manual ferlux _30-04-12
Contents
1. COMPRADOR COMPRADOR PURCHASER Nombre Nome name 4 Direcci n Morada mailing address 5 5 5 5 4 Codigo postal C digo postal post code pp Poblacion Local dag6G7 on Telefonoy Teleioney IONS peace ice linia acidosis ip caia Pals Pals on VENDEDOR INSTALADOR SELLER Sello del vendedor Carimbo do instalador seller stamp Denominaci n del aparato Nome do equipamento equipment name Referencia Refer ncia reference MUY IMPORTANTE MUITO IMPORTANTE VERY IMPORTANT La garant a s lo es v lida A garantia apenas v lida The guarantee is only valid Si se respetan las reglas contractuales Se as regras contratuais forem respeitadas If the contractual rules are respected Si el presente certificado est rellenado Seo certificado estiver preenchido H the present certificate is filled correctamente y completamente y si se ha correctamente e for devolvido dentro de 10 correctly and completely and if it is devuelto dentro de los diez d as dias seguintes a instala o compra returned within the ten days after the siguientes a la fecha de compra purchase date 192. El vent air T MIN OVERLAP intake 24 40 mm la z p 4 1 er eye A 2 MIN OVERLAP sa Pd i E AL 4 0 mm ee 14 Li Fi EE El Ta AAA NEVER ALTER THE DIAMETER OF THE VENTILATION DUCT If a chimney connector 1s used its full length must be visible whether directly or through a door or grating in the chimney breast It is also essential to ventilate the area between the top of the fireplace and the ceiling either frontally or laterally by means of gratings or diffusers with a cross section of at least 100 cm INSTALLATION IN A NEW OR EXISTING CHIM NEY The appliance can be inserted into any fireplace built of incombustible materials and in good condition The appliance must be installed in a floor resistant enough to support the appliance weight without problem It is important to place the air vent grill in such a way that it cannot become obstructed No part of the existing masonry should nor may be removed to increase the space in order to insert the appliance Any defect or deterioration in the fireplace masonry must be suitably repaired before installing the appliance Openings and gaps between the exterior wall masonry and the fireplace masonry must be permanently sealed with refractory mortar All materials on or within the walls floors walls ceilings around t
3. 6 This Commercial Warranty is valid under the aforesaid conditions for the above stated periods In no case shall FERLUX be liable for any damage caused to persons or things by improper handling or use of the appliance In all cases the warranty holder shall have all the minimum rights provided in law 7 FERLUX reserves the right to make any modification in the manual without prior warning 8 Consumers wishing to exercise their rights under this Commercial Warranty may lodge claims by any of the following means E mail Web Tel Fax Mailing address 18 GARANT A GARANTIA WARANTEE CHIMEMEAS BARBACOAS CERTIFICADO DE GARANT A CERTIFICADO DE GARANTIA COMMERCIAL WARRANTY La presente Garant a Comercial se otorga sin perjuicio adem s de cualesquiera de los derechos reconocidos por la Ley 23 2003 y RDL 1 2007 frente al vendedor Para ejercitar sus derechos de conformidad con esta Garant a Comercial el comprador deber rellenar este certificado en el punto de venta en el momento de la compra y presentarlo junto con la factura ticket de compra o albar n de entrega A Garantia Comercial se outorga sem preju zo de quaisquer direitos reconhecidos pela Lei 23 2003 e RDL 1 2007 de Espanha Para que os direitos da garantia comercial sejam activos dever o comprador entregar o presente certificado preenchido com uma c pia da factura tal o de compra ou documento comprovativo de compra This Commercia
4. FER UX CHIMENEA E BARBACOAS BLOQUES DE FUNDICI N BLOCOS DE FUNDICAO FIREPLACE IN CAST IRON Modelos Modelos Models C 19 C20 C21 C40 701 710 720 715 725 726 727 801 810 820 830 835 840 705 805 825 CASSETTES CASSETTES INSERTS Modelos Modelos Models ZEUS 730 SIRIUS ASTRO 735 ORION 740 ATMOS 750 752 753 OMIX 754 1103 755 760 850 860 F 800 F 900 F 1000 HOGARES DE CHAPA FOGOS ABERTO EM CHAPA FIREPLACE IN STEEL Modelos Modelos Models SERIE S SERIE E SERIE F S 50100 PRACTIC 80 HORNO FORNO 60 ACORDE CON LA NORMA EUROPEA ACORDO COM A NORMA EUROPEIA ACCORDING TO THE EUROPEAN STANDARD UNE EN 13229 INSTRUCCIONES DE INSTALACI N USO Y MANTENIMIENTO INSTRU ES DE INSTALA O USO E MANUTEN O INSTRUCTIONS FOR INSTALLATION USE AND MAINTENANCE NOTA IMPORTANTE NOTA IMPORTANTE IMPORTANT NOTICE Todas las reglamentaciones locales incluidas las que hacen referencia a normas nacionales o europeas han de cumplirse cuando se instala el aparato Todas as regulamenta es locais que fazem refer ncia s normas nacionais e europeias devem ser cumpridas no acto da instala o do aparelho All local regulations even those referring to national or european norms must be fulfilled when Apreciado Cliente FERLUX Chimeneas y Barbacoas le felicita por adquirir uno de sus productos realizados para satisfacer a la clientela m s exigente cumpliendo
