Home

ROSA – ROSETTA - Kaminofen

image

Contents

1. ROSETTA Bordeaux 153 kg Petra 167 kg Maiolica 169 kg 50 1095080 Rev 05 IT EN DE FR ROSA ROSETTA E iN o f UA DECLARATION OF DICHIARAZIONE a DI CONFORMIT KONFORMIT TSERKL RUNG In accordo con la Direttiva 89 106 CEE Prodotti da Costruzione il Regolamento CE n 1935 2004 Materiali e Oggetti destinati a venire a contatto con prodotti alimentari According to the Directive 89 106 EEC Construction Products the CE Regulation No 1935 2004 Materials and Articles intended to come into contact with foodstuffs Im Einklang mit der Direktive 89 106 EEC Bauprodukte und der CE Vorschrift Nr 1935 2004 Materialien und Gegenstande die f r den Kontakt mit Lebensmitteln vorgesehen sind N di identificazione Identification No Identifikationsnummer 049 La NORDICA S p A Emesso da Issued by Ausgestellt von Via Summano 104 36030 Montecchio Precalcino VICENZA 39 0445 804000 Fax 39 0445 804040 Cucine a combustibile solido Tipo di apparecchio Type of equipment Ger tetyp Fire coocker by solid fuel Herde f r Festbrennstoffe Marchio commerciale Trademark Handelsmarke La NORDICA Modello o tipo Model or type Modell ROSA Uso Use
2. Der Herd darf nur mit eingesetztem Aschenkasten betrieben werden Die festen Verbrennungsr ckst nde Asche m ssen in einen geschlossenen und feuerfesten Beh lter gef llt werden Der Herd darf bei Auftreten entz ndlicher Gase oder D mpfe z B von Linoleumkleber Benzin etc nicht betrieben werden Bewahren Sie das Anz ndmaterial nicht in der N he des Herdes auf Durch den Abbrand von Brennmaterial wird Warmeenergie frei die zu einer starken Erhitzung der Oberfl chen der T ren der T r und Bediengriffe der Glasscheiben des Rauchrohrs und ggf der Frontwand des Herdes f hrt Die Ber hrung dieser Teile ohne entsprechende Schutzbekleidung oder Hilfsmittel hitzebest ndige Handschuhe oder andere Bedienungsmittel ist zu unterlassen Machen Sie Kinder auf diese Gefahren aufmerksam und halten Sie sie w hrend des Heizbetriebes vom Herd fern Wenn ein falscher oder zu feuchter Brennstoff benutzt wird k nnte aufgrund von Ablagerungen die im Rauchfang vorhanden sind ein Brand darin entstehen 1095080 Rev 05 DE 29 NOGDICA ROSA ROSETTA 4 1 NOTFALLEINGRIFF Wenn im Verbindungsst ck oder im Rauchfang ein Brand entsteht a Ladet r und Aschenladet r schlie en b Verbrennungsluftregler schlieBen c L schen mit Hilfe von Kohlensaurel schern CO2 Pulver d Sofort die Feuerwehr rufen Das Feuer nicht mit Wasserstrahlen l schen Wenn der Rauch
3. Picture 2 The cooker must operate exclusively with the ash drawer inserted The solid residues of the combustion ashes must be collected in an hermetic container resistant to fire The cooker must never be ignited near when there are gas or steam emissions e g glue for linoleum gasoline etc Never deposit flammable materials near the stove During the combustion will be spread thermal energy which warms up the surfaces the door the fireplace glass the handles and knobs the smoke pipe and the front side of the stove Please avoid the contact of these parts without gloves or the relevant tools Warn children of the danger and keep them away during the operation of the stove The use of a wrong or wet fuel causes the formation of creosote deposits in the flue and will fuel a chimney fire 4 4 FIRST AID MEASURES Should any fire arise in the stack or in the flue a Close the feeding door and the ash drawer door b Close the registers of combustion air c Extinguish the fire using carbon dioxide fire fighting means CO dust d Seek immediate intervention of FIRE BRIGADE DO NOT EXTINGUISH FIRE USING WATER JETS When the fire has been extinguished let the flue check by an expert to find possible cracks and permeable points 1095080 Rev 05 EN 19 ONeill ROSA ROSETTA 5 FLUE Essential requirements for a correct operation of the device e the internal section must be preferabl
4. 2 Refractory flue with double insulated chamber and external coating in lightweight concrete Efficiency 100 excellent 3 Traditional clay flue square section with cavities Efficiency 80 excellent 4 Avoid flues with rectangular internal section whose ratio differs from the drawing Efficiency 40 poor too big flue section can feature a too big volume to be heated and consequently cause difficulties in the operation of the device to avoid this tube the flue along its whole height A too small section causes a decrease of the draught Picture 3 The flue must be properly spaced from any flammable materials or fuels through a proper insulation or an air cavity It is forbidden to let plant piping or air feeding channels pass in the same flue Moreover it is forbidden to create movable or fixed openings on the same for the connection of further other devices 5 1 CHIMNEY CAP POSITION The draught of the flue depends also on the suitability of the chimney cap Therefore if it is handicraft constructed the output section must be more than twice as big as the internal section of the flue Should it be necessary to exceed the ridge of the roof the chimney cap must assure the discharge also in case of windy weather Picture 4 The chimney cap must meet the following requirements e have internal section equivalent to that of the stack e have a useful output section twice as big as the flue internal one e be manufactur
5. Riscaldamento e cottura uso domestico Space heating and cooking in buildings Verwendungszweck Erw rmung von Wohnr ume und Kochen La NORDICA S p A Costruttore Manufacturer Herstelle Via Summano 104 36030 Montecchio Precalcino VICENZA 0445 804000 Fax 0445 804040 RRF1625 Ente notificato Notified body Benanntes Labor RRF Rhein Ruhr Feuerstatten Pr fstelle GmbH Am Technologie Park 1 D 45307 ESSEN Le norme armonizzate o le specifiche tecniche designazioni che sono state applicate in accordo con le regole della buona arte in materia di sicurezza in vigore nella CEE sono The following harmonised standards or technical specifications designations which comply with good engineering practice in safety matters in force within the EEC have been applied Die folgenden abgeglichenen Standards bzw technischen Einzelheiten Bestimmungen angewandt im Einklang mit den Normen in Sicherheitsangelegenheiten die in der CEE in Kraft sind wurden angewandt Norme o altri riferimenti normative Rapporto di Prova ITT Standards or other normative documents Initial Type Tests Report Standards oder andere normensetzende Dokumente Pr fbericht EN 12815 RRF 15 06 1217 Condizioni particolari Particular conditions Besondere Bedingungen Informazioni marcatura CE CE Marking information Auszeichnungsinformationen In qualit di costruttore e o rappresentante autorizzato della societ all interno della CE
6. devra d passer l autre d au moins 50 cm afin d viter des transferts de pression entre les conduits eux m mes Figure 5 1 Le terminal ne doit pas rencontrer d obstacles sur 10 m repr sent s par des murs des pans de toit et des arbres Dans le cas contraire rehausser celui ci d au moins 1 m au mi dessus de l obstacle Le terminal doit d passer le fa tage du d toit d au moins 1 m Figure 6 E Figure 7 42 1095080 Rev 05 FR ROSA ROSETTA e iN o f UA TERMINAUX DISTANCES ET POSITIONNEMENT UNI 10683 98 meinaisonaunon Distance ente o ata tle Hauteur minimum do a chemin e a A m H m Ss 1 85 m 0 50 m au dessus du faitage gt 1 85 m 1 00 m du toit T 1 50 m 0 50 m au dessus du faitage 1 50 m 1 30 m du toit yen 1 30 m 0 50 m au dessus du fa tage 1 30 m 2 00 m du toit 1 20 m 0 50 m au dessus du faitage 1 20 m 2 60 m du toit 6 RACCORDEMENT AU CONDUIT DE FUMEE Les appareils avec fermeture automatique de la porte type 1 doivent obligatoirement fonctionner pour des raisons de s curit avec la porte du foyer ferm e exception faite pour la phase de chargement du combustible ou de l enl vement des cendres Les appareils dot s de p
7. Dust emissions 13 96 O2 24 mg m Staubemissionen 13 96 O2 Massima pressione idrica di esercizio ammessa Maximum operating pressure AE Maximale Betriebsdruck Temperatura gas di scarico Flue gas temperature 255 Abgastemperatur Potenza termica nominale Thermal output 6 kW Nennheizleistung Rendimento Energy efficiency Wirkungsgrad 74 Tipi di combustibile Fuel types Brennstoffarten LEGNA WOOD HOLZ VKF Nr Z 13083 SINTEF Nr 045 159 15a B VG Nr PL O246 P 54 1095080 Rev 05 IT EN DE FR Dati e modelli non sono impegnativi la ditta si riserva di apportare modifiche e migliorie senza alcun preavviso Data and models are not binding the company reserves the right to carry out modifications and improvements without notice Daten und Modelle sind nicht verpflichtend Die Firma behalt sich das Recht vor ohne vorherige Ankundigung Anderungen und Verbesserungen vorzunehmen Les donn es fournies et les mod les n engagent en rien l entreprise qui se r serve le droit d apporter des modifications et des am liorations sans aucun pr avis NONB La NORDICA S p A Via Summano 104 36030 Montecchio Precalcino VICENZA ITALIA Tel 39 0445 804000 Fax 39 0445 804040 email info lanordica com www lanordica extraflame com 1095080 Rev 05 IT EN DE FR
8. Als Brennstoffe werden Der Dauerbrandherd besteht aus verzinkten Stahlblechplatten emaillierten Gusseisen und Warmestrahlungskeramik T ren Vorderseite Platte Die Feuerstelle ist mit einer Panoramat r mit einem hinteren Keramikglas bis 700 hitzebest ndig D as erm glicht einen faszinierenden Blick auf die z ngelnden Flammen Die Feuerstelle ist innen mit einzelnen GuBplatten verkleidet Im Innenraum der Feuerstelle befindet sich einen Planrost Der Herd kann mit einer Hubrost ausgestattet werden die durch eine dazu bestimmte Kurbel sich erhebt Die Selbe kann als OPTIONAL gekauft werden Die obere Stellung verbessert den Gebrauch der Platte die untere Stellung verbessert den Gebrauch des Backofens OPTIONAL Unter der Backt r befindet sich einen Warmhalteraum mit Verschlusst r Bitte kein entz ndbares Material hineinlegen Die Raumbeheizung erfolgt Durch Strahlung ber die Sichtfensterscheibe und heiBe AuBenfl chen des Ofens wird Warme in den Raum abgestrahlt Der Dauerbrandherd ist mit Prim r und Sekund rlufteinstellvorrichtungen ausger stet mit denen die Verbrennungsluft eingestellt wird 2 1 DER PRIM RLUFTSCHIEBER drehebare Klapppe Mit dem unteren Luft Schieber an der Feuerstelletuer wird der Zustrom an Prim rluft im unteren Ofenteil durch den Aschenkasten und den Rost in Richtung Brennstoff eingestellt ABB 1 A Die Prim rluft ist f r den Verbrennungsproze notwendig Der Aschenkasten mu
9. e Der horizontale Abschnitt darf in keinem Fall 2m berschreiten UNI 10683 2005 e Jeder Bogen des Rauchkanals verringert den Zug des Rauchabzugs erheblich was gegebenenfalls durch dessen angemessene Erh hung des Rauchabzugs auszugleichen ist 36 1095080 Rev 05 DE ROSA ROSETTA e iN o f UA e Die Norm UNI 10683 2005 ITALIA sieht vor dass es in keinem Fall mehr als 2 B gen oder Richtungsanderungen einschlieBlich der M ndung in den Rauchabzug sein d rfen Wenn der Rauchabzug eines offenen Kamins benutzt werden soll muss die Haube unter der Stelle der Einm ndung des Rauchkanals hermetisch verschlossen werden Pos A ABB 10 Wenn der Rauchabzug zu gro ist z B 30x40 oder 40x50 cm muss er mit einem Rohr aus rostfreiem Stahl von mindestens 200mm Durchmesser verrohrt werden Pos B wobei darauf zu achten ist den verbliebenen Raum zwischen dem Rohr und dem Rauchabzug unmittelbar unter dem Schornstein fest zu schlieBen Pos C rn C Abdichtung my ES YO A Hermetischer de Verschluss Inspektionsklappe F r jede weitere Erkl rung wenden Sie sich bitte an Ihren Vertrauensh ndler 1095080 Rev 05 DE 37 ROSA ROSETTA NOGDICA CEE Hu 1 DONNES TECHNIQUES D finition Cuisini re bois
10. sur l appareil et tout particulierement sur les superficies laqu es Les surfaces laqu es ne doivent pas tre touch es pendant le chauffage 6 Apr s avoir termin la p riode de rodage vous pourrez utiliser votre appareil comme le moteur d une voiture en vitant de brusques chauffements avec des charges excessives Pour allumer le feu nous conseillons d utiliser du petit bois et du papier journal ou d autres moyens d allumage vendus dans le commerce l exception de toutes les substances liquides telles que alcool essence p trole et quivalents Les r glages pour l air primaire et secondaire doivent tre ouvertes au m me temps il faut r guler le r gulateur fum es pour l utilisation cuisini re c est dire que la manette doit tre enfonc e vers l arri re de la cuisini re Quand le bois commence br ler on peut charger plus de combustible et r gler l air pour la combustion selon les indications du chap 10 Au cours de cette phase ne jamais laisser le po le sans surveillance Ne jamais surcharger la cuisini re comparez le tableau technique quantit max de combustible qui peut tre charg Trop de combustible et trop d air pour la combustion peuvent causer une surchauffe et donc endommager le po le La garantie ne couvre pas endommagements caus s par le sur chauffage de l appareil 10 FONCTIONNEMENT STANDARD Les appareils avec fermeture automatique de la porte type 1 doivent obligatoirement fo
11. 1095080 Rev 05 DE ROSA ROSETTA E iN o f UA Luftumw lzung muss durch einige feste ffnungen nach auBen gew hrleistet sein Die Gr Be der erforderlichen Luft ffnungen ist durch die entsprechenden Vorschriften festgelegt Bitten Sie einen Schornsteinfeger Ihres Vertrauens um Informationen Die Offnungen sollten mit Gittern gesch tzt werden und d rfen nie verstopft sein Die Abzugshauben die im selben Raum oder Raumluftverbund wie der Ofen eingebaut sind k nnen die Funktion des Ofens negativ beeinflussen bis hin zum Rauchaustritt in die Wohnraume trotz geschlossener Feuerraumt r Daher d rfen sie unter keinen Umstanden gleichzeitig mit dem Ofen betrieben werden Der Unterdruck einer Abzugshaube kann im schlimmsten Falle die Rauchentwicklungen verschlucken mit schweren Folgen f r den Ofenbetreiber 8 ZULASSIGE UNZULASSIGE BRENNSTOFFE Die zul ssigen Brennstoffe sind Brennholz Es d rfen ausschlieBlich trockene Holzst cke Wassergehalt max 20 verwendet werden Die Holzst cke sollten eine L nge von ca 30 cm und einen Umfang von max 30 cm haben Brennholz mit maximal 20 Wasser erh lt man durch eine mindestens einj hrige Weichholz bzw zweij hrige Hartholz Trocknung in einem trockenen und bel fteten Raum z B unter einem Regendach Feuchtes Holz macht das Anfeuern schwieriger da eine gr Bere Energiemenge notwendig ist um das vorhandene Wasser verdunsten zu lassen Der Feuchtigkeitsgehalt
12. Controllate quindi che tutte le aperture per la pulizia e i collegamenti al camino siano ermetici 13 MANUTENZIONE E CURA Fate controllare dal Vostro spazzacamino responsabile di zona la regolare installazione della cucina il collegamento al camino e l aerazione Per la pulizia delle parti smaltate usare acqua saponata o detergenti non abrasivi o chimicamente non aggressivi Qualora i componenti in ottone dovessero diventare azzurrognoli a causa di un surriscaldamento ci pu essere risolto con un adeguato prodotto per la pulizia IMPORTANTE si possono usare esclusivamente parti di ricambio espressamente autorizzate ed offerte da La Nordica In caso di bisogno Vi preghiamo di rivolgerVi al Vs rivenditore specializzato L APPARECCHIO NON PUO ESSERE MODIFICATO 13 1 PULIZIA CANNA FUMARIA La corretta procedura di accensione l utilizzo di quantit e tipi di combustibili idonei il corretto posizionamento del registro dell aria secondaria il sufficiente tiraggio del camino e la presenza d aria comburente sono indispensabili per il funzionamento ottimale dell apparecchio Almeno una volta l anno consigliabile eseguire una pulizia completa o qualora sia necessario problemi di malfunzionamento con scarsa resa Questa operazione fatta esclusivamente a cucina fredda dovrebbe essere svolta da uno spazzacamino che contemporaneamente pu effettuare un ispezione Il vano di raccolta dei fumi pu essere pulito attraverso lo sporte
13. Lufteinstellvorrichtungen ABB 1 wird die W rmeabgabe der Feuerstelle eingestellt Sie sind je nach W rmebedarf zu ffnen Der beste Abbrand geringe Emissionen wird erreicht wenn bei Einsatz von Holz der gr te Teil der Verbrennungsluft ber die Sekund rlufteinstellvorrichtung zugef hrt wird Man darf immer den Ofen mit geschlossener T r benutzen um die berhitzungsschaden zu vermeiden Schmiedeeffekt Der Herd darf nie berladen werden siehe H chstmengen in der unten stehenden Tabelle Zu viel Brennstoff und zu viel Verbrennungsluft k nnen zur berhitzung f hren und daher den Ofen besch digen Durch berhitzen verursachte Sch den sind nicht durch die Garantie gedeckt PRIM RLUFT SEKUND RLUFT Neben der Einstellung der Verbrennungslufteinstellvorrichtungen beeinflu t der Schornstein die Intensit t der 34 1095080 Rev 05 DE ROSA ROSETTA I iN o f UA Verbrennung und damit die Heizleistung Ihres Dauerbrandherdes Erh hter Schornsteinzug erfordert kleinere Verbrennungslufteinstellungen geringerer Schornsteinzug erfordert gr Bere Verbrennungslufteinstellungen WICHTIG Um die gute Verbrennung Ihres Dauerbrandherdes zu pr fen kontrollieren Sie ob der aus dem Schornstein austretende Rauch transparent ist Wenn er weiB ist bedeutet das daB der Herd nicht richtig eingestellt ist oder das Holz zu naB ist wenn er grau oder schwarz scheint ist dies ein Zeichnen f r unvollst ndig
14. Vi preghiamo di rivolgerVi al Vs rivenditore di fiducia Figura 10 16 1095080 Rev 05 IT ROSA ROSETTA Qi CEE 1 TECHNICAL DATA H H Definition wood cooker according to EN 12815 CIG ROSA ROSETTA Constructive System 2 2 Rating power in kW 6 5 6 Efficiency in Yo 78 9 74 Pipe diameter in mm 150 130 Maximum quantity of fuel wood in kg h 1 9 2 Mean content of CO to 13 O in wood in kg 8 7 9 56 Emission of exhaust gases in g s wood 239 255 Temperature of exhaust gas in C wood 0 11 0 12 Depression by rating calorific value in mmH 0 wood 1 0 1 2 Size of hearth opening in mm W x H 223x265 209x265 Hearth body size hearth head in mm W x H x D 270x340x400 230x350x382 Oven size in mm W x H x D 330x298x410 245x300x384 Grate type mobile flat Stove height in mm 851 843 Stove width inmm 1030 869 Stove depth without handles in mm 666 572 Weight kg See chapter 17 Safety measures See chapter 4 The heating volume of the cookers according to EN 12815 for those buildings in which the thermal insulation does not correspond to the instructions on heat protection is 30 Kcal h x m type of favourable construction 40 Kcal h x m type of less favourable construction 50 Kcal h x m type of unfavourable construction ROSA 185 m 138 m 111 m R
