GAS HEATER SERVICE MANUAL
Contents
1. 5 18 EAU y a Apjusueunm LAS Li urag 090705 x ssouendor LW urag 00070015 UD Qr sapu 51 pide 6 GE 00005 gt CAM chung TA Or weg 000 001 gt put wo c DOD DL lt lt un 6 CAM nag 090 015 TL uras 000701 24 22 ur 5 5 106 g MOPUIM 10 pap um 7 un yau pns spuma SORRY EST 501 20 UEIPEUET 29 Gas Heater Service Manual THELIN HEARTH PRODUCTS FIGURE 23 PARLOUR B VENT SIT VALVE SERIAL 543 OM Spill switch Safety shut off Pressure Test Taps am Power Cord Receptacle On left side ol stove Wall Thermostat Connection ee Label Indicating Type ol Gas Gas Line In NPL Gas Control Knob Off On Pilat Hi Lo Flame Adjust Gas Heater Service Manual 34 THELIN HEARTH PRODUCTS FIGURE 24 PARLOUR B VENT ROBERT SHAW VALVE SERIAL 100 542 Spill switch Safety shut off j Power Cond Receptacle On lati side of2. L1 EE o 1201431 60 Gas Heater Service Manual THELIN HEARTH PRODUCTS FIGURE 48 DIRECT VENT DIMENSIONS 90 Elbow I 90 Elhow 24 Section YS 70 5 0 PARLOUR Gas Heater Service Manual 61 THELIN HEARTH PRODUCTS APPENDIX SIT VALVE TROUBLESHOOTING GUIDE Gas Heater Repair Manual THELIN HEARTH PRODUCTS APPENDIX B CONVERSION KIT INSTRUCTIONS Gas Heater Repair Manual THELIN HEARTH PRODUCTS F CONVERSION KIT 2 2 PARLOUR 3000 B VENT WITH ROBERT SHAW VALVE Conversion from Natural Gas to Propane or Conversion from Propane to Natural Gas The Conversion Kit contains Regulator Pilot Orifice Main Orifice WARNING and Gas Type Labels This conversion kit shall be installed by qualified service agency in accordance with the manufacturer s 3 Optional Disconnect the end pipe and the flex line at the stove instructions and all applicable Shut off gas at the gas cock or shut off valve Open door and remove the log set Spread a blanket or a drop cloth on the floor and tip the stove over codes and requirements of the on its left side as you face the stove This step 1s not necessary but authority having jurisdiction it will make the job more visible and easier to do If the information in these 4 Take a 1 2 open ended wrench and from the bottom of the s
3. 1 Gas Heater Service Manual THELIN HEARTH PRODUCTS TABLE OF FIGURES Figure 1 Parlour B Vent Exterior Vent 1994 2001 en 12 Parlour Direct NELSON OR eean 15 Figure Direct Vent Extenor 14 Figure 4 Echo Venting PU HUS ei a 15 4 6 ed a a nn ee ec do 16 Fibre Echo Co Lincar Ple X SUSU a ee no then ele 16 Figure 7 Parlour Direct Vent Pipe naissent ent 17 Figure Onome Direct Vont Pipe 18 Figure 9 Pipe 19 Figure 10 Vent Termination tor B Vent and Direct 20 Figure 11 Parlour B Vent Laboratory Listing Label 1994 2001 21 Figure 12 Parlour Direct Vent Laboratory Listing Label 1995 2004 22 Figure 13 Parlour Direct Vent Laboratory Listing Label OMNI 2004H 23 Figure 14 Gnome Direct Vent Laboratory Listing Label 1995 2004 24 Figure 15 Gnome Direct Vent Laboratory Listing Label OMNI 2004 25 Figure 16 Echo Laboratory Listing Label 10 2 6 2007 4 asssieesisssixsbvee vo 26 Figure 17 Echo Laboratory Listing Labe
4. Plumber s tape 1 Pes 23 i connected to 2 0 Minimum 174 rise AR wall 7 or every 12 pf a Wall penetration all Strap equipment Le thimble ell 4 m 2 46 Elbows S 14 Snarklg Termination cap 4 minimum Haar protection Eb Air intake Go Linear adaptor Straight Pipa Gas Heater Service Manual 16 THELIN HEARTH PRODUCTS FIGURE 7 PARLOUR DIRECT VENT PIPE CONFIGURATION T PARLOUR HORIZONTAL VENT Horizontal Termination ue T Vertical Termination torm Collar lt gt Snorkde 14 387 lt gt bmjwal thimble C amp BV pipe length Gas Heater Service Manual 17 THELIN HEARTH PRODUCTS FIGURE 8 GNOME DIRECT VENT PIPE CONFIGURATION hara 51 Termination 45 7777 GNOME HORIZONTAL VENT Minimum Dimensions ninimum 0 6 Horizontal Termination storm Collar lt gt Snorkle 14 or 387 je pound support lt gt Ceiling Firestop bax wall gt thimble AN Cathedral Ceiling OM Support 3 DV pipe length YN K m GNOME HORIZONTAL VENT WITH SNORKLE 18 Gas Heater Service Manual THELIN HEARTH PRODUCTS FIGURE
5. Igniter A Red i Gas Control Knob Off On Pitot L Wall Thermostat Connection Label Indicating Type of Gas Gas Line In 3 8 N P T Hi Lo Flame Adjust Fan Air Passageway Right Side Gas Heater Service Manual 35 THELIN HEARTH PRODUCTS FIGURE 25 PARLOUR AND GNOME DIRECT VENT SIT VALVE Gas Heater Service Manual Red Button Pressure Test Taps Power Cord Receptacle On side of stove Label Indicating Type of Gas Gas Line In 3 8 N P T El Milltvalt Gas Control Knob Thermostat Oft On Pilot Terminal Connection here only Hi Lo Flame Adjust 36 THELIN HEARTH PRODUCTS FIGURE 26 PARLOUR AND GNOME DIRECT VENT ROBERT SHAW VALVE Power Cord Receptacle quo Un left side of stove x ai Vg ith Label Indicating Type of Gas Gas Line In y 3 8 Igniter Le Red Button Thermostat Van Terminal Connection here only Hi Lo Flame Adjust Gas Heater Service Manual 37 THELIN HEARTH PRODUCTS FIGURE 27 DIAGRAM OF ECHO CONTROL COMPONENTS SIT VALVE 500505095065 VIV DMX X XX XX Burner Switch 4 2 EN Button Thermostat Terminal Connection Hi Lo Rang
6. GAS HEATER TOELIN SERVICE MANUAL HEARTH PRODUCTS Please familiarize yourself with entire manual before attempting a repair or adjustment of the heaters zm m Ec eal T EE fag SPT a 1 Parlour Direct Vent Gnome Direct Vent Echo Direct Vent We recommend that our gas hearth products be installed and serviced by profes sionals who are certified in the U S by the National Fireplace Institute as Gas Specialists Thelin Co Inc 800 949 5048 530 273 1976 530 273 3707 TH REF GEN 200 Rev A THELIN HEARTH PRODUCTS TABLE OF CONTENTS I UTNE OG RET m 5 II IO 5 III 6 IV lt 6 oos E MEME MM 6 YE G VaVe MUON Borse NR UU 7 VIL Shutter Adjustment Correct Flame and Removal of Burner 7 SR _ ________ 9 QU ____ __ 9 Conversion Kits ea 9 AL DO 001101 _ 9 Gonera M riche RUNE 9 Warranty Replacement 10 Appendix SIT Valve Troubleshooting Guide eer rrt HER PIE FERA RR ERES 1 Appendix Conversion Kit
7. Unit to Backwall Mur arri re au po le Unit 16 Cornarwall Mur du coin au pole Minsmurm Width i a ava aree de Alcove Maximum Depth 2 nn deur Maximum de l Alcove Alconwe Minimum Haight 45 1145mm Hauteur Minimum da l Alc ve This appliance is equipped only for altitudes 0 2 000 0 510m in USA and 0 4 500 ft 0 1370m in Canada Cel appareil est quip pour le altitudes de 0 2000 10 610 aux Etats Unis et au Canada pour ks aflitudea de 0 4500 0 1370m Blower Electrical Rati valuation du Ventilateur lectrique 115 Volts 1 8 Amps 60 Hz FAN TYPE VENTED CI LATOR VENTILATEUR CIRCULATOIRE WARNI NG qu of this heater when not connected to a p rly installed and maintained ct venting system can result in injury and death Improper installation adjustment alteration service or maintenance can cause injury prope mage Refer to the information in the owner s manual provided with this appliance For assistance or additional information consult a qualified Installer service agency or the gas supplie Risk of electrical shock Disconnect power before servicing unit This appliance may be installed in a mobile hame and sleeping room pr the wall thermostat option is used This appliance is only for use with the type of gas indicated on the rating plate and may be installed in an 3 anently located manufactured mobile home where not prohibited by local codes See owner s
8. ECHO LABORATORY LISTING LABEL 3 7 2007 TO PRESENT AVERTISSEMENT Sct peu en un enpoisonnemeni au installation un unt or r paration o un entretien mal System in socordasce wit the s n oraninin gaz Emparn Vent 55 ad em instructions TE For una wit door with the appliance SS DO NOT REMOVE THIS LABEL HE PAS ENLEVER L TIQUETTE Gas Heater Service Manual 21 THELIN HEARTH PRODUCTS FIGURE 18 PARLOUR DIRECT VENT VERTICAL PIPE INSTALLATION AIR INTAKE RESTRICTOR DISKS 2 Restrictor plate Looking up inside stove under burner Pm TORTE Tur VIRTU UN 1 Remote burner 2 Locate restrictor plate 3 The higher the verticle pipe run the more the restriction See below 4 10 18 Ft 60 18 25 FL 70 16 30 Ft 80 Gas Heater Service Manual 28 THELIN HEARTH PRODUCTS FIGURE 19 PARLOUR DIRECT VENT STOVE WITH BURNER 2 Lead Thermopiie Thermocouple Spark Ignitar inside Pilot Housing Important Orifica Must fit securely into air ahutter hole T we Brass Coupler Nut ah 57 inlet Tube vo Gas Heater Service Manual 29 THELIN HEARTH PRODUCTS FIGURE 20 PYROTECH LOG PLACEMENT 1 Ember bed installed with brick panel 2 Install rear log 2 against brick panel and center right to left 3 Place sm
