User Manual ARK-3360
Contents
1. JP1 JP2 JP3 COMS type select JP4 JP5 JP6 COM4 type select JP7 COMS type select JP8 COM6 type select JP9 JP10 COM2 type select 2 2 3 Jumper Location At Mother Board Figure 2 1 Jumper and connector layout Mother Board 9 ARK 3360 User Manual At MIO Board JP4 JP5 JP6JP1 JP2 JP3 JP10 JPY Figure 2 2 Jumper layout MIO Board 2 2 4 Jumper Setting At Mother Board J2 COM2 RS232 422 485 Select Part Number 1653003260 Footprint HD_3x2P_79 Description PIN HEADER 3 1P 180D M 2 0mm SMD SOUARE PIN Setting Function 1 2 RS232 default 3 4 RS485 5 6 RS422 J3 ATX AT Mode switch Part Number 1653002101 Footprint HD_3x2P_79_D Description PIN HEADER 2 1P 180D M SQUARE 2 0mm DIP W O Pb Setting Function NL ATX Mode ON AT Mode default ARK 3360 User Manual 10 J4 CLEAR CMOS Part Number 1653003101 Footprint HD _3x1P_ 79 D Description PIN HEADER 3 1P 180D M DIP SQUARE W O Pb Setting Function NL NORMAL Default ON CLEAR CMOS J5 Internal LVDS PANEL POWER Select Part Number 1653003101 Footprint HD _3x1P_ 79 D Description PIN HEADER 3 1P 180D M 2 0mm DIP SQUARE W O Pb Setting Function 1 2 5 V for LVDS PANEL POWER 2 3 3 3 V for LVDS PANEL POWER Default At MIO Board JP1 JP2 JP3 COM3 Type Select Part Number 1653003200 Footprint HD _3x2P_ 100 D Descript2. 44 Advanced Chipset Settings 45 Figure 3 24Advanced Chipset Settings 45 3 7 1 North Bridge Chipset Configuration ee se ee ee ee 45 Figure 3 25North Bridge Configuration 45 Figure 3 26 Video function configuration 46 3 7 2 South Bridge Chipset Configuration 47 Figure 3 27South Bridge Configuration 47 side N OR AE EN AFD 48 Figure 3 28 Exit Option 48 3 8 1 Save Changes and Exit iii ee ee ee Ge Re ee namen 48 3 8 2 Discard Changes and Exit iese ese se ee ee Ge Re AA ee ee ee 48 3 8 3 Load Optimal Defaults iese ee ee ee RA Ge Re AA ee ee 48 3 8 4 Load Fail Safe Defaults iii se ee ee ee Ge RA ee ee ee 49 ARK 3360L COM2 RS422 485 Communication Setting Procedure 51 ARK 3360L COM2 RS422 485 Communication Setting Procedure 52 Table A 1 Jumper setting of ARK 3360 COM2 mode 52 xi ARK 3360 User Manual ARK 3360 User Manual xii General Introduction This chapter gives background information on ARK 3360 series 1 1 Introduction ARK 3360 fanless Embedded Box Computer is an ideal application ready system platform solution All electronics are protected in a compact sealed aluminum case for easy embedding in the customer s own housing or as a stand alone application where space is limited and the environment harsh A solid sealed aluminum case p
3. AddOn ROM Display Mode Set display mode for option ROM Bootup Num Lock Select the Power on state for Numlock m PS 2 Mouse Support Select support for PS 2 Mouse m Wait For F1 If Error Wait for the F1 key to be pressed if an error occurs m Hit DEL Message Display Displays Press DEL to run Setup in POST Interrupt 19 Capture This item allows option ROMs to trap interrupt 19 ARK 3360 User Manual 42 3 6 Security Setup O gt A i CO Y O ON U LA O N Figure 3 23 Password Configuration Select Security Setup from the ARK 3360 Setup main BIOS setup menu All Security Setup options such as password protection and virus protection are described in this section To access the sub menu for the following items select the item and press lt Enter gt m Change Supervisor User Password Boot sector Virus protection The boot sector virus protection will warn if any program tries to write to the boot sector 43 ARK 3360 User Manual 3 7 Advanced Chipset Settings BIOS SETUP UTILITY Main Advanced PCI PnP Boot secur ity Advanced Chipset Settings Configure North Bridge features WARNING Setting wrong values in below sections may cause system to malfunction South Bridge Configuration Select Screen tl Select Item Enter Go to Sub Screen Fi General Help F18 Save and Exit ESC Exit v02 61 C Copyright 1985 2006 American Megatrends Inc Figure 3 24 Advanced Chipset
4. User Manual ARK 3360 Box IPC Trusted ePlatform Services AD ANTECH ARK 3360 User Manual Attention Please note This package contains a hard copy user manual in Chinese for China CCC certifica tion purposes and there is an English user manual included as a PDF file on the CD Please disregard the Chinese hard copy user manual if the product is not to be sold and or installed in China iii ARK 3360 User Manual Copyright The documentation and the software included with this product are copyrighted 2010 by Advantech Co Ltd All rights are reserved Advantech Co Ltd reserves the right to make improvements in the products described in this manual at any time without notice No part of this manual may be reproduced copied translated or transmitted in any form or by any means without the prior written permission of Advantech Co Ltd Information provided in this manual is intended to be accurate and reliable However Advantech Co Ltd assumes no responsibility for its use nor for any infringements of the rights of third parties which may result from its use Acknowledgements Award is a trademark of Award Software International Inc VIA is a trademark of VIA Technologies Inc IBM PC AT PS 2 and VGA are trademarks of International Business Machines Cor poration Intel and Pentium are trademarks of Intel Corporation Microsoft Windows is a registered trademark of Microsoft Corp RTL is a trademark
5. ACPI Version Features This item allows you to enable RSDP pointers to 64 bit fixed system description tables ACPI APIC support Include APIC table pointer to RSDT pointer list AMI OEMB table Include OEMB table pointer to R x SDT pointer lists m Headless mode Enable Disable Headless operation mode through ACPI 3 3 6 3 Chipset ACPI Configuration BIOS SETUP UTILITY Figure 3 12 Chipset ACPI Configuration m Energy Lake Feature Allows you to configure Intel s Energy Lake power management technology m APIC ACPI SCI IRQ Enable Disable APIC ACPI SCI IRQ USB Device Wakeup From S3 S4 Enable Disable USB Device Wakeup from S3 S4 m High Performance Event Timer Enable Disable High performance Event timer ARK 3360 User Manual 34 3 3 7 AHCI Setting BIOS SETUP UTILITY Vhile entering setup BIOS auto detects the presence of IDE devices This displays the status of auto detection of IDE devices Select Screen Ti Select Item Enter 60 to Sub Screen Fi General Help F18 Save and Exit ESC Exit Figure 3 13 AHCI Setting AHCIPort0 Port While entering setup BIOS auto detects the presence of IDE devices This dis plays the status of auto detection of IDE device 3 3 8 APM Configuration BIOS SETUP UTILITY APM Configuration Enable or disable _ _ 1 AP Power Button Mode On Off Restore on AC Power Loss Power Off Video Power Down Mode Suspend Hard Disk Power Down Mode Suspend Standby
