Operating Instructions Gasoline engine
Contents
1. e Make sure that the engine operates only in well ventilated environments otherwise a health risk may occur because of the fumes e In the vicinity of other persons the engine has to work with due diligence Make sure the exhaust pipe is free and acces sible it must not be covered or blocked e Before filling the tank with fuel the engine must always be switched off e The tank must not be filled till overflowing e If the fuel is spilled on the device when filling it has to be removed before starting the engine e Before changing the oil make sure that the cap of the tank is closed so no oil can go into the petrol tank e Do not use the unit near open flames flammable or explo sive substances or gases and flying sparks e The engine should be at least one meter away from house walls or other fixed facilities e Make sure that all moving and rotating parts are covered e While the device works the individual components eg ex haust heat Be careful when touching because otherwise it may cause burns e Operate in a safe environment and keep children away from it while operating e Operate on a straight and solid surface On slopes the de vice may leak fuel e A larger gap oblique bar can have even with full oil level negative influence on the gear e Take care when transporting the device make sure there are no fuel leaks We recommend that the tank is emptied and the fuel inlet valve closed by Wil2. rato 4 stroke 1 cylinder air cooled OHV gasoline engine Displacement 208 270 389 CC at 3600 rpm at 3600 rpm at 3600 rom E start recoil start SAE 15W 40 mineral for Winter Summer Fuel consump lt 3 4g 280g 2 59 tion g hp h E type Super unleaded Fuel tank ca pacity super unleaded in cc in I mae Cooling Gross weight 15 kg 27 kg 88kg sid 41 7 x 36 8 x 38 5 54 x 50 x 51 54 2 x 50 0 x 50 7 Bore x stroke 70 x 54 77x 58 88 x 64 in mm Transistor Magnet Z ndung Engine stop Circuit to ground system by WilTec Wildanger Technik GmbH http www wiltec info Engine designa UP190 190 192 tion 4 stroke 1 cylinder air cooled OHV gasoline engine Displacement 419 420 439 CC at 3600 rom at 3600 rpm at 3600 rpm E Starting device start recoil start PCE start recoil start oS Engine oil type SAE 15W 40 mineral for Winter Summer Fuel consump 374g 2759 tion g hp h Super unleaded Fuel tank capac 6 5 0 ity Super unleaded in Engine oil capac 1 10 ity in D Cooling Gross weight Bore x stroke in 90 x 66 92 x 66 mm Ignition Transistor Magneto Engine stop sys Circuit to ground tem Important note Reproduction in whole or in part and any commercial use including parts of the manual only with the written approval of Wiltec Wildanger Technik GmbH WilTec Wildanger Technik GmbH Konigsbenden 12 28 D 52249 Eschweile
3. Operating Instructions Gasoline engine tz by WilTec Wildanger Technik GmbH http www wiltec info Introduction Thank you for purchasing this quality product This petrol engine offers One cylinder 4 stroke engine Hand or electric starter Powerful air cooling system OHV Over Head Valve except 152F TCI Ignition Module Fan hood from special silent steel plate Our series of air cooled four stroke gasoline engines has been developed in terms of material and energy saving Due to their compact design the devices are easy to carry to every location and convenient to handle They offer a wide range of applica tions in the fields of craft industry horticulture and agriculture or household This manual will help you use your engine optimally Please read it carefully before using the device in operation By doing so the life of the device is signifi cantly increased Please contact us if you have any questions or comments about these instructions In some cases the equipment of the apparatus may vary from the kind described in this guide by WilTec Wildanger Technik GmbH http www wiltec info Af LICHT KRAFT TECHNIK Safety instructions Please follow the following tips and ideas for your own safety otherwise damage to the equipment or injury of the operator may occur i fe TPO SAN i i hog p Ag Fp pm gt Mt E AN Art Sh 4 Motor ES Luftgekunit a