9. err tetra 46 Figure 35 Parlour B Vent Manifold Valve Robert Shaw Valve Bottom 48 Figure 36 Parlour and Gnome Stove with Burner Removed ss 49 Figure 37 Location or Echo Pilot Burners and Air SAUTER uns 50 Figure 38 Directions for Enabling Echo Door Opening and Securing Door 51 Figure 39 Delayed Echo Ignition Safety Shut Down ss 52 Figure 40 Location of Restrictor Disks in Parlour and Gnome 1995 2004 Figure 41 Location of Restrictor Disks in Parlour and Gnome 2004 54 Figure 42 Parlour Gnome Direct Vent Delayed Ignition Fan Mount Snap Disc Sensor 1995 2004 55 Figure 43 Delayed Ignition Safety Shut Down 20047 seine 56 Figure 44 Parlour B Vent Wiring Diagram Robert Shaw Valve 21 Gas Heater Service Manual 3 THELIN HEARTH PRODUCTS Figure 45 Parlour B Vent Wiring Diagram SIT Valve 58 E15ure 46 VCHBBS sc a 59 Figure 47 Direct Vent Wiring Diagram 1995 2004 60 Figure 48 Direct Vent OPE 61 Gas Heater Service Manual 4 THELIN HEARTH PRODUCTS INTRODUCTION Thelin Hearth Products manufactures three models of free standing gas hea
10. DISCONNECT POWER BEFORE SERVICING UNIT NOTE For use with glasa door DO NOT RUN POWER CORD UNDER APPLIANCE with the appliance only SEE INSTALLATION AND OPERATING INSTRUCTIONS Gas Heater Service Manual 21 THELIN HEARTH PRODUCTS FIGURE 12 PARLOUR DIRECT VENT LABORATORY LISTING LABEL 1995 2004 Thelin Co Grass Valley DO NOT REMOVE LABEL INSTALL AND USE ONLY IN ACCORDANCE ACTURER 5 INSTALLATION SLI AND OPERATINO INSTRUCTIONS 1 LOCAL AL BUR OF FIALS ABOUT le RESTRICTIONS INSTALLATION INSPECTION IN YOUR AREA Parlour 3000 BTU INPUT CE 3000 31 31 000 NG 31 000 NG MFG SERIAL No DVGas 28 000 LP Vented Gas Fireplace Heater Not For Use With Solid Fuel to 221 88 1988 CSA 2 33 MGB Vented Healers and 2 17 This gas heater ta not lor with air Hitara This unit is equipp ed for use with NATURAL GAS PROPANE L P 1 Input Land Orlice 5 acifications L P Minimum Clearance to Combustibles Maximum Input Rating BTU Hr 31 000 28 000 IN MM Minimum Input Raling BTU Hr 18 600 15 800 Unit to Sidewall 10 255mm Burner Orifice OMS 38 53 Uni to Backwatl 4 100mm Output Rating BTU Hr No Fan 23 560 21 000 Unit to Cornarwail 8 205mm Altitude 0 4500 0 137201 Alcove Minimum Width 50 1270mm Pressure Soeciticalions Alco
11. L P 0 input and Specifications L P Minimum Clearance to Combustibles Maximum Input Rating BTU Hr 33 000 36 000 IN CM Minimum Input Rating BTU Hr 18 500 21 600 Unit to Sidewall 15 0 3810 Burner Orifice OMS 52 36 Unit to Backwali 15 380 Output Rating BTU Hr No Fan 24 800 28 600 Unit to Cornarwall 3 0 17 50 Alcove Minimum Width 500 127 00 Alcove Maximum Depth 320 81 30 Mantle Above Unit 1 5 3 81 Halght 50 0 127 00 Manifold Pressure Setting 110 35 Manifold Pressure LO Setting in WC 27 17 Minimum Inlet Pressure In W C 11 5 5 5 _ Blower Electrical Rating 115 Volts 1 5 Amps 60 Hz FAN TYPE VENTED CIRCULATOR WARNING 1 Operation of this heater when not connected to a properly installed and maintained venting system tampering with the vent safety shutoff system can result in carbon mosoride poisoning and possible death hnproper installation adjustment alteration service or maintenance can cause injury or property damage Refer to the information in the owner s manual provided with this appliance For assistance or additional information consult a qualified installer service agency or the gas supplier Risk of electrical shock Disconsect power before servicing unit This heater must be properly connected to a venting system This heater 1 equipped with a vent safety shutoff system DANGER RISK OF ELECTRICAL SHOCK
12. conduils de chemin e gar Dura Vent GS et selon lea Inst u t For use with glass door certified with the appliance only REMARQUE Cet appareil ne peut tre utilis qu avec la porte certifi e DANGER RISK ELECTRICAL SHOCK DISCONNECT POWER BEFORE SERVICING UNIT 00 NOT RUN POWER CORD UNDER APPLIANCE KEEP L COMPARTMENT CLEAN SEE INSTALLATION AND OPERATING INSTRUCTIONS DANGER IL Y RISQUE DE HGE ELECTRIQUE DECONNECTEZ LE FIL ELE UE DE LA PRISE DE CONTACT AVANT LE SERVICE LOIGNEZ LE FIL LECTRIQUE DE L APPAREIL NE PAS FAIRE PASSER LE FIL LECTRIQUE AU DESSUS OU EN DESSOUS DE L APPAREIL S ASSURER QUE LE BRULEUR ET LE COMPARTIMENT DES COMMANDE SONT PROPRES VOIR LES INSTRUCTIONS D INSTALLATION ET D UTILISATION QUI ACCOMPAGNENT L APPAREIL DO MOT REMOVE THES PAS ENLEVER L TIQUETTE Kal Gas Heater Service Manual 25 THELIN HEARTH PRODUCTS FIGURE 16 ECHO LABORATORY LISTING LABEL TO 3 6 2007 AVERTISSEMENT Sct peu en un enpoisonnemeni au installation un unt or r paration o un entretien mal System in socordasce wit the s n oraninin gaz Emparn Vent 55 ad em instructions TE For una wit door with the appliance SS DO NOT REMOVE THIS LABEL HE PAS ENLEVER L TIQUETTE Gas Heater Service Manual 26 THELIN HEARTH PRODUCTS FIGURE 17
13. manual for details This appliance is nat convertible for use with other gases unless certified kit is used AV ERTISSEMENT Si cet appareil fonctionne sans tre raccord un syst me d vacuation correctement install et entretenu il peut en r sulter un empoisonnement au monoxyde de carbone et la mort Une installation un r glage une modification une r paration ou un entretien mal effectue peut causer des dommages mat riels ou des blessures Voir la notice de l utilisateur qui accompagne l appareil Pour de l aide ou des renseignements suppl mentaires consultez un installateur un technicien agr ou le fournisseur de gaz ya de d charge lectrique D cannectez le fil lectrique de la prise de contact avant le service T peut Etre uislis dans un mobile home ou des les chambers coucher condition que le thermostat mural soit utilize areil doit tre utilis uniquement avec le type de gaz indiqu sur la plagu e signal tique Cet appareil peut dans une maison pr fabriqu e ou mobile seulement install e demeure si les r glements locaux le permettent Voir la notice de l utilisateur pour plus de Cet appareil ne peut pas tre utilis avec d autres gaz sauf si une trousse de conversion c est fournie This healer must be property connected to a Simpson Dura Vent GS Venting System in accordance with tha manufacturer s Inetalleteor instructions a ave
14. rise Floor protection Floor protection Gas Heater Service Manual 12 THELIN HEARTH PRODUCTS FIGURE 2 PARLOUR DIRECT VENT EXTERIOR VENT Exterior Vent Minimum 1 4 rise for every 12 of run i amp thimble 4 minimum Floor protection Interior Vent Wind Guard Cap Ceiling penetration equipment DV pipe 4 minimum Floor protection Gas Heater Service Manual Wall penetration equipment exterior Ven SS with Snorkle Minimum 1 4 for every 12 of run Minimum 24 rise Wall penetration equipment 18 thimble 4 minimum Floor protection Attic installation sm Wind Guard Plumber s tape connected to 13 THELIN HEARTH PRODUCTS FIGURE 3 GNOME DIRECT VENT EXTERIOR VENT Exterior Vent Minimum 1 4 rise for every 12 of run thimble 4 minimum Floor protection Interior Vent Wind Guard Cap Root penetration lt equipment Ceiling penetration equipment DV pipe 1 minimum 4 minimum Floor protection Gas Heater Service Manual DV Termination cap Minimum 6 rise Wall penetration equipment xterior Ven Minimum 1 4 rise for every 12 of run DV Termination a Snorkle Minimum 6 rise Wall penetration equipment i e thimble 4 minimum Floor protection Attic installation Wind Guard
15. they will mate and align easily The correct flame for all burners is blue flame at the bottom and yellow at the top Too much orange means the stove 15 burning too rich If you notice wisps of black smoke coming off the tips of the flames this means the burner is starved for air and the air shutter should be opened to allow more air to flow with the gas It is important to watch the flame characteristics for some time after light up as the heat generated from the burner can change the flame pattern It usually takes 15 or 20 minutes for the flame pattern to stabilize THELIN HEARTH PRODUCTS RESTRICTOR DISKS Thelin Hearth Products Direct Vent stoves are equipped with incoming air Restrictor disks so you can fine tune the combustion air and prevent air turbulence at the pilot light For location of these disks see Figure 40 and Figure 41 To access the disks you must remove the burner as outlined in Section VII Air Shutter Adjustment Some scenarios that may require disk adjustment are as follows 1 If the Direct Vent heater is installed with a high vertical run in excess of eight 8 feet the incoming combustion air may create too much air turbulence and lift the pilot flame away from the thermocouple A quick drop out may result shutting off the burner and pilot light 2 A powerful prevailing wind aimed directly at the DV termination cap could result in too much incoming air and disturb the pilot flame Adj
