave the hose unattended while you are filling the fresh water tank C22 Note There is an overflow vent located at the top of the fresh water tank If the tank is filled beyond capacity water will flow out through this vent onto the ground When using water from the fresh water tank the system must be pressurized A self priming 12V DC pump is provided to handle this function A pump ON OFF switch is located on the monitor panel When initially starting up the self contained water system follow this procedure 1 Make sure the tank is filled with water 2 Open all the faucets in the motorhome both hot and cold Water Systems 3 Place the pump control switch in the ON position 4 Allow time for the hot water tank to fill Shut off each faucet as the flow becomes steady and free of air When the last faucet is shut off the pump should also shut off 5 The system is now ready for use E gt Note When filling the sys
137. isms Concentrations higher than 50 PPM may damage water lines and or tank 3 Close all faucets and drains and fill the fresh water tank with the rinse solution through the potable water fill 4 Turn on pump switch and circulate the rinse solution throughout the entire system 5 Once the rinse solution has been circulated through the entire system fill the fresh water tank until it is full 6 Close all faucets and drains and let the system sit for approximately three 3 hours 7 Drain the entire system 8 Flush the complete system with fresh water until chlorine odor disappears 9 Finally close all drains and fill the fresh water tank as you normally would Make sure the water heater has water in it prior to igniting Chlorine is poisonous Recap bottle and clean any appliances used with soap and water The monitor panel allows you to quickly check the levels in the fresh water and waste water tanks Electrical sensors at various points on the tanks send signals to the monitor panel To check fluid levels press and hold the test switch designated for the tanks and read the level indicators on the panel The indicator is proportioned in thirds with each light being lit up to the level that the tank contains Sometimes residue on the sides of a tank or water with a low mineral content will give a false reading Check the levels occasionally when you are sure of a tank s contents to double check the accuracy of the mon
138. itor panel The monitor panel allows you to quickly check the levels in the fresh water and waste water tanks Electrical sensors at various points on the tanks send signals to the Water Systems monitor panel To check fluid levels press and hold the test switch designated for the tanks and read the level indicators on the panel The indicator is proportioned in thirds with each indicator light illuminating to the level that the tank contains Indicator lights and their meanings The accuracy of two wire holding tank monitoring systems can be adversely affected by dirty tanks or unusual mineral content in the water These conditions can cause the monitoring system to have oversensitive reads higher than actual level or under sensitive reads lower than actual level readings Oversensitive readings can occur as a result of scum build up on the tank walls or abnormally high mineral content in the water In these situations the monitoring system indicates higher levels than are actually present in the holding tank Certain cleaning products and food by products can build up on the inside walls of the holding tanks producing a layer of scum that can cause the monitoring system to read higher than the actual level To correct this problem the holding tanks should be cleaned periodically consult dealer for cleaning instructions Under sensitive readings can occur if the mineral content of the water is abnormally low In this case the m
139. k your tire s air pressure daily when you are driving your motorhome Pressure sealing valve caps should always be used to prevent air from escaping from the valve stem If you use valve stem extension hoses make sure they are good quality stainless steel braid reinforced and are securely anchored to the outer wheel If your motorhome has wheel covers which must be removed to check the inflation then consider removing them as the extra time and effort required may lead you to avoid checking your pressure When replacing your tires always make sure the proper AWARNING size and rating is used Check the federal certificate located in the drivers area for your model s specific size and rating In a sudden stop or collision loose equipment could strike someone Storing a jack a tire or other equipment in the passenger compartment of the vehicle could cause injury Store and secure all of these items in a proper place gt Note Thor Motor Coach does not provide jacks with our motorhomes Any changing of tires should be performed by a professional mechanic with proper equipment 43 Controls and Operations Driving a motorhome is similar to driving a car You have an ignition switch gearshift controls turn signals and dash components As you sit in the driver s seat the center of the cluster includes tachometer speedometer fuel gauge oil gauge temperature gauge and amp meter Switches may have symbols to describe their
140. ked while driving The screen door can be attached to the outer door A sliding panel on the screen door permits access to the handle on the outer door to prevent unnecessary handling of both doors Separate keys are provided for both types of door locks It is a good idea to keep a record of the key numbers in a safe place should it become necessary to have duplicate keys made Adjacent to each entry door is an entry assist handle for convenience and safety in entering and exiting your unit The electric step is automatic When the ignition switch is activated the step will automatically retract When the door is opened the step will extend automatically even if the engine is running If the switch for the step is in the OFF position the step will fail to operate automatically If the step malfunctions check the battery voltage fuses Switch alignment and verify that the step switch is in the ON position DUE TO THE HEIGHT OF THE Motorhome YOU MAY ACCIDENTALLY SLIP OR FALL IF ATTEMPTING TO EXIT WITHOUT USE OF THE STEP If the step will not operate use extra care when exiting Never activate the step when someone is using it and be sure to keep hands feet children and pets away from the mechanism when activated If the motorhome is driven with the step in the extended position there is the possibility of causing major damage to both the step and the motorhome CAUTION MAKE SURE BEFORE EXITING THE Motorhome THAT THE STEP IS
141. l the awning out Once extended slide the pull strap to the right and wrap the strap around the awning arm Cc Note Prior to closing remove tie downs and screen if used Ensure that the travel strap and buckle are clear of the back channel e Unwrep the pull strap from the awning arm and slide it slightly to the left Retract the Awning With one hand firmly grip the awning pull strap and gently pull down while at the same time using the awning rod to rotate the Safe T Lock to the UNLOCK CLOSE position e While holding the pull strap firmly hook the awning rod into the pull strap loop and slowly allow the awning to retract controlling the speed with the awning rod in hand the awning has fully retracted reconnect the travel clamps Press and hold the remote switch located near the entrance door in the extend Automatic Patio position until the awning is fully open or utilize the remote control if equipped Awning Extend the Awning Cc Note Do not press more than one EXTEND button at the same time Awning will not work and or may cause control box fuse to blow er Note Not all awnings have a control box e Press and hold the remote switch in the retract position When awning is fully Retract the Awning closed release the switch o Note Do not press more than one RETRACT button at the same time Awning will not work and or may cause control box fuse to blow Please consult your awning o
142. le fuel burning equipment including wood or AWARNING charcoal burning grills and stoves should not be used inside the motorhome because they may cause fire or asphyxiation Underwriter Laboratories classify fires into three types Class A Fires in wood paper fabric rubber and certain plastics Class B Flammable liquids such as grease cooking oils gasoline or kerosene Class C Electrical fires started from live electrical wires from short circuits motors or switches The fire extinguisher which is located by the entry door of the motorhome is a chemical type suitable for extinguishing small fires of the class B or C type Extinguishers are designed to put out fires in the initial stage not when it is blazing out of control If a fire cannot be approached within 10 the extinguisher will not be effective To fight a fire with an extinguisher first remove the tamper tape which covers the discharge push button Hold it upright and stand six to ten feet from the fire with a clear path to an exit Press the button down all the way aimed at the base of the fire and spray with quick motions from side to side Avoid inhaling the dry chemicals Although non toxic they could cause temporary irritation and vomiting When the fire is out clean up the area as soon as possible The dry chemicals are non corrosive but some residue may cause surface damage if left too long To keep the fire extinguisher in proper operating conditions
143. lean back to position seat and then release the lever to lock the back rest in place To return the backrest to upright position lift up on the control lever It will automatically return to its normal upright position To prevent damage be sure to return the seat back to it s upright position before operating the slide out rooms Seat Swivel A control lever on the side of seat controls the swivel function Push the lever forward to release the detent on the swing mechanism Once the lock is released the seat may be rotated either left or right Forward And Back Adjustment The forward and back sliding action is controlled by a lever on the lower left side of the seat To adjust pull the lever outward to release the latch and slide the seat to the desired position Make sure the seat locks into the position you have selected Arm Rests Arm rests can be rotated up and out of the way when not required Controls and Operations E gt Note It may be necessary to adjust the sliding position of the seat and the tilt of the back to enable the seat to be rotated without obstruction from sidewalls or items to the rear Some models do not allow complete seat rotation Some Thor Motor Coach bedroom doors slide conveniently out of the way beside the wall Thor Motor Coach provides a vinyl travel strap or a slide latch to secure the door while the motorhome is in motion The door latch is a bayonet type which is engaged by turning the handle S
144. leted the above inspection on this recreation vehicle and have taken the test drive at the time of purchase noted the following issues Before purchased this vehicle received read and agreed to the terms and conditions of Thor Motor Coach s 1 page Limited Warranty published within its Owner s Manual and the Chassis Limited Warranty understand and agree that any legal action for breach of express or for breach of implied warranties that may arise by operation of law must be filed within ninety 90 days of the expiration of the applicable warranty coverage period as defined within the limited warranty agree that the vehicle is to be used only for travel on improved roads also agree that the selling dealer is not an agent for Thor Motor Coach but is an independent company with no authority to make any representation or promise for Thor Motor Coach understand and acknowledge that the chassis and component parts and appliances that are exclusively covered by the warranty issued by the manufacturer of the chassis and warranty issued by the manufacturer of the component part and appliance Thor Motor Coach s limited warranty excludes the chassis and component parts and appliances that are warranted by their manufacturer understand that this form is for product registration purposes and failure to return this form does not diminish my warranty rights during the warranty period By signing the line below acknowledge and agree
145. liary batteries are Controller kept separated from each other within the electrical system through the use of a battery isolating controller The controller prevents the auxiliary batteries from discharging the chassis battery when the motorhome is parked Some additional characteristics of the isolator system include 1 Delays connecting the auxiliary batteries to the charging system for approximately 15 seconds to allow the alternator time to reach full charging ability 2 After this initial time delay if the alternator has come up to full charging ability 13 2 Volts the isolator will electrically connect the auxiliary and chassis batteries together for charging 3 If the charging voltage drops below 13 2 Volts for a period of 4 seconds due to low idle speed and or excessive load the isolator will disconnect the auxiliary batteries until the voltage returns to a level of 13 2 volts for about 10 seconds 4 In the event the automotive battery is discharged it will be necessary to press and hold the Start Switch located in the dash E gt Note When operating 12 Volt equipment from battery reduce equipment in use to conserve battery Gradual dimming of lights and slowing of motors indicates low battery voltage 96 Electrical Systems The converter inverter also operates as a battery charger when it is connected to a 120V power source If the battery is below its full charge the converter inverter charger will begin oper
146. limitations on how long an implied warranty lasts so the above limitation may not apply to you WHAT THE WARRANTY COVERS Warrantor s Limited Warranty covers only defects in the workmanship performed and or materials used to assemble those portions of your motorhome covered by the limited warranty See also the section What the Warranty Does Not Cover set out below Defect means the failure of the workmanship performed and or materials used to conform to Warrantor s design and manufacturing Specification and tolerances WHAT WE WILL DO TO CORRECT PROBLEMS Warrantor s sole and exclusive obligation is to repair and or replace at its option any covered defect if 1 you notify Warrantor and one of its authorized servicing dealers of the defect which is discovered within the warranty coverage period within ten 10 days of discovering the defect and 2 you deliver your Motorhome to Warrantor or Warrantor s authorized servicing dealer at your cost and expense It is reasonable to expect some service items to occur during the warranty period Unless prohibited by state law the performance of warranty repairs shall not extend the original warranty coverage period Further any performance of repairs after the warranty coverage period has expired or any performance of repairs to component parts and appliances that are excluded from coverage shall be considered good will repairs which shall not alter the express terms of this limited warranty If th
147. listing the maximum load capacity Failure to comply with the load capacity could cause bed failure which may result in injury Bed s must be stowed in the up position with the stop pins in place during travel Elevated beds may present a fall hazard which may result in injury Please follow the guidelines below regarding the elevated beds and the use of bed rails The elevated bed should not be used as a storage area using the elevated bed as a storage area may cause the bed to lower while the unit is in transit Various Thor Motor Coach products are equipped with standard built in elevated beds or bed loft areas These beds can be upwards of 4 to 5 feet above the floor level and are often enclosed on one two or three sides and sometimes even partially on a fourth side Because there are so many potential users and different types of elevated bed designs elevated beds are not equipped with bed rails We feel that you as the customer are best equipped to determine if a bed rail system is necessary or best for you based on your intended uses the actual users of the elevated beds and the comfort level of the users For those customers who would prefer using an elevated bed with a bed rail there are numerous bed rail styles heights and designs available even in the style of bumpers which can be purchased at various retail locations and or the internet When installing a bed rail please make sure that you follow the manufac
