BK540 User Guide
Contents
1. User Guide araca HAMLET For stove ranges Camborne Deluxe Generation 2 Hardy 4 amp 5 Series 4 Solution Series 2 PLEASE RETAIN THIS GUIDE FOR FUTURE REFERENCE EN 13240 2001 AN Amd A2 MADE IN BRITAIN February 2013 HAMLET More than 20 years experience has been put into the development of our stoves to ensure ultimate performance and years of trouble free use and enjoyment Every detail of the stove has been carefully designed and engineered which is why we are so confident in the reliability of our products Should you have any questions about our stoves that are not covered by this manual please contact the Arada retailer in your area or call our technical support department on 08448 567181 All Arada stoves are tested to European Standard EN 13240 WARNINGS Pure Petroleum coke or Bituminous house coal must not be burned in this appliance The use of these fuels will invalidate the appliance guarantee Arada recommends the use of HETAS approved smokeless fuels which have been deemed suitable for use on closed appliances including multi fuel stoves If in doubt contact The Solid Fuel Association telephone 0845 601 4406 01773 835400 or visit www solidfuel co uk It is a legal requirement that the installation of all new or replacement wood or solid fuel heating appliances must obtain building control approval from your local authority This can be done by using a qualified heating2. Fig 2 Fig 2 Fully Closed Position AIRWASH SYSTEM SECONDARY AIR The airwash system is located either at the top of above the fire door Sliding the control knob to the RIGHT as far as it will go achieves the fully Open position see Fig 3 Fig 3 Airwash Fully Open Position Hamlet User Guide Sliding it to the LEFT will shut off the air inlet slots as shown in Fig 4 8 8 fT Fig 4 Airwash Fully Closed Position BURNING WOOD e Set the fire by using scrunched up newspaper and place a layer of dry kindling wood on top of this e The use of two or three fire lighters may assist to light the kindling e Set the primary air and airwash controls to the fully open position e After the kindling has caught light you should leave the fire door ajar by about 20mm This will aid flue draw e The flue draw should be established after five minutes and the kindling well burnt down to form an ember bed e Carefully load the stove with well seasoned wood and close the fire door e After ten to fifteen minutes regulate the airwash control typically reduce to approximately half way e Close the primary air control as generally no air from below the grate is required when burning wood Visit our Youtube channel for our how to series of videos http www youtube com aradastoves Hamlet User Guide USER GUIDE Please Note The high temperature paint acquires durability by being cured duri
3. a TEN YEAR GUARANTEE against splitting or cracking of the main body The main body being defined as the steel outer casing and items fixed immovably to the casing All other parts which would be subject to normal wear or tear are excluded from this guarantee These include the firebox liner panels fuel retainers throat plate door rope door glass grate bars gaskets hotplate and spigot This guarantee shall not apply to any stove that has been altered in any way or which in our professional judgement has been subjected to misuse neglect accident abuse and excessive wear and tear The guarantee is conditional upon the appliance being serviced and checked annually by a qualified heating engineer with documentation to be retained and produced in the event of a claim being made Claims are not valid where installation does not conform to appropriate building regulations The manufacturers decision shall be final However if your appliance proves to be defective as a result of faulty materials or workmanship during the guarantee period we will repair or replace it FREE OF CHARGE Use of spare parts other than those supplied by Arada will invalidate the appliance warranty Arada will not be responsible for any consequential or incidental loss damage or injury however caused All guarantee periods commence on the date of purchase and are non transferable Our guarantee is offered as an addition to your statutory rights If you think