16. 18 53 Orifice du d Manifold Pressure Setting 3 5 10 0 Pression du collecteur d Echappement HI pa Manifold LO Pression du collecteur d Echappement LO Minimum Inlet Pressure in WC ES 11 0 Pression Minimum de la Valve Minimum Clearance to Combustibles Espaces Libres Minimum Des Mat riaux Combustibles 10 255mm Mur de c t au 4 100mem Mur arri re au poble du com au po le Alcowe Minimum Width ur Minimum da Alcira Alcove Maximum Depth M Een ndeur Maximum de l Ac ve Alcove Minimum Height 80 1270mm Hauteur Minimum de l Alc ve This appliance is equipped only for altitudes 0 2 000 ft 0 510 in USA amd 0 4 500 ft 0 1370m in Canada Cet appareil eat quip pour les altitudes de 0 2000 510m aux Etats Unis et au pour lea alEitudes de 0 4500 0 1 370m Blower Electrical Hating Evaluation du Ventilateur leciri 115 Volts 1 5 Amps 80 Hz FAH TYPE VEHTED CULATORAENTILATEUA WARNI NG Operation of this heater when not connected to a properly installed and maintained direct venting system can result in injury and possible death Improper installation adjustment alteration service maintenance can cause injury or property damage Refer to the information in the owner s manual provided with this appliance For assistance or additional informat
17. 38 DIRECTIONS FOR ENABLING ECHO DOOR OPENING AND SECURING DOOR Se ee Se 1 Remove stove top to access glass door Figure 39 2 Unhook latch at bottom of door 3 Lift door up and out Gas Heater Service Manual 2 THELIN HEARTH PRODUCTS FIGURE 39 DELAYED ECHO IGNITION SAFETY SHUT DOWN Safety Release Latch Gas Heater Service Manual 22 THELIN HEARTH PRODUCTS FIGURE 40 LOCATION OF RESTRICTOR DISKS IN PARLOUR AND GNOME Restrictor disks under air intake tubes Gas Heater Service Manual 1995 2004 Air intake tubes behind fire wall 7 16 Nut Burner must be removed to access restrictor disks Loosen 7 16 nut and adjust disk to cover air intake tube opening The higher the vertical pipe run the more the restriction See Below 10 18 Ft 60 19 25 Ft 70 26 30 Ft 80 22 THELIN HEARTH PRODUCTS FIGURE 41 LOCATION OF RESTRICTOR DISKS IN PARLOUR AND GNOME 2004 2 Restrictor plate Looking up inside stove under burner 1 Remove burner 2 Locate restrictor plate 3 The higher the verticle pipe run the more the restriction see below 4 10 18 Ft 60 19 25 Ft 7096 16 30 Ft 80 Gas Heater Service Manual 54 THELIN HEARTH PRODUCTS FIGURE 42 PARLOUR GNOME DIRECT VENT DELAYED IGNITION FAN MOUNT SNAP DISC SENSOR 1995 2004 140 Snap Disc Sensor Delayed igni
18. Gaon codes and requirements of the authority having jurisdiction 4 With the burner removed you can access both orifices see Figure 35 and Figure 36 instructions is not followed 5 To change the pilot orifice and burner orifice you will need both exactly a fire explosion or 1 2 and 7 16 open end wrenches IMPORTANT Do not bend production of carbon or move the gas tube when you unscrew the burner orifice Make monoxide may result causing sure you re seal orifice threads with yellow tape and do not allow property damage personal tape to enter orifice opening The brass burner orifice 1s located injury or loss of life The on the right side of stove under burner on Parlour and in the qualified service agency is middle of stove on Gnome You will need both wrenches to responsible for the proper remove the burner orifice installation of this kit The 6 The pilot orifice is located on the left side and is in the middle of installation 15 not proper and the pilot assembly To remove pilot orifice use the 1 2 wrench complete until the operation and unscrew pilot housing and lower the tube down to remove of the converted appliance 1s orifice Place the new pilot orifice over the end of the pilot tube checked as specified in the and insert into the base of the pilot Screw the fitting on and manufacturer s instructions tighten down snugly with the 1 2 open end wrench See Figure supplied with this kit 35 and Figure 36 7 R
19. Gas Heater Service Manual x Air Supply Inlet D Restriction Zone Termination Not Allowed Do not install above a meter regulator assembly within 3 feet 90 cm horizontally from the centerline of the meter regulator Clearance to a service regulator vent outlet 6 minimum 1 8 m Clearance to non mechanical air supply inlet to a building or the combustion air inlet to any other appliance 12 minimum 30 cm Clearance to a mechanical air supply inlet 6 minimum 1 8 m Clearance above paved sidewalk or paved driveway located on public property refer to local code Clearance under open verandah porch deck or balcony 12 minimum 30 cm Maximum horizontal run 4 after 27 vertical rise THELIN HEARTH PRODUCTS FIGURE 22 VENT TERMINATION LOCATIONS OMNI 2004 rei zup zip pug E264 YA SOU ELA PE soup RH y 3 5 uymaauepig ce ur Bu join SUE LW y eu Ba peux SILET LE au j 10514 Fi Ie 95 Wii ui ani ch 104 HOUSE QU Ue uada 10 epum paz pu s Thug Mp usa ae pur ups Aj Pio 4 p TAJA DEL 1 ae my paroi end pe
20. ROTA eee ul 4 pur mms VEU 10 1 yamma IA Lg asp T Be C See seque Faj S wef 888 t AJUE E 1070 7 pa pepa aug gua pes H PID 27 LD spEJnoO 24 81 p si ijs tcd 1112 10 ge 0 SU pp pee oy dug psje num Jem Aadeud pates po Paved ROUES Jour o Ayer oY c OL WY un 6 88411 g p 7 Ce urag 00010015 yng O00 oS 06 un 6 our og mApurzitA si 00005 gt TAA OC urnas 0007001 gt put Cy c un3g lt 20 000701 saauxipdele 10 c uopsnquuos gg apu op E 474 10011 5 7 00070185 20 upang aui Aden da 9 mousse 10 unm Cy
21. can result in injury and possible death mproper installation adjustment alteration service or maintenance can cause injury or property damage Refer to the information in the owner s manual provided with this appliance For assistance or additional Information consult a qualified installer service agency or the gas supplier Risk of electrical shock Disconnect power before servicing This appliance be installed in mobile home and sleeping room provided the wall thermostat option is used FAN TYPE VENTED CIRCULATOR This heater must be properly connected to a Simpson Dura Vent GS Venting System DAMGEH OF ELECTRICAL SHOCK DISCONNECT POWER BEFORE SERVICING UNIT DO NOT RUN POWER CORD UNDER APPLIANCE NOTE For use wlth giass door certified KEEP BURNER AND CONTROL COMPARTMENT CLEAN with the appliance only SEE INSTALLATION AND OPERATING INSTRUCTIONS Gas Heater Service Manual 24 THELIN HEARTH PRODUCTS FIGURE 15 GNOME DIRECT VENT LABORATORY LISTING LABEL OMNI 2004 Model Mod le Gnome r n 5 HELIN Tested amp Beavertan Foyer au Gaz Evacuation Hat For Use With Solid Fuel 0 Oregon Pas Ufiliser Avec du Combustible Solide DATE OF MFG SERIAL OMMI Test Laboratories Inc OATEGUMAMUFACTURIER NUM RODES ME Thelin Company Inc Report Numero 220 5 02 5 12400 Loma Pica Grass Valley
22. fifty dollars 50 00 per occurrence and thirty five cents 0 35 per mile maximum one hundred miles round trip Gas Heater Service Manual Qualification for Warranty Performance Return product or defective part with proof of purchase and narrative description of defect together with your name and address freight prepaid to Thelin Hearth Products Warranty Division 12400 Loma Rica Dr Grass Valley CA 95945 Returned part or product will be repaired or replaced at Thelin Hearth Products option and will be returned to you freight prepaid as soon as practical but not later than 30 days after received Warranty Work All warranty work must be authorized by the factory in advance of the repair and an authorization number assigned warranty claim form must be completed and signed by both the repair person and the customer claims must be submitted to your distributor if you are buying products through a distributor In the event a unit has to be replaced the warranty claim form must be affixed to the unit with a description of the defect Only the factory can authorize a heater return Any replacement parts required may be obtained from Thelin Hearth Products and will require a purchase order Parts will be invoiced to the dealer account and credit will be 1ssued upon return to Thelin All returned parts must be accompanied by a warranty claim form If you have a warranty claim for installing parts use the same cl