5. Tal ie AMBIENT VENTED AIR CAVITY 49 mm DOF FLOR EXTERIOR AIR INTAKE 40 mm Smoke may emerge from the appliance on lighting the fire if for example the ventilation system causes draw down in the room where it is located This generally occurs in rooms equipped with CMV Conventional Mechanical Ventilation air extraction systems cooker hoods etc Operation of a chimney equipped with a closed fireplace or insert requires an additional supply of air to that necessary for the regulation air renewal Spanish order of 24 March 1982 11 FER UX ENG It is advisable to check that the air required for combustion may be taken in sufficient quantity from the room in which the fireplace is located When the construction of the building is such that the normal air intake of the room does not meet the combustion and ventilation air requirements an external air supply must be assured by means of permanent openings with a minimum size of 200 cm This these opening s must A Communicate directly with the exterior eee ee AN 7777 B Or communicate with a space that opens onto the exterior C Or communicate with a space that allows sufficient air to penetrate from the exterior fa CLOSABLE OUTLETS Note distribution of the hot air Great care must be taken in the case of new buildings designed for electrical type CHIMNEY BREAST ENTRY OF AIR FROM heating which are heavily insulated and above all w
6. es indicadas nas instru es de instala o e uso fornecidos com o seu equipamento Para garantir e ajustar s seguran as do cliente final 5 Exclus es Esta Garantia Comercial n o incluiu o vidro do aparelho uma vez que este foi submetido a uma s rie de provas e testes de qualidade durante o processo de fabrica o garantido a sua durabilidade e resist ncia Suportando a uma temperatura de 750 C a qual nunca ser alcan ada na c mara de combust o Por este modo o vidro encontra se exclu do da garantia em caso de ruptura O vidro s quebra por m utiliza o ou por impacto Tamb m n o est o inclu das em garantia as juntas que s o pe as de desgaste assim como as pe as dentro da c mara de combust o que estejam em contacto directo com a combust o tais como placa de fundo decorativa grelha de cinza deflector para lenhos puxador e etc Os danos produzidos pelo uso de qualquer outro combust vel distinto da lenha n o ser coberto pela garantia comercial Esta garantia n o inclu a instala o o primeiro funcionamento as desinstala es as instala es incorrectas voltagem inadequada ou descargas atmosf ricas raios assim como manipula es por pessoas ou empresas n o autorizadas 6 A presente Garantia Comercial v lida nas condi es indicadas anteriormente A FERLUX n o respons vel em nenhum dos casos por eventuais danos produzidos a pessoas ou objectos
7. A presente Garantia Comercial oferece a repara o gratuita de qualquer avaria por defeito de fabrico atrav s do Servi o de Assist ncia T cnica Autorizado incluindo as pe as de substitui o a desloca o e m o de obra do SAT n o se inclui em garantia S estamos obrigados troca gratuita dos elementos defeituosos depois termos inspeccionado e controlado pelo nosso pessoal t cnico e sempre que n o tenham verificado nenhuma das exclus es da garantia Se a troca dos elementos for um valor muito elevado a repara o n o seja satisfat ria e que seja verificado que as condi es ptimas n o sejam destinadas para o seu uso a que esteja estudado o titular da garantia tem o direito substitui o do objecto por outro de caracter sticas id nticas ou devolu o do valor pago Condi es aplicadas de acordo com a lei do consumidor nos locais vigentes 2 O prazo de validade contado a partir da data da compra v lida Cinco anos para todos os elementos de ferro fundido que fabricamos Dois anos para todos os componentes distintos da fundi o tais como ventiladores interruptores fios el ctricos domin e etc parte el ctrica 3 A garantia n o v lida se n o estiver acompanhada da correspondente factura de aquisi o do aparelho devidamente rubricada e carimbada pelo estabelecimento autorizado 4 A Garantia s v lida se o produto for utilizado segundo as regras e recomenda
8. N T CNICA INFORMA O T CNICA TECHNICAL INFORMATION COTAS DIMENS ES MEASUREMENTS mm L MODELOS MODELOS MODELS 0 COTAS DIMENS ES MEASUREMENTS mm L 0 F s s Hi P H gt H P kW P2 R kg Pa m CO2 06 LL FUNCIONAMIENTO FUNCIONAMENTO WORKING kW R kg Pa C LL 15 FELIX INFORMACI N T CNICA INFORMA O T CNICA TECHNICAL INFORMATION CHIMENEAS Y BARBACOAS 70 80 90 100 PRACTIC 80 HORNO FORNO 60 kW Potencia t rmica nominal Pot ncia termica nominal Rated heat capacity R Rendimiento Efici ncia Efficiency kg Peso del aparato Peso do aparelho Appliance weight Pa Depresi n del tiro ideal para la potencia t rmica nominal Depress o ideal de tiragem de fumos Ideal chimney depression m Caudal m sico de humos g s Caudal m ssico de fumos g s Mass flow rate of solid combustion product g s CO2 Concentraci n media de CO2 funcionando a la potencia t rmica nominal Concentra o media de CO2 funcionando na pot ncia t rmica Average concentration of CO2 functioning with a nominal thermal power 2C Temperatura media de los humos Temperatura m dia de fumos Average combustion product temperature c Carga de le a para 1 hora de funcionamiento Carga de lenha para 1 hora de funcionamento Load 1 hour performance LL m Longitud de los le os Tamanho