15. chaque m tre de parcours horizontal du canal de fum e provoque une sensible perte de charge qui devra ventuellement tre compens e en levant le tuyau d vacuation des fum es go C Tamponnement e dans tous les cas le tron on horizontal ne devra jamais B d passer 2 m UNI 10683 2005 e chaque coude du canal de la fum e r duit sensiblement le tirage du tuyau d vacuation des fum es ce qu il faudra A Fermeture compenser en l levant ad quatement hermetique e a Norme UNI 10683 2005 ITALIE pr voit que les coudes et les variations de direction ne doivent en aucun cas d passer le nombre de 2 y compris l introduction dans le tuyau d vacuation des fum es Si on souhaite utiliser le tuyau d vacuation des fum es d une Porte d inspection chemin e ou d un foyer ouvert il faudra fermer herm tiquement la hotte au dessous du point d entr e du canal de fum e pos A ABB 10 Si le tuyau d vacuation des fum es est trop grand par ex cm 30 x 40 ou 40 x 50 il faut y ins rer un tuyau suppl mentaire en acier inox d un diam tre minimum de 200 mm pos B en ayant soin de bien fermer l espace restant entre le tuyau lui m me et le tuyau Figure 10 d vacuation des fum es imm diatement en dessous du terminal de chemin e pos C Nous vous prions de contacter votre revendeur de zone pour toute information compl mentaire pour pl
16. dell apparecchio il vostro benessere e la vostra sicurezza Bisogna pertanto garantire una alimentazione aggiuntiva di aria fresca mediante una presa d aria esterna posta nelle vicinanze dell apparecchio oppure tramite la posa di una conduttura per l aria di combustione che porti verso l esterno od in un vicino locale areato ad eccezione del locale caldaia o garage VIETATO Il tubo di collegamento deve essere liscio con un diametro minimo di 120 mm deve avere una lunghezza massima di 4 m e presentare non pi di tre curve Qualora questo sia collegato direttamente con l esterno deve essere dotato di un apposito frangivento 1095080 Rev 05 IT 11 NONDIC ROSA ROSETTA L entrata d aria per la combustione nel luogo d installazione non deve essere ostruita durante il funzionamento della cucina E assolutamente necessario che negli ambienti in cui vengono fatte funzionare cucine con un tiraggio naturale del camino venga immessa tanta aria quanta ne necessaria per la combustione ossia fino a 20 m3 ora Il naturale riciclo d aria deve essere garantito da alcune aperture fisse verso l esterno la loro grandezza stabilita da relative normative in materia Chiedete informazioni al Vostro spazzacamino di fiducia Le aperture devono essere protette con delle griglie e non devono mai essere otturate Una cappa di estrazione aspirante installata nella stessa stanza od in una confinante pu nel caso d insufficiente apport
17. di combustione circa met della quantit indicata nel manuale d istruzioni e tenere il prodotto acceso per almeno 6 10 ore di continuo con i registri meno aperti di quanto indicato nel manuale d istruzioni 3 Ripetere questa operazione per almeno 4 5 o pi volte secondo la Vostra disponibilit 4 Successivamente caricare sempre pi seguendo comunque quanto descritto sul libretto di istruzione relativamente al massimo carico e tenere possibilmente lunghi i periodi di accensione evitando almeno in questa fase iniziale cicli di accensione spegnimento di breve durata 5 Durante le prime accessioni nessun oggetto dovrebbe essere appoggiato sulla stufa ed in particolare sulle superfici laccate Le superfici laccate non devono essere toccate durante il riscaldamento 6 Una volta superato il rodaggio si potr utilizzare il Vostro prodotto come il motore di un auto evitando bruschi riscaldamenti con eccessivi carichi Per accendere il fuoco consigliamo di usare piccoli listelli di legno con carta di giornale oppure altri mezzi di accensione in commercio escluse tutte le sostanze liquide come per es alcool benzina petrolio e simili Le aperture per l aria primaria e secondaria devono essere aperte insieme il registro fumi da regolare per la funzione cucina ovvero la leva di comando deve essere spinta verso la schiena si deve aprire anche l eventuale valvola a farfalla posta sul tubo di scarico fumi Quando la legna co
18. du conduit de la fum e d pend galement de la bonne conformation du terminal de chemin e Par cons quent il est indispensable s il a t construit artisanalement que la section de sortie soit deux fois la section interne du conduit d vacuation de la fum e Devant toujours d passer le faitage du toit le terminal de chemin e devra assurer l vacuation m me en pr sence de vent Figure 4 Le terminal de chemin e doit r pondre aux conditions suivantes e avoir une section interne quivalente celle de la chemin e e avoir une section utile de sortie double de celle interne du conduit de chemin e 1095080 Rev 05 FR 41 NOTO ROSA ROSETTA tre construit de mani re emp cher la p n tration dans le conduit de la chemin e de pluie de neige et de tout autre corps tranger pouvoir tre facilement inspect pour d ventuelles op rations d entretien et de nettoyage 1 Un terminal industriel E e 2 Terminal de chemin e 3 Terminal pour conduit de l ments pr fabriqu s artisanal La section F chemin e en acier avec permet une excellente correcte de sortie doit tre c ne interne d flecteur de la limination de la fum e au minimum 2 fois la fum e section interne du conduit de la chemin e id ale 2 5 fois KSSS Figure 4 1 En cas de conduits de fum e mitoyens un des deux terminaux
19. du produit et on il NE FAUT PAS descendre au dessous des valeurs indiqu s b dans la zone de radiation devant la porte du foyer la distance entre la porte et tout objet ou mat riel inflammable et sensible la chaleur doit tre d au moins 100 cm Cette distance peut diminuer 40 cm si une protection r troventil e et r sistante la chaleur est install e entre le foyer et les l ments inflammables C si le produit est install e sur un sol de mat riau inflammable pr voir une base ignifuge Les sols compos s par mat riaux inflammables comme moquette parquet ou li ge etc doivent tre remplac s pas une couche de mat riel pas inflammable par exemple c ramique pierre vitre ou acier etc dimensions selon les dispositions r gionales Le fond doit d passer frontalement d au moins 50cm et lat ralement d au moins 30cm au del de l ouverture de la porte de charge voir Figure 2 B d Il ne faut pas mettre des l ments inflammables au au dessus du produit es meubles suspendus Figure 2 La cuisini re doit fonctionner exclusivement avec le tiroir pour cendres ins r Les r sidus solides de la combustion cendres doivent tre ramass s dans un conteneur herm tique et r sistant au feu La cuisini re ne doit jamais tre allum e en pr sence d missions de gaz ou de vapeurs par
20. exemple colle pour linol um essence etc Ne pas d poser de mat riaux inflammables dans les proximit s de la cuisini re des portes des poign es des commandes des vitres du conduit de fum e et ventuellement de la partie avant de l appareil Evitez de toucher ces l ments sans un habillement de protection ad quat ou sans accessoires gants de protection contre la chaleur dispositifs de commande Faites prendre conscience de ces dangers aux enfants et tenez les loign s du foyer pendant son fonctionnement L utilisation d un combustible incorrect ou trop humide pourrait provoquer un incendie du tuyau d vacuation de la fum e cause des d p ts pr sents dans ce tuyau 40 1095080 Rev 05 FR ROSA ROSETTA Qi 4 1 INTERVENTION EN CAS D URGENCE En cas d incendie sur le raccordement ou dans le tuyau d vacuation de la fum e a Fermer la porte de chargement b Fermer les r gulateurs d air comburant c Eteindre l incendie l aide d extincteurs au dioxyde de carbone CO2 en poudre d Appeler imm diatement les Pompiers Ne pas utiliser de jets d eau pour teindre le feu Une fois le tuyau d vacuation teint le faire v rifier par un sp cialiste pour localiser d ventuelles fissures ou points perm ables 5 CONDUIT DE FUMEE Exigences fondamentales pour un fonctionnement correct de l appareil e la section interne doit tre de pr f rence circulaire e tre thermiqueme
21. fait par rayonnement la chaleur est rayonn e dans le milieu ambiant travers les superficies externes chaudes de la cuisini re La cuisini re est quip e avec de r gulateurs d air primaire et secondaire avec les quels on r gle la combustion 2 1 REGULATEUR AIR PRIMAIRE vanne pivotante Le registre d air inf rieur Figure 1 pos A r gle le passage d air primaire dans le bas de la cuisini re travers le bac cendres et la grille en direction du combustible L air primaire est n cessaire pour le processus de combustion Le bac cendres doit tre r guli rement vid de fa on ce que les cendres ne puissent g ner l arriv e de l air primaire pour la combustion Le feu est galement maintenu en vie par le biais de l air primaire Le registre d air primaire ne doit tre ouvert qu un petit peu durant la combustion de bois pour viter que le bois ne br le rapidement ce qui pourrait entrainer une surchauffe de la cuisini re Chap 10 2 2 REGULATEUR AIR SECONDAIRE Le registre d air secondaire se trouve au dessus de la porte du foyer Il doit tre ouvert et par cons quent d plac vers la Droite Figure 1 pos B en particulier pour la combustion de bois Chap 10 Figure 1 2 3 REGULATEUR FUMEES Conversion de la fonction de cuisiniere celle de cuisini re cuisson a
22. fen tres et portes avec fermeture tanche joints d tanch it Il n est pas permis de raccorder plusieurs appareils la m me chemin e Le diam tre de l ouverture du tuyau d vacuation de la fum e pour le raccordement doit 1095080 Rev 05 FR 39 UNITO ROSA ROSETTA correspondre au moins au diam tre du conduit de fum e L ouverture devrait tre quip e d une connexion murale pour y introduire le conduit de d charge et d une rosace Le tronc de d charge non utilis doit tre recouvert avec le bouchon ad quat Avant l installation v rifiez que le sol puisse supporter le poids de votre appareil En cas de port e insuffisante il faut adopter des mesures opportunes par ex plaque pour la distribution du poids La soci t Nordica S p a n est pas responsable en cas de modifications apport es au produit sans autorisation et n est pas responsable non plus dans le cas d utilisation de pieces de rechange non originales Les foyers ne doivent pas tre modifi s 4 SECURITE ANTINCENDIE Lors de l installation de la cuisini re il faut respecter les mesures de s curit suivantes a pour assurer une isolation thermique suffisent respecter la distance minimale de s curit entre le po le et les l ments de construction et objets inflammables et sensibles la chaleur meubles rev tements en bois tissus etc voir Figure 2 Toutes les distances minimales de s curit sont indiqu es dans l tiquette
23. hat auBerdem den Nachteil dass sich das Wasser bei Absinken der Temperatur zuerst im Feuerraum und dann im Schornstein niederschl gt Frisches Holz enth lt etwa 60 H2O und ist daher nicht zum Verbrennen geeignet Unter anderem d rfen nicht verbrannt werden Kohlereste Abschnitte Rinden und Bretterabfalle feuchtes oder mit Lack behandeltes Holz Kunststoffe in diesem Fall verf llt die Garantie f r das Ger t Papier und Karton d rfen nur zum Anfeuern benutzt werden Die Verbrennung von Abf llen ist verboten Sie w rde sowohl den Ofen als auch den Schornstein besch digen und zu Gesundheitsschaden und auf Grund der Geruchsbel stigung zu Nachbarschaftsbeschwerden f hren Holz ist kein Dauerbrennstoff sodass ein Durchheizen des Herdes ber Nacht nicht m glich ist Typ Kg mc EGRE TE URS Buchen 750 0 Zerreichen 900 4 2 Ulme 640 4 1 Pappel 470 44 Laerche 660 44 Rottanne 450 m Waldkiefer 550 se HARZIGE HOLZ NICHT GEEIGNET FUR EINEN OFEN WARNUNG Die standige und dauernde Verwendung von Aromatisch lreichen Holz Eukalyptus Myrte etc wird eine schnelle Beschadigung Abspaltung der Gussteilen des Gerates verursachen 9 ANZUNDEN WICHTIG Es ist unvermeidlich dass beim ersten Anfeuern ein unangenehmer Geruch entsteht aufgrund des Austrocknens der Dichtung oder der Schutzlacke der nach kurzer Betriebsdauer verschwindet In jedem Fall muss eine gute Bel ftung des Raums gesi
24. la combustion jusqu 20m heure La recirculation naturelle de l air 1095080 Rev 05 FR 43 NOTAI ROSA ROSETTA doit tre garantie par quelques ouvertures fixes vers l ext rieur leur grandeur est tablie par les normes en la mati re Demander des informations votre ramoneur habituel Les ouvertures doivent tre prot g es par des grilles et il ne faut jamais les obstruer Une hotte d extraction aspiration install e dans la m me pi ce ou dans une pi ce adjacente provoque une d pression dans le local Ceci provoque l chappement de gaz br l s paisse fum e odeur et il faut donc assurer une plus grande arriv e d air frais La d pression d une hotte aspirante peut dans le pire des cas transformer le tuyau d vacuation des fum es du po le en prise d air ext rieure et aspirer nouveau les fum es dans le local ce qui entra ne de tr s graves cons quences pour les personnes 8 COMBUSTIBLES ADMIS NON ADMIS Les combustibles admis sont les b ches de bois de chauffage On doit utiliser exclusivement des b ches de bois sec contenu en eau max 20 On peut charger max 2 3 buches de bois la fois Les b ches de bois devront avoir une longueur d environ 30 cm et une circonf rence de 30 35 cm max Le bois utilis comme combustible doit contenir un taux d humidit inf rieur 20 on l obtient apr s un an au moins de s chage bois tendre ou de deux ans bois dur en plagant ce bois dans un e
25. m UNI 10683 o Plugging 2005 a e each bend of the smoke channel considerably reduces the draught of the flue which must be compensated for by raising it suitably e the UNI 10683 2005 Regulation Italy requires that the bends or variations of direction must in no case be greater than 2 including the emission into the flue A Hermetic closure Wanting to use the flue of a chimney or open furnace it will be necessary to close the hood hermetically below the inlet point of the smoke channel pos A Picture 10 If the flue is too large e g cm 30x40 or 40x50 it is necessary to duct it with a stainless steel tube of at least 200 mm of diameter pos B taking care to close the space between the tube itself and the flue immediately below the chimney cap pos C Inspection For further information please contact your Dealer Picture 10 26 1095080 Rev 05 EN ROSA ROSETTA aore CEE Hu 1 TECHNISCHE DATEN Definition Dauerbrandherd nach EN 12815 L 7 LO ROSA ROSETTA Bauart 2 2 Nennw rmeleistung in KW 6 5 6 Wirkungsgrad in 96 78 9 74 Rauchrohrdurchmesser in mm 150 130 Maximal aufzugebende Brennstoffmassen Holz in kg h 1 9 2 Abgasmassenstrom Brennstoff Holz in g s 8 7 9 56 Abgastemperatur hinter dem Abgasstutzen Holz in C 239 255
26. r sistante des pouss es thermiques allant jusqu 750 C et ne sont donc pas sujettes des c hocs thermiques Elles ne peuvent se rompre que par chocs m caniques coups ou fermeture violente de la porte etc Par cons quent le remplacement de la vitre n est pas sous garantie 13 3 NETTOYAGE DU CENDRIER Toutes les cuisini res La NORDICA sont quip es d une grille de foyer et d un tiroir pour le ramassage des cendres Nous vous conseillons de vider p riodiquement le tiroir des cendres et d en viter le remplissage total pour ne par surchauffer la grille De plus nous recommandons de laisser toujours 3 4 cm de cendres dans le foyer ATTENTION les cendres retir es du foyer doivent tre d pos es dans un r cipient en mat riel ignifuge muni d un couvercle tanche Le r cipient doit tre pos sur un sol ignifuge loin de mat riaux inflammables jusqu ce que les cendres soient teintes et compl tement refroidies 13 4 FAIENCES LA NORDICA Les faiences La Nordica sont des produits de haute fabrication artisanale et comme tels elles peuvent pr senter de tr s petits grumeaux des craquelures et des imperfections chromatiques Ces caract ristiques sont la preuve de leur grande valeur L mail et la faience pour leur diff rent coefficient de dilatation produisent des microfissures craquelure qui en d montrent l authenticit Pour nettoyer les faiences nous conseillons d utiliser un chiffon doux et sec un d terge
27. regelm ig entleert werden da die Asche den Eintritt der prim ren Verbrennungsluft behindern kann Durch die Prim rluft wird auch das Feuer am Brennen gehalten Der Prim rluft Schieber darf w hrend der Verbrennung von Holz nur wenig ge ffnet werden da andernfalls das Holz schnell verbrennt und der Kaminofen sich berhitzen kann Abschnitt 10 2 2 DER SEKUNDARLUFTSCHIEBER ber der Feuerraumt r befindet sich der Sekund rluft Schieber ABB 1 B Dieser Schieber mu ebenfalls bei der Verfeuerung von Holz ge ffnet werden Abschnitt 10 2 3 RAUCHGASKLAPPE Umstellung von KOCHBETRIEB auf Koch Back und HEIZBETRIEB Auf der Vorderseite rechts des Dauerbrandherdes zwischen der Schutzstange und der Backofent r befindet sich der Bedienknopf der Rauchgasklappe der durch einen Ballengriff aus Messing erkennbar wird ABB 1 C Wenn man die Einstellvorrichtung nach hinten schiebt str men die Rauchgase ber den Backraum direkt zu dem Rauchgasstutzen KOCHBETRIEB Platte Gebrauch wenn man die Einstellvorrichtung nach auBen zieht str men die Rauchgase um den Backofen herum so da seine innere Temperatur gleichm ig erh ht wird Koch Back und HEIZBETRIEB Backofen Gebrauch 3 INSTALLATIONSVORSCHRIFTEN Der Herd ist anschlussfertig montiert und muss mit einem
28. si trova il registro aria secondaria Questa valvola deve essere aperta quindi spostata verso destra Figura 1 pos B in particolare per la combustione di legna vedi paragrafo 10 Figura 1 2 3 REGISTRO FUMI Conversione dalla funzione di cucina a quella di cucina cottura al forno e riscaldamento Sulla destra del lato anteriore della cucina tra il corrimano di protezione e la porta del forno si trova la leva di comando del registro fumi riconoscibile da un pomolo in ottone Figura 1 pos C Quando si spinge la leva verso il retro della cucina i gas di combustione fluiscono sopra il forno direttamente verso il tronchetto di scarico funzione cucina USO PIASTRA quando invece si tira la leva verso di s i gas di combustione fluiscono tutto intorno al forno cosicch la sua temperatura interna aumenta in modo uniforme funzione cucina cottura al forno e riscaldamento USO FORNO 3 NORME PER L INSTALLAZIONE La cucina assemblata e pronta per l allacciamento e deve essere collegata mediante un raccordo all esistente canna fumaria della casa Il raccordo deve essere possibilmente corto rettilineo orizzontale o posizionato leggermente in salita collegamenti devono essere a tenuta stagna E obbligatorio rispettare norme nazionali ed europee disposizioni locali o in materia di legislazione edilizia nonch regolamentazioni
29. the calorific need The best combustion with minimum emissions is reached when by loading the wood most part of the air for combustion flows through the secondary air register Never overload the appliance Too much fuel and too much air for the combustion may cause overheating and then damage the stove You should always use the appliance with the door closed in order to avoid damages due to overheating forge effect The inobservance of this rule makes the warranty expire PRIMARY AIR SECONDARY AIR ROSETTA 1 6 OPEN OPEN ROSA 2 3 OPEN 20mm OPEN Further from the adjustment of air for the combustion the intensity of combustion and then the calorific value of your cooker is affected by the chimney A good flue of the chimney requires a more reduced adjustment of air for the combustion while a poor flue needs more an exact adjustment of air for combustion IMPORTANT To verify the good combustion of the cooker check if the smoke coming out from the chimney is transparent If it is white it means that the cooker is not correctly adjusted or the wood is too wet if on the contrary the smoke is grey or black it means that the combustion is not complete it is necessary a greater quantity of secondary air 11 USE OF THE OVEN After shaking the grate load some fuel Thanks to the air flow for the combustion the temperature of the oven may become remarkably affected A good flue of the chimney and channels well clean