6. Plug 0 40 C for Home and Office Use 1700001947 Power cable 2 pin 180 cm USA for ARK 338X 1700001948 Power cable 2 pin 180 cm Europe for ARK 338X 1700001949 Power cable 2 pin 180 cm UK for ARK 338X 1700009001 2 Pole Phoenix to DC Jack Power cable vil ARK 3360 User Manual Safety Instructions 10 11 Please read these safety instructions carefully Please keep this User s Manual for later reference Please disconnect this equipment from AC outlet before cleaning Use a damp cloth Don t use liquid or sprayed detergent for cleaning Use moist sheet or cloth for cleaning For pluggable equipment the socket outlet shall near the equipment and shall be easily accessible Please keep this equipment from humidity Lay this equipment on a reliable surface when install A drop or fall could cause injury The openings on the enclosure are for air convection hence protecting the equipment from overheating DO NOT COVER THE OPENINGS Make sure the voltage of the power source when connecting the equipment to the power outlet Place the power cord such a way that people cannot step on it Do not place anything over the power cord All cautions and warnings on the equipment should be noted If the equipment is not used for long time disconnect the equipment from mains to avoid being damaged by transient over voltage Never pour any liquid into ventilation openings this could cause fire or electrical shock Never open the
7. Select the PCI PnP tab from the ARK 3360 setup screen to enter the Plug and Play BIOS Setup screen You can display a Plug and Play BIOS Setup option by highlighting it using the lt Arrow gt keys All Plug and Play BIOS Setup options are described in this section The Plug and Play BIOS Setup screen is shown below BIOS SETUP UTILITY Main Advanced P PnP Boot ecuritu hip et Advanced PCI PnP Settings WARNING Setting wrong values in below sections may cause system to malfunction Plug amp Play 0 S No PCI Latency Timer 64 Allocate IRQ to PCI UGA Yes Palette Snooping Disabled PCI IDE BusMaster Enabled OffBoard PCI ISA IDE Card Auto Select Screen Available TL Select Item Available Change Option Available F1 General Help Available F19 Save and Exit Available ESC Exit Available Available C Copyright 1985 2006 American Megatrends In Figure 3 20 PCI PNP Setup top m Clear NVRAM Set this value to force the BIOS to clear the Non Volatile Random Access Mem ory NVRAM The Optimal and Fail Safe default setting is No m Plug amp Play O S When set to No BIOS configures all the device in the system When set to Yes and if you install a Plug and Play operating system the operating system config ures the Plug and Play device not required for boot PCI Latency Timer Value in units of PCI clocks for PCI device latency timer register Allocate IRQ to PCI VGA When set to Yes will assigns
8. Time Out Disabled Suspend Time Out Disabled Disabled Disabled Select Screen Disabled Ti Select Item Change Option F1 General Help F18 Save and Exit ESC Exit v02 61 C Copyright 1985 2006 American Hegatrends Inc Figure 3 14 APM Configuration 35 ARK 3360 User Manual m Power Management APM Enable or disable APM m Power Button Mode Power on off or enter suspend mode when the power button is pressed The following options are also available m Restore on AC power Loss Use this to set up the system response after a power failure The Off setting keeps the system powered off after power failure the On setting boots up the system after failure and the Last State returns the system to the status just before power failure m Video Power Down Mode Power down video in suspend or standby mode m Hard Disk Power Down Mode Power down Hard Disk in suspend or standby mode Standby Time Out Go into standby in the specified time m Suspend Time Out Go into Suspend in the specified time m Resume On Ring Enable Disable RI to generate a wake event Resume On PME Enable Disable PME to generate a wake event Resume On RTC Alarm Enable Disable RTC to generate a wake event 3 3 9 Event Log Configuration BIOS SETUP UTILITY Event Logging details View all unread events on the Event Log Mark all events as read Clear Event Log Select Screen 11 Select Item Enter Go to Sub Screen F1 G
9. equipment For safety reasons only qualified service personnel should open the equipment If one of the following situations arises get the equipment checked by service personnel M The power cord or plug is damaged Liquid has penetrated into the equipment m The equipment has been exposed to moisture The equipment does not work well or you cannot get it to work according to the user s manual m The equipment has been dropped and damaged m The equipment has obvious signs of breakage DO NOT LEAVE THIS EQUIPMENT IN AN ENVIRONMENT WHERE THE STORAGE TEMPERATURE MAY GO BELOW 40 C 40 F OR ABOVE 85 C 185 F THIS COULD DAMAGE THE EQUIPMENT THE EQUIPMENT SHOULD BE IN A CONTROLLED ENVIRONMENT CAUTION DANGER OF EXPLOSION IF BATTERY IS INCORRECTLY REPLACED REPLACE ONLY WITH THE SAME OR EQUIVALENT TYPE RECOMMENDED BY THE MANUFACTURER DISCARD USED BATTERIES ACCORDING TO THE MANUFACTURER S INSTRUCTIONS The sound pressure level at the operator s position according to IEC 704 1 1982 is no more than 70 dB A RESTRICTED ACCESS AREA The equipment should only be installed in a Restricted Access Area DISCLAIMER This set of instructions is given according to IEC 704 1 Advan tech disclaims all responsibility for the accuracy of any statements contained herein ARK 3360 User Manual viii Contents Chapter 1 sb D 1 3 1 4 1 5 1 6 Chapter 2 2 1 2 2 2 3 General Introduction us
10. is operated in a commercial environment This equipment generates uses and can radiate radio frequency energy and if not installed and used in accordance with the instruction manual may cause harmful interference to radio communications Opera tion of this equipment in a residential area is likely to cause harmful interference in which case the user will be required to correct the interference at his own expense V ARK 3360 User Manual Technical Support and Assistance 1 Visit the Advantech web site at www advantech com support where you can find the latest information about the product 2 Contact your distributor sales representative or Advantech s customer service center for technical support if you need additional assistance Please have the following information ready before you call Product name and serial number Description of your peripheral attachments Description of your software operating system version application software etc A complete description of the problem The exact wording of any error messages Warnings Cautions and Notes Warning Warnings indicate conditions which if not observed can cause personal injury Caution Cautions are included to help you avoid damaging hardware or losing data e g A There is a danger of a new battery exploding if it is incorrectly installed Do not attempt to recharge force open or heat the battery Replace the battery only with the same or equivalent type