9. and 1f necessary remove it To avoid daily creosote formation and prevent build ups we recommend a hot fire from time to time with the fireplace door closed Only use suitable equipment for cleaning your chimney and ensure that others do likewise Sweep the chimney twice a year GENERAL INFORMATION Consult your local authority building inspector fire brigade or insurance agent to find out what regulations are applicable in your area They will also be able to inform you about inspections of your installation Read these instructions carefully before installing the appliance Mistakes can cause damage to people and property Keep these instructions INSTRUCTIONS FOR USE FUEL AND ADDING MORE FUEL To obtain efficient working of the fireplace use only wood that has been dried for a minimum of 2 years It is advisable to use dried firewood from beech holm oak olive tree or any other with similar caloric features Hardwoods are preferred to softwoods such as poplar willow aspen etc Only use dry wood with less than 20 humidity Green wood produces less heat and more creosote Green wood and wet wood also suffocate the fire and lead to abnormal creosote build up which can cause chimney fires Solid mineral fuels such as coal etc must not be used Neither must tropical woods such as mahogany framire okabe etc The use of chemicals or liquids such as oil alcohol fuel oil naphthalene etc as fuels or fire lighters 1s also fo
10. certain degree controlled by the thermostat Position I Constant working in slow speed Position II Constant working in fast speed The regulation of flow of air in models 760 F 900 amp F 1000 is made manually with a potentiometer provided with the appliance It must be installed according to the diagram enclosed To regulate the flow of air you have to turn the potentiometer When reached the minimum point you will hear a click by means the ventilators will stop and will start again automatically when a certain temperature is reached in the chamber controlled by the thermostat Ventilators are provided with each FERLUX inserts and have the following features 220 230 V 50 19 W 24 W with potentiometer Protection Degree IP54 IMPORTANT The ventilators must be always connected to the power supply 13 CHIMEMEAS Y k AREA OA INFORMACI N T CNICA INFORMA O T CNICA TECHNICAL INFORMATION BLOQUES DE FUNDICI N BLOCOS DE FUNDI O FIREPLACES IN CAST IRON MODELOS COTAS DIMENS ES MEASUREMENTS mm FUNCIONAMIENTO FUNCIONAMENTO WORKING MODELOS MODELS L F 5 P H kW R kg Pa m CO2 LL 720 COSMOS 700 14 CHIMENEAS F CASSETTES DE FUNDICI N CASSETTES DE FUNDI O INSERTS IN CAST IRON FUNCIONAMIENTO FUNCIONAMENTO WORKING MODELOS MODELOS MODELS 730 SIRIUS ASTRO 735 3C AP LAT ORION SERIE SERIES k FARBACOAS INFORMACI
11. de troncos Logs length Pe P HOGARES DE CHAPA FOGOS ABERTO EM CHAPA FIREPLACES IN STEEL CASSETTES CASSETTES INSERTS 16 L R RESISTENCIA M TURBINA 230 V 50 Hz 20W T TERMOSTATO L INFORMACI N T CNICA INFORMA O TECNICA TECHNICAL INFORMATION ello marilleiyellows BARBACOAS O 00 LO 00 N LO LO N LO N LO T N LO N LO N N LO N O N 0 LU N 9 A FERUIX CHIMENEAS F POTENCIOMETRO MANGUERA 2 ALIMENTACION 7 s wa 2 MARR N s 3 NEGRO 4 AZUL MANGUERA 5 HILOS F800 F900 F1000 TURBINA TURBINA mos sap mo ia te 17 FER UX CHIME WE AS F BARBACOAS GARANT A GARANTIA WARANTEE CONDICIONES GENERALES DE ESTE CONTRATO DE GARANTIA COMERCIAL 1 La presente Garant a Comercial ofrece la reparaci n gratuita de cualquier aver a por defecto de fabricaci n en el Servicio T cnico Autorizado incluyendo la mano de obra y piezas de recambio el desplazamiento del personal del Servicio T cnico Autorizado no se incluye S lo estamos obligados al cambio gratuito de los elementos reconocidos defectuosos despu s de haberlos inspeccionado y controlado por nuestro personal t cnico y siempre que no hayan concurrido ninguna de las exclusiones de la garant a Si el c
12. of any obstruction at all times To avoid the risk of accidental fires we advice to take protection measures as keeping flammable objects well away from the appliance and thermal insulation The minimum distance from inflammable materials must be at least 1 5 m to the front of the fireplace Keep the same security distance with damp clothes put close to the fire to dry The fireplace and surround must not be installed in a place where there is heavy movement To avoid accidents tell the children that the fireplace gets very hot when is being used and advise them not to touch it Do not put the residual ashes on top of materials that could burn such as paper cardboard or wood The ashes can remain hot for a very long time The first time the fire is used it 1s important not to touch it until it is cold to allow the paint to seal It is normal when the fire is first used for smells and smokes to be given off until the paint joints are well sealed We therefore recommend that windows are left slightly open during this time It is dangerous to overheat the appliance Blazing fires of twigs kindling vine shoots straw cardboard etc are definitely not advisable Do not burn refuse plastics etc Do not build the fire high The combustion chamber must not be removed or taken apart Never use the appliance without the ashtray cleaned up in order to avoid the deformation of the cast iron grill base which wi