30. tube d vacuation ou dans la chemin e ze AFFLUX DE L AIR DANS LE LIEU D INSTALLATION PENDANT LA COMBUSTION Etant donn que les po les bois pr l vent l air utile la combustion dans le local d installation il est indispensable qu une quantit d air suffisante soit pr sente dans la pi ce En cas de fen tres et de portes tanches par ex les maisons construites conform ment au crit re de l conomie d nergie il se peut que l entr e d air froid ne soit plus garantie cela risque de compromettre le tirage de l appareil votre bien tre ainsi que votre s curit Par cons quent il faut garantir une alimentation suppl mentaire d air froid au moyen d une prise d air externe plac e proximit de l appareil ou bien installer une conduite pour l air de combustion dirig e vers l ext rieur ou dans une pi ce a r e l exception de la pi ce ou se trouve la chaudi re ou le garage INTERDIT Le tuyau de raccordement doit tre lisse de 120mm de diam tre minimum devra mesurer 4 m de longueur maximum et ne devra pas avoir plus de 3 coudes Si celui ci sera raccord directement avec l ext rieur il devra tre quip d un pare vent L entr e d air pour la combustion dans le lieu d installation ne doit pas tre ferm e durant le fonctionnement du po le Il est absolument n cessaire que dans les locaux o fonctionnent les po les avec un tirage naturel de la chemin e soit introduite une quantit d air suffisante pour
31. 4 SOMMERPAUSE iii 36 15 ANSCHLUSS AN DEN RAUCHABZUG EINES OFFENEN KAMINS a wre 36 16 MONTAGGIO CORRIMANO LATERALI MONTAGE DER SEITLICHEN HANDL UFE MONTAGE DES BARRES LATERALES EE 49 17 SCHEDA TECNICA CARACTERISTIQUES TECHNIQUES TECHNISCHE PROTOKOLLE FICHE Elle cor A A W em e 50 TABLE DES MATIERES FR 1 DONNES TECHNIQUES mener 38 2 DESCRIPTION TECHNIQUE cette tette tette tette te EESE EAE tts se Dess oss ODD 39 2 4 REGULATEUR AIR PRIMAIRE vanne pivotante ns 39 2 2 REGULATEUR AIR SECONDAIRE cnrs 39 2 3 REGULATEUR FUMEES einen 39 3 NORMES POUR L INSTALLATION ere 39 4 SECURITE AN TINGE ND IE is vet biyen dan isi pot gas rete iom nu e e ties eee etes a et e DN a Ed 40 gt INTERVENTION EN CAS DURGENGE voit hare ere ende ne miete ir 41 CONE 41 51 POSITION DU TERMINAL DE LA CHEMINEE rnnt tette Irene 41 6 RACCORDEMENT AU CONDUIT DE FUM E ie 43 7 AFFLUX DE L AIR DANS LE LIEU D INSTALLATION PENDANT LA COMBUSTION es 43 8 COMBUSTIBLES ADMIS NON ADMIS e 44 o ALLUMAGE ie 44 10 FONCTIONNEMENT STANDARD 45 11 UTILISATION DU FOUR 46 12 FONCTIONNEMENT PENDANT LES PERIODES DE TRANSITION 46 13 ENTRETIEN ET SON 46 13 1 NETTOYAGE DU CONDUIT D EVACUATION DE EUMEE e 46 122 NETTOYAGE DE LA VITRE och la 47 133 NETTOYAGE DU CENDRIER c ll aaa 47 19 4 FAIENCES LA NOBDIGR luana ei 47 14 SOMMERPAUSE i 47 15 RACCORDEMENT AU CON
32. CUCINA A FUOCO CONTINUO WOOD COOKER DAUERBRANDHERD CUISINIERE A BOIS ROSA ROSETTA Testata secondo Tested according to Gepr ft nach Certifi e selon EN 12815 Complimenti per aver acquistato una prodotto a legna LA NORDICA Compliments for buying a wood cooker LA NORDICA Wir gratulieren Ihnen zum Kauf eines LA NORDICA Holzger tes Recevez nos compliments pour avoir choisi une cuisini re LA NORDICA Sentirsi bene e allo stesso tempo risparmiare energia con i prodotti LA NORDICA diventa possibile With LA NORDICA cookers it is now possible to feel good and to save energy at the same time Sich wohl f hlen und gleichzeitig Energie sparen Mit den Produkten der Marke LA NORDICA wird es m glich Bien tre et conomie d nergie sont d sormais possibles grace aux produits LA NORDICA NORME DI SICUREZZA SUGLI APPARECCHI Secondo le norme di sicurezza sugli apparecchi l acquirente e l esercente sono obbligati ad informarsi sul corretto funzionamento in base alle istruzioni per l uso SAFETY PRESCRIPTIONS ON EQUIPMENT According to the safety prescriptions on equipment the purchaser and the operator are obliged to get informed about the correct operation according
33. Carta e cartone devono essere utilizzati solo per l accensione La combustione di rifiuti vietata e danneggerebbe la stufa e la canna fumaria provocando inoltre danni alla salute ed in virt del disturbo olfattivo a reclami da parte del vicinato La legna non un combustibile a lunga durata e pertanto non possibile un riscaldamento continuo della cucina durante la notte Specie Kg mc KWh Kg Umidit 20 Faggio 750 4 0 Cerro 900 4 2 Olmo 640 4 1 Pioppo 470 4 1 Larice 660 4 4 Abete rosso 450 4 5 Pino silvestre 550 4 4 LEGNI RESINOSI POCO ADATTI PER UNA STUFA ATTENZIONE L uso continuo e prolungato di legna particolarmente ricca di oli aromatici p e Eucalipto Mirto etc provoca il deterioramento sfaldamento repentino dei componenti in ghisa presenti nel prodotto 9 ACCENSIONE IMPORTANTE alla prima accensione inevitabile che venga prodotto un odore sgradevole dovuto all essiccamento dei collanti nella cordicella di guarnizione o delle vernici protettive che sparisce dopo un breve utilizzo Deve comunque essere assicurata una buona ventilazione dell ambiente Alla prima accensione Vi consigliamo di caricare una quantit ridotta di combustibile e di aumentare lentamente la resa calorifica dell apparecchio registri d aria per la combustione dovrebbero essere aperti solo un po 12 1095080 Rev 05 IT ROSA ROSETTA I iN o f A Per effettuare una
34. DUIT DE FUMEE D UNE CHEMINEE OU D UN FOYER OUVERT 48 16 MONTAGGIO CORRIMANO LATERALI MONTAGE DER SEITLICHEN HANDLAUFE MONTAGE DES BARRES LATERALEES ille leale 49 17 SCHEDA TECNICA CARACTERISTIQUES TECHNIQUES TECHNISCHE PROTOKOLLE FICHE CNE GR SO EN MN 50 1095080 Rev 05 IT EN DE FR 5 NOGDICA ROSA ROSETTA CEE Hu 1 DATI TECNICI Definizione Cucina a fuoco continuo secondo EN 12815 Ci D ROSA ROSETTA Sistema costruttivo 2 2 Potenza nominale in kW 6 5 6 Rendimento in 78 9 74 Diametro tubo in mm 150 130 Quantit max di combustibile legna in kg h 1 9 2 Emissione gas di scarico in g s legna 8 7 9 56 Temperatura gas allo scarico in legna 239 255 CO misurato al 13 di ossigeno in 0 11 0 12 Depressione a rendimento calorifico nominale in mmH O legna 1 0 1 2 Dimensioni apertura focolare in mm L x P 223x265 209x265 Dimensioni corpo focolare piano focolare in mm Lx H x P 270x340x400 230x350x382 Dimensioni forno in mm L x H x P 330x298x410 245x300x384 Tipo di griglia movibile piana Altezza cucina in mm 851 843 Larghezza cucina in mm 1030 869 Profondit cucina senza maniglie in mm 666 572 Peso in kg Capitolo 17 Distanze di sicurezza antincendio Capitolo 4 La capacit di riscaldamento delle cucine secondo EN 12815 per edifici il cui isolamento termico non c
35. E si dichiara sotto la propria responsabilit che gli apparecchi sono conformi alle esigenze essenziali previste dalle Direttive su menzionate As the manufacturer s authorised representative established within EEC we declare under out sole responsibility that the equipment follows the provisions of the Directives stated above Als vom Hersteller bevollmachtigter und in der EEC etablierter Vertreter erkl ren wir dass wir die volle Verantwortung daf r bernehmen dass die Ger te den Vorschriften entsprechen die in den oben angegebenen Direktiv n dargelegt werden vedi allegato see enclosure siehe Beilage 07 02 2007 Montecchio Precalcino VI data e luogo di emissione place and date of issue Ort und Datum der Ausstellung 1095080 Rev 05 IT EN DE FR 51 NOTAI ROSA ROSETTA INFORMAZIONI MARCATURA C E MARKING INFORMATION AUSZEICHNUNGSINFORMATIONEN CE LA NORDICA S p A 07 EN 12815 ROSA Distanza minima da materiali infiammabili Laterale lateral seiten 20 cm Distance to adjacent combustible materials 1 Mindestabstand zu brennbaren Materialen Posteriore rear hinten 20 cm Emissione di CO 13 96 02 Emission of CO 13 Oz 0 11 1500 mg m CO Ausstoss bez auf 13 O2 Emissioni polveri 13 02 Dust emissions 13 96 O2 30 mg m Staubemissionen 13 96 O2 Massima pressione idrica di esercizio ammessa Maximum operating pressure d Maximale Betrieb
36. Mittlerer CO Gehalt der Abgase bezogen auf 13 Oz in Yo 0 11 0 12 F rderdruck bei Nennwarmeleistung in mmH O Holz 1 0 1 2 Gr Be der Feuerraum ffnung in mm B x P 223x265 209x265 Gr Be des Feuerraumbodens des Feuertopfes in mm B x H x T 270x340x400 230x350x382 Gr Be Backfachraum in mm B x Hx T 330x298x410 245x300x384 Rostkonstruktionen R ttelrost plan Hohe der Feuerstatte in mm 851 843 Breite der Feuerstatte in mm 1030 869 Tiefe der Feuerstatte ohne Griffe und Schutzstange in mm 666 572 Annahrendes Gewicht in kg Abschnitt 17 Mindeste Brandschutzabstande Abschnitt 4 Das Raumheizverm gen des Dauerbrandherdes nach EN 12815 fiir Gebaude deren Warmedammung nicht der Warmeschutzverordnung entspricht betragt 30 Kcal h x m g nstige Bauweise 40 Kcal h x m weniger g nstige Bauweise 50 Kcal h x m ungtinstige Bauweise ROSA 185 m 138 m 111 m3 ROSETTA 172 m 129 m 103 m3 Bei Warmedammung gem B Warmeschutzverordnung erh ht sich das Raumheizverm gen Bei zeitweilige Beheizung ist das Raumheizverm gen um ca 2596 geringer 1095080 Rev 05 DE 27 NOTO ROSA ROSETTA 2 TECHNISCHE BESCHREIBUNG Die Dauerbrandherde von La Nordica eignen sich daf r zu kochen backen und Wohnr ume zeitweise zu beheizen bzw zur Unterst tzung einer nicht ausreichenden Raumheizung Sie sind ideal f r Ferienwohnungen und Wochenendhauser bzw als Zusatzheizung wahrend des ganzen Jahres
37. NNECTING A CHIMNEY OR OPEN FURNACE TO THE FLUE o ae DE EE ee 26 16 MONTAGGIO CORRIMANO LATERALI MONTAGE DER SEITLICHEN HANDLAUFE MONTAGE DES Ee TR TE 49 17 SCHEDA TECNICA CARACTERISTIQUES TECHNIQUES TECHNISCHE PROTOKOLLE FICHE TECHNIQUE ee 50 4 1095080 Rev 05 IT EN DE FR ROSA ROSETTA n Nono INHALTSVERZEICHNIS DE 1 TECHNISCHE DATEN 27 2 TECHNISCHE BESCHREIBUNG ccssessssssesssessssscsesseesessscssessuccsscssccssssssesscsusesscssscesessscesecsscssesseesecsceseesseess 28 2 1 DER PRIM RLUFTSCHIEBER drehebare Klapppe ii 28 2 2 DER SEKUNDARLUFTSCHIEBER nn 28 23 RAUCHGASKLAPPE siii eieiei 28 3 INSTALLATIONSVORSCHRIFTEN ii 28 MEANS Zr a a ee ee M Ld dui 29 AAs NOTFALLEINGRIFP o 30 B SSCHORNS TEM IA Lose en et kt it n en a dd ba ii pense 30 Bd ie nes en 30 6 KAMINANSCHLUSS ie 32 7 LUFTZUSTROM IN DEN AUFSTELLRAUM BEI DER VERBRENNUNG ssssssssssssssssssstesessssenessnerrrnen 32 8 ZULASSIGE UNZULASSIGE BRENNSTOFFE sssssssseeeeeenettettett ettet tette ttt 33 EE ANZUNDEN iii 33 10 NORMALBETRIEB o ii 34 11 BACKEN mnc cp uu E E E 35 12 BETRIEB IN DER BERGANGSZEIT eterne tette tette tts tette 35 13 WARTUNG UND PFLEGE ie 35 13 1 REINIGUNG DES SCHORNSTEINS eee 35 132 REINIGUNG DES SICHTFENSTERS cile 36 13 3 REINIGUNG DES ASCHEKASTENS eines 36 13 4 LA NORDICA e EE EE 36 1
38. OSETTA 172 ms 129 m 103 m With a suitable thermal insulation complying with the instructions on heat protection the heating volume is greater In case of temporary heating the heating volume is reduced by about 25 1095080 Rev 05 EN 17 NOTO ROSA ROSETTA 2 TECHNICAL DESCRIPTION The continuous fire cookers of La Nordica are suitable to cook on the grill and on the oven and to heat living spaces for some periods or to support an insufficient centralized heating system They are ideal for holiday apartments and weekend houses or as an auxiliary heating system during the whole year As fuel wood logs are used The continuous fire cooker is made of galvanized and enamelled steel sheets and enamelled cast iron doors front side plate The hearth is totally sheathed with single cast iron sheets Inside there is a flat grate The cookers ROSA and ROSETTA can be equipped with a height adjustable grate The upper position optimizes the PLATE function the lower one the OVEN use The hearth is equipped with a panoramic door with ceramic glass resistant up to 700 This allows a wonderful view on the burning flames Furthermore it is thus avoided the output of sparks and smoke Below the oven door there is an extractable food warmer drawer with the related closing door never introduce flammable objects or materials The heating of the environment is made by irradiation through the panoramic glass and the external
39. TEGNIGA b n ik k0 nas aa i ARAARA EEEREN EAEE NANA AAA ANA NANA RR RRRA AERE RE RERE RENERE ERRARE 7 2 1 REGISTRO ARIA PRIMARIA valvola girevole sise 7 2 2 REGISTRO ARIA SECONDARIA e 7 2 3 KIELEN 7 Sy NORME PER L INSTALLAZIONE iii 7 4 SICUREZZA ANTINCENDIO ER alia 8 4 1 PRONTO INTERVENTO a a acter ees eee 9 5 GANNA FUMARIA nine iii ano einladen a ee 9 5 1 POSIZIONE DEL GOMIGNOUO m 9 6 COLLEGAMENTO AL CAMINO aaa a a aa aaa aaa aaa eee aaa aaa aaa aa aaa aaa aaa aaa ii iii ii aaaattttttttttttttttsttsssssoooooo 11 7 AFFLUSSO D ARIA NEL LUOGO D INSTALLAZIONE DURANTE LA COMBUSTIONE nenn 11 8 COMBUSTIBILI AMMESSI NON AMMESSI akne eee aaa aaa aaa aaa a aaa aaa aaaaaatttttttttsttottnoooooooon 12 BEEN ENEE AAA 12 10 FUNZIONAMENTO NORMALE rrr rhe ph rtp bara pa ha Pha Ee pa ERR tetta 13 11 WSO DEL elle ETE M 14 12 FUNZIONAMENTO NEI PERIODI DI TRANSIZIONE esses nina 14 13 MANUTENZIONE E CURA 2 7 0 0 7 dir iii 14 18 1 PULIZIA CANNA FUMARIA e 14 13 2 HIE En Ke Le EE IU I i IMEEM ILU 15 13 3 PULIZIA CASSETTO GENERE io 15 13 4 DN e lee 15 14 FERMO ESTIVO ii veut tre boss re eee reina is ie ale dwe n ke n p keep e IS 15 15 COLLEGAMENTO ALLA CANNA FUMARIA DI UN CAMINETTO O FOCOLARE APERTO 16 16 MONTAGGIO CORRIMANO LATERALI MONTAGE DER SEITLICHEN HANDLAUFE MONTAGE DES ET MN GT 49 17 SCHEDA TECNICA CARACTERISTIQUES TECHNIQ
40. UES TECHNISCHE PROTOKOLLE FICHE TECHNIQUE ee 50 INDEX EN 1 TECHNICAL RL RK 17 2 TEGHNIGAL DESGRIPTION t t irene et et en ananas ane Ex ERR ang a ka ER a RINO a NARRA kan kana aa ande 18 2 1 PRIMARY AIR CONTROL movable valve a aaaaett tea aa nennen nne ooooottassseesooooootooesesesotooooooeseseoesonn 18 2 2 SECONDARY AIR CONTROL ii 18 2 3 SMOKES CONTROL pull push Jever i 18 Be RULES FOR INSTALLATION ki aaa 18 4 FIRE AFET Y a cca 19 4 1 FIRST AID MEASURES an ie GER eis 19 INS 20 5 1 GHIMNEY CAP POSIT O N P 20 6 CONNECTION TO THE CHIMNEY EE 22 7 AIR ENTRANCE INTO THE INSTALLATION PLACE DURING COMDUIGTION nenn 22 8 ADMITTED NOT ADMITTED FU EL ierit rpeteeebepeh eese tete v ve py be py v pa ote se pos rta aiar 22 9 a EIGFITIN EE 23 10 NORMAL OPERATION URRPRPRERPPFPFPFEPPEELPFEERFFEPFEPEFEEFEEFEFEEFEEFEFEFEEPFFEFPEEFPPPFFFEPPEPEPPPEPEPEPEPPEFEEPEPPEEPEPEFPEFEEPEFPEFEEPPEEPEEEPE 24 11 USE elen ele VE BE 24 12 OPERATION IN TRANSITION PERIOUDG cece eee e cette eee e cnet eee EE nnn nn nnn nenne EEE EEE EEE EEE enn EE EEEES 24 13 MAINTENANCE AND CARE 5 7 3 11 I hh I hh EE I dh RE oe oa nnn nun on c nn nni meno ek e 25 13 1 GLEANING OF THE FLUE c c nen ee een 25 13 2 CLEANING OF THE GLASS eege EE eR aA E EEE iE EERE 25 13 3 CLEANING OF THE ASH DRAWER iaia aiar 25 H EN elle 26 14 sies 26 15 CO
41. Verbindungsst ck an den bestehenden Hausschornstein angeschlossen werden Das Verbindungsst ck soll m glichst kurz geradlinig waagerecht oder leicht steigend angeordnet sein Verbindungen sind abzudichten Nationale und europ ische Normen rtliche und baurechtliche Vorschriften sowie feuerpolizeiliche Bestimmungen sind einzuhalten Informieren Sie daher vorher Ihren Bezirksschornsteinfegermeister 28 1095080 Rev 05 DE ROSA ROSETTA De iN o f UA Es ist sicherzustellen dass die f r die Verbrennung ben tigte Luftmenge ausreichend ist Hierauf ist besonders bei dicht schlieBenden Fenstern und T ren Dichtlippen zu achten Der Anschluss mehrerer Ger te an denselben Schornstein ist zul ssig Der Durchmesser der Offnung des Rauchfangs f r den Anschluss muss mindestens dem Durchmesser des Rauchrohrs entsprechen Die Offnung sollte mit einem Wandanschluss zum Empfang des Abzugsrohrs und einer Rosette versehen sein Das unbenutzte Rauchabzugsstutzenloch muss mit der entsprechenden Verschlusskappe bedeckt werden Pr fen Sie vor dem Aufstellen ob die Tragf higkeit der Unterkonstruktion dem Gewicht Ihres Herdes standh lt Bei unzureichender Tragf higkeit m ssen geeignete Ma nahmen z B Platte zur Lastverteilung getroffen werden um diese zu erreichen La Nordica S p A ist nicht f r das Produkt verantwortlich wenn es ohne Genehmigung ge ndert wurde und umso weniger wenn andere als die Originalersatzteile ver
42. am Schornstein vermindern 7 LUFTZUSTROM IN DEN AUFSTELLRAUM BEI DER VERBRENNUNG Da Holzherde die Verbrennungsluft aus dem Raum in dem sie installiert sind entnehmen ist es u erst wichtig dass in diesen Raum eine ausreichende Luftmenge eintritt Bei hermetisch dichten Fenstern und T ren z B bei H usern die nach dem Kriterium der Energieersparnis gebaut sind kann es sein dass die Frischluftzufuhr nicht mehr gew hrleistet ist wodurch das Zugverhalten des Herdes und damit Ihr Wohlbefinden und Ihre Sicherheit beeintr chtigt wird Daher muss f r eine zus tzliche Frischluftzufuhr durch den Einbau eines Lufteintritts von au en in der N he des Kaminofens oder durch Verlegung einer nach au en oder in einen nahen bel fteten Raum ausgenommen Heizungskeller oder Garage VERBOTEN f hrenden Leitung gesorgt werden Das Verbindungsrohr muss glatt sein und einen mindesten Durchmesser von 120 mm haben Es darf eine L nge von h chstens 4 m haben und nicht mehr als 3 Kr mmungen aufweisen Wenn das Rohr direkt nach au en angeschlossen wird muss es ber einen entsprechenden Windschutz verf gen Der Eintritt von Verbrennungsluft in den Aufstellort darf w hrend des Betriebs des Ofens nicht verschlossen werden Es ist unbedingt notwendig dass den R umen in denen Ofen mit nat rlichem Zug des Schornsteins betrieben werden soviel Luft zugef hrt wird wie f r die Verbrennung notwendig ist d h bis zu 20 m h Die nat rliche 32
43. and bar must be pushed to the back of the cooker the eventual butterfly valve which is found on the exhaust smoke pipe is also to be opened 1095080 Rev 05 EN 23 NOGDICA ROSA ROSETTA When the wood starts burning you may load other fuels and adjust the air for combustion according to the instructions on paragraph 10 Please always be present during this phase Never overload the appliance see the hourly wood load in the table Too much fuel and too much air for the combustion may cause overheating and then damage the stove The inobservance of this rule makes the warranty expire 10 NORMAL OPERATION For safety reasons the door of the appliances with constructive system 1 must be opened only for the loading of the fuel or for removing the ashes while during the operation and the rest the door of the hearth must remain closed The appliances with constructive system 2 must be connected to their own flue The operating with open door is allowed under supervision IMPORTANT For safety reasons the door of the hearth can be opened only for the loading of the fuel The hearth door must always remain closed during operation or rest The nominal power will be reached with a minimum depression in the chimney of 10 12 Pascal 1 0 1 2 mm of water column With the controls positioned on the front of the appliance Picture 1 it is possible to adjust the heat emission of the hearth They have to be opened according to
