Home

Dream Service Manual - Mike Channon`s Directory of HTC Service

1. Remove the rubber as location indicated HTC CONFIDENTIAL G NTE ite Corporati smart mobility orporation A04 Doc Title Dream Service Manual Remove the Touch Panel Separate Touch Panel and bezel Remove the LED Lens from bezel HTC CONFIDENTIAL Odo e hrc smart mebilie HTC Corporation T Doc Title Dream Service Manual Finish LCM disassembly HTC CONFIDENTIAL ido a nT on mone sees HTC Corporation Issued Date 2008 07 14 T smart mobility Doc Title Dream Service Manual 36 of 113 2 2 4 Keyboard module disassembling procedure Remove the Regulation label Remove the camera Unfasten the screws as location indicated Philip Screw Driver 0 HTC CONFIDENTIAL Ud Mos 7 issued Date 2008 07 14 nat mai w HTC Corporation Issued Date 2008 07 14 R Revised Date 2008 10 20 Doc Title Dream Service Manual 37 of 113 BH pi F 3 1 i 3 AET DDD o 800 052 39325591 Al Wy T1038 SN Li wd LI mi AL ae 3 x es JJ AH ml r a A A 7 LL MET TILL Lu HTC CONFIDENTIAL Sao GO NTE pro corporation ZEM smart mobility Doc Title Dream Service Manual 38 38 of 113 113 2 3 Assembling procedure 2 3 1 Keyboard module assembling procedure Please wear the ESD Wrist Strap during the work and make sure the strap is firmly around your wrist Put the Qwerty keypad on the C cover Combine the
2. IMEI XXXXXXXXXXXXXXX SIN XXXXXXXXXXXX P N XXHXXXXX XX HTC Innovation Made in Taiwan barcode label 0 05T ZU HTC CONFIDENTIAL SS NTC netus seni EE NA HTC Corporation Issued Date 2008 07 14 smart mobilitv Doc Title Dream Service Manual 96 96 of 113 113 8 3 Unit label location explanation Water sensitive label HTC P N 77H00685 00M Qty 2 Tamper evident label HTC P N 77H00460 01M Qty 1 IMI OUIOOODOOUCK WIN KAXXKKKKKAKA KAR PIN XXHXXXXX XX this label assemble by vendor Agency label di Water Sensitive label Tamper evident label HTC CONFIDENTIAL ZEM Doc Title Dream Service Manual 8 4 battery label Dynapack WW version DREA160 1150mAh jie 53 0mm 36 0mm m Serial no Part no artwork only dimension for reference E for reference only not for printing B blackC m coolgray 9C cool gray 5C font english Helvetica Neue 55 Roman chinese 44 EX IE ik Ese HTC CONFIDENTIAL Page 97 97 of 113 113 ENTE qure corporation SEE smart mobility Doc Title Dream Service Manual 98 98 of 113 113 9 Generic Spare Part List and Photos 9 1 SPL for Repair un a F m mm Item Description Oty 5 1 36H00695 01M Receiver AAC ELECTRONICS SDRP0611AS 01 F1B G 2 36H00720 00M Speaker EDIC MPS101707BB 3 51H00441 00M PCBA UMTS Antenna Board for US Dream 4 51H00442 00M PCBA GPS Antenna Board
3. could be duplicated HTC CONFIDENTIAL lo g NTC on tone IE MAG T HTC Corporation Issued Date 2008 07 14 smart mobility Doc Title Dream Service Manual 92 92 of 113 113 1 If test result is NFF it is possible caused by user connect cradle to computer 2 3 Check Use for USB storage is enable Menu gt Setting gt Data gt SD card amp device storage Check whether it connects with other cables or cradle customer s cable might be damaged 4 5 6 Check the external appearance of the connector on the unit whether it is physically damaged Replace Main Board if necessary Once the defective part has been identified verify it again with the defective part whether the symptom could be duplicated 1 Make sure the Battery Pack takes fully charge with AC Adapter 2 3 4 5 6 Check whether the condition of Battery Charging status is correct Dismantle the unit and check the appearance of Battery Pack Try with another Battery Pack or Replace Battery Pack if necessary Try with another Main Board or Replace Main Board if necessary NN o Once the defective part has been identified verify it again with the defective part whether the symptom could be duplicated 1 Make sure the Battery Pack takes fully charge with AC Adapter 2 Check whether the condition of Battery Charging status is correct Charge should be done no more t
4. smart mobility Doc Title Dream Service Manual 18 of 113 2 Device Disassembling and Assembling Procedure 2 1 Tools list Level Mo Item Vendor F N NENNEN 2 Bamphone Headset 3 Jacadapter 4 WLANAB LI 6 Diagnostic Cards level2 TC design DCT 00053 Powersupply p Power supply 9 Current Meter E special Made Plastic Stick L2 13 Handtools Barcode label printer 400dp1 resolution and up oc L 15 Lead free Soldering station 16 Airheater 11000000 2 2 Disassembling procedure 2 2 1 Key parts disassembling procedure Tools needed for Assembling and Disassembling the device Glove amp Cleaning Tissue Tweezers Suggest to use plastic made Philip Screw Driver 0 Philip Screw Driver type T6 Philip Screw Driver type T5 Flat Plastic Stick ESD bracelet HTC CONFIDENTIAL went C u Issued Date 2008 07 14 HTC Corporation smart mobility p A04 l Revised Date 2008 10 20 Doc Title Dream Service Manual Page 19 of 113 4 A U p 4 uz 4 rr PF M 147 y 4 L fe Ld Ld d E i Please wear the ESD Wrist Strap during the work and make sure the strap is firmly around your wrist 1 Slide out the device 2 Remove the battery cover from device Remove the battery from device HTC CONFIDENTIAL BTC ire corporat smart mobility orporation Doc Title Dream Service Manual 20 20 of 113 113 E P N O9HEWOOO oo il MITT AM
5. thers refer to production Ez i P Others refer to production release spec release spec OTHERS Description Accept Criteria Class A Exposure of substrate do not accept Scratch L 4mm W x 0 2mm N x2 Sz 10mm Class B Exposure of substrate do not accept Scratch LE 7mm W x 0 25mm N x3 Sz 10mm Label area don t care o Class C Exposure of substrate do not accept Scratch Lx 10mm W x0 4mm N x5 S2 5mm Description Accept Criteria Class A D x0 5mm Nzx2 S 215 mm Ignored if D D x 0 15mm Class B D x0 6mm Nzx4 S 215 mm Ignored if D D lt 0 25mm M Class C D 0 9mm N lt 4 S 210 mm M Description Accept Criteria Don t ii hand scrape M Accept Description Accept Criteria 8 0 25 x diameter lt 0 65mm N 3 M 0 65 lt diameter lt 1 00mm N lt 3 oomm N 3 mi Accept Description Accept Criteria L lt 2 5mm W lt 0 25mm N lt 3 MI L 3 0mm W x 0 25mm N lt 4 MI HTC CONFIDENTIAL Aia i Smart monli HTC Corporation A04 Doc Title Dream Service Manual L lt 3 0mm W lt 0 3mm N lt 5 Lint Accept Criteria L 3mm W lt 0 2mm N lt 2 S 25 mm L lt 5mm W lt 0 3mm Nx3 S 25mm L 10mm W lt 0 3 mm Nz3 HTC CONFIDENTIAL enc on pestes sema m HTC Corporation Issued Date 2008 07 14 T smart mobility i y 2008 10 20 Doc Title Dream Service Manual 20 AR 7 Generic Troubleshooting 1 Main Unit Does Not Respond to Power Button 1 Connect the AC adapter maybe the
6. Dream Service Manual 12 12 of 13 113 Left panel Right panel VOLUME UP Press to Increase the ringer or media volume VOLUME DOWN Press to lower the ringer or media volume L CAPTURE Press to open p Camera When in the Storage card slot l Camera application Open the slot cover f po ipii i to install a storage Y i activate auto Tocus Press fully to take the ma l F shot HTC CONFIDENTIAL Sao e nTc on sone sea En um HTC Corporation Issued Date 2008 07 14 smart mobility AO Doc Title Dream Service Manual 13 of 113 insert SIM 8 battery 1 Slide the display up to reveal the keyboard 2 Ihe cover release tab Is located to the left of the the keyboard along the edge Pull the tab up with your thumb while pulling the battery cover back then free 3 urn the device over Slide the SIM card into the slot with the gold contacts face down and with the cut corner facing away from the slot 4 Insert the battery with the contacts faci ng BWIN tnen wii HTC CONFIDENTIAL 3 hTC MITO HTC Corporation sos Insert SD card 1 Slide the display up to reveal the keyboard 2 Open the SD card slot rubber cover located just below the Call button 3 Insert the SD card with the gold contacts facing down until the card clicks into place Replace the cover To remove the card press it in slightly and release Charge battery 1 Connect the AC adapter plug t
7. Unlock the camera connector Move the main board as the direction shows to disconnect the camera FPC Disconnect the hinge FPC and separate main board HTC CONFIDENTIAL S nrc a 107 14 smart mobility HTC Corporation A04 Doc Title Dream Service Manual 24 of 113 Unfasten the screw s as location indicated Philip Screw Driver 0 SCREW T1 6 6 P N 72H02403 00M 2 i 1 4 Y 4 4 Y d Torque 0 44 0 1kgf c m Use the plastic stick to release the UI Cover HTC CONFIDENTIAL PJ v G NTC ire corporat TEM smart mobilit y O pora ION A04 Doc Title Dream Service Manual 25 of 113 Through the gap to release the hooks Use type screw driver insert the hole Separate the UI Cover HTC CONFIDENTIAL BATS ire corporat smart mobility orporation A04 Doc Title Dream Service Manual 4 Og HFNDOD 00 BEIGE f TIM an Unfasten the screw s as location indicated Philip Screw Driver 0 Screw hinge PH BIH M1 6 2 P N 72H00624 01M 4 Torque 1 54 0 1kgf c m Finish key parts disassembly HTC CONFIDENTIAL je NTC S MTO ure corporation 052e s Doc Title Dream Service Manual 27 of 113 2 2 2 UI module disassembling procedure HTC CONFIDENTIAL j PU m a hre smart mobility HTC Corporation Doc Title Dream Service Manual 28 28 of 113 113 Release the FPC and disassembly the daughter board from UI module Unfasten the screws as location indicated Ph
