Home

INSTALLATION & OPERATING INSTRUCTIONS

image

Contents

1. INSTALLATION amp OPERATING INSTRUCTIONS for the PROQUIP ENGAGER WIRELESS CONTROL INSTALLATION The BRAKE Transmitter box can be fitted anywhere on the trailerand preferably as close as possible to the Breakaway Battery Box The wires should be fitted in the order listed below 1 WHITE to earth negative 2 ORANGE to trailer 12V Positive NOTthe Breakaway battery positive 3 BLUEto the Electnc Brake wire Next disconnect the Breakaway Battery s postive lead in the following order 1 RED wire with the Male spade terminal push into the Female terminal on the end of the Breakaway Battery s positive lead 2 PINK wire with the Female spade terminal push onto the Breakaway Battery s Positive terminal 3 The short thin black wire isthe aenal leave that hanging out of the box DO NOTCUT THIS WIRE OFF OPERATION The BRAKE Tra nsmitter s LED will flash rapidly once poweris applied to the trailer when the trailer plug isconnected to the tow vehicle and the LED will continue to flash rapidly when the Brake Pedal is pressed in the tow vehicle When the Brake Pedal is first pressed the LED will glow constantly for 2 seconds while the first battery voltage reading istransmitted If the brake isnot pressed again for some time the transmitter will send the same data to the CAB Receiveronce every 60 seconds Aftereach Brake Pressand Transmit cycle The BRAKE Transmitter will not test the battery for 60 secondsand will ignore
2. any application of the brakes for this 60 second penod This isto allow the Break Away Battery charging time between tests If you are stopped fora long pernod of time forexample ata set of traffic lights and you have the brake pressed the entire time that you are stopped the BRAKE Transmitter will only test once every 60 seconds Every time the BRAKE Transmitter is activated when the brakesare applied the BRAKE Transmitters LED will flash rapidly forup to 5 second while the battery is being tested and then the LED will glow constantly for 2 seconds while the code isbeing transmitted The LED willthen go back to giving a short pulse every 2 seconds until the next Battery Test and or Transmit cycle Page lof 2 INSTALLATION amp OPERATING INSTRUCTIONS for the PROQ UIP ENG AG ER WIRELESS CONTROL When the CAB Receiver is first plugged into a power socket the ignition must be tumed on the Red and Green LEDs will flash altematively and the buzzer will pulse Once the trailer is connected the brake pedal mustbe pressed to activate the BRAKE Transmitte r NOTE While the BRAKE Transmitter is powered up assoon asthe trailer plug is connected to the tow vehicle the BRAKE transmitter will NOT start transmitting until the Electnc Brake is used atleast once This isa safety operation because the CAB Receiver will continue to pulse the buzzer until it receivesa signal from the trailer telling it that the trailer is powered up and the brakes
3. are working This will not happen if the trailer plug isconnected to the tow vehicle and the Electnc Brakesare applied Afterthe Electnc Brake isfirst operated an additional operation of the Electnc Brake will now cause the BRAKE Transmitter to send a signal indicating the charge state of the Breakaway Battery The CAB Receiver showsa fast flashing altemate RED and GREEN LED and pulses the buzzer continuously until the Electnc Brake is activated If the BRAKE AWAY Battery is very low or faulty the CAB Receiver RED and GREEN LED s will continue fast altemate flashing but the buzzer will not sound e A constant RED indicatesa low Breakaway Battery e A Slow flashing GREEN indicatesa charging Breakaway Battery e A constant GREEN indicatesa fully charged ornear fully charged Breakaway Battery PRO QUIP ENGAGER WIRELESS CONTROL Break Away Battery Monitor amp Transmitter RED or BLACK 12v n p ea Trailer BLUE Electric Brake Plug Pad Break Away ORANGE 12v Control Unit WHITE Ground BLUE Electric Brake Sense Wire www proquip com au BLACK _ Break Away Aerial Wire COPYRIGHT G 201 1 PRO QUIP Battery PROQU gt VALUE ADDED PRODUCTI Page 2of2

Download Pdf Manuals

image

Related Search

Related Contents

Samsung 320PX Uživatelská přiručka    Haier DW9-AFE User's Manual  ATS125x 4-Door DGP Installation Manual  N°26 Tevet-Shevat 5773  César Flores.indd - Universidade Estácio de Sá  Collecteur à urine - Euro  Bomba KAN.qxd  TDR Manual  Phoenix FL SWITCH SFN 8TX  

Copyright © All rights reserved.
Failed to retrieve file