23. for Gnome authority having jurisdiction 4 With the burner removed you can access the pilot orifice see If the information in these Figure 35 and Figure 36 instructions is not followed 5 To change the pilot orifice and burner orifice you will need a 1 2 SOON 2 de OG MONO Gi open end wrench and a 7 16 open end wrench IMPORTANT Do not bend or move the gas tube when you unscrew the burner orifice Make sure you re seal orifice threads with yellow tape and do not allow tape to enter orifice opening Brass burner orifice 18 088 9r nm Tine located on the right side of stove under burner on Parlour and in the middle of stove on Gnome You will need both wrenches to RESPONSI ior remove the burner orifice 9 808 6 The pilot orifice is located on the left side and 18 in the middle of EB eal the pilot assembly To remove pilot orifice use the 1 2 wrench and unscrew pilot housing and lower tube down to remove orifice Place the new pilot orifice over the end of the pilot tube and insert into the base of the pilot Screw the fitting on and tighten down snugly with the 1 2 open end wrench See Figure 35 and Figure 36 of the converted appliance 15 checked as specified in the manufacturer s instructions supplied with this kit 7 Remove the regulator from the valve see Figure 26 The regulator is the knob that adjusts the flame from H
24. visually prominent after the installation 15 complete Do not compromise on the placement of the shut off valve The following should always be strictly adhered to when hooking up the heater to the line 1 Use yellow Teflon gas tape when making connections to the stove and valve Do not allow pieces of tape or other materials to enter the pipe and valve openings Foreign matter in the pipe of valve openings will prevent the even flow of gas and create problems when the stove 1s burning 2 Purge the gas line of air before attempting to light the pilot Air pockets in the gas line will create problems when trying to light the pilot and burner Gas Heater Service Manual 3 If you are not certain of the gas pressure for the stove always test the pressure before lighting the pilot Thelin Hearth Products gas valves are equipped with pressure test ports see Figure 23 through Figure 26 for location of ports With a low cost manometer you can make sure the pressure is correct before lighting the pilot See Figure 11 through Figure 22 for the correct manifold pressure water columns for each stove and each fuel LP or natural gas 4 Always check connections for leaks before lighting stove We recommend a battery operated gas sniffer but liquid soap also works well for checking the connections for leaks V LOG INSTALLATION Figure 30 through Figure 33 show the correct placement of the logs in the stoves Inc
25. 9 ECHO PIPE CONFIGURATIONS ECHO HORIZONTAL VENT Gas Heater Service Manual ECHO VERTICAL VENT 19 THELIN HEARTH PRODUCTS FIGURE 10 VENT TERMINATION FOR B VENT AND DIRECT VENT Lowest Discharge Opening Listed Direct Vent Cap Listed Direct Gas Vent _ Roof Pitch is X 12 H Min Minimum Height from Roof to Lowest Discharge Opening Roof Pitch H Ft Fatto G T 1 0 Over o 1 25 Over 7 12 to 8 12 1 5 Over 8 12 to 9 12 2 0 Over 9 12 to 10 12 2 5 Over 10 1210 11 82 3 25 Over 11 12 4 0 Over 12 12 to 14 12 5 0 Over 14 12 to 16 12 6 0 Over 16 12 to 8 2 7 0 Over 1224020082 56 7 5 Over 20 12 to 2 LES 8 0 Gas Heater Service Manual THELIN HEARTH PRODUCTS FIGURE 11 PARLOUR B VENT LABORATORY LISTING LABEL 1994 2001 Thelin Co Grass Valley CA THIS LABEL ss USE ONLY IN ACCORDANCE WITH MANUF INSTALLATION ACTURE AND OPERATI INSTRUCTIONS CONTACT LOCAL BUILDING OFFICIALS ABOUT RESTRICTIONS INSTALLATION INSPECTION IN TOUR AREA MAX BTU INPUT 7 F EE DATE OFMFG SERIAL ie Heater Not For Use With Solid Fuel Tested to ANSI Z21 88 1988 CSA 2 23 08 Vented Gas Fireplace jc and CAN CGA 2 17 This venied gas heater la for use wilh air Miara This unit Is equipped for use with NATURAL GASO PROPANE
26. 95945 Tested ba Test ac ANS 221 886 2003 5 2 33b 2003 Venied Gas Fireplace Heaters and 2 17 This vented gas heater for with air filters Ne pas utiliser de filtra alr ce foyer au gaz vacuation This iance must be installed in accordance with local codes any the National Fuel Gas Code ANS 2223 1 8 ar Gas and Propane Installation Codes CSA 148 1 installer l apparesi selon les codes ou reglements locaux ou en l absence de tels r glements selon les codes d installation ANSI Z223 UNFPA 54 National Fuel Gas Code ou 149 1 en vigueur This unit equipped for use with Pour nous cet apparell est equip avec O NATURAL GAS PROPANE L P Input and Orifice Specifications Spe cifications de l arriv e de gaz et des orifices N G L P Maximum Input Rating T 22 000 21 500 Puissance Minimum Input Rating BTU H 13 200 12 900 Puissance Mir BTU Hr Burner Orifice DMS 41 55 Orifice du Br leur OMS Manifold Pressure Setting in W C is 10 0 Pression du collecteur d HI WIC Manifald Pressure LO Seins n 1 7 3 5 Pression du collecteur em ep TU LOF Minimum Inlet Pressure fin We IA 5 5 na Pression Minimum de la Valve po W C Minimum Clearance to Combustibles Espaces Libres Minimum Des Mat riaux Combustibles Unit to Sidewall 205mm de cot au
27. AM SIT VALVE 10014 aA EA 115 10150 WELTI TOA n 118 1 A A pay uams 11145 Ci anng HOA 021 10 38uu07 18 I 4 anhesds 188 02814 104407 paads 1aMo g 919 UE 3510 oway suum mM 58 Gas Heater Service Manual THELIN HEARTH PRODUCTS FIGURE 46 ECHO VENTING CHART maximum vertical max horizontal run termination 10 after minimum 30 b vertical rise of 4 minimum vertical minimum centerline 54 25 vertical S termination max horizontal 12 with min vertical of 24 14 snorkel rear exit centerline maximum horizontal directly off stove ERR 24 x 050 09055055 XX XXX Gas Heater Service Manual 59 THELIN HEARTH PRODUCTS FIGURE 47 DIRECT VENT WIRING DIAGRAM 1995 2004 paads samog X3JEIg yy WOA 021 02 pup 75 Opt _ sisseyg L 101239000 SUM af 229 0 EL 11 ong nig 129005 v uet 42019 yis
28. ARTH PRODUCTS FIGURE 14 GNOME DIRECT VENT LABORATORY LISTING LABEL 1995 2004 Thelin Co Grass Valley CA DO NOT REMOVE THIS LABEL INSTALL AND USE ONLY IN ACCORDANCE WITH MANUFACTURER S INSTALLATION AL AND OPERATING INSTRUCTIONS CONTACT LOCAL BUILDING OFFICIALS ABOUT be d RESTRICTIONS AND INSTALLATION INSPECTION YOUR AREA ETE No 29 000 NG BTU INPUT Vented Fireplace Heater Not For Use With Solid Fuel to ANS Z21 88 1888 CSA 2 33 98 Vented Gas Fireplace Heaters ard 2 17 This verted gas heater not for with aly This unit is equipp od for use with NATURAL GASCO PROPANE L P Input and Orifice LP Minimum Clearance to Combustibles Maximum Input Rating BTU Hr 22 000 21 500 Minimum Input Rating BTU Hr 13 200 12 900 Unit to Sidewall B 205mm Burner DMS 43 55 Unit to Backwall 4 100 Output Rating BTU Hr No Fan 17 180 16 985 to Cornerwall B 205mm Altitude 4500 ft 0 1372 Alcove Minimum Width 45 1145mm Specitications Alcove Maximum 27 685mm Manifold Pressure HI Setting In W C 35 1140 Alcove Halght 45 T145mm Manifold Pressure LO Setting im W C 1 7 2 7 Minimum Pressure In 8 5 11 5 Blower Electrical Rating 5115 Volts 1 5 60 Hz WARNING Operation of this heater when not connected to a properly installed and maintained direct venting system
29. Cap Plumber s tape connected to wall strap 2 45 Elbows Wall strap 14 THELIN HEARTH PRODUCTS FIGURE 4 ECHO VENTING REQUIREMENTS Exterior Vent Exterior Vent _ paie with Snorkle OW D 8 Minimum 1 4 rise Minimum 1 4 rise for every 12 of run for every 12 of DV Termination 4 Snorkle DV Termination cap Minimum 24 rise Wall penetration equipment Le thimble Minimum 24 rise Wall penetration equipment i e thimble Wall penetration equipment i a thimble 4 minimum 4 minimum 2 tus se T m af M E a E zs m i uta E 25 a x Fa pta y 2 n Ci i i ape e 05 inf 2 rds en at Em Floor protection 4 Floor protection Interior Vent a Wind Guard Cap Roof penetration equipment Ceiling penetration equipment DV pipe 4 minimum protection Gas Heater Service Manual 15 THELIN HEARTH PRODUCTS FIGURE 5 ECHO VENTING REQUIREMENTS Direct Vent Attic Installation Er Wind Guard Cap eee