8. Applications A under OHD distribution model Home Screen Application Launcher Lock Screen and Track View for notification Settings Dialer Browser Camera Pictures Music Media Player and streaming media supported SMS MMS IM MSN Yahoo IM TBD Contacts Calendar Alarm Clock Calculator Voice Dialer SIM Toolkit pplications under GMS licensing model Search Maps Street View YouTube Gmail IM GTalk AIM synchronization Contacts Calendar Gmail Market Modules Codec under OHD distribution model Bluetooth profiles lity HTC Corporation sessjoni HTC CONFIDENTIAL Page 7 Tofll3 113 Z NTC sone seni pad oe HTC Corporation Issued Date 2008 07 14 Smart mobility Doc Title Dream Service Manual 8 8of113 113 GAP RFCOMM HFP HSP e Audio Codec MP3 MIDI AAC LC AAC AMR NB AMR WB SBC e Video Codec MPEGA SP H 263 H 264 Image File Format PNG JPG e OMA DRM 1 0 Forward Lock only Multiple APN Enhancements Android Application Enhancements smart Dialer TBD Input Method support Traditional and Simple Chinese handwriting recognition TBD Camera Multiple modes support Camera Photo ID Camcorder TBD HTC Value Added Applications Generic E POP3 IMAP4 Mail Client e WAP Browser TBD J2ME Support JAM JSR 5 PIM access amp FC JSR 118 JSR 120 Wireless Messaging API JSR 135 Mobile Media API JSR 139 JSR 185 JTWI Cust
9. Dream 5 51H10069 00M Rigid Flex Board ASSY Daughter board Dream 6 51H40446 00M PCBA MAIN BOARD with SKU ID GSM UMTS 2100 AWS ri 54H00287 00M Camera Module MI3130 4Targan9410 F OXCONN CMHT 3A404D AF Largan 8 9 60H00152 00M TFT LCD Module SHARP LS032B7LX01 76 45 50 55 1 95mm 71H02354 00M Lens Led r LI E 10 72H00624 01M Screw hinge PH BIH MI 6 2 NIN Y 11 72H01059 01M Screw POINT Mechanical P 1 6 4 5 NIHNVLOK T6 12 72H02325 00M Screw KT M1 6 3 5 Ni plated NY 13 72H02403 00M Screw PH FD T1 6 6 Nickel 14 72H02404 00M Screw PH FD T1 4 2 65 Nickel Black 15 72H02481 00M EMI Gasket Hinge FPC stiffener 15 8 0 1mm 16 72H02483 00M EMI Gasket Shielding 20 5 1 3mm 17 72H02663 00M Screw BT KH 1 4X3 3 BZ 18 73H00284 00M Cable UMTS ACON CP7P75 0079000 UMTS coaxial 7 8mm 19 73H00285 00M Cable GPS ACON CP7P75 0023000 Coaxial 22mm 20 73H20136 41M FPC Pre Assy AP Dome FPC GLOBAL FLEX 21 73H20137 41M FPC Pre Assy Qwerty Keypad FPC GLOBAL FLEX 22 76H02523 00M Adhesive Double Tape backup Camera FPC 18 18 0 05mm 3M 9703 23 76H02529 00M Tape Qwerty FPC conn Kapton 24 76H02561 00M Sponge TP LCD connector 25 76H02562 00M Rubber Microphone T 26 76H02564 00M Tape LCD conn Kapton 27 76H02565 00M Tape Touch Screen Kapton 28 76H02566 00M Mylar Receiver 29 76H02569 00M Rubber Front LCD boa HTC CONFIDENTIAL ku HTC pro corporation ZEM smart mobility Doc Title Dream Service Manual 99 99 of 1
10. NTC AP eb HTC Corporation emart Doc Title Dream Service Manual 76 of 113 USB Test Select to use your memory card as USB mass storage when your phone is connected to your computer selected by default or press Menu Settings SD card 8 phone storage gt Use for USB storage Insert USB cable and connect device to computer then you can view and manage the SD card storage from your computer Tap the application tab and press Camera icon to turn on the Camera Make sure the device will present and enter the preview display Check camera pre view and image quality Photo Test 1 Press Capture key 2 Press Capture key again 3 Tap Delete icon on the preview screen Press Menu button Tap the icon Settings Select Wireless controls and then select the Bluetooth check box to turn on Bluetooth services To pair with a device in the list select it Once the other Bluetooth device shows connected status you can start using it to make and receive phone calls HTC CONFIDENTIAL A N43 4 58 PM Securitv 8 location Mv Location screen unlock SIM card Applications Manage applications set up quick launch shortcuts Date 8 time Set date time time zone amp formats PE View legal info phone status soft versior 1 2 MEME amp Alarm Clock Amazon MP3 Bonsai Blast Browser BCH b Calculator Calendar Contacts KEK gt Gmail a wm Maps Market Messaging D
11. Qwerty keypad FPC with C cover HTC CONFIDENTIAL hre smart mobility HTC Corporation A04 Doc Title Dream Service Manual Philip Screw Driver 0 SCREW T1 4 2 9 SCREW P N 72H02663 00M 2 TORQUE 0 6 0 1KGF C m e nTc on sone sea Il HTC Corporation Issued Date 2008 07 14 T smart mobility Doc Title Dream Service Manual 40 of 113 2 3 2 LCM assembling procedure OW uw Attach the LED Lens to the bezel A cover Combine the Touch Panel with bezel A Cover Attach the rubbers to Bezel A cover to fix the Touch Panel HTC CONFIDENTIAL nrc smak me Gi HTC Corporation Doc Title Dream Service Manual 41 Ao 113 113 Combine the LCD with Bezel A cover Attach the receiver to the Bezel A cover Paste the gasket around the FPC cable Gasket 72H02996 01 M HTC CONFIDENTIAL BTC ire corporat smart mobility orporation Doc Title Dream Service Manual 42 a2 of 113 113 Connect the Touch panel FPC connector Paste the gasket on the LCD Connect LCM FPC with display FPC HTC CONFIDENTIAL 49 n e hre smart mobility HTC Corporation Doc Title Dream Service Manual 43 438 of 113 113 Connect the hinge FPC with display FPC Combine the LCD bracket with Bezel A cover Combine the Hinge chassis with LCD Chassis HTC CONFIDENTIAL BTC ire corporat smart mobility orporation Doc Title Dream Service Manual 44 44 of 13 113 Put the
12. Transmitter Test 12 TX Power o 521 lt 65 13 TXFower 698 65 27dbm 14 TXFower 885 65 FCE 1900 Receiver Test Fast Bit Error Rate oO 512 104 10 Fast Bit Error Rate oO 661 104 L 28 11 Fast Bit Error Rate oO 810 104 PCs 1900 Transmitter Test 12 TXFower o u2 65 13 TXFower 661 65 25dbm 14 TX Power 0 810 5 HTC CONFIDENTIAL
13. battery pack is exhaust and wait few minutes for battery recharging 2 Check if battery installed well 3 Check the Power Button whether it s damaged 4 Replace another battery pack 1 2 3 4 5 Try to start boot loader mode refer to section 4 2 Re flash ROM if boot loader mode is enabled 6 Check all connectors including LCD FPC to Main Board 7 Replace Daughter Board if necessary 8 Replace Main Board if necessary 9 Once the defective part has been identified verify the defective part again whether the symptom could be duplicated with another unit 2 Touch Panel Does Not Respond to Screen Tap 1 Check the connection of LCD FPC cable whether is properly connected 2 Try to cold boot the unit then perform screen tap again 3 Try with another Touch Panel 4 Try with another Main Board 5 Replace Touch Panel if necessary 6 Replace Main Board if necessary 7 Once the defective part has been identified verify the defective part again whether the symptom could be duplicated with another unit 3 Buttons Do Not Respond 1 Try to cold boot the unit then tries again 2 Dismantle the unit check the status of switches on the Main Board and the plastic parts of the Button not responding 3 Try with another Main Board or Front Bezel 4 Replace Main Board or Front Bezel if necessary 5 Once the defective part has been identified verify the defective part again whether the symp
14. of 113 72H02404 00 Screw PH FD T1 4 2 65 Nickel Black Gasket Hinge FPC Description e ener 15 8 0 1mm Description om 73H00284 00M Dodo Cable UMTS ACONU DascHvton Cable GPS ACON Co P MTS coaxial 80mm P axial 22mm i 13H20136 41M D ww oe eau FPC Pre Assy AP Description Dome FPC GLOBAL Ps S i OU LEM OOO HTC CONFIDENTIAL c NTC wec 7 smart mobility orporation Doc Title Dream Service Manual 76H02523 00M o9 76H02529 00M Adhesive Double Description Tape backup Camera been 1705 ne FP FPC 18 18 0 05mm3 d 16H02564 00M Tape Kapton_Spong_ LCD connector Description Rubber Microphone Description Refurbishment Refurbishment 76H025689 00M Description Rubber Front L CD Description Tape Kapton_Spong_ TP connector Tamper Evident Description abel VOID wording black ph Refurbishment Refurbishment HTC CONFIDENTIAL a hre i mart mebi HTC Corporation m Doc Title Dream Service Manual 7 7H00612 00M co 7 TH00685 00M Water Sensitive Description Label MING JYE 4 4mm 3M 5558 s O I Made in Taiwan Refurbishment Refurbishment 76H10039 00M Protector Description Film 39 78 0 04 88 34 Blank Label for PIN XXWOOXX XX mm MA2550 2 d ai IMI o FT ILI Refurbishment Repair code Return to HTC 76H10005 01M Different P N by 76H03105 00M customer Protector Film screen
