Home
UFAS Ecosense Anti-Scale Manual
Contents
1. INSTALLATION Place system in desired location close to water supply inlet keeping far enough away from walls and other obstructions to allow enough room for servicing the unit Install the anti scale system as an upflow filter The words UPFLOW INLET and DOWNFLOW INLET are molded into the in out head ADD MINERAL Remove the in out head by turning counter clockwise Plug the distributor tube to prevent mineral from entering and add the mineral Remove plug from the distributor and replace the in out head OPTIONAL BYPASS VALVE The use of a bypass valve is recommended for ease of maintenance The bypass valve connects to the in out head using nuts that only require hand tightening Install with red knobs in the upward position Press end of bypass valve with o rings into the in out head HAND TIGHTEN NUTS Avoid getting primer and solvent cement on any part of the o rings bypass valve or in out head DO NOT use pipe dope or any other sealant on threads Teflon tape is not necessary on the caps because of o ring seal DO NOT use Vaseline or other unacceptable lubricants on o rings A silicone lubricant may be used on black o rings FITTING ADAPTER V3007 1 PVC Male NPT elbow assembly comes standard with each unit Other options available see page 4 When assembling the installation fitting package inlet and outlet connect the fitting to the plumbing system first and then attach the nut split ring and o ring Heat from
2. soldering or solvent cements may damage the nut split ring and o ring Solder joints should be cool and solvent cements should be set before installing the nut split ring and o ring Avoid getting primer and solvent cement on any part of the O rings split rings bypass valve or in out head POSITION HANDLES ON OPTIONAL BYPASS Orient the red handles on the bypass to point as shown below by lifting red arrow handles straight off of bypass valve and replacing in the proper position In Out Head i a IN W OUT Distributor a Tube UPFLOW ON Assembly IN p Tank OUT UPFLOW OFF Mineral Turn bypass to the OFF position and connect to water pipes PLACING THE SYSTEM INTO SERVICE SLOWLY turn on water supply to the system If using the optional bypass valve slowly turn the bypass to the ON position Open nearest cold water faucet and allow water to run until clear Turn off faucet HOT WATER TANKS should be drained and flushed after the initial 30 90 days and again in a year to remove the fallen scale in the bottom of the tank caused by the descaling action of the system Follow the manufacturer s instructions when draining the tank FAUCET aerators and drains may plug occasionally as old scale is removed from your plumbing system and water heater Unscrew the aerators to clean the screens then reinstall You may also experience milky water while descaling is taking place DISHWASHERS with existing scale buildup
3. I __ LANCASTER__ WATER MREAIIMUEIN IC INSTALLATION OPERATING AND SERVICE MANUAL RESIDENTIAL ANTI SCALE SYSTEM WITH THE D1400 1 IN OUT HEAD L 7 UFAS 011 7 UFAS 016 L 7 UFAS 026 Congratulations on purchasing your new Lancaster Anti Scale System For servicing and future inspection purposes please file this booklet with your important documents In the event that you need assistance for servicing your system please first contact the professional contractor who installed the system OPERATING PARAMETERS Water pressure 12 125 psi Water temperature 34 F 120 F pH range 6 0 9 0 Maximum hardness 25 grains per gallon Hydrogen sulfide iron and manganese must be pretreated Maximum chlorine 3ppm De chlorination is recommended Do not exceed recommended flow rates Designed for intermittent flows For continuous flows please contact Lancaster Water Treatment Additional equipment will be needed if using a tankless water heater Consult factory Conservative life expectancy of the mineral is 5 years minimum based on meeting the above parameters PACKAGING All systems are shipped from the factory in cartons COMPONENTS Fiberglass mineral tank in out head installation fitting package distributor tube assembly mineral MODEL MAXIMUM MEDIA MINERAL TANK NUMBER SERVICE FLOW CU FT LBS DIA x HT 7 UFAS 011 10 GPM 0 11 5 0 7 UFAS 016 15 GPM 0 16 7 6 10x54 7 UFAS 026 25 GPM 0 26 12 7 13x48
4. on the sidewalls and washing arm may need to be treated by the use of a product like Jet Dry Dishwasher cleaner until all of the scale in the plumbing is dissolved You may find unusual initial spotting because of the de scaling taking place This system is not a water softener Low or phosphate free cleaning products are recommended to achieve optimum results INSTALLATION FITTING PACKAGE V 3007 1 PVC Male NPT Elbow Assembly Item No Quantity Part No Description 1 2 V3151 Nut 1 Quick Connect 2 2 V3150 Split Ring 3 2 V3105 O Ring 215 4 2 V3149 PVC Male NPT Elbow OPTIONAL V3007 02 1 Brass Sweat Assembly BP2000 Bypass Valve p Item No Quantity Part No Description Item No Quantity Part No Description 1 2 V3151 Nut 1 Quick Connect 2 2 V3150 Split Ring 1 2 V3151 Nut 1 Quick Connect 3 2 V3105 O Ring 215 2 2 V3150 Split Ring 4 2 V3188 Fitting 1 Brass Sweat 3 2 V3105 O Ring 215 4 2 V3145 Bypass 1 Rotor 5 2 V3146 Bypass Cap 6 2 V3147 Bypass Handle 7 2 V3148 Bypass Rotor Seal Retainer 8 2 V3152 O Ring 135 9 2 V3155 O Ring 112 f 10 2 V3156 O Ring 214 OPTIONAL V3007 02 Brass Sweat Assembly Item No Quantity Part No Description 1 2 V3151 Nut 1 Quick Connect 2 2 V3150 Split Ring 3 2 V3105 O Ring 215 4 2 V3188 01 Fitting Brass Sweat D1400 1 In Out Item No Quantity Part No Description OPTIONAL V3191 01 Vertical 1 1 D1400 Body Assembly Adapter Assembly 2 1 V3105 Distributor T
5. ube O Ring f TS 3 1 V3180 Body O Ring Item No Quantity Part No Description 4 1 D1203 Upper Basket not shown 1 2 3151 Nut 1 Quick Connect 2 2 V3150 Split Ring 3 2 V3105 O Ring 215 4 2 V3191 Vertical Adapter __LANCASTERW___ 07 10 WATER TREATMENT A Division of C B Tool Co 1340 Manheim Pike Lancaster PA 17601 3196 Phone 717 397 3521 Fax 717 392 0266 www lancasterwatertreatment com
Download Pdf Manuals
Related Search
Related Contents
USB 3.0 Flash Drive “C-Turn USB Type-C 3.0 / USB 3.0” MOEN P5050 Installation Guide オープンカウンター方式による見積合せの公示 ZIPP 404 FIRESTRIKE Table of contents Tripp Lite APSINT612 User's Manual ROMER ABSOLUTE ARM Benutzerhandbuch 取扱説明書 - 日立マクセル А300.068 / A300.151 nc integrator manual Copyright © All rights reserved.