Nokia 1616 RH-125 126 Service Manual L1L2
Contents
1. Service Manual Level 1 amp 2 5 CARE AND MAINTENANCE This product is of superior design and craftsmanship and should be treated with care The suggestions below will help you to fulfil any warranty obligations and to enjoy this product for many years Keep the phone and all its parts and accessories out of the reach of small children Keep the phone dry Precipitation humidity and all types of liquids or moisture can contain minerals that will corrode electronic circuits Do not use or store the phone in dusty dirty areas Its moving parts can be damaged Do not store the phone in hot areas High temperatures can shorten the life of electronic devices damage batteries and warp or melt certain plastics Do not store the phone in cold areas When it warms up to its normal temperature moisture can form inside which may damage electronic circuit boards Do not drop knock or shake the phone Rough handling can break internal circuit boards Do not use harsh chemicals cleaning solvents or strong detergents to clean the phone Do not paint the phone Paint can clog the moving parts and prevent proper operation Use only the supplied or an approved replacement antenna Unauthorised antennas modifications or attachments could damage the phone and may violate regulations governing radio devices All of the above suggestions apply equally to the product battery charger or any accessory T Confide2. 1 Tighten the six TORX size 6 screws to the torque of 15 Ncm in the order shown 15 Confidential e Copyright 2009 Nokia e All rights reserved Version 1 0 ISSUE 1 NOKIA Care RH 125 RH126 Academy Service Manual Level 1 amp 2 12 SOLDER COMPONENTS Note that these solder components are only applicable to India TOP BOTTOM 16 Confidential e Copyright 2009 Nokia e All rights reserved Version 1 0 ISSUE 1
3. of the and terminals of the battery metal strips on the battery for example when you carry a spare battery in your pocket or purse Shortcircuiting the terminals may damage the battery or the connecting object Leaving the battery in hot or cold places such as in a closed car in summer or winter conditions will reduce the capacity and lifetime of the battery Always try to keep the battery between 15 C and 25 C 59 F and 77 F A phone with a hot or cold battery may temporarily not work even when the battery is fully charged Batteries performance is particularly limited in temperatures well below freezing Do not dispose batteries in a fire Dispose of batteries according to local regulations e g recycling Do not dispose as household waste 8 Confidential e Copyright 2009 Nokia e All rights reserved Version 1 0 ISSUE 1 NOKIA Care Academy 7 EXPLODED VIEW A COVER ASSY 10001 SCREW 1 6x4 5 TORX 6 a 10003 ste LCD MODULE 10007 ste PWB ASSY 10008 DC JACK 10010 N NS MFD BARD A 16x4 5mm Nokia 1616 RH 125 RH 126 Service Manual Level 1 amp 2 KEYMAT ASSY 10002 UI SHIELDING ASSY sfe 10004 KEYMAT LIGHT GUIDE fe 10005 DOMESHEET ASSY se D COVER ASSY ste 10011 TYPE LABEL 10012 B COVER 10013 ofp ONIY available as These parts can not be assembly fl reused after removal 9 Confidential e Copyright 2009 Nokia e All rights reserved Version 1 0 ISSU
4. 9 Nokia e All rights reserved Version 1 0 ISSUE 1 NOKIA Care Nokia 1616 RH 125 RH 126 Academy Service Manual Level 1 amp 2 iS STR er amp Ha rr f OROFO o Was xi rE Ae an Whe a i Saget EENI M 7 Remove the A COVER ASSY 8 Protect the LCD MODULE with protective film PINUS eat Rey aN TEAMS S te coN WN RRON SS De aN od ame 9 Unscrew the six TORX size 6 screws inthe order 10 Lever out the ENGINE BOARD with the SS 93 shown Do not use them again Discard them Start from the left side of the device and continue on the bottom side i ore eee oe o iTS m TR Z TTT Gn 11 Separate the ENGINE BOARD and the D COVER 12 Using the SS 93 release the two clips holding ASSY the UI SHIELDING 13 Confidential e Copyright 2009 Nokia e All rights reserved Version 1 0 ISSUE 1 NOKIA Care RI 125 RH 126 Academy Service Manual Level 1 amp 2 gt k ge AS Pe 7a s vy eo ae Ses 15 Use the DC plug to lift up and remove the DC 16 Lift up the SPEAKER with the SS 93 tool and JACK remove it with the tweezers 17 Separate the KEYMAT ASSY and the A COVER ASSY 18 Nokia 1616 disassembly is now complete by pushing out the KEYMAT ASSY END OF DISASSEMBLY 14 Confidential e Copyright 2009 Nokia e All rights reserved Version 1 0 ISSUE 1 NOKIA Care meet Academy Service Manual Level 1 amp 2 11 ASSEMBLY HINTS