148. ly the motorhome alternator will be able to handle normal vehicle driving requirements and also recharge the batteries in a reasonable time when on the road e Every 30 days check battery mounting Tighten battery cables and clean terminals if necessary e Check and recharge as necessary Keep connections clean and covered with a light coat of grease e Check the water level weekly and add distilled water if necessary ce Note Vehicles left in storage for extended periods of time require further provisions to maintain a proper state of charge of the vehicle batteries Parasitic loads drains from the radio clock powertrain control module courtesy lights or other accessories will discharge a battery if the vehicle is not used for an extended period of time A discharged battery can actually freeze in temperatures of 32 degrees F 32 F resulting in permanent damage to the battery Batteries may also be permanently damaged if allowed to stand for long periods of time in a state of discharge em DE ut JAN E oe bo LZ TET X gt Ld 119 Care and Maintenance WATER SYSTEM WASTE WATER SYSTEM FRESH WATER SYSTEM ELECTRICAL SYSTEM GENERATOR POWER SYSTEM 120 To alleviate battery discharge during periods of storage of two weeks or less disconnect the battery by pressing the battery disconnect switch located by the entry steps to the store mode For extended periods of ti
149. m which Connecting to an it is delivered When you connect your motorhome to an outside source the fresh outside source water tank and the water pump are kept separate from the remainder of the system by in line check valves To connect the motorhome to an outside source of water 1 Remove the cap from the fresh water inlet on the side of the motorhome and attach one end of the fresh water hose to the outside source of water 2 Connect the other end of the hose to the motorhome city water inlet 3 Turn the outside source of water ON and open the various faucets in the motorhome gradually to clear the air from the lines Close the faucets when the water flows freely E gt Note not turn the water pump on when using water from an external supply To disconnect from the outside source of supply 1 Shut off the outside source of water and disconnect the hose from the valve and vehicle inlet 2 Re reel the hose and reinstall the cap on the motorhome inlet Some water sources develop high water pressure CAUTION particularly in mountainous regions These campgrounds or hookup locations may not have regulated water pressure which could be considered excessive High pressure is anything over 55 psi Excessive pressure may cause leaks or damage to your water system Water pressure regulators are available to protect the water system against high pressures Check with your dealer for recommendations of water pressur
150. mats etc Be extremely careful when fueling the motorhome Always shut off the engine do not smoke or use cellular phones and shut off all pilot lights before adding fuel Fuel spills represent a serious fire hazard and should be cleaned up immediately Never restart the engine or relight pilot lights while raw fuel is present When weather gets cold or the motorhome has not been used for a while a fuel anti gel additive will be needed For your convenience there may be two fuel fills on the motorhome If so equipped they are located on both sides of the motorhome towards the front of the unit This allows access into filling stations from either side of the motorhome CS Note If you should lose your fuel cap it should be replaced as soon as possible with a cap of the same type er Note Always remove the fuel cap slowly and pay close attention to the fuel recommendations outlined in the chassis literature If your motorhome is involved in a collision it is possible that an inertia switch in the fuel pump circuit will open shutting down the flow of fuel to the engine This is a safety feature designed to help keep raw fuel from spilling out and creating additional danger When this inertia switch has been tripped it is necessary to manually reset it before the motorhome can be restarted and moved Review your chassis owner s manual for the location of the switch and instructions for resetting Like any vacation trip pre plann
151. me the battery should be disconnected by removing the negative cable from the battery A disconnected battery may also self discharge especially in high ambient temperatures therefore every disconnected battery should be checked periodically and recharged if necessary Check all hoses fittings and connections regularly for leaks and signs of wear Make sure to keep the system sanitized and take care to winterize during cold weather see instructions elsewhere in this manual Do not allow water to remain in system for extended periods or after a trip The drainage system including the tanks and associated drain piping should be periodically inspected for loose fittings from vibrations Any deterioration of the sealant around joints and fittings should be repaired immediately Check the operation of the termination valves If they pull or close with effort lubricate the shaft and slide valve with spray silicone Termination valves that leak should be repaired or replaced as soon as possible Sometimes a buildup of paper or other material in the inside groove of the termination valve can obstruct the valve and cause it to seat improperly If you suspect that this is occurring the valve can be removed from the drainage line by removing the four screws that hold it in place and sliding it out The valve groove may then be cleaned out with a screwdriver or similar tool Replace the valve in the line and reinstall the screws to secure it in pl
152. n sensor no other action is necessary on your part in the event that the rain sensor has moisture on it Use the dome hand crank knob only in an emergency for dome adjustment Pull the knob to the desired dome placement Push the knob back upward Ensure that the knob is locked in place E gt Note vent cover or foam filter is not recommended on Fantastic Vent 91 Electrical Systems The electrical system in your motorhome is designed and built in accordance with the latest codes standards and regulations effective at the time of construction It consists of two types of systems alternating current AC 120 Volt service and direct current DC 12 Volt service Because of the many model variations and options it is not possible to provide wiring diagrams in this manual We recommend that any electrical work be done by a Thor Motor Coach dealer or a qualified RV electrician Note The electrical system is engineered and tested for safety Circuit breakers and fuses protect the electrical circuits from overloading If you plan to make modifications or additions to the electrical system Thor Motor Coach strongly recommends consulting a certified electrician for assistance to ensure continued integrity and safety of the electrical systems Please note that any modifications may void the Limited Warranty The electrical power supply provided for the motorhome is a dual system operating with 120 240 volt AC and or 12 Volt DC
153. n the scale To determine individual wheel position weights it is necessary to repeat the previous three steps 1a 1b and 1c but this time use only one side of the scale To calculate the opposite side of the vehicle wheel position weight subtract this side s weights from the weights recorded in steps 1a 1b and 1c Your motorhome must remain as level as possible on the scale even though an axle or side is not physically on the scale To obtain the side to side weights there must be enough space on either side of the scale to allow the motorhome to be partially off the scale Individual wheel position weights must not exceed the maximum tire load capacity CAUTION Maximum tire load capacity can only be achieved by utilizing the maximum allowable pressure psi as listed on the sidewall of the tire 22 Note The above information is provided by the Tire Industry Safety Council Rubber Manufacturer s Association Used with permission http www rma org tire_safety For improved accuracy Thor Motor Coach recommends using a segmented 4 pad scale when possible to determine individual wheel weights The corner weights should not exceed half of the respective Gross Axle Weight Rating GAWR or the maximum load rating for the tire or set of dual tires at the rear whichever is less The maximum load rating for the tire can be found embossed on the tire s sidewall If any of the corner weights exceed half of the listed GAWR o
154. n the tank or if the tank has been over filled Always use moisture free propane gas and make sure the tank has not been filled beyond 80 of capacity If moisture has entered the tank have the tank purged or have hydrous methanol added by an authorized propane gas supplier The term regulator freeze up is a misleading one Regulators and propane gas do not freeze However the moisture that can be contained in the gas will freeze as the gas expands and cools passing through the regulator This freezing of the moisture in the gas can build up and partially or totally block the passage of the gas through the regulator Freezing can also occur when outside temperatures are low enough to contribute to the freezing of the moisture in the gas The source of the moisture is varied It can occur at the refinery or gas bulk plant in the rail cars used to transport the gas or even within the motorhome propane gas tank Moisture in a propane gas tank can occur when a tank service valve is left open allowing moist air to enter and become trapped Atwo staged regulator helps to reduce the possibility of freeze up because of its larger orifice size and the fact that heat is transferred through the walls of two regulators instead of just one Take these steps to inhibit or prevent this from happening 1 Make sure that the propane gas tank is free of moisture before refilling 2 DO NOT overfill the propane gas tank 3 Make sure to keep the service v
155. nd the Awning 78 Some lower compartment doors may have a pocket latch To open simply insert your fingers under the flap and pull up The door will continue to open on the gas assisted struts until fully open Push the door to close the compartment and the latch will close automatically The doors under the slide out and doors that are mounted below gas fired appliances with exhaust may have a prop rod so the exhaust does not damage the door Many models have pass through compartments for storing longer items Always keep the doors locked when traveling to prevent accidental opening or theft A WARNING DO NOT CLIMB ON OR WALK ON THE ROOF WHILE WET THE ROOF COULD BE VERY SLIPPERY CAUSING YOU TO FALL WHICH CAN RESULT IN SERIOUS INJURY OR DEATH Do not use the roof as an observation platform or storage area as it is not designed for these purposes Thor Motor Coach motor coaches have plywood reinforced roofs which are strong enough to walk on Use the ladder to climb up on the roof for inspecting the roofing seal and components Take the ladder into consideration when backing up or parking your motorhome Where equipped the exterior rear ladder provides access to the roof for maintenance of the roof and roof mounted items only When ascending and descending the ladder ensure the ladder is clear of debris such as water ice and other slippery substances Always wear shoes that provide good traction and do not wear sandals or other types
156. nd the step will remain in the extended position In this case the override switch must be turned OFF for the step to retract When closing the storage doors make sure that hands and fingers are clear of pinch points Make sure all compartment doors are completely closed and latched and that contents are secure prior to moving the motorhome The motorhome is equipped with numerous outside storage compartments Each door can be locked for security except for the Propane Gas compartment Note Ensure proper clearance is available for the door to open If your unit utitilizes a side vented drainage system and AWARNING you connect to a campground sewage hookup be sure to keep the drain valve closed Failure to do so may result in sewer gases being vented outside the RV and into the atmosphere When closing the storage doors make sure that hands AWARNING and fingers are clear of pinch points Make sure all compartment doors are completely closed and latched and that contents are secure prior to moving the motorhome When storing items within the compartment bays do not overload them with heavy densely packed items remember that any weight added to the motorhome affects the overall weight of the vehicle Ensure that side to side weight is comparable to distribute the load evenly COMPARTMENT DOORS amp STORAGE COMPARTMENTS TT Controls and Operations REAR LADDER AWNINGS Slide Out Awning Manual Patio Awning Exte
157. ndle most any problem that may occur Customer service is of the utmost importance to your dealer and is just as important to the manufacturer This manual contains a section outlining the warranty and explaining your rights and obligations as well as the rights and obligations of the dealer and manufacturer under the terms of the warranty Please read this section carefully You will be better informed in case you have a warranty related problem and your dealer will be better able to get you back on the road again in a timely manner We sincerely believe that your dealer and the factory representative will be able to solve any problem which may arise If their combined efforts are not satisfactory please send a letter describing the circumstances to Thor Motor Coach PO Box 1486 Elkhart IN 46515 1486 Thor Motor Coach Customer Service is the support arm for Thor Motor Coach and was developed to streamline technical assistance warranty claims authorization requests and parts for our dealer network and owners This will greatly improve our business relationship with you and our dealer network and in the event of a problem will get you back on the road again in a timely manner You must include the dealer s name as well as the model and serial number of your motorhome The Thor Motor Coach serial number is located on the bottom of the federal sticker which is located in the driver s compartment area Thank you for choosing our product Your
158. ned professional before using again oN cm When performing any work or maintenance in the motorhome ensure that you do not puncture a gas line with a nail screw or drill bit Warning labels and decals are used throughout the motorhome in locations where the potential for a dangerous situation is present They have been installed not only because of the requirement to do so but also as a constant reminder to occupants of the motorhome to exercise proper caution when using or being around propane gas appliances and equipment Make sure that you and your family understand and follow all of them Never remove these warning labels and decals If one should be lost it should be replaced as soon as possible Care and Maintenance GENERAL INFORMATION Periodic maintenance and cleaning of your recreational vehicle is necessary to retain the dependability safety and appearance that will provide you with many miles of trouble free operation as well as protecting your investment Make sure you read and follow all the maintenance tips and schedules that appear not only in this manual which for your convenience we have provided for you but also in the manuals provided by the chassis manufacturer and various component manufacturers Keep good records of maintenance functions performed and make sure you perform all owner obligations as may be required to keep your warranty in force It is also important to note that operating conditions will