13. the spaces below with the supplier information regarding purchase date and maintenance registration for easy future reference We also recommend that you attach the proof of purchase to this manual as this will be required for any claim under the guarantee e Fecha de compra Data de Compra Purchase date e Distribuidor Instalador DG o Nombre Nome Name 2 o Direcci n Morada AQaoress 4 o Tel fono Telefone Telephone number REGISTRO DE MANTENIMIENTO REGISTO DE MANUTEN O MAINTENANCE REGISTER e Fecha de engrase de las bisagras Data da Lubrifica o Hinge lubrication date e Piezas de recambio Pe as Substitui o Spare parts Ed 30 04 12 FER UX ENG CHIMENEAS Y BARBACOAS DESCRIPTION The appliance is composed of a number of cast iron parts fitted together with special overlap joints and sealed with refractory cement The unit is held in place by nuts and bolts ingeniously placed on the outside of the heating chamber The sheet metal fireplace joints are hermetically welded All the appliances work through the process of intermittent combustion HOW THE FIREPLACE AND INSERT WORK e FIREPLACE The fireplace has a built in secondary air heat exchange system composed of fins on all the st
14. throughout There must be no more than two changes in direction and their angle must not be greater than 45 from vertical for chimneys up to 5 m or 20 for those of greater height INSERTS FIREPLACE Thana i E Eee 1 F a mid 10 FER UX CHIT E WE AS BARBACOAS ENG In the case of a tall flue over 1 8 m it is advisable to locate a clean out door in the chimney to facilitate soot removal using a vacuum cleaner The draught created by the flue must be adequate but limited The draw down at the bottom of the flue should be 5 10 Pascals which almost always means that a suitable damper will need to be installed The damper must always be visible and accessible from the room in which the fireplace is located and must be self closing when the draught pressure drops Check the condition of the existing flue carefully as many are too old or inappropriate an unusual build up of dirt could present a hazard or the most frequent case they may not be suitable or designed to withstand the smoke temperatures of around 500 C that have been measured in fireplaces with a lively fire An over sized flue can be too large to heat up and can therefore cause fireplace performance problems To avoid these we recommend re lining the entire flue in these cases CHIM NEY CONNECTION The flue must provide every assurance of absolute safety and resistance Proof against the effects of the combustion product temp
15. Never light the fire when the room contains combustible gases INSERTS Example with combustible or thin wall floor and ceiling The insert must not be connected to an exterior air intake to provide combustion air only connection with an air inlet for the air to be heated is advised CEILING SUPPORTS METAL sam INSULATION SULA TOM 40 mm Er p B M A i CERABOARD 5 OF a 2 lt EUA 1 Ac I CEILING ls DEFLECTOR PLATE SMALL CEILING RELIEF VENT LEITH En e E 5 pet BREAST RAGIANT HOT Da E DIPAUSER por gt 4 E i j INTERNALLY INSULATED sn FRONTAL CONVECTION HOT 21 iTi LET T 2 MULT FUEL STAINLESS see HIGH TEMPERATURE INSULATED TO REGULATION STANDARD CONVECTION HOT Te CHIMNEY BREAST NON FLAMABLE CAVES Ti iF TAR pu OWALS TIBLE WATERIALS OF QUTL ET TO ANOTHER 8 NON CAWS LS TNE ROCA EI SPACER METAL PLATE DIAN WITH INS OLA TION A efa K a Ok pns Y ama 3 2 Lis Ed ais VENTED AIR CAVITY CAVITY to min Sh BRICK REFRACTORY CONCRETE PROTECTING f WOOD MANTEL PIECE FRONTAL CONVECTION HOT AIR OUTLET q ij MELLA TEA 2c HA CERABCARD 5 OR SL ns
16. REGULATOR keep the combustion chamber closed Only open the chamber to add more wood Remember that the fire and its exterior will be very hot during the combustion process Do not touch any surfaces close to 1t IV MAINTAINING THE FIRE 6 Clean the exterior surface with a damp cloth Do not use cleaning products that may damage the paintwork and or produce unpleasant fumes The combustion chamber door must be kept shut except when lighting the fire or adding wood to the fire The ashtray must also be kept shut except when removing ashes 6 Do not use the fire in a total isolated room it is important to allow a constant flow of fresh air 6 Do not attempt any unauthorised modification to the fireplace 6 Only use spare parts approved by the manufacturer 6 Periodically clean the appliance the flue connector and the chimney pipe and check there is no obstruction on them after a large period without using V SAFETY ADVICE Never use the fire when there are inflammable gases in the room In order to let the fire working efficiently and safely the room needs to have a sufficient flow of air When the building has been built up in a way that doesn t provide the necessary flow of air to fulfil the essential requirements we recommend an exterior air vent through permanent slits of at least 200 cn The combustion air inlets must not be modified under any circumstance The grill air vents of the fireplace must be kept clear
