Shorai BMS01 User's Guide
Contents
1. 60 state is reached will re charge to 80 level and so on This range is ideal for lithium iron storage LFX crank vehicles strongly even if well below 60 capacity state however for the best performance and longest life span press the charge button to fully charge the battery before use Charge Mode The BMSO1 charge mode charges at 2A peak rate while balancing the internal LFX cells and performing battery diagnostics Charge completion will typically occur within 30 minutes to 4 hours depending on the size and state of the battery at charge start When the battery voltage reaches 14 4V the charging process is complete and the BMSO1 unit will beep several times the light will turn solid green and then power off within 30 seconds Important after charging is complete disconnect the charger from the battery to help maintain a high state of charge Ready Mode Both Solid STORE CHARGE Charge Complete Solid Green sure asive Festina Yetow E O OTO Store Maintain Solid Yellow or Condition Fisting Toeter RE WE 1 When the AC power cord is first plugged to AC power each LED will turn on solid to indicate charger READY for input Note If a button is not pressed within 30 seconds the charger will power down Charge Active Flashing Green i Ts 4 2 When the LFX battery is above 50 capacity at the START of CHARGING only the Green LED will flash However if below 50 capacity at the start of charging the yellow2. Shorai BMS01 User s Guide Wp Battery Management System Rev 032015 for LFX Lithium Iron Batteries See http www shoraipower com Support tab for video and extended photo battery install guides and FAQ for information on charging and other topics LFX BATTERY CAUTIONS e Do not short battery terminals together Remove all jewelry ring bracelet necklace watch etc before working near batteries or chargers Do not short the 5 pin BMS port Attach ONLY Shorai Chargers to the BMS port Do not open or allow damage to the battery case Keep batteries away from pets and children Do not allow LFX discharge below 13 0V resting Fully discharge LFX battery before disposal recycle connect a 12V bulb until light is out for example BMS01 CHARGER CAUTIONS e BMSO0O1 are for charging and storage of Shorai LFX Lithium Iron batteries ONLY e Connect BMSO1 AC Input plug to 100V 250V 50 60Hz single phase AC wall socket only e Never allow the charger to become wet Keep out of snow rain and highly humid environments e Chargers damaged by impact moisture or any other cause must NOT be used e Use the built in retractable hook to hang BMS0O1 off the floor whenever possible e Keep 5 1 5M minimum clearance from flammables around battery or vehicle during charge or store mode e Keep charge output cable connectors clean and dry Apply an anti corrosion electrical grease if in salty humid or wet environments e Replace cha
3. and green LED will flash alternately This warns you that the battery has been allowed to drop low in voltage and you may need to charge more often or use Store Mode while parked long term To correct this condition press the charge button a triple beep indicates the charger is active and the lights continue to alternate Once the battery reaches 50 capacity the charger returns to flashing green only 3 Errors are indicated by a flash pause sequence of both LED flashing together An alarm buzzer may also sound until error is corrected or power off e 1 flash pause Internal input voltage error Check that AC power is in range and properly connected Try another outlet e 2 flashes pause Polarity error Not typical e 3 flashes pause Open Circuit Charge cables not properly connected broken or worn Inspect and or try new cable set e 4 flashes pause Battery Cell voltage error Cell variation issue use the store mode for 24hrs then charge to correct issue WARRANTY North America Shorai Inc offers a Limited One Year Warranty for Shorai BMSO1 chargers and BMSO1 accessories solely for defects in material and or workmanship All warranty claims for North American sales are handled directly by Shorai Inc USA See http www shoraipower com rma for online submission of warranty claims and Return Merchandise Authorization RMA assignment Please do NOT return any product without an RMA or before Shorai has con