159. nsibility of the retail owner Check that the top and bottom bracket screws are tight at the start of each camping AWNING season 1 Lubricate the rafter arms and support arms using paraffin wax or silicone spray Also lubricate the threads on the knobs 2 Periodically clean the awning fabric as follows For a vinyl material use a mixture of 1 4 cup of dish soap and 1 4 cup of bleach mixed with 5 gallons of warm water Liberally apply this mixture on the top of the fabric then roll the awning up for 5 minutes This will apply the mixture to the bottom as well Roll the awning back out and hose off with fresh water Repeat if necessary Allow to dry before rolling back up Avoid the use of caustic household cleaners mildew removers or hard bristle brushes Do not scrub 121 Care and Maintenance CHASSIS EXTERIOR LIGHTS 122 For an acrylic material periodically hose off the fabric with water then let dry completely before rolling it back up The acrylic material is water repellent not water proof The fabric is pretreated with a water retardant finish Mildew cannot form on the fabric but rather will form on dirt or dust on the fabric The key is to keep the fabric clean Do not scrub Whenever the awning is wet while rolled up as soon as conditions allow roll it out hose it off and let it dry completely before rolling it back up again If you get water streaking or seeping behind the awning rail inspect the rail for lo
160. nstrated and or explained to you 4 the dealer has answered any questions you may have and 5 you find the vehicle in good condition acceptable to purchaser The dealer is not authorized to deliver this vehicle until this has been done and both you and the dealer have signed this form PRODUCT LINE SERIAL NUMBER M VIN NUMBER PURCHASER S LAST NAME PURCHASERS FIRST NAME CO PURCHASER S LAST NAME CO PURCHASER S FIRST NAME STREET ADDRESS CITY STATE ZIP COUNTRY PHONE PURCHASER S EMAIL RETAIL DELIVERY DATE Owner Dealer Inspection 1 Exterior and interior finish 5 Operate plumbing facilities including water faucet s shower and toilet 2 Operate all appliances electrical and gas 6 Observe or check to assure that all wheel lugs are tight and tire pressure is correct a Furnace and thermostat T Review operation of manual or automatic Propane Gas regulator lighting and maintenance 8 Operate all air conditioners radio entertainment system and televisions b Range and oven lighting and maintenance if so equipped c Water heater lighting and maintenance 9 Complete review of owner s manual by dealer with owner d Refrigerator operation and maintenance 10 Test drive 3 Operate 120 Volt generator if so equipped 11 Odometer reading as observed by customer is _____ 4 Operate all doors and windows including locks 12 Obtain answers to any questions you may have MILES KILOMETERS have comp
161. o handle aprox 1800 watts of demand Keep in mind that the size of the house battery bank along with the load will determine how long the inverter can supply power to your 120V appliances without having to recharge the batteries Xantrex 1 Detachable remote panel to display inverter status and battery status information GFCI receptacle AC wiring compartment Knockouts for routing AC input and output wiring Mounting flange BROWN 1 15 A circuit breaker 2 Grounding stud 3 Cooling fans turn on when powering loads above 500 W or when the internal temperature rises above 113 F 45 C 102 No Na Electrical Systems Negative DC cabling terminal Ventilation opening Do not obstruct for the proper operation of the cooling fan and inverter Positive DC cabling terminal Serial number of your unit Panel Operation D Input Voltage V O Input Current A Output Power kW XM1000 On Off button Press once to turn the XM Series Inverter on or off Three digit LED display shows status information and fault codes Status LED Indicates the mode of operation with a three color LED Utility green indicates the XM Series Inverter is in shore power mode using utility power to operate loads connected to the XM Series Inverter Battery yellow indicates the XM Series Inverter is in inverter mode using the battery to provide A
162. o the carpet The rollers under the slide room are not sealed rollers therefore some residue may appear on your carpet This is a normal function so be aware and take proper precautions Vacuum the carpet after each extension of the slide out room Verify that your house batteries are fully charged before operating the room In areas where the hot sun constantly beats down on the motorhome shading the tires by covering can reduce tire sidewall cracks from forming Tire covers can be purchased at any motorhome supply store Check your Chassis Owner s Manual for the tire rotation requirements Due to the weight of the motorhome you should have a qualified service center rotate the tires if recommended by your chassis manufacturer To keep the rims of the motorhome looking their best follow these simple steps 1 Rinse the wheel with high pressure water to remove any debris grit or dirt particles 2 Use a 100 cotton cloth dipped in a mild soap solution to help remove Stuck on dirt and grease 3 Rinse the remaining soap residue from the wheel 4 Dry the wheel thoroughly with a 10096 cotton cloth To lubricate the elevating gear apply a liberal amount of silicone spray lubricant to the elevating gear with the lift in the down position Run the lift up and down a few times to distribute the lubricant over the gears If rotating the antenna becomes difficult lubricating the bearing surface between the rotating gear housing and the
163. ocks Y Type Water Hose Fitting CAMPFIRE COMFORT Bug Repellent Bug Zapper Charcoal Enclosed Screen Tent Firewood Grill Matches Picnic Table Cloth w Clips Yard Chairs PET COMFORT Food amp Water Dish Leash Litter Litter Box Pet Food Portable Cages Scoop w bags Screw Stake for tie out Tick Repellent Tie Out Cable Toys OTHER Maintenance Schedule PROCEDURE TO BE PREFORMED Maintenance schedules are minimum requirements Heavy use unusual temperatures or humidity or other extreme conditions may require more frequent maintenance Inspect amp reseal roof amp exterior attachment areas Lubricate roof vent mechanism w light oil Clean as needed PRIOR TO STORAGE ITEM Roof amp Components Fiberglass Exterior Na AS REQUIRED i X Windows amp Doors X Lubricate door locks amp strike pockets exterior components Inspect and reseal if necessary x Check for leaks and damage Check line pressure should be checked by technician Seals amp Adhesives X Propane System Water System EE asm x Per chassis manufacturer manual Safety Equipment Safety Equipment x X X Carpet Front Wheel Alignment Chassis amp Components x x gt lt Check fluid levels including oil brake washer engine cool ant transmission battery water etc Clean amp lubricate with spray lithium grease Check for pr
164. odels have a wire framed pull out pantry To extend this pantry remove the travel lock pin at the bottom track and pull the pantry rack outward To prepare for travel push the pantry rack in and reinsert the travel lock pin Do not store cumbustible material in this area Failure to A DANGER comply could result in fire or personal injury Do not operate this appliance unless the privacy curtain DANGER is secured Failure to comply could result in fire or serious injury The range cover provides extra counter space and covers the burners when not in use When opened it acts as a grease and splash guard To raise the range cover lift and push back until it snaps into place To return the cover to its counter flush position lift straight up to disengage the holding mechanism and return it to the original position The range has a piezo lighter To operate turn the burner valve on then turn the piezo lighter At that point the pilot light will remain on for the oven until it is manually turned off The oven is not self cleaning and will need routine cleansing Please do not store anything in your oven and do not cook while the vehicle is in motion For further instructions please refer to the Range Instruction Manual in your Owner s Information Kit BEDROOM DOOR amp LATCH BLINDS amp SHADE WATER HEATER SWITCH KITCHEN CABINETS KITCHEN DRAWERS KITCHEN PANTRY RANGE 73 Controls and Operations REFRIGERAT
165. ols and Operations 1 Completely retract the slide out irai 2 Allow the motors to amp out and hold the switch for an additional 3 5 seconds Timing 3 Extend the slide out anywhere from 2 4 inches enough to break the seal and slide out system stop 4 Retract slide out again allowing the motors to amp out and holding the switch for 3 5 seconds 5 Repeat this 3 times 6 On the 4th time FULLY extend the slide out and hold the switch until the motors amp out and for an additional 3 5 7 FULLY retract the room and hold the switch until the motors amp out and for an additional 3 5 seconds Controller Error Codes During operation when an error occurs the board will use the leds to indicate where the problem exists For motor specific faults the green LED will flash once for Motor 1 and two times for Motor 2 The red LED will flash from two to nine times depending on the error code The error codes are as follows 2 Battery drop out Battery capacity low enough to drop below 6 volts while running 3 Low battery Voltage below 8 volts at start of cycle 4 5 Excessive motor current High amperage also indicated by 1 side of slide High battery Voltage greater than 18 volts continually stalling Motor short circuit Motor or wiring to motor has shorted out Hall signal not present Encoder is not providing a signal Usually a wiring problem Hall power short to ground Power to encoder has been s
166. ome If using a tar and insect remover make sure it is safe for use on painted surfaces and decals E gt Note The exterior painted finish on the motorhome is of the finest quality Proper maintenance will assure a long lasting durable finish Do not wax or polish the exterior for the first 60 days gt Note DO NOT dry wipe the surface clean only with water and liquid detergent E gt Note DO wax the sidewalls using nonabrasive automotive waxes or cleaner polishes developed for use on fiberglass boats showers and tubs Follow the directions on the package Proper care and maintenance of vinyl graphics or paint is critical in maintaining its appearance The following cleaning and maintenance recommendations should be followed to ensure the maximum appearance and performance of your vehicle s custom designed finish When washing flush the surface with water to loosen large particles of dirt and grime Fill a bucket with warm water not to exceed 120 degrees F 120 F and use a mild detergent or a liquid car wash mixture Follow manufacturer instructions on the container Using a clean soft cloth or sponge and the liquid car wash mixture wipe the entire surface using horizontal motions until it is clean Rinse off the detergent with clean water starting from the top and rinse downward until it is clean Dry your vehicle with a clean soft cloth or let the vehicle air dry Care and Maintenance When waxing ALWAYS use
167. ome models have an accordion type door which latches to the wall when the door is closed Your motorhome may have day night shades which are designed to serve a dual purpose For daytime use pull down the bottom half of the light colored shade which allows light to enter the motorhome while affording some privacy For night use or to shut light out and increase your privacy pull the top darker part of the shade down The water heater start switch is located on the wall in the galley bathroom or monitor panel area The light illuminates when the switch is turned on The light goes off when the burner is on and the water is heating If the light comes back on the burner is not yet lit It may take several tries to light the water heater burner When the element is turned on the red light will glow Be sure the tank is full of water before using Do not store cumbustible material in this area Failure to DANGER comply could result in fire or personal injury A DANGER For your convenience there is plenty of storage above and around the range area for canned goods kitchen utensils etc Please ensure that the doors are closed and latched before traveling to prevent the contents from falling out Drawers are designed to ensure that they do not open inadvertently during travel To open the drawers pull out until catch releases Until you get used to the operation of the drawers you may think that they are stuck Some Thor Motor Coach m
168. on 61 Controls and Operations Hydraulic Pump Function Wiring WHITE PARK BRAKE RED IGNITION BLACK AIRBAG DUMP YELLOW AIRBAG FILL 1 WHITE CHASSIS POWER 2 BLACK WWHITE PUMP SOLENOID 3 RED CURBSIDE REAR VALVE 4 GREEN ROADSIDE FRONT VALVE 5 YELLOW PSI SWITCH 6 BLUE ROADSIDE REAR VALVE 7 BROWN GROUND 8 PURPLE CURBSIDE FRONT VALVE 9 GREY PUMP SOLENOID 10 AUX 11 AUX 12 AUX SS3NMHVH 3NOHd Nid b PLUGS INTO PUMP HARNESS PROVIDED BY LCI DIRECTIONAL VALVE 62 Controls and Operations 63 Controls and Operations SLIDE OUTS Extending the room To Retract Slide Out 64 InWall Slide Out Refer to the manufacturers operation s manual for complete details and troubleshooting guide Keep people and obstructions clear of room when A DANGER operating CAUTION Operating the room with any room locking devices in place can cause personal injury and vehicle damage It is the operator s responsibility to ensure that all room locking devices if equipped are disengaged before operating the room CAUTION The motorhome must be level before extending the slide out room s Failure to do so may result in structural damage to the motorhome or water intrusion Qm Note BEFORE EXTENDING OR RETRACTING SLIDE OUT ROOM Be sure that the driver s seat is in the forward position and the seat back is straight up Slide out room will contact cha
169. onitoring system indicates lower levels than are actually present in the holding tank This problem can be corrected by moving the ground probe closer to the other probes The waste water system is comprised of dual holding tanks with individual termination valves The holding solid waste tank as indicated on your monitor panel collects all the waste material from the toilet The gray water tank collects all of the liquid waste material from the sinks drains and showers Both tanks are joined together after the termination valve to provide a single termination outlet for convenient dumping of waste materials A flexible sewer hose which is not provided is required to make the connection between your unit s termination valve and the approved dump station inlet Note On some models the sinks may be plumbed to drain into the black tank instead of the grey tank C The drainage system is very similar to that of your home The system is trapped and vented to prevent waste gases from entering your motorhome The drain piping is made of ABS material and is resistant to most chemicals The P traps at the sinks showers and tubs are available for use as clean outs if necessary Your vehicle s holding tank compartments are heated by the furnace duct work It will heat the tanks when the furnace is operating As mentioned previously your holding tanks terminate together at one location for convenience in dumping your tanks A twist on c
