Presto 06301 Use and Care Manual
Contents
1. 2 Wash the dehydrator trays and cover in warm water and a mild detergent or wash in a dishwasher The fruit roll trays and the mesh screens should be washed in warm sudsy water Do NOT wash these parts in a dishwasher If necessary a soft brush may be used to loosen dried on food particles Do not use steel wool scouring pads or abrasive cleaners on any of the dehydrator parts 3 Wipe the dehydrator base with a soft damp cloth DO NOT IMMERSE THE DEHYDRATOR BASE IN WATER OR OTHER LIQUID The screen which covers the center hub on the dehydrator platform lifts off for cleaning if needed Wash in warm water dry thoroughly reposition over hub and snap in place Presto Jerky Gun sold separately see page 11 Jerky Marinade recipe provided by So Easy To Preserve 5th ed 2006 Bulletin 989 Cooperative Extension Service The University of Georgia Athens Revised by Elizabeth L Andress Ph D and Judy A Harrison Ph D Extension Foods Specialists Storing the Dehydrator Before stacking the trays onto the base for storage turn the base upside down and wrap the cord around the center hub securing the cord under the clips For compact storage stack the trays onto the base so all of the trays with handles are upside down raised ribs facing up and all of the trays without handles are smooth side up Once all of the trays are stacked onto the base turn the cover upside down and place on top of the trays Consumer Service Info2. appliance 6 Do not operate any appliance with a damaged cord or plug or in the event the appliance malfunctions or has been damaged in any manner Return the appliance to the Presto Factory Service Department for examination repair or electrical or mechanical adjustment The use of accessory attachments not recommended by the appliance manufacturer may cause injuries Use only Presto dehydrating trays and accessories with this dehydrator Do not let cord hang over edge of table or counter or touch hot surfaces 9 Do not use outdoors 10 Do not place on or near a hot gas or electric burner or in a heated oven 11 Never use this appliance to dehydrate foods that contain alcohol or have been marinated in alcohol 12 Do not use appliance for other than intended use SAVE THESE INSTRUCTIONS THIS PRODUCT IS FOR HOUSEHOLD USE ONLY N oo 1 Important Cord Information e This appliance has a polarized plug one blade is wider than the other To reduce the risk of electric shock this plug is intended to fit into a polarized outlet only one way If the plug does not fit fully into the outlet reverse the plug If it still does not fit contact a qualified electrician Do not attempt to modify the plug in any way e A short power supply cord or cord set is provided to reduce the risk resulting from becoming entangled in or tripping over a longer cord Extension cords may be used if care is properly exercised in their use e If an
3. dehydration Meat that is precooked prior to dehydrating will have shorter drying times however the end product will have a dry crumbly texture If cooking the meat before dehydrating is preferred follow the instructions below Cooking meat before dehydrating After marinating meat strips place meat strips and liquid marinade into a shallow pan If no liquid remains add enough water to cover meat strips Bring liquid to a boil and boil for 5 minutes Remove meat strips from marinade drain and then position strips on dehydrator trays Position strips on dehydrator trays close together but not overlapping Dry jerky at 160 F or 71 C for 4 to 8 hours See Determining Dryness information below If you did not cook the meat prior to dehydrating cook it after following the instructions below Cooking meat after dehydrating Preheat oven until the internal temperature is 275 F For an accurate temperature reading check with an oven thermometer Remove jerky strips from dehydrator trays and place on a baking sheet close together but not touching Heat jerky in preheated oven for 10 minutes Remove jerky from baking sheet and cool to room temperature Preparing Jerky from Ground Meat Use one packet of Presto Jerky Seasoning Mix and combine entire contents of one packet each of jerky spice and cure with 1 pound ground meat that is about 93 lean Mix until meat and seasoning are blended Place the ground meat mixture in a Presto
4. drying time is needed recheck every 30 minutes While slightly warm starting from the outer edge carefully peel the fruit roll from the sheet Loosely roll in plastic wrap or waxed paper and follow Packaging and Storage information on page 4 For immediate enjoyment cut in strips or roll and cut into serving pieces Note Remove fruit rolls from sheets prior to cutting them FRUIT DRYING GUIDE Dry fruit at 135 F or 57 C Drying times are highly variable depending on the type and amount of food thickness evenness of food pieces humidity air temperature personal preference and even the age of the plant at the time of harvesting Average Preparation Pretreatment Drying Time Apples Peel if desired core and cut in rings or slices to 4 thick Ascorbic acid ascorbic acid mixture 4 9 hours or lemon juice Apricots Cut in half remove pit and cut in quarters or thick slices See apples 8 16 hours Bananas Peel and cut into 4 thick slices See apples Blueberries Remove stems Dip in boiling water for 30 to 60 seconds and then plunge in ice 9 17 hours a to crack the skin Cherries Remove stems and pit Cut in half Remove stems and pit Cut in half chop or leave whole or leave whole 15 23 hours 23 hours Cranberries Remove stems Dip in boiling water for 30 to 60 seconds and then plunge in ice 10 18 hours water to crack the skin i Remove stems Small figs can be left whole Otherwise c