4. engineer affiliated to a government approved competent persons scheme such as operated by HETAS If in doubt contact HETAS limited telephone 0845 634 5626 or visit www hetas co uk A fireguard conforming to BS 8423 2002 should be used in the presence of children and old or infirm people Do not use aerosol sprays or any other flammable materials near the appliance in use Arada Ltd will not be responsible for any consequential or incidental loss or injury however caused Arada has a policy of continuous product development and therefore we reserve the right to amend any product specification without prior notice Hamlet User Guide OPERATING YOUR STOVE Hamlet stoves are designed to be operated with the fire door s closed at all times apart from re fuelling when alight or cleaning when cold Never leave the appliance unattended for an extended length of time with the door s open FUEL TYPES WOOD Any type of wood is suitable provided it is well seasoned and has a moisture content below 20 This usually implies that the timber has been suitably stored to allow moisture to evaporate for at least nine months in the case of soft wood and at least twenty four months in the case of hard wood We recommend that for general burning wood should be split into logs of no more than 100mm 4 diameter WARNING Wet wood must not be used as this will greatly contribute to the creation of tar and creosote which may in extreme c
5. ases run down the chimney in liquid form This will seriously damage both the chimney and the appliance and increase the risk of a chimney fire Please Note If you have sticky tar inside the appliance or chimney your wood is green or too wet PAPER Paper will burn successfully Burn dry paper only or chimney damage will occur WARNING Never burn plastics household waste or liquid fuels in your stove Hamlet User Guide USER GUIDE SOLID FUEL Arada recommends the use of HETAS approved smokeless fuels which have been deemed suitable for use on closed appliances including multi fuel stoves These include Homefire Ecoal Homefire Ecoal Instant Light Taybrite Homefire Newflame Homefire Ovals Maxibrite Supertherm Sunbrite Ancit Pureheat Phurnacite SOLID FUEL ASSOCIATION VP HETAS For additional advice on fuels please refer to The Solid Fuel Association LIGHTING THE FIRE Prior to lighting the stove for the first time check with the installer that e Installation and all building work is complete Refer to the installation guide e he chimney is sound has been swept and is free from obstruction e Adequate provision for combustion air has been made i e a permanent vent of at least 550mm sq per kW of rated output above 5kW is fitted in the room in which the appliance is installed e hat Building Regulations and any local USER GUIDE by laws have been followed during install
6. ation See separate installation guide e All firebox liner panels and throat plate are in place e That the chimney draw has been checked and Is within specification With the chimney warm the draught should be between 1 2 mm water gauge or 0 1 to 0 2 mbar e A Carbon Monoxide detector is correctly installed in the same room as the appliance WARNING An over drawing chimney can cause over firing resulting in damage to the appliance Ensure that you have read and understood these instructions before lighting the fire Always wear suitable protective fire gloves when refuelling your stove such as the Arada glove supplied with your stove AIR INLET CONTROLS If you have a DEFRA stove model please refer to page 6 for instructions on operating the air controls Your stove has two air inlet controls These may be located either on the stove body or the door The primary air inlet providing under draught to the base of the fire chamber and the airwash system secondary air providing overdraught The exact controls may differ from those illustrated in this manual but will work in the same way PRIMARY AIR Air enters the appliance through the control on the bottom of the fire door Your stove has a single control knob which slides left to right Sliding the knob to the right see Fig 1 will increase the amount of air intake to the stove Fig 1 Fully Open Position To decrease push the slider to the left see
7. ches 404 16 J99 22 Height to centre of rear flue mm inches 37 0 142 387 151 4 409 16 423 163 4 423 1693 4 434 17 424 163 4 449 1 71 2 485 19 479 1839 4 Depth into fireplace mm inches 22S 7s 362 4 4 Depth from back to centre of top flue mm inches 93 5 33 4 vou ud 103 4 103 4 105 41 4 141 572 94 384 109 41 2 103 4 141 51 2 Depth of front fascia mm inches S576 127 Oe Depth from back to centre of top flue Minimum distance to combustible Mean Flue Mean CO Add in Output to Output to materials mm Flue Diameter Nett Gas Emissions Boiler Room Water TO mm inches Efficiency Temperature 13 02 If Available KW T 102 4 AIB7 2 8 1 2 102 4 AIBO 3 2 1 8 102 4 AIBO 32 1 8 127 5 AIB8 3 2 127 5 AIB9 5 4 2 6 152 6 AIB10 7 6 3 4 625 525 102 4 74 7 306 0 58 AIBO 3 2 1 8 650 450 127 5 72 1 363 0 58 AIB8 4 2 50 500 127 5 71 6 364 0 68 AIB9 6 4 2 6 800 500 152 6 74 7 670 0 71 AIB10 7 6 3 4 Mean Flue Mean CO Nett Gas Emissions Flue Outlet Efficiency Temperature 13 02 Rectangular MGE 80 176 26 0 50 30 Sloping 72 1 346 0 58 Flue Final Factory Check list Quality Finish Model Hot Plate Fuel Retainer Firebox Liners Throat Plate Door Catch Door Handle Operating Tool Stove Glove Grate Fuel Bed Installation Guide Assembled BY sisictureenatoteasasc