170. onnect an external audio source 13 USB Port 55 Controls and Operations 56 RAPID CAMP WHERE EQUIPPED The Rapid Camp feature allows you to operate components such as lights leveling systems slides and generator via remote control Note The features available to be operated by remote will vary depending on the options and components available on your coach If you do not see the component you wish to operate on the remote s screen press the Next arrow to see more selections If the componant still does not appear on the list it may not be set up to operate via remote contol To return to the previous Menu page press the back arrow Note The Rapid Camp control has a range of approximately 50ft f Leveler ee E Main Slide y X E Bedroom Slide bu 4 To operate the remote Press the silver home button The main menu screen will appear The components available for remote operation will appear in the list If the comonant you wish to operate does not appear on the screen press the Next button to see more components Once you locate the componant you wish to operate press the oval that contains the componant s name The componant specific screen will come up Slide outs To extend or retract the slide out press and hold the arrow buttons The left pointing arrow button will extend the slide The right pointing arrow button will retract the slide
171. onnel trained in the handling of Propane may fill test or repair the Propane gas system A WARNING IF YOU SMELL GAS EXTINGUISH ANY OPEN FLAMES PILOT LIGHTS AND ALL SMOKING MATERIALS DO NOT TOUCH ELECTRICAL SWITCHES Shut off the gas supply at the tank valve s or gas supply connection Open doors and other ventilation openings Do not use the range hood Leave the area until the odor clears and have the system checked by a trained professional before using again Propane gas regulators must always be installed with the diaphragm vent facing downward Regulators that are not in compartments have been equipped with a protective cover Make sure that the regulator vent faces downward and the cover is kept in place to minimize vent blockage which could result in excessive gas pressure causing fire or explosion Identification and Safety The propane gas detector is powered at all times when the coach battery disconnect PROPANE GAS switch is in the ON position When power is supplied to the detector the green indicator DETECTOR light will illuminate After 60 seconds the detector will begin monitoring the air in the motorhome for combustible vapors The Propane you use to cook refrigerate and heat is combustible Should a leak occur the detector will produce a pulsating alert sound when the gas reaches the detector This alert will continue to sound until the gas has dissipated or until the reset button is pressed When the alert so
172. oper weight distribution per specifications Clean per manufacturer s specifications _ l Appliances X X Inspect for wear amp proper inflation Check all wheel lug nuts and tighten per chassis specifications a HP gt oc LLI gt LLI EVERY MONTH EVERY 3 x gt x MONTHS EVERY6 MONTHS ES ELLE ey eer LLL E HELLE ETE EET x As required by appliance manufacturer 141 Maintenance Schedule Mileage Date Service Preformed Date Service Preformed Maintenance Schedule Date Service Preformed Fuel Oil Record Date Mileage Fuel Oil Gallon Quarts 144 Date Mileage Fuel Oil MPG Gallon Quarts Date Mileage Fuel Oil MPG Gallon Quarts Fuel Oil Record Date Mileage Fuel Oil MPG Gallon Quarts Notes Notes Index 12V System Fuses 12V System Fuses Automotive 12V System Fuses Interior 30 Amp Shore Power 50 Amp Shore Power ABS Plastic Parts Air Hide A Bed Sofa Alignment Appliances Assist Handle Attic Fan Create A Breeze Attic Fan Fantastic Vent Automatic Hydraulic Power Levelers Automatic Leveling and Retraction Procedure Automatic Patio Awning Automotive Dash Auxiliary Battery Awning Barrel Chair Bath Fixtures Bathtub Seal Batteries Battery Charging Battery Isolator Controller Battery Maintenance Battery Replacement Battery Safety Bedroom Door amp Latc
173. or unlocking instructions Your Smoke Alarm requires one standard 9V battery The following batteries are acceptable as replacements Duracell MN1604 Ultra MX1604 Eveready Energizer 522 You may also use a Lithium battery like the Ultralife U9VL J for longer service life between battery changes Carbon monoxide is a colorless tasteless odorless gas It is a by product of combustion in the engine generator and propane appliances The engines in your motorhome and generator system produce it constantly while they are running CARBON MONOXIDE IS DEADLY Please read and understand the following precautions to protect yourself and others from the effects of carbon monoxide poisoning DO NOT ALTER OR MODIFY ANY COMPONENT OF THE EXHAUST SYSTEM AT ANY TIME Inspect the exhaust system at regular intervals for damage If you suspect or locate damage to the system have it repaired immediately by a qualified service facility NEVER SLEEP WHILE THE ENGINE OR GENERATOR IS RUNNING Be aware of carbon monoxide poisoning A WARNING and its symptoms Dizziness Severe Headache Vomiting Weakness Sleepiness Muscular Twitching and Throbbing in Temples If anyone in the motorhome experiences any of these symptoms shut off the engine and immediately go outside into fresh air Get medical attention as soon as possible Choosing a Replacement Battery CARBON MONOXIDE SAFETY PRECAUTIONS 29 Identification and Safety 30 LP S
174. or warning lights See the chassis manufacturer s owner s manual for specific jacking and tire removal and replacement instructions which pertain to your unit Lug nuts vary from chassis to chassis and the GVW Gross Vehicle Weight of your motorhome See Chassis Owner s Manual for specific instructions on tightening lug nuts After operating 50 100 miles retighten to the same specification If you don t have proper equipment stop at the nearest service facility and have the torque of the lug nuts checked A WARNING Never place the jack under a bumper or under the edge of the sidewall Always place the jack as specified by the chassis owner s manual Never use the rear differential as a jacking point Use the jack only for changing tires NEVER get underneath the vehicle when using the jack never start or run the engine while the vehicle is on the jack The most important factor in maximizing the life of your tires is maintaining proper inflation pressure An under inflated tire will build up excessive heat that may go beyond the prescribed limits of endurance of the rubber and the radial cords Over inflation will reduce the tire s footprint on the road reducing the traction braking capacity and handling of your vehicle An over inflated tire will also cause a harsh ride and uneven tire wear To determine the correct air pressure for your tires load your motorhome as you would normally for travel including water and fuel
175. orhome which would not be covered under the Limited Warranty Warranty SUPPLIERS PROVIDING SEPARATE WARRANTIES The following list of components has been compiled to help you know which products on your motorhome may If you have any of these components on your motorhome be sure to check the literature supplied by the manufacturer to see if they require that you register your purchase with them to validate their warranty We recommend that you send the various warranty registration cards immediately before any time constraints on registration expire Manufacturer s literature is contained in a separate packet furnished with the owner s manual on newly delivered units Only those products and options which are on your motorhome will be included in this packet You should go over this literature with your dealer during the pre delivery inspection Any shortages of literature should be reported to the dealer at that time have their own warranties Air Conditioners Dometic 800 544 4881 www dometicusa com RV Products 316 832 4357 www rvcomfort com Awnings Carefree of Colorado 303 469 3324 www carfreeofcolorado com Dometic 800 544 4881 www dometicusa com Back up Monitors ASA Electronics Jensen Voyager 800 688 3135 www asaelectronics com Batteries Interstate Batteries www interstatebatteries com Harris Battery 800 367 7670 www harrisbattery com Lifeline Batteries 626 969 6886 www lifetimebatteries com Bunk Lift Power Gear 574 25
176. ose screws or peeled sealant Always make sure the awning is extended high enough before opening the entry door Lower one end of the awning for proper water run off and to avoid water pooling and possible damage to the awning Refer to your awning users guide for complete instructions onthe care maintenance of your awning CAUTION Failure to lower one side of the awning could result in damage to the awning fabric and or hardware due to the weight of water pooling Refer to your Chassis Operators Manual for information on chassis service recommendations Have the engine coolant and engine oil level checked each time when refueling E gt Note Proper engine servicing and record of servicing may be mandatory to ensure chassis warranty protection Follow the manufacturer s instructions on periodic maintenance checks Make sure to check the operation of all exterior lights often Check headlights clearance turn signal brake and backup lights to make sure they are working correctly Remember to check any towed vehicle or trailer lights also Replace burned out bulbs as soon as possible Condensation occurs when the air inside the lamp assembly through atmospheric changes reaches the dew point When this takes place the moisture in the air within the lamp assembly condenses creating a fine mist or white fog on the inside surface of the lamp lens or chrome reflector surfaces The head lamps are designed to remove accumulat
177. ot allow for the necessary 20 vapor expansion space and may result in an uncontrolled gas flow which can cause a fire or explosion PROPANE GAS TANK gt Note sure the tank service valve is accessible at all times In an Filling the Tank emergency it may be necessary to shut off the valve quickly A DANGER 1 Before entering the propane bulk plant or service station make sure all pilot lights are extinguished Shut off gas to all appliances by first turning off each appliance then close the propane gas main shut off valve 2 Extinguish open flames and smoking materials 3 Never remove the propane gas tank from the motorhome Always drive the motorhome to the gas supplier to fill 4 Have the supplier connect the fill nozzle to the tank fill connection 5 Always remember to close the supply valve and open the 20 liquid level valve 6 Never use a wrench to close the service or the 20 liquid level valve If when closing by hand leaking occurs have the valve repaired or replaced 115 LP System 7 Drive at least one mile from the propane gas supplier before relighting pilot lights or appliances This will allow any minimal leakage which occurred while filling the tank to dissipate DO NOT light pilot lights if you continue to smell propane gas Shut off the Supply Valve Allow the motorhome to ventilate for 30 minutes If you still detect propane odor have the source of the leak located and repaired
178. otorhome A WARNING INDICATES A POTENTIALLY HAZARDOUS SITUATION THAT IF NOT AVOIDED MAY RESULT IN DEATH OR SERIOUS INJURY A CAUTION INDICATES A POTENTIALLY HAZARDOUS SITUATION THAT IF NOT AVOIDED MAY RESULT IN MINOR OR MODERATE INJURY C NOTE A NOTE INDICATES AN INSTRUCTION OR PROCEDURE THAT IS IMPORTANT FOR PROPER SERVICE A NOTICE CAN ALSO SUPPLY INFORMATION THAT WILL HELP TO MAKE YOUR CAMPING EXPERIENCE MORE PLEASANT A DANGER A DANGER INDICATES AN IMMINENTLY HAZARDOUS SITUATION THAT IF NOT AVOIDED WILL RESULT IN DEATH OR SERIOUS INJURY REPORTING SAFETY DEFECTS If you believe that your vehicle has a defect which could cause an accident injury or death you should immediately inform the National Highway Traffic Safety Administration NHTSA in addition to notifying Thor Motor Coach If NHTSA receives similar complaints it may open an investigation and if it finds that a safety defect exists in a group of vehicles it may order a recall and remedy campaign However NHTSA cannot become involved in individual problems between you and your dealer or Thor Motor Coach To contact NHTSA you may either call the Vehicle Safety Hotline toll free at 888 327 4236 TTY 800 424 9153 or write to Administrator NHTSA 1200 New Jersey Avenue S E Washington DC USA 20590 You can go to the NHTSA website www safercar gov You can also obtain other information about motor vehicle safety from the Hotline Introduction ae ee eS
179. otorhome Exterior Checks Exterior Entertainment Center Exterior Graphics Paint Exterior Lights Exterior Interior Extrusions and Aluminum Surfaces Federal Weight Label Fiberglass Fire Extinguisher Fire Safety Food Storage Ford Fuel Pump Collision Shut off Switch Formaldehyde Fresh Water System Fresh Water System External Hook up Fresh Water Tank with Gravity Fill Fresh Water Tank without Gravity Fill Fuel System Fuel Oil Record Fueling the Motorhome Furnace Furnace Door Furnace Operation Instructions Gear Selector Generator Generator Compartment Generator Power System Graphics and Exterior Paint Precautions Ground Fault Circuit Interrupter Hardware Hazard Flasher Control Heated Holding Tanks Heating Heating and Air Conditioning Hide A Bed Sofa High Pressure Laminate Countertop Home Theater System How to Prevent Blockage of Drain Lines How to Use this Manual How to Weigh Your Motorhome Hydraulic Fluid Hydraulic Pump Function Wiring 18 58 41 89 109 34 54 54 63 75 98 61 61 52 37 38 37 68 62 18 73 110 39 68 102 100 13 103 20 101 26 26 113 38 32 85 98 85 85 86 41 122 38 72 66 72 45 82 66 98 103 79 107 47 89 113 71 57 107 68 89 21 106 53 Identification and Safety Index Inspect and Maintain Insurance Introduction InWall Slide Out Kitchen Cabinets Kitchen Drawers Kitchen Faucet Kitchen Fixtures Kitchen Pantry
180. ould be inspected to ensure proper operation and sealing The slide out gaskets should also be inspected to ensure proper sealing when the slide out is operated During those periods when the motorhome is not in use care must be taken to ensure moisture sources are addressed Ideal storage of the motorhome would be in an enclosed climate controlled environment When this is not possible the following steps should be taken to ensure moisture is controlled Turn off all water sources e Turn off all combustion appliances Drain all holding tanks Drain the water heater e Open all closets cabinet doors and drawers e Close all windows and entrance doors e Open a vent enough to allow for some limited ventilation air flow but not so far as to allow snow or rain to enter When storing the motorhome high humidity climates ambient relative humidity is greater than 60 year round add a dehumidifier drained to the exterior to control humidity inside the recreational vehicle during storage Areas that are exposed to water spills or leaks should be dried as soon as possible and definitely within 24 48 hours Drying areas quickly minimizes the chance for moisture damage and possible mold growth which can begin to form colonies in 48 hours A variety of methods can be used to help the drying process e Remove excess water with an extraction vacuum Use a dehumidifier to air drying Use portable fans to move air across the sur
181. owner s packet Manual retraction 2 Attach flexible shaft to the 1 4 hex fitting on the end of the motor 3 Attach 1 4 socket amp ratchet or drill to the other end and turn in the proper direction to move the room 4 If the cables tighten and the motor is difficult to turn REVERSE THE DIRECTION Over torquing can happen resulting in severe damage 67 Controls and Operations GARAGE A DANGER Where equipped ANY MOTORIZED VEHICLE OR ANY MOTORIZED EQUIPTMENT POWERED WITH FLAMMABLE LIQUID CAN CAUSE FIRE EXPLOSION OR ASPHYXIATION IF STORED OR TRANSPORTED WITHIN THE RECREATIONAL VEHICLE TO REDUCE THE RISK OF FIRE EXPLOSION OR ASPHXIATION 1 Do not ride in the vehicle storage area while vehicles are present 2 DO not sleep in the vehicle storage area while vehicles are present 3 Close doors and windows in walls of separation if installed while vehicle is present 4 Run fuel out of engines of stored vehicles after shutting off fuel at tank 5 Do not store transport or dispense fuel inside this vehicle 6 Open windows openings or air ventalation systems provided for venting the transportation area when vehicles present 7 Do not operate propane appliances pilot lights or electrical equiptment when vehicles are present FAILURE TO COMPLY COULD RESULT IN AN INCREASED RISK OF FIRE EXPLOSION ASPHXIATION DEATH OR SERIOUS INJURY There is a 2500 pound maxmum capacity for the cargo area