44. antincendio Pertanto vi consigliamo di informarvi preventivamente presso il Vs capo spazzacamino distrettuale Bisogna inoltre verificare il sufficiente afflusso d aria necessario alla combustione a tale proposito fondamentale prestare attenzione a finestre e porte con chiusura stagna guarnizioni di tenuta 1095080 Rev 05 IT 7 NOTO ROSA ROSETTA Non consentito il collegamento di pi apparecchi allo stesso camino Il diametro dell apertura della canna fumaria per il collegamento deve corrispondere per lo meno al diametro del tubo fumo L apertura dovrebbe essere dotata di una connessione a muro per la ricezione del tubo di scarico e di un rosone Il tronchetto di scarico fumi non utilizzato deve essere ricoperto con il relativo tappo Prima dell installazione verificare se la portata della sottostruttura regge il peso del vostro apparecchio In caso di portata insufficiente necessario adottare opportune misure ad es piastra per la distribuzione del peso La Nordica S p A non responsabile del prodotto modificato senza autorizzazione e tanto meno per l uso di ricambi non originali NON SI POSSONO EFFETTUARE MODIFICHE ALL APPARECCHIO 4 SICUREZZA ANTINCENDIO Nell installazione della cucina devono essere osservate le seguenti misure di sicurezza a AI fine di assicurare un sufficiente isolamento termico rispettare la distanza minima di sicurezza dal retro e da entrambi i lati da elementi costruttivi e
45. apedini Efficienza 80 dell apparecchio fibrocemento acciaio zincato superfici ottima interne ruvide e porose In Fig 3 sono riportati alcuni esempi di 4 Evitare canne fumarie con sezione soluzione rettangolare interna il cui rapporto sia diverso dal disegno S k E 2 La sezione minima deve essere di 4 dm per esempio Efficienza 40 mediocre Fig 3 20x20cm per gli apparecchi il cui diametro di condotto inferiore a 200mm o 6 25dm per esempio 25x25cm per gli apparecchi con diametro superiore a 200mm Il tiraggio creato dalla vostra canna fumaria deve essere sufficiente ma non eccessivo Una sezione della canna fumaria troppo importante pu presentare un volume troppo grande da riscaldare e dunque provocare delle difficolt di funzionamento dell apparecchio per evitare ci provvedete ad intubare la stessa per tutta la sua altezza Una sezione troppo piccola provoca una diminuzione del tiraggio La canna fumaria deve essere adeguatamente distanziata da materiali infiammabili o combustibili mediante un opportuno isolamento o un intercapedine d aria E vietato far transitare all interno della stessa tubazioni di impianti o canali di adduzione d aria E proibito inoltre praticare aperture mobili o fisse sulla stessa per il collegamento di ulteriori apparecchi diversi 5 1 POSIZIONE DEL COMIGNOLO Il tiraggio della canna fumaria dipende anche dall idoneit del comignolo E pertanto indispensabile che se co
46. bustion into the installation place must not be closed during the operation of the cooker It is absolutely necessary that in the environment in which the cookers operate with the natural flue of the chimney it is introduced as much air as necessary for the combustion i e up to 20 m3 hour The natural recirculation of air must be ensured by some fixed openings on the outside The size of the necessary openings for air is fixed by the relevant prescriptions Ask information to your chimney sweeper The openings should be protected with grids and should never be obstructed An extraction hood aspirating installed in the same room or in a room nearby causes depression with output of combusted gasses smoke smell As consequence it is necessary to ensure more flow of fresh air The depression in an extraction hood can at worst hypothesis transforms the flue into an external air intake by sucking the smokes of the rooms with dangerous consequences for the people 8 ADMITTED NOT ADMITTED FUEL The fuel admitted is made of wood logs One must use only logs of dry wood water content max 20 One must load at maximum two or three logs of wood per time The wood pieces should have a length of 30 cm and a maximum circumference of 30 35 cm The wood used as fuel must have a moisture contents lower than 20 which is obtained after at least 1 year drying tender wood or 2 years hard wood and must be stored in a dry and ventilated place for ex Und
47. cciata della cucina viene regolata l emissione di calore del focolare Essi devono essere aperti secondo il bisogno calorifico Figura 1 La migliore combustione emissioni minime viene raggiunta quando caricando legna la maggior parte dell aria per la combustione passa attraverso il registro d aria secondaria La regolazione dei registri necessaria per l ottenimento della resa calorifica nominale con una depressione al camino di 10 12 Pa 1 0 1 2 mm di colonna d acqua la seguente 1095080 Rev 05 IT 13 NOGDICA ROSA ROSETTA ARIA PRIMARIA ARIA SECONDARIA ROSETTA 1 6 APERTO APERTO ROSA 2 3 APERTO 20mm APERTO L intensit della combustione e quindi la resa calorifica della Vostra cucina influenzata dal camino Un buon tiraggio del camino richiede una regolazione pi ridotta dell aria per la combustione mentre uno scarso tiraggio necessita maggiormente di una esatta regolazione dell aria per la combustione IMPORTANTE per verificare la buona combustione della stufa verificate che il fumo che esce dal camino sia trasparente Se bianco significa che la cucina non regolata correttamente o la legna troppo bagnata se invece il fumo grigio o nero segno che la combustione non completa necessaria una maggior quantit di aria secondaria 11 USO DEL FORNO Dopo aver pulito la griglia del focolare caricate del combustibile Grazie all apporto d aria per la co
48. chen anlegt Es ist daher wichtig beim Anfeuern die folgenden kleinen Vorkehrungen zu treffen 1 Vergewissern Sie sich dass am Aufstellort des Ofens ein starker Luftaustausch gew hrleistet ist 2 Bef llen Sie bei den ersten Anfeuerungen die Feuerkammer nicht zu stark mit ungef hr der H lfte der in der Bedienungsanleitung angegebenen Menge und lassen Sie den Ofen mindestens 6 10 Stunden st ndig bei Reglern laufen die weniger offen als in der Bedienungsanleitung beschrieben sind Wiederholen Sie diesen Vorgang nach M glichkeit mindestens 4 5 Mal 4 Bef llen Sie den Ofen danach immer st rker wobei jedoch die Hinweise der Bedienungsanleitung ber die maximale Bef llung zu beachten sind und lassen Sie ihn lange laufen Vermeiden Sie zumindest in dieser Anfangsphase kurzfristige Anfeuer und L schzyklen 5 Bei den ersten Anfeuerungen sollte kein Gegenstand auf den Ofen gestellt werden insbesondere nicht auf die lackierten Fl chen Die lackierten Fl chen d rfen w hrend des Heizens nicht ber hrt werden 6 Sobald die Anfeuerungsphase abgeschlossen ist k nnen Sie Ihren Ofen wie den Motor eines Autos nutzen wobei abruptes Heizen mit zu starker Heizmaterialzufuhr zu vermeiden ist Zum Anfeuern raten wir kleine Holzsp ne mit Zeitungspapier oder andere handels bliche Anfeuermittel mit Ausnahme von fl ssigen Stoffen wie z B Alkohol Benzin Petroleum oder hnliche Stoffe zu verwenden Die Prim r und Sekund rluf
49. chert werden Beim ersten Anfeuern empfehlen wir Ihnen eine geringe Menge Brennmaterial zu laden und die Heizleistung des Herdes langsam zu erh hen Um ein korrektes erstes Anfeuern der mit Hochtemperaturlacken behandelten Produkte durchzuf hren muss man Folgendes wissen e Das bei dem betreffenden Produkten verwendete Baumaterial ist nicht einheitlich Es gibt Teile aus Gusseisen Stahl feuerfestem Material und Majolika e Die Temperatur welcher der Ofenkorpus ausgesetzt ist ist nicht einheitlich In den verschiedenen Bereichen werden unterschiedliche Temperaturen zwischen 300T und 500C gemessen 1095080 Rev 05 DE 33 NOGDICA ROSA ROSETTA e W hrend der Nutzungsdauer des Ofens wird dieser mehrmals am Tag angefeuert oder gel scht Je nach Jahreszeit ist der Ofen abwechselnd intensiver Nutzung oder vollstandigem Stillstand ausgesetzt e Bevor man das neue Ger t als ausgereift bezeichnen kann muss es diverse Male in Betrieb genommen werden damit alle Materialien und die Lacke den unterschiedlichen elastischen Beanspruchungen ausgesetzt werden k nnen e Besonders am Anfang wird man den typischen Geruch von Metallen die gro eren thermischen Beanspruchung ausgesetzt sind und von noch frischem Lack wahrnehmen Obwohl der Lack bei der Herstellung einige Stunden lang bei 250 gebrannt wird muss er mehrmals f r eine bestimmte Dauer einer Temperatur von Uber 350 C ausgesetzt werden bevor er sich perfekt an die Metalloberfl
50. cifique La position sup rieure optimise lutilisation de la plaque de cuisson alors que la position inferieure optimise l utilisation du four Telle grille peut tre achet e comme OPTION Comme OPTION il est disponible aussi une grille pour le four 12 FONCTIONNEMENT PENDANT LES PERIODES DE TRANSITION Pendant la p riode de transition c est dire quand les temp ratures externes sont plus lev es en cas d augmentation impr vue de la temp rature il peut se produire certaines difficult s avec le tuyau d vacuation de la fum e qui font que les gaz de combustion ne sont pas compl tement aspir s Les gaz de d charge ne sortent plus compl tement forte odeur de gaz Dans de tels cas secouez plus fr quemment la grille et augmenter l air pour la combustion Ensuite chargez une quantit r duite de combustible en faisant en sorte que celui ci br le plus rapidement avec plus de flammes et le tirage du tuyau d vacuation de la fum e se stabilise Contr lez galement que toutes les ouvertures pour le nettoyage et les raccordements la chemin e soient herm tiques 13 ENTRETIEN ET SOIN Faites contr ler par votre ramoneur de zone l installation de la cuisini re le raccordement la chemin e et l a ration Pour le nettoyage des parties maill es utiliser de l eau et du savon ou des d tergents non abrasifs ou chimiquement agressifs Dans le cas de pi ces en laiton devenues bleu tres suite une surchauffe utilis
51. comignolo non deve avere ostacoli entro i 10 m da muri falde ed alberi In caso contrario innalzare lo stesso d almeno 1 m sopra l ostacolo Il comignolo deve oltrepassare il colmo del tetto d almeno 1 m 1 Asse colmo Figura 6 Figura 7 10 1095080 Rev 05 IT ROSA ROSETTA e iN o f UA COMIGNOLI DISTANZE E POSIZIONAMENTO UNI 10683 98 Inclinazione del tetto Distanza tra il colmo e il camino Atene debcamino PASUA daa sbocco a A m H m 1 85 m 0 50 m oltre il colmo 15 gt 1 85 m 1 00 m dal tetto 1 50 m 0 50 m oltre il colmo 30 gt 1 50 m 1 30 m dal tetto 1 30 m 0 50 m oltre il colmo 45 gt 1 30 m 2 00 m dal tetto lt 1 20m 0 50 m oltre il colmo 60 gt 1 20 m 2 60 m dal tetto 6 COLLEGAMENTO AL CAMINO Le cucine con chiusura automatica tipo 1 della porta devono obbligatoriamente funzionare per motivi di sicurezza con la porta del focolare chiusa fatta eccezione per la fase di carico del combustibile o l eventuale rimozione della cenere Le cucine con le porte non a chiusura automatica tipo 2 devono essere collegate ad una propria canna fumaria Il funzionamento con porta aperta consentito soltanto previa sorveglianza Il tubo di collegamento alla canna fumaria deve essere pi corto possibile rettilineo ed a tenuta stagna Il collegamento deve essere eseguito con tubi stabili e robusti Vi con
52. corretta prima accensione dei prodotti trattati con vernici per alte temperature occorre sapere quanto segue j materiali di costruzione dei prodotti in questione non sono omogenei infatti coesistono parti in ghisa in acciaio in refrattario e in maiolica la temperatura alla quale il corpo del prodotto sottoposto non omogenea da zona a zona si registrano temperature variabili dai 300 ai 500 durante la sua vita il prodotto sottoposto a cicli alternati di accensioni e di spegnimento durante la stessa giornata e a cicli di intenso utilizzo o di assoluto riposo al variare delle stagioni la stufa nuova prima di potersi definire stagionata dovr essere sottoposta a diversi cicli di avviamento per poter consentire a tutti i materiali ed alla vernice di completare le varie sollecitazioni elastiche in particolare inizialmente si potr notare l emissione di odori tipici dei metalli sottoposti a grande sollecitazione termica e di vernice ancora fresca Tale vernice sebbene in fase di costruzione venga cotta a 250 per qualche ora dovr superare pi volte e per una certa durata la temperatura di 350 prima di incorporarsi p erfettamente con le superfici metalliche Diventa quindi importante seguire questi piccoli accorgimenti in fase di accensione 1 Assicuratevi che sia garantito un forte ricambio d aria nel luogo dove installato l apparecchio 2 Nelle prime accensioni caricare non eccessivamente la camera
53. d f r die Glassauberkeit unerl sslich BRECHEN VON GL SER Die Gl ser sind aus Keramikglas und deswegen bis 750 hitzebest ndig Sie sind nicht f r thermische Schocks anf llig Das Brechen kann nur von mechanischen Schocks St e starke Schlie ung der T r etc verursacht werden Das Ersatzteil ist daher von der Garantie ausgeschlossen 13 3 REINIGUNG DES ASCHEKASTENS Alle Kamin fen und Herde der Marke LA NORDICA besitzen einen R ttelrost und eine Aschenlade Wir raten Ihnen die Aschelade regelm ig zu entleeren und zu vermeiden dass sie vollst ndig bef llt wird um den Rost nicht zu berhitzen Au erdem empfehlen wir immer 3 4 cm Asche im Feuerraum zu lassen ACHTUNG Die aus dem Feuerraum entfernte Asche muss in einen Beh lter aus feuerfestem Material mit einem dichten Deckel gef llt werden 13 4 LA NORDICA KACHELN Die La Nordica Kacheln werden in hochstehender handwerklicher Arbeit geschaffen Dadurch k nnen sie Mikroporenbildung Haarrisse und Farbunterschiede aufweisen Gerade diese Eigenschaften sind ein Beweis daf r dass sie aus wertvoller handwerklicher Fertigung stammen Email und Majolika bilden wegen ihres unterschiedlichen Dehnungskoeffizienten Mikrorisse Haarrisse die ihre Echtheit beweisen Zum Reinigen der Kacheln empfehlen wir Ihnen ein weiches trockenes Tuch zu benutzen falls Sie irgendein Reinigungsmittel oder eine Fl ssigkeit benutzen k nnte letztere in die Haarrisse eindringen und sie
54. d oggetti infiammabili e sensibili al calore mobili rivestimenti di legno stoffe ecc vedi Figura 2 A Tutte le distanze minime di sicurezza sono indicate sulla targhetta tecnica del prodotto e NON si deve scendere al di sotto dei valori indicati b davanti alla porta del focolare e nell area di radiazione della stessa non deve esserci alcun oggetto o materiale di costruzione infiammabile e sensibile al calore a meno di 100 cm di distanza Tale distanza pu essere ridotta a 40 cm qualora venga installata una protezione retroventilata e resistente al calore davanti all intero componente da proteggere c qualora il prodotto venga installato su un pavimento di materiale infiammabile bisogna prevedere un sottofondo ignifugo pavimenti in materiale infiammabile come moquette parquet o sughero etc devono essere sostituiti da uno strato di materiale non infiammabile ad esempio ceramica pietra vetro o acciaio etc dimensioni secondo l ordinamento regionale Il sottofondo deve sporgere frontalmente di almeno 50 cm e lateralmente di almeno 30 cm oltre all apertura della porta di carico Figura 2 B d sopra la cucina non devono essere presenti componenti infiammabili es mobili pensili Figura 2 La cucina deve funzionare esclusivamente con il cassetto cenere inserito residui sol
55. de de la cuisini re Figure 8 v rifiez que la position du d flecteur fum es soit comme indiqu en Figure 9 ou du haut Dans ce cas il faut enlever les cercles de la plaque de cuisson et d montez le tuyau fum es Le nettoyage peut se faire avec l aide d une brosse ou d un aspirateur Faites attention qu une fois termin e le nettoyage toutes les parties soient r install es herm tiquement 130 150mm ei 13 2 NETTOYAGE DE LA VITRE Grace a une entr e sp cifique de l air secondaire la formation de d p ts de salet sur la vitre de la porte est efficacement ralentie Cependant il est impossible de l viter compl tement avec l utilisation des combustibles solides exemple bois humide mais ceci ne doit pas tre consid r comme un d faut de l appareil IMPORTANT il ne faut nettoyer la vitre panoramique que quand la cuisini re est froide pour en viter l explosion Ne pas utiliser cependant de chiffons produits abrasifs ou chimiquement agressifs Figure 9 La proc dure correcte d allumage l utilisation de quantit s et combustibles appropri s la position correcte du registre d air secondaire le bon tirage du conduit et la pr sence d air comburent sont indispensables pour le bon fonctionnement de l appareil et garantissant le nettoyage de la vitre RUPTURE DES VITRES les vitres sont en vitroc ramique
56. deutlicher hervortreten lassen 14 SOMMERPAUSE Nachdem die Feuerstelle der Kamin und der Schornstein gereinigt und dabei alle Aschenreste und sonstigen R ckst nde entfernt worden sind alle Feuerraumt ren und Luftschieber schlie en und dann das Ger t vom Kamin trennen Der Schornstein sollte mindestens einmal j hrlich gereinigt werden dabei ist stets auch der Zustand der Dichtungen zu berpr fen Nur wenn die Dichtungen unversehrt sind k nnen sie eine einwandfreie Funktion des Ger ts gew hrleisten Die Dichtungen sollten daher ersetzt werden sobald sie nicht mehr einwandfrei sind Sollte der Raum in dem der Ofen aufgestellt ist feucht sein so sind entsprechende feuchtigkeitsabsorbierende Salze in den Feuerraum zu geben Die Gusseisenteile sollten mit neutraler Vaseline gesch tzt werden wenn deren Aussehen ber lange Zeit in unver nderter Sch nheit erhalten bleiben soll 15 ANSCHLUSS AN DEN RAUCHABZUG EINES OFFENEN KAMINS Der Rauchkanal ist der Rohrabschnitt der das Produkt mit dem Rauchabzug verbindet Bei der Verbindung sind diese einfachen aber u erst wichtigen Grunds tze zu beachten e Auf keinen Fall darf ein Rauchkanal benutzt werden der einen geringeren Durchmesser als die Ausgangsmanschette hat mit dem das Produkt ausgestattet ist e Jeder Meter eines horizontalen Verlaufs des Rauchkanals verursacht einen merklichen Lastverlust der gegebenenfalls durch eine Erh hung des Rauchabzugs auszugleichen ist
57. dieser schneller mit Flammentwicklung abbrennt und dadurch der Schornsteinzug stabilisiert wird Kontrollieren Sie dann ob alle ffnungen zur Reinigung und die Verbindungen mit dem Schornstein dicht sind 13 WARTUNG UND PFLEGE Lassen Sie die ordnungsgem e Aufstellung Ihres Kaminofens den Schornsteinanschluss und die L ftung von dem zust ndigen Bezirkschornsteinfegermeister pr fen F r die Reinigung der Emailleteile Seifenwasser oder nicht scheuernde oder chemisch aggressive Reinigungsmittel verwenden WICHTIG Es d rfen nur Ersatzteile verwendet werden die von LA NORDICA SpA ausdr cklich zugelassen bzw angeboten werden Bitte wenden Sie sich bei Bedarf an Ihren Fachh ndler DIE FEUERSTATTE DARF NICHT VERANDERT WERDEN 13 1 REINIGUNG DES SCHORNSTEINS Das richtige Anfeuern die Verwendung der geeigneten Art und Menge von Brennstoff die korrekte Einstellung des Sekundarluftreglers der ausreichende Kaminzug und das Vorhandensein von Verbrennungsluft sind f r eine optimale Funktionsweise des Ger ts unerl sslich Der Kaminofen sollte mindestens einmal pro Jahr vollst ndig gereinigt werden oder im Fall von Betriebsproblemen Die Reinigung darf nur bei kaltem Ofen erfolgen Diese Arbeit sollte von einem Schornsteinfeger ausg