30. Figure 47 In conclusion we would like to remind you that Thelin Hearth Products can provide support via telephone Service personnel are welcome to use our toll free number 800 949 5048 THELIN HEARTH PRODUCTS Warranted for five years from the date of retail purchase against defects 1 workmanship to include heater cabinet and body Warranted for one year from date of retail purchase to include drive mechanism and electronic components Solely for the benefit of the original purchaser Retain your dated sales receipt as proof of purchase Covered Replacement of defective parts and labor and product return to consumer Not Covered Door glass plating and gasket Damages caused by abuse or failure to perform normal maintenance and any related expense This warranty shall not apply to any defect malfunction or failure to conform with the watranty provisions if caused by damage not resulting from defect or malfunction due to unreasonable use by purchaser Consequential damages incidental damages or incidental expenses including damage to property Some states do not allow the exclusions or limitation or incidental consequential damages so the above limitation or exclusion may not apply to you This warranty gives you specific legal rights which vary from state to state Authorized Warranty Payment Thelin Hearth Products will credit the distributor dealer account the sum of
31. Hearth Products option and will be returned to you freight prepaid as soon as practical but not later than 30 days after receipt To register your Thelin Hearth Products warranty complete and sign the enclosed warranty card and mail it within ten 10 days from date of purchase OTHER RIGHTS This warranty provides you with certain legal rights You may have additional rights which vary from state to state in regard to this warranty AUTHORIZED WARRANTY PAYMENT Thelin Hearth Products will credit the dealer account the sum of fifty dollars 50 00 per occurrence and thirty five cents 0 35 per mile maximum one hundred 100 miles round trip Thelin Hearth Products reserves the right to change without notice product features or specifications described Gas Heater Service Manual 11 THELIN HEARTH PRODUCTS FIGURE 1 PARLOUR B VENT EXTERIOR VENT 1994 2001 xlerior Vent Nm m ST Roof penetration SIN RK Minimum 5 ft MS vent height 1 1 Minimum Wall penetration of stove 4 Type B vent ph Sunnart st _ equipment Support strap 1 thimble Minimum 1 4 rise for every 12 of run Minimum 24 rise Floor protection Exterior Vent Chase Sub Zero Climate ee Roof penetration equipment Ceiling penetration pisi of stove 4 Type B vent Wall penetration of oe Wall strap T Minimum equipment Tee i 8 thimble _ Tee cap Minimum 24
32. TH PRODUCTS FIGURE 35 PARLOUR B VENT MANIFOLD VALVE ROBERT SHAW VALVE BOTTOM VIEW Air Shutter Gas Orifice Pressure Test Outlet Gas Line Factory installed orifices are as follows Natural Gas 36 up to 4 500 elevation LP Gas 52 up to 4 500 elevation Recommendation If installing at higher altitudes Thelin Hearth Products recommends at the discretion of the installer Natural Gas 37 5 000 to 7 000 elevation LP Gas 53 5 000 to 7 000 elevation REMEMBER The size of the orifice hole should be reduced the higher the elevation Gas Heater Service Manual 48 THELIN HEARTH PRODUCTS FIGURE 36 PARLOUR AND GNOME STOVE WITH BURNER REMOVED 90111 Seg jn 85818 epu eaquc X Fil UISNGH 10814 apsu Saug weds ajdnoaouud 11 40 49 Gas Heater Service Manual THELIN HEARTH PRODUCTS FIGURE 37 LOCATION OF ECHO PILOT BURNERS AND AIR SHUTTER ge ee CUM Cm m CR Burner Quick Drop Out Thermopile Thermocouple Spark Igniter Pilot Detail NOTE Flame must touch thermopile Air Shutter Gas Heater Service Manual 50 THELIN HEARTH PRODUCTS FIGURE
33. aim form and authorization number Please note No credit will be issued until a warranty form with an authorization number 15 received along with the defective part 10 THELIN HEARTH PRODUCTS PELLET amp GAS HEATER LIMITED WARRANTY Thelin Hearth Products warrants the Pellet amp Gas Heater against defects in material and workmanship for a period of five 5 years from the date of purchase with the exception of the electrical components gaskets logs moving parts gas valve and control and burner which are warranted for a period of one 1 year from date of purchase Glass gasketing gold plating and paint are not covered by the warranty This warranty does not include service call cost or any other additional charges Call the dealer to arrange for all warranty work Exclusions to this limited warranty include Injury due to malfunction of the product loss damage defect failure to function due to an accident negligence misuse improper installation alteration or adjustment of the manufacturer s settings lack of proper and regular maintenance damage incurred while in transit or an act of God Only the original purchaser of this heater 15 covered by this limited warranty If the unit is used for commercial purposes it is excluded from this warranty The warranty is automatically voided if the unit s serial number has been removed or altered any way or the wrong fuel has been used No dealer distributor or similar per
34. all log 3 with the notch on the 4 Rest the log 4 on top of the small bottom setting of the ledge indicated in log and rear log with the right end the illustration against the firebox and the left end against the brick panel and crotch of the rear log Gas Heater Service Manual 30 THELIN HEARTH PRODUCTS FIGURE 20 PYROTECH LOG PLACEMENT CONTINUED 5 Place the front log 5 against the log in the notch shown in the illustration with the bottom end up against the lip of the door opening Note The bottom of the log has the taper cut Gas Heater Service Manual 31 THELIN HEARTH PRODUCTS FIGURE 21 DIRECT VENT GAS HEATER VENT TERMINATION LOCATIONS 1994 Termination Cap Gas Meter The horizontal run must have a 1 4 rise on an exterior wall and must meet all local and national building codes and must not be easily blocked or obstructed Termination clearances are as follows see Figures 2 and 3 A Clearance above ground verandah porch deck or balcony 12 minimum 30 cm B Clearance to a window or door that may be opened 9 minimum 23 cm C Vertical clearance to a ventilated soffit located above the termination within a horizontal distance of 2 feet form the centerline of the termination 18 minimum 46 cm D Clearance to an unventilated soffit 12 minimum 30 cm Clearance to an outside corner 9 23 cm F Clearance to an inside corner 9 23
35. d shut off the burner Both Direct Vent stoves are equipped with the safety door The stove can not be restarted until the door 15 reset the switch 15 activated and the cause of the explosion 15 determined To access this door you must remove the outer wrap on the stove Be careful when removing the shield as the wires to the fan and sensors are attached to the inner side of the shield These can be easily removed once the shield 15 loose from the body of the stove The gas valve pilot assembly and gas lines should all be checked before re assembly THELIN HEARTH PRODUCTS XII GENERAL MAINTENANCE At least once a year the following maintenance should be performed on the gas heaters l Remove log set and inspect burner for soot build up and or blocked holes in the burner tubes Excessive soot build up indicates an air fuel ratio problem and means some adjustment 15 necessary Remove the outer wrap and inspect the fan for dust and lint build up Pay particular attention to the squirrel cage fan blades as these can accumulate dust and lint affecting the performance of the fan Clean as necessary Gas Heater Service Manual 3 The wire harness and control knob connections should be checked for wear and tear Make sure all wires are pliable and not hard or brittle Connections should be secure and tight Replace wires and connectors as needed Remember all wires are color coded as per wiring shown in Figure 44 through