182. pane Gas Detector Hair Spray Triggers the Detector Most aerosol hair sprays use butane gas as the propellant Butane like Propane is heavier than air and will settle to the floor level where it will be detected Other Gases Other gases which can cause the detector to respond with an alert include the vapors from any fuel liquor alcohol deodorants colognes perfumes wine adhesives lacquer and most cleaning agents Slow Beep Rate This could be the failure alarm and will occur in the event that the circuitry fails It is a continuous series of short beep tones between long intervals and is distinctively different from the alert sound If the problem still exists Contact the detector manufacturer for assistance TO AVOID EXHAUST GAS ENTRY INTO THE DANGER MOTORHOME KEEP WINDOWS CLOSED WHEN THE CHASSIS OR GENERATOR ENGINES ARE RUNNING Note The Propane Gas Detector enters a cleaning and initializing mode every time itis powered If turned OFF for less than 15 minutes the Propane Gas Detector may produce several short chirps within the first 80 seconds of operation This is a normal function of the LP Gas Detector Identification and Safety See your Thor Motor Coach Dealer or a qualified Propane Service Center should service be required If they are not familiar with this product have them call the detector manufacturer for assistance If service is not available in your area call MTI Industries After you first
183. panels Appearance of these conditions away indicate a serious condensation problem When you recognize the signs of excessive moisture and condensation in the motorhome action should be taken to minimize their effects E gt Note Your motorhome is not designed nor intended for permanent housing Use of this product for long term or permanent occupancy may lead to premature deterioration Long term occupancy may not be considered normal and may under the terms of the warranty constitute misuse abuse or neglect and void certain warranty protections 131 Care and Maintenance Tips for Controlling To avoid condensation problems try to follow these tips to help alleviate Condensation Avoid Drastic Thermostat Setbacks Carpet Care And Moisture Management Exterior Care of the 132 Motorhome excess moisture Allow excess moisture to escape to the outside when bathing washing dishes hair drying laundering and using appliances and non vented gas burners Always use the vent hood when cooking Keep the bathroom door closed and the vent or window open when bathing and for a period of time after you have finished Do not hang wet clothes in the vehicle to dry In hot weather start the air conditioner early as it removes excess humidity from the air while lowering the temperature Keep the temperature as reasonably cool during cold weather as possible The warmer the vehicle the more cold exterior temperatures
184. portant if you drive with the overhead vents open or if the motorhome is equipped with a roof air conditioner roof rack or TV radio antenna Check the total height for 41 On the Road Safety 42 CHANGING TIRES TIRE CARE CHECK AIR PRESSURE your particular motorhome and make sure that you are aware of it when driving under bridges or underpasses When parking parallel to a curb be sure to allow for poles or obstructions as the front and rear portions of the motorhome will swing wider than an automobile Remember that your motorhome is larger than your automobile and will require more space Be careful your unit does not occupy road space or block driveways while parking When parking on an incline turn the front wheels into the curb in the direction of the roll to aid the parking brake Always set the parking brake when parking CAUTION Changing a tire on a motorhome is more difficult than an ordinary automobile Motorhome tires are larger and heavier than ordinary tires Whenever possible call for roadside assistance to help you in changing your tires This task should not be done alone due to the weight of the unit Motorhomes are extrememly heavy Changing a flat tire is best left to a professional mechanic with the proper tools If absolutely necessary change the tire on a level and firm surface If you are on the roadside activate the vehicle s hazard warning flashers Apply the parking brake Set up flares and
185. pply of fresh air for combustion Unlike homes the oxygen supply is limited due to the size of the motorhome and proper ventilation when using the cooking appliances will avoid dangers of asphyxiation LAWS OF THE ROAD 20 Identification and Safety 26 FIRE SAFETY A DANGER ANY MOTORIZED VEHICLE OR ANY MOTORIZED EQUIPMENT POWERED WITH FLAMMABLE LIQUID CAN CAUSE FIRE EXPLOSION OR ASPHYXIATION IF STORED OR TRANSPORTED WITHIN THE RECREATIONAL VEHICLE TO REDUCE THE RISK OF FIRE EXPLOSION OR ASPHYSIATION 1 Do not ride in the vehicle storage area while vehicles are present 2 Do not sleep in the vehicle storage area while vehicles are present 3 Close doors and windows in walls of separation if installed while any vehicle is present 4 Run fuel out of engines of stored vehicles after shutting off fuel at the tank 5 Do not store transport or dispense fuel inside this vehicle 6 Open the windows openings or air ventilation systems provided for venting the transportation area when vehicles are present 7 Do not operate propane appliances pilot lights or electrical equipment when motorized vehicles are present FAILURE TO COMPLY COULD RESULT IN AN INCREASED RISK OF FIRE EXPLOSION ASPHYXIATION DEATH OR SERIOUS INJURY Fire safety is an important part of owning a motorhome Make sure that everyone traveling in the motorhome is familiar with the location of exits including emergency exit windows should an em
186. r s sole and exclusive obligation is to repair and or replace at its option any covered defect if 1 you notify Warrantor and one of its authorized servicing dealers of the defect which is discovered within the warranty coverage period within ten 10 days of discovering the defect and 2 you deliver your Motorhome to Warrantor or Warrantor s authorized servicing dealer at your cost and expense It is reasonable to expect some service items to occur during the warranty period Unless prohibited by state law the performance of warranty repairs shall not extend the original warranty coverage period Further any performance of repairs after the warranty coverage period has expired or any performance of repairs to component parts and appliances that are excluded from coverage shall be considered good will repairs which shall not alter the express terms of this limited warranty If the repair or replacement remedy fails to a cure a defect after Warranty Warrantor received a reasonable opportunity to cure the defect s your sole and exclusive remedy shall be limited to Warrantor paying you the cost of having an independent third party perform repairs to the defect s or diminution in value damages if defect s are incurable Warrantor may use new and or remanufactured parts and or components of substantially equal quality to complete any repair Defects and or damage to interior and exterior surfaces trim upholstery and other appearance items may o
187. r tire ratings relocate the passengers and redistribute or remove a portion of the cargo until the weight is within the proper limits for all four corners of the vehicle E gt Note Additional cargo carrying capacity can be obtained by reducing the amount of fresh water carried while driving Check vehicle weight periodically to obtain optimum mileage from tires and improve handling Tires should always be inflated as recommended in the chassis manufacturer s instructions or on the tire sidewall See your chassis operator s manual Improper weight distribution or too much weight on your motorhome s suspension system can cause spring shock absorber or brake failure handling or steering problems irregular tire wear tire failure or other damage An overloaded motorhome is hard to drive and hard to stop In cases of serious overloading brakes can fail completely particularly on steep hills The load a tire will carry safely is a combination of the size of tire its load range and corresponding inflation pressure Planning and Preparation The following is an explanation of commonly used weight abbreviations Gross Vehicle Weight Rating GVWR is the maximum permissible weight of this motorhome Unloaded Vehicle Weight UVW is the weight of this motorhome as manufactured at the factory with full fuel engine oil and coolants Occupant and Cargo Carrying Capacity OCCC is equal to the GVWR minus UVW and LP In other words
188. ranty Emergency NNR FOLLOWING MANUAL OVERRIDE OPERATION B traeti n Procedura FAILURE TO RETURN ALL VALVES TO NORMAL POSITION MAY RESULT IN ONE OR MORE JACK LEGS DRIFTING DOWN FROM THEIR RETRACTED STOWED POSITION FOR CARTRIDGE VALVES ROTATE THE CENTER SCREW FULLY COUNTER CLOCKWISE In the event of electrical failure the jack leg s may be retracted manually by following the procedure below 1 The individual cartridge valves are clustered together on the side of the pump manifold Locate the screws on the appropriate cartridge valve s Using a 5 32 Allen wrench turn the screw s clockwise until all the way in Note The normal operating position of the screw in the cartridge valve is the counter clockwise out position The only time the valve should be shifted manually is when attempting to operate jack s via manual override 2 Remove the plastic cap from the top of the motor and disconnect the power cables 3 Attach a 1 2 socket to the motor s coupler and drive it with a drill ratchet or similar 60 Controls and Operations device 4 To retract your jack s run the drill in the counter clockwise direction 5 To extend your jack s run the drill in the clockwise direction 6 When manual override is complete return the cartridge valve s to the normal positions Reinstall power cables and plastic cap on motor EMS Lie J 2 Clockwise for manual override Counter clockwise for normal operati
189. reakers The panel contains circuits with replaceable fuses for protection of motorhome 12 Volt lines If any line is shorted the fuse will blow Replace the fuse with the same size fuse DO NOT replace with a larger fuse than indicated If this action does not solve the problem there may be a short somewhere along the 12 Volt line or at a non fused 12 Volt component on the line Check the 12 Volt line and any components along the line Locate the short and take necessary steps to repair it If you cannot locate the problem have a qualified electrician check it out It is a good idea to keep additional fuses on hand in the motorhome Replacement fuses are available at filling stations hardware stores or automotive supply stores Remember that the replacement fuse must be the same amperage rating as the original Your motorhome chassis is equipped with an automotive 12 Volt fuse panel located below the dash near the steering column and or under the hood You should refer to the chassis owner s manual for details on these fuses The Class A motorhome also has a 12 Volt fuse panel electrical distribution box located on the fire wall under the hood These fuses protect the automotive features which are installed by Thor Motor Coach There is a complete breakdown on the various fuses printed on the backside of this fuse panel cover The 120 Volt system is protected by circuit breakers which automatically shut the circuit off if the c
190. reasonable and necessary maintenance see Owner s Manual damage caused by off road use collision fire theft vandalism explosions overloading in excess of rated capacities and odometer tampering shall discharge Warrantor from any express or implied warranty obligation to repair any resulting defect DISCLAIMER OF CONSEQUENTIAL AND INCIDENTAL DAMAGES THE ORIGINAL PURCHASER OF THE MOTORHOME AND ANY PERSON TO WHOM THE MOTORHOME IS TRANSFERRED AND ANY PERSON WHO IS AN INTENDED OR UNINTENDED USER OR BENEFICIARY OF THE MOTORHOME SHALL NOT BE ENTITLED TO RECOVER FROM WARRANTOR ANY CONSEQUENTIAL OR INCIDENTAL DAMAGES RESULTING FROM ANY DEFECT IN THE MOTORHOME INCLUDING BY WAY OF EXAMPLE FUEL AND TRANSPORTATION EXPENSES TO DELIVER THE PRODUCT TO THE SERVICING DEALER HOTEL ROOMS LOST WAGES AND MOISTURE DAMAGE SUCH AS MOLD AND MILDEW THE EXCLUSION OF CONSEQUENTIAL AND INCIDENTAL DAMAGES SHALL BE DEEMED INDEPENDENT OF AND SHALL SURVIVE ANY FAILURE OF THE ESSENTIAL PURPOSE OF ANY LIMITED REMEDY Some states do not allow the exclusion or limitation of consequential or incidental damages so the above exclusions may not apply to you LEGAL REMEDIES THIS LIMITED WARRANTY DOES NOT EXTEND TO FUTURE PERFORMANCE ANY ACTION TO ENFORCE THIS LIMITED WARRANTY OR ANY IMPLIED WARRANTIES SHALL NOT BE COMMENCED MORE THAN 90 DAYS AFTER THE EXPIRATION OF THE WARRANTY COVERAGE PERIOD DESIGNATED ABOVE IF YOUR MOTORHOME IS NOT OF THE CURRENT OR PRIOR MODEL YEAR
191. remove daily accumulations High pressure laminate counter tops are quite easy to keep clean Waxing is not necessary Glass rings food spills water spots and smudges usually wipe off with a damp cloth or sponge Stubborn stains can be removed with a spray cleaner Laminated surfaces resist alcohol fruit acids cosmetics and most household chemicals It is better to avoid contact with dyes strong laundry bleaches and bluing solutions Indelible inks used on food packages may leave a stain so take care when unpacking groceries on a damp counter top Sharp knives can damage the finish so confine slicing to a good cutting board The counter top resists moderate heat and boiling water Pots and pans straight from the oven or broiler should be placed on hot pads Keep irons on an ironing board and lighted cigarettes in an ashtray For lasting beauty avoid using harsh abrasives scouring powders peroxides or bleaches These can dull surfaces making the counter top more likely to accept stains Wipe clean as you would for daily cleaning Use a nonabrasive cleaner to avoid damaging the finish To clean wipe with a soft damp cloth Warm water will remove dry water spots Do not use cleansers which contain abrasive or harsh chemicals Never use alcohol or other organic solvents Keep your blinds looking new by wiping with a soft cloth Vacuum shades regularly Use a mild detergent to spot clean if necessary Close the blinds and shades all the way
192. rn pattern 3 beeps pause 3 beeps pause and the Red LED will flash rapidly or Note If the unit does not alarm make sure the batteries are correctly installed and test again If the unit still does not alarm replace it immediately Identification and Safety This unit has been designed to be as maintenance free as possible but there are a Regular Maintenance few simple things you must do to keep it working properly Use only the replacement batteries listed below The unit may not operate properly with other batteries Never use rechargeable batteries since they may not provide a constant charge e Test it at least once a week e Clean the Smoke Alarm at least once a month gently vacuum the outside of the Smoke Alarm using your house hold vacuum s soft brush attachment Test the Smoke Alarm Never use water cleaners or solvents since they may damage the unit If the Smoke Alarm becomes contaminated by excessive dirt dust and or grime and cannot be cleaned to avoid unwanted alarms replace the unit immediately e Relocate the unit if it sounds frequent unwanted alarms See product manual under Locations to Avoid for Smoke Alarms for details When the battery becomes weak the Smoke Alarm unit will chirp about once a minute This low battery warning should last 7 days but you should replace the battery immediately to continue your protection Ce Note If locking pin is engaged see Locking Feature section f