5. easy adjustment of dehydration temperature In addition it will automatically shut off the dehydrator when the selected time has elapsed To Adjust Temperature Temperature 1 Press the TIME TEMP button and the temperature in the display window will begin to display flash if the time flashes press the TIME TEMP button again 2 Press the or buttons to select the desired temperature To change the temperature rapidly hold down the or buttons The temperature range for this dehydrator is 90 to 165 F 32 to 74 C Note To convert from Fahrenheit to Celsius hold down the TIME TEMP button To Set Timer 30 minutes to 48 hours 1 Press the TIME TEMP button and 00 00 will begin to flash if the temperature flashes press the TIME TEMP button again Note If appears the unit is in the Count Up mode Hold down the START STOP button to reset to 00 00 2 Press the or buttons until the desired time is displayed If you hold down the or buttons the time will change rapidly To reset the time to 00 00 hold down the START STOP button 3 Once you have the desired time and temperature set press the START STOP button to turn the dehydrator on At any time you can adjust the time or temperature by using the TIME TEMP and buttons You can stop the dehydrator at any time by pressing the START STOP button 4 The dehydrator will automatically shut off after the set time has expired and the green indicator lig
6. extension cord is used the marked electrical rating of the extension cord should be at least as great as the electrical rating of the appliance The extension cord should be arranged so that it will not drape over the countertop or tabletop where it can be pulled on by children or tripped over unintentionally e Connect the power supply cord to a 120VAC electrical outlet only Before First Use Become familiar with the food dehydrator Fig A and read and follow the instructions carefully As received your food dehydrator will be in the storage position Remove the dehydrator trays and cover from the base and wash them according to the Care and Cleaning instructions on page 9 How To Assemble and Load Trays for Dehydrating 1 10 Continue filling and stacking Remove trays and cover from unit 2 Turn power base over and locate cord Uncoil from base Set base right side up on a dry level surface In order to function properly the dehydrator must have sufficient airflow therefore be sure the base and cover vents are not obstructed at any time Never place dehydrator on carpet or a towel Note that each tray has a smooth surface on one side and raised ribs on the reverse side Food goes on the smooth side see Fig B1 The raised ribs should always be facing down see Fig B2 Select a tray with handles Set the tray on the counter so the words THIS SIDE UP which are molded onto the ha
7. water If desired fruit can be pretreated to preserve its natural color Add 1 4 teaspoons of lemon juice to each 1 cups pur ed fruit See the Fruit Drying Guide on page 6 to determine which fruits will benefit from pretreatment The natural sweetness of fruit is intensified with drying However if your preference is for a sweeter fruit roll you can add honey maple syrup corn syrup or sugar to the pur ed fruit if desired Try different amounts of sweeteners starting with tablespoon for each 14 cups of fruit pur e to find your preference Fruit with sweeteners added will take longer to dry than fruit that is not sweetened Canned fruit can also be used to easily make fruit leather Drain juice from fruit saving juice for later use Place fruit in food processor or blender and pur e until smooth Applesauce can be used directly from the container For frozen fruit thaw and pur e until smooth Pour pur ed fruit on lightly oiled fruit roll sheet and spread with a spatula to form a uniform layer about 1 4 inch thick Place fruit roll sheet on dehydrator tray set temperature to 135 F or 57 C and begin drying Average drying time for all fruit rolls is 4 to 7 hours Determining Dryness Acceptably dried fruit leather will be slightly tacky to the touch but will not indent when touched in the center Begin checking the fruit roll after 4 hours of drying If drying more than one fruit roll be sure to check all of the trays If additional
8. Jerky Gun or a cookie press and extrude meat directly onto dehydrator trays making sure that the meat does not touch or overlap Dry jerky at 160 F or 71 C for 4 to 8 hours See Determining Dryness information below Cook the meat after dehydrating following the instructions above Determining Dryness Begin checking jerky after about 4 hours and every 30 minutes thereafter Drying time will depend on a variety of factors These factors include the type of meat the amount of fat in the meat and whether or not you precooked the meat before dehydrating In addition times will vary depending on size thickness of the pieces and how full the trays are Jerky that is acceptably dry will crack when bent but will not break Packaging and Storage After cooling pat jerky with paper toweling to remove any fat droplets which may form on the jerky Follow Packaging and Storage information on page 4 Jerky can be stored 1 to 2 months at room temperature However to maintain the best flavor and quality store in the refrigerator or freezer Jerky Marinadet 1 2 pounds of lean meat Y cup soy sauce 1 tablespoon Worcestershire sauce 1 teaspoon hickory smoke flavored salt 4 teaspoon onion powder Y teaspoon garlic powder 4 teaspoon black pepper Combine all ingredients in a small bowl and follow Preparing Jerky from Meat Strips instructions beginning on page 8 Care and Cleaning 1 Remove plug from wall outlet before cleaning