15. test menu After the test pattern is show up please check the pattern if any un uniform color or chromatist Press Action key to continue the next test pattern HTC CONFIDENTIAL e NTC netus seni X mr HTC Corporation Issued Date 2008 07 14 Smart mobility Doc Title Dream Service Manual 69 69 of 113 113 Display Test Green Blue pattern IV Press Action key to continue the next test pattern Display Test Black White pattern V Press Action key to continue the next test pattern Display Test Gray pattern Vl Press Action key to continue the next test pattern HTC CONFIDENTIAL N diii bin P Ly s l l Issued Date 2008 07 14 bun HTC Corporation Issued Date 2008 07 14 T smart mobil Doc Title Dream Service Manual 70 of 113 LED Test Press Action key and follow the instruction on screen to perform the LED inspection test Green Red Blue UI LED and Key LED Press Action key to next or return to Function test menu LED GREEN OM LED RED OW LED GREEM GM LED BLUE OM LED RED GM LED OM LED BLUE QM hiction Hoxt Action Next Action Next HTC CONFIDENTIAL TI er C HTC Corporation Issued Date 2008 07 14 m smart mobility Doc Title Dream Service Manual 71 of 113 Sliding Test Sliding Press Action key to select Sliding Test on Function test menu Follow the instruction on screen to Pls close t
16. the test result If the capacity is under 70 please replace a new battery HTC CONFIDENTIAL Sao B NTCK pro corporation ZEM smart mobility Doc Title Dream Service Manual 86 86 of 113 113 6 Cosmetic Inspection Criteria 6 1 Classes definition of inspective area Class A area gt The front side of main unit involve all buttons and LED lens except LCD Class B area gt Qwerty key of main unit Class C area gt 5 sides and back views of main unit Except Front view of main unit Y Y v WV Class D area gt Apart from the previous 2 areas the class D area indicates the inner part which can t be seen while a user operations Photo of inspection areas IT IS GENERIC COSMETIC INSPECTION CRITERIA FOR ALL PRODUCTS IF THERE HAVE ANY CONFLICT WITH THESE GENERIC CRITERIONS PLEASE FOLLOW THE PRODUCT INSPECTION CRITERIA RESPECTIVELY Description gt D Diameter L Length W Width N Number of defects S Distance from dot to dot gt J Inspecting distance 30 5cm Mechanical inspection angle 90 degrees gt LCM inspection angle 90415 degrees Inspection time 5 secs per surface gt Ambient illumination is to be 500 1100 lux HTC CONFIDENTIAL enc on pestes sema HTC Corporation Issued Date 2008 07 14 AGA smart mobility i y 2008 10 20 Doc Title Dream Service Manual oT gt The inspection condition of Newton ring a Inspection distance 30cm Inspection time 5 sec b A
17. 13 113 30 76H02570 00M Rubber Side LCD 4 31 76H03105 00M Mylar Daughter Board Kapton 32 77H00612 00M Regulation Label 55 9 38 04mm F i 33 7T7H00685 00M Water Sensitive Label MING JYE 4 4mm 3M 5558 34 36H00375 02M Switch Black PANASONIC EVQWINO08 1 61H00144 10M Touch Window SYNAPTICS TM 01062 001 w o CAMERA HOLE 77 74 51 1 0 48mm 36 71H02357 00M Cover IO cover TMUS Black 37 72H00740 01M Screw PH FD M1 6X1 6 Nickel Black NYLOK 38 72H02873 00M Screw FH M1 4 0 3 4 3 BZ Ny 39 73H20132 41M FPC Pre Assy Dispaly FPC GLOBAL FLEX 40 73H20179 41M FPC Pre Assy Hinge FPC GLOBAL FLEX 41 74H01149 00M Cover Pre Assy C cover TMUS Black matt 42 74H01155 01M Cover Pre Assy Battery cover Black TMUS w logo Dream O6 43 74H01156 00M Cover Pre Assy UI TMUS Black 44 74H01157 00M Housing Pre Assy D cover TMUS Black matt 45 74H01158 00M Keypad Pre Assy TMUS QOQWERTY Black WWE 46 74H01163 01M Bezel Pre Assy A Cover TMUS Black w logo 47 74H01164 00M Keypad Pre Assy APP key TMUS Black 48 74H01172 04M Hinge Pre Assy Black TMUS w logo DIABELL 35 NOTE THE PHOTO OF SPL IS GENERIC AND ONLY FOR REFERENCE THE COLOR AND APPEARANCE MAY BE DIFFERENT FROM THE SHIPPED PARTS IF YOU WANT TO APPLY THOSE PARTS PLEASE CONTACT YOUR SERVICE ACCOUNT MANAGER FOR MORE INFORMATION AS FOR PICTURE PLEASE REFER TO THE TABLE AS BELOW FOR REFURBISHMENT PARTS THE TABLE IS FOR YOUR REFERENCE YOU CAN DO THE REFURBISHMENT ONLY WHEN YOUR
18. 78 592 KB KREARLfE WZOSRENAA f dbis faac Download ROM image from SDO http htescm10 htc com tw SDO iE ESSE RA LB PRB DIESE fS e PARSE fetu s Un zip the image file rd HERTEL _ Shen darch Bri Demi Select file system and format the SD card to FAT32 mode zi BEER TES FE i GE cep MGM TAL AGI Copy image file XXX nbh to the SD 29 em card and rename to DREAIMG NBH x 2 UCET UL E 10 H F UE Peet At LES Rte Shas BFA F X kings s JI aH dei d goma ae HTC CONFIDENTIAL a hre MIETET Bop W HTC Corporation era smart mobilitv Doc Title Dream Service Manual 64 64 of 113 113 Turn the device power off and insert Diagnostic SD card Hold Camera button and press Power button to entry Boot loader mode Press Power button to start upgrade procedure Reading source code from SD card Note This process will takes 5 mins please don t power off the device After finish perform the soft reset to reboot HTC CONFIDENTIAL e 8 nTc on perone aa HTC Corporation Issued Date 2008 07 14 AGA smart mobilit y 2008 10 20 Doc Title Dream Service Manual 65 of 113 4 DIAGNOSTIC PROGRAM 4 1 List of Diagnostic Android Test Items Mode No tem Desorption TRema Auto Regular Tests SD card Vibrator Display 1 Auto B L etc 2 SDRAM Test RAM memor
19. ACK HTC CONFIDENTIAL GO NTC qure corporation ZEM smart mobility y 2008 10 20 Doc Title Dream Service Manual 109 of 113 9 2 Board Level 2 5 Repairs B Basic Repair Instructions for Component Replacement otep 1 Place the solder proof tape to cover the surrounding area of the components which being replaced arning DO NOT overheat the tape and components to avoid the tape melted and the components damaged Step 2 Use Heater Gun HAKO850B set the temperature between 350 C Air Speed 3 5 to remove the components Step 3 It has to wait the temperature cool down before the damaged components been removed Or the others components could be gone when the solder proof tape been taken off Step 4 After the damaged or defective components have been replaced clear the surroundings for solder and flux residues Notice A Checking the polarity of CON5 CON6 CON7 CONG CON10 and the position can t be shifted B Checking the polarity of CON7 CONS and it can t be reversed C Allthe parts of the PCB should be checked if it is missing or not D The OP must to wear antistatic wrist band Don t put boards together and avoid hitting them HTC CONFIDENTIAL ao e nTc on sone sea ba HTC Corporation Issued Date 2008 07 14 T smart mobility Doc Title Dream Service Manual 110 of 113 51H40446 XXM PCBA MAIN BOARD Side A Location P N Description Remark sss ec REGRET rm 7640075500 o
20. Favorites LO E l Press Call Button to dial for performs the RF Tasers test Also you can test by mobile tester Erase all test data fi MI 9 59 AM amp M 10 00 AM Factorv data reset Before shipping vou should erase all test data on the phone Total space This action will reset the phone to its initial factory state erasing all data and downloaded applications Available space avallapie Press Menu button and tap the icon a Settings Use for USB storage Select SD card 8 phone storage gt Press T the Factory data reset and press the Reset Available space phone button Also you can perform the hard reset when the device is power off Press and hold Home Back Button then press Power Button HTC CONFIDENTIAL yo NTC eius somma Eu cd a P E HTC Corporation Issued Date 2008 07 14 smart mobility Doc Title Dream Service Manual 80 80 of 113 113 5 Power measurement test 5 1 Main board leakage current Test Procedure This is a quick method to measure if any abnormal leakage current on main board which caused high power consumption compare to GOOD main board Requirement Power Supply Micro current Meter Current series JIG CABLE Battery JIG 1 Control box 2 Four colors cables Cable A Red Cable B Yellow Cable C Green Cable D Black HTC CONFIDENTIAL BTC ire corporat smart mobility orporation Doc Title Dream Ser
21. Google Map Canada 2 V Press Menu button and select My Location TA p Market Messaging Music M xico am Note The device should test at you can view of m Te 8 Pictures Settings Voice Dialer sky area or within connection extension antenna area VI The screen should appear your location on the map HTC CONFIDENTIAL emart d ATC mobility HTC Corporation A04 Doc Title Dream Service Manual 78 of 113 WLAN Test Press Menu button and tap the icon Settings Select Wireless controls select the Mobile networks select USE only 2G networks check box Select Wireless controls select the Wi Fi check box to turn on Wi Fi services and open the Wi Fi settings screen View and scan for available network Connect to a network Select it from the network list Provide your username or password if required And you can see the icon Hs on the status bar when Wi Fi service connected Make sure the device can access to the internet via Wi Fi network Press Menu button and tap the icon Settings Select Sound amp display gt select the Phone ringtone Select and play a ringtone then check the sound quality from the speaker HTC CONFIDENTIAL Mobile network settings M B 22 26 Wireless controls Data roaming Operator selection select a network operato Access Point Names Wi Fi settings Wi Fi Connected to wlan Netwo