11. nm DANTECH A ee A AU O OA 252 50 9 9411 LISS Ore LSEST BETE 264 50 10 413 Figure 1 1 ARK 3360 Mechanical dimension drawing 1 4 2 Weight 2 2 kg 4 4 Ib t iremen 1 5 Power Requ 1 5 1 System Power Minimum power input ARK 3360L DC12 V3A ARK 3360F DC12 V 24V 3A 1 5A 1 5 2 RTC Battery Lithium 3 V 210 mAH ARK 3360 User Manual 1 6 Environment Specification 1 6 1 Operating Temperature m With Industrial Grade CompactFlash disk 20 60 C 32 131 F when air flow speed 0 7 m sec m With 2 5 inch extended temperature hard disk 0 to 45 C 32 113 F when air flow speed 0 7 m sec 1 6 2 Relative Humidity m 95 40 C non condensing 1 6 3 Storage Temperature m 40 85 C 40 185 F 1 6 4 Vibration during Operation m When system is equipped with Compact Flash card only 5Grms IEC 60068 2 64 random 5 500 Hz 1 Oct min 1hr axis x y z 3 axes m When system is equipped with 2 5 inch HDD 1Grms IEC 60068 2 64 random 5 500 Hz 1 Oct min 1hr axis x y z 3 axes 1 6 5 Shock during Operation m When system is equipped with Compact Flash card only 50G IEC 60068 2 27 half sine 11 ms duration m When system is equipped with 2 5 inch 20G IEC 60068 2 27 half sine 11 ms duration 1 6 6 Safety m UL CCC BSMI 1 6 7 EMC m CE FCC CCC BSMI ARK 3360 User Manual 6 H W Installation This chapter introduces external IO and th
12. of Realtek Semi Conductor Co Ltd ESS is a trademark of ESS Technology Inc UMC is a trademark of United Microelectronics Corporation SMI is a trademark of Silicon Motion Inc Creative is a trademark of Creative Technology LTD CHRONTEL is a trademark of Chrontel Inc All other product names or trademarks are properties of their respective owners For more information about this and other Advantech products please visit our web site at http www advantech com http www advantech com ePlatform For technical support and service please visit our support website at http support advantech com tw support Part No 2066336001 Edition 2 Printed in China December 2010 ARK 3360 User Manual iv Product Warranty 2 years Advantech warrants to you the original purchaser that each of its products will be free from defects in materials and workmanship for two years from the date of pur chase This warranty does not apply to any products which have been repaired or altered by persons other than repair personnel authorized by Advantech or which have been subject to misuse abuse accident or improper installation Advantech assumes no liability under the terms of this warranty as a consequence of such events Because of Advantech s high quality control standards and rigorous testing most of our customers never need to use our repair service If an Advantech product is defec tive it will be repaired or replaced at no cha
13. recommended by the man ufacturer Discard used batteries according to the manufacturer s instructions Note Notes provide optional additional information Packing List Before installation please ensure the following items have been shipped m 1x ARK 3360 unit m 1x Driver Utility CD Mm 1x Registration and 2 years Warranty card ARK 3360 User Manual vi Ordering Information Model Number Description ARK 3360L N4A1E Intel Atom N450 1 66 GHz Compact Embedded Box IPC w 2 x GbE 6 x USB 2 0 4 x COM 1x MiniCPle VGA DIO Audio ARK 3360L D5A1E Intel Atom D510 1 66 GHz Compact Embedded Box IPC w 2 x GbE 6 x USB 2 0 4 x COM 1x Mini PCle VGA DIO Audio ARK 3360F N4A1E Intel Atom N450 1 66 GHz Compact Embedded Box IPC w 3 x GbE 6 x USB 2 0 6 x COM 1x MiniCPle miniPCI VGA Audio ARK 3360F D5A1E Intel Atom D510 1 66 GHz Compact Embedded Box IPC w 3 x GbE 6 x USB 2 0 6 x COM 1x MiniCPle miniPCI VGA Audio Optional Accessories For ARK 3360L Part Number Description Adapter AC 90 264V 36W 12V W PFC FSP036 RAB For ARK 1757003553 3360L 1700001524 Power Cable 3 pin 180 cm USA Type 170203183C Power Cable 3 pin 180 cm Europe Type 1702031804 Power Cable 3 pin 180 cm UK Type 1700008921 Power Cable 3 pin 180 cm PSE Mark For ARK 3360F Part Number Description AC to DC Adapter DC19 V 3 42 A 65 W with Phoenix Power 1297002833
14. safe settings when you select this option Fail Safe Defaults are designed for maximum system stability but not maximum performance Select Fail Safe Defaults if your computer is experi encing system configuration problems 1 Select Load Fail Safe Defaults from the Exit menu and press lt Enter gt The fol lowing message appears Load Fail Safe Defaults OK Cancel 2 Select OK to load Fail Safe defaults ARK 3360 User Manual 48 49 ARK 3360 User Manual ARK 3360 User Manual 50 ARK 3360L COM2 RS422 485 Communication Setting Procedure A 1 ARK 3360L COM2 RS422 485 Communication Setting Procedure Table A 1 Jumper setting of ARK 3360 COM2 mode J2 COM RS232 422 485 Select Part Number 1653003260 Footprint HD_3x2P_79 Description PIN HEADER 3 1P 180D M 2 0mm SMD SOUARE PIN Setting Function 1 2 RS232 default 3 4 RS485 5 6 RS422 The default COM2 cable is only for RS 232 if you want to use RS 422 485 please follow the following steps to use RS 422 485 1 Unscrew the screws and frames to open the case as shown in the figures below ARK 3360 User Manual 52 2 Unscrew the screws to open the top cover as shown in as shown in the figures below 3 After remove the top cover you will find COM2 cable as shown in the figure below 53 ARK 3360 User Manual 4 Please replace the internal COM2 cable by new cable Part Number 1700001967 and adjust jumper 2
15. 360 User Manual COM2 COM3 COM4 COMS COM6 PWR LINE IN LAN LED USB4 USB2 HDD USB5 USB3 DIO MIC LINE OUT LED Figure 2 4 ARK 3360F IO connectors drawing 2 3 1 1 COM Connector ARK 3360 provides maximum six D sub 9 pin connectors which offers RS 232 422 485 serial communication interface ports Default setting is RS 232 if you want to use RS 422 485 you can find the jumper installation in Chapter 2 2 4 The RS 422 485 mode of ARK 3360L COM2 can be supported via replacing the internal COM 2 cable by using the new cable Part Number 1700001967 and adjusting the jumper inside the system The extra cable pn 1700001967 has been stored in the accessory box of the product carton The setting procedure is in Appen dix A 6789 Figure 2 5 COM connector ARK 3360 User Manual 14 2 3 1 2 Table 2 3 COM Connector Pin Assignments RS 232 RS 422 RS 485 Pin Signal Name Signal Name Signal Name 1 DCD Tx DATA 2 RxD Tx DATA 3 TxD Rx NC 4 DTR Rx NC 5 GND GND GND 6 DSR NC NC 7 RTS NC NC 8 CTS NC NC 9 RI NC NC Note NC represents No Connection E Ethernet Connector LAN ARK 3360 is equipped up to three Ethernet controllers that are fully compliant with IEEE 802 3u 10 100 1000 Mbps CSMA CD standards LAN1 is equipped with 82567 LAN1 is equipped with 82583V and LANG is equipped with 82541PI The Ethernet port provides a standard RJ 45 jack connector with LED i
