Bianco RainsaverMK5 Installation and Operating Instructions Bianco
Contents
1. SUBMERSIBLE PUMP DIVERTRON 1200 OPTIONAL PUMP STAND Part No 8IA PUMPSTAND Page 8 Accessories Pump Cover protects pump from the elements Pump stand for submersible pumps Piggy back float switch option for Divertron Pumps pump cleaner water DAB Divertron X conversion kit allows pumping from higher level and connection to floating suction kits to pump cleaner water higher in the tank INSTRS5 rev 0 03 06 14 Page 9 TM Gave F 5 2YEAR REPLACEMENT WARRANTY Terms amp Conditions I White International Pty Ltd White International NZ Ltd White International warrant that all products distributed are free from defects in workmanship and materials for their provided warranty period as indicated on the top or opposite side of this document Subject to the conditions of the warranty White International will repair any defective products free of charge at the premises of our authorised service agents throughout Australia and New Zealand if a defect in the product appears during the warranty period If you believe that you have purchased a defective product and wish to make a claim under this warranty contact us on our Sales Hotline on 1300 783 601 or send your claim to our postal address or fax line below and we will advise you as to how next to proceed You will be required to supply a copy of your proof of purchase to make a claim under this warranty 2 This warranty excludes transportation costs to and f2. Additional water filters may be required Also check the water tank and first flush diverter as per manufacturers instructions regarding periodic servicing that is required Filters need to be checked regularly as reduced flow caused by blocked filters can damage pumping equipment 4 3 Plumbing Plumbing connections should be carried out by a licensed plumber Use of flexible pipe connections and isolation vales is recommended to assist in alignment and servicing and to reduce any transmitted noise All pipe work and outlet fittings from the Bianco Rainsaver MK5 must be labelled to AS3500 The Bianco Rainsaver MK5 control incorporates a dual check valve to prevent cross connection between mains and rainwater Connection to an underground rain water tank or local water supply authorities may require additional or higher safety level back flow prevention and your licensed plumber can advise you on this The incorporation of an additional Tee fitting between the tank water pressure pump supply and the Bianco Rainsaver MK5 lower PUMP INLET will allow the householder to use collected rainwater but NOT mains water supply to irrigate gardens and lawns or wash cars Cautions In conjunction with this manual read and understand the installation and maintenance manual for the water pump that is to be connected to the Bianco Rainsaver MK5 The Bianco Rainsaver MK5 and any pump connected to it are not to be used by children or
3. To the fullest extent permitted by law White International s liability under this warranty and any other conditions guarantees or warranties at law that cannot be excluded including those in the Competition and Consumer Act 2010 Cth is expressly limited to a in the case of products the replacement of the product or the supply of equivalent product the payment of the cost of replacing the product or of acquiring an equivalent product or the repair of the product or payment of the cost of having the product repaired is at the discretion of White International or a 3rd party tribunal elected under the Competition and Consumer Act 2010 Cth for goods purchased in Australia and the Consumer Guarantees Act 1993 NZ for goods purchased in New Zealand and 6 To the fullest extent permitted by law this warranty supersedes all other warranties attached to the product or its packaging 7 In the case of services supplying the services again or the payment of the cost of having the services supplied again is at the discretion of White International or a 3rd party tribunal elected under the Competition and Consumer At 2010 Cth for goods purchased in Australia and the Consumer Guarantees Act 1993 NZ for goods purchased in New Zealand 8 Our warranty commences from the date of purchase of the above mentioned pumps Proof of purchase is required before consideration under warranty is given Record your date of purchase in the space below and retain