9. PRESTO Dehydro Digital Electric Food Dehydrator e Dehydrates fruits vegetables herbs and spices e Makes jerky and fruit rolls e Digital temperature control and timer for precise drying time and temperatures e Six drying trays included for big drying capacity Expands up to 12 trays Trays nest for compact storage Additional trays sold separately see page 11 Estas instrucciones tambi n estan disponibles en espa ol Para obtener una copia impresa Descargue en formato PDF en www GoPresto com espanol Env e un mensaje de correo electr nico a contact GoPresto com e Llame al 1 800 877 0441 oprima 2 y deje un mensaje US LISTED Intertek Visit us on the web at www GoPresto com INSTRUCTIONS ee The following important safeguards are recommended by most portable appliance manufacturers IMPORTANT SAFEGUARDS To reduce the risk of personal injury or property damage when using electrical appliances basic safety precautions should always be followed including the following 1 Read all instructions 2 Do not touch hot surfaces Use handles or knobs 3 To protect against electrical shock do not immerse cord plug or the dehydrator base in water or other liquid 4 Close supervision is necessary when any appliance is used by or near children 5 Unplug from outlet when not in use and before cleaning Allow to cool before putting on or taking off parts and before cleaning the
10. ables to remove fibrous or woody portions or bruised and decayed areas peel and slice using the preparation information found on the Vegetable Drying Guide on page 7 Slice or cut vegetables into pieces that are uniform in size See page 7 for pretreatment information about specific vegetables Pretreatment The process of blanching involves subjecting vegetables to a high enough temperature to deactivate the enzymes Blanching is necessary to stop the naturally occurring enzymes from causing loss of color and flavor during drying and storage Blanching also relaxes the tissue walls so moisture can more readily escape during drying and enter during rehydrating Blanching can be done in water or steam Water blanching causes a greater loss of nutrients but is faster than steam blanching and achieves a more even heat penetration Steam blanching Fill a deep pot with water and bring to a boil Place vegetables loosely in a basket or colander that will allow steam to freely circulate around the vegetables Do not fill basket or colander with more than a 22 inch layer of vegetables Position the basket or colander in the pot making sure it does not contact the boiling water Cover with a close fitting lid Steam for the time indicated in the Vegetable Drying Guide on page 7 Water blanching Fill a large pot full with water Cover and bring to a boil Place vegetables loosely in a basket or colander and submerge in the boiling water Cover and blanch
11. ble products such as Mrs Wages Fresh Fruit Preserver are a combination of ascorbic acid and sugar and are commonly used for fresh fruits and for canning and freezing Follow the manufacturers directions for use of these mixtures Lemon juice Mix equal parts lemon juice and cold water Place cut fruit in solution and soak for 10 minutes Remove fruit and drain well before placing on drying trays Place pieces of fruit on dehydrator trays in a single layer close together but not touching or overlapping Refer to the Fruit Drying Guide on page 6 for suggested preparation pretreatment and drying times Dry fruit at 135 F or 57 C Mrs Wages is a registered trademark of Precision Foods Inc Determining Dryness Refer to the Fruit Drying Guide on page 6 and begin checking the fruit at the beginning of the average drying time range Remove a few pieces of fruit from each dehydrator tray and allow to cool to room temperature Fruits are acceptably dry when they are soft and pliable but not sticky Fruit folded in half should not stick together Apple and banana slices can be dried until crisp if desired If fruits seem to have a lot of moisture remaining recheck every 1 to 2 hours If fruits appear to be almost done check again in 30 minutes Always check fruits from each tray Conditioning After drying allow fruit to cool for 30 minutes to 1 hour before packaging Dried fruits may have uneven amounts of moisture remaining because of diff