58. e consentir tous ses mat riaux et la peinture de compl ter les diff rentes sollicitations lastiques e en particulier au tout d but on pourra noter l mission d odeurs typiques des m taux soumis une grande sollicitation thermique et de vernis encore frais Ce vernis bien qu il soit cuit 250 C pendant quelques heures au cours de sa fabrication devra d passer plusieurs fois et pendant une certaine dur e la temp rature de 350 C avant de s incorporer parfaitement aux surfaces m talliques Il est donc important de prendre ces petites pr cautions au cours de l allumage 1 S assurer qu un renouvellement important de l air soit garanti dans le local o est install l appareil 2 Au cours des premiers allumages ne pas charger excessivement la chambre de combustion la moiti environ de la quantit indiqu e dans le manuel d instructions et maintenir le produit allum pendant au moins 6 10 heures de suite avec les r glages moins ouverts que ce qui est indiqu dans le manuel d instructions R p ter cette op ration au moins 4 5 fois ou plus selon votre disponibilit 4 Ensuite charger de plus en plus en suivant de toute facon les indications fournies dans le manuel d instructions au sujet de la charge maximale et si possible effectuer de longues p riodes d allumage en vitant au moins au d but des cycles d allumage arr t de courte dur e 5 Au cours des premiers allumages aucun objet ne devrait tre appuy
59. e Verbrennung es ist eine h here Sekundarluftmenge erforderlich 11 BACKEN Geben Sie nach dem Abr tteln des Rostes Brennstoff auf Mit Hilfe der Verbrennungsluftzuf hrung kann die Backraumtemperatur beeinfluBt werden Ein ausreichender Schornsteinzug und gut gereinigte Heizgasz ge um den Backraum herum sind f r ein gutes Backergebnis wichtig Der Rauchschieber mu komplett nach au en gezogen werden Der Backrost und die Fettpfanne k nnen auf verschiedenen Ebenen eingeschoben werden Hohe Kuchen und groBe Braten werden auf der untersten Schiene eingeschoben Flache Kuchen und Geb ck auf der mittleren Schiene Die obere Schiene kann zum Nach bzw Uberbacken genutzt werden Der Herd kann mit einer Hubrost ausgestattet werden die durch eine dazu bestimmte Kurbel sich erhebt Die Selbe kann als OPTIONAL gekauft werden Die obere Stellung verbessert den Gebrauch der Platte die untere Stellung verbessert den Gebrauch des Backofens OPTIONAL Als Optional ist auch einen verchromten Backrost verf gbar 12 BETRIEB IN DER BERGANGSZEIT In der bergangszeit d h bei h heren AuBentemperaturen kann es zu St rungen des Schornsteinzuges kommen sodass die Verbrennungsgase nicht vollst ndig abgezogen werden Die Abgase treten nicht mehr vollst ndig aus starker Gasgeruch In diesem Fall sollten Sie den Rost h ufiger r tteln und die Verbrennungsluft erh hen Legen Sie dann eine geringere Brennstoffmenge auf und sorgen Sie daf r dass
60. e cooker the combustion gases flow around the oven and directly into the flue and up to the chimney OVEN COOKING when the control bar is pulled out the combustion gases flow around the oven heating it 3 RULES FOR INSTALLATION The stove assembled and ready for the installation must be connected with a junction to the existing flue of the house The junction must be possibly short straight horizontal or positioned a little uphill The connections must be tight It is obligatory to respect the National and European rules local regulations concerning building matter and also fireproofs rules Please apply to your chimney sweeper for all information You should verify the sufficient air entrance for the combustion in the installation place with particular attention to windows and doors with tight closing seal ropes It is not allowed the connection of various appliances to the same chimney The diameter of the opening for the connection must correspond at least to the diameter of the smokes pipe The opening should be equipped with a wall connection for the reception of the exhaust pipe and a rose window The small hole for the smoke connection pipe not in use must be covered with the related cap Before installation verify if your floor can support the weight of the cooker for ex distributing weight plate 18 1095080 Rev 05 EN ROSA ROSETTA D Nono LA NORDICA is not responsible in case of modification of th
61. e cucine ROSA e ROSETTA previsto come optional una griglia sollevabile tramite un apposita manovella La posizione superiore ottimizza l uso della piastra mentre quella inferiore ottimizza l uso del forno Sotto la porta forno si trova un vano scaldavivande con relativa porticina di chiusura non introdurre mai oggetti o materiali infiammabili Il riscaldamento dell ambiente avviene per irraggiamento attraverso il vetro panoramico e le superfici esterne calde della stufa viene irraggiato calore nell ambiente La cucina a legna fornita di registri aria primaria e secondaria con i quali viene regolata la combustione 2 1 REGISTRO ARIA PRIMARIA valvola girevole Con il registro inferiore Figura 1 pos A viene regolato il passaggio dell aria primaria nella parte bassa della cucina attraverso il cassetto cenere e la griglia in direzione del combustibile L aria primaria necessaria per il processo di combustione Il cassetto cenere deve essere svuotato regolarmente in modo che la cenere non possa ostacolare l entrata d aria primaria per la combustione Attraverso l aria primaria viene anche mantenuto vivo il fuoco Il registro dell aria primaria deve essere aperto appena un po durante la combustione di legna poich altrimenti la legna arde velocemente e la cucina si pu surriscaldare vedi paragrafo 10 2 2 REGISTRO ARIA SECONDARIA Sopra la porta del focolare
62. e product and for the use of not original spare parts NO MODIFICATIONS CAN BE CARRIED OUT TO THE APPLIANCE 4 FIRESAFETY In the installation of the cooker the following safety measures are to be followed a In order to ensure sufficient thermal insulation respect the minimum safety distance from objects or furnishing components flammable and sensitive to heat furniture wood sheathings fabrics etc and from materials with flammable structure see Picture 2 A All the minimum safety distances are shown on the product data plate and lower values must not be used b In front of the hearth in its radiation area there must not be any flammable object or construction material sensitive to the heat at least within 100 cm s This distance can be reduced to 40 cm s if you will install in front of the element to protect a retro ventilated and heat resistant protection c If the product is installed on a non totally refractory floor one must foresee a fireproof background The floors made of inflammable material such as moquette parquet or cork etc must be replaced by a layer of no inflammable material for instance ceramic stone glass or steel etc size according to regional filing The platform must stick out 50 cm s in front and 30 cm s sideways Picture 2 B d no flammable components e g wall units must be present above the product
63. ed for the flow of burning smokes around the oven are fundamental for a good cooking result The register of smokes must be pulled totally to the outside The oven pan may be located on different plans Thick cakes and big roasts must be introduced in the lowest level Flat cakes and biscuits must reach the medium level The upper level may be used to heat or grill The cooker can be endowed with a grate for the cast iron hearth which can be lifted through a suitable handle The same can be purchased as an optional The upper position optimises the use of the grate while the lower one optimises the use of the oven OPTION As an OPTIONAL it is available also a chromium plated grate for the oven 12 OPERATION IN TRANSITION PERIODS During transition periods when the external temperatures are higher if there is a sudden increase of temperature it can happen that the combustion gases inside the flue cannot be completely sucked up The exhaust gases do not come out completely intense smell of gas In this case shake the grating more frequently and increase the air for the combustion Then load a reduced quantity of fuel in order to permit a rapid burning growing up of the flames and the stabilization of the draught 24 1095080 Rev 05 EN ROSA ROSETTA E iN o f UA Then check that all openings for the cleaning and the connections to the stack are air tight 13 MAINTENANCE AND CARE Let the installation of your s
64. ed in such a way as to prevent the penetration of rain snow and any other foreign body in the flue e be easily checkable for any possible maintenance and cleaning operation TT 2 Handicraft chimney 3 Chimney cap for steel flue with conical NN deflector of smokes 1 Industrial chimney cap with pre fabricated elements it allows an excellent discharge of the smokes cap The right output section must be at least twice as big as the internal section of the flue ideal value 2 5 times Picture 4 EE EEN rr 20 1095080 Rev 05 EN ROSA ROSETTA E iN o f UA 1 In case of flues side by side a chimney cap must be higher than the other one of at least 50 cm in order to avoid pressure transfers between the flues themselves Picture 5 1 The chimney cap must not show hindrances within 10 m from walls pitches and trees Otherwise raise it of at least 1 m over the hindrance The chimney cap must exceed the ridge of the roof of at least I 7 Picture 6 1 Idee axis Picture 7 CHIMNEY CAPS DISTANCES AND POSITIONING UNI 10683 98 inclination of ihe root Distance pa ridge Minim
65. ef hrt werden der gleichzeitig eine Inspektion vornehmen kann Rauchgaskasten kann durch die T r unter dem Backfach nachdem die zwei Schrauben abgezogen worden sind ABB 8 und nach der Pr fung dass die Stellung der Umlenkplatten korrekt ist siehe ABB 9 oder von 130 150mm oben die Ringe und der Gussstutzen sind zu entfernen mit Hilfe einer ru B rste und eines Saugers gereinigt werden Nach der Reinigung sollen alle Teilen wieder hermetisch eingestellt werden 1095080 Rev 05 DE 35 NOGDICA ROSA ROSETTA 13 2 REINIGUNG DES SICHTFENSTERS Die Bildung von Schmutzablagerungen auf der Glasscheibe der T r wird durch einen speziellen Sekundarlufteinlass wirksam verz gert Bei der Verwendungen von festen Brennstoffen z B feuchtem Holz k nnen Ablagerungen nie ganz vermieden werden Dabei handelt es sich jedoch nicht um einen Fehler des Ofens WICHTIG Die Reinigung des Sichtfensters darf nur bei kaltem Ofen erfolgen um eine Explosion der Scheibe zu vermeiden Keine T cher und scheuernde oder chemisch aggressive Mittel verwenden Das richtige Anfeuern die Verwendung der geeigneten Art und Menge an Brennstoff die korrekte Einstellung des Sekundarluftreglers der ausreichende Kaminzug und das Vorhandensein von Verbrennungsluft sind f r eine optimale Funktionsweise des Ger ts un
66. er a shed The wet wood makes ignition more difficult because it is necessary a greater quantity of energy to evaporate the existing water The humid contents has the disadvantage that with the temperature lowering the water condensates first in the hearth and then in the chimney The unseasoned wood contains about 60 of H20 then it is not suitable to be burnt The following cannot be burnt rests of coal cut offs parts of barks and panels wet wood or treated with varnished plastic materials In this case the guarantee on the appliance lapses Paper and carton must be used only for ignition The combustion of wastes is forbidden This may damage the stove and the chimney causing health damages and claims by the neighbourhood owing to the bad smell 22 1095080 Rev 05 EN ROSA ROSETTA E Nono The wood is not a fuel which allows a continuous operation of the appliance as consequence the heating all over the night is not possible Variety Kg mc TO Beech 750 2 Oak 900 4 2 Elm 640 4 1 Poplar 470 51 Larch 660 44 Spruce 450 4 9 Scots pine 550 4 4 RESINOUS WOOD NOT SUITABLE FOR THE BURNING WARNING The continuous and protracted use of aromatic wood eucalyptus myrtle etc quickly damages the cast iron parts cleavage of the product 9 LIGHTING IMPORTANT The first time that the appliance is lit there will be an odour given off due to the drying of the adhes
67. er un produit de nettoyage ad quat pour liminer cet inconv nient IMPORTANT Utiliser exclusivement des pi ces de rechange express ment autoris es et offertes par la soci t La Nordica En cas de besoin nous vous prions de vous adresser votre revendeur sp cialis L APPAREIL NE PEUT PAS ETRE MODIFIE 13 1 NETTOYAGE DU CONDUIT D EVACUATION DE FUMEE La proc dure correcte d allumage l utilisation de la quantit et du type de combustibles ad quats le tirage suffisant de la chemin e et la pr sence d air comburant sont les conditions indispensables pour le fonctionnement optimal de l appareil Nous recommandons d effectuer un nettoyage complet au moins une fois par an ou chaque fois que n cessaire W probl mes de mauvais fonctionnement avec faible rendement TT Figure 8 46 1095080 Rev 05 FR ROSA ROSETTA e iN o f UA Cette op ration qui ne peut avoir lieu qu avec la cuisini re froide devrait tre effectu e par un ramoneur qui en m me temps peut faire une inspection Le compartiment de r colte de fum es peut tre nettoy travers la petite porte au dessous du four apr s avoir d viss les vis qui fixent la petite porte la faca
68. etallic surfaces Therefore it is extremely relevant to take these easy steps during the lighting 1 Make sure that a strong air change is assured in the room where the appliance is installed 2 During the first starts do not load excessively the combustion chamber about half the quantity indicated in the instructions manual and keep the product continuously ON for at least 6 10 hours with the registers less open than the value indicated in the instructions manual 3 Repeat this operation for at least 4 5 or more times according to your possibilities 4 Then load more and more fuel following in any case the provisions contained in the installation booklet concerning maximum load and if possible keep the lighting periods long avoiding at least in this initial phase short ON OFF cycles 5 During the first starts no object should be leaned on the appliance and in detail on enamelled surfaces Enamelled surfaces must not be touched during heating 6 Once the break in has been completed it is possible to use the product as the motor of a car avoiding abrupt heating with excessive loads To light the fire it is suggested to use small wood pieces together with paper or other traded lighting means It is forbidden to use any liquid substance as for ex alcohol gasoline oil and similar The openings for air primary and secondary must be opened together the smoke register is to be adjusted for the cooker function i e the comm
69. etto posizionamento del registro dell aria secondaria il sufficiente tiraggio del camino e la presenza dell aria comburente sono indispensabili per il funzionamento ottimale dell apparecchio e per mantenere pulito il vetro ROTTURA DEI VETRI i vetri essendo in vetroceramica resistenti fino ad uno sbalzo termico di 750 non sono soggetti a shock termici La loro rottura pu essere causata solo da shock meccanici urti o chiusura violenta della porta ecc Pertanto la sostituzione non in garanzia 130 150mm 13 3 PULIZIA CASSETTO CENERE FE e Tutte le stufe camino e cucine LA NORDICA hanno una griglia focolare con relativo scuoti griglia ed un cassetto cenere per la raccolta della ceneri Vi consigliamo di svuotare periodicamente il cassetto cenere e di evitarne il riempimento totale per non surriscaldare la griglia Inoltre Vi consigliamo di lasciare sempre 3 4 cm di cenere nel focolare Figura 9 ATTENZIONE le ceneri tolte dal focolare vanno riposte in un recipiente di materiale ignifugo dotato di un coperchio stagno Il recipiente va posto su di un pavimento ignifugo lontano da materiali infiammabili fino allo spegnimento e raffreddamento completo delle ceneri 13 4 LE MAIOLICHE Le maioliche LA NORDICA sono prodotti di alta fattura artigianale e come tali possono presentare micro puntinature cavillature ed imperfezio
70. fang aufgeh rt hat zu brennen ihn von einem Fachmann berpr fen lassen um eventuelle Risse oder durchl ssige Stellen auszumachen 5 SCHORNSTEINROHR Grundsatzliche Anforderungen f r den richtigen Betrieb der Ausr stung e Das Innenteil soll vorzugsweise rund sein e Das Schornsteinrohr muss thermisch isoliert wasserdicht und mit Materialen aufgebaut sein welche die Warme die Verbrennungsprodukte und etwaige Kondensaten bestehen e Es muss keine Querschnittreduzierung aufweisen und muss einen senkrechten Lauf mit Biegungen nicht hoher al 45 h aben e Wenn es schon angewandt worden ist muss es sauber sein e Die technischen Angaben des Gebrauchshandbuches beachten Sollten die Schornsteinrohre einen viereckigen oder rechteckigen Querschnitt aufweisen m ssen die Innenkanten mit einem Radius nicht kleiner als 20 mm abgerundet sein Was den rechteckigen Querschnitt betrifft muss das Verh ltnis zwischen den Seiten lt 1 5 Ein zu kleiner Querschnitt verursacht eine Verminderung des Zuges Eine Mindesth he von 4 m wird empfohlen Folgende Materialen sind verboten und gef hrden demzufolge den richtigen Betrieb der Ausr stung Asbestfaserstoff verzinkter Stahl innerliche rohe und porige Oberfl chen 3 gibt einige Losungsbeispiele an Der Mindestquerschnitt muss 4dm zum Beispiel 20x20cm f r die Ausr stungen mit Rohrquerschnitt kleiner als 200mm sein oder 6 25dm Zum Beispiel 25x25cm f r die Ausr stungen mit Rohr
71. he cleaning of the majolica we suggest you to use a soft and dry cloth if you use a detergent or liquid the latter might soak in and make the crackles more visible 14 SUMMER STOP After cleaning the hearth chimney and hood totally eliminating the ash and other eventual residues close all the doors of the hearth and the related registers and disconnect the equipment from the chimney We suggest to perform the cleaning operation of the flue at least once per year verify in the meantime the actual status of the gaskets which cannot ensure the good operation of the equipment if they are not perfectly solid In this case the gaskets must be replaced In presence of dampness in the room where the stove has been placed we advise you to put absorbent salts into the hearth If you want to keep for long the aesthetic look of the cooker it is important to protect its parts in row cast iron with neutral Vaseline 15 CONNECTING A CHIMNEY OR OPEN FURNACE TO THE FLUE The smoke channel is the section of tube that connects the product to the flue in the connection these simple but very important principles must be followed e for no reason must the smoke channel be used with a diameter lower than that of the neck of the outlet with which the product is fitted e each metre of horizontal route of the smoke channel causes a small leak of charge which should be compensated for by raising the flue e the horizontal section must never be higher than 2