4. the rain water level in the tank is too low or if there is a power or pump failure the Bianco Rainsaver MK5 will automatically change over to supply mains water to meet the household needs When the rainwater supply is replenished and auto restart has commenced or the power is restored to the pump the pump will pressurise the Bianco Rainsaver MK5 and the unit will switch back automatically to supplying tank water to the household 4 Installation 4 1 Rainsaver MK5 installation The Bianco Rainsaver MK5 can be Wall mounted or Pump Mounted i e mounted directly onto a pressure pump outlet 4 11 Wall Mounting The Rainsaver MK5 can be remotely mounted any distance from the pump The Rainsaver MK5 can be mounted outdoors The Rainsaver MK5 can be mounted with the mains inlet pointing in either direction when supported by the pipework INSTRS5 rev 0 03 06 14 Page 2 4 12 Pump Mounting Rainsaver MK5 can be mounted directly onto the outlet of the pump controller 4 2 Filtration and Water Quality The Bianco Rainsaver MK5 is designed to operate on clean rainwater and clean mains water supply and as such the rainwater tank should be fitted with an inlet strainer preferably shaded type to reduce algae and a suitable first flush device White International strongly recommends the use of a strainer or filter upstream with easy access for period cleaning from both the rainwater and mains inlet connections of the Bianco Rainsaver MK5
5. this copy for your records Date of Purchase Model Purchased WHITE INTERNATIONAL PTY LTD WHITE INTERNATIONAL NZ LTD ABN 48 000119380 15G Kerwyn Ave East Tamaki AUCKLAND NZ 52 60 Ashford Ave MILPERRA NSW 2214 PO BOX 12 704 PENROSE AUCKLAND Fp PO BOX 304 MILPERRA LPO NSW 2214 Ph 09 579 9777 Fax 09 579 7775 WHITE Ph 02 9783 6000 Fax 02 9783 6001 Customer Service Hotline 0800 509 506 vv INTERNATIONAL Customer Service Hotline 1300 783 601 Customer Service Faxline 0800 804 344 Customer Service Faxline 02 9783 6003 EMAIL General Info Enquiries sales whiteint co nz EMAIL Sales Enquiries info whiteint com au INSTRS5 rev 0 03 06 14 Page 10
6. 6 Typical Installations icu i r T UNION T BALL VALVE RAINSAVER MK5 1 UNION s F BALL VALVE r HOUSE WATER Hd MAINS WATER m _ NAR di EET BEA 18 C r r 3 mm p 1 UNION C H _ POWER POINT s BIA 842A SUBMERSIBLE PUMP F FLOAT SWITCH l ABOVE GROUND WATER STORAGE OPTIONAL PUMP STAND Part No BIACPUMPSTAND q r 4 UNION RAINSAVER MKS f 1 T UNION i BALL VALVE f i BALL VALVE j HOUSE WATER BIA B424 SUBMERSIBLE PUMP FLOAT SWITCH OPTIONAL PUMP STAND Part No BIA PUMPSTAND 90 0 BIANCO B42A JH8003P submersible pumps with remote SK13 pump controller Page 7 RAINSAVERMK5 can be pipe mounted INSTRSS5 rev 0 03 06 14 Typical Installations 3 UNION Fij BALL VALVE l r HOUSE WATER 1 UNION ABOVE RAINSAVER 3 UNION y 3 BALL VALVE MAINS WATER Ay ff Pii POWER POINT GROUND WATER STORAGE DIVERTRON 1200 SUBMERSIBLE PUMP OPTIONAL PUMP STAND Part No BIA PUMPSTAND w r 1 UNION Y VALVE HOUSE WATER UNION i BALL VALVE MAINS WATER POWER POINT BELOW GROUND WATER STORAGE DAB DIVERTRON 1200 submersible pump with internal pump controller RAINSAVERMK5 can be pipe mounted INSTRSS5 rev 0 03 06 14
7. d usage Operate the Rainsaver on mains regularly or at least once a month by turning the power off to the pump 7 Trouble shooting Consult the manuals supplied with the water pump and its controller if fitted in addition to the following guide Mains flow is not available or low when Pump is switched off or not operating a Isolation valve if fitted is not open b Debris has blocked the inlet c External Inlet strainer filter if fitted are blocked 2 Pump flow is not available or low when pump is operating through Bianco Rainsaver MK5 a Pump has lost its prime b Isolation valve if fitted is not open c External Inlet strainer filter if fitted is blocked 3 Pump does not start a Rainwater tank is empty b Power supply is off c Pump controller is not installed correctly or jammed with debris d Pump has a fault 4 Pump does not stop a Leak in plumbing b Pump controller is not installed correctly or jammed with debris For after sales service please contact White International Customer Service 1 300 783 601 INSTRS5 rev 0 03 06 14 Page 4 8 Pumps Pumps and pump controllers must be accessible and fitted with barrel unions for service and maintenance All surface mounted pumps must be protected from the elements with a suitable pump cover Submersible pump accessories such as pump stands high inlets floating suction hose kits assist in the pumping cleaner water that is found at highe