12. d Fruits that are sliced thin and peeled will dry the fastest Fruits left whole will require the most drying time Slice fruit uniformly and in pieces about 4 inch thick Fruits that are left whole such as blueberries cranberries and grapes should be dipped in boiling water for 30 to 60 seconds and then plunged in ice water to crack the skin This procedure will reduce the drying time Pretreatment Many fruits will darken quickly once they are peeled and or cut and will continue to darken even after the fruit is dried This is due to the exposure of the natural enzymes in some fruits to air There are several pretreatment options to prevent this discoloration Pretreatment is not necessary but is recommended to prevent discoloration Some people may detect a slight flavor change with pretreated fruit See the Fruit Drying Guide on page 6 to determine which fruits will benefit from pretreatment You may want to try the different options and see which you prefer Ascorbic acid Vitamin C Ascorbic acid available in tablet or powdered form is available at drugstores Mix 2 tablespoons of powdered ascorbic acid in 1 quart cold water Vitamin C tablets six 500 mg tablets equal 1 teaspoon ascorbic acid should be crushed before mixing with water Place cut fruit such as bananas peaches apples or pears in mixture and soak for 10 minutes Remove fruit and drain well before placing on drying trays Ascorbic acid mixtures These commercially availa
13. e time of harvesting Pretreatment water blanching or Average Drying Vegetable Preparation steam blanching Time Asparagus Cut into 1 pieces water 31 4 minutes 6 8 hours steam 4 5 minutes Beans green wax Remove ends and strings Cut into 1 pieces water 2 minutes 6 11 hours steam 2 2 minutes Cook until tender Cool and peel Cut into shoestring strips 1 thick None Already cooked Broccoli Cut into serving pieces water 2 minutes 4 7 hours steam 3 3 minutes Carrots Peel and cut off ends Cut into to 1 4 slices water 3 minutes 4 10 hours steam 3 3 minutes Cauliflower Cut into serving pieces water 3 4 minutes 5 8 hours steam 4 5 minutes Celery Trim ends Cut into 1 4 slices water 2 minutes 2 4 hours steam 2 minutes Corn cut Husk and remove silk Blanch and cut corn from cob water 1 2 minutes 6 10 hours steam 2 2 minutes Peas Shell water 2 minutes 5 9 hours steam 3 minutes Peppers and pimientos Remove stem core and inner partitions Cut into 1 4 strips None 5 10 hours Potatoes Peel and cut into slices water 5 6 minutes 4 8 hours steam 6 8 minutes Summer squash and zucchini Trim ends Cut into slices water 1 minutes 4 6 hours steam 2 4 3 minutes Peel if desired Cut into sections 3 4 wide None O OE f 6 11 hours Uses Dried vegetables have a unique flavor and texture and are best used as ingredients for soups stews casseroles and sauces rather than
14. er time as this may result in poor quality and or unsafe food Packaging and Storage e Dried foods need to be properly packaged to prevent reabsorption of moisture and microbial deterioration Pack food in clean dry airtight containers Glass jars or freezer containers with tight fitting lids are good for storage Resealable plastic freezer bags are also acceptable e Store packaged dried food in a dry cool location away from light Higher temperatures and exposure to light will shorten the storage time and result in loss of quality and nutrients Most dried fruit when properly packaged and stored will be good for 1 year at 60 F or 6 months at 80 F Fruit leather rolls should keep for up to 1 month at room temperature Vegetables have about half the storage life as fruit If food is to be kept longer then store it in a freezer e Package vegetables and fruits in separate storage containers to avoid flavor transfer How to Dehydrate Fruit and Fruit Rolls Dried fruits and fruit rolls or leathers are nutritious and portable snacks Drying fruit intensifies the natural sweetness of the fruit because the moisture is removed Fruit Selection and Preparation Select fruits that are at the peak of ripeness Wash fruits to remove dirt and debris There are many options when it comes to drying fruit and personal preference should be your guide Fruits can be sliced halved or if small left whole peeled or unpeeled pretreated or left untreate
15. erences in the size of various pieces Although fruit appears to be dry there may still be moisture remaining in some of the individual pieces Conditioning is a procedure that can be used to more evenly distribute moisture which will reduce the chances of mold growth It allows you to determine if you ve removed enough moisture before you put it into storage To condition place the pieces of fruit loosely in a clean plastic or glass container and seal and let stand for 1 week This will allow drier pieces of fruit to absorb excess moisture that may be present in other pieces Daily shake the jar to separate the pieces and observe for condensation If condensation develops remove the fruit and dehydrate for additional time After conditioning follow Packaging and Storage information on page 4 Uses Dried fruits make great snacks They can also be added to trail mixes cereals muffins breads and other baked products Dried fruit can be used as is or softened prior to use To soften dried fruit submerge in boiling water and soak for 5 minutes or place fruit in a steaming basket over a pot of boiling water and steam for 5 minutes or until fruit is plumped Fruit Rolls Leather Fruit rolls or fruit leather are made by drying a thin layer of pur ed fruit on a flat surface Once dried the fruit layer is pulled from the surface and rolled The term leather derives from the leather like texture of the pur ed fruit once it is dried Almost a