17. ambio de estos elementos resultase muy oneroso la reparaci n efectuada no fuera satisfactoria y el objeto no revistiese las condiciones ptimas para cumplir el uso a que estuviese destinado el titular de la garant a tendr derecho a la sustituci n del objeto adquirido por otro de id nticas caracter sticas o la devoluci n del precio pagado 2 El plazo de validez contado a partir de la fecha de la compra es de Cinco a os para todos los elementos de hierro fundido que fabricamos Dos a os para los componentes distintos de la fundici n tales como torniller a resortes ventiladores circuitos impresos interruptores terminales hilos el ctricos funda el ctrica etc 3 La Garant a no ser v lida si no va acompa ada de la correspondiente factura de compra debidamente rellenada y sellada por el establecimiento vendedor autorizado 4 La Garant a s lo es v lida si el producto se utiliza seg n las reglas y recomendaciones indicadas en las instrucciones para la instalaci n y uso suministradas con la estufa o chimenea que el comprador reconoce haber recibido y acepta ajustarse a las mismas para su seguridad 5 Exclusiones Esta Garant a no Incluye el cristal de la estufa el cual ha sido sometido a una serie de pruebas y test de calidad durante el proceso de fabricaci n quedando probada su durabilidad y resistencia soportando una temperatura de 750 la cual nunca ha sido alcanzada en la c mara
18. de combusti n por lo que queda dicho elemento totalmente excluido de la garant a en el caso de ruptura solo posible por mala manipulaci n en el uso o manejo de la estufa Tampoco est n incluidas en la garant a las juntas que son consideradas como piezas de desgaste as como las piezas del hogar en contacto directo con el combustible en ignici n tales como placa decorativa parrilla deflector parale os etc Los da os producidos por el uso de cualquier otro combustible distinto de la le a no ser n cubiertos con la garant a Esta garant a no incluye las instalaciones las puestas en marcha las roturas instalaci n incorrecta voltaje inadecuado o descargas atmosf ricas rayo as como manipulaciones por personas o talleres no autorizados 6 La presente Garant a Comercial es v lida en las condiciones indicadas durante los plazos se alados anteriormente FERLUX no se hace responsable en ning n caso de eventuales da os producidos a personas o cosas por manipulaci n indebida del aparato o por mal uso En todo caso el titular de la garant a tiene todos los derechos m nimos reconocidos por la Ley 7 FERLUX se reserva el derecho a modificar este manual sin preaviso 8 Para ejercitar los derechos conforme a esta Garant a Comercial el consumidor dispone de las siguientes v as de reclamaci n E mail Web Tino Fax Direcci n CONDI ES GERAIS DO CONTRATO DA GARANTIA COMERCIAL 1
19. ell sealed Insufficient RADIANT HOT AIR INTEROR LOFT FROM ventilation and lack of oxygen in the room can cause malfunctions and can even DIFFUSER CHIMNE Y BREAST prevent any heat being released Hot air cannot move or form a circuit unless the air can circulate Insufficient ventilation of rooms and of passage of air between them makes them unhealthy causing smells condensation humidity and mould Installing accessories or additional appliances not supplied by ourselves may affect the performance of the fireplace Please consult your local health regulations STAINLESS STEEL PIPE sm ADVICE ON MAINTENANCE as ay eS ASH 52227 T Ash must be removed whenever necessary by emptying the ash pan Ash and s cinders must not be allowed to fill the ash pan and come into contact with the grate x 3 firstly because the grate would not cool down and could rapidly be damaged and also because it would affect the circulation of the combustion air ENTRY 0F THE PRIMARY Place the ash and cinders removed from the fireplace into a metal container with AIR COMBUSTION a close fitting lid The container must be placed on a fire proof floor away from combustible materials until the cinders are completely extinguished and cold g 6 E ook Au CLEANING THE GLASS The glass must pe cleaned while the fireplace is still warm A Various commercially available products are easy to use and facil