36. e Gas Heater Service Manual 38 THELIN HEARTH PRODUCTS FIGURE 28 DIAGRAM OF ECHO CONTROL COMPONENTS AIR RESTRICTOR AIR RESTRICTOR es 7 2 0 9 9 9 2 9 5 0 ms Air Restrictor Adjustment Lever 15 Open 2 25 Open 3 85 Open Air Restriction Vertical Pipe Run Position 1 Use Only When 2 or More Elbows in Pipe Run Position 2 I2 Ft Position 3 2 Ft Fan Option replaces shroud Back Shroud Gas Heater Service Manual 39 THELIN HEARTH PRODUCTS FIGURE 29 PARLOUR B VENT AIR SHUTTER AND MANIFOLD VALVE SIT VALVE BOTTOM VIEW 1 8 Pipe Fitting N P T canbe removed 7 for pressure inim Gas orifite Gas Line 1 Bottom of Valve of manifold 3 Mounting Screws Factory installed orifices are as follows Natural Gas 36 up to 4 500 elevation LP Gas 52 up to 4 500 elevation Recommendation If installing at higher altitudes Thelin Hearth Products recommends at the discretion of the installer Natural Gas 37 5 0007 to 7 000 elevation LP Gas 53 5 000 to 7 000 elevation REMEMBER The size of the orifice hole should be reduced the higher the elevation Gas Heater Service Manual 40 THELIN HEARTH PRODUCTS FIGURE 30 PARLOUR B VENT LOG PLACEMENT AND AIR SHUTTER ADJUST Logs are placed above burners Burners Pilot light Vie
37. e air shutter opening 43 THELIN HEARTH PRODUCTS FIGURE 33 ECHO STOVE WITH LOG amp EMBER TRAY PLACEMENT Following 15 a step by step procedure for installing the Echo log set 1 Remove top lid and top from stove 2 Install Log 1 as per picture below Unhook glass door latch at bottom of stove and lift out glass door Gas Heater Service Manual 44 THELIN HEARTH PRODUCTS ECHO STOVE WITH LOG PLACEMENT CONTINUED 7 Install Ember Basket as per picture below 8 Install Embers as per picture below Make sure all logs are secure and not impinging on the burner tubes Re install glass door top and lid You are ready to light your Echo Gas Heater Service Manual 45 THELIN HEARTH PRODUCTS FIGURE 34 ECHO STOVE WITH LOG amp EMBER TRAY PLACEMENT Following 16 a step by step procedure for installing the Echo log set 1 Remove top lid and top from stove 2 Install Log 1 as per picture below Unhook glass door latch at bottom of stove and lift out glass door m P LJ L 38 p Ta EL 1 4 mm f 5 T oot LE x rer i 3 L 1 A a 2 Gas Heater Service Manual 46 THELIN HEARTH PRODUCTS FIGURE 34 ECHO STOVE WITH LOG amp EMBER TRAY PLACEMENT CONT D 7 Make sure all logs are secure and not impinging on the burner Re install glass door top and lid You are ready to light your Echo Gas Heater Service Manual 47 THELIN HEAR
38. e knob that adjusts the flame from Hi to Lo and 15 attached to the valve with two screws as shown in Figure 24 The regulator and rubber gasket will come out together Make sure you put the new gasket on the new regulator and screw the new regulator onto the valve it will only go one way 9 Make sure you replace labels on the back of the stove and on the valve Labels are furnished with the conversion kit Note These instructions are for either the LP or natural gas valves and orifices If you mix up the parts you can identify the LP parts in the following way the LP orifice has the smaller hole The LP regulator is marked and has the numbers 11 0 and 2 7 stamped on it The natural gas regulator 15 unmarked Gas Heater Repair Manual B 2 THELIN HEARTH PRODUCTS PARLOUR 3000 DIRECT VENT AND GNOME DIRECT VENT Conversion from Natural Gas to Propane or Conversion from Propane to Natural Gas ROBERT SHAW The conversion kit contains Regulator Pilot Orifice Main Orifice WARNING and Gas Type Labels 1 Shut off gas at the gas cock or shut off valve Tor ane ve installed by qualified 2 Open door and remove the log set service agency in accordance 3 To change orifices on the Direct Vent stoves you will have to with the manufacturer s remove the burner by removing two 1 4 x 20 hex bolts located on instructions and all applicable either side of the burner see Figure 35 for Parlour and Figure 36 codes and requirements of the
39. emove the regulator from the valve see Figure 25 The regulator 1 the knob that adjusts the flame from Hi to Lo and it is attached to the valve with two screws as shown in Figure 25 The regulator and rubber gasket will come out together Make sure you put the new gasket on the new regulator and screw the new regulator onto the valve it will only go one way 8 Make sure you replace the labels on the back of the stove and on the valve The labels are furnished with the conversion kit Note These instructions are for either the LP or natural gas valves and orifices If you mix up the parts you can identify the LP parts in the following way the LP orifice has the smaller hole The LP regulator is marked and has the numbers 11 0 and 2 7 stamped on it The natural gas regulator 15 unmarked Gas Heater Repair Manual
40. er than one 90 degree elbow 3 Long vertical runs over 8 feet on the Direct Vent models can create turbulence problems with the incoming combustion air and these installations may require adjustment of the Restrictor disks see Section VII If the pilot flame pulls away from the thermocouple a drop out will occur and the burner will go out This symptom can be created by too much incoming combustion air 4 115 extremely important that all interlocking connections are locked properly and securely Failure to lock sections together correctly will result in a mixture of combustion air and exhaust gases and the fire will lift off of the burner and go out THELIN HEARTH PRODUCTS CLEARANCES Figure 11 through Figure 22 will give you the proper clearances to combustible surfaces both for the stove and surrounding areas including walls windows porches etc The Parlour B Vent requires a hearth pad extending the full width and length of the heater The Direct Vent stoves do not require a hearth pad but it is highly recommended on carpets rugs or any other soft material A hearth pad on these surfaces will give stability to the heater and prevent tipping Follow the instructions carefully when placing the stove near drapes furniture and other combustible material IV GAS HOOK UP You are required to have a shut off valve immediately preceding the flex gas line to the stove This valve should be easily accessible and
41. eut tre install dans une maison pr fabriqu e ou mobile seulement install e demeure si les r glements locaux le permettent Voir la notice de l utilisateur pour plus de renseignements Cet appareil ne peut pas tre utilis avec d autres gaz si une rousse de conversion est fournie This healer must be properly connected 1o Simp Dura Vent GS Venling System in accordance wilh Ihe manulacturer a installation instruction Cel appareil de chauffage doit tre correctement install avec les conduits de chemin e gaz Simpson Dura Vent GS ot selon les instructions d installation du fabricant NOTE use with glass door certified with the appliance only REMAROUE Cet appareil ne peut utilised qu avec la porte vitr s certifi s DANGER RISK OF ELECTRICAL SHOCK DISCONNECT POWER BEFORE SERVICING UNIT DO NOT POWER CORD UNDER APPLIANCE KEEP BURNER AND CONTROL COMPARTMENT CLEAN SEE INSTALLATION AND OPERATING INSTRUCTIONS DANGER IL Y A RISQUE DE D CHARGE LECTRIQUE D CONNECTEZ LE FIL LECTRIQUE DE LA PRISE DE CONTACT AVANT LE SERVICE ELOIGNEZ LE FIL ELECTRIQUE DE L APPAREIL NE PAS FAIRE PASSER LE FIL ELECTRIQUE AU DESSUS OU EN DESSOUS DE L APPAREIL S ASSURER QUE LE BRLILEUR ET LE COMPARTIMENT DES COMMANDE SONT PROPRES VOIR LES INSTRUCTIONS D INSTALLATION ET D UTILISATION QUI ACCOMPAGNENT L APPAREIL DO NOT REMOVE THIS LABEL NE PAS ENLEVER L TIQUETTE Gas Heater Service Manual THELIN HE
42. he appliance only SEE INSTALLATION AND OPERATING INSTRUCTIONS Gas Heater Service Manual 22 THELIN HEARTH PRODUCTS FIGURE 13 PARLOUR DIRECT VENT LABORATORY LISTING LABEL OMNI 2004 HEL IN o Nat For Use With Solid Fuel Pas LHiliger Avec du Combustible Solide Tu Beaverton Oregon USA c z 4 OMNI Tast Laboratorien Inc wmm HERI 2 Company Inc eee nen Tested ta Tast ANSI Z21 885 2003 C 5A 2 330 2003 Vented Gas Fireplace Healers and 2 17 This gas heater is mat for use with air filters pas utiliser de filtre air avec ce foyer au gaz evacuation Th s appliance must be installed in accordance with local codes if any none follow the National Fuel Gas Code ANS 2223 1 HFP 54 Nabural Gas and Propane Installation Codes CSA B14B 1 Installer l appareil selon les cades au r glements locsux en l absence de tela reglements selon les codes d installation ANSI 2223 UNFPA 54 National Fuel Gas Code ou CS5A B149 1 an vigueur Th s unit is equipped use wih Pour nous cet appareil est equip avec DINATURAL GAS Input and Orifice Specifications Specifications de l arriv e de gaz et des orifices Maximum Input Rating BTU Hr 31 000 28 000 Evalue BTU Hr Minimum input B TLUHr 18 600 15 800 Puissance Evalude Min BTU Hr Burner Orifice DMS
