SERVICE MANUAL REFRIGERATOR Door on Door
Contents
1. Displayed during the temperature setting It disappears 5 seconds after temperature setting is complete Displayed when the temperature in the freezer has been above 8 C and has returned to a lower value Displays the highest temperature in the cabinet after a power failure showed for 5 seconds while pressing the reset button The warning light turns off simultaneously Sensor failure in the freezer 15 16 8 Accessibility cd000864 cd000865 16 162. With this function temperature is automatically set at 3 C for 48 hours If you wish to deactivate the function earlier than 48 hours just press T8 button again 4 2 Balance heater with automatic connection 3 4 STAR The three four star model is provided with a balance heater that connects automatically when NTC sensor S put on the electronic module detects a room temperature above 20 C 13 16 cd000856 5 Refrigeratore L1 L2 D1 cd000862 T1 T2 T3 T4 The description of the functions buttons and leds is the same as the one of the combined bicompressors 6 Freezer L3 L4 L5 D2 cd000863 T5 T6 T7 T8 T9 The description of the functions buttons and leds is the same as the one of the combined bicompressors 14 16 Refrigerator 0 39 steady light 2 8 flashing light o steady light H steady light Li steady light Dar steady light Freezer 39 35 steady light 15 24 flashing light 39 35 flashing light 39 8 steady light m steady light 7 SYMBOLS OF THE DISPLAY Displays the average temperature in the refrigerator Displayed during temperature setting Disappears 5 seconds after temperature setting is complete Displayed if the temperature in the refrigerator is below 0 C Displays the Holiday function Air sensor failure Air sensor failure Displays the highest temperature in the freezer
3. een hear 3 16 1 Presentation In this manual are described the new models of built in door on door refrigerators that will be produced in the factories of Susegana Florence and Kassel Germany This new range of refrigerators has the following main characteristics new cabinet width 556mm against 540mm of the sliding door model new door on door installation system low noise compressor accurate styling availability of the models in electromechanical and electronic version apart from 1780 bicompressor control panel on the top of the appliance cd000866 TA The principal markets are Germany Austria Holland Belgium Swisse Great Britain The principal trademarks are AEG JUNO ELECTROLUX PRIVILEG 4 16 The Door on Door range presents both the electronic and mechanical control system version for every model except for the bicompressor that it is available only in electronic version The models are PNC BASE MODEL TYPE CAPACITY CONTROL litres 922 692 80 FREEZER BI DOD FREEZER 76 ELECTRONIC 922 692 80 FREEZER BI DOD FREEZER 76 MECHANICAL 922 752 110 FREEZER BI DOD FREEZER 109 ELECTRONIC 922 752 110 FREEZER BI DOD FREEZER 109 MECHANICAL 923 415 160 COOLER BI DOD COOLER 157 ELECTRONIC 923 415 160 COOLER BI DOD COOLER 157 MECHANICAL 923 415 190 COOLER BI DOD COOLER 18
4. 1 ON OFF refrigerator D1 refrigerator T2 refrigerator temperature increase L2 coolmatic function D2 freezer T3 refrigerator temperature decrease L3 ON OFF freezer T4 coolmatic function L4 frostmatic function T5 ON OFF freezer L5 alarm T6 freezer temperature increase T7 freezer temperature decrease T8 frostmatic function T9 alarm reset 2 1 1 Start and Switch off of the Appliance To start a compartment you need to press the ON OFF button T1 for the refrigerator and T5 for the freezer It starts immediately To switch off the compartment you need to press the ON OFF button for 1 second The display will show 3 2 1 and then it switches off 2 1 2 Regulation of the Freezer Temperature To change the set temperature in the freezer you need to press the T6 button increase or T7 decrease It is possible to set the temperature from 15 C till 24 C Once you have pressed T6 or T7 button the display flashes for 5 seconds showing the set temperature The display then will indicate a steady temperature which has been detected inside the freezer The start and the switch off of the compressor of the freezer compartment are regulated by the evaporator 8 16 2 1 3 Fast freezing Function By pressing T8 button the fast freezing function activates and it powers the compressor continuously for 54 hours To deactivate the function earlier than 54 hours just press T8 button again The L4 led lights till the freezing function is