22. I 158770010015773 1 5 d MID MIN IN f TANPLIONIAB XA Unfasten 4 screws from housing as red mark Philip Screw Driver type T5 SCREW MI 6 3 5 P N 72H02325 00M 4 Torque 2 04 0 1kgf c m Unfasten 1 screw from housing as blue mark Philip Screw Driver type T6 SCREW P1 6 4 P N 72H01059 00M 1 Torque 2 0 0 lkgf c m HTC CONFIDENTIAL nrc i smart mobility HTC Corporation A04 Doc Title Dream Service Manual Use plastic stick into the gap and release the hooks 2 Separate the housing from device Separate the speaker from housing SPEAKER P N 36H00693 00M 1 HTC CONFIDENTIAL BATS ire corporat smart mobility orporation Doc Title Dream Service Manual 22 22 of 13 113 P N 99HEWOOO 00 TIR HOT E FU ECT T IMEI 3582798010015723 U Ai ILLI JU M HT802G200149 Unplug UMTS coaxial cable and GPS coaxial cable Unfasten 2 screws from UMTS board and GPS board UMTS COAXILA CABLE 80mm P N 73H00284 00M GPS Coaxial Cable 22mm P N 73H00285 00M Philip Screw Driver 0 SCREW T1 4 2 9 SCREW P N 72H02663 00M 2 Torque 0 6 0 lkgf c m 1 Remove GPS board from device 2 Remove UMTS board from device HTC CONFIDENTIAL C Issued Date 2008 j 07 14 Eat meb HTC Corporation AOA l l m l Revised Date 2008 10 20 Doc Title Dream Service Manual 23 of 113 1 Remove the tape and disconnect Qwerty key FPC 2 Disconnect the daughter board FPC connector 3
23. NFIDENTIAL BTC ire corporat smart mobility orporation A04 Doc Title Dream Service Manual Attach the Camera FPC to C cover Attach the Mylar regulation label Install the USB IO cover and attach the speaker to the housing D cover HTC CONFIDENTIAL BTC tire corporat smart mobility orporation A04 Doc Title Dream Service Manual Combine the housing with C cover P N 989HEWOOOD 00 HORE ANTI MI BI IMEI A4582780100157223 MULTI N HTHO2GZOU149 MA Fasten 4 screws from housing as red mark Philip Screw Driver type T5 SCREW M1 6 3 5 P N 72H02325 00M 4 Torque 2 04 0 1kgf c m HTC CONFIDENTIAL gt ng e nTc on eme SAL HTC Corporation era Doc Title Dream Service Manual 61 61 of 113 113 Fasten 1 screw from housing as blue mark Philip Screw Driver type T6 SCREW P1 6 4 P N 72H01059 00M I Torque 2 04 0 1kgf c m Install the Battery Install the battery cover HTC CONFIDENTIAL if g G NTC ire corporat TEM smart mobilit y orpora Ion A04 Doc Title Dream Service Manual 62 of 113 Power on the device Power on the device Finish assembly HTC CONFIDENTIAL odo a htc 07 14 smart mobility HTC Corporation A04 Doc Title Dream Service Manual 63 of 113 3 ROM Re flash Procedure 3 1 Rom Image upgrade thru SD card Ae KARO SHEW IA MAW x Q i owe we l KA Bez za DV72 2 MeinVe0 76 0 MFG 40 780 KB DreslMG bh NEH ti
24. SDO or replace new daughter board if the problem still Please re execute the process when getting any error HTC CONFIDENTIAL ASP Calibration Station 19 17 18 Waiting CHD 19 17 16 Open USB port OK 19 17 13 start USB thread Notice Version 1 040ffline Station ALL OK Sending pass ack i 1 Send string length 2056 Open file and read its content ok Read file Open file Found SFC Dream 20080902 0000073E200000008859C684D80D8090 Search file 0000073E200000008859 684D80D8090 40F0283500782 Notice Version 1 0 Offline enc on pestes sema bon HTC Corporation Issued Date 2008 07 14 T smart mobility Doc Title Dream Service Manual 75 of 113 Android Test Test Requirement 3G SIM card Google account a I B 1 35 PM Don t have an account Create one now It s easy Insert the 3G SIM card Create i Already have an account Signing In the Google account and enter to Sign in with the Google account vou want linked to this phone the svstem BALL 0 dn aye eui SIUL 3unoo2e Ino dn 3un as pue S19A19S 3 3005 UJIM Sune iunuiuloo SI euoud INO Wd ce y V a Alarm Clock Amazon MP3 Bonsai Blast Il Follow the test item of the service manual to fi n37 Calculator Calendar Camera perform the function test Dialer Email a Dialer Contacts Browser Maps PA m A Maps Market Messaging HTC CONFIDENTIAL A04
25. SERVICE MODEL IS ALLOWED TO DO THE REFURBISHMENT HTC CONFIDENTIAL Sao e nTc on stone sea lon UE HTC Corporation Issued Date 2008 07 14 AGA smart mobility Doc Title Dream Service Manual 100 of 113 al v mere Tu BCEGORAAR S smart mobility HTC Corporation Picture for SPL 80H Kernel and Accessories Part no on WA is for Generic version only please check SPL for E tail per FE 36H00695 01M rz 51H00442 00M Receiver AAC Description Li ECTRONICS Description GPS Antenna Board Refurbishment Repair code Return to HTC 51H00441 XXM 51H40446 XXM Different P N by Different P N by customer customer Description UMTS Antenna Board Refurbishment Refurbishment Return to HTC Return to HTC 91H10069 00M Description Daughter Board HTC CONFIDENTIAL P gt gt ng di EU 7 AP ie en HTC Corporation ssued Pate 26 Doc Title Dream Service Manual 101 of 113 36H00 f 20 00M TFT LCD Description Speaker KDIC Module SHARP 61H00144 10M Different P N by customer Touch Window Description SYNAPTICS w o Description Lens Led Dream CAMERA HOLE mea Screw hinge PH BIH M 1 6 2 NINY Repair code Return to HTC 72H02325 00M Description Scrow KT M1 6 3 5 N NU Screw PH PROT Ni plated NY ze pon FD T1 6 6 Nickel HTC CONFIDENTIAL Y d i i i C HTC C B Issued Date 2008 07 14 smart mobilitv orporation A04 Revised Date 2008 10 20 Doc Title Dream Service Manual 102
26. SES DEFINITION OF INSPECTIVE AREA cccsceccececcececcececcccuccceceuecuececacuaecuuaecseuecseausucuenecsunecsuaecuuauseuaeaecsuaeees 86 6 2 MAIN UNIT INSPECTION 2ccececcececcececcececccceccceccceceucecuececseuucueuucecuuecunecsusececsusecsunecseaecseausecuseceusessuaeceuaeeseneaees 87 7 GENERIC TROUBLESHOOTING sisssissscsecsicecssceaccccsacactecccssdsccsedacsaseataaceanncessaseeostaaesideausacedocavanasacsaasevsessuseseansansseceieasansasnn 90 8 GENERIC LABELING PLAN bisissscscsceciscecwscdecteusessevensdacesscecdosessssccdcascocsnesavensdavsannacdessassdoceseessecswesatecsenessbuceosasecccossescseevedacees 94 9 GENERIC SPARE PART LIST AND PHOTOS ian 2 00 ccccccssssccccccsscccccccssccccccccccccccccscccccccccccccccccccccccsecccccccssecccees 98 9T OPLFOR REPA EEE eee 98 9 2 BOARD LEVEL 2 5 REPAIRS ccceccsceconceccncsccececcecaccesecauancncauancauancscoucueaaceeaasacaesacauancesancseaaaecseancscaeseccesacauanears 109 10 RF ANTENNA SPECIFICATION u cccccccsccccssssccccccssccccccccsccccccccsccccccccssccccccccccccccsccccccccccccecccscesccccsseeececes 112 HTC CONFIDENTIAL GS hTC era ee ee ee HTC Corporation Issued Date moon mob Doc Title Dream Service Manual 4 4 of 13 113 1 Introduction This manual provides the technical information to support the service activities of this product m This document contains highly confidential information so any or all of thi
27. a hre i DE HTC Corporation smart mobility Doc Title Dream Service Manual 1 1of1l3 113 Dream Service Manual HIC Proprietary Confidential Ireatment Requested Rev A04 HTC Corporation HTC CONFIDENTIAL B NTCK qr corporation ZEM smart mobilit Doc Title Dream Service Manual 2 eerie 113 Engineering Mobility REVISION CONTROL TABLE DATE CONTENTS DEPT REVISED STAGE AX01 2008 7 14 First draft AX02 2008 8 7 Second draft 1 Update diagnostic program 2 Update power measurement AX03 2008 9 10 test PSE Aken Kan PVT 3 Update spare part list 2008 9 12_ A01 version release 2008 9 19 Add 1 3 product service flowchart 1 Add one gasket in page 41 LCM assembling procedure 2008 10 8 2 Add one gasket in SPL list Sen sen page 106 E 2008 10 20 Update SPL list ET HTC CONFIDENTIAL N Doc No DOC 00045020 rea a mehi HTC Corporation sued Date ssued Date 2008 07 14 smart mobility y BTT Doc Title Dream Service Manual 30 13 MUNTRODU TION oraren 4 1 1 PRODUCT FEATURES ccccccccccecccceccccececcececcecuucecuececueaucscuuuucsusecuucecsececseauaucseausecuunecesecsunecsuaussuuseeaeuecaunecnssecaeeas 5 1 2 PRODUCT OVERVIEW ibidu iena kubi odda di kari u uti ia aria Meis ebd tad ana Uni u korda bad Banana uriet 9 1 3 PRODUCT SERVICE FLOWCHART FOR DREAM cccsceccececcececcececccceccccecuccecuecececuua
28. ast Bit Error Rate 104 6 7 gt 18 dbm 8 cell power 1 Wait Signal o 600 65 Gebi ZU Receiver Test 3 4 xo w SSM S50 Transmitter Test 6 7 gt 28 dbm 8 Ds 1800 Receiver Test Fast Bit Error Rate oO 512 104 1O Fast Bit Error Rate O 698 lt 2 11 Fast Bit Error Rate 885 104 Ds 1800 Transmitter Test 12 TX Power 0 2521 65 13 TX Power 0 698 gt 25 dbm 14 TX Power _ S895 65 FCE 1900 Receiver Test Fast Bit Error Rate 512 104 1O Fast Bit Error Rate Oo 661 1O4 x 11 Fast Bit Error Rate 810 IO4 FCE 1900 Transmitter Test 12 TX Power 52 65 13 TX Power X 661 6 amp 5 27 dbm 14 TX Power O S910 65 HTC CONFIDENTIAL G hTc sinned mabitite HTC Corporation Issued Date 2008 07 14 Doc Title Dream Service Manual 113 of 113 Uplink Downlink jlst Downlink tem Campe W COMA 2 Receiver Test 3 4 5 Transmitter Test 6 7 gt 18 dbm 8 cell power 1 Wait Signal 9 2 Power Class 600 65 GSM SOO Receiver Test 3 4 lt 2 5 cli SOO Transmitter Test 6 7 gt 28 dbr 8 DCs 1800 Receiver Test Fast Bit Error Rate oO 512 104 10 Fast Bit Error Rate oO 698 104 lt 2 11 Fast Bit Error Rate oO 885 104 DCs 1800