16. Dynamic Video Memory Technology DirectX 9 compliant Pixel Shader 2 0 m Dual display choose on board VGA LVDS or VGA LVDS through OS Driver LVDS is optional a and m Intel Clear Video Technology Controllers m VGA Intel Atom N450 supports up to 1400 x 1050 SXGA Mm Intel Atom D510 supports up to 2048 x 1536 m LVDS Single channel 18 bit LVDS up to WXGA 1366 x 768 Optional VGA Connector on board D SUB 15P LVDS Connector MDR 26P SB Intel ICH8M chip supports Supports the Serial ATA specification Revision 1 0a m Supports several optional sections of Serial ATA Il Extensions to Ee Serial ATA 1 0 Specification Revision 1 0 Mm Supports SATA transfers to 300 Mbytes sec Supports Compact Flash Card Type II Socket m CF Socket CF Type ll 50P 90D M external connector x 1 SB Intel ICH8M chip supports Audio Link Supports HD Codec m Supports Link for Audio and Telephony CODECS USB Interface SB Intel ICH8M chip supports m USB host interface with support for 6 USB 2 0 ports m All ports are High Speed Full Speed and Low Speed capable m Supports legacy keyboard mouse software 3 ARK 3360 User Manual SB Intel ICH8M chip supports Power Management m Supports ACPI 2 0 m ACPI Power Management Logic Support BIOS SB Intel ICH8M chip supports AMI 16Mb Flash BIOS via SPI 1 3 1 3 Others Serial ports SMSC SCH 3114 support a Up to 6 serial ports by SMSC SCH 3114 a High Speed N
17. E Detect Time Out Sec This item allows you to select the time out value for detecting ATA ATAPI device s 3 3 3 Super VO Configuration BIOS SETUP UTILITY Figure 3 6 Super VO Configuration Serial Port1 Port2 Port3 Port 4 address Port 3 4 only for ARK 3360L This item allows you to select serial porti port4 of base addresses Serial Port1 Port2 Port3 Port 4 IRQ Port 3 4 only for ARK 3360L This item allows you to select serial port1 port4 of IRQ m Parallel Port Address optional This item allows you to select Parallel port address m Parallel Port Mode optional This item allows you to select Parallel port Mode m Parallel Port IRQ optional This item allows you to select Parallel port IRQ m RS 485 Control for SP2 This item allows you to select RS485 control Auto Direction Control Select This item allows you to enable or disable auto flow control function ARK 3360 User Manual 30 3 3 4 Hardware Healt Je deu9 H V Health Function Enabled 3 Pu tting 1 On Fu sDuMmes SOIg Figure 3 7 Hardware Health Configuration m H W Health Function This item allows you to control H W monitor of showing Temperature amp Voltage Show CPU System Temperature Vcore 43 3 Vin 5 Vin 12 Vin VBAT 3 3 5 Advanced Serial Port3 Address N 3 LRU Figure 3 8 Super VO Configuration 31 ARK 3360 User Manual m Serial Port3 Port4 Port5 Port 6 Address This item allows you t
18. Figure 6 5 Finally you can screw the new COM2 cable on the front panel and screw all screws back ARK 3360 User Manual 54 Appendix A ARK 3360L COM2 RS422 485 Communication Setting Procedure ARK 3360 User Manual 55 Trusted ePlatform Services AD ANTECH www advantech com Please verify specifications before quoting This guide is intended for reference purposes only All product specifications are subject to change without notice No part of this publication may be reproduced in any form or by any means electronic photocopying recording or otherwise without prior written permis sion of the publisher All brand and product names are trademarks or registered trademarks of their respective companies Advantech Co Ltd 2010
19. IO connectors drawing 14 Figure 2 5 COM connector iese ee ee ee AR ee ee 14 Table 2 3 COM Connector Pin Assignments 15 Figure 2 6 Ethernet connector 15 Table 2 4 Ethernet Connector Pin Assignments 15 Figure 2 7 Audio connector 16 Table 2 5 Audio Connector Pin Assignment esse see 16 Figure 2 8 DIO Connector ARK 3360L 16 Table 2 6 DIO Connector Pin Assignments ARK 3360L 16 Figure 2 9 DIO connector ARK 3360F ee ee nennen 17 Table 2 7 DIO Connector Pin Assignments ARK 3360P 17 Figure 2 10USB connector Lee ee ee AA AR ee ee 17 Table 2 8 USB Connector 17 Figure 2 11VGA Connector ee se ee RR ee ee ee 18 Table 2 9 VGA Connector Pin Assignments 18 ix ARK 3360 User Manual 2 4 Chapter 3 3 1 3 2 3 3 3 4 ARK 3360 User Manual Figure 2 12Power Input Connector ARK 3360L 18 Figure 2 13Power Input Connector ARK 3360F 18 Table 2 10 Power connector Pin Assignments ARK 3360F 18 Figure 2 14Power Button 19 Figure 2 15LED Indicators 19 Installation se ee EE ee 19 241 ADD Installations nn ne 19 Figure 2 16Unscrew the HDD door SCreWS aseeseen 19 Figure 2 17Assembl
20. IRQ to PCI VGA card if card requests IRQ When set to No will not assign IRQ to PCI VGA card even if card requests an IRQ m Palette Snooping This item is designed to solve problems caused by some non standard VGA card m PCIIDE BusMaster When set to enabled BIOS uses PCI busmastering for reading writing to IDE drives OffBoard PCI ISA IDE Card Some PCI IDE cards may require this to be set to the PCI slot number that is holding the card When set to Auto will works for most PCI IDE cards ARK 3360 User Manual 40 m IRQ3 4 5 7 9 10 11 This item allows you respectively assign an interruptive type for IRQ 3 4 5 7 9 10 11 m DMA Channel0 1 3 5 6 7 When set to Available will specified DMA is available to be used by PCI PnP devices When set to Reserved will specified DMA will Reserved for use by leg acy ISA devices m Reserved Memory Size This item allows you to reserved size of memory block for legacy ISA device 3 5 Boot Settings TINTE Figure 3 21 Boot Setup Utility 41 ARK 3360 User Manual e 161deuy9 suas SOIg 3 5 1 Boot Settings Configuration BIOS SETUP UTILITY Quick Boot Enabled Figure 3 22 Boot Setting Configuration Quick Boot This item allows BIOS to skip certain tests while booting This will decrease the time needed to boot the system Quiet Boot If this option is set to Disabled the BIOS displays normal POST messages If Enabled an OEM Logo is shown instead of POST messages
21. Not Detectedl Primary IDE Slave Not Detected Secondary IDE Master Not Detected Secondary IDE Slave Not Detected gt Third IDE Master Not Detected Third IDE Slave Not Detected Hard Disk Write Protect Disabled Select Screen IDE Detect Tine Out Sec 135 tl Select Item Change Option F1 General Help F10 Save and Exit ESC Exit v02 61 C Copyright 1985 2006 American Megatrends In Figure 3 5 IDE Configuration sm ATA IDE Configuration This item allows you to select Disabled Compatible Enhanced m Legacy IDE Channels When set to Enhanced mode you can select IDE or AHCI mode When select Compatible mode you can select SATA only SATA pri PATA sec or PATA only m Primary Secondary Third IDE Master Slave BIOS auto detects the presence of IDE device and displays the status of auto detection of IDE device Type Select the type of SATA driver Not Installed Auto CD DVD ARMD LBA Large Mode Enables or Disables the LBA mode Block Multi Sector Transfer Enables or disables data multi sectors trans fers PIO Mode Select the PIO mode DMA Mode Select the DMA mode M A R T Select the smart monitoring analysis and reporting technology 32Bit Data Transfer Enables or disables 32 bit data transfer m Hard Disk Write Protect Disable Enable device write protection This will be effective only if device is accessed through BIOS 29 ARK 3360 User Manual m ID