16. foods such as herbs that may mean every 10 minutes and with other foods such as fruits that may mean every to 2 hours Slightly overripe fruits are acceptable for making fruit rolls e Dehydration prevents microbial growth however chemical reactions caused by enzymes in fruits and vegetables can occur unless the product is pretreated before drying Pretreatment will prevent or minimize undesirable color and texture changes during drying and storage See specific sections for recommended pretreatment e Place foods in a single layer on the trays Do not allow food to touch or overlap e When drying strong smelling foods such as onions and garlic be aware that there will be a strong odor during the drying process That odor may linger after drying has been completed e Individual pieces of food may not all dry at the same time Foods that are appropriately dried should be removed before those that still require additional drying Always check all of the trays for foods that are appropriately dried Allow dried pieces to cool and then place in a covered container e If one tray of food is finished before the others remove the dried food and return the empty tray to the unit rather than rearranging the trays e Do not add fresh fruits and vegetables to a partially dried load This will add moisture and increase the drying time e Allow for continuous drying Do not unplug dehydrator in the middle of the drying cycle and resume drying at a lat
17. for the time indicated in the Vegetable Drying Guide Water should return to a boil in less than 1 minute If not too many vegetables were added to the basket reduce the amount of vegetables added for the next batch Water blanch for the time indicated in the Vegetable Drying Guide below Immediately after steam or water blanching dip the vegetables in cold water to quickly cool them Drain the vegetables and arrange them in a single layer on the dehydrator trays Refer to the Vegetable Drying Guide below for drying times Determining Dryness Refer to the Vegetable Drying Guide below and begin checking the vegetables at the beginning of the average drying time range Remove a few pieces of vegetables from each dehydrator tray and allow to cool to room temperature Test for dryness by breaking the pieces in half Most vegetables will be crisp when appropriately dried and will break easily If vegetables do not break easily additional drying time is needed If vegetables seem to have a lot of moisture remaining recheck every to 2 hours If vegetables appear to be almost done check again in 30 minutes Always check vegetables from each tray Follow Packaging and Storage information on page 4 VEGETABLE DRYING GUIDE Dry vegetables at 125 F or 52 C Drying times are highly variable depending on the type and amount of food thickness evenness of food pieces humidity air temperature personal preference and even the age of the plant at th
18. ht will flash When this occurs check the food for dryness If dehydration is complete remove food from dehydrator If additional drying time is needed follow the preceding steps through 3 to continue dehydrating To Use Count Up Timer up to 48 hours 1 If START STOP is pressed with 00 00 showing on the timer display the dehydrator will turn on and the unit will begin counting up in seconds for the first minute After 59 seconds the time is displayed in hours and minutes HH MM 2 At any time the temperature can be adjusted using the or buttons Note The time is not adjustable when the timer is counting up 3 At any time you can stop the dehydrator by pressing the START STOP button To reset the time to 00 00 hold down the START STOP button 4 The unit will automatically shut down after 48 hours How to Use the Nonstick Mesh Screens The flexible mesh screens fit into the dehydrator trays to keep foods that get very small when dried such as herbs berries and carrots from falling through the tray grates The screens may also be used when drying foods that stick to the grates such as bananas and tomatoes Position the mesh screen on the dehydrator tray Then place the food you want to dry on the mesh screen Once the food is dehydrated lift the mesh screen out of the tray using the cutouts on the side of the screen Remove food Bending the screen is helpful for removing foods that have a tendency to stick How
19. ires Please provide your daytime telephone number should we need to contact you Make checks payable to National Presto Industries Inc Please allow 2 to 3 weeks for delivery Prices are subject to change without notice This offer good in the USA and Canada only SHIP TO Name Address City
20. ndles are facing up Begin loading tray with a single layer of food Place loaded tray onto power base The first tray placed onto the power base MUST have handles see Fig A Select a tray without handles Load food onto smooth surface and stack tray without handles onto tray with handles trays alternating trays with handles and without handles see Fig A Place clear cover over stacked trays Position cover so that the words on the cover handles THIS SIDE UP are facing up Plug cord into a 120VAC electrical outlet only and begin dehydrating See pages 4 through 9 for dehydrating information for specific foods For dehydrating stack trays onto base as shown This dehydrator also includes 2 Nonstick mesh screens 2 Fruit roll sheets See through cover 2 Sample packets of spice and cure for preparing homemade jerky Tray without handles Tray with handles Six nestable drying trays Tray without handles Tray with handles Tray without handles Center hub center hub screen Power base se I Digital control panel lt _ ee Place food on smooth surface Fig B1 Additional trays sold separately see page 11 Tray with handles Base platform Fig A Fig B2 Raised ribs should be facing down How to Use the Digital Control The digital control Fig C allows for