29. aughter board for repair Power off the device and measure the sleep mode current The sleep current value must under If out of the criteria it means the devices is fail and please replace M B or daughter board for repair HTC CONFIDENTIAL pu se hre tort me bile HTC Corporation Doc Title Dream Service Manual 84 84 of 113 113 Conclusion If current consumption is passed at both of flight and power off mode it means the device is GOOD If there is any item FAILED at flight or power off mode it means M B or Daughter board is failed please replace M B or daughter board for repair Measurement parameter Measurement mode Measured Current REMARK Under 180 mA Device is good Flight Mode need to be further repaired Under 3 mA Device is good POWER OFF Sleeping mode Over 3 mA Fail MB or daughter board need to be further repaired 5 2 Battery Test Procedure Battery Test Turn the device power off and insert Diagnostic SD card Press and hold Capture button then press Power button to enter Diagnostic mode Select item Battery Info to check the battery capacity reaa SPACE key to reset HTC CONFIDENTIAL ojo s nrc i smart mobilne HTC Corporation 262 Doc Title Dream Service Manual 85 of 113 SKU amp Calibration Test T Compass Test IV If the battery has been fully Bec o charged please perform the Battery Test Prev Next After one hour check
30. curacy Position lt 15 meters 95 typical Velocity 0 05 meter sec steady state AGPS e Support UE Based amp UE Assisted AGPS e OMA SUPL v1 0 compliance v2 0 if available SUPL RRLP SUPL RRC optional TBD WAP push initiated SUPL e Standard 3GPP AGPS compliance 3GPP TS 44 031 RRLP 5 12 3GPP TS 25 305 GSM 8 UMTS Performance requirement TTFF 95 successful rate lt 20 seconds 2D Location Error 95 successful rate lt 100 m Sensitivity requirement lity HTC Corporation t 9 t 9 HTC CONFIDENTIAL Page 6 6o13 113 4J nTc smart mob Doc Title Dream Service Manual Liquid Indicator Lanyard Strap Hole Accessories e Quick Start Guide Inbox CD User manual amp Sync software Inbox Screen Protector Inbox Travel Charger Inbox Pouch Carrying Case Inbox USB Sync Cable mini USB USB Inbox Battery with battery cover Inbox Wired Stereo Headset Inbox Mono Bluetooth Headset BH M200 Stereo Bluetooth Headset BH S100 Bluetooth Keyboard Car Charger Car Holder Compatibility Test Below 3 party accessories are required to do the compatibility test for all models Mono Bluetooth Headset BH M100 Handsfree Carkit Parrot CK3400LS Parrot MK6100 Parrot Minikit Audi BMW amp Mercedes in car solutions Bluetooth Conference Parrot Conference Bluetooth Speaker Parrot Boombox sanDisk memory cards including SDHC format Android
31. e shooting Chapter 8 Generic Labeling Plan In this chapter you will find generic labels for reference ex Regulation label and battery label etc Chapter 9 Generic Spare Part List and Photos In this chapter you will find Spar parts reference list and photos for repairing including unit and Board level Chapter 10 RF Antenna Specification Reference Spec for RF test HTC CONFIDENTIAL HTC pro corporation ZEM smart mobility Doc Title Dream Service Manual 5 Sof 113 113 1 1 Product Features Platform e slide out QWERTY Internet phone Android platform Dimension e 117 8 x 55 7 x 17 1 mm Processor Chipset Qualcomm MSM 7201a 528 MHz Memory Flash 256 MB RAM 192 MB DDR include 64MB baseband chip LCD Module 3 2 inch 320x480 HVGA resolution 262K color TFT LCD with LED back light OS support 65K color e Capacitive touch screen HSUPA HSDPA UMTS EDGE GPRS GSM Function Internal antenna HSDPA UMTS dual band 2100 1700 2100 MHz and GSM GPRS EDGE Quad band 850 900 1800 1900 MHz HSDPA UMTS v 2100 1920 1980 2110 2170 MHz v AWS band 1700 1710 1755 MHz and 2100 2110 2155 MHz GSM GPRS EDGE v 850 829 849 869 894MHz v 900 880 915 925 960 MHz v 1800 1710 1785 1805 1880 MHz v 1900 1850 1910 1930 1990 MHz e HSDPA 3GPP release 5 compliant UE category 8 up to 2 Mbps downlink e HSUPA 3GPP release 6 compliant UE category 5 up to 2 Mbps uplink e Global roaming Aut
32. ecsenesacauuucsusecuenecseausecacseceeaececaees 17 2 DEVICE DISASSEMBLING AND ASSEMBLING PROCEDURE osssoooooooooooooooooooooooooooooooooooooooo0000ooooo0o0000 18 271 TOOL IP 18 2 2 DISASSEMBLING PROCEDURE cccsececcececccceccccecececuececuucecuucucsenecucuusuceuecsusecuuaessesucecsuausseenseauaucauaecsuaecsucessuaeses 18 2 3 ASSEMBLING PROCEDURE azs cw ik CHE AG ERA EEEE APE a bb bib a Ded sesvedeadankuedadsevedeadackeatesaeGentecscsenenezese DE 38 a ROM RE FLASH PROCEDURE site oni DGA naadi ODAS ROLKA PEER GENIE A 63 3 1 ROM IMAGE UPGRADE THRU SD CARD eee eeaeaew aaa aa aa eene aaa aaa aa sase essai MA MA NEE EEA ese e sese eges se Laanen sapere 63 4 DIAGNOSTIC PROGRAM i a i a EEEE E 65 4 1 LIST OF DIAGNOSTIC ANDROID TEST ITEMS ccccceccececcececcececcccucccecececscueuecuececuenecueaececaeeecauaecauaeceuaecauaenecass 65 S POWER MEASUREMENT TEST 2 eictiecen ioci a a Da 80 5 1 MAIN BOARD LEAKAGE CURRENT TEST PROCEDURE sscsceccecccceccccecccceccccecuececucuenecueaeceeacuecucuecseuecuuaeceuaesaeaenes 80 5 2 BATTERY TEST PROCEDURE csccececcececccceccccecucecuececuececsucecseaeuacuusucueuecsusecsuaesscauaucsuaessecueeaesecueuecsuaecsuenseaeaes 84 6 COSMETIC INSPECTION CRITERIA eee e eee eee e e e reor e eoo eere esse ees ss estote esse totes osse sete esses sete esse esee ee ose esee eeosseeee 86 6 1 CLAS
33. er button to enter 6 Calibration Test Diagnostic mode ezz MR RE MN Using the Vol up or Vol down 7 Battery Info button to select the test item Also you can press the hot key O I to perform the test item Select item Function Test to find the Function test menu o AutoTest 1 Test Auto F T1 Test for Unit SDRAN Test 3 Display Test Button Test 5 LED Test Back Light Test 7 Touch Test SIM Test sliding Test 1 Vibrator Test Headset Audio LoopBack Speaker Audio LoopBack Press the Action key to start the Auto test It will perform the regular tests please follow the system instruction to do the test Receive Audio LoopBack SD Test Battery Info ROM Checksum G sensor Calibration Exit Prev Next HTC CONFIDENTIAL io NTC netus seni BEEN i EE HTC Corporation Issued Date 2008 07 14 smart mobility Doc Title Dream Service Manual 68 68 of 113 113 SD card Test SD Card Test SD Card Test lt SD Card Init 4 Sh Card nii Insert the SD card and follow the svstem instruction to do the test Pls open Key pad Pls close SD door If success press Action key to next or return to Function test menu Vibrator Test Vibrator Test Press Action key to select Vibrator Test on Function test menu Press Action key to next or return to Function test menu Action Next Press Action key to select Display Test on Function
34. er the symptom could be duplicated with another unit 12 Wireless connection WLAN BT not functioning 1 Make sure the wireless environment is OK before connecting to WLAN 2 3 4 Make sure the wireless connection setting has properly set Make a life connection with Internet or another device Try to re flash the ROM code 5 Trv with another main board if necessary 6 Nh NA Once the defective part has been identified verify the defective part again whether the symptom could be duplicated with another unit HTC CONFIDENTIAL Sao B NTCK pro corporation mme smart mobility Doc Title Dream Service Manual 94 94 of 113 113 8 Generic Labeling Plan Main unit 8 1 Agency label DREA100 HTC P N 77H00612 00M regulation label 38 04 X 55 9mm 77H00470 01M barcode label 23 0 X 15 0mm Layer1 regulation label 0 25T printing area 3 DREA100 5V DC 1A o X JW P N XXHXXXXX XX IMEI XXXXXXXXXXXXXXX SINXXXXXXXXXXXX 16 96 HTC Innovation Made in Taiwan Layer2 barcode label 0 05T Tar 15 0 HTC CONFIDENTIAL 4 TC i netus seni SM HTC Corporation Issued Date 2008 07 14 smart mobility Doc Title Dream Service Manual 95 95 of 113 113 8 2 Agency label DREA110 HTC P N 77H00612 01M regulation label 38 04 X 55 9mm 77H00470 01M barcode label 23 0 X 15 0mm Layer1 regulation label 0 25T printing area DREA110 5V DC 1A o X LILU
35. han 4 hours 3 Dismantle the unit and check the appearance of Battery Pack 4 Try with another Battery Pack or Replace Battery Pack if necessary 5 6 Try with another Main Board or Replace Main Board if necessary 058 Once the defective part has been identified verify it again with the defective part whether the symptom could be duplicated 1 Check Sound amp Notifications Settings in the unit for Sound Enabling 2 Make sure it s not MUTED 3 Try to re flash the ROM code HTC CONFIDENTIAL NTC era DEMNM ad ia HTC Corporation Issued Date moon smart mobility Doc Title Dream Service Manual 93 93 of 113 113 4 Clean up the speaker connection side on MB if there is any contamination 5 Dismantle and Check whether the Speaker is properly installed Orientation 6 Replace Speaker if necessary 7 Replace Main Board if necessary 8 Once the defective part has been identified verify it again with the defective part whether the symptom could be duplicated 11 No Recorded Sound or Distorted sound 1 Check Sound amp Notifications Settings in the unit for Sound Enabling 2 Make sure it s not MUTED 3 Try to re flash the ROM code 4 Dismantle and Check whether the Microphone is properly installed 5 Replace Microphone if necessary 6 Replace Main Board if necessary 7 Once the defective part has been identified verify the defective part again wheth