193. rotection Warranty THOR MOTOR COACH S LIMITED WARRANTY WHAT THE PERIOD OF COVERAGE IS This Limited Warranty provided by Thor Motor Coach Inc 9 Warrantor covers those components assemblies and systems of your new motorhome not excluded under the section What is Not Covered when sold by an authorized dealer The duration of the limited warranty ends twelve 12 months after you first take delivery of the motorhome from an authorized dealership or after the odometer reaches 15 000 miles whichever occurs first However this Limited Warranty provided by Warrantor covers the steel or aluminum frame structure only of the sidewalls excluding slide outs roof and rear and front walls for twenty four 24 months from the original retail purchase date or the first 24 000 miles of use whichever occurs first Warrantor s Limited Warranty is not transferable and only applies to the first retail owner of the motorhome If the motorhome is not of the current or prior model year when you take delivery of the motorhome OR you register your new motorhome in a business name or use your motorhome for any commercial or business purposes other than for rental purposes the duration of the limited warranty ends ninety 90 days after you first take delivery of the motorhome or after the odometer reaches 5 000 miles whichever occurs first The duration of the Limited Warranty covering the steel or aluminum frame structure only of the sidewalls excluding
194. rtains amp Blinds Windows Holding Tanks Drain Traps Refrigerator Ice Maker Air Conditioner Roof Vents Sinks amp Showers Batteries Close all the drapes and curtains and protect the curtains from sun fading by placing foil or paper between the windows and the curtains blinds Close and lock Inspect and reseal if necessary Drain and rinse Close valves Add a small amount of RV antifreeze to keep valves and gaskets lubricated Pour a cup of RV antifreeze down all drains Wipe all fixtures clean Clean Leave both doors propped open Cover exterior panels and roof vents Leave an opened box of baking soda inside the refrigerator to prevent any musty odors from accumulating Refer to your refrigerator owner s manual for proper winterization procedures Remove air filters and clean or replace Cover shroud Must be kept clear of significant snow accumulation or damage may occur Inspect and reseal if necessary Check all furnace refrigerator range hood A C etc vents and close securely Cover or tape up to prevent mice or insects from building nests that can disturb the air flow and keep the appliances from functioning properly Clean and then pour one cup of nontoxic RV antifreeze into the drains to prevent freezing Wipe all fixtures clean Add distilled water and recharge if necessary If possible remove batteries and store them in a cool dry place approximately 50 60 F Check them p
195. ry Wear safety glasses when inspecting or servicing the system to protect eyes from dirt metal chips or leaks etc Follow all other applicable shop safety practices The motorhome should be parked on a fairly level surface Ensure that there are no obstructions in the extend or retract paths of the jacks If the surface is soft due to saturation or heat place boards under the jacks to distribute the weight over a larger area Using a board which measures approximately 2 wide by 2 in length is recommended Ensure the front tires are pointing forward and not to the left or right 22 Note Refer to manufacturer s operations manual before operating The automatic hydraulic power leveling system allows quick and easy leveling of the motorhome from the driver s seat by utilizing the system touch panel The following instructions are general operating instructions CAUTION MAKE SURE THERE ARE NO OBSTRUCTIONS IN THE EXTEND OR RETRACT PATHS OF THE JACKS KEEP ALL PEOPLE CLEAR OF THE VEHICLE WHILE OPERATING THE LEVELING SYSTEM Do not allow excessive motion in the motorhome during the Auto Level operation This could cause the system to level improperly 1 TURN ON POWER The power to the unit must be turned on You need to have the engine running and the parking brake must be set to turn the control panel on Push the POWER touch pad to engage power The power touch pad should be lit when power is on 2 PRESS THE AUTO LEVEL TOUCH PAD T
196. s filters wheel alignments and resealing exterior sealant areas see Care and Maintenance Section of Owner s Manual the automotive chassis and power train including by way of example the engine drive train steering ride and handling braking wheel balance muffler tire wear or failure tubes batteries and gauges appliances and components covered by their own manufacturer s warranty including by way of example the microwave refrigerator ice maker stove oven generator roof air conditioners hydraulic jacks VCR television s water heater furnace stereo radio compact disc player washer dryer inverter and cellular phone or flaking peeling and chips or other defects or damage in or to the exterior or finish caused by rocks or other road hazards the environment including chemical off gassing airborne pollutants salt tree sap and hail causing any damage including but not limited to corrosion Component part and appliance manufacturers issue limited warranties covering those portions of the motorhome not covered by the Limited Warranty issued by Warrantor To learn more on what specific component parts and appliances are excluded from the Limited Warranty issued by Warrantor please dins Warranty your selling dealership or Warrantor directly or review the warranty packet inside the Motorhome EVENTS DISCHARGING WARRANTOR FROM OBLIGATION UNDER WARRANTY Misuse or neglect accidents unauthorized alteration failure to provide
197. s not have to work as hard since the second stage receives consistent pressure rather than inlet pressure which varies The result is an efficient safer system that helps to eliminate problems such as freeze up and pilot outage The regulator has been preset by the manufacturer of the regulator and adjustment should not be necessary If adjustment should be required DO NOT attempt to adjust it yourself Adjustment must be made with special equipment by a qualified propane gas service technician Have the regulator checked annually or whenever you suspect 116 LP System a problem The correct line pressure should be 6 oz or 11 inches of water column Because air is required for proper operation of the regulator it is very important that the regulator vent is kept clean and free of dirt and debris This is why it is necessary to keep the vent facing downward and the regulator covered to protect if from contamination A toothbrush can be used to clean the vent if it becomes clogged by foreign matter If you believe a regulator has been damaged or otherwise is not functioning have it replaced by a qualified propane gas service representative During cold weather it is important to keep ice from forming in the regulator which will shut off the flow of propane gas to the appliances Have the supplier add a hydrous methanol when filling the tank for use during cold weather Regulator freeze up can occur in any weather if there is moisture i
198. s turned on all buttons are backlit Press to select brightmess contrast color or tint adjustment options or press and hold to access setup menu Time out of OSD menu is approximately 5 seconds from the last key press Use to select source input fron channels 1 channel 3 Source ID is indicated in top left corner Used to adjust brightness contrast colot and tint as well as to navigate through the menu Use to select DAY NIGHT or AUTO mode Press to increase volume and to decrease volume Also used for menu option setting selection Controls and Operations STAND ALONE DASH RADIO Jensen 210 The dash radio will control the multi functions for the dash audio system Basic Operations are listed below For complete information consult your owner s manual provided Satellite Ready means that the in dash radio will work with a satellite radio tuner should you decide to install one 1 Volume Control To increase the volume rotate clockwise To decrease the volume rotate counter clockwise 2 Remote Sensor Thor Motor Coach does not provide remote controls for this radio 3 Power On Off Press the power button to turn the unit on off 4 Mode Press to select a different mode of operation Available modes include TUNER SIRIUS CD USB IPOD and AUXILIARY 5 RPT Press to repeat play the current track Press again to stop repeat play 6 INT Press to play the first 10 seconds of each track
199. se personal injury and vehicle damage It is the operator s responsibility to ensure that all room locking devices if equipped are disengaged before operating the room The motorhome must be level before extending the slide out room s Failure to do so may result in structural damage to the motorhome or water intrusion Note BEFORE EXTENDING OR RETRACTING SLIDE OUT ROOM Be sure that the driver s seat is in the forward position and the seat back is straight up Slide out room will contact chair if chair is improperly positioned Controls and Operations Keep people and obstructions clear of room when A DANGER operating x Note Make sure that there is adequate clearance to fully extend the room 1 Apply the parking brake 2 Make sure ignition is in OFF position 3 To extend the room press and hold the ROOM CONTROL SWITCH in the OUT position When the room is fully extended release the ROOM CONTROL SWITCH Note Releasing the ROOM CONTROL SWITCH will halt the operation of the room Make sure to clear any obstruction in the slide out area and set the parking brake 2 To retract the room press and hold the ROOM CONTROL SWITCH in the IN position When the room is fully retracted release the ROOM CONTROL SWITCH Install the room locking devices if equipped If the room will not retract refer to the Manual Retract Procedure AO Locate the included flexible shaft in your
200. se the Fan selector to select Auto or On as well as the fan speed Setting the Temperature Use the slider on the temperature display to selecet the desired temperature Digital Model RVYVCOMFORT HC Coleman Choosing a Mode Use the Thermostat selector to select Cool Heat or to turn the system off Fan Control Use the Fan Mode selector to select Auto or On Use the Fan Speed selector so set the fan speed to Hi or Lo Setting the Temperature Use the up and down arrow to the right of the digital display to set the desired temperature 89 Heating and Air Conditionin 90 Dometic CEILING VENTS Exhaust Vent Dometic 4 Off Mode Mode Selection Press and release the On Off Mode button to cycle through the available modes All Dometic Single Zone LCD Thermostats have Cool and Furnace modes Select models will have an additional mode either Heat Pump or Heat Strip When desired mode has been selected the LCD will display the temperature set point and the green LED will be lit next to the selected mode To change the set point press the button to increase the set point and the button to decrease the set point Fan 4 Cool 4 Furnace 4 Fan Mode Setting Press and release the On Off Mode button Press and release the or button to cycle through the fan speed options Lo Low Hi High Au Auto Inside Temperature To display the Inside Temperature the Single Zone
201. should be disposed of down the drain Never put grease food or other obstructions down the drain because you may plug the holding tank The faucet in your motor coach may be a single lever faucet with sprayer To use the sprayer pull out on the head of the faucet Press the button on top to release the water To reinsert the hose gently guide it back to the original position If you are not hooked up to a pressurized water system at the city water fill you must turn the water pump switch on You can find the water pump switch on a bathroom wall or on the monitor panel in the hall The water pump is a demand pump so it will only operate when a faucet is opened to release the pressure The shower hose has a bracket that keeps the shower head from dropping and contaminating the fresh water system It also has a vacuum breaker to prevent the head from siphoning water back into the fresh water system The shower operates just like the shower at your home with two knobs that control the mix and flow of water and a center valve to divert water into the shower head A stopper is provided so that you can fill the tub The motorhome may be equiped with a washer dryer hookup for your convienience Controls and Operations The elevated bed mechanism represents a pinch or crush hazard Make sure that all extremeties are clear and do not stand under the bed during operation bed during operation Each vehicle with elevated beds has a warning label
202. sis fluid levels including engine oil coolant power steering fluid brake fluid transmission rear axle oil and washer fluid Top off if necessary e Check all exterior lights clearance brake turn and reverse should be fully functional Your motorhome should be ready for a new traveling season Your dealer can check your preparation and correct any defects or make any necessary adjustments These items are the absolute minimum requirements necessary for pre travel Your motorhome is designed to carry the loads defined by the Gross Axle Weight Rating GAWR the value specified by the chassis manufacturer as the load carrying capacity of a single axle system as measured at the tire ground interface The Gross Vehicle Weight Rating GVWR the maximum permissible loaded weight of the motorhome is shown on the vehicle information sticker posted near the driver s side front window or inside the driver s side door jam These ratings are for a fully loaded vehicle including passengers and normal belongings ZOWARNING EXCEEDING THE GAWR OR GVWR OF YOUR Motorhome CAN CAUSE UNDESIRABLE HANDLING CHARACTERISTICS and may even create a safety hazard Modification of your vehicle to carry additional equipment or vehicles is not recommended and may void your warranty v Note Be sure the weight of passengers equipment and supplies does not cause your motorhome to exceed axle loads and overall vehicle loads for which it was designed If in doubt
203. slide outs roof and rear and front walls ends twelve 12 months after you first take delivery of the motorhome or after the odometer reaches 15 000 miles whichever occurs first A conclusive presumption that your motorhome has been used for commercial and or business purposes arises if you have filed a federal or state tax form claiming any business tax benefit related to your ownership of the motorhome LIMITATION AND DISCLAIMER OF IMPLIED WARRANTIES IMPLIED WARRANTIES IF ANY ARISING BY WAY OF STATE LAW INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILITY AND ANY IMPLIED WARRANTY OF FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED IN DURATION TO THE TERM OF THIS LIMITED WARRANTY AND ARE LIMITED IN SCOPE OF COVERAGE TO THOSE PORTIONS OF THE MOTORHOME COVERED BY THIS LIMITED WARRANTY WARRANTOR DISCLAIMS ALL IMPLIED AND EXPRESS WARRANTIES INCLUDING THE IMPLIED WARRANTY OF MERCHANTABILITY AND THE IMPLIED WARRANTY OF FITNESS FOR A PARTICULAR PURPOSE ON COMPONENTS AND APPLIANCES EXCLUDED FROM COVERAGE AS SET FORTH BELOW There is no warranty of any nature made by Warrantor beyond that contained in this Limited Warranty No person has authority to enlarge amend or modify this Limited Warranty The dealer is not the Warrantor s agent but is an independent entity Warrantor is not responsible for any undertaking representation or warranty made by any dealer or other person beyond those expressly set forth in this Limited Warranty Some states do not allow
204. source The converter will run warm and this is normal If however it gets too hot it will turn itself off After it cools down it will come back on In most cases when this happens it is because something has been put around or too near the converter preventing it from receiving adequate ventilation Make sure not to put anything near the converter that could obstruct ventilation A slight hum during operation is also normal for the converter if you do not have 12 Volt power and no hum check to see if 120 volt power to the converter has been interrupted Even with GFCI protection persons with severe heart or A WARNING other health problems may still be seriously affected by an electrical shock The GFCI outlet is not a substitute for good electrical safety DOES NOT protect against contact of the hot and neutral wire at the same time The 120 volt outlet in the kitchen and or bath and outside recepts are equipped with a protective circuit interrupter The ground fault circuit interrupter GFCI is designed to break the flow of current to the protected outlet when an imbalance of current is detected Imbalances include electrical leakage in an appliance such as a shaver or hair dryer that have developed a weak spot in electrical insulation The possibility of electrocution exists when using a faulty appliance while at the same time being in contact with an electrical ground such as water plumbing or the earth If an imbalance