5. E 1 NO KIA Ca re EE Academy Service Manual Level 1 amp 2 8 SERVICE DEVICES BL 5CB NOKIA CA 101 Service Cable BL 5CB Battery AC 3 Travel Charger ard Toolkit V2 NMP standard toolkit v2 For more information refer to the Service Bulletin SB 011 on NOKIA Online Supplier or manufacturer contacts for tool re order can be found in Recommended service SF 204 Flash adapter equipment document on NOKIA Online 10 Confidential e Copyright 2009 Nokia e All rights reserved Version 1 0 ISSUE 1 NOKIA Care RH 125 RH 126 Academy Service Manual Level 1 amp 2 9 SW UPDATE Flash concept Point of Sale Please check always for the latest version of flash software which is available on Nokia Online SERVICE SOFTWARE EE PRODUCT SPECIFIC r Bl ADAPTER 11 Confidential e Copyright 2009 Nokia e All rights reserved Version 1 0 ISSUE 1 NIOKIA Care Rte Academy Service Manual Level 1 amp 2 10 DISASSEMBLY INSTRUCTIONS 1 Nokia 1616 disassembly 2 You must use the Nokia Standard Toolkit version 2 You will also need a DC plug SSP att 3 Use the opening notch to release the BATTERY 4 Start releasing the A COVER ASSY by releasing the COVER Remove the BATTERY COVER bottom corner as shown Vf i vapid iii fe ae Ye a isis y a 4 Then release the other bottom corner 6 Conine eien the top ETA of the A COVER ASSY Start from the corner as shown 12 Confidential e Copyright 200
6. NOKIA Care E Academy Service Manual Level 1 amp 2 SERVICE MANUAL Level 1 amp 2 NOKI t RH 125 RH 126 Transceiver characteristics Band RH 125 EGSM 900 1800 RH 126 GSM 850 1900 Display 1 8 128 x 160 pixels TFT display with up to 65k colors Operating System S30 SB8 Connections 3 5 mm AV connector 2 0 mm DC charger connector Transceiver with BL 5CB battery pack Talk time Standby GSM GSM Up to 8 52 hours Up to 540 hours Note Talk times are dependant on network parameters and phone settings 1 Confidential e Copyright 2009 Nokia e All rights reserved Version 1 0 ISSUE 1 NOKIA Care PR preter Academy Service Manual Level 1 amp 2 Contents E nande M ON nA Cn On OR CO ca Oe ee 3 2 OPONE eee rae ne ec ee nm Pn vO CT SD RESET EO SS OE NS NC 4 3 Warnings and COMTI ONS ss sccsssccssceccescscevaccececdvsvientssussyaessacaciscecateasesencasavsusiectssvaecsavssusieeasieanteha ween rename 5 3A Warnings acca cccce ace cee cece EE E cats E AEE E farce ene ate eee 5 Bel AUN ING potas costco cesses E E E A sees 5 a EDO ON ea nS ve ne E er E ere ree ae 6 5 Care and maintenance eeeeesesssseeeeeeeessssssseereeererssssssssessrerrrsssssssesureeererssssssenereeerrrsssssseuusuenererrrsssssssssnreeerresssssnenereeerrrsssssssesns T 6 Battery information n sssessesseessessessesseessessesseessesscssesssesscssesssossesscoseossrsscoscrssossesscossrssossscsscoseesscoseosscsscsscoseosscsse
7. cified in the parts list 4 Ensure all components modules screws and insulators are correctly re fitted after servicing and alignment 5 Ensure all cables and wires are repositioned correctly 5 Confidential e Copyright 2009 Nokia e All rights reserved Version 1 0 ISSUE 1 NOKIA Care PR rte Academy 4 ESD PROTECTION Service Manual Level 1 amp 2 Nokia requires that service points have sufficient ESD protection against static electricity when servicing the phone Any product of which the covers are removed must be handled with ESD protection The SIM card can be replaced without ESD protection if the product is otherwise ready for use To replace the covers ESD protection must be applied All electronic parts of the product are susceptible to ESD Resistors too can be damaged by static electricity discharge All ESD sensitive parts must be packed in metallized protective bags during shipping and handling outside any ESD Protected Area EPA Every repair action involving opening the product or handling the product components must be done under ESD protection ESD protected spare part packages MUST NOT be opened closed out of an ESD Protected Area For more information and local requirements about ESD protection and ESD Protected Area contact your local Nokia After Market Services representative Confidential e Copyright 2009 Nokia e All rights reserved Version 1 0 ISSUE 1 NOKIA Care PR preter Academy
8. ded for use by qualified service personnel only 4 Confidential e Copyright 2009 Nokia e All rights reserved Version 1 0 ISSUE 1 NOKIA Care PR preter Academy Service Manual Level 1 amp 2 3 WARNINGS AND CAUTIONS Please refer to the phone s user guide for instructions relating to operation care and maintenance including important safety information Note also the following 3 1 Warnings 1 CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE MANAGEMENT SYSTEMS AND ANTI SKID BRAKING SYSTEMS UNDER CERTAIN FAULT CONDITIONS EMITTED RF ENERGY CAN AFFECT THEIR OPERATION IF NECESSARY CONSULT THE VEHICLE DEALER MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF ENERGY 2 THE HANDPORTABLE TELEPHONE MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN POTENTIALLY EXPLOSIVE ATMOSPHERES EG PETROL STATIONS SERVICE STATIONS BLASTING AREAS ETC 3 OPERATION OF ANY RADIO TRANSMITTING EQUIPMENT INCLUDING CELLULAR TELEPHONES MAY INTERFERE WITH THE FUNCTIONALITY OF INADEQUATELY PROTECTED MEDICAL DEVICES CONSULT A PHYSICIAN OR THE MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY QUESTIONS OTHER ELECTRONIC EQUIPMENT MAY ALSO BE SUBJECT TO INTERFERENCE 3 2 Cautions 1 Servicing and alignment must be undertaken by qualified personnel only 2 Ensure all work is carried out at an anti static workstation and that an anti static wrist Strap is worn 3 Use only approved components as spe