21. ny fruit or combination of fruit can be pur ed and dried for fruit leather The quality of the fruit leather depends on whether the fruit has a low or high amount of the naturally occurring starch called pectin Fruits that have a high amount of pectin will make leathers that bond together in a solid sheet and easily peel while fruits that have little pectin will flake and crack rather than peel When making leather with fruits low in pectin add another fruit that is high in pectin to improve the texture of the leather Fruits naturally high in pectin are apples apricots blueberries cranberries figs grapes peaches pears pineapples and plums Fruits low in pectin include cherries citrus fruits raspberries and strawberries When using a low pectin fruit with a high pectin fruit use equal parts of each to produce the best results Preparation Use a Presto Fruit Roll Sheet to prepare fruit rolls Apply a thin layer of vegetable oil or no stick cooking spray to the fruit roll sheet Caution If using cooking spray be sure to spray away from the dehydrator base Use about 1 cups of pur ed fruit for each fruit roll sheet Select ripe or slightly overripe fruit and remove any bruised areas Wash fruits and remove peel seeds and stems Cut fruit into chunks and using a food processor or blender pur e until smooth applesauce consistency To get the pur eing process started you may need to add approximately 1 tablespoon of fruit juice or
22. or with these handy accessories Presto Jerky Gun and Seasoning Kit including spice and cure Part 08631 Part 08631 Make delicious homemade jerky from beef venison or other meats Kit includes a jerky gun with three interchangeable nozzles plus five packets of Classic flavor jerky spice and cure Presto Add on Nesting Dehydrator Trays Part 06306 Expand the capacity of your Presto Dehydro Dehydrator Trays are designed to nest inside each other when not in use to save storage space Sold in sets of two g f Part 06306 Model 06301 is designed to work with up to twelve trays Need additional accessories Presto Fruit Roll Sheets Part 06308 Sold in sets of two Presto Nonstick Mesh Screens Part 06307 Sold in sets of two Presto Jerky Seasoning Kits including spice and cure Classic Flavor Part 08635 Includes 6 packets of Classic jerky spice and cure Variety Flavor Part 08636 Includes 2 packets each of Classic Teriyaki and Hot amp Spicy jerky spice and cure These dehydrator accessories should be available wherever Presto Dehydro Dehydrators are sold however if you would like to order them directly from Presto see the information below How To Order Complete the order form on the back of the book and mail it to the address shown or call toll free 1 800 995 9960 weekdays between 8 00 AM and 4 00 PM Central Time Please have your credit card number and expiration date
23. per gallon of water Allow surface to air dry e Marinate meat under refrigeration Discard marinade after meat is removed e Keep raw meat and dried jerky separate NOTE The United States Department of Agriculture recommends that meat be precooked prior to dehydrating or cooked after dehydrating to reduce the risk of foodborne illness Preparing Jerky from Meat Strips Select lean meats such as beef and venison sirloin rump and round cuts and pork loin and ham cuts Trim meat of visible fat connective tissue and gristle Freeze meat until firm but not solid to make slicing easier Slice meat into strips that are 1 4 inch thick 1 inch wide and 5 to 6 inches long Slice meat across the grain for a more tender jerky or with the grain for a chewier jerky Venison or wild game meat that has been contaminated with entrails should not be used for making jerky 8 Flavor the meat slices by marinating in Presto Jerky Seasoning your own favorite marinade a commercial marinade or use the marinade recipe below To use the Presto Jerky Seasoning mix one packet of spice and one packet of cure with 1 4 cup of water Place marinade and meat strips in a resealable plastic storage bag Seal bag and shake to thoroughly coat the meat strips Refrigerate for 8 to 12 hours Turn bag often to evenly coat the meat strips Refer to the note on page 8 about cooking the meat before or after dehydrating For a more desirable texture cook meat after