36. he Key pad perform open and close the key pad The screen will go to the next test or return to Function test menu Button Test Press Action key to select Button Test on Function test menu Button Test Bu tton Test Follow the instruction on screen to perform the Button Key test Volume up Volume down Menu Send End Home Back Up Right Action Focus Capture and Keyboard test The screen will go to the next test or return to Function test menu Press Action key to select Backlight Test on Function test menu Press Action key to switch the LCD Level 8 backlight level from Level 0 Level 1 Level 2 Level3 Level 4 The screen will go to the next test or return to Function test menu Act ion Nert HTC CONFIDENTIAL e NTC nettes zona X mr HTC Corporation Issued Date 2008 07 14 Smart mobility Doc Title Dream Service Manual 72 72 of 113 113 Headset Audio Test Press B key or select Headset Audio Test on Function test menu Insert the headset and speaking You can hear the sound output from the headset lt ietion gt Next Press the action to exit the test Press C key or select Receiver Audio Test on Function test menu You can hear the sound output from the recelver Action Mest Press the action to exit the test Select Check WLAN Cal on the menu Check the WLAN ID status if WLAN ID error please go to the Calibration Test Press the action
37. hinge FPC in the bezel Paste the tape on hinge FPC The hinge FPC is recyclable parts after reassembly Adhesive double tape P N 76H02553 00M HTC CONFIDENTIAL e nrc on eee SAL HTC Corporation era Doc Title Dream Service Manual 45 45 of 113 113 Remove the scrap tape of hinge FPC Stick the tape of hinge FPC to hinge Assembly hinge and bezel HTC CONFIDENTIAL B nrc i e HTC Corporation smart mobility Doc Title Dream Service Manual 46 46 of 113 113 Fasten the screws as location indicated Philip Screw Driver 0 SCREW M1 6 0 35 4 8 P N 72H02873 00M Black 2 Or 72H02873 01M White 2 Torque 1 5 0 lkgf c ni Fasten the screws as location indicated Philip Screw Driver 0 HTC CONFIDENTIAL J nTc smart mobilit Doc Title HTC CONFIDENTIAL a Issued Date 2008 07 14 HTC Corporation ETY Revised Date a Dream Service Manual 47 aT of 113 113 SCREW T1 4 2 65 P N 72H00740 00M White 2 Or 72H00740 01M Black 2 Torque 1 54 0 1kgf c m Finish LCM assembly GO NTC pro corporation ZEM smart mobility Doc Title Dream Service Manual 48 48 of 113 113 2 3 3 UI module assembling procedure Put the App Keypad on the UI Cover Install the AP Dome FPC Install the Trackball Switch HTC CONFIDENTIAL G NTE ite Corporati smart mobility orporation A04 Doc Title Dream Service Manual Fasten the screws as location indicated Philip Scre
38. ialer Email Music E3 B FI 15 10 Wireless controls Wi Fi Connected to wlan Wi Fi OE Set up amp manag R SU elect to turn on Bluetooth Bluetooth settings Mal lag skad ieciieidus set device amp dis erability name pian mode el dis ble all wirele onnections Mobile networks Set options for roam ing ne jorks a v Ed Ch ail 48 6 09 PM Total space Unavailable Available space Unavailable NOUI O Internal device storage sees Space 8 MB Factory data reset Erases all data on device ES B Ma 15 11 Bluetooth settings turn on Bluetooth CES xt Select tor device dis Device name T Mobile G1 Bluetooth devices Scanning O m MB Nokia 6021 Pair with this device G NTE ture corporat smart mobility orporation A04 Doc Title Dream Service Manual GPS Test EAR 2 44 PM Settings My Location settings Press Menu button and tap the icon Wireless co Manage WI F ntro Je Is mode amp mobile network Settings Call settings walting caller ID Select Security 8 location 5el iwtones no screen i brightness Require pattern Must draw pattern to unlock screen l Data svnchronization Select Mv Location settings to GPS are xe visible pattern satellites ect which applica Change unlock pattern O AMI 2 45 PM IV Tap the application tab and press the Maps icon to enter to the
39. ilip Screw Driver 0 SCREW T1 4 2 65 SCREW P N 72H002404 00M Torque 0 54 0 1kgf c m Remove the Trackball switch HTC CONFIDENTIAL hre mart mobil HTC Corporation noe Doc Title Dream Service Manual HTC CONFIDENTIAL VERUS i ro owe zooma m HTC Corporation Issued Date 2008 07 14 smart mobility Doc Title Dream Service Manual 30 30 of 113 113 2 2 3 LCM disassembling procedure Unfasten the screws as location indicated Philip Screw Driver 0 SCREW M1 6 0 35 4 8 P N 72H02873 00M Black 2 Or 72H02873 01M White 2 Torque 1 5 0 lkgf c ni Unfasten the screws as location indicated Philip Screw Driver 0 HTC CONFIDENTIAL P gt gt ny AA 7 OIE smart mobi HTC Corporation issued Dale 2008 07 14 Doc Title Dream Service Manual 31 31 of 113 113 SCREW T1 4 2 65 P N 72H00740 00M White 2 Or 72H00740 01M Black 2 Torque 1 5 0 lkgf c m Use the plastic stick to slide through the gap to separate the hinge with bezel Remove the hinge Remove the display FPC Chassis HTC CONFIDENTIAL BTC ire corporat smart mobility orporation A04 Doc Title Dream Service Manual Disconnect the hinge FPC Disconnect the display FPC Remove the receiver ZET LOWE O vdd i T HTC CONFIDENTIAL BTC ire corporat smart mobility orporation Doc Title Dream Service Manual 33 38 of 113 113 Disconnect Touch Panel FPC Remove the LCD
40. kar Deui Description protector w o warning Description iud Ka m message did oa Refurbishment Repair code Return to HTC 36H00375 XXM 71H0235 7 XXM Different P N by Different P N by customer customer Description Switch PANASONIC Refurbishment Refurbishment Return to HTC Return to HTC HTC CONFIDENTIAL nrc in smart mobility C Corporation A04 Doc Title Dream Service Manual 72H00740 01M o 72H02873 00M Screw PH FD M1 6 X ig Description 1 6 Nickel z Description PA 4 Black NYLOK sk NO w Refurbishment Return to HTC Return to HTC 73H20179 41M 73H20132 41M E Different P N by 8 customer en FPC Pre Assy Dispaly i i P gt FPC Pre Assy Hinge Description C GLOBAL FLEX J FPC GLOBAL FLEX Return to HTC Return to HTC 74H01149 0M 74H01155 0M Different P N by sp d HE 13 Different P N by customer customer caan D9 Description CCGA JE CGOLILULIDB E COTULULU U n GHAL Jn Refurbishment Return to HTC Return to HTC 14H01156 0M 74H01157 0M Different P N by Different P N by customer customer Housing Pre Assy D_cover Refurbishment Repair code Return to HTC HTC CONFIDENTIAL Sao e nTc on sone sea iu ELITS HTC Corporation Issued Date 2008 07 14 T smart mobility Doc Title Dream Service Manual 106 of 113 714H01158 XXM 714H01163 XXM Different PN by Er ta a 0G 5 a ae Different P N by customer customer Ke
41. mbient illumination is to be 500 1000 Lux Incandescent lamp c Inspection should be performed under the condition that LCD screen could reflect the mirror image of lamp d The criteria of Newton ring s tinges and measure of area must follow up the worst case sample e The area of Newton ring is smaller than 10 10 square mm Display inspection Inspection Defects Accept Level Bright adjacet p ss adjacent Electrical Characteristic park por Single Total Number 2 S gt 5mm Dark or Bright lines 0 1 1 1 Minor All Allowable Dots Defects Total Number x 3 S 5mm Shift and tilt of screen The black edge around display area must Minor iewed area be detected by front view 0 03 W x 0 1 mm Foreign Scratch Objects or Lint Lint linear foreign objects on power off Defects Minor Singe Red Green Blue 3 S gt 5mm 6 2 Main unit inspection GAP INSPECTIONS Gap between each key and Can t stuck up or no click feeling ME parts It couldn t allow stuck up at pressing process EE ASAIERCZAT Gap between all generic ME parts lt 0 4 mm HTC CONFIDENTIAL s hrc mart mobility HTC Corporation Doc Title Dream Service Manual 88 88 of 13 113 3 a P PEE o Gap between B C parts lt 0 5 mm sliding cover phone DTI DIO AL Others refer to production release spec release spec STEP INSPECTIONS L step between mating parts Step 03mm 00000 0 3 mm