4. point you should have the battery charge cable connected to the battery BMS port and the AC input cord connected to the charger Now insert the AC plug into an appropriate AC wall socket Whenever possible use the charger s retractable hook to hang the BMS0O1 above the floor in a location which allows easy access to the battery charge cable Now plug the battery charge cable into the correct LFX charge output port or into the extension cable The charger will beep a few times when the LFX battery is connected to the charge cable and you should see both the yellow Store and green Charge LED on solid indicating that the charger is ready for input After pressing either the store or charge button you will hear a triple beep which indicates the charger is active Note If a button is not pressed within 30 seconds the charger will power down To turn the BMSO1 on press the charge button The photo above shows the two operation buttons and their corresponding LED indicators Store Mode The BMSO1 Store Mode is optimized to maintain Shorai LFX batteries for best lifespan and performance Once Store Mode has been started the BMS0O1 can remain attached to the LFX battery and wall power indefinitely until the vehicle is to be used again When Store Mode is activated the BMSO1 will either charge or discharge the LFX battery until an approximate 80 charged state is reached At that point the BMSO1 will monitor capacity and when
5. rge output cables after 1200 connect cycles e BMSOl1 has 6V and 12V Output Ports Only one type 12V OR 6V may be used at a time Again only ONE output port can be cabled at any time BMS01 BOX CONTENTS Shorai BMSO1 with Charge amp Store modes AC input cord US EU or UK version per sales location Battery Charge Cables for 12V Charge Extension Cables for 12V This User s Guide SETUP Remove the BMSO01 charger AC Input cord and the two charge cables from the packaging and attach the AC Input power cord to the AC port shown below d EEO MD LEE LEE a eee a DAFF a a SF EF ra ae is Pa F z 3 i Fi PE MERS E F E al j na 5 F z F j Fa E Note that the small 3 pin port to right of the AC Input is reserved for factory diagnostics and should never be used modified or have anything attached to it The BMSO1 is supplied with a long and short cable for 12V LFX cables for the 6V LFX batteries are sold separately The longer cable can be permanently attached to the battery via its 5 pin connector which is labeled to battery and tied off at a convenient location on the vehicle where it is protected from water and damage The opposite end of the cable can be plugged directly into the BMS01 charger output port if it is long enough to reach If extension is required the shorter cable in the set can be used for that purpose The 12V 6V charge ports are shown below SS i i At this
6. tacted you to perform some simple diagnostics In many cases issues can be solved prior to return Conditions NOT Covered e Physical Damage occurring after purchase impact water moisture salt corrosion etc e Improper AC input voltage or phase e Connection to other than Shorai LFX batteries e Short circuit of output ports Returns MUST be accompanied by A copy of Original Dealer Receipt or Shorai Order ID Shorai Issued RMA Returns without Receipt and or RMA can only be replaced at 30 discount from Shorai MSRP suggested retail price plus return shipping charges Products found NOT defective after in house testing at Shorai can only be returned to customers at their expense for shipping Customers are responsible for paying initial shipping charge to return any warranty claim BMSO1 Shorai Inc will pay shipping on replacements returned to customers except those without copy of receipt and or RMA Note that for any Shorai product which is purchased from a North American dealer or Shorai Inc USA and shipped to an end user outside North America ALL shipping costs related to warranty claims are the responsibility of the user NON WARRANTY RETURNS Any merchandise in new condition and originally purchased via the Shorai website may be returned to Shorai Inc within 30 days of purchase For as new returns to other sellers please consult your seller for their terms Merchandise must be accompanied by a Re
7. turn Authorization Number copy of receipt or order number and all original packaging in new condition Refunds will be granted less the original shipping cost A restocking fee may be assessed or refund entirely refused in case the product or packaging is damaged depending on severity Input Voltage 100V 250V 50 60Hz single phase AC Weight w o cables 720g 1 58 lbs Dimensions L x W x H 11 4 x11 4 x 3 8cm 4 5 x 4 5 x 1 5 100V 250V AC Input SHIPPING DAMAGE Any item damaged in transit must be reported to the SHIPPER IMMEDIATELY upon opening of the package and also Shorai Inc All original packaging must be retained until further notice Shorai will respond with instructions ASAP after consultation with the shipping agent retractable hook Thank you for choosing Shorai We hope and expect that you ll be pleased with the performance of our products for years to come Do be sure to contact us if you have questions problems or suggestions we re here to help weather resistant pe cover SHORAI INC 16020 Caputo Drive Suite 100 Morgan Hill Ca 95037 USA P the free end of battery TEL 408 720 8821 a Cable ma Li fect tO aar Lal port arie FAX 408 720 1537 extension cable end battery side cable may remain on vehicle order return inquiries shop shorai org technical questions racetech shorai org
Download Pdf Manuals
Related Search