24. ready Perfect companions for your Presto Food Dehydrator Part 02910 Presto SaladShooter electric slicer shredder Part 02910 The quick and easy way to evenly slice fruits and vegetables for drying Includes interchangeable slicing and shredding cones Presto Professional SaladShooter electric slicer shredder Part 02970 Part 02970 a Same great features as the original SaladShooter but with added power and capacity Includes three interchangeable processing cones for making thick and thin slices and ripple cuts plus a shredding cone Also includes a handy funnel guide for directing ingredients right where TAa they re needed 4 A Payment options on telephone orders limited to credit card only Form 76 031A Clip and mail to Presto Dehydrator Accessories P O Box 1212 Eau Claire WI 54702 1212 Please send me the following Qty Item Cost Package of 2 Fruit Roll Sheets Part No 06308 6 99 each package 3c xc seca wcll reardahecdsew tie ayer teideaieal ark ne eraren Package of 2 Nonstick Mesh Screens Part No 06307 6 99 each package 0 ccc cece nce cece cnet eter e nena ees Package of 2 Dehydrator Trays Part No 06306 16 99 each package lt u oicw ise peck oei ert ee edie oe steueee ede dete pees es Jerky Gun and Seasoning Kit includes jerky gun with 3 interchangeable nozzles and 5 packets of Classic jerky spice and cure Pa
25. rmation If you have any questions regarding the operation of your PRESTO appliance or need parts for your appliance contact us by any of these methods e Call 1 800 877 0441 weekdays 8 00 AM to 4 00 PM Central Time e Email us through our website at www GoPresto com contact e Write National Presto Industries Inc Consumer Service Department 3925 North Hastings Way Eau Claire WI 54703 3703 When contacting the Consumer Service Department please indicate the model number and the series code for the dehydrator These numbers can be found on the bottom of the unit Please record this information Model Number Series Code Date Purchased Inquiries will be answered promptly by telephone email or letter When emailing or writing please include a phone number and a time when you can be reached during weekdays if possible The Presto Factory Service Department is equipped to service PRESTO appliances and supply genuine PRESTO parts Genuine PRESTO replacement parts are manufactured to the same exacting quality standards as PRESTO appliances and are engineered specifically to function properly with its appliances Presto can only guarantee the quality and performance of genuine PRESTO parts Look alikes might not be of the same quality or function in the same manner To ensure that you are buying genuine PRESTO replacement parts look for the PRESTO trademark Canton Sales and Storage Company Presto Factory Service Depa
26. rt No 08631 19 99 each package n nnana thaw tun eaniaiealiataassaundenetdaekess Classic Flavor Jerky Seasoning Kit includes 6 packets of spice and cure Part No 08635 8 99 each kit n n annann et Aad oles od a ads Els a Variety Flavor Jerky Seasoning Kit includes 2 packets each of Classic Teriyaki and Hot amp Spicy jerky spice and cure P rt N 08636 8 99 each Kil ri eie tir rinise anu na an Ea E E i E SaladShooter electric slicer shredder Part No 02910 39 99 each nannaa eet at Si oh a Mak hat a i Ek ea eh Aste eed At Professional SaladShooter electric slicer shredder Part No 02970 59 99 GAC cnadccceeticrevekscitigar erate este weet eree tees ee ike ei eEGes Postage ang Handling taxiceencapenad ste Ob aiuerk whey Spit items ctnpy ae ee peice Soe b eae eeei ks Dee e kes __ 5 00 SUBTOTAL v iee venti ha ade ata eee sateen teenie Dia han ue teeth hy Add sales tax for NY 9 TX 8 25 WI 5 WA8 6 00 eee cece eee eens TOTAL COSTA raro ces ue gotten teas domyae ena wet daworesunaeeaseaece tu a egauicee wade Enclosed is my check or money order for the total cost as indicated above authorize you to charge the total cost indicated above to my credit card account Please check card type and indicate account number and expiration date Mastercard Visa Discover American Express Account No Exp
27. rtment 555 Matthews Dr Canton MS 39046 3251 PRESTO Limited Warranty This quality PRESTO appliance is designed and built to provide many years of satisfactory performance under normal household use Presto pledges to the original owner that should there be any defects in ma terial or workmanship during the first year after purchase we will repair or replace it at our option Our pledge does not apply to damage caused by shipping To obtain service under the warranty call our Con sumer Service Department at 1 800 877 0441 If unable to resolve the problem you will be instructed to send your PRESTO appliance to the Presto Factory Service Department for a quality inspection shipping costs will be your responsibility When returning an appliance please include a description of the problem and indicate the date the appliance was purchased We want you to obtain maximum enjoyment from using this PRESTO appliance and ask that you read and follow the instructions enclosed Failure to follow instructions damage caused by improper replacement parts abuse misuse or neglect will void this pledge This warranty gives you specific legal rights and you may also have other rights which vary from state to state This is Presto s personal pledge to you and is being made in place of all other express warranties NATIONAL PRESTO INDUSTRIES INC Eau Claire WI 54703 3703 Form 76 031A 10 Get the most from your Presto Food Dehydrat