22. Pin Assignments ARK 3360F Pin Signal Name V5 DIOO DIO1 DIO2 DIO3 DIO4 DIO5 DIO6 DIO7 0 GND NII A ON USB Connector ARK 3360 provides six USB interface connectors which give complete Plug amp Play and hot swapping for up to 127 external devices The USB interface complies with USB UHCI Rev 2 0 compliant The USB interface can be disabled in the system BIOS setup Please refer to Table 2 8 for its pin assignments The USB connectors are used to connect any device that conforms to the USB interface Most digital devices conform to this standard The USB interface supports Plug and Play without turning off computers Figure 2 10 USB connector Table 2 8 USB Connector Pin Signal name Pin Signal name 1 VCC 2 USB_data 3 USB_data 4 GND 17 ARK 3360 User Manual 2 3 1 6 VGA Connector The ARK 3360 provides a high resolution VGA interface connected by a D sub 15 pin connector to support a VGA CRT monitor lt supports display resolution of up to 2048 x 1536 or 1400 x 1050 Figure 2 11 VGA Connector Table 2 9 VGA Connector Pin Assignments Pin Signal Name Pin Signal Name 1 Red 2 Green 3 Blue 4 NC 5 GND 6 GND 7 GND 8 GND 9 NC 10 GND 11 NC 12 NC 13 H SYNC 14 V SYNC 15 NC 2 3 1 7 Power Input Connector ARK 3360L comes with a DC Jack header that carries 12 VDC external power input and ARK 3360F comes with a two pins header that
23. S16C550A Compatible UARTS with Data rates to 1 5Mbps Support IRQ Sharing among serial ports on XPE For ARK 3360L m COM1 COM3 COM4 Supports to RS 232 m COM2 Supports to RS 232 422 485 and setting by Jumper COM2 RS 485 support Auto flow control For ARK 3360F H COM1 Supports to RS 232 m COM2 COM4 Supports to RS 232 422 485 and setting by Jumper m COM5 COM6 Support RS 422 485 with isolation 7 5 kV COM2 COM6 RS 485 support Auto flow control COM connector D SUB CON 9P LAN LAN1 Intel 82567 LAN2 Intel 82583V LAN3 Intel 82541PI m Compliant with IEEE 802 3 IEEE 802 3u IEEE 802 3x IEEE 802 3y IEEE 802 ab Support 10 100 1000 Mbps LAN Connectors Phone Jack RJ45 8P 90D F Audio Audio Codec Realtek ALC888 je Compliant with HD Audio specifications Eg Supports to 16 20 24 bit DAC and 16 20 24 bit ADC resolution ag Support Speak out Line in Mic in Audio Connectors Ear Phone Jack 3 DIO SMSC SCH 3114 support E 10 VO pins with one 5V power ping and one ground pin a 5V tolerance l Os DIO Connectors m ARK 3360L 9 pins DSUB 9 connector m ARK 3360F 10 pins phoenix connector Battery backup M BATTERY 3V 210 mAh with WIRE x 1 ARK 3360 User Manual 1 4 Mechanical Specifications 1 4 1 Dimensions 264 5 10 41 x 69 2 2 72 x 137 25 5 4 Unit mm Inch LrOr S SLE L30 31 S29 69 00 2 7177 69 20 2 724 I ee ee m mn mn EE RE mn BEER om
24. Settings 3 7 1 North Bridge Chipset Configuration BIOS SETUP UTILITY North Bridge Chipset Configuration PCI MMIO Allocation 46B To 3072MB Configure DRAM Timing by SPD Enabled Menory Hole Disabled Initate Graphic Adapter IGD Internal Graphics Mode Select Enabled 1MB PEG Port Configuration Video Function Configuration Select Screen Select Item Change Option General Help Save and Exit Exit v02 61 C Copyright 1985 2006 American Megatrends Im Figure 3 25 North Bridge Configuration m DRAM Frequency This item allows you to manually changed DRAM frequency Configure DRAM Timing by SPD This item allows you to enables or disables detect by DRAM SPD ARK 3360 User Manual 44 Memory Hole This item allows you to free 15MB 16MB of memory size for some ISA devices Initiate Graphic Adapter This item allows you to select which graphics controller to use as the primary boot device Internal Graphics Mode Select Select the amount of system memory used by the Internal graphics device 3 7 1 1 Video function configuration BIOS SETUP UTILITY Figure 3 26 Video function configuration DVMT Mode Select Displays the active system memory mode DVMT FIXED Memory Specify the amount of DVMT FIXED system memory to allocate for video memory Boot Display Device Select boot display device at post stage Flat Panel Type This item allows you to select which panel resolution you wants Spread Spectrum C
25. an Megatrends Inc Figure 3 18 USB Configuration ARK 3360 User Manual 38 m Legacy USB Support Enables support for legacy USB Auto option disables legacy support if no USB devices are connected m USB 2 0 Controller Mode This item allows you to select HiSpeed 480Mbps or FullSpeed 12Mpbs m BIOS EHCI Hand Off This is a workaround for OSes without EHCI hand off support The EHCI owner ship change should claim by EHCI driver Hotplug USB FDD Support A dummy FDD device is created that will be associated with the hotplugged FDD later Auto option creates this dummy device only if there is no USB FDD present 3 3 12 1 USB Mass Storage Device Configuration BIOS SETUP UTILITY USB Mass Storage Device Configuration Number of seconds POST waits for the USB mass storage device after start Device 1 USB Hotplug FDD unit command Emulation Type Autol Select Screen 11 Select Item Change Option Fi General Help F10 Save and Exit ESC Exit v02 61 C Copyright 1985 2006 American Megatrends In Figure 3 19 USB Mass storage Device Configuration m USB Mass Storage Reset Delay Number of sends POST wait for the USB mass storage device after start unit command Emulation Type If Auto USB devices less than 530MB will be emulated as Floppy and remaining as hard drive Force FDD option can be used to force a FDD formatted drive to boot as FDD Ex ZIP drive 39 ARK 3360 User Manual 3 4 Advanced PCI PnP Settings
26. and Exit ESC Exit u02 61 C Copyright 1985 2006 American Megatrends In Figure 3 28 Exit Option Save Changes and Exit When you have completed system configuration select this option to save your changes exit BIOS setup and reboot the computer so the new system configuration parameters can take effect 1 Select Exit Saving Changes from the Exit menu and press lt Enter gt The following message appears Save Configuration Changes and Exit Now Ok Cancel 2 Select Ok or cancel Discard Changes and Exit Select this option to quit Setup without making any permanent changes to the system configuration 1 Select Exit Discarding Changes from the Exit menu and press lt Enter gt The fol lowing message appears Discard Changes and Exit Setup Now Ok Cancel 2 Select Ok to discard changes and exit Discard Changes 3 Select Discard Changes from the Exit menu and press lt Enter gt Load Optimal Defaults The ARK 3360 automatically configures all setup items to optimal settings when you select this option Optimal Defaults are designed for maximum system performance but may not work best for all computer applications In particular do not use the Opti mal Defaults if your computer is experiencing system configuration problems Select Load Optimal Defaults from the Exit menu and press lt Enter gt 47 ARK 3360 User Manual 3 8 4 Load Fail Safe Defaults The ARK 3360 automatically configures all setup options to fail