4. Tec Wildanger Technik GmbH http www wiltec into Before commissioning the device keep the following points in mind e Make sure all fuel lines are connected and firmly attached so no leakage may oc cur e Make sure all screws and nuts are firmly applied e Check the fuel and oil level and if necessary fill fuel or oil MTA l i 42 as 1 un F f ra H A n a rats ds a KL re amp TR ol 1 Oil dipstick AA BAY S F n KS di SSS he S 2 Max Oil Level REF D t FF _ 3 Min Oil Level LT r Eeer 1 Fuel tank TJ 8 2 Fuel Cap 3 red mark for max 3 fuel level Wing nut Air filter housing Wing nut Air filter Foam filter Seal Air filter holder An PP PP A a PS PS PT St St St SN The air filter should be regularly checked and if necessary cleaned or replaced by WilTec Wildanger Technik GmbH http www wiltec info Start Waste Oil mm Altol every 20 hours Or every 3 months Huile us e us e Oil change Crankshaft inclination engine inclination tolerable inclination Start and stop the engine Open the throttle 1 and the drain screw 3 of the carburettor Once the fuel runs out the drain screw 3 may be refastened Then you can start the engine as usual 4 Throttle lever 5 Throttle valve is opened 6 Drain screw The engine may be run only within the rated power and rated speed If you det
5. ap 0 6 0 7mm 0 024 0 028in Valve clearance cold IN 0 15 0 02mm EX 0 20 0 02mm Technical Data Engine desig 152F UP154 154F A P nation Engine type 4 stroke 1 cylinder air 4 stroke 1 cylin 4 stroke 1 cylinder cooled SV gasoline der air cooled air cooled SV engine OHV gasoline gasoline engine engine a s e e CC at 3600 rpm at 3600 rpm at 3600 rpm tion En Ho Fuel type pacity Super unleaded in l Engine oil ca oacity in Cooling _ Air cooled engine 11 5 ko Sizeinem 29 x 28 x 35 39 7 x 34 5 x 36 7 31 x 28 x 36 5 Size in erm x stroke 52 x 46 54 x 38 54 x 46 in mm Transistor Magneto Sane stop Circuit to ground system by WilTec Wildanger Technik GmbH http www wiltec info Engine designa 154 F P 160F P tion 4 stroke 1 cylinder air cooled OHV gasoline engine Displacement 8 118 196 CC Spark plug FETC Max power 3 kW 4hp 4 8 KW 6 5 hp at 3600 rpm at 3600 rpm at 3600 rpm Starting device Engine oil Type SAE 15W 40 mineral for Winter Summer Fuel consump 330g 309g 290g tion g hp h Fuel type Fuel tank capac 1 5 3 6 3 60 unleaded in ity in I Gross weight 10 kg 14 kg 18 kg 35 5 x 32 5 x 34 40 x 34 5 x 36 41 7 x 36 8 x 38 5 Bore x stroke in 54 x 38 60 x 42 68 x 54 mm Transistor Magneto Engine stop sys Circuit to ground tem by WilTec Wildanger Technik GmbH http www wiltec info
6. ect abnormal episodes please stop the engine immediately and initiate corrective meas ures The engine should not be charged during the first 1 3 minutes after the start by WilTec Wildanger Technik GmbH http www wiltec info 4 Choke 5 Choke not activated 6 Carburattor drain screw OH OFF Switch 3 Ignition OFF 4 Ignition switch lf you want to stop the engine reduce the speed to a minimum set the choke to OFF and rotate the On Off switch to Off the engine should be shut immedi ately The switch is located right on the crankshaft housing Regular maintenance Clean the air filter regularly and replace it if it is not clean anymore It should be cleaned after approximately 25 hours of working Check all fittings for tightness and tighten them if necessary Check the engine oil level regularly a m on A i A i i i Si too much ff Le FT ll a i oe aa ae ag lt nl d G f Fa E nmi Fa p is See s a 7 CZ A FRE ae 7 SSS err OSS Max Oil Level FER oe fe vi Ne 3 Min Oil Level 4 il a f F 1 by WilTec Wildanger Technik GmbH http www wiltec info Every 50 hours of operation the spark plug should be cleaned tested or replaced if necessary lf the earth electrode is burnt too strong or the spark plug worn it should be exchanged against a new spark plug of the same type Only mount or dis mount spark plugs in a c
7. old engine Use ONLY ORIGINAL spark plugs al 0 6 nr lt i 0 020 lin i S SS o 1 Di t spark pl N Nani 1 ismount spark plug J A 2 adjust elektrode 1 7 T 2 2 D nn MEE a a ff ff fo va cE J _ UPS Ay j NEE AON 1 Oil drain screw e A ioo mih WAN ko LL 6 ANE 2 Oil filler A w 314 CV ESS 7 W VEN i LN ptimal CEANA ER _ a i j fy _2 ul i co f Y al eT yo Seeeseresessesers i Leer 1 SE enaa Clean the fuel tank every 100 hours of operation This tank should be taken from the holder and rinsed The fuel filter should periodically be cleaned If the engine shall be stored for long periods of time the fuel tank shall be completely emptied and the carburettor emptied on his discharge screw 3 The engine oll should be discharged when the engine is hot but switched off Then fill in new oil The engine should be completely cleaned of dirt from the outside The air filter and spark plug should be checked again and replaced or cleaned if necessary The combustion chamber should be filled with some motor oil when the spark plug is un screwed so that the combustion chamber is not oxidized After that the engine may be stored in a dry storage place by WilTec Wildanger Technik GmbH http www wiltec info f f L LICHT KRAFT TECHNIK CA Torques ____152F 160 168 177 192 Fly wheel screws 50 75 85 110 120 DO Spark plugs Spark plug g
8. r by WilTec Wildanger Technik GmbH http www wiltec info
Download Pdf Manuals
Related Search