28. ryness Herbs are acceptably dry when they are crispy and crumble easily Refer to the Herb Drying Guide below and begin checking the herbs at the beginning of the average drying time range Remove a few herbs from each dehydrator tray and allow to cool to room temperature If the herbs do not crumble easily recheck every hour Packaging and Storage Dried leaves are best stored whole and then crumbled when needed Follow Packaging and Storage information on page 4 Uses Most dried herbs are 3 to 4 times stronger than the fresh herbs therefore when using dried herbs in a recipe that calls for fresh herbs use 4 to 3 of the amount called for in the recipe HERB DRYING GUIDE Dry herbs at 95 F or 35 C Average Average Drying Time Drying Time Break veins to speed drying Drying Jerky Homemade jerky is a flavorful dried meat product that is especially popular with outdoor sports enthusiasts because it is light and easy to transport Jerky can be made from almost any lean meat including beef pork or venison Whenever handling meat basic food safety precautions need to be observed e Wash hands thoroughly before and after handling raw meat e Keep meat refrigerated or frozen until ready to use e Raw meat and its juice should be kept away from other foods Wash cutting boards utensils counters etc with hot soapy water after contact with raw meat After washing sanitize with a solution of 1 tablespoon chlorine bleach
29. stand alone side dishes When using in soups dried vegetables can be added without soaking Dried vegetables used for other purposes need to be soaked before cooking To soak start with 1 4 to 2 cups of boiling water for every 1 cup of dried vegetables Soak for 1 to 2 hours or until vegetables have returned to nearly the same size they were before dehydrating Additional water should be added as needed during the soaking process After soaking simmer the vegetables in the soaking water until tender allowing excess water to evaporate Drying Herbs Drying fresh herbs allows you to have a ready supply of economical herbs that are available to use all through the year To retain the best flavor of your herbs it is recommended that you dry them at the lowest temperature setting 95 F or 35 C Selection and Preparation Pick herbs for drying just before the flowers first open These herbs will be the most flavorful The best time to pick herbs is early morn ing just after the dew has evaporated Rinse leaves and stems in cool water to remove any dust or insects and then gently shake to remove excess water Remove dead and bruised leaves or stems Large leafed herbs such as basil sage and mint should be removed from their stems for faster drying Smaller leafed herbs can be left on their stem and removed after drying Placing the herbs on a mesh screen will help prevent them from falling through the grates in the tray as they dehydrate Determining D
30. to Use the Fruit Roll Sheets A fruit roll sheet should be used when making fruit rolls and strips from fresh frozen or canned fruit Refer to page 5 for instructions on making fruit rolls General Dehydrating Information Safety precaution Wash hands thoroughly prior to preparing food for dehydrating Likewise thoroughly clean all utensils cutting boards and counters that will be used for preparing food Wash foods before preparing them for dehydrating e When selecting food for drying choose those that are at peak eating quality Avoid overripe or immature fruits and vegetables Remove any parts of the food that are bruised or blemished For even drying cut food into uniform sizes shapes and thicknesses Use a Presto SaladShooter slicer shredder food processor or mandoline to aid in cutting uniform slices Drying times are highly variable depending on the type and amount of food thickness evenness of food pieces humidity air tem perature personal preference and even the age of the plant at the time of harvesting That is why throughout the book you will notice there is a range of average drying times In some cases you may find you may need to or prefer to dry your foods for shorter or longer periods than those listed For best results begin checking your food at the beginning of the range listed in the instructions You should then gauge how often you should recheck the food based on how the drying is progressing With some
31. ut in half Dip whole figs 8 15 hours in boiling water for 30 to 60 seconds and then plunge in ice water to crack the skin Grapes Leave whole or cut in half Dip whole grapes in boiling water for 30 to 60 seconds 13 21 hours and then plunge in ice water to crack the skin Nectarines Cut in half and remove pit May also quarter or slice 4 thick See apples 6 10 hours slices 36 48 hours halves or quarters Peaches Peel if desired Cut in half and remove pit May also quarter or slice 4 thick See apples 6 10 hours slices 36 48 hours halves or quarters PunsPanes Have orquaterandrenovent o e O o Rhubarb Trim and discard leaves Cut stalk into 1 4 slices Noes o ho Strawberries Remove the leafy crown Halve or slice 1 4 thick None o hos O Drying Vegetables Dry vegetables at 125 F or 52 C Vegetables dry much faster than fruits At the end of the drying period moisture loss is rapid As a result vegetables need to be checked often towards the end of the drying time to prevent overdrying Food turns brown when it is overdried When drying smaller vegetables such as peas or carrots it is recommended that you place them on a mesh screen on the tray A mesh screen will help prevent smaller foods from falling through the grates in the tray as they dehydrate See information on page 3 How to Use the Nonstick Mesh Screens Selection and Preparation Wash vegetables to remove dirt and debris Trim veget
Download Pdf Manuals
Related Search