72. hot surfaces of the stove the heat is radiated into the environment 2 1 PRIMARY AIR CONTROL movable valve With the primary air control movable valve which is found below the hearth door it is adjusted the passage of air through the ash drawer and the grate in the fuel direction Picture 1 pos A The primary air is necessary for the combustion process The ash drawer must be regularly emptied so that the ash does not obstruct the primary air entry Through the primary air the fire is also kept alive During wood combustion the register of primary air must be opened only for a while because otherwise the wood burns fast and the stove may overheat see chapter 10 2 2 SECONDARY AIR CONTROL On the over part Picture 1 pos B of the door there is the secondary air control Also this register must be opened then moved to the right especially for wood combustion see chapter 10 2 3 SMOKES CONTROL pull push lever Picture 1 Conversion of the cooker function to the cooker bake oven and heating function Picture 1 pos C The smokes control in the style of a brass knob can be found on the top right corner of the front side of the cooker between the protection bar and the oven door This control has two settings HOB COOKING when the bar is pushed to the back of th
73. idi della combustione ceneri devono essere raccolti in un contenitore ermetico e resistente al fuoco La cucina non deve mai essere accesa in presenza di emissioni gassose o vapori per esempio colla per linoleum benzina ecc Non depositate materiali infiammabili nelle vicinanze della cucina Durante la combustione viene sprigionata energia termica che comporta un marcato riscaldamento delle superfici di porte maniglie comandi vetri tubo fumi ed eventualmente della parte anteriore dell apparecchio Evitate il contatto con tali elementi senza un corrispondente abbigliamento protettivo o senza utensili accessori guanti resistenti al calore dispositivi di comando Fate in modo che i bambini siano consapevoli di questi pericoli e teneteli lontani dal focolare durante il suo funzionamento Quando si utilizza un combustibile errato o troppo umido a causa di depositi presenti nella canna fumaria si potrebbe avere un incendio della stessa 8 1095080 Rev 05 IT ROSA ROSETTA E Nono 4 1 PRONTO INTERVENTO Se si manifesta un incendio nel collegamento o nella canna fumaria a Chiudere la porta di caricamento b Chiudere i registri dell aria comburente c Spegnere tramite l uso di estintori ad anidride carbonica CO2 a polveri d Richiedere l immediato intervento dei Vigili del Fuoco Non spegnere il fuoco con l uso di getti d acqua Quando la canna fumaria smette di bruciare farla verificare da uno specialista per indi
74. ives of the junction chord which disappears after a short use lt must be ensured in any case a good ventilation of the environment Upon the first ignition we suggest loading a reduced quantity of fuel and slightly increasing the calorific value of the equipment To perform a correct first lighting of the products treated with paints for high temperature it is necessary to know the following information e the construction materials of the involved products are not homogeneous as matter of fact there are simultaneously parts in cast iron steel refractory material and majolica e the temperature to which the body of the product is subject is not homogeneous from area to area variable temperatures within the range of 300 500 are detected e during its life the product is subject to alternated lighting and extinguishing cycles in the same day as well as to cycles of intense use or of absolute standstill when season changes e the new appliance before being considered seasoned has to be subject to many start cycles to allow all materials and paints to complete the various elastic stresses e in detail initially it is possible to remark the emission of smells typical of metals subject to great thermal stress as well as of wet paint This paint although during the manufacture it is backed at 250 for some hours must exceed many times and for a given period of time the temperature of 350 before becoming completely embedded in the m
75. lation We declare that in all products we produce the materials which will get in touch with food are suitable for alimentary use according to the a m CE regulation KONFORMITATSERKLARUNG DES HERSTELLERS Betreff Fehlen von Asbest und Kadmium Wir bestatigen dass die verwendeten Materialen oder Teilen f r die Herstellung der La Nordica Ger te ohne Asbest und Derivat sind und auch das Lot f r das SchweiBen immer ohne Kadmium ist Betreff Ordnung CE n 1935 2004 Wir erklaren in alleiniger Verantwortung dass die Materialien der Teile die f r den Kontakt mit Lebensmitteln vorgesehen sind f r die Nahrungsbenutzung geeignet sind und der Richtlinien CE n 1935 2004 erf llen D CLARATION DE CONFORMIT DU FABRICANT Objet absence d amiante et de cadmium Nous d clarons que tous nos produits sont assembl s avec des mat riaux qui ne pr sentent pas de parties en amiante ou ses d riv s et que le mat riel d apport utilis pour les soudures ne pr sente utilise pas de cadmium sous aucune forme comme pr vu par la norme de r f rence Objet R glement CE n 1935 2004 Nous d clarons que dans tous nos appareils les mat riaux destin s a entrer en contact avec les aliments sont aptes a l usage alimentaire conform ment au R glement CE en question 1095080 Rev 05 IT EN DE FR 3 NONDICA ROSA ROSETTA INDICE IT Te e E 61 EE 6 2 DESGRIZIONE
76. llo posto sotto il forno dopo aver tolto le due viti che fissano lo stesso alla facciata della cucina Figura 8 controllate che la posizione del deflettore fumi corrisponda con quanto riportato in Figura 9 oppure dall alto 14 1095080 Rev 05 IT ROSA ROSETTA e iN o f A A tale scopo rimuovete i cerchi della piastra di cottura e smontate il tubo fumi dal tronchetto di scarico La pulizia pu essere effettuata con l aiuto di una spazzola e di un aspiratore Fate attenzione che dopo la pulizia tutte le parti smontate vengano reinstallate in modo ermetico 13 2 PULIZIA VETRO Tramite uno specifico ingresso dell aria secondaria la formazione di deposito di sporco sul vetro della porta viene efficacemente rallentata Non pu comunque mai essere evitata con l utilizzo dei combustibili solidi es legna umida e questo non da considerarsi come un difetto dell apparecchio IMPORTANTE la pulizia del vetro panoramico deve essere eseguita I solo ed esclusivamente a cucina fredda per evitarne l esplosione Non usare comunque panni prodotti abrasivi Figura 8 o chimicamente aggressivi La corretta procedura di accensione l utilizzo di quantit e tipi di combustibili idonei il corr
77. lume de chauffage diminue de 25 environ 38 1095080 Rev 05 FR ROSA ROSETTA E Nono 2 DESCRIPTION TECHNIQUE Les cuisini res bois La Nordica permettent de cuisiner sur la plaque et de chauffer des espaces de logement durant certaines p riodes ou de compl ter un chauffage centralis insuffisant Elles conviennent parfaitement aux appartements de vacances ou de week end ou bien comme chauffage d appoint pendant toute l ann e Comme combustible elles utilisent des b ches de bois La cuisini re se compose de plaques en t le d acier maill e et zingu e et de pi ces en fonte maill e portes face avant et ch ssis plaque Le foyer est quip d une porte panoramique avec vitre c ramique r sistante jusqu 700 qui permet une vue agr able des du feu et qui prot ge par la fuite des fum es et des tincelles Le foyer est rev tu l int rieur de plaques individuelles en fonte et son int rieur comprend une grille plate Pour les cuisinieres ROSA et ROSETTA il y a comme OPTION une grille foyer qui s l ve en hauteur avec une manivelle sp cifique La position sup rieure de telle grille OPTION permet d optimiser l utilisation de la plaque de cuisson alors que le position inferieure est plus adapte l utilisation du four En dessous de la porte du four se trouve un bac chauffe plats avec sa porte de fermeture jamais y mettre aucun objet ou mat riaux inflammables Le chauffage du milieu ambiant se
78. mbustione la temperatura del forno pu essere sensibilmente influenzata Un sufficiente tiraggio al camino e dei canali ben puliti per il flusso dei fumi roventi attorno al forno sono fondamentali per un buon risultato di cottura Il registro dei fumi deve essere tirato completamente verso l esterno La padella forno pu essere collocata su diversi piani Torte spesse e arrosti grandi sono da inserire al livello pi basso Torte piatte e biscotti vanno al livello medio Il livello superiore pu essere utilizzato per riscaldare o rosolare La cucina pu essere dotata di una griglia per il focolare in ghisa sollevabile tramite un apposita manovella La posizione superiore ottimizza l uso della piastra mentre quella inferiore ottimizza l uso del forno La presente pu essere acquistata come OPTIONAL Come OPTIONAL disponibile anche una griglia per il FORNO 12 FUNZIONAMENTO NEI PERIODI DI TRANSIZIONE Durante il periodo di transizione quando le temperature esterne sono pi elevate si possono avere dei disturbi alla canna fumaria che fanno si che i gas combusti non vengano aspirati completamente gas di scarico non fuoriescono pi completamente odore intenso di gas In tal caso scuotete pi frequentemente la griglia e aumentate l aria per la combustione Caricate in seguito una quantit ridotta di combustibile facendo s che questo bruci pi rapidamente con sviluppo di fiamme e si stabilizzi cos il tiraggio della canna fumaria
79. mincia ad ardere si possono caricare altri combustibili e regolare l aria per la combustione secondo le indicazioni del paragrafo 10 Durante questa fase non lasciare mai la cucina senza supervisione Non si deve mai sovraccaricare la cucina Troppo combustibile e troppa aria per la combustione possono causare surriscaldamento e quindi danneggiare la cucina La garanzia non copre i danni dovuti al surriscaldamento dell apparecchio 10 FUNZIONAMENTO NORMALE Gli apparecchi con chiusura automatica della porta tipo 1 devono obbligatoriamente funzionare per motivi di sicurezza con la porta del focolare chiusa fatta eccezione per la fase di carico del combustibile o l eventuale rimozione della cenere Gli apparecchi con le porte non a chiusura automatica tipo 2 devono essere collegati ad una propria canna fumaria Il funzionamento con porta aperta consentito soltanto previa sorveglianza IMPORTANTE Per motivi di sicurezza la porta del focolare pu essere aperta solo durante il caricamento di combustibile Il focolare deve rimanere chiuso durante il funzionamento ed i periodi di non utilizzo Bisogna pertanto usare la cucina sempre con porta chiusa per evitare l effetto forgia Non si deve mai sovraccaricare la cucina Troppo combustibile e troppa aria per la combustione possono causare surriscaldamento e quindi danneggiare la cucina danni causati da surriscaldamento non sono coperti da garanzia Con i registri posti sulla fa
80. nctionner pour des motifs de s curit quand la porte du foyer est ferm e l exception de la phase de chargement du combustible ou de l enl vement ventuel des cendres Les appareils dot s de portes sans fermeture automatique type 2 doivent tre raccord s leur propre conduit d vacuation de la fum e Le fonctionnement avec la porte ouverte est permis seulement sous surveillance IMPORTANT Pour des raisons de s curit la porte du foyer ne peut tre ouverte que pendant le chargement de combustible Le foyer doit rester ferm pendant le fonctionnement et pendant les p riodes de repos Il faut donc toujours utiliser le po le avec la porte ferm e abaiss e pour viter l effet forge Jamais surcharger la cuisini re Trop combustible et trop sari pour la combustion peuvent causer une surchauffe et par cons quence endommager la cuisini re Les dommages caus s par surchauffe ne sont pas couverts par garantie Grace aux r gulateurs qui se trouvent sur la facade de la cuisini re on r gle l mission de la chaleur du foyer Ils doivent rester ouverts selon la demande calorifique Figure 1 On obtient la meilleure combustion missions min quand en chargeant le bois la plus grande partie de l air de combustion passe travers le registre air secondaire La r gulation des registres n cessaire pour obtenir le rendement calorifique nominale avec une d pression du conduit de fum e de 10 12 Pa 21 0 1 2 mm de colo
81. ndroit sec et ventil par exemple sous une toiture Le bois humide rend l allumage plus difficile car pour faire vaporer l eau pr sente dans le bois il faut une quantit suppl mentaire d nergie Le contenu d humidit est un d savantage puisque lorsque la temp rature s abaisse l eau se condense d abord dans le foyer puis dans la chemin e Le bois frais contient environ 60 d H2O par cons quent il n est pas apte a tre br l Les produits suivants ne peuvent pas tre br l s restes de charbon rognures d chets d corce et de panneaux bois humide ou verni mat riels plastiques dans le cas contraire la garantie de l appareil d choit Le papier et le carton doivent tre utilis s uniquement durant l allumage La combustion des d chets est interdite puisqu elle peut endommager le po le ainsi que le conduit de chemin e provoquer des dommages a la sant eta cause de son odeur peut entrainer des probl mes avec le voisinage Le bois n est pas un combustible a longue dur e et par cons quent il ne permet pas de chauffer continuellement pendant toute la nuit Type EHE Hand duos H tre 750 4 0 Ch ne 900 4 2 Orme 640 4 1 Peuplier 470 4 1 M leze 660 4 4 Sapin rouge 450 4 5 Pin Silvestre 550 4 4 e BOIS RESINEUX PEU ADAPTES POUR UN POELE ATTENTION l utilisation continue et prolong e d un bois particuli rement riche en huiles aromatis es telles que Eucalyptus Myrte e
82. nel collegamento devono essere rispettati questi semplici ma importantissimi principi e per nessuna ragione si dovr usare il canale fumo avente un diametro inferiore a quello del collarino di uscita di cui dotato il C tamponamento prodotto e ogni metro di percorso orizzontale del canale fumo provoca una sensibile perdita di carico che dovr eventualmente essere compensata con un innalzamento della canna fumaria e il tratto orizzontale non dovr comunque mai superare i 2m UNI 10683 2005 e ogni curva del canale fumi riduce sensibilmente il tiraggio della canna fumaria che dovr essere eventualmente compensata innalzandola adeguatamente e la Normativa UNI 10683 2005 ITALIA prevede che le curve o variazioni di direzione non devono in nessun caso essere superiori a 2 compresa l immissione in canna fumaria A Chiusura ermetica Volendo usare la canna fumaria di un caminetto o focolare aperto sar necessario chiudere ermeticamente la cappa al di sotto del punto di imbocco del canale fumo pos A Figura 10 Se poi la canna fumaria troppo grande p e cm 30x40 oppure 40x50 necessario intubarla con un tubo di acciaio inox di almeno 200mm di diametro pos B avendo cura di chiudere bene lo spazio rimanente fra Sportello di il tubo stesso e la canna fumaria immediatamente sotto al comignolo ispezione pos C Per qualsiasi ulteriore chiarimento
83. ni cromatiche Queste caratteristiche ne testimoniano la pregiata natura Smalto e maiolica per il loro diverso coefficiente di dilatazione producono microscrepolature cavillatura che ne dimostrano l effettiva autenticit Per la pulizia delle maioliche si consiglia di usare un panno morbido ed asciutto se si usa un qualsiasi detergente o liquido quest ultimo potrebbe penetrare all interno dei cavilli evidenziando gli stessi 14 FERMO ESTIVO Dopo aver effettuato la pulizia del focolare del camino e della canna fumaria provvedendo all eliminazione totale della cenere ed altri eventuali residui chiudere tutte le porte del focolare ed i relativi registri e sconnettere l apparecchi dal camino Consigliamo di effettuare l operazione di pulizia della canna fumaria almeno una volta all anno verificare nel frattempo l effettivo stato delle guarnizioni che se non perfettamente integre non garantiscono il buon funzionamento dell apparecchio In tal caso necessaria la sostituzione delle stesse In caso di umidit del locale dove posto l apparecchio sistemare dei sali assorbenti all interno del focolare Proteggere le parti in ghisa se si vuole mantenere inalterato nel tempo l aspetto estetico con della vaselina neutra 1095080 Rev 05 IT 15 NOGDICA ROSA ROSETTA 15 COLLEGAMENTO ALLA CANNA FUMARIA DI UN CAMINETTO O FOCOLARE APERTO Il canale fumi il tratto di tubo che collega il prodotto alla canna fumaria
84. nne d eau est la suivante 1095080 Rev 05 FR 45 NONDIC ROSA ROSETTA AIR PRIMAIRE AIR SECONDAIRE ROSETTA 1 6 OUVERT OUVERT L intensit de la combustion et par cons quent le rendement calorifique de votre cuisini re sont influenc s non seulement par le r glage de l air de combustion mais aussi par votre chemin e IMPORTANT Pour s assurer de la bonne combustion de votre po le v rifier que la fum e qui sort de la chemin e est bien transparente Lorsqu elle est blanche cela signifie que le po le n est pas bien r gl ou que le bois est trop humide si au contraire la fum e est grise ou noire cela veut dire que la combustion n est pas totale 11 UTILISATION DU FOUR Apr s avoir nettoy la grille chargez le combustible L apport d air pour la combustion peut influencer sensiblement la temp rature du four Un tirage suffisant de la chemin e et des conduits bien propres permettant le flux des fum es chaudes autour du four sont des conditions fondamentales pour un bon r sultat de cuisson La plaque du four peut tre situ e diff rents niveaux Les g teaux pais et les grands r tis doivent tre enfourn s au niveau le plus bas les g teaux plats et les biscuits au niveau moyen Le niveau sup rieur peut tre utilis pour r chauffer ou rissoler La cuisini re peut tre quip e avec une grille OPTIONNELLE pour le foyer en fonte qu on peut soulever gr ce une manivelle sp
85. nt isol e et imperm able et construite avec des mat riaux r sistants a la chaleur aux produits de la combustion et aux ventuelles condensations e tre exempt d tranglements et avoir un parcours vertical comportant des d viations qui ne d passent pas 45 e d ja utilis au pr alable il doit tre nettoy e respecter les donn es techniques du manuel d instructions Si le conduit de chemin e tait section carr e ou rectangulaire les angles internes doivent tre arrondis avec un rayon non inf rieur 20 mm Pour la section rectangulaire le rapport maximum entre les c t s doit tre lt 1 5 Une section trop petite provoque une diminution du tirage Nous conseillons une hauteur de 4m Sont interdits et pour cette raison portent pr judice au bon fonctionnement de l appareil fibrociment acier galvanis surfaces internes rugueuses et poreuses Dans la Figure 3 certains exemples de solution sont mentionn s La section minimale soit tre de 4 dm2 par exemple 20 x 20 cm pour les appareils dont le diam tre de conduit est inf rieur 200 mm ou 6 25 dm2 par exemple 25 x 25 cm pour les appareils avec un diam tre sup rieur 200 mm Le tirage cr par votre conduit de chemin e doit tre suffisant mais non pas excessif Une section du conduit de chemin e trop importante peut pr senter un volume trop important r chauffer et par cons quent peut provoquer des difficult s de fonctionnement de l appareil