8. eestaseurs Gia ced ole MM We recommend recording where and when you purchased your stove for future reference he Fireworks Weycroft Avenue Axminster Devon EX13 SHU www aradd uk com q rg a www aradastovesandspares com BK540
9. fuels WARNING The ash can be very hot Empty only info a metal container Even if the ash appears cold red hot embers may be concealed and could easily start a fire or cause an injury Hamlet User Guide USER GUIDE MAINTENANCE SUMMER STORAGE NON USAGE Please ensure that your stove is left clean and moving components are well lubricated for the summer months during periods of prolonged non use If possible store the throat plate outside of the stove Check all moveable components at regular intervals to ensure they are moving freely Allow air movement through the stove by opening the airwash and primary air inlet control s to about half way open or leave the door ajar This will allow a free flow of air through the appliance thus preventing moisture and condensation forming inside the stove and chimney This preventative maintenance will ensure your stove stays in the best condition for the coming winter months ADJUSTING THE DOOR HINGES Once the appliance has been under fire for a period of time the fire door may appear to have moved out of alignment with relation to the door aperture or catch This is quite normal and due to the settling of the casting he fire door can be re aligned as follows 1 When the appliance is cold open the fire door so that it is at right angles to the front of the stove 2 Lift the fire door up off its hinges 3 Gently tap the hinge pins to compensate for the misalignment 4 Re fit t
10. he door and check to ensure it now sits square to the body if not repeat the above steps If the fire door needs to be raised please follow the instructions below 1 When the appliance is cold open the fire door so that it is at right angles to the front of the stove 2 Lift the fire door up off the hinges 3 Drop one washer on the top and bottom hinge pins Fit the door and check REPLACEMENT PARTS As a leading manufacturer we are conscious of being ps arada online able to support all our stove users with the supply of spare parts to ensure your continued enjoyment and warmth from your Arada stove You can find a complete list of spares and consumables such as liners grate bars and throat plates as well as items to enhance its visual appearance and efficiency such as Arada touch up En As x F aerosol cans and rope kits eaccessores Multi Fuel Stove Spares Electric Stove Sr S sas Stove Spares ilti Fuel Stove Spares ir C hP ray j A e Bar Supports and Locks Air Controls Ash Pans n amp Grate Bar Supports All the above can be ordered from you local stove dealer or online direct from Arada at vars LI www aradastovesandspares com 8 Hamlet User Guide GUARANTEE Once again we would like to thank you for buying a Hamlet stove When you buy a Hamlet stove you are not only buying a first class appliance you are buying a commitment from us to look after you and your appliance Hamlet stoves comes with
11. indows to ventilate room e Let the fire die or extinguish and safely dispose of fuel from the appliance e Check for flue or chimney blockage and clean if required Seek expert advice from your HETAS registered installer Do not attempt to re light the fire until the cause of the fume emission has been identified and corrected MULTI FUEL GRATE The grate in your Hamlet stove comprises of a series of reciprocating cast iron bars seated on a pivoted comb These should come pre assembled in your new stove All bars in the grate are identical but every other bar is turned 180 degrees with the ends of the bars marked H sitting on the high sec tions of the comb and the ends marked L sitting on the low sections The riddling lever either on the side or front of the stove can be operated with the stove operating tool to riddle ash into the ash pan below Only riddle the stove with the door closed and stop once red embers begin to fall into the ash pan After extended use it may be necessary to replace some of the grate bars Periodic inspection of the bars is recommended and any damaged bars replaced Also check for obstructions that may prevent the operation of the riddling mechanism DOOR GLASS The door glass should remain clear during normal burning However under certain conditions such as burning at a low rate or using damp wood or overnight burning the glass may become somewhat blackened To remedy this o