8. infirm persons and must not be used as a toy A licensed plumber should carry out plumbing connections Servicing of the Bianco Rainsaver MK5 and or water pump should only by carried out by qualified persons INSTRS5 rev 0 03 06 14 Page 3 Do not clean the Bianco Rainsaver MK5 with abrasive or petroleum based fluids and do not use hydrocarbon propelled sprays on or around the Bianco Rainsaver MK5 5 Sound Emissions The Bianco Rainsaver MKS is virtually silent but may emit noises associated with the flow of water through the unit In any case the pump which is connected to the Bianco Rainsaver MK5 may emit sound levels which may inconvenience you or your neighbours or may operate during normal sleeping hours which may be prohibited by local government regulations If this is the case your pump can be switched off during the night or may be operated from a time clock Your Bianco Rainsaver MK5 will automatically supply your house with Mains water supply while the pump is inactive 6 Maintenance Ensure that water flowing through the Rainsaver MKS is as free from dirt and foreign matter as conditions allow Ease of accessibility will aid any maintenance and reduce any servicing costs if required Periodically inspect the rainwater tank inlet strainer and the first flush device Periodically inspect filters downstream and strainers if fitted upstream from the Bianco Rainsaver MKS every 6 months depending on water quality an
9. r levels in the rainwater tank 9 Water Tanks Water borne algae and roof litter can accumulate at the bottom of your rainwater tank that can be sucked up by your pump To reduce filter blockages we recommend that suction outlets on rainwater tanks be 100 mm from the bottom of the tank and submersible pumps elevated by 90 mm 10 Installation Dimensions RIGHT VIEW TS _ lt Part 2 LEFT VIEW m Part amp 1 OMS a Part 3 p Part 4 4 DISCHARGE OUTLET MAINS WATER INLET E INSTRSS5 rev 0 03 06 14 Page 5 Typical Installations i BALL VALVE r HOUSE WATER ABOVE GROUND WATER STORAGE ao 100 0 Min r DAB BIANCO or UNIVERSAL surface mounted pumps fitted with SK20 pump controller UNION T RAINSAVER MK5 1 UNION BALL VALVE MAINS WATER _ t PLEASE NOTE PUMPS MUST BE PROTECTED FROM THE ELEMENTS M El r UNION j RAINSAVER MKS BALL VALVE 4 SER TI r UNION i Y BALL VALVE HOUSE WATER E J WATER X f i zm cu i TE 3i SK20 d L POWER POINT SURFACE PUMP gamsi mais im Fi RAINSAVERMK5 can be pump or pipe mounted INSTRSS5 rev 0 03 06 14 100 0 Min PLEASE NOTE PUMPS MUST BE PROTECTED FROM THE ELEMENTS Page
10. rainsawver BIANCO Bianco RainsaverMKS Installation and Operating Instructions Bianco RainsaverMK5 uses WaterMarked components and incorporates a dual check valve for back flow prevention for the mains water WaterMark INSTRS5 rev 0 03 06 14 Page Bianco Rainsaver MK5 Installation and Operating Instructions I Introduction The Bianco Rainsaver MK5 is an Automatic Rainwater Mains Water Changeover Device designed to provide automatic mains back up for Pressure Pump supply systems The Bianco Rainsaver MKS is designed to be installed in conjunction with a DAB BIANCO or UNIVERSAL surface mounted or submersible Pressure Pump supply system that is fitted with an independent PRESSURE AND FLOW CONTROLLER with LOSS OF PRIME PROTECTION and AUTOMATIC RE START that is set at 2 2 bar start pressure WARNING The Bianco Rainsaver MK5 is NOT A PUMP CONTROLLER 2 General Specifications Maximum water temperature mains pump 40 C Maximum recommended continuous pump flow 120 litres per minute Maximum recommended pump pressure 1000 kPa Maximum recommended mains inlet pressure 000 kPa 3 Operation The Bianco Rainsaver MK5 supplies clean rainwater from a rainwater tank and associated pressure pump system to toilets laundry garden taps and household Mains water is also connected to the Bianco Rainsaver MK5 as an automatic back up When the pressure pump ceases to supply water because it has detected that
11. rom White International or its appointed service agents and excludes defects due to non compliance with installation instructions neglect or misuse inadequate protection against the elements low voltage or use or operation for purposes other than those for which they were designed For further information regarding the suitability of your intended application contact us on our Sales Hotline on 1300 783 601 If you make an invalid claim under this warranty the original product will be sent back to you unrepaired 3 This warranty refers only to products sold after the Ist January 2012 and is not transferable to another product type and only applies to the original owner purchaser or end user and is in addition to the consumer guarantees found within the Competition and Consumer Act 2010 Cth for goods purchased in Australia and the Consumer Guarantees Act 1993 NZ for goods purchased in New Zealand 4 Our goods come with guarantees that cannot be excluded under the Australian Consumer Law You are entitled to a replacement or refund for a major failure and for compensation for any other reasonably foreseeable loss or damage You are also entitled to have the goods repaired or replaced if the goods fail to be of acceptable quality and the failure does not amount to a major failure 5 To the fullest extent permitted by law White International excludes its liability for all other conditions or warranties which would or might otherwise be implied at law
Download Pdf Manuals
Related Search