20. eratures Perfect air smoke tightness Adequate flue cross section The stainless steel pipe must overlap the collar by a minimum of 40 mm and the joint must be sealed with refractory mortar to ensure air smoke tightness CHIM NEY CONNECTORS AND RE LINERS The following materials are forbidden for chimney connectors and pipes aluminium aluminised steel and galvanised steel The use of rigid or flexible multi fuel pipes must be justified by a technical report approving such use Additionally in the case of a re lining pipe it is obligatory to vent the air between the interior of the masonry flue and the outer surfaces of the liner a 15 x 10 cm space for example at top and bottom in the attic or where the chimney passes through the ceiling EXAMPLES OF INSTALLATION FIREPLACES Example with incombustible wall floor and ceiling gt EMISTING INSULA TON DO mr FLANGED COLLAR CEILING EXTERIOR OF INTERIOR WALL PRESSURE RELIEF MIN 45 oti THER Cn CHIMNEY BREAST RADIANT VENTED AIR CAVITY 20 mm AR DIFFUSER 60 x 20 44 MUL PUEL SA STEEL PIPE RADIANT HOT ALR QUTLET TO CHIMNEY BREAST MOM ANOTHER ROCAS Nae COMBUSTIBLE MA TERIA Ls INSLIL ATION ISOLATO Min EO ma THIDE VENTED RADIANT AR CAVITY 2 mm AMBIENT AIF EXTERIOR MIR INTAKE 40 em VENTILATION WARNING VERY IMPORTANT It is dangerous to overheat the appliance
21. he chimney that are combustible or could be damaged by heat must be removed if the chimney is in contact with these walls The surface temperature of such walls should not exceed 50 C in accessible areas or 65 C in inaccessible areas The insulation required to achieve this should be of an adequate thickness of incombustible insulating materials such as Special high temperature rock wool with aluminium on one side Ceramic fibres with aluminium on one side with or without an air cavity The insulation work must be carried out with the greatest care An access point must be made before installation to allow future cleaning of the flue connector and the chimney pipe FLUE If necessary the chimney and flue liner should be cleaned beforehand Check that they are air smoke tight and unblocked do not curve too sharply ensure that the flue liner and flue collar cross sections allow for connection using a chimney connector starter pipe WARNING Connecting more than one appliance to the same flue is forbidden A good flue liner must be made of materials that are not good heat conductors so that it retains the heat It must be leak proof and the walls must be tested beforehand for air smoke tightness unless it is re lined for connection to the fireplace The minimum flue size is 40 cm e g 20 x 20 for fireplace collars of under 200 mm or 62 5 cm e g 25 x 25 for those with a collar of over 200 mm The cross section must be the same
22. itate the removal of deposits Follow the instructions carefully ENTRY OF AIR TO BE HEATED Do not use abrasive products THROUGH LOG HOLE If the glass needs replacing remove the screws holding it place Re use the insulating and cushioning gaskets The new glass must be special high temperature 750 C glass of the vitroceramic or vision type Do not use any other materials or types of glass Try not to bang the door shut use the handle to close it For appliances with upward opening doors keep hold of the door until it is fully open Do not lay the fire too close to the glass Do not use the appliance if the glass is broken Do not use flammable liquids fats or any unsuitable fuel CREOSOTE REMOVAL HOW IT FORMS AND HOW TO CLEAN IT When wood burns slowly it gives off organic vapours and tar like by products that react with the steam released by the wood and create a build up of creosote on the walls of a relatively cold chimney If these build ups burn or catch fire they can cause an extremely hot fire Creosote build up should be checked daily until you are familiar with the fireplace as used in your case and can tell how frequently it needs to be cleaned Remember that the greater the combustion the less creosote builds up so 1t may be necessary to clean the appliance every week in mild weather but only every two months during very cold spells The chimney should be inspected every two months to check the creosote build up over that time
23. l Warranty does not in any way affect the purchaser s rights in respect of the vendor as set forth in Spanish Act 23 2003 and RDL 1 2007 The purchaser must complete this certificate at the point of sale at the time of purchase and must present it together with the invoice purchase slip or delivery note in order to exercise his or her rights under this Commercial Warranty Fecha de compra comienzo de la garant a Data de compra inicio da garantia purchase date beginning of the warranty COMPRADOR COMPRADOR PURCHASER Nombre Nome Z Name taria pt titi I Direcci n Z Morada Z Mailing add esS9u uuu nu uu rir uu u A ia da ensaios ada dai a qa Sa a Codigo postal C digo postal post code aa a a qayapuna yun Poblaci n Localidade own pp Tel fono Telefone ielephomne renan een EEE EEE EEE EEE 5355 5 4 93 93 99 55 95 44 P is Pas COMUN is ANA nac Sello del vendedor Carimbo do instalador seller stamp CERTIFICADO A DEVOLVERNOS DENTRO DE LOS 10 D AS SIGUIENTES A LA COMPRA ESTE CERTIFICADO DEVER SER NOS ENVIADO DENTRO DE 10 DIAS SIGUINTESA DATA DA COMPRA CERTIFICATE TO RETURN US WITHIN THE TEN DAYS FOLLOWING THE PURCHASE Fecha de compra Data da Compra purchase date pp Comienzo de la garant a Come o da garantia beginning of the warranty