27. carries 12 24 VDC external power input ARK 3360L lt e Figure 2 12 Power Input Connector ARK 3360L ARK 3360F 2 N Figure 2 13 Power Input Connector ARK 3360F Table 2 10 Power connector Pin Assignments ARK 3360F Pin Signal Name 1 GND 2 12 24 VDC ARK 3360 User Manual 18 2 3 1 8 Power ON OFF Button ARK 3360 comes with a Power On Off button that support dual function of Soft Power On Off Instant off or Delay 4 Second and Suspend Figure 2 14 Power Button 2 3 1 9 LED Indicators There are two LEDs on ARK 3360 front metal face plate for indicating system status PWR LED is for power status and HDD LED is for HDD amp compact flash disk status PWR HDD Figure 2 15 LED Indicators 2 4 Installation 2 4 1 HDD Installation 1 Unscrew the HDD door screws Figure 2 16 Unscrew the HDD door screws 19 ARK 3360 User Manual 2 Assemble HDD and HDD frame with four screws Figure 2 17 Assemble HDD and HDD frame with 4 screws 3 Use the HDD damper screws to assemble the HDD door and HDD frame Figure 2 18 Use the HDD damper screws to assemble the HDD door and HDD frame ARK 3360 User Manual 20 4 Connect the HDD cables Figure 2 19 Connect the HDD cables 5 Replace HDD door and secure with screws 2 4 2 Memory Installation 1 Refer to section 2 4 1 1 to open the HDD door 2 Install the memory module into the SO DIMM socket at the bo
28. e 3 x RS232 1 x RS232 422 485 for ARK 3360L 1x RS 232 3x RS 232 422 485 2 x RS 422 485 with 7 5 KV isolation protection amp auto flow control for ARK 3360F m USB 6 x USB 2 0 compliant ports M Audio High Definition Audio HD Line in Line out Mic in DIO 8 bit general purpose input output Expansion Interface Supports 1xMini PCI ARK 3360F only and 1 x Mini PCle device 1 2 2 Display Chipset Embedded Gen3 5 GFX Core Memory Size Up to 224 MB of dynamic video memory allocation m Resolution CRT Intel Atom N450 up to 1400 x 1050 SXGA LVDS Single channel 18 bit LVDS up to WXGA 1366 x 768 Mm LVDS LCD Supports 18 bit LVDS LCD Optional Dual Display CRT LVDS 18 bit ARK 3360 User Manual 2 1 2 3 1 3 1 3 1 1 3 1 1 1 3 1 2 Ethernet Chipset LAN1 Intel 82567 LAN2 Intel 82583V LAN3 Intel 82541PI ARK 3360F only Speed 10 100 1000 Mbps m Interface 2 x RJ45 ARK 3360L 3 x RJ45 ARK 3360F Standard Compliant with IEEE 802 3 IEEE 802 3u IEEE 802 3x IEEE 802 3y IEEE 802 ab Chipset Functional Specification Processor Intel Atom Processor N450 D510 Processor Intel Atom N450 D510 at 1 66 GHz with 512 KB 1MB L2 cache Manufacturing Technology 45 nm Chipset Intel N450 D510 M Mm Supports DDR2 667 MHz up to 2 GB emory SODIMM Socket 1 200 pin SODIMM socket type 1 Intel 3 5 Gen Integrated Graphic Engine GFX core DVMT 3 0
29. e HDD and HDD frame with 4 screws 20 Figure 2 18Use the HDD damper screws to assemble the HDD door and HDD frame 20 Figure 2 19Connect the HDD cables 21 2 4 2 Memory Installation 21 Figure 2 20Install the memory module into the SO DIMM socket at the bottom of the Main board 21 2 4 3 CF Card Installation AA AR ee ee ee e 22 Figure 2 21Unscrew the CF door screws 22 Figure 2 22Pull the CF tray out 22 Figure 2 23Remove CF bracket ii sesse ee se ee ee Re ee 23 Figure 2 24Put CF onto the CF tray s es 23 BIOS Settings 29 Figure 3 1 Setup Program Initial Screen 26 Entering BIOS Setup 26 Main MON counts billar 27 Figure 3 2 Main Setup Screen 27 3 2 1 System Time System Date 27 Advanced BIOS Features Setup 27 Figure 3 3 Advanced BIOS Features Setup Screen 28 3 3 1 CPU Configuration 28 Figure 3 4 CPU Configuration Setting iese se ee ee ee ee 28 3 3 2 IDE Configuration ees ese ee ek ee Re ee ee ee ee ee ee nn 29 Figure 3 5 IDE Configuration 29 3 3 3 Super VO Configuration 30 Figure 3 6 Super VO Configuration 30 3 3 4 Hardware Health Configuration sesse see ees ese ee ee ee ee Re ee ee ee 31 Figure 3 7 Hardware Health Configuration 31 3 3 5 Secondary Superl O Configuration Only for ARK 3360F 32 Fi
30. e installation of ARK 3360 hardware 2 1 2 2 2 2 1 Introduction The following sections show the internal jumper settings and the external connectors and pins assignment for applications Jumpers Jumper Description You may configure the ARK 3360 to match the needs of your application by setting jumpers A jumper is a metal bridge used to close an electric circuit It consists of two metal pins and a small metal clip often protected by a plastic cover that slides over the pins to connect them To close a jumper you connect the pins with the clip To open a jumper you remove the clip Sometimes a jumper will have three pins labeled 1 2 and 3 In this case you would connect either pins 1 and 2 or 2 and 3 lt 24 J p open closed closed 2 3 The jumper settings are schematically depicted in this manual as follows 1 2 1 2 1 2 3 w Un he 4 open closed closed 2 3 A pair of needle nose pliers may be helpful when working with jumpers If you have any doubts about the best hardware configuration for your application contact your local distributor or sales representative before you make any changes Generally you simply need a standard cable to make most connections ARK 3360 User Manual 8 2 2 2 Jumper List Table 2 1 Jumper List of Mother Board J2 COM2 Setting J3 AT ATX Power SEL J4 Clear CMOS J5 Internal LVDS Panel Voltage Select Table 2 2 Jumper List of MIO Board for ARK 3360F only
31. eneral Help F18 Save and Exit ESC Exit v02 61 C Copyright 1985 2006 American Megatrends Inc Figure 3 15 Event Log Configuration ARK 3360 User Manual 36 m View Event Log View all unread events on the event Log m Mark all events as read Mark all unread events as read Mm Clear Event Log Discard all events in the event Log 3 3 10 MPS Configuration BIOS SETUP UTILITY Figure 3 16 MPS Configuration m MPS Revision This item allows you to select MPS reversion 37 ARK 3360 User Manual e Jajdeyo suites SOI 3 3 11 Smbios Configuration Smbios Configuration Screen Smbios Configuration SMBIOS SMI Wrapper support for PnP Func 50h 54h Select Screen 11 Select Item Change Option F1 General Help F18 Save and Exit ESC Exit C Copyright 1985 2006 American Megatrends Inc Figure 3 17 Smbios Configuration Smbios Smi Support SMBIOS SMI wrapper support for PnP function 50h 54h 3 3 12 USB Configuration BIOS SETUP UTILITY Configuration Enables support for ee legacy USB AUTO Module Version 2 24 3 13 4 option disables legacy support if USB Devices Enabled no USB devices are 1 Keyboard 1 Mouse connected USB 2 0 Controller Mode HiSpeed BIOS EHCI Hand Off Enabled Hotplug USB FDD Support Auto USB Mass Storage Device Configuration Select Screen tL Select Item Change Option F1 General Help F1 Save and Exit ESC Exit v02 61 C Copyright 1985 2006 Americ
32. es 1 Introduction ciao 2 Product Feature nus men ann 2 ENE IE ER ner OE N 2 1 2 2 RE EE een 2 1 23 HARE ne ee 3 Ghipset m EE RE RE EE EAE TG 3 1 3 1 Functional Specification iese ee RA AR Re ee AR ee 3 Mechanical Specifications 5 1 41 DIMENSIONS iia 5 Figure 1 1 ARK 3360 Mechanical dimension drawing 5 1 4 2 eie AE RE ee EE EE 5 Power Reduireiment stasies sees se se eg e date ese gegee gee ek 5 1 51 System POWEF essens HR a toco ci 5 1 5 2 RIG Battery sucia ic da 5 Environment Specifications 6 1 6 1 Operating Temperature AA ee ee ee ee ee 6 1 6 2 Relative Humidity esse ccc ese ee Re ER Re ER Re ee AE Re ee ee 6 1 6 3 Storage Temperature ee AA ee ee 6 1 6 4 Vibration during Operation 6 1 6 5 Shock during Operation ee ee RA RR AA ee ee 6 1 6 6 ER OE ONE EE RE nine 6 AN se RE EE ME EE ni 6 H W Installation ees ese ese Rene nee e ee Z slee lisie OR EE AE 8 Roe EE td EE OE N 8 2 2 1 Jumper Description 8 272 2 Jumper Ust iste ee echte le 9 Table 2 1 Jumper List of Mother Board 9 Table 2 2 Jumper List of MIO Board for ARK 3360F only 9 2 2 3 Jumper Location 4 9 Figure 2 1 Jumper and connector layout Mother Board 9 Figure 2 2 Jumper layout MIO Board 10 224 Jumper Seti imitan iia 10 Seel OR EE N 13 2 3 1 ARK 3360 External VO Connectors iese sees se ee ee ke ee 13 Figure 2 3 ARK 3360L IO connectors drawing 13 Figure 2 4 ARK 3360F