9. ntial e Copyright 2009 Nokia e All rights reserved Version 1 0 ISSUE 1 NOKIA Care PR rte Academy Service Manual Level 1 amp 2 6 BATTERY INFORMATION Note A new battery s full performance is achieved only after two or three complete charge and discharge cycles The battery can be charged and discharged hundreds of times but it will eventually wear out When the operating time talk time and standby time is noticeably shorter than normal it is time to buy a new battery Use only batteries approved by the phone manufacturer and recharge the battery only with the chargers approved by the manufacturer Unplug the charger when not in use Do not leave the battery connected to a charger for longer than a week since overcharging may shorten its lifetime If left unused a fully charged battery will discharge itself over time Temperature extremes can affect the ability of your battery to charge For good operation times with Ni Cd NiMh batteries discharge the battery from time to time by leaving the product switched on until it turns itself off or by using the battery discharge facility of any approved accessory available for the product Do not attempt to discharge the battery by any other means Use the battery only for its intended purpose Never use any charger or battery which is damaged Do not short circuit the battery Accidental short circuiting can occur when a metallic object coin clip or pen causes direct connection
10. onersecoscoseesscsseos 8 Te 48 0 10 216 0 2 eeen oP E O E E eee 9 8 Service dEVICES esseen nv nnn orn mn EEE E Ter eee i 10 2 51 616 E E E S E E Or E E A EE E A E AS 11 10 Disassembly instructionS eeeeseessesseessessessessesscssssscrssesscssesssrssessesssosscssessesssessosscsssossessoesscossoscsssoscrsscsscrssessosscoseessessesss 12 I ASC HINT e E E A A ore er ve 15 1 SOOO S a T E A A E 16 2 Confidential e Copyright 2009 Nokia e All rights reserved Version 1 0 ISSUE 1 NOKIA Care Mae Academy Service Manual Level 1 amp 2 1 CHANGE HISTORY Version No Date Comments irst approved version 1 0 2312 2009 a The purpose of this document is to help NOKIA service levels 1 and 2 workshop technicians to carry out service to NOKIA products This Service Manual is to be used only by authorized NOKIA service suppliers and the content of it is confidential Please note that NOKIA provides also other guidance documents e g Service Bulletins for service suppliers follow these regularly and comply with the given instructions While every endeavor has been made to ensure the accuracy of this document some errors may exist If you find any errors or if you have further suggestions please notify NOKIA using the address below Nokia Care Academy mailto Service Manuals nokia com Please keep in mind also that this documentation is continuously being updated and modified so watch always out for the newest version 3 C
11. onfidential e Copyright 2009 Nokia e All rights reserved Version 1 0 ISSUE 1 NOKIA Care PR preter Academy Service Manual Level 1 amp 2 2 COPYRIGHT Copyright 2009 Nokia All rights reserved Reproduction transfer distribution or storage of part or all of the contents in this document in any form without the prior written permission of Nokia is prohibited Nokia Nokia Connecting People and Nokia X and Y are trademarks or registered trademarks of Nokia Corporation Other product and company names mentioned herein may be trademarks or tradenames of their respective owners Nokia operates a policy of continuous development Nokia reserves the right to make changes and improvements to any of the products described in this document without prior notice Under no circumstances shall Nokia be responsible for any loss of data or income or any special incidental consequential or indirect damages howsoever caused The contents of this document are provided as is Except as required by applicable law no warranties of any kind either express or implied including but not limited to the implied warranties of merchantability and fitness for a particular purpose are made in relation to the accuracy reliability or contents of this document Nokia reserves the right to revise this document or withdraw it at any time without prior notice The availability of particular products may vary by region IMPORTANT This document is inten
Download Pdf Manuals
Related Search