24. ll cancel the guarantee To protect the appliance of water accumulation avoid humidity in the outlet pipe as well as the entry of water into the fireplace The climatological conditions of the place can affect to the good working of the equipment and security of the users particularly when there is a potential risk of frosts VI TROUBLE SHOOTING ANOMALY SOLUTIONS THE GLASS BECOMES DIRTY Check the humidity of fuel OIE RES Open the front air vents IN CASE OF A FIRE IN THE FIREPLACE OF CHIMNEY TAKE THE FOLLO WING MEASURES THE FIREPLACE DRAWS TOO Shut the damper MUCH Ask your supplier INMEDIATELY CLOSE ALL THE AIR VENTS Check the fireplace and the chimney see the user s manual A Front door THE FIREPLACE DOESN T DRAW B Ashtray WELL WITH EMISSION OF FUMES Remove any obstruction C Primary air vents INTO THE ROOM Sweep the chimney Open the damper FOLLOWING INFORM THE FIREFIGHTING Check if the fuel is dam LOCAL AUTHORITIES ABOUT THE EVENT P THE FUEL DOESN T BURN WELL Cia Remove any obstruction in the air vents Open the damper VII VENTILATOR SYSTEM The system of the Ventilators is done in order to make an air flow through the chamber from ambient to hot air expelled into the front air vents Regarding the regulation you can use the interrupter placed in the front of the insert behind the door working with three positions Position O The fans start working when the temperature has reached a
25. or UNE 13229 Para a boa utiliza o do aparelho FERLUX fornece lhe este manual de utilizador manuten o e instala o assegurando assim um funcionamento ptimo e das condi es adequadas sua seguran a N o obstante seguindo as instru es marcadas por este manual poder tornar mais longa a vida til do nosso produto Pela FERLUX recomenda que leia cuidadosamente e guarde o num lugar onde se possa dispor facilmente de ele em qualquer momento Dispomos tamb m ap s um espa o de modo que possa anotar os dados do fornecedor do aparelho bem como a data de compra e um registo de manuten o de modo que esta informa o esteja sempre devidamente conservada Poder de igual maneira juntar a este manual a factura de compra do produto dado que necess ria para a garantia Dear Customer FERLUX Chimeneas y Barbacoas is pleased that you have been chosen one of his products manufactured to satisfy the most discerning clientele Our products fulfil the levels of quality functionality security and possess all the features of a top quality heating product All our products comply with the European Standard UNE EN 13229 To ensure efficient use of this appliance we do provide a comprehensive user s manual which covers installation and maintenance When following it the life of the appliance will be extended FERLUX therefore advice you to read it carefully and keep it in a safe place We suggest that you fill full in
26. ove s outer surfaces The energy that this draws from the fire is propelled by the dynamics of the hot air in the chimney breast and immediately circulated into the room through the diffuser or into adjoining rooms The fireplace gives off heat through Radiation heat radiates from all its cast iron and glass parts Convection air circulates within the chimney breast and is distributed into the room or nearby rooms e INSERT The insert has a built in U shaped heat exchanger around the heating chamber composed of a horizontal cast iron casing box underneath which takes in the ambient air on either side of the ash pan and underneath the fire a vertical galvanised sheet metal casing box a horizontal galvanised sheet metal casing box above The air circulates between the finned outer walls of the iron stove which act as radiators and these sheet metal casings drawing energy from the fire and the ducts placed in the top casing box propel it to both sides of the chimney breast and or to other rooms The heating power of the INSERT is completed by radiation heat radiating from all its cast iron and glass parts convection the air circulates within the chimney breast and is distributed to the room in which the insert is located Vent upper vent air outlet Deflector Inspection door CHIM NEY CONNECTION FIREPLACES INSERTS PIPE INNER DIAMETER PIPE INNER DIAMETER OS Lower