33. gure 3 8 Super I O Configuration 32 3 3 6 ACPI Settings iii see AA RA AR nana Re ee ea 33 Figure 3 9 ACPI Settings 33 Figure 3 10General ACPI Configuration 33 Figure 3 11 Advanced ACPI Configuration 34 Figure 3 12Chipset ACPI Configuration esse ee nn 35 8 3 7 Ek RR ER EE aan 36 Figure 3 18AHCI Setting ee ee Re ee ee de ee ee 36 33 8 APM Configuration se el 36 Figure 3 14APM Configuration srs440 nennen 36 3 3 9 Event Log Configuration 37 Figure 3 15Event Log Configuration 37 3 3 10 MPS Configurations ur euere 38 Figure 3 16MPS Configuration 20 42240444sn nennen 38 3 3 11 Smbios Configuration ssrsssennnnneennnnnnnnnnnnnnnnnnnnnnnennnnnnnn nn 39 Figure 3 17 Smbios Configuration 39 3 3 12 USB Configuration ainiaan anai 39 Figure 3 18USB Configuration 39 Figure 3 19USB Mass storage Device Configuration 40 Advanced PCI PnP Settings iese see ee se ee ee ee ee ee ca ee ee ee ee e 41 x 3 5 3 6 3 7 3 8 Appendix A A 1 Figure 3 20PCI PNP Setup top ees ee see ee ee ee ee ee ee conca 41 Boot oie AE EE ano li OE AR edad 42 Figure 3 21Boot Setup Utility 42 3 5 1 Boot Settings Configuration 43 Figure 3 22Boot Setting Configuration 43 SECUNILY SOUP RE OE OE N 44 Figure 3 23Password Configuration
34. ion PIN HEADER 3 2P 180D M 2 54mm DIP W O Pb Setting Function JP1 1 3 2 4 JP2 1 3 2 4 RS 232 Default JP3 5 6 JP1 3 5 4 6 JP2 3 5 4 6 RS 422 JP3 3 4 JP1 3 5 4 6 JP2 3 5 4 6 RS 485 JP3 1 2 JP4 JP5 JP6 COM4 Type Select Part Number 1653003200 Footprint HD_3x2P_100_D Description PIN HEADER 3 2P 180D M 2 54mm DIP W O Pb Setting Function JP4 1 3 2 4 JP5 1 3 2 4 RS 232 Default JP6 5 6 JP4 3 5 4 6 JP5 3 5 4 6 RS 422 JP6 3 4 JP4 3 5 4 6 JP5 3 5 4 6 RS 485 JP6 1 2 11 ARK 3360 User Manual JP7 COM5 Type Select Part Number 1653002200 Footprint HD_2x2P_100_D Description PIN HEADER 2 2P 180D 2 54mm DIP WO Pb Setting Function 1 2 RS 485 Default 3 4 RS 422 JP8 COM6 Type Select Part Number 1653002200 Footprint HD_2x2P_100_D Description PIN HEADER 2 2P 180D M 2 54mm DIP WO Pb Setting Function 1 2 RS 485 Default 3 4 RS 422 JP9 JP10 COM2 Type Select Link with JP10 and MB J2 Part Number 1653003200 Footprint HD_3x2P_100_D Description PIN HEADER 3 2P 180D M 2 54mm DIP W O Pb Setting Function P9 1 3 2 4 En RR a RS 232 Default JP9 3 5 4 6 JP10 3 5 4 6 ARK 3360 User Manual RS422 485 12 2 3 Connectors 2 3 1 ARK 3360 External VO Connectors ARK 3360L LINE IN COM 2 COM3 COM4 MIC LINE OUT Figure 2 3 ARK 3360L IO connectors drawing 13 ARK 3
35. lock This item allows you to enables or disables spread spectrum clock 45 ARK 3360 User Manual e 161deuy9 sbuines sola 3 7 2 South Bridge Chipset Configuration BIOS SETUP UTILITY USB Functions 8 USB Ports Figure 3 27 South Bridge Configuration m USB Functions Disabled 2 USB Ports 4 USB Ports 6 USB Ports or 8 USB Ports m USB 2 0 Controller Enables or disables the USB 2 0 controller m Internal LAN3 Bootroom Enables or disables internal LAN boot with LAN3 m Internal LAN2 controller Enables or disables the internal LAN controller with LAN2 m Internal LAN2 Bootroom Enables or disables internal LAN boot with LAN2 GbE controller Enables or disables the GbE controller with LAN1 GbE LAN Boot Enables or disables GbE LAN boot with LAN1 m GbE Wake Up From S5 Enables or disables GbE LAN wake up from S5 function HDA Controller Enables or disables the HDA controller SMBUS Controller Enables or disables the SMBUS controller m SLP S4 Min Assertion Width This item allows you to set a delay of sorts ARK 3360 User Manual 46 3 8 3 8 1 3 8 2 3 8 3 Exit OS BIOS SETUP UTILITY Main Advanced PCIPnP Boot Security hipset Exit Options Exit systen setup HO rit si ile changes Discard Changes and Exit Discard Changes F10 key can be used for this operation Load Optinal Defaults Load Failsafe Defaults Select Screen TL Select Item Enter Go to Sub Screen F1 General Help F18 Save
36. ndicators on the front side to show its Active Link status Green LED and Speed status Yellow LED 8 1 UNA Figure 2 6 Ethernet connector Table 2 4 Ethernet Connector Pin Assignments Pin 10 100 1000BaseT Signal Name TX TX RX MDI2 MDI2 RX MDI3 MDI3 OO NOOP OIPD 15 ARK 3360 User Manual 2 3 1 3 Audio Connector ARK 3360 offers stereo audio ports by three phone jack connectors of Line_Out Line In Mic In The audio chip is controlled by ALC888 and it s compliant with Aza lea standard Figure 2 7 Audio connector Table 2 5 Audio Connector Pin Assignments Pin Audio Signal Name 1 Mic In 2 Line Out 3 Line In 2 3 1 4 DIO Connector ARK 3360F provides one phoenix 10 pin male connectors and ARK 3360L provides one DSUB 9 pin female connectors which offer Digital Input Output communication interface If client want to use DIO please find the Pin assignment as following ARK 3360L 5432 1 00000 OOOO 9 8 7 6 Figure 2 8 DIO Connector ARK 3360L Table 2 6 DIO Connector Pin Assignments ARK 3360L Pin Signal Name DIO bitO DIO bit1 DIO bit2 DIO bit3 DIO bit4 DIO bit5 DIO bit6 DIO bit7 GND Oo NOV PP Ww hy gt ARK 3360 User Manual 16 2 3 1 5 ARK 3360F 1 10 Figure 2 9 DIO connector ARK 3360F Table 2 7 DIO Connector
37. o select base addresses for serial ports 1 4 m Serial Port3 Port4 Port5 Port 6 IRQ This item allows you to select IRQs for serial ports 1 4 m RS 485 Control for SP2 This item allows you to select RS485 control m SP 3 4 5 6 Auto Direction Control Select This item allows you to enable or disable auto flow control function 3 3 6 ACPI Settings BIOS SETUP UTILITY BEESTE AG 1 C Copyright 1985 2006 American Megatrends In Figure 3 9 ACPI Setting ARK 3360 User Manual 32 3 3 6 1 General ACPI Configuration BIOS SETUP UTILITY General ACPI Configuration Repost Video on S3 Resune No Select Screen 11 Select Item Change Option F1 General Help F18 Save and Exit ESC Exit v02 61 C Copyright 1985 2006 American Megatrends In Figure 3 10 General ACPI Configuration m Suspend Mode Select the ACPI state used for system suspend Report Video on S3 Resume This item allows you to invoke VA BIOS POST on S3 STR resume 3 3 6 2 Advanced ACPI Configuration BIOS SETUP UTILITY Advanced ACPI Configuration Enable RSDP pointers eee To 64 Bit Fixed sten Description Tables Di ACPI APIC support Enabled ACPI version has some AMI OEMB table Enabled Head less mode Disabled Select Screen 11 Select Item Change Option Fi General Help F18 Save and Exit ENG pet v02 61 C Copyright 1985 2006 American Megatrends Inc Figure 3 11 Advanced ACPI Configuration 33 ARK 3360 User Manual m