205. tal purposes and any motor home sold or registered outside of the United States or Canada items which are added or changed after the motorhome leaves Warrantor s possession items that are working as designed but with which you are unhappy with because of the design normal wear and usage such as fading or discoloration of fabrics or the effects of moisture inside the motorhome defacing scratching dents and chips on any surface or fabric of the motorhome not caused by Warrantor owner maintenance including by way of example replacement of wiper blades bulbs filters wheel alignments and resealing exterior sealant areas see Care and Maintenance Section of Owner s Manual the automotive chassis and power train including by way of example the engine drive train steering ride and handling braking wheel balance muffler tire wear or failure tubes batteries and gauges appliances and components covered by their own manufacturer s warranty including by way of example the microwave refrigerator ice maker stove oven generator roof air conditioners hydraulic jacks VCR television s water heater furnace stereo radio compact disc player washer dryer inverter and cellular phone or flaking peeling and chips or other defects or damage in or to the exterior or finish caused by rocks or other road hazards the environment including chemical off gassing airborne pollutants salt tree sap and hail causing any damage including but not limite
206. tant to note that any finish will deteriorate with time Dulling fading and yellowing will be increased by exposure to extreme sunlight air pollutants and excessive moisture Motorhomes located in warmer weather climates are more prone to this type of premature fading Surface weathering of fiberglass does not change the strength of the fiberglass Regular washing and waxing of exterior surfaces is the best insurance against surface deterioration If deterioration has occurred check with your dealer for the steps required to restore the finish Buffing or even painting may be necessary in extreme cases Small cracks known as gel coat crazing are a common characteristic of the gel coat finish and not warrantable defects Wax fiberglass surfaces at least once a year with a standard liquid or nonabrasive paste wax Make sure to follow the directions for use as outlined by the product manufacturer Make sure to wash and wax your unit out of the hot sun when the exterior surfaces are cool Storage of the recreational vehicle out of direct sun is also a primary way to help preserve fiberglass finishes Physical damage to fiberglass should be taken care of immediately to avoid moisture from entering through breaks and causing problems with interior walls and components Cover breaks in the fiberglass with plastic sealing the edges with tape until proper repairs can be made Note DO NOT use rubbing compound or any abrasive cleaner or cloth on the motorh
207. tem you may want to add additional water to the tank to replace the water used when filling the hot water tank and water lines gt Note When trying to drain the entire on board fresh water system make sure to open faucets water heater drain and system low point drains to remove all fresh water from the system The fresh water storage tank supplies potable water to all fixtures within your motorhome by means of a 12 Volt water pump This pump is located close to the storage tank and is equipped with a check valve that ensures directional flow away from the tank The pump has an on off switch which is located on the monitor panel bathroom or termination compartment The pump will automatically build up pressure and maintain that pressure when turned on The pump should be turned off when the fresh water tank is empty or when the motorhome will not be in use Continued operation with a dry tank may damage the pump Your pump has a filter on the inlet side This filter should be cleaned after each tankful of water for the first few uses To remove the cover press in firmly and twist counterclockwise about one eighth turn Pull the screen out of the bowl and rinse clean Reassemble in the reverse fashion For more information check your water pump Owner s Manual located in your Owner s Information Kit The low point drains are located in the water lines on the floor of the motorhome except the Windsport brand motorhome Specific locations along
208. ter off when you are not using it Shore power will pass through the inverter even though the inverter s power is off Q2 Note XM Series Inverter will operate most AC loads within its power rating of 1800 watts However some appliances and equipment may be difficult to operate and other appliances may actually be damaged if you try to operate them with the XM Series Inverter Examples include Speed controllers found in some fans power tools kitchen appliances and other loads may be damaged Some chargers for small rechargeable batteries can be damaged Metal halide arc HMI lights can be damaged E01 Yellow Under voltage warning Check the connections and cable to see if the battery is fully charged Recharge the battery if it is low Reduce the load E02 Red Under voltage shutdown Disconnect the load and recharge the battery E03 Red Over voltage shutdown Make sure the XM Series Inverter is connected to a 12 V battery E04 Yellow Overload shutdown warning Make sure the load does not exceed the XM Series Inverters output rating Reduce the load if necessary E05 Red Overload shutdown Short circuit Reduce or disconnect the load Make sure the load does not exceed the XM Series Inverters output rating Check connection to the load E06 Not used E07 Yellow Over temperature shutdown warning Allow the unit to cool off Reduce the load if continuous operation is required Improve ventilation Make sure the inverter s ventilation
209. that have inspected or been given the opportunity to inspect the vehicle taken a test drive of the vehicle and made notations of any issues discovered in the space provided PURCHASER SIGNATURE DATE DEALER SIGNATURE DATE SELLER DEALER DATE AldVLS LON Od 3S V3 ld AdVL FOLD HERE THOR MOTOR COACH P O Box 1486 ELKHART INDIANA 46516 FOLD HERE TAPE PLEASE DO NOT STAPLE Table of Contents Introduction How to Use this Manual Reporting Safety Defects Warranty Production Changes Owner Responsibility Major Equipment Suppliers Planning and Preparation Read the Book Licenses Insurance Inspect and Maintain Loading and Weight Distribution Control of the Motorhome Pre Travel Check Opening Checklist Weights Weighing Your Motorhome Identification and Safety Laws of the Road Fire Safety Fire Extinguisher Smoke Detector Carbon Monoxide Safety Precautions LP Safety LP Gas Carbon Monoxide Detector Chemical Sensitivity Seat Belts Egress Window Trailer Towing Chassis Emergency Stopping Engine and Drive Train Fueling the Motorhome Travel Preparation On the Road Safety Fuel System Driving Parking Changing Tires Tire Care Check Air Pressure Controls and Operations Automotive Dash Gear Selector Dash Controls Steering Wheel Adjustment Turn Signal Lane Change Hazard Flasher Control Stand Alone Rear Vision System Stand Alone Dash Radio Combination Rear Vision and Radio
210. the Performance closest A C outlet vent and the return air inlet grill under most operating conditions Characteristics Factors that can affect the performance of the cooling system Use window and patio awnings when outside ambient temperature is above 95 F to help deflect the Sun load during the heat of the day If window awnings are not installed then use shades or blinds to deflect the Sun e Try to avoid using the cook top or oven when the ambient temperature is over 95 F e Keep windshield covered when facing the afternoon Sun when parked number of windows within the slide outs and the number of cold air registers to handle heat gain when facing the afternoon Sun e Color of exterior paint or graphics the darker the exterior the more heat will be absorbed PERUT AIRINGS Note DO NOT USE HARSH CHEMICALS OR SOLVENTS TO CLEAN THE FILTER Clean the return air filters as needed for the environment in which they operate The return air filters are inside the air intake vent covers located on the motorhome ceiling Never operate the air conditioners without the return air filters in place Doing so may result in the build up of dirt on the evaporator core affecting the performance of the air conditioner TO CLEAN Remove the vent cover and filter and wash in warm soapy water Rinse the filter and cover thoroughly with fresh water and allow to dry Reinstall the filter and cover FURNACE CAUTION THIS APPLIANCE
211. tive humidity including operating a dehumidifier with a continuous drain The carpet should be cleaned when it shows signs of discoloration or traffic patterns The use of a professional steam cleaning system is recommended for cleaning the carpet unless otherwise noted To manage moisture from the cleaning process the cleaning system needs to be capable of extracting the excess water from the carpet after it has been cleaned Important Be sure the carpet is thoroughly dry before closing the motorhome for storage Water from the cleaning process can cause significant damage to the motorhome if the carpet is not completely dry before closing up the motorhome for an extended period The exterior shell of the motorhome is the primary weather and moisture barrier Over the life of the motorhome the shell will require regular care and maintenance The shell includes the roof sidewalls windows doors and under carriage of the motorhome Particular attention needs to be devoted to ensure these components are maintained to ensure a tight barrier against bulk water intrusion The shell should be inspected periodically for tears gaps and condition of sealants Areas that require maintenance should be resealed utilizing a proven high quality sealant of similar characteristics as the original sealant Particular attention should be Care and Maintenance devoted to ensure the slide outs are functioning properly Each time a slide out is used it sh
212. toring your motorhome for the winter or other extreme conditions certain precautions need to be made to protect it until you open it up again for use Make sure to talk with your local dealer concerning any special requirements for storage in your particular geographic area The following steps are general and your dealer can help you choose those that are most appropriate to your needs Chassis Run engine for 30 minutes once a month if possible Prepare as outlined in the Chassis Owner s Manual Generator Prepare as outlined in the Generator Owner s Manual Plumbing Lines Drain and protect by filling with approved RV antifreeze Water Heater Drain Toilet Drain Hold pedal down and pour RV antifreeze into bowl Fresh Drain pour RV antifreeze solution and run through the fresh Water Tank water system or use the dry method Remove and discard the filter Install diverter tube in place of filter assembly Body Clean and wax Oil locks and hinges Seal roof trim as needed Tires Block up motorhome with wooden blocks or manufactured jack stands on a hard level surface to relieve the constant pressure on one area of the tires Partially deflate the tires Cover to protect against sunlight with burlap plywood or specially designed tire covers which are available at RV dealerships Countertops Wash with mild soap and water amp Cabinets WATER HEATER BYPASS WINTERIZATION CHECKLIST 137 Winter Use and Storage 138 Cu
213. ts and fittings Repair if necessary e Check 12 Volt circuit breakers and inspect all fuses Operate all 12 Volt lights and accessories e install new batteries in battery operated devices e Test propane smoke and carbon monoxide detectors Replace the batteries if necessary e Check the monitor panel operation e Open and operate all vents and vent fans Remove any outside coverings if applicable e Inspect 120 Volt electrical system which includes power cord converter all outlets and exposed wiring If defects are found consult your servicing dealer or an authorized service center e Operate 120 Volt appliances and air conditioner s Be sure to uncover air conditioner shroud s e Inspect the propane system and check for leaks If propane tank shows signs of rust or corrosion have it inspected by a qualified propane technician Refill if necessary e Operate each propane appliance Observe all burner pilot flames for proper color and size f necessary have propane regulator adjusted for proper pressure by a qualified technician 19 Planning and Preparation WEIGHTS Federal Weight Label 20 Capacity e Check sealants around all roof and body seams and windows Reseal if necessary e Lubricate all exterior locks hinges and latches e Wash and wax exterior Inspect body for scratches or other damage Touch up or repair as necessary Flush underside of the motorhome thoroughly e Check all the chas
214. ts on the ledges provided Loosen the seat cushion from the Velcro fasteners and slide each together to form the bed Reverse this process when reconverting to the dinette configuration Wall Mounted This dinette can also be converted into an additional bed Lift the aisle side of the table and pinch in the pins on the table leg to collapse the leg Unhook from side wall and swing into place The table supports on the dinette base Loosen the seat cushion from the Velcro fasteners and slide each together to form the bed Reverse this process when reconverting to the dinette configuration The barrel chair has controls on the bottom right and left sides under the chair skirt that controls the swivel and side to side action of the chair To recline sit down grasp the armrest s and lean back to recline Since a seat belt is not provided do not use the barrel chair while in transit The euro recliner where equipped has controls on the left side of the chair that release the footrest To recline sit down pull the recline lever or switch to release the footrest Since a seat belt is not provided do not use the euro recliner while in transit PILOT AND CO PILOT SEATS MUST BE LOCKED IN A WARNING A FORWARD FACING POSITION WITH SEAT BELTS FASTENED WHILE THE Motorhome IS IN MOTION Avoid seat rotation while in transit Reclining Back A control lever on the left or right side of seat controls the angle of the back rest Lift up on the lever
215. turers installation instructions carefully and that you take in to account the size and height of the mattress either originally installed by Thor Motor Coach or later replaced by you so that the rails are the approprate height above the mattress This is important because residential mattresses differ in size from the RV mattresses originally installed by Thor Motor Coach Please also make sure that the bed rail you select allows for adequate room to get in and out of the elevated bed after installation especially in the event of an emergency e Please use sound judgment when allowing children to sleep in any style of elevated bed Generally it is not suitable for children under the age of 6 to sleep in an elevated bed or bed loft area Discuss proper usage of any elevated bed electric lift system with your children and make sure they are supervised if playing in the bedroom sleeping area with elevated beds Please do not allow horseplay on or under the elevated bed and no items such as hooks belts jump ropes or towels should hang from any part of the elevated bed Place a night light in the bedroom sleeping area so users can see at night when getting in and out of the beds ELEVATED BEDS Tips For Safe Usage Use Of Bed Rails 15 Controls and Operations 76 than one person should be in an elevated bed at once and make sure you follow the weight restrictions posted on the warning label near the beds