43. i to Lo and it is attached to the valve with two screws as shown in Figure 26 The regulator and rubber gasket will come out together Make sure you put the new gasket on the new regulator and screw the new regulator onto the valve it will only go one way 8 Make sure you replace labels on the back of the stove and on the valve Labels are furnished with the conversion kit Note These instructions are for either the LP or natural gas valves and orifices If you mix up the parts you can identify the LP parts in the following way the LP orifice has the smaller hole The LP regulator is marked and has the numbers 11 0 and 2 7 stamped on it The natural gas regulator is unmarked Gas Heater Repair Manual THELIN HEARTH PRODUCTS Ai CONVERSION KIT PARLOUR DIRECT VENT GNOME DIRECT VENT PARLOUR VENT AND ECHO Eg B Conversion from Natural Gas to Propane Conversion from Propane to Natural Gas The conversion kit contains Regulator Pilot Orifice Main Orifice and Gas Type Labels 1 Shut off gas at the gas cock or shut off valve This conversion kit shall be 2 Open door and remove the log set installed by Es qualified 3 To change orifices on the Direct Vent stoves you will have to E remove the burner by removing two 1 4 x 20 hex bolts located on us ne instructions and all applicable either side of the burner see Figure 35 for Parlour and Figure 36 for
44. ion consult a qualified installer service agency or the qas supplier Risk of electrical shock Disconnect power before servicing unit This appliance may be installed in a mobile home and sleeping room provided the wall thermostat option is used This appliance is only for use with the type of gas indicated on the rating plate and may be installed in an aftermarket permanently located manufactured mobile home where not prohibited by local codes See owner s manual for details This appliance is not convertible for use with other gases unless a certified kit is used AVE RTISSEMEN appareil fonctionne sans tre raccord un systeme d vacualion 1 correctement install et entretenu il peut en r sulter un empoisonnement au monoxyde de carbone et la mort Une installation un r glage une modification une r paration ou un entretien mal effectue m causer des dommages mat riels ou des blessures Voir la notice mper ge Pour de l aide ou des renseignements suppl mentaires consultez un installateur un technicien agr ou le fournisseur de gaz a risque de d charge lectrique D connectez le fil lectrique de la prise de contact avant le service m Cet appareil peut tre utilis dans un mobile home au des les chambers coucher condition que le thermostat mural soit utilize Cet appareil doit tre utilis uniquement avec le type de gaz indiqu sur la plaque signal tique Cet appareil p
45. l 3 7 2007 to Present 21 Figure 18 Parlour Direct Vent Vertical Pipe Installation Air Intake Restrictor Disks 28 Figaro 499 Direct Vent 29 Feur 20 Los 30 Figure 21 Direct Vent Gas Heater Vent Termination Locations 1994 2004 32 Figure 22 Vent Termination Locations OMNI 200417 petu ee ere 33 Figure 23 Parlour B Vent Sit Valve Serial 543 OM 34 Figure 24 Parlour B Vent Robert Shaw Valve Serial 100 542 35 Figure 25 Parlour and Gnome Direct Vent SIT Valve 1 0 01400004 8 4 44 36 Figure 26 Parlour and Gnome Direct Vent Robert Shaw Valve ss 37 Figure 27 Diagram of Echo Control Components SIT Valve ss 38 Figure 28 Diagram of Echo Control Components Air Restrictor seen 39 Figure 29 Parlour B Vent Air Shutter and Manifold Valve SIT Valve Bottom View 40 Figure 30 Parlour B Vent Log Placement and Air Shutter Adjust sese 4 Figure 31 Parlour Direct Vent Log Placement and Air Shutter Adjust 42 Figure 32 Gnome Direct Vent Log Placement and Air Shutter Adjust 43 Figure 33 Echo Stove with Log amp Ember Tray Placement 44 Figure 34 Echo Stove with Log amp Ember Tray Placement
46. orrect log installation will create burn problems sooting and clogged burners Important points to remember when checking log placement are as follows 1 Each stove has a front and rear log make sure the front log and rear log are in their proper places Consult diagrams if you not sure 2 Make certain the logs do not impinge upon the flame flow Logs must not be placed over the flame so as to obstruct the flame pattern Make sure the burners can be seen through the log openings 3 Ifthe logs are installed correctly you will be able to see the pilot when it 1s lit This 15 important on start up as you will be able to watch the pilot as 1t lights THELIN HEARTH PRODUCTS VI GAS VALVE MILLIVOLT CHECK Thelin Hearth Products uses two gas valves on their heaters Early stoves from 1994 to 1998 have Robert Shaw valves All current models are equipped with SIT valves Diagrams for both these valves are attached see Figure 23 through Figure 26 The diagrams show you the location of the Piezo lighter the Hi Lo flame adjustment knob and the On Off Pilot knob In addition the pilot flame adjustment set screw can be located by viewing these diagrams Study them carefully as the location of each component 15 exactly like they are on the valve itself Checking for proper millivoltage Attached as Appendix A to this manual is the SIT valve troubleshooting guide This guide will take you step by step through the adj
47. son has the authority to represent or warrant Thelin Hearth Products beyond the terms contained in this limited warranty Thelin Hearth Products assumes no liability for such representations or warranties THIS LIMITED WARRANTY IS THE ONLY WARRANTY SUPPLIED BY THELIN HEARTH PRODUCTS UNLESS AN EXTENDED WARRANTY HAS BEEN PURCHASED THE MANUFACTURER OF THE UNITS ALL OTHER WARRANTIES WHETHER EXPRESS OR IMPLIED ARE HEREBY EXPRESSLY DISCLAIMED AND PURCHASER S RECOURSE IS EXPRESSLY LIMITED TO THE WARRANTIES SET FORTH WITHIN HOW TO USE THIS WARRANTY If you find this unit to be defective in material and or workmanship within a period of five 5 years from the date of purchase contact your local dealer from whom you purchased the heater All warranty work must be authorized by the factory in advance of repair and an authorization number assigned A warranty repair claim form must be signed by both the dealer and the customer In the event your dealer 18 no longer in business or you cannot locate a dealer you may do the following Call or write factory giving proof of purchase information and a narrative description of the defect together with your name and address Only the factory can authorize a heater or part return Upon authorization by factory return defective heater or part freight prepaid to Thelin Hearth Products Warranty Division 12400 Loma Rica Drive Grass Valley CA 95945 Returned part or product will be repaired or replaced at Thelin
48. ters the Parlour Direct Vent Gnome Direct Vent and Echo Direct Vent This manual will give you the information you need to install them correctly troubleshoot problems and fine tune them after they are installed In addition in Section X you will find a step by step guide to converting the LP stoves to natural gas and vice versa To properly perform maintenance and work on all models you will need the following tools 1 4 3 8 or 1 2 inch socket set Slot and phillips screw drivers a Makita similar cordless drill works well Digital read out volt meter Allen wrench set 30 Torx tip Wire stripper crimp connectors and crimp tool Drop light or flashlight with extension cord Crescent wrench and set of end wrenches Instrument for checking gas pressure 1 e manometer Gas Heater Service Manual VENTING Figure 1 through Figure 10 will give you the recommended venting systems for all Thelin Hearth Products gas heaters Venting properly 15 extremely important Ninety percent of problems with Direct Vent stoves relate to improper venting If you deviate from these installation diagrams you must remember the following 1 All horizontal runs must maintain 1 2 inch per foot rise Horizontal funs over 4 feet are highly discouraged 2 Each added 90 or 45 degree bend creates static pressure and will affect the performance of the heater Two 45 degree elbows are always bett