38. rge during the warranty period For out of warranty repairs you will be billed according to the cost of replacement materials service time and freight Please consult your dealer for more details If you think you have a defective product follow these steps 1 Collect all the information about the problem encountered For example CPU speed Advantech products used other hardware and software used etc Note anything abnormal and list any onscreen messages you get when the problem occurs 2 Call your dealer and describe the problem Please have your manual product and any helpful information readily available 3 If your product is diagnosed as defective obtain an RMA return merchandise authorization number from your dealer This allows us to process your return more quickly 4 Carefully pack the defective product a fully completed Repair and Replacement Order Card and a photocopy proof of purchase date such as your sales receipt in a shippable container A product returned without proof of the purchase date is not eligible for warranty service 5 Write the RMA number visibly on the outside of the package and ship it prepaid to your dealer Declaration of Conformity FCC Class A Note This equipment has been tested and found to comply with the limits for a Class A digital device pursuant to part 15 of the FCC Rules These limits are designed to provide reasonable protection against harmful interference when the equipment
39. rovides vibration and dust resistance while also pro viding a passive cooling solution The ARK 3360 gives system integrators with a turn key solution and versatile application development path without breaking the bank or missing time to market deadlines The ARK 3360 can be used as a standalone system wall or DIN rail mounted The system accepts a wide range of DC power in for ARK 3360F only and comes in a footprint of only 264 5 x 69 2 x 137 25 mm 10 41 x 2 72 x 5 4 The rugged cast aluminum case not only provides great protection from EMI shock vibration cold and heat but as we mentioned before passive cooling for quiet fanless operation The ARK 3360 answers demands by offering 1 x VGA 6 x USB 2 0 ports up to 3 x Giga LAN port and 6 x COM ports packed into a small rugged unit and powered by an Intel Atom processor It also supports a wide range of input voltages from 12 VDC to 24 VDC for ARK 3360F only The ARK 3360 Compact Embedded Computer supports both 2 5 SATA HDD and Compact Flash card for storage options and it pro vides for diversified application fields 1 2 Product Feature 1 2 1 General m CPU Intel Atom Processor N450 D510 1 66 GHz m System Chipset Intel Atom M N450 D510 ICH8M m BIOS AMI 16 Mbit Flash BIOS System Memory DDRII 667 MHz up to 2 GB m SSD Supports CompactFlash Card TYPE VII m Watchdog Timer Single chip Watchdog 255 level interval timer setup by soft ware m 1 O Interfac
40. ttom of the main board BE Figure 2 20 Install the memory module into the SO DIMM socket at the bottom of the Main board 3 Replace HDD door and secure with screws 21 ARK 3360 User Manual 2 4 3 CF Card Installation 1 Unscrew the CF door screws Figure 2 21 Unscrew the CF door screws 2 Pull the CF tray out Figure 2 22 Pull the CF tray out ARK 3360 User Manual 22 3 Remove the black CF bracket Figure 2 23 Remove CF bracket 4 Put CF on to the CF tray Figure 2 24 Put CF onto the CF tray 5 Push the CF tray back and secure with screws 23 ARK 3360 User Manual ARK 3360 User Manual 24 BIOS Settings This chapter introduces how to set BIOS configuration data 3 1 AMIBIOS has been integrated into many motherboards for over a decade With the AMIBIOS Setup program you can modify BIOS settings and control the various sys tem features This chapter describes the basic navigation of the ARK 3360 BIOS setup screens BIOS SETUP UTILITY Figure 3 1 Setup Program Initial Screen AMPs BIOS ROM has a built in Setup program that allows users to modify the basic system configuration This information is stored in battery backed CMOS so it retains the Setup information when the power is turned off Entering BIOS Setup Turn on the computer and check for the patch code If there is a number assigned to the patch code it means that the BIOS supports your CPU If there is no n
41. tures Setup Select the Advanced tab from the ARK 3360 setup screen to enter the Advanced BIOS Setup screen You can select any of the items in the left frame of the screen such as CPU Configuration to go to the sub menu for that item You can display an Advanced BIOS Setup option by highlighting it using the lt Arrow gt keys All Advanced BIOS Setup options are described in this section The Advanced BIOS Setup screens is shown below The sub menus are described on the following pages 27 ARK 3360 User Manual TUP UTILITY gt CPU Configuration 3 3 1 CPU Configurati Figure 3 4 CPU Configuration Setting Max CPUID Value Limit This item allows you to limit CPUID maximum value sm Execute Disable Bit Capability This item allows you to enable or disable the No Execution page protection technology m Hyper Threading Technology This item allows you to enable or disable Intel Hyper Threading technology ARK 3360 User Manual 28 m Intel SpeedStep Tech When set to disabled the CPU runs at its default speed when set to enabled the CPU speed is controlled by the operating system E Intel C STATE tech This item allows the CPU to save more power under idle mode m Enhanced C States CPU idle set to enhanced C States disabled by Intel C STATE tech item 3 3 2 IDE Configuration BIOS SETUP UTILITY IDE Configuration Disabled Legacy IDE Channels SATA Pri PATA Sec Compatible Enhanced Primary IDE Master
42. umber assigned to the patch code please contact an Advantech application engineer to obtain an up to date patch code file This will ensure that your CPU s system status is valid After ensuring that you have a number assigned to the patch code press lt DEL gt and you will immediately be allowed to enter Setup ARK 3360 User Manual 26 3 2 3 2 1 3 3 Main Menu When you first enter the BIOS Setup Utility you will enter the Main setup screen You can always return to the Main setup screen by selecting the Main tab There are two Main Setup options They are described in this section The Main BIOS Setup screen is shown below BIOS SETUP UTILITY Figure 3 2 Main Setup Screen The Main BIOS setup screen has two main frames The left frame displays all the options that can be configured Grayed out options cannot be configured options in blue can The right frame displays the key legend Above the key legend is an area reserved for a text message When an option is selected in the left frame it is highlighted in white Often a text message will accom pany it System Time System Date Use this option to change the system time and date Highlight System Time or Sys tem Date using the lt Arrow gt keys Enter new values through the keyboard Press the lt Tab gt key or the lt Arrow gt keys to move between fields The date must be entered in MM DD YY format The time must be entered in HH MM SS format Advanced BIOS Fea
Download Pdf Manuals
Related Search