5. 7 ELECTRONIC 923 415 190 COOLER BI DOD COOLER 187 MECHANICAL 923 415 230 COOLER BI DOD COOLER 227 ELECTRONIC 923 415 230 COOLER BI DOD COOLER 227 MECHANICAL 923 415 145 BI DOD 3 4 STARS 143 ELECTRONIC 923 415 145 BI DOD 3 4 STARS 143 MECHANICAL 923 415 175 BI DOD 3 4 STARS 173 ELECTRONIC 923 415 175 BI DOD 3 4 STARS 173 MECHANICAL 923415 215 BI DOD 3 4 STARS 215 ELECTRONIC 923415 215 BI DOD 3 4 STARS 215 MECHANICAL 925 700 290 COMBI 2 C BIDOD BICOMPRESSOR 209 76 ELECTRONIC 5 16 cd000851 Freezer cd000854 Refrigerator cd000852 cd000853 Combined bicompressor 3 4 STAR 6 16 1 1 New Door on Door Installation System The characteristics of the new Door on Door installation system are easy installing fast installing no measurement applicability to every cabinet z gt 2 ED 04000859 The installation operations are described in the user manual 7 16 2 Control Functions The combined bicompressor refrigerator is available only in the electronic version 2 1 Combined Bicompressor L1 L2 L3 L4 L5 T 2 T3 T4 T5 T6 T7 T8 T9 Buttons Led Display T1 ON OFF refrigerator L
6. SERVICE MANUAL E Electrolux Technical Support Europe REFRIGERATOR cd000850 Door on Door ELECTROLUX ZANUSSI Publication Number ELETTRODOMESTICI S p A 599 34 44 49 VIA GIARDINI CATTANEO 3 001023 33170 PORDENONE ITALY ITZ SERVICE AA Fax 0434 394096 2 16 TABLE OF CONTENTS PR SENTATION 2 33 28 as an aa ee un ki Er nn NEW DOOR ON DOOR INSTALLATION SYSTEM CONTROL FUNCTIONS u mesrine tent nn lan NA ARE Eee nis COMBINED BICOMPRESSORS u4s4susnennesnsnnennnennennnnnnnnennnnnenennennnn nennen nn sn nn nn START AND SWITCH OFF OF THE APPLIANCE iii REGULATION OF THE FREEZER TEMPERATURE Sins FAST FREEZING FUNCTION 2 24 2 ouate 222 aan sen Saad see are c TEMPERATURE ALARM occiso REGULATION OF THE REFRIGERATOR TEMPERATURE ee eee eee eteens REFRIGERATOR HOLIDAY FUNCTION 0 00 ceeeeeeeeeeeeeeee eee ee eeeeeeeeeaeeaeeeee erent nennen REFRIGERATOR CONTROL is 2 22 1 22 2 LI Rem iii COOLMATIC irae a IA niet eae eats DEMO MODE 34 H ehe eben HichetlenensneNerelemaneen reelle 2 1 100PEN DOOR ALARM nennen blend 3 4 4 1 4 2 NTE SENSOR FAULT lia A Ad on ia THREE FOUR STARS COMPARTMENT iii FAST FREEZING IN THE 4 STAR COMPARTMENT ins BALANCE HEATER WITH AUTOMATIC CONNECTION REFRIGERATOR coord diana pila lei FREEZER e tdo eto de nn SYMBOLS IN THEDISPLAY 2 12 aa reale eier ACCESSIBILITY 2 3 A ee
7. activated 2 1 4 Temperature Alarm The alarm is activated when the temperature reaches 8 C L5 led and the display flash and the buzzer sounds You can switch off the alarm by pressing the T9 button and when the buzzer has stopped the display shows the max reached temperature for 5 seconds and L5 led continues to flash Only when the temperature goes below 8 C also the L5 led will turn off If the alarm condition stops automatically without pressing T9 button the buzzer stops to sound but L5 led and the display will flash By pressing T9 L5 led stops to flash while the display will show the max reached temperature for 5 seconds 2 1 5 Regulation of the Refrigerator Temperature To change the set temperature in the refrigerator you need to press T2 button increase or T3 decrease It is possible to set temperature from 2 C till 8 C Once you have pressed T2 or T3 button the display will flash for 5 seconds showing the set temperature The display then will indicate a steady temperature which has been detected inside the freezer 2 1 6 Refrigerator Holiday Function only in cooler and bicompressor The max temperature you can set in the refrigerator compartment reaches 8 C by pressing T2 button once again after having reached 8 C the symbol H on the display will indicate that the holiday function is activated With this function the refrigerator temperature is maintained at 15 C This temperature doesn t allow