49. tion reset Remove two screws for dismount Safety door FAN REMOVAL 1 Remove outer jacket label wires before removing 2 Disconnect wires to fan motor 3 Remove two screws at base of a mounting bracket 4 Install new fan on mounting bracket and re mount bracket on stove 2 Make sure two pieces of insulation are in place behind motor and on left side of fan housing 6 Replace wires and outer shield Gas Heater Service Manual 55 THELIN HEARTH PRODUCTS FIGURE 43 DELAYED IGNITION SAFETY SHUT DOWN 2004 140 Snap Disc Sensor This unit 1s equipped with a safety shut down system that will disable the stove in the event pressure builds up and the stove ignites with delayed combustion If this happens you must have a qualified service person determine the cause of the delayed ignition Gas Heater Service Manual 56 THELIN HEARTH PRODUCTS FIGURE 44 PARLOUR B VENT WIRING DIAGRAM ROBERT SHAW VALVE yanng MOA 021 I 1 1509 48 01 8 gb IUM 2510 1 T 82 3218 en 10 28 07 181114 10101 8 0 0 181 abut 10 40 1 ozaig 919 2 9018 un ejsouau S 3 S 1 gt m gt D _ 92 n 5 1105 ysig oway I 2 2 THELIN HEARTH PRODUCTS FIGURE 45 PARLOUR B VENT WIRING DIAGR
50. tove instructions is not followed unscrew the pilot tube from the pilot When the fitting is loose exactly a fire explosion or pull the tube straight out and remove the pilot orifice production of carbon monoxide may result causing 5 Remove the three mounting screws from the main control valve See Figure 32 Pull the orifice from the air shutter at the base of property damage personal the burner Remove the air shutter plate and tension spring Now injury or loss of life The remove the main orifice qualified service agency is responsible for the proper installation of this kit The installation 1s not proper and complete until the operation of the converted appliance 15 checked as specified in the manufacturer s instructions supplied with this 6 Coat the threads of the orifice with pipe joint sealer or pipe tape that is rated for gas Do not allow sealant to enter orifice opening Screw the new orifice in tight Slip the orifice into the air shutter and replace the screws while holding tension on the brass manifold and be careful to keep the orifice going straight into the burner It should not be necessary to disconnect the wiring during this conversion 7 Place the new pilot orifice over the end of the pilot tube and insert into the base of the pilot Thread the fitting on and tighten down snugly with a 1 2 open ended wrench 8 Remove the regulator from the valve see Figure 24 The regulator 15 th
51. usting the Restrictor disks will overcome this problem IX THERMOSTAT HOOK UP Diagrams 11 through 14 will show you the location of the thermostat hook up terminal Do not try to wire around this terminal The wiring has already been done for you and the provided terminal must be used for thermostat hook up Note a millivolt thermostat must be used on all Thelin Hearth Products gas heaters NO EXCEPTIONS Gas Heater Service Manual CONVERSION KITS AND INSTALLATION All Thelin Hearth Products gas stoves can be converted from LP gas to natural gas or from natural gas to LP gas The kits consist of three parts plus a label indicating the change has been made The components of the kit are a Main Orifice b Control Regulator c Pilot Orifice and d label indicating for which gas the stove is equipped See Figure 23 through Figure 26 and Figure 36 through Figure 41 for the location of these parts Tools necessary for making the conversion are 716 1 2 and 9 16 end wrenches slot and phillips screw drivers and a 1 4 inch drive ratchet set Removal of the main orifice requires two wrenches Do not attempt to remove orifice with one wrench as you can twist the gas line and break it For specific instructions on conversions see Appendix B DELAYED IGNITION SAFETY DOOR 1995 2004 See Figure 42 for the location of the safety door In the event of a delayed ignition and or explosion this door will fly open an
52. ustment and troubleshooting of the SIT valve Please note that on Page 2 of the guide General Guide for Set Up of Nova mV System item numbers 7 and 8 are procedures for checking millivoltage of the valve Follow the steps outlined in the guide to make sure the valve is functioning properly Inlet outlet pressure Both inlet and outlet pressure can be checked directly from the valve by utilizing a small plastic tube hooked directly to a manometer Note IN and OUT receptacles on the SIT valve Figure 23 and Figure 25 Hook tube to these orifices after loosening internal screw and hook directly to manometer to check pressure Robert Shaw valves do not have these receptacles Pressure can be checked on the Robert Shaw valves from the orifice manifold See Figure 32 Gas Heater Service Manual AIR SHUTTER ADJUSTMENT CORRECT FLAME AND REMOVAL OF BURNER Both B Vent and Direct Vent stoves equipped with air shutters that allow for fine tuning and adjusting of the air to fuel ratio The B Vent heater can be adjusted from the bottom of the stove see Figure 28 The Direct Vent stoves require the removal of the burner to adjust the air shutter see Figure 35 and Figure 36 for removal of burner and location of air shutter It is critical when removing or replacing the burner to make sure the orifice is aligned correctly into the air shutter hole Do not force or pry burner or orifice If alignment 15 correct
53. ve Maximum fepih 32 tmm Manifold Pressure Setting in 35 11 0 Alcove Helght 50 1270mm Manl old LO Setting W C 1 7 3 5 Minimum Inlet Pressure ln 5 5 11 5 Blower Electrical Rating 115 Volts 1 5 Amps 60 Hz FAN TYPE VENTED CIRCULATOR WARNING mg af E heater when not commected to properly and maintained direct venting system can rasull in injury and installation ad uskment alteration service ar malwtlenamce can cause Injury or property damage Refer to the information in the owner s manna provided with this apphance For assistance or additional formation consult a qualified installer service agancy or the gas supplier Risk of electrical shock Disconnact ct power before sarvicing unit This appliance may be installed in a mobile home and sleeping room provided the wall tharmortat option is used This appliance is for use with the of gas indicated on the rating plata and may be installed in an aftermarket rime located manufactured mobile home where not prohibited by local codes Sae owner s manual for his appliance is wot convertible for use with other gases a certified 15 used This heater must be properly connected to a Simpson Dura Vent GS Venting System DANGER DO NOT RUN POWER CORD UNDER APPLIANCE NOTE For use with glass door certified KEEP BURNER AND CONTROL COMPARTMENT CLEAN with t
54. w without logs in place Top view of burner Pilot Detail NOTE Flame must touch thermopile Gas Heater Service Manual View showing logs in place Access to air shutter Bottom view of burner Air shutter 4 THELIN HEARTH PRODUCTS FIGURE 31 PARLOUR DIRECT VENT LOG PLACEMENT AND AIR SHUTTER ADJUST Logs are placed above burners Raar logs flush with back Pilot light Thermopile Spark lgnitor Top view of Log placement with burners showing Front logs View without View showing 1 lags in place DEM logs in place Access to air shutter Top view of burner Bottom view of burner x 90 Bolt 1 4 20 Balt Pilot Detail NOTE Flame must touch thermopile 42 Gas Heater Service Manual THELIN HEARTH PRODUCTS FIGURE 32 GNOME DIRECT VENT LOG PLACEMENT AND AIR SHUTTER ADJUST Logs are placed above burners Rear logs flush with back Place niche rer pil Front logs View without logs in place To remove burners remove two hex bolts Gas Heater Service Manual NS Front burner should be visible batween the front and rear logs Jj Logs in Place Important Be sure front log is put firmly in place square with door opening Loosen screw Turn to enlarge or decreas
Download Pdf Manuals
Related Search