86. nt ou produit liquide quelconque pourrait p n trer l int rieur des craquelures et les mettre en vidence 14 SOMMERPAUSE Apr s avoir nettoy le foyer la chemin e et le tuyau d vacuation de la fum e et avoir retir toutes les cendres et autres r sidus ventuels il faut fermer toutes les portes du foyer et les r gulateurs correspondants et d connecter l appareil de la chemin e Nous conseillons d effectuer le nettoyage du tuyau d vacuation de la fum e au moins une fois par an tout en v rifiant entre temps le bon tat des joints d tanch it qui s ils n taient plus en parfait tat ne garantiraient pas le bon fonctionnement de l appareil Il serait donc n cessaire de les remplacer En cas d humidit du local o est situ l appareil placer des sels absorbants l int rieur du foyer de celuici Prot ger les pi ces en fonte brute avec de la vaseline neutre pour maintenir intact dans le temps leur aspect esth tique 1095080 Rev 05 FR 47 NOGDICA ROSA ROSETTA 15 RACCORDEMENT AU CONDUIT DE FUMEE D UNE CHEMINEE OU D UN FOYER OUVERT Le canal des fum es est le trongon du tuyau qui relie l appareil au tuyau d vacuation des fum es il faut respecter ces simples principes tr s importants au cours de son raccordement e sous aucun pr texte on devra utiliser le conduit d vacuation de la fum e s il a un diam tre inf rieur a celui du collier de sortie dont est dot l appareil e
87. o d aria fresca influenzare negativamente le funzioni della Vostra cucina La depressione di una cappa aspirante pu nella peggiore delle ipotesi trasformare la canna fumaria della stufa in presa d aria esterna risucchiando i fumi nell ambiente con conseguenze gravissime per le persone 8 COMBUSTIBILI AMMESSI NON AMMESSI I combustibili ammessi sono ceppi di legna Si devono utilizzare esclusivamente ceppi di legna secca contenuto d acqua max 20 Si possono caricare al massimo 2 o 3 ceppi di legna per volta pezzi di legna dovrebbero avere una lunghezza di ca 30cm ed una circonferenza di 30 35 cm max La legna usata come combustibile deve avere un contenuto d umidit inferiore al 20 e la si ottiene con un tempo di essiccazione di almeno un anno legno tenero o di due anni legno duro in ambiente asciutto e ventilato per esempio sotto una tettoia La legna umida rende l accensione pi difficile poich necessaria una maggiore quantit d energia per far evaporare l acqua presente Il contenuto umido ha inoltre lo svantaggio che con l abbassarsi della temperatura l acqua si condensa prima nel focolare e quindi nel camino La legna fresca contiene circa il 60 di H2O perci non adatta ad essere bruciata Tra gli altri non possono essere bruciati resti di carbone ritagli cascami di corteccia e pannelli legna umida o trattata con vernici materiali di plastica in tal caso decade la garanzia sull apparecchio
88. operation of the equipment it is essential that in the installation place it is introduced sufficient air for combustion see chapt 7 The depression on the chimney should be 10 12 Pa 1 0 1 2 mm of water column The measurement must be done always with the equipment hot rating calorific value When the depression exceeds 17 PA 1 7mm of water column it is necessary to reduce the same with the installation of an additional flue adjuster butterfly valve on the exhaust pipe or in the chimney 7 AIR ENTRANCE INTO THE INSTALLATION PLACE DURING COMBUSTION As the cookers take their combustion air from the installation place it is essential that a sufficient quantity of air is introduced in the installation room itself In case of tight doors and windows for example houses built according to the energy saving criteria it is possible that the air entrance is not guaranteed compromising the draught the welfare and the security of the people It is necessary to guarantee a further air entrance through an external air intake to be positioned in the nearby of the appliance or through air connection towards outside or a near ventilated room with the exception of thermal units place or garages FORBIDDEN The connection pipe must be flat with a minimum diameter of 120 mm a maximum length of 4 m and with no more than 3 bends If there is a direct connection with the outside it must be endowed with a special windbreak The air entrance for com
89. orrisponde ai requisiti del Regolamento sugli isolamenti termici ROSA ROSETTA 30 Kcal h x m tipo di costruzione favorevole 185 m3 172 m 40 Kcal h x m tipo di costruzione meno favorevole 138 m 129 m 50 Kcal h x m tipo di costruzione sfavorevole 111 m 103 m Con un isolamento termico adeguato alle disposizioni sulla protezione del calore il volume di riscaldamento maggiore Con un riscaldamento temporaneo in caso di interruzioni superiori a 8h la capacit di riscaldamento diminuisce del 25 circa 6 1095080 Rev 05 IT ROSA ROSETTA E Nono 2 DESCRIZIONE TECNICA Le cucine a legna La Nordica si addicono a cucinare sulla piastra e al forno e a riscaldare spazi abitativi per alcuni periodi o a sostenere un riscaldamento centralizzato insufficiente Esse sono ideali per appartamenti di vacanza e case del fine settimana oppure come riscaldamento ausiliario durante tutto l anno Come combustibili vengono utilizzati ceppi di legna La cucina a fuoco continuo costituita di lastre in lamiera d acciaio zincata ghisa smaltata e ceramica termo radiante Il focolare dotato di una porta panoramica con vetro ceramico resistente fino a 700 Questo cons ente un affascinante vista sulle fiamme ardenti Inoltre viene cos impedita ogni possibile fuoriuscita di scintille e fumo Il focolare internamente rivestito di singole lastre in ghisa AI suo interno si trova una griglia piana Per l
90. ortes sans fermeture automatique type 2 doivent tre raccord s a leur propre conduit d vacuation de la fum e Le fonctionnement avec la porte ouverte est permis seulement sous surveillance Le tube de raccordement au conduit de la chemin e doit tre le plus court possible rectiligne herm tique et conforme aux normes en vigueur Le raccordement doit tre effectu avec des tubes stables et robustes nous conseillons une paisseur de 2 mm et d tre fix herm tiquement au conduit de la chemin e Le diam tre interne du tube de raccordement doit correspondre au diam tre externe du manchon d vacuation de la fum e du po le DIN 1298 ATTENTION Si le raccordement devait transiter au travers d l ments compos s de mat riels inflammables dans un rayon de 20 cm tout autour du tube tous les mat riels inflammables doivent tre substitu s par des mat riels ignifug s et r sistants la chaleur Pour un bon fonctionnement de l appareil il est essentiel que dans le lieu de l installation suffisamment d air s introduise pour la combustion voir paragraphe 7 La d pression la chemin e TIRAGE doit tre au moins de 10 12 Pa 1 0 1 2 mm de colonne d eau La mesure doit tre toujours effectu e avec l appareil chaud rendement calorifique nominal Lorsque la d pression d passe 17 Pa 1 7 mm de colonne d eau il faut r duire celle ci en installant un r gulateur de tirage suppl mentaire vanne papillon sur le
91. ostruttore e o rappresentante autorizzato della societ all interno della CEE si dichiara sotto la propria responsabilit che gli apparecchi sono conformi alle esigenze essenziali previste dalle Direttive su menzionate As the manufacturer s authorised representative established within EEC we declare under out sole responsibility that the equipment follows the provisions of the Directives stated above Als vom Hersteller bevollm chtigter und in der EEC etablierter Vertreter erkl ren wir dass wir die vglle Verantwortung daf r bernehmen dass die Ger te den Vorschriften entsprechen die in den oben angegebenen Direl amp fen dargelegt werden vedi allegato see enclosure siehe Beilage 12 06 2006 Montecchio Precalcino VI data e luogo di emissione place and date of issue nome posizione e firma name function and segnature Ort und Datum der Ausstellung Positionsbezeichnung 1095080 Rev 05 IT EN DE FR 53 NOTAI ROSA ROSETTA INFORMAZIONI MARCATURA C E MARKING INFORMATION AUSZEICHNUNGSINFORMATIONEN CE LA NORDICA S p A 06 EN 12815 ROSETTA Distanza minima da materiali infiammabili Laterale lateral seiten 35 cm Distance to adjacent combustible materials I Mindestabstand zu brennbaren Materialen Posteriore rear hinten 35 cm Emissione di CO 13 96 02 Emission of CO 13 Oz 0 12 1500 mg m CO Ausstoss bez auf 13 O2 Emissioni polveri 13 O
92. pour viter cela il faut garnir de tubes celui ci le long de toute sa hauteur Une section trop petite provoque une diminution du tirage Le conduit de chemin e doit tre une certaine distance des PEEN U D DI sen 1 Tuyau d vacuation des fum es en acier AISI 316 avec double chambre isol e avec du mat riel r sistant a 400 Efficacit 10096 optimale 2 Tuyau d vacuation des fum es en mat riel r fractaire avec double chambre isol e et rev tement ext rieur en b ton all g Efficacit 100 optimale 3 Tuyau d vacuation de fum es traditionnel en argile section carr e avec cloisons de doublage Efficacit 80 optimale 4 Eviter des tuyaux d vacuation des fum es d une section rectangulaire interne dont le rapport soit diff rent de celui indiqu sur le dessin Efficacit 40 m diocre Figure 3 mat riaux inflammables ou combustibles au moyen d une isolation appropri e ou d un matelas d air Il est interdit de faire transiter l int rieur du m me tube des installations ou des canaux d amen e d air Il est interdit en outre de pratiquer des ouvertures mobiles ou fixes sur celui ci pour y raccorder d autres appareils 5 1 POSITION DU TERMINAL DE LA CHEMINEE Le tirage
93. querschnitt gro er als 200mm betragen Der von Ihrem Schornsteinrohr erzeugte Zug muss ausreichend aber nicht bertrieben sein Ein Schornsteinrohr mit einem zu weiten Querschnitt kann ein Volumen aufweisen das zu gro zu heizen ist und das demzufolge Betriebsst rungen bei der Ausr stung verursachen kann Um das zu vermeiden ist das Schornsteinrohr seine ganze H he lang in einem anderen Rohr einzuf hren Ein zu kleiner Querschnitt verursacht eine Zugverminderung Der Schornsteinrohr muss von entz ndlichen und w rmeempfindlichen Materialen durch eine passende Isolierung oder ein Luftzwischenraum entfernt sein Es ist verboten innerhalb des Schornsteinrohrs Anlagerohre oder Luftanleitungen durchgehen zu lassen Keine Offnung 1 Max A 1 2A luni LA Schornsteinrohr aus Stahl AISI 316 mit doppelter mit 400 bestandigem Material verkleideter Kammer Wirkungsgrad 100 ausgezeichnet Schornsteinrohr aus feuerfestem Material mit doppelter isolierter Kammer und AuBenverkleidung aus Halbdichtbeton Wirkungsgrad 100 Yo ausgezeichnet 3 Traditionelles Schornsteinrohr aus Ton viereckiger Querschnitt mit Spalten Wirkungsgrad 80 ausgezeichnet 4 Schornsteinrohre mit rechteckigem weder beweglich noch fest f
94. r den Anschluss anderer Gerate durchf hren 5 1 SCHORNSTEIN Innenquerschnitt sind zu vermeiden dessen Verhaltnis von der Zeichnung abweicht Wirkungsgrad 40 ABB 3 Der Zug des Schornsteinrohres hangt von der Tauglichkeit des Schornsteines an Wenn der Schornstein handwerklich gebaut ist muss der Ausgangsquerschnitt zwangsmaBig zwei Male gr Ber als der Innenquerschnitt des Schornsteinrohrs sein Da er den Firsttr ger immer berschreiten muss muss der Schornstein das Abblasen auch dann sichern wenn es Wind gibt ABB 4 Der Schornstein muss mit folgenden Anforderungen bereinstimmen e Er muss einen zum Kaminquerschnitt aquivalenten Innenquerschnitt haben 30 1095080 Rev 05 DE ROSA ROSETTA iN o f UA e Er muss einen anwendbaren Ausgangsquerschnitt haben der doppelt so gro wie der Innenquerschnitt des Schornsteinrohrs ist e Er muss derart aufgebaut sein dass Regen Schnee und allerlei Fremdk rper ins Schornsteinrohr nicht durchdringen k nnen e Er muss einfach zu pr fen sein im Rahmen von etwaigen Wartungs und Reinigungsvorgangen 1 Industrialschornstein mit 2 Handwerklicher 3 Schornstein f r Fertigteilelemente er Schornstein Der richtige r Schornsteinrohr aus gestattet eine Ausgangsquerschnitt muss Stahl mit einer ausgezeichnete mindestens 2 Male des Kegelf rmigen Abgasentsorgung Innenquerschnittes des Rauchumlenkplatte Schornsteinrohrs betragen ideal w
95. re 2 5 Male ESSES Im Falle von naheliegenden Schornsteinrohren muss ein Schornstein den anderen um mindestens 50cm berragen um Druck bertragungen unter den Schornsteinrohren selbst zu vermeiden 1 Der Schornstein muss keine Hindernisse innerhalb 10m von Mauern Schichten und B umen Anderenfalls der Schornstein mindestens 1m ber das Hindernis stellen mi Wi II I i Der Schornstein muss den Firsttr ger um mindestens 1m berschreiten En ABB 6 1 Firsttragerachse 2 Dach 1 JAsse colmo 1095080 Rev O5 DE 31 ONeill ROSA ROSETTA SCHORNSTEINE ABSTANDE UND STELLUNG UNI 10683 98 Dachneigung Abstand i tour und EE alt eer vom a A m H m lt 1 85m 0 50 m vom First gt 1 85 m 1 00 m vom Dach T lt 1 50 m 0 50 m vom First gt 1 50 m 1 30 m vom Dach m 1 30 m 0 50 m vom First gt 1 90 m 2 00 m vom Dach wi lt 1 20m 0 50 m vom First gt 1 20 m 2 60 m vom Dach 6 KAMINANSCHLUSS Bei Herden mit selbstschlieBenden Feuerraumt ren Typ 1 ist ein Anschluss an einen bereits mit anderen fen oder Feuerstatten belegten Schornstein m glich sofern die Rauchfangbemess
96. rke La NORDICA Modello o tipo Model or type Modell ROSETTA Uso Use Riscaldamento e cottura uso domestico Space heating and cooking in buildings Verwendungszweck Erw rmung von Wohnr ume und Kochen La NORDICA S p A Costruttore Manufacturer Herstelle Via Summano 104 36030 Montecchio Precalcino VICENZA 0445 804000 Fax 0445 804040 NB 1881 Ente notificato Notified body Benanntes Labor IMQprimacontrol S R L 31020 Zoppe San Vendemiano TV Via dell Industria 55 Le norme armonizzate o le specifiche tecniche designazioni che sono state applicate in accordo con le regole della buona arte in materia di sicurezza in vigore nella CEE sono The following harmonised standards or technical specifications designations which comply with good engineering practice in safety matters in force within the EEC have been applied Die folgenden abgeglichenen Standards bzw technischen Einzelheiten Bestimmungen angewandt im Einklang mit den Normen in Sicherheitsangelegenheiten die in der CEE in Kraft sind wurden angewandt Norme o altri riferimenti normative Rapporto di Prova ITT Standards or other normative documents Initial Type Tests Report Standards oder andere normensetzende Dokumente Pr fbericht EN 12815 CS 06 108 Condizioni particolari Particular conditions Besondere Bedingungen Informazioni marcatura CE CE Marking information Auszeichnungsinformationen In qualit di c
97. sdruck Temperatura gas di scarico Flue gas temperature 239 C Abgastemperatur Potenza termica nominale Thermal output 6 5 kW Nennheizleistung Rendimento Energy efficiency Wirkungsgrad 78 9 Tipi di combustibile Fuel types Brennstoffarten LEGNA WOOD HOLZ VKF Nr Z 13083 SINTEF Nr 045 159 15a B VG Nr RRF 15 06 1217 52 1095080 Rev 05 IT EN DE FR ROSA ROSETTA E iN o f UA DECLARATION OF DICHIARAZIONE a DI CONFORMIT KONFORMIT TSERKL RUNG In accordo con la Direttiva 89 106 CEE Prodotti da Costruzione il Regolamento CE n 1935 2004 Materiali e Oggetti destinati a venire a contatto con prodotti alimentari According to the Directive 89 106 EEC Construction Products the CE Regulation No 1935 2004 Materials and Articles intended to come into contact with foodstuffs Im Einklang mit der Direktive 89 106 EEC Bauprodukte und der CE Vorschrift Nr 1935 2004 Materialien und Gegenstande die f r den Kontakt mit Lebensmitteln vorgesehen sind N di identificazione Identification No Identifikationsnummer 050 La NORDICA S p A Emesso da Issued by Ausgestellt von Via Summano 104 36030 Montecchio Precalcino VICENZA 39 0445 804000 Fax 39 0445 804040 Cucine a combustibile solido Tipo di apparecchio Type of equipment Ger tetyp Fire coocker by solid fuel Herde f r Festbrennstoffe Marchio commerciale Trademark Handelsma
98. selon EN 12815 L 7 LO ROSA ROSETTA Type 2 2 Puissance nominale en kW 6 5 6 Rendement en 78 9 74 Diam tre tuyau en mm 150 130 Consommation horaire de bois en kg h bois avec 2096 d humidit 1 9 2 Emission gaz de d charge en g s bois 8 7 9 56 Temp rature gaz de d charge en bois 239 255 Emission de CO au 1396 Oxig 0 11 0 12 D pression rendement calorifique nominal en mmH O bois 1 0 1 2 Dimensions ouverture foyer en mm L x P 223x265 209x265 Dimensions corps du foyer plan foyer en mm L x H x P 270x340x400 230x350x382 Dimensions du four en mm L x H x P 330x298x410 245x300x384 Type de grille Grille plate Hauteur cuisini re en mm 851 843 Largeur cuisini re en in mm 1030 869 Profondeur cuisini re sans poign es en mm 666 572 Poids en Kg Chap 17 Distances de s curit anti incendie Chap 4 La capacit de chauffage des cuisini res selon EN 12815 pour des difices dont l isolation thermique ne correspond pas aux dispositions du R glement sur les isolations thermiques est de ROSA ROSETTA 30 Kcal h x m type de construction favorable 185 m 172 m 40 Kcal h x m type de construction moins favorable 138 m 129 m 50 Kcal h x m type de construction d favorable 111 m 103 m Avec une isolation thermique conforme aux dispositions sur la protection de la chaleur le volume de chauffage est sup rieur En cas de chauffage temporaire en cas d interruptions sup rieures 8 h le vo
99. sigliamo uno spessore di 2 mm ed essere fissato ermeticamente alla canna fumaria Il diametro interno del tubo di collegamento deve corrispondere al diametro esterno del tronchetto di scarico fumi della cucina DIN 1298 ATTENZIONE qualora il collegamento attraversi particolari composti da materiali infiammabili nel raggio di 20cm attorno al tubo tutti i materiali infiammabili devono essere sostituiti da materiali ignifughi e resistenti al calore Per un buon funzionamento dell apparecchio essenziale che nel luogo d installazione venga immessa sufficiente aria per la combustione vedi paragrafo 7 La depressione al camino TIRAGGIO deve essere di almeno 10 12 Pa 1 0 1 2 mm di colonna d acqua La misurazione deve essere fatta sempre ad apparecchio caldo resa calorifica nominale Quando la depressione supera 17 PA 1 7mm di colonna d acqua necessario ridurre la stessa con l installazione di un regolatore di tiraggio supplementare valvola a farfalla sul tubo di scarico o nel camino 7 AFFLUSSO D ARIA NEL LUOGO D INSTALLAZIONE DURANTE LA COMBUSTIONE Poich le stufe a legna ricavano la loro aria di combustione dal locale di installazione essenziale che nel luogo stesso venga immessa una sufficiente quantit d aria In caso di finestre e porte a tenuta stagna es case costruite con il criterio di risparmio energetico possibile che l ingresso di aria fresca non venga pi garantito e questo compromette il tiraggio