12. ng the initial firings of the appliance It will give off fumes which are non toxic but certain persons may find they have an unpleasant or irritant effect Ensure that the surrounding area is well ventilated during this time BURNING SOLID FUELS Only applicable to multi fuel stoves e Set the airwash to one quarter open e Set the primary air inlet to fully open e Light as with wood with kindling and fire lighters e Once flue draw has been established after about five minutes carefully load the stove with fuel and close the door e When the fire is well alight regulate the burning rate by controlling the primary air inlet control e The airwash should be opened sufficiently to keep the door glass clean Whilst burning solid fuel if can be beneficial to occasionally riddle the grate bars so any burnt fuel will fall between the grate bars into the ash pan below This will ensure a good under draught is maintained WARNING Properly installed with a suitable flue or chimney operated and maintained correctly this appliance will not emit fumes into the dwelling Occasional fumes when de ashing and re fuelling may occur However persistent fume emission is potentially dangerous and must be investigated by a HETAS registered installer USER GUIDE Stop using the appliance if you smell fumes or see smoke escaping If fume emission does persist the following immediate actions should be taken e Open doors and w
13. perate the appliance at a fast rate Alterna tively when the stove Is cold open the door and clean the inside face of the glass with a damp cloth or with glass cleaner available from stove stockists and online at www aradastovesandspares com REDUCED BURNING When wood is burnt slowly in a closed appliance it produces moisture and tar which will create condensation and deposits in the chimney This effect can be minimised by burning hard for a short period fifteen to twenty minutes twice a day Please Note To avoid chimney problems your appliance should not be burnt at a reduced burn rate without a period of fast burning OVER FIRING amp CHIMNEY FIRES DO NOT over fire your appliance Firing the stove at maximum for prolonged periods may result in over firing If the chimney connector or casing glows red the appliance is being over fired this may result in a chimney fire ASH REMOVAL The appliance will require ash to be removed periodically but an ash bed of approximately 20mm 3 4 should be maintained Care must be taken not to burn hands or household objects with falling embers Hamlet User Guide The ash pan should be emptied when the level of ash reaches the top of the ash pan On no account should the ash be allowed to build Up To touch the underside of the grate bars as this will greatly reduce the life soan of the grate The ash will require less frequent removal when burning wood compared fo solid
14. your stove is not operating correctly please call your local Hamlet dealer who will have the knowledge and facilities to help you When you call your dealer they will want to know 1 Your Name address post code and telephone number 2 Clear and concise details of the fault 3 Proof of purchase installation and annual servicing will also be required If further information is required our technical helpline will be pleased to help Please telephone 0844 8475107 or email info arada uk com Hamlet User Guide 9 Technical Specifications Freestanding Description Hardy 4 Series 4 Hardy 5 Series 4 Camborne Deluxe Compact Generation 2 Camborne Deluxe Small Generation 2 Camborne Deluxe Medium Generation 2 Camborne Deluxe Large Generation 2 Solution 5 Series 2 Solution 7 Series 2 Solution 9 Series 2 Solution 11 Series 2 Inset Models Description Solution 5 Inset Solution 7 Inset Output Height kW mm inches 1 4 458 18 Ls 4 5 19 505 20 js 530 2094 Zo 392 Apo Z9 1 292 Ze as 522 T0 Pone 558 22 2 600 512 2 9 605 2239 4 Output Height kW mm inches io ADR PIS kosy 590 231 4 Width mm inches 3007 13 370 14 2 394 1512 477 1898 4 586 23 5 2 261 2 397 Se 47 6 1898 4 586 23 6 2 261 2 Width mm inches Sy 22 9 2 2202 Depth mm inches 323 1298 4 333 13 377 14 4 386 15 382 15 467 1812 388 5 4 386 15 396 5 2 442 1712 Depth mm in
Download Pdf Manuals
Related Search