27. para ello con los niveles de calidad funcionalidad seguridad y prestaciones exigibles a un buen aparato de calefacci n tal y como exige la normativa europea en vigor UNE EN 13229 Para el buen uso del aparato FERLUX le suministra este manual de usuario mantenimiento e instalaci n asegurando as un funcionamiento ptimo y unas condiciones adecuadas de cara a la seguridad No obstante siguiendo las instrucciones marcadas por este manual podr hacer m s larga la vida til de nuestro producto Por ello FERLUX recomienda lo lea atentamente y lo sit e en un lugar donde pueda disponer f cilmente de l en cualquier momento Disponemos a continuaci n un espacio para que pueda anotar los datos del proveedor del aparato as como la fecha de compra y un registro de mantenimiento de modo que esta informaci n est siempre debidamente conservada Podr a de igual manera adjuntar a este manual la factura o prueba de compra del producto ya que es necesaria para la garant a e Tipo de aparato Tipo de aparelho Equipment type e Referencia Refer ncia Reference installing the installing the appliance Apreciado Cliente FERLUX Chimeneas y Barbacoas felicita o por adquirir um dos seus produtos realizados para satisfazer o cliente mais exigente cumprindo com eles os n veis de qualidade de funcionalidade de seguran a e presta es exigidas a um bom aparelho de aquecimento como exige a regulamenta o europeia em vig
28. por manipula o indevida pelo aparelho ou por mau uso Em todo o caso o titular da garantia comercial tem todos os direitos m nimos reconhecidos por lei 7 FERLUX reserva se ao direito de realizar qualquer modifica o no presente manual sem aviso pr vio 8 Para exercitar os direitos conforme esta Garantia Comercial existem as seguintes formas de reclama o E mail Web Tel Fax Morada GENERAL CONDITIONS OF THIS COMMERCIAL WARRANTY AGREEMENT 1 This Commercial Warranty covers the free repair of any failure due to defective manufacture at the Official After Sales Service including labour and parts the staff trip of the Authorized Technical Service is not included Our liability is limited to free replacement of the parts that are acknowledged to be defective after inspection and checking by our technical personnel and always provided that none of the exclusions are applicable Should replacement of these parts prove highly onerous or should the repair effected not prove satisfactory and the object not be in perfect condition for its intended use the warranty holder shall be entitled to replacement of the object purchased by another of identical characteristics or to a refund of the purchase price 2 The warranty period commencing on the date of purchase is Five years for all cast iron parts manufactured by ourselves Two years for parts other than cast iron such as bolts springs fans circuit boa
29. rbidden Do not use the appliance as an incinerator When adding more fuel make sure that the ashtray is enough empty to let the natural air going through and not destroy the grill base When inserting firewood handle the door gently Normal load of wood approximately 3 or 4 logs 12 to 15 cm 4 34 6 in diameter Before loading for a slow fire allow the flames to die down do not load on top of embers that are too bright Il TOLIGHT THE FIRE 1 Empty the ashtray 2 Put the wood into the firebox 3 Light the fire using kindling small sticks of wood or firelighters 4 FIRE up the wood 12 INSULATED NON INSULATED FER UX ENG 5 Let the door slightly open to avoid dirtying the glass the glass 15 relatively cool and resulting condensation can cause soot particles to stick to the k SECONDARY N AIR REGULATOR glass 6 When the glass is sufficiently hot close the door 7 Wait until the kindling is burning well and then add progressively larger pieces of wood 8 Follow the instructions below on regulating the fire III REGULATION OF THE FIRE The fire is controlled by a primary air regulator which is situated in the centre of the front panel see diagram This regulator controls the maximum and minimum flow of air to the fire Inserts in cast iron are also provided with a secondary air regulator PRIMARY In order to control the fire and avoid the escape of smoke it is essential to AIR
30. rds switches terminals electrical wires electrical sheathing etc 3 The Warranty shall not be valid unless accompanied by proof of purchase duly completed and stamped by the authorised vendor 4 The Warranty is only valid if the product is used in accordance with the rules and recommendations given in the instructions for installation and use supplied with the stove or chimney which the purchaser acknowledges having received and agrees to follow for his or her own safety 5 Exclusions This Warranty does not include the glass of the stove which has been subjected to a series of tests and quality testing at the factory that have proved its durability and resistance including subjecting it to a temperature of 750 which has never been reached in the combustion chamber Consequently this part is totally excluded from the warranty in the event of breakage which can only be caused by poor use or handling of the stove Gaskets are also excluded from the warranty as they are considered parts subject to wear as are the parts of the fireplace in direct contact with the burning fuel such as the decorative plate grate deflector log stops etc Damage caused by the use of any fuel other than wood is not covered by the Warranty The Warranty does not include installations start ups breakages incorrect installation unsuitable voltage or atmospheric discharge lightning or handling by unauthorised persons or businesses
Download Pdf Manuals
Related Search