100. struito artigianalmente la sezione di uscita sia pi di due volte la sezione interna della canna fumaria Dovendo sempre superare il colmo del tetto il comignolo dovr assicurare lo scarico anche in presenza di vento Fig 4 1095080 Rev 05 IT 9 NOGDICA ROSA ROSETTA Il comignolo deve rispondere ai seguenti requisiti avere sezione interna equivalente a quella del camino avere sezione utile d uscita doppia di quella interna della canna fumaria essere costruito in modo da impedire la penetrazione nella canna fumaria di pioggia neve e di qualsiasi corpo estraneo essere facilmente ispezionabile per eventuali operazioni di manutenzione e pulizia 1 Comignolo industriale ad elementi prefabbricati consente un ottimo smaltimento dei fumi mi F II LE 2 Comignolo artigianale La giusta sezione di uscita deve essere minimo 2 volte la sezione interna della canna fumaria ideale 2 5 volte una tt ur 3 Comignolo per canna fumaria in acciaio con cono interno deflettore dei fumi 1 In caso di canne fumarie affiancate un comignolo dovr sovrastare l altro d almeno 50 cm al fine d evitare trasferimenti di pressione tra le canne stesse 1 Il
101. t les petits bassins pour l eau doivent tre nettoy s avec un chiffon doux et de l alcool froid Il ne faut pas utiliser des abrasifs ou des diluants La plaque maill e doit tre nettoy e froid avec un chiffon imbib d eau ou avec des produits d tergents pas abrasifs Il ne faut utiliser papier de verre ou paille de fer La plaque et les cercles doivent tre p riodiquement frott s avec papier de verre grain 150 1095080 Rev 05 IT EN DE FR 49 gt NONDIC ROSA ROSETTA 17 SCHEDA TECNICA CARACTERISTIQUES TECHNIQUES TECHNISCHE PROTOKOLLE FICHE TECHNIQUE ROSA Bordeaux 178 kg Petra 197 kg Maiolica 196 kg 843 DAL PIANO
102. t the deflectors are set as indicated in the Picture 9 or from the top To this purpose remove the circles of the cooking plate and disassemble the smokes pipe from the exhaust small trunk Cleaning can be made with a brush and a vacuum cleaner Pay attention that after cleaning all dismounted parts are reinstalled hermetically 130 150mm 13 2 CLEANING OF THE GLASS Thanks to a specific entry of the secondary air the building of deposit on 4 the glass of the door is slowed down in a remarkable way However the ER building of this deposit cannot be avoided with the use of solid fuels such as wet wood and this is not to be considered as a defect of the appliance Picture 9 IMPORTANT The cleaning of the sight glass must be carried out only and exclusively with cold appliance to avoid the explosion of the same Do not use cloths abrasive or chemically aggressive products by cleaning the hearth glass The correct lighting phase the use of proper quantities and types of fuels the correct position of the secondary air regulator enough draught of the chimney flue and the presence of combustion air are
103. tc provoque la d t rioration effritement brusque des l ments en fonte qui composent l appareil 9 ALLUMAGE IMPORTANT il est in vitable qu une odeur d sagr able se produise au premier allumage suite au s chage des collants de la cordelette c bl e du joint d tanch it et des vernis de protection qui dispara t apr s une courte p riode d utilisation Il faut donc assurer une bonne ventilation du local Au premier allumage nous vous conseillons de charger une quantit r duite de combustible et d augmenter progressivement le rendement calorifique de l appareil Pour effectuer un premier allumage correct des produits trait s avec des vernis pour hautes temp ratures il faut savoir ce qui suit 44 1095080 Rev 05 FR ROSA ROSETTA e iN o f UA e les mat riaux utilises pour la fabrication des appareils en question ne sont pas homog nes en effet coexistent des l ments en fonte en acier r fractaire et en faience e la temp rature laquelle le corps de l appareil est soumis n est pas homog ne de secteur secteur on enregistre des temp ratures qui varient de 300 500 T e tout au long de sa dur e de vie l appareil est soumis des cycles altern s d allumage et de repos durant la m me journ e et des cycles d utilisation intense ou de repos absolu au cours des saisons e l appareil neuf avant de pouvoir se consid rer rod devra tre soumis divers cycles d allumage afin d
104. the essential elements for the optimal functioning of the appliance and for the cleaning of the glass BREAK OF GLASSES Considering that the glasses are manufactured in glass ceramic and resistant to heat shock up to 750 C they are not subject to thermal shocks Their break can be caused only by mechanic shocks bumps or violent closure of the door etc Therefore their replacement is not included in the warranty 13 3 CLEANING OF THE ASH DRAWER All the appliances are equipped with a shaking hearth grate and an ash drawer for the collection of the ashes It is suggested to empty periodically the ash drawer and to avoid it fills completely in order not to overheat the grate Moreover we recommend leaving always 3 4 cm of ash in the hearth ATTENTION The ashes removed from the hearth have to be stored in a container made of fire resistant material equipped with an air tight cover 1095080 Rev 05 EN 25 UNITO ROSA ROSETTA The container has to be placed on a fire resistant floor far from flammable materials up to the switching off and complete cooling 13 4 MAJOLICAS LA NORDICA has chosen majolica tiles which are the result of high quality artisan work and therefore the majolica may present crackles speckles and shadings These characteristics certify their precious origin Enamel and majolica due to their different coefficient of dilatation produce micro crackles which show their authentic feature For t
105. to the instructions for use GERATE SICHERHEITSVORSCHRIFTEN Laut der Gerate Sicherheitsvorschriften sind Kaufer und Betreiber verpflichtet sich Uber den funktionsgerechten Betrieb auf Grundlage der Gebrauchanweisung zu informieren NORMES DE S CURIT SUR LES APPAREILS Conform ment aux normes de s curit en mati re d appareils l acheteur et le commercant se doivent d tre inform s sur le fonctionnement correct conform ment aux instructions concernant l utilisation ROSA ROSETTA E iN o f UA DICHIARAZIONE DI CONFORMITA DEL COSTRUTTORE Oggetto assenza di amianto e cadmio Si dichiara che tutti i nostri apparecchi vengono assemblati con materiali che non presentano parti di amianto o suoi derivati e che nel materiale d apporto utilizzato per le saldature non presente utilizzato in nessuna forma il cadmio come previsto dalla norma di riferimento Oggetto Regolamento CE n 1935 2004 Si dichiara che in tutti gli apparecchi da noi prodotti i materiali destinati a venire a contatto con i cibi sono adatti all uso alimentari in conformit al Regolamento CE in oggetto DECLARATION OF CONFORMITY OF THE MANUFACTURER Object Absence of asbestos and cadmium We declare that the materials used for the assembly of all our appliances are without asbestos parts or asbestos derivates and that in the material used for welding cadmium is not present as prescribed in relevant norm Object CE n 1935 2004 regu
106. tove the connection to chimney and the ventilation check by your chimney sweeper For the cleaning of enamelled surfaces use soap water or not aggressive and not chemically abrasive detergents If the components become bluish due to overheating this can be solved with a suitable product for cleaning IMPORTANT It is possible to use exclusively spare parts clearly authorized and offered by LA NORDICA In case of need please apply to your dealer THE APPLIANCE CAN NOT BE MODIFIED 13 1 CLEANING OF THE FLUE A correct lighting the burning of a proper fuel the loading of the suggested quantity of fuel the right adjustments of the secondary air control the sufficient draught of the chimney and the presence of air for the combustion are essential for the good operation of the appliance The appliance should be completely cleaned at least once a year or every time it is needed in case of bad working and low yield The cleaning must be carried out exclusively with cold equipment This operation should be carried out by a chimney sweeper who can simultaneously perform an audit of the flue checking of possible MS ois W deposits During cleaning remove from the cooker the smokes exhaust small trunk and the smokes pipe The smokes collection casing can be cleaned either through the door Picture 8 which is under the oven after removing the two screws which fix the door to the front side of the cooker Picture 8 please verify tha
107. tschieber sind gleichzeitig zu offen die Rauchklappe ist nach hinten zu schieben in der Stellung Kochbetrieb Platte Gebrauch und man darf auch die eventuelle Drosselklappe des Rauchrohrstutzens offen Sobald das Holz zu brennen beginnt kann weiterer Brennstoff nachgelegt werde und die Luftschieber gem der Angaben im Abschnitt 10 einstellen Lassen Sie den Ofen in dieser Phase niemals unbeaufsichtigt Der Herd darf nie berladen werden siehe H chstmengen in der unten stehenden Tabelle Zu viel Brennstoff und zu viel Verbrennungsluft k nnen zur berhitzung f hren und daher den Ofen besch digen Durch berhitzen verursachte Sch den sind nicht durch die Garantie gedeckt 10 NORMALBETRIEB Aus Sicherheitsgr nden m ssen Ger te mit selbstschlie ender T r Bauart 1 au er beim Nachlegen von Brennstoff und dem eventuellen Entfernen der Asche zwingend mit geschlossenem Feuerraum betrieben werden Ger te ohne selbstschlie ende T ren Bauart 2 m ssen an einen eigenen Schornstein angeschlossen werden Der Betrieb mit offener T r ist nur unter Aufsicht zul ssig WICHTIG Aus Sicherheitsgr nden kann die Feuerraumtuer nur beim Nachlegen von Brennstoff ge ffnet werden Der Feuerraum muss beim Betrieb oder Abk hlzeiten geschlossen bleiben Der Nominalbrennwert des Herdes betr gt 6 5 kW Dieser Wert wird mit einem Zug Depression von mindestens 12 Pa 1 2 mm Wassers ule erreicht Mit den auf der Herdfront angebrachten
108. u four et chauffage Sur la droite de la partie frontale de la cuisini re entre la barre inox de protection et la porte du four se trouve la manette de commande du r gulateur fum es qui se pr sente comme un bouton inox Figure 1 pos C Quand la manette est enfonc e vers l arri re de la cuisini re les gaz de combustion passent au dessus du four directement vers le tronc de d charge fonction cuisini re UTILISATION PLAQUE quand par contre la manette est tir e vers l ext rieur les gaz de combustion tournent autour du four faisant ainsi augmenter la temp rature int rieure du four de fa on uniforme fonction cuisini re cuisson au four et chauffage UTILISATION FOUR 3 NORMES POUR L INSTALLATION La cuisini re est assembl e et pr te pour le raccordement Elle doit tre connect e par un raccord au tuyau d vacuation de la fum e existant Dans la mesure du possible le raccord doit tre court rectiligne horizontal ou l g rement en mont e Les raccordements doivent tre tanches Il est obligatoire de respecter les normes nationales et europ ennes les dispositions locales ou en mati re de l gislation dans le secteur de la construction ainsi que les r glementations anti incendies Pour cette raison nous conseillons de vous informer au pr alable aupr s de votre ramoneur de zone Il faut de plus v rifier l arriv e d air en quantit suffisante pour la combustion et il convient donc de faire attention aux
109. um en ak kn a a A m H m 1 85 m 0 50 m above the roof ridge n gt 1 85 m 1 00 m from the roof lt 1 50 m 0 50 m above the roof ridge gt gt 1 50 m 1 30 m from the roof a 1 30 m 0 50 m above the roof ridge l gt 1 30 m 2 00 m from the roof A 1 20 m 0 50 m above the roof ridge gt 1 20 m 2 60 m from the roof 1095080 Rev 05 EN 21 NONDICA ROSA ROSETTA 6 CONNECTION TO THE CHIMNEY For safety reasons the door of the appliances with constructive system 1 must be opened only for the loading of the fuel or for removing the ashes while during the operation and the rest the door of the hearth must remain closed The appliances with constructive system 2 must be connected to their own flue The operating with open door is allowed under supervision The connection pipe to the flue must be the shortest possible right tight and according to the current regulations The connection to the chimney must be performed with stable and strong pipes we recommend a thickness of 2 mm The pipe for smokes exhaust must be fixed hermetically to the chimney The diameter inside the connection pipe must correspond to the external diameter of the smokes exhaust small trunk of the stove This is ensured by pipes according to DIN 1298 ATTENTION Eventual flammable pieces in the area of 20 cm round the connection pipes must be changed with fireproof and not sensitive to heat materials For a good
110. ung gem DIN 4705 Teil 3 dem nicht widerspricht Aus Sicherheitsgr nden m ssen die Herde mit selbstschlieBender T r au er beim Nachf llen von Brennstoff und der eventuellen Entfernung der Asche unbedingt mit geschlossenem Feuerraum betrieben werden Die Herde ohne selbstschlie ende T ren Typ 2 m ssen an einen eigenen Schornstein angeschlossen werden Der Betrieb mit offener T r ist nur unter Aufsicht statthaft Das Anschlussrohr zum Rauchfang muss m glichst kurz geradlinig und hermetisch dicht sein Die Verbindung muss mit stabilen und robusten Rohren erfolgen wir empfehlen Ihnen eine St rke von 2 mm und hermetisch am Rauchfang befestigt werden Der Innendurchmesser des Verbindungsrohres muss dem Au endurchmesser des Rauchabzugsstutzens des Herdes entsprechen DIN 1298 ACHTUNG Falls der Anschluss besondere Verbunde von brennbarem Material durchquert m ssen s mtliche brennbaren Stoffe im Umkreis von 20 cm um das Rohr durch feuerfestes und hitzebest ndiges Material ersetzt werden Es ist u erst wichtig dass am Aufstellort des Ofens eine ausreichende Luftmenge zugef hrt wird siehe Abschnitt 7 Der Unterdruck im Schornstein sollte 10 12 Pa 1 0 1 2 mm Wassers ule sein Die Messung mu immer bei warmem Ger t Nennw rmeleistung durchgef hrt werden Wenn der Unterdruck 17 PA 1 7mm WS berschreitet mu man diesen mit der Installation eine Nebenlufteinrichtung Drosselklappe auf dem Rauchgasrohr oder
111. us de pr cisions 48 1095080 Rev 05 FR ROSA ROSETTA a iN o f UA 16 MONTAGGIO CORRIMANO LATERALI MONTAGE DER SEITLICHEN HANDLAUFE MONTAGE DES BARRES LATERALES AVVERTENZA Le maniglie il corrimano e la vaschetta per l acqua vanno puliti con un panno soffice ed alcool a freddo NON usare abrasivi o diluenti La piastra smaltata va pulita a freddo con uno straccio imbevuto d acqua o con prodotti detergenti NON abrasivi NON usare carta vetrata o paglietta in ferro Il centrino ed i cerchi vanno periodicamente carteggiati con carta vetrata grana 150 ATTENTION The handles the handrail and the tank water should be cleaned with a soft cloth and alcohol cold DO NOT use abrasives or solvents The enameled plate must be cleaned with a cloth soaked in cold water or non abrasive cleaning products DO NOT use sandpaper or steel wool The cast iron top and the hot plates should be periodically sanded with 150 grit sandpaper WARNUNG Zum Reinigen der Griffe der Halterung und des Wasserschiffs empfehlen wir Ihnen ein weiches Tuch mit Alkohol zu benutzen kalt Schleifprodukte und Verd nnungen d rfen nicht benutzt werden Die emaillierte Platte darf kalt mit einen trockenen Tuch order Verd nnungen gereinigt werden Glaspapier order Metallwolle d rfen nicht benutzt werden Die Gussteile und die Ringe d rfen periodisch geschliffen werden mit k rniges Glasspapier 150 ATTENTION Les poign es la barre de protection e
112. viduare eventuali crepe o punti permeabili 5 CANNA FUMARIA Requisiti fondamentali per un corretto funzionamento dell apparecchio e la sezione interna deve essere preferibilmente circolare e essere termicamente isolata ed impermeabile e costruita con materiali idonei a resistere al calore ai prodotti della combustione ed alle eventuali condense e essere priva di strozzature ed avere andamento verticale con deviazioni non superiori a 455 e se gi usata deve essere pulita e rispettare i dati tecnici del manuale di istruzioni 1 Canna fumaria in acciaio AISI 316 con doppia Qualora le canne fumarie fossero a sezione quadrata o camera isolata con materiale resistente a rettangolare gli spigoli interni devono essere arrotondati con 400 Efficienza 100 ottima raggio non inferiore a 20 mm Per la sezione rettangolare il 2 rapporto massimo tra i lati deve essere lt 1 5 Canna fumaria in refrattario con doppia camera isolata e rivestimento esterno in calcestruzzo alleggerito Efficienza 100 ottima Una sezione troppo piccola provoca una diminuzione del tiraggio Si consiglia un altezza minima di 4 m 3 Canna fumaria tradizionale in argilla sezione Sono vietate e pertanto pregiudicano il buon funzionamento quadrata con interc
113. wendet wurden DAS GERAT DARF NICHT ABGE NDERT WERDEN 4 BRANDSCHUTZ Bei der Herdinstallation m ssen die folgenden Brandschutzvorschriften beachtet werden a Um eine ausreichende W rmed mmung zu gew hrleisten muss die Mindestanforderungen f r Sicherheitsabstand siehe ABB 2 A eingehalten werden Alle Sicherheitsabst nde sind auf der Typenschild des Produktes gezeigt und sollten nicht unter der angegebenen Werte liegen b Vor dem Herd d rfen sich im Strahlungsbereich vom 1 m weder Personen noch brennbare Bauteile befinden oder w rmeempfindliche Gegenst nde oder Baumaterialien im Abstand von 100 cm befinden Diese Entfernung kann auf 40 cm verringert werden wenn zwischen dem Herd und den entflammbaren Bauelementen ein beidseitig bel ftetes Schutzblech angebracht wird c Wenn das Produkt auf einem leicht entz ndlichen Boden installiert wird muss ein feuerfester Unterbau vorgesehen werden Fu b den aus brennbaren Materialien wie Teppich Parkett oder Kork m ssen durch einen entsprechenden Belag aus nicht brennbaren Baustoffen zum Beispiel Keramik Stein Glas oder Stahl ersetzt werden Abmessungen nach der regionalen Ordnung Die Verkleidung muss frontal mindestens 50 cm und seitlich mindestens 30 cm ber die Offnung der Ladet r vorstehen ABB 2 Pos B d Oben sollte das Produkt keine entz ndliche Teilen z B H ngeschr nke befinden
114. y circular e be thermally insulated and water proof and produced with materials suitable to resist to heat combustion products and possible condensates e not be throttled and show a vertical arrangement with deviations not greater than 453 e if already used it must be clean e observe the technical data of the instructions manual Should the flues have a square or rectangular section internal edges must be rounded with a radius not lower than 20 mm For the rectangular section the maximum ratio between the sides must be lt 1 5 A too small section causes a decrease of the draught It is suggested a minimum height of 4 m The following features are FORBIDDEN and therefore they endanger the good operation of the device asbestos cement galvanized steel rough and porous internal surfaces Picture 3 gives some examples of execution The minimum section must be 4 dm2 for example 20 x 20 cm for devices whose duct diameter is lower than 200 mm or 6 25 dm2 for example 25 x 25 cm for devices with diameter greater than 200 mm The draught created by the flue must be sufficient but not excessive A Max A 1 LI 1 AISI 316 steel flue with double chamber insulated with material resistant to 400 Efficiency 100 excellent

Download Pdf Manuals

image

Related Search

Related Contents

OWNER`S MANUAL  Sony DMX-DVD Operating Instructions  JDPC.001 Jaga Dynamic Product Controller    Fran çais  Nullpunktspannsystem NSE mini 90 NSE-M mini 90 Quick  VIZIO XVT3D554SV LCD TV  

Copyright © All rights reserved.
Failed to retrieve file