216. u cannot find a resolution to your issue you may contact a Thor Motor Coach Dealer with questions or contact the Thor Motor Coach Customer Service Department at 877 855 2867 Thor Motor Coach offers many different configurations and locations for the televisions depending on the floor plan of the unit These may include swing out cab over televisions small televisions in the bunk bed area and a removable television in the bedroom that may be moved to the exterior of the Motorhome Please consult the television user s guide that was provided in your unit packet for detailed operating instructions Your Motorhome may be equipped with a home theater system This system offers a DVD Player as well as auxiliary speakers Please consult the user s guide that was provided in your unit packet for detailed operating instructions Your Motorhome may be equipped with an exterior entertainment center This entertainment center may contain the following radio CD Player television DVD player and speakers Please consult the user s guide that was provided in your unit packet for detailed operating instructions of the various components that make up the exterior entertainment center C Note These components are not waterproof Be sure to safeguard against moisture intrusion from rain and other precipitation Your Motorhome may be equipped with a video switch box This box will allow you to switch between different inputs without disconnecting an
217. unctioning properly The smoke alarm will only indicate the presence of smoke that reaches the sensor The smoke alarm is not designed to sense gas heat or flames The CO alarm is not designed to detect fire or any other gas It will only indicate the presence of CO gas at the sensor CO may be present in other areas For instruction on programming the alarm refer to the Smoke Alarm User s Manual within your Owner s Packet for detailed setup information AWARNING Never remove a fuse or battery providing power to a carbon Monoxide LP or Smoke alarm for the purpose of turning the alarm off AWARNING DO NOT STAND CLOSE TO THE ALARM WHEN THE HORN IS SOUNDING Exposure at close range may be harmful to your hearing When testing step away when the horn starts sounding A WARNING NEVER USE AN OPEN FLAME OF ANY KIND TO TEST THIS UNIT The built in test switch accurately tests the unit s operation as required by Underwriters Laboratories Inc UL It is important to test this unit every week to make sure it is working properly Using the test button is the recommended way to test this Smoke Alarm Press and hold the test button on the cover of the unit until the alarm sounds the unit may continue to alarm for a few seconds after you release the button If it does not alarm make sure the unit is receiving power and test it again If it still does not alarm replace it immediately During testing you will hear a loud repeating ho
218. unds open all doors and major windows to air out the motorhome and turn the gas off at the tank Do not reenter the motorhome until the alert stops sounding If the alert sounds a second time after the gas is turned back on leave the gas off and have a qualified Propane Dealer or Motorhome Service Center make the necessary repairs The reset button only stops the alert from sounding for 60 seconds This device is intended for detection of carbon monoxide and propane gas ONLY Ce Note Never use water cleaners or solvents to clean the detector Detector Maintenance The following maintenance steps should be taken to ensure proper function of the detector Test the detector at least once per week Clean the detector at least once a month gently vacuum the outside of the detector using the vacuum s soft brush attachment If detector becomes contaminated by excessive dirt dust and or grime and cannot be cleaned to avoid unwanted alarms replace the unit immediately Be sure to replace your detectors by the replace by CAUTION date on the cover or according to the timeframe listed in the detector s user s manual NEVER USE AN OPEN FLAME OF ANY KIND TO TEST WARNING How To Test THIS UNIT The built in test switch accurately tests the unit s operation as required by Underwriters Laboratories Inc UL Simply press the TEST switch any time during the warm up cycle or while in normal operation The LED should flash red
219. ust to the extent permitted by law notify Warrantor directly in writing of the failure to successfully repair the defect s so that Warrantor can become directly involved in exercising a final repair attempt for the purpose of performing a successful repair to the identified defect s Minor adjustments such as adjustments to the interior or exterior doors drawers latches by way of example and not by limitation will be performed by your selling dealer during the first ninety 90 days of warranty coverage Thereafter such adjustments are the owner s exclusive responsibility as normal maintenance HOW TO GET SERVICE The Acknowledgement of Receipt of Warranty Product Information form must be returned to Warrantor promptly upon purchase to assure proper part replacement and repair of your motorhome Failure to return the Acknowledgement of Receipt of Warranty Product Information form not affect your rights under the Limited Warranty so long as you can furnish proof of purchase For warranty service simply contact one of Warrantor s authorized service centers for an appointment then deliver your motorhome at your expense to the service center If you need assistance in locating an authorized warranty service facility contact Warrantor s Warranty Department 877 855 2867 The mailing address is P O Box 1486 Elkhart Indiana 46515 1486 WHAT THE WARRANTY DOES NOT COVER This Limited Warranty does not cover any motorhome used for ren
220. ust be between 40 degrees and 100 degrees Fahrenheit and also have a source of moisture such as humidity standing water damp materials etc Indoors the most rapid growth occurs with warm and humid conditions Care and Maintenance By controlling relative humidity the growth of mold and mildew can be inhibited In Inhibiting Mold warm climates use of the air conditioner will reduce the relative humidity Vents are Growth located in the bathing and cooking areas and constant use is advised during food preparation and bathing even during colder weather Additionally opening a window during these activities will assist in ventilation In extremely humid conditions the use of a dehumidifier can be helpful E gt Note If using a dehumidifier please read and follow all manufacturer instructions and recommendations to the use and cleaning of the dehumidifier Ideally relative humidity should be at 60 or less Relative humidity can be monitored utilizing a portable hygrometer a small device that measures temperature and relative humidity Hygrometer s are available at electronics or building supply stores for minimal cost gt Note cold climates relative humidity may need to be at 35 or less to avoid window condensation Frequent use of the motorhome or cleaning regularly is an important preventive measure Further any spills should be wiped up quickly and dried as soon as possible Avoid leaving damp items lying a
221. w suburbanmanufacturing www selectcomfort com com Microwaves Windows Midwest Sales Hehr International 574 287 3365 574 935 5122 Whirlpool www hehr international com 866 688 2002 Lippert Components www whirlpool com 574 534 0001 Radios www lci1 com ASA Electronics Jensen 800 688 3135 www asaelectronics com Ranges and Cooktops Atwood Mobile Products 800 825 4328 www atwoodmobile com Refrigerators Norcold 800 543 1219 www norcold com Dometic 800 544 4881 www dometicusa com Whirlpoool 866 688 2002 www whirlpool com Slide Out Systems Lippert Components 574 534 0001 www lci1 com Norco 800 347 2232 www norcoind com Televisions ASA Electronics Jensen 800 688 3135 www asaelectronics com Toilets Thetford 800 521 3032 www thetford com Washer Dryer Combos Ariston 877 356 0766 www aristonappliances com Splendide 800 356 0766 www splendide com 15 Warranty Planning and Preparation A thorough working knowledge of your motorhome is important if you are going to get the most out of the convenience and safety items built into your unit Be as familiar with it as you are with your personal car or truck Study all the booklets included in your Owner s Information Kit These booklets cover details of operation for the major appliances and equipment built into your motorhome for your comfort convenience and safety Your selling dealer should provide you with a complete walk through of your vehicle at the time of purchase An
222. wn on this page may not be applicable to your vehicle Please reference the Yellow label affixed directly to the door of your motorhome for your actual Occupant and Cargo Carrying Capacity MOTOR HOME OCCUPANT AND CARGO CARRYING CAPACITY VINEA AREARE THE COMBINED WEIGHT OF OCCUPANTS AND CARGO SHOULD NEVER EXCEED XXX kg or XXX Ibs SAFETY BELT EQUIPPED SEATING CAPACITY XXX CAUTION A FULL LOAD OF WATER EQUALS XXX kg OR XXX Ibs OF CARGO 1kg L 8 3 Ib gal AND THE TONGUE WEIGHT OF A TOWED TRAILER COUNTS AS CARGO 22 DO NOT OVERLOAD THE Motorhome When loading your cargo be sure it is distributed evenly to prevent overloading front WEIGHING to back and side to side Heavy items should be placed low and as close to the axle YOUR LOADED positions as reasonable Too many items on one side may overload a tire MOTORHOME Periodically weigh the motorhome at a public scale to determine axle loads The following procedure is suggested although any method recommended by the scale operator which correctly determines weight value is acceptable During all measurements it is important to keep the vehicle as level as possible To weigh your motorhome correctly measure the fully loaded vehicle axle by axle Where To Weigh Your and wheel position by wheel position You can find several certified public or com Motorhome mercial scales at moving and storage lots farm suppliers with grain elevators gravel pits recycling companies and
223. wner s manual for complete instructions or a qualified Manually Closing the service technician Automatic Awning Note The awning must be serviced by a qualified service technician e before attempting to open the awning after this procedure has been performed Please reference the owner s manuals and user s guide provided CABLE HOOKUP in your unit packet for detailed operating instructions for specific PHONE JACKS appliances ic Many RV parks have cable television and telephone jack connections available This will enable you to watch cable television in either the bedroom or the living area by utilizing the video selector box in the dash overhead It will also allow you to access a telephone jack hookup Simply plug in the TV cable or telephone cord into the outside cable and telephone receptacle 79 Controls and Operations GENERATOR COMPARTMENT arquis id WATER HEATER DOOR REFRIGERATOR DOOR 80 The generator compartment is located in a storage compartment on the side of the motorhome You can start stop the generator from outside the unit by pushing the start button in and holding it until you hear the generator start stop Refer to the Generator Owner s Manual for operating and maintenance information The furnaces used by Thor Motor Coach have electronic ignition and there is no need to access this panel except for service As with all appliances service is best left for your dealer To remove t
224. y questions and concerns should be addressed at that time The vehicle licensing laws vary from state to state Check with your state license bureau or nearest branch office for the requirements of your state Be sure to renew your license if it has expired or will expire during your trip Your motorhome is considerably larger and heavier than your car therefore certain precautions should be exercised A CDL license may not be required to operate your motorhome but Thor Motor Coach recommends you attend a CDL class to better understand the motorhomes driving and handling characteristics Thor Motor Coach wants your driving experience to be pleasant and enjoyable Talk to your insurance agent about the appropriate coverage for your motorhome Always carry your policy card Follow a consistent schedule of inspection and maintenance for your motorhome Your continuing safety and comfort depend on it This manual includes recommended maintenance intervals and instructions Adherence to these schedules will minimize the possibility of failure of any important system or part of your motorhome The time spent inspecting and maintaining your motorhome will provide you with many years of recreational pleasure Improper inspections or maintenance neglect may invalidate your Limited Warranty Proper loading is one of the most important considerations when traveling in a motorhome Your motorhome is built to withstand a certain maximum load Check the Feder
225. you through the proper steps to winterize your motorhome which is critical to maintain maximum durability over the life of your vehicle The fresh water storage tank is located inside a lower storage compartment The furnace will heat the fresh and waste water compartments In severe cold however it is wise to monitor the water temperature in the tank and take appropriate steps to drain and winterize if necessary In severe cold weather it may also be necessary to open the lower cabinet doors at night in both the bath and kitchen areas to keep warmer air circulating around the water fixtures DO NOT keep faucets open and water running in an effort to keep water lines from freezing This could result in the flooding of or damage to your motorhome If you are going to leave the coach unheated for any length of time in severe cold conditions it is best not to keep water in the fresh water system It may work best to carry cooking and drinking water with you in plastic jugs instead If you will be using your motorhome when conditions fall below the freezing level it may be necessary to protect the drainage system components from damage by the addition of an approved antifreeze solution as outlined on the product directions Any drain lines exposed to external air temperatures are especially susceptible to freezing and precautions should be taken to protect them from damage In the event that the motorhome is left for a period of time without th
226. ystem CS Note Refer to the Chassis Manufacturer s Owner s Manual for more information Pay careful attention to where and what type of flammable materials you store Certain storage areas are clearly labeled DO NOT STORE COMBUSTIBLE MATERIALS Examples of spark producing areas depending on the motorhome model are base kitchen cabinets front dinette base exterior refrigerator service compartment as well as refrigerator cabinet Please use discretion as to what potentially dangerous products your motorhome contains while traveling Be sure all canisters and bottle tops are secure and leak free The following checklist will assist your preparing the living quarters for a trip In winter make sure that the fresh water tank system is freeze protected Make sure that all storage items are secured and that heavy items are stored low so they do not fall e Check operation of stove and refrigerator e Check that you have proper paperwork such as owners registration card vehicle registration proof of insurance and valid driver s license When preparing for your trip always consider vehicle weight when loading the motorhome Exterior Checks Undercarriage Checks Operational Checks Pre Trip Checklist 39 On the Road Safety Use only recommended fuel as specified by the chassis AWARNING FUEL SYSTEM manufacturer Do not overfill the fuel tank but allow for expansion of fuel caused by rising temperatures by stopping

2015 Windsport Motorhomes Owner`s Manual by Thor

Contents

Download Pdf Manuals

Related Search

Related Contents