OPERATING INSTRUCTIONS FOR WESSAMAT ICE CUBE
Contents
1. 18627 limit switch 34310A chain wheel motor shaft 32314 gear motor 34140 tension spring 43205 plexiglass lid 4 Wiring Diagram S1 S2 S3 FE OQ OQ NX NN bg C1 230 V 50 Hz Legend S1 on off switch S2 limit switch filling lid S3 limit switch ice container C1 operating capacitor 5uF M1 gear motor BA C105_e 10 03 2004 18 10 2011 page 22. the machine or actual values The machine shall only be used e for operation in accordance with instructions e if in technically safe and unobjectionable condition Troubles which may impair safety shall be eliminated immediately 1 5 Warranty and Liability On principle our General terms and conditions are applicable The latter are available for the user of the machine as of conclusion of the contract at the latest Warranty and liability claims for injuries to persons and property damages are excluded if they are not to be attributed to one or more of the following causes e operation of the machine not in accordance with instructions e improper installation initial operation operation and maintenance of the machine e operation of the machine with defective safety appliances or not properly installed or unoperable safety and protection devices non compliance with the directions of the operating instructions arbitrary modifications of the machine insufficient inspection of machine parts subject to wear and tear improperly performed repairs emergencies due to foreign matter and acts of God 1 6 Structural Modifications of the Machine No modifications alterations or attachments to the machine shall be made without written approval by the manufacturer In case of non compliance the manufacturer s warranty expires Change all parts of the machine which are not in an efficient shape Use only original spare parts Other spare part
3. OPERATING INSTRUCTIONS FOR WESSAMAT ICE CUBE CRUSHER C 105 1 Basic Safety Instructions 1 1 Proper Use The ice cube crusher is solely meant for crushing of small ice cubes For crushing only the ice cubes produced of ice cube makers should be used not the deep frozen one s Proper use shall also comprise observation of all directions of the operating instructions 1 2 Setting Up The ice cube crusher shall not be used in the following surroundings surroundings exposed to explosion hazards toxic atmospheres humid rooms CAUTION Under certain ambient conditions e g high ambient temperature and or high humidity there can be formation of condensation water in the area of the ice cube crusher 1 3 Adherence to Directions of the Operating Instructions A basic prerequisite for safe handling and troublefree operation of this machine is the knowledge of the basic safety instructions and safety regulations These operating instructions particularly the safety instructions shall be observed by all persons operating the machine In addition the accident prevention rules and regulations valid at the place of installation shall be observed 1 4 Hazards when Handling the Machine The ice cube crusher was built in accordance with the state of technique and the approved technical safety rules Nevertheless use of this machine can cause threats for life and limb of the person using the machine or third parties respectively result in impairment of
4. s do not guarantee to work correctly concerning security and wear and tear Otherwise the manufacturers warranty expires 2 Operation 2 1 Setting Up The machine shall be set up on a firm and horizontal subbase Unevennesses can be compensated by the vertically adjustable legs BA C105_e 10 03 2004 18 10 2011 page 1 operating instructions WESSAMAT Eismaschinenfabrik GmbH 2 2 Electrical Connection The ice cube crusher is delivered ready for connection and operates with alternating voltage of 230 V 50 Hz 2 3 Operation Open plexiglass lid and fill in ice cubes up to max 80 of the total capacity Completely slide the ice collecting container into the ice crusher and shut plexiglass lid Operate rocker switch and hold down until the desired quantity of ice has been crushed Caution For reasons of safety the ice cube crusher only operates when the ice collecting container has been slidden in completely and the plexiglass lid is shut 2 4 Safety Instructions The ice cube crusher may only be operated with completely slidden in ice collecting container The unit may only be operated with the enclosed sheet metal plate underneath the ice collecting container Never block the limit switches 3 Spare Parts 34330 drive chain 31410 operating capacitor 40510 outer casing 43444 bearing for shaft 42401 crusher shaft VA 32313 spiral wheel 32102 on off switch 21307 pin 43107 ice container PE 34310 chain wheel crusher shaft
Download Pdf Manuals
Related Search