KYOSHO GS11R エンジン
Contents
1. 1 Running area In order to avoid accidents check if no one else is on your frequency and that the running area is remote enough from roads residential districts and people Always start and run engines outdoors 2 Check before running Check the radio batteries and be sure the model moves accordind to your inputS Check that all screws and nuts are tight 3 Observe when starting the engine Always break in Do not run t2. O S No 8 No 3 1 2 3 10
3. 5 6 7 Throttle Stop Screw 2 Idle Adjustment Throttle Stop ScreW Adjust so the engine enters idling before the clutch engages and By unscrewing the throttl
4. Throttle Stop Screw Carburetor Adjustment 1 Needle The needle adjusts the amount of fuel sucked into the carburetor It comes factory set 2 turns from closed position Start the engine with this needle setting 2 Throttle Stop Screw Set the idle rpm with this screw When 1mm After rotating the 1 throttle drum until the opening is 1mm wide start the engine 50cm
5. R C
6. 178 1 1 6 1 2 rotating it clockwise right rpm increase As a thumb rule the setting for cars lies between the rpm the clutch engages and the rpm the engine stops Idle rpm should be in the lower range Recoil Starter This engine features a recoil starter as standard equipment For starting the engine take the starter knob and pull it quickly However do not pull past 50cm because the rope or the spring inside the recoil starter might tear Glow Plug When the filament becomes blackish or deforms replace the glow plug Steps from Break in to Normal Running 1 Start the engine with the needle position a
7. No No No NE CinA No EN ES eA 651027 noodle St OD Oxt 420 210 851022 Caikshan GD OO WO x 1946i 2 1 a 4 6 6510 05 Flywheel Spacer dD UI xd 263 6510 23 Bicton amp Cylinder Set x1 2100 4 GSTIR 6510 09 Cylinder Head for Marine 2 G3 x1 1260 6510 24 Sinder ior Can 8STIR xt 1680 gt 85061M NE x 210 6510 29 Garburetor Drum Set DODAxI 1155 6510 11 SESfSGGE G0 x2 210 6510 30 Carburetor Assembly 1365 1 6510 13 Piston Pi Gudgn Pin x1 420 74381 Roadl BB 95 G8 YGYx1 2 6x6mm x1 2100 59 6510 14 Gonnecting Rod x1 473 74381 01 One Way Ball Bearing 893 G63 x1 2x6mm x2 74381 02 G4 x1 368 6510 15 Screw set 2 6x6mm 2 6x12mm 2x15mm x1 263 6510 19 Stn Ha x1
8. 1575 7498107 Becoil starter Main Part 2 6x6mm x1 840 Short Cylinder Head PS G S11R i 14381 08 Saner lolder x1 368 6510 21 Crankcase GS11R 2625 SPECIFICATIONS ARE SUBJECT TO BE CHANGED WITHOUT NOTICE 2004 KYOSHO CORPORATION 16 7 1 243 0034 153 046 229 4115 lt 10 00 18 00 63019911 2 PRINTED IN JAPAN
9. KYOSHO GS11R KYOSHO GS11R ENGINE S M4 FINEST RADIO CONTROL MODELS INSTRUCTION SHEET No 74711 GS11R 10 The GS11R engine has been designed for entry level GP10 cars and boats lts easy to adjust carburetor and its recoil starter for smooth engine starting make it one of the best available For safe use plenty of power output and lots of R C fun attentively read the instructions below 1 2 11 2
10. e stop screw the engine speed wl decreaSe Py Narrow opening Engine Troubles and their Reasons 1 Performing no break in gt Always run engines in and make sure all parts work smoothly 2 Needle is too tight An overtight needle results in overheat which burns the piston and the cylinder head 3 Running the engine unloaded at full throttle gt Engine rpm increase too much breaking the connectind rod 4 Running without air cleaner only in case of GP cars Dirt enters the engine and scratches the piston cylinder surfaces 5 Running with water onboard Water contaminates the carburetor and the engine breaking the connectind rod 6 Are brake and power drive train jammed 7 Check the glow plug regularly and carefully choose your fuel Engine Life Dust infiltration and excessive heat are every endine s enemies No 1 Dif ficulties in starting immediate engine stalling once started or once the glow plug heater is being removed often indicate that the engine s life might be over In such cases replacement of the connecting rod and the cylinder piston set will bring the engine back to life EXPLODED VIEW 1 2 3 4 5 6
11. he engine at full throttle with the wheels aloof from ground this will damadge the engine Always wear protective gloves Because it can become very hot do not touch the engine once it is started or after finishing runnind it Fuel for GP models mainly contains methanol Never expose fuel to direct sun light and always store it in safe places out of children s reach lf getting into eyes or if swallowed wash out or induce a lot of water and immediately consult a physician Keep hands and any objects away from rotating parts Do not fail to install an air cleaner only in case of GP cars 4 Observe when running The moment the model does not respond to your inputs stop it and check the model as well as the radio Find the reason for the problem and correct it 5 Observe after running Draw out any fuel left over Also wipe off dirt and oil and regrease all rotating Darts 6 Other points to observe Unless they got used to entry level racers are advised not to run excessively They should ask veteran racers for hints techniques etc Do not use parts other than appointed and do not modify them Take out an injury insurance and get registered as racer Or after getting redis tered taking out an injury insurance is also possible PARTS LIST For Japanese market only
12. s it is Place the car on a test stand so the wheels become aloof from ground Or hold the boat firmly in place without putting it on the water Then position the engine control stick to lowest throttle and start the engine OQ Once started While running the car boat in practice another 2 3 tanks make sure it does not rev up When breaking the engine in do not rev it up in the beginning but run it at a comfortable pace for 10 tanks by screwing the needle in little by little Once the engine is run in and once increasing engine speed can be done and whenever the engine is close to losing engine speed screw the needle out 1 8 turn The needle Valve should be screwed out 1 and 3 4 turns for normal engine running Screwing it further in again excessive heat may be generated 3 4 By tightening the throttle stop Screw the engine speed wil increaSse P Wide opening 8
Download Pdf Manuals
Related Search