42. o an electrical outlet and connect the other end to the USB port at the bottom of the device Keep connected for at least three hours 2 o power on your device press amp hold the PWHR button E To power off press amp hold the PWR button 3 seconds From the menu that opens either tap Power off with your finger or select it using the trackball HTC CONFIDENTIAL Sao a hrc smart mobility HTC Corporation A04 Doc Title Dream Service Manual 15 of 113 When your device is turned off charging is indicated by a solid amber light on the LED indicator When your device is turned on charging is indicated by a solid amber light on the LED indicator as well as a charging icon 4B on status bar After the battery has been fully charged the LED indicator becomes green and a full battery icon appears on status bar Home screen Status bar Notifications BO EA 8 49 AM 4 Connection status slide your fingertip down the screen to u read details r For horizontal orientation rotate your device or open the Today dde i Ana display to reveal the keyboard is revealed when you 7 A ra tap notifications Alarm Clock Browser Calculator Calendar Contacts Dialer Gmail Home In Maps Market Messaging Recent applications Tap any icon window s T FR to start using the opens when you press amp hold the HOME button application Favorite eo 2 Tap Applica
43. o band switching Handover and cell selection between GSM GPRS EDGE and UMTS DTM SAIC circuit switch only Equalizer HSDPA channels only Audio codec AMR NB EFR FR HR SMS MO MT concatenated SMS 640 characters support MCC MNC UC ID as stated in 3GPP TS 25 401 R98 Section 6 for both RIL and radio Generic Services Call holding waiting forwarding Call barring CLI Calling Line Identity HTC CONFIDENTIAL 4J nTc smart mob Doc Title Dream Service Manual Display own number Network selection Cell broadcast Multi party conference call Spool icon Phase 2 unstructured supplementary service data Network Lock USSD CPHS EGPRS functionality EGPRS class B Multi slot standard class 12 PBCCH Link Adaptation and Incremental Redundancy USIM SIM 1 8 3V of UICC USIM Application at least according to 3GPP TS 31 102 SIM Application Toolkit release 99 EAP SIM Over the Air OTA programming FDN ADN SDN security Pin 1 amp 2 control Standalone GPS e Internal GPS antenna e sensitivity 145 dBm for cold start and 155 dBm for tracking e Support NMEA 0183 version 3 0 or above Dynamically allocate parallel channel GPS receiver e Acquisition time Hot start 8 seconds typical TTFF open sky amp static condition Warm start 60 seconds typical TTFF open sky amp static condition Cold start 75 seconds typical TIFF open sky 8 static condition Update rate once 1sec default e GPS Ac
44. omer Specific Applications Regulatory RETTE EMC EMI Safety SAR European Union FCC approval E USB Certification BQB Certification e Wi Fi Certification e CB Certificate report International GCF Certification European Union LI Note Not ready dependent on Google HTC CONFIDENTIAL a nT on stone sea HTC Corporation Issued Date 2008 07 14 T smart mobility Doc Title Dream Service Manual 9 of 113 1 2 Product overview Front panel Earpiece Listen to a phone Notification LED call from here u a nja n a MODI LCS Touch Screen Keyboard MENU CALL O 3 END CALL POWER HOME i BACK TRACKBALL HTC CONFIDENTIAL BTC pro corporation ZEM smart mobility Doc Title Dream Service Manual 10 10 of 113 113 Back panel 3 2 Megapixel Camera speaker i e 9 Back Cover N m P HTC CONFIDENTIAL Sao a nrc on sone sea HTC Corporation Issued Date 2008 07 14 T smart mobility Doc Title Dream Service Manual 11 of 113 Top panel Back Cover Release Tab Bottom panel Microphone f D PC Connector Earphone Jack Flip open the coverto connect the supplied USB cable and transfer files or to plug in the AC adapter and recharge the battery You can also connect the supplied USB stereo headset for hands free conversation or for listening to music and videos HTC CONFIDENTIAL gn HTC Corporation smart mobility
45. r 0 HTC CONFIDENTIAL m Sao nrc 07 14 smart mobility HTC Corporation A04 Doc Title Dream Service Manual 54 of 113 SCREW T1 6 6 P N 72H02403 00M 2 M QAO Ay Torque 0 44 0 1kgf c m Put the rubber on the device Connect the Camera FPC with main board and attach 1 tape to the connector Tape P N76H02529 00M 1 HTC CONFIDENTIAL e hre on eee smart mobility HTC Corporation era man Doc Title Dream Service Manual 55 55 of 113 113 Connect the hinge FPC with main board Paste gaskets on the hinge FPC Gaskets P N 72H02481 00M 2 HTC CONFIDENTIAL g_ hre 07 14 ae mebi HTC Corporation m Doc Title Dream Service Manual 56 of 113 gt a Assembly main board with C cover 1 Connect the Qwerty Keypad FPC with main board 2 Connect the daughter board FPC with main board Connect the cable with UMTS board Connect the cable with main board HTC CONFIDENTIAL igo EG hYTc era a HTC Corporation Issued Date moon smart mobility Doc Title Dream Service Manual 57 57 of 113 113 Put the cable into the hooks and Attach 2 tapes to the connector Tape P N76H02529 00M 2 Connect the cable with GPS board HTC CONFIDENTIAL Sao NTC 07 14 smart mobility HTC Corporation A04 Doc Title Dream Service Manual 58 of 113 Connect the cable with main board Fasten the Screw s as the location indicated HTC CO
46. rk notification Notify available ynnect to data services when roaming Wi Fi settings Set up amp manage wireless access points Bluetooth Select to turn on Bluetooth Bluetooth settings Manage connections set device name amp discoverability Airplane mode Select to disable all wireless connections Mobile networks Set options for roaming networks ADAIc AFIN EJ finance yahoo com Yahoo Finance fahoo My Yahoo Mai YAFHOO FINANCE More w NEWS amp OPINION GG GET Quotes INVESTING me when an open network is Wi Fi networks wlan Connected HTC Guest Open network Free Stock Symbol Lookup Scottrade Leading stock research MARKET SUMMARY us ELG ASIA NI 11 268 92 38 19 0 34 11400 59P 18 59pm Guest Open network HTC Computer Secured with WEP AM 19 01 ka Sound settings Silent mode All sounds except Select a ringtone media are silenced Ringer volume Cot wu gt EL VI olume for incoming calls Bell Phone Media volume Phone vibrate Vibrate phone for incoming calls Set volume for music and videos Bentlev Dubs Bird Loop Caribbean Ice Notification ringtone Set vour default notification ringtone Audible touch tones ii n a hre i smart mebi HTC Corporation m Doc Title Dream Service Manual RF Test M 12 35 PM wiitek Dialer Calllog Contacts
47. rnat to GPD 4pich AMSIOIGAPAMASONCDIABAVSGndim 75HO7G500M Connector 5 t0 16 dptch AXTBIBIBA PANASONIC DSA BOV SOmehm 31 7640076300M Connector FPC26P DJPIENDJABIVFFI ZEARTIBDDKU ao SIDE A PHOTO AND COMPONENT LOCATION a m LEER m HTC CONFIDENTIAL do e nTc on sone sea HTC Corporation Issued Date 2008 07 14 T smart mobility Doc Title Dream Service Manual 111 of 113 51H40446 XXM PCBA MAIN BOARD Side B Description Q y Remark Connector Device Battery conn 3P 2 5pitch 2SO089MBOUS64004L SUYIN O54 SY 50maehm TEHXVGLOUM Connector FPC 31E D aptoh FFI SIARMBDDKO2AWW p 1 76HDD78400M Connector B to B 60P D Apich AXT3B0164 PANASONIC J3ABIVSDm m 1 36600665 00M VibratorGHT S205 SANVO SMT E LL SIDE B PHOTO AND COMPONENT LOCATION HTC CONFIDENTIAL e nc EIN HTC Corporation Issued Date 2008 07 14 AGA smart mobility 7 Revised Date 2008 10 20 Doc Title Dream Service Manual 112 of 113 10 RF Antenna Specification Uplink Downlink Tx Level UA RE CH Item Test Mame let Downlink note cell power a e Campo Ww CD DHA Band AWE BS Cripinate Cell 1312 1537 1312 1527 Receiver Test 1312 1527 145071675 Sis 17856 104 104 104 Fast Bit Error Fate Fast Bit Error Fate Fast Bit Error Fate Un W Transmitter Test BS Orisinate Cell Fast Bit Error Rate O4 Fast Bit Error Rate O4 F
48. s document should not be revealed to any third party Chapter 1 Introduction This Chapter is about Products features and basic Product function After reading this chapter you will know what feature the product has and basic hardware operation Also you will know how to perform soft rest and hard rest in this chapter Chapter 2 Device Disassembling and Assembling Procedure After reading this chapter you will learn how to disassemble and assemble the product Also you will know what tools to use and the torque Please follow the instruction to disassemble the unit to prevent from damaging the unit Chapter 3 ROM Re flash Procedure After reading this chapter you will learn how to perform the ROM image re flesh by using RUU and SD Card Also you can find the steps of enter the boot loader mode e Chapter 4 DIAGNOSTIC PROGRAM After reading this chapter you will learn How to use the diagnostic program to perform unit function test e How to test some functions in Windows Mobile mode ex WLAN Bluetooth and USB etc Chapter 5 Power measurement test After reading this chapter you will learn how to use leakage test procedure and Battery test procedure Chapter 6 Cosmetic Inspection Criteria After reading this chapter you will learn the appearance quality inspection criteria ex Display bezel and housing etc Chapter 7 Generic Troubleshooting After reading this chapter you will learn how to do generic troubl