8. activates The inside machine temperature must be above 10 C so that the function can activate The display board is active the light turns on when you open the door but the compressor is switched off 2 1 10 Open Door Alarm The open door alarm is activated through a sensor reed element located on the display board which identifies the presence of a little magnet on the refrigerator door As the picture shows the magnet is replaceable Alarm will turn on after 80 seconds for the freezer door after 5 minutes for the refrigerator door alarm will not be implemented on all models 10 16 3 NTC Sensors Failure The NTC sensors have the following temperature resistance characteristic 100000 90000 80000 IKK EUCH SKKN 40000 30300 20000 10000 co000409 Resistance Ohm 4 20 20 10 D 10 29 30 40 Temperature po Abnormal resistance values will be interpreted as sensor failure and the display will show a signal If a sensor is defective the related compressor will be on for about 30 minutes and off for about 45 minutes All NTC sensors are foamed and therefore cannot be replaced In case of sensors failure Refrigerator defective air sensor the lower part of the thermometer will show the symbol Refrigerator defective evaporator sensor the higher part of the thermometer will show the symbol I Freezer defective sensor freezer the lower part of the thermometer will show th
9. e symbol m aa At extreme temperatures alarm levels can be activated even if the sensors are intact You don t have to consider the failure codes at temperatures above 39 C and below 35 C 11 16 Conversion table for NTC sensors 7 17429 8 24418 8 25862 9 27402 9 29045 56541 I i fie i jit f j A 4 A A A A A A fr AA A A AA A Ir Ir ojojojojojojojojojojojojojojo jojo jojojo joO JO OJOJOo Oo OPN ANS SAO O O OO asa ajaja jajajaa E ea e en ien I i eu I i z SEepEPE I i ojojoj ojom ce A AAA IH e lt ETES ESSE 8 ESEE Bere FE EEE ee 0 RESTES 2 EE Less ae ETE ee 10 REA 14 0 7 15 ETS 18 EXA ETS HENO 22 23 RES 26 28 Ber 32 234 35 40 I 12 16 4 Four Star Compartment L1 L4 L2 TITZ T3 T8 T4 cd000861 Buttons Led T1 ON OFF L1 ON OFF T2 temperature increase L2 coolmatic function T3 temperature decrease L4 frostmatic function T4 coolmatic function T8 frostmatic function The description of the functions buttons and leds is the same as the one ofthe combined bicompressors The only difference is the fast freezing function and the introduction of a balance heater with automatic connection 4 1 Fast freezing function in the four star compartment The function activates by pressing T8 button the jellow L4 led turns on
10. to conserve food but it s very useful when you don t use the refrigerator compartment as it avoids the formation of unpleasant smells To deactivate the function you need to set another temperature so that the H symbol disappears from the display 2 1 7 Refrigerator Control The compressor is activated when both the evaporator and air sensor detect the cut in temperature and is turned off when the temperature detected by the air sensor reaches the cut out temperature With low room temperatures the rest time of the compressor can be extremely long therefore the control sytem sets a max deactivation time of 6 hours With high room temperatures the compressor can activate after a long time or even work continuously if the thermostatic regulation is not adapt therefore the control system sets a max activation time of 18 hours Only for four star compartment by low room temperatures a balance heater is activated automatically through an electronic board provided with a sensor 2 1 8 Fast freezing Function in the Refrigerator COOLMATIC The fast freezing function activates by pressing T4 button and the refrigerator temperature is set automatically at 2 C The function deactivates automatically after 6 hours or by pressing T4 button The yellow L2 led lights as to indicate that the function is activated 9 16 2 1 9 Demo Mode By pressing atthe same time the decrease temperature button and ON OFF one for 5 seconds the demo function
Download Pdf Manuals
Related Search