49. t applications dock 2 u 4 ap APP di Ps aJ biways visible oe cese asd with your fingertip to reveal hide the application icons HTC CONFIDENTIAL P gt NTC Umart mobili HTC Corporation era Doc Title Dream Service Manual 16 16 of 113 113 e To perform a soft reset Press Call Menu power button at the same time Menu 4 Capture Call End call Power Trackball e To perform a hard reset Warning Your device will be set back to factory default settings Please ensure any additional installed programs and or user data have been backed up before a hard reset is performed 1 Power off the device 2 Press and hold Home Back Button then press Power Button 3 Press Call Button to double confirm hardware reset HTC CONFIDENTIAL enc on pestes sema lity HTC Corporation Issued Date 2008 07 14 T smart mobil Doc Title Dream Service Manual 17 of 113 1 3 Product service flowchart for Dream Incoming KALA devices Receiving Diagnosis Data upload Fail Failure Codes amp Fail Repair Actinns Data Pass Fail Diagnostic test Pass Replace ME ar WLAN calibration daughter board process Ves PH m a Fail Afr amp RP test Pass Cosmetic Fail Fail sampling Data Packing Pass Shipping HTC CONFIDENTIAL enc on pestes sema HTC Corporation Issued Date 2008 07 14 T
50. to exit Prev Next HTC CONFIDENTIAL d nrc smart mobility HTC Corporation A04 Doc Title Dream Service Manual 73 of 113 Calibration Test After replace M B or daughter board the device should go to the WLAN calibration process Download calibration program and data from SDO http htcscm10 htc com tw SDO GERARELN dj e gurkk rdg g nissrassie Umrg dus Ill Un zip the file to CASFC Note Don t un zip the data to third layer The chip date will be updated and upload to SDO by week Please download them from SDO once per week WLAN Calibration 1 Disable ActiveSync in Windows before running WLAN calibration 2 Execute the ASP IV Execute the ASP calibration station n O Calibration Station program in the computer program in the computer Notice Remark You can perform WLAN calibration for 4 units by 1 computer at same time HTC CONFIDENTIAL Quo L ABA HTC Corporation smart mobi A04 Doc Title Dream Service Manual 74 of 113 Connect the device and computer via USB cable Select Calibration Test on the menu and start the calibration VII The program will automaticallv run and exit when finish the process Note If the display show Get SFC data error it means can not found the chip data in the SFC folder please download all data from
51. tom could be duplicated with another unit HTC CONFIDENTIAL m NTC eius somma HTC Corporation Issued Date 2008 07 14 smart mobility Doc Title Dream Service Manual 91 91 of 113 113 1 Check the connection of LCD FPC whether is properly connected 2 3 4 5 6 7 8 Try to cold boot the unit then tries again Try to re flash the ROM code Try with another LCD Try with another Main Board Replace LCD if necessary Replace Main Board if necessary STF ar ll N Once the defective part has been identified verify it again with the defective part whether the symptom could be duplicated 1 Check the connection of LCD FPC whether is properly connected 2 Try to re flash the ROM code 3 Try with another LCD 4 Try with another Main Board 5 Replace LCD if necessary 6 Replace Main Board if necessary 7 Once the defective part has been identified verify it again with the defective part whether the symptom could be duplicated 1 Check whether CF SD Card is fully inserted to the slot until you hear a click 2 Try to re flash the ROM code 3 Try with another CF SD Card 4 Try with another Daughter Board 5 6 7 8 Try with another Main Board Replace Daughter Board if necessary Replace Main Board if necessary NN TN NN c c M AM M me So No Once the defective part has been identified verify it again with the defective part whether the symptom
52. vice Manual 81 81 of 113 113 3 Test Jig Jig F 3 pins Long for Dream Equipment set up Connect control box and jig through 4 colors cable Set up each button by row A D according to product specification Following is an example for Dream Button set up matrix MADEL JIG TYPE It means press button A 1 B 8 C X D 0 X Don t care the Dream battery only 3 pins HTC CONFIDENTIAL d nrc i smart mobility HTC Corporation A04 Doc Title Dream Service Manual Install the jig to device Turn on control box power button ad r 4 4 1 4 mmm Press power button to turn on the Device 4 x ORT GAKIWIKAKFACZFACI La n Y DINE HTC CONFIDENTIAL Sao e nTc on sone sea HTC Corporation Issued Date 2008 07 14 T smart mobility Doc Title Dream Service Manual 83 of 113 Idle current test a 8 U OAM e 11 59 am GMa 17 37 Wireless controls Wi Fi D 1 Set the device to airplane mode Select to turn on Bluetooth 2 Set the brightness to minimum Press Network settings MENU gt Settings gt Sound 8 display gt Brightness Call settings Set up voicemail call forwarding call waiting caller ID Mobile networks Set options for roaming networks APNs Wi Fi settings li g My L z Measure the idle mode current The idle current value must under If out of the criteria it means the devices is fail and please replace M B or d
53. w Driver 0 SCREW T1 4 2 65 SCREW P N 72H002404 00M Torque 0 5 0 lkgf c m Install the rubber on the Microphone Attach one tape on daughter board TT z LL m m HTC CONFIDENTIAL i af gt G NTE uro corporat IN smart mobility orpora lon A04 Doc Title Dream Service Manual 50 of 113 Tape P N76H02529 00M 1 Connect the AP Dome FPC with the daughter board Install the SD cover Fasten the screws as location indicated Philip Screw Driver 0 HTC CONFIDENTIAL i n a hre i smart mebi HTC Corporation m Doc Title Dream Service Manual SCREW T1 4 2 9 SCREW P N 72H02663 00M 2 Torque 0 6 0 lkgf c m Finish UI module assembly HTC CONFIDENTIAL EG hTC netus moni mr HTC Corporation Issued Date 2008 07 14 smart mobility Doc Title Dream Service Manual 52 52 of 113 113 2 3 4 Module assembling procedure Pass the hinge FPC through the hole on the C cover Fasten the Screws as the location indicated Philip Screw Driver 0 Screw hinge PH BIH MI 6 2 P N 72H00624 01M 4 Torque 1 5 0 lkgf c ni HTC CONFIDENTIAL dn a hre i smart mebi HTC Corporation m Doc Title Dream Service Manual r WA 4 t R D ds Siljo E M 4 uu d R z JE P m t B Combine the UI module FPC with C cover Assembly UI cover through hinge track Fasten the Screw s as the location indicated Philip Screw Drive
54. y test IX 3 IDisplav Test Color bar R G B Black White Gray pattern Send Home Return End Power Menu Button Test Volume up Volume down Up Down Left Right Action Capture QWRERTY Key test LED Test ed Green Blue UI Key Led ack Light Test ack light test Level 0 1 2 3 4 y Touch Test Touch panel test Vibrator Test ibrator on test D door test SD card Read Write test 0 iding Test OM checksum IM card test sensor calibration Audio Test eadset Receiver audio test Hour Run in Test Hours Run in Test Hours Run in Test Hours Run in Test O O O O o o o o jo o o ET DA lt Diagnostic Q I HTC CONFIDENTIAL Dodo g NTC i mart meb HTC Corporation A04 Doc Title Dream Service Manual USB Test USB link test GPS Test GPS test WLAN Test WLAN test Speaker Test Speaker test NEN 3 Bluetooth Test Bluetoothtest P NEN NEN EA p HTC CONFIDENTIAL i hre HTC Corporation A04 smart mobili Doc Title Dream Service Manual 67 of 113 Test Procedure How to select test item Using Vol Up or Down to select the test items How to execute the test program Press Action button to start each of test items Diagnostic Main Menu Function Test Menu A Fu nct i ion Turn the device power off and insert E nod Diagnostic SD card Sea Press and hold Capture button then km ia cat press Pow
55. ypad Pre Assy QWERTY Bezel Pre Assy A Description Description Return to HTC Return to HTC 74H01 164 0 74H01172 gt 0M Different P N by Different P N by customer customer Keypad Pre Description Assy APP key Refurbishment Repair code Return to HTC 16H02929 00M Rubber LED to A cover Description 16H03274 00M 16H02553 00M Adhesive Double Tape Adhesive Double PARZE Tape Hinge FPC Description Refurbishment Refurbishment Yes Repair code Return to HTC HTC CONFIDENTIAL Sao e nTc on stone sea i sa HTC Corporation Issued Date 2008 07 14 T smart mobility Doc Title Dream Service Manual 107 of 113 1H02353 0M 1H02352 0M Different P N by Different P N by customer customer Chassis Display FPC Chassis Hinge FRC p Ma Description me 79H0005520 M l Different PIN by 73H00296 01M customer Cable 60 45 16 200 MEC DC U200 08 ID z uszzzzzsa 70H00177 XXM Different P N by 36H00582 01M customer b Earphone COTRON C HM 311STV08002 54H20043 X XM Different P N by 54H20003 00C customer Samisk 72 Micro SD 1 0c8 Consign Module Card 1GB TMUS wico fi ero Assy SIM Card ntent w o plastic case Module T MOBILE US HTC CONFIDENTIAL do G NTC gro corporat TEM smart mobility orpora lon A04 Doc Title Dream Service Manual 108 of 113 35H00106 01M BATTERY Ll ION 1150mAh 3 7V S ANYO DYNAP

Dream Service Manual - Mike Channon`s Directory of HTC Service

Contents

Download Pdf Manuals

Related Search

Related Contents