Salsbury Industries 4350GRN Installation Guide
Contents
1. to 45 from the ground or street surface up to the point of mail entry The door should be set back 6 to 8 back from the front face of the curb or the road edge However you should check with your local postmaster to ensure that the mailbox is installed according to local regulations Itis important to note that it is not the responsibility of mail carriers to open mailboxes that are locked accept keys for this purpose or lock mailboxes after delivery of the mail To install the bolt mounted pedestal begin by digging a hole for the E e CONCRETE concrete footing and then prepare the concrete The top surface of ANCHORS the footing should be about 12 by 18 See the illustration for the f i NOT relative position of the rectangular footing to the pedestal and l INCLUDED mailbox The concrete should extend into the ground 24 or greater if your local frost line is deeper Installing the concrete below the frost line will prevent movement during ground freezing and thawing The bottom of the hole for the concrete footing should be filled with a depth of about 6 of gravel to promote drainage under the post The top of the footing should be sloped for water runoff When digging the hole for the footing be careful to not puncture water sewer or gas lines Hardware for attaching the pedestal to the concrete footing is not included J bolts are shown in the illustration as an example The concrete footing should2. Thank you for selecting Salsbury s 4350 mail chest mailbox This instruction sheet is for installing the 4350 mail chest on spreaders and a pedestal Other installation instructions are available for installing the mail chest on a pedestal or on a deluxe post installing the mail chest on a newspaper holder and installing the pedestal in a concrete footing When you install a curbside or roadside mailbox make sure that it is easily accessible to the mail carrier By regulation a locked mailbox should be 41 to 45 from the ground or street surface up to the point of mail entry The door should be set back 6 to 8 back from the front face of the curb or the road edge However you should check with your local postmaster to ensure that the mailbox is installed according to local regulations It is important to note that it is not the responsibility of mail carriers to open mailboxes that are locked accept keys for this purpose or lock mailboxes after delivery of the mail Installing Mail Chests on a Spreader amp Pedestal 4382 2 Wide Spreader All hardware to attach the spreader to the pedestal is included with the spreader To attach the spreader to the pedestal install four 4 5 16 18 X 1 long hex flange head bolts through the four 4 center square holes of the spreader and through the four 4 tapped holes on the top plate of the standard mailbox post Cover the hex flange head bolts with cap plugs All hardware to attach th
3. Newspaper Holders Installation to Pedestal All hardware to attach the newspaper holders to the spreader is included with the spreader To attach a newspaper holder to the spreader install four 4 5 16 18 x 1 3 4 long carriage bolts through the four 4 square holes in the inside floor of the newspaper holder and through the four 4 corresponding holes on the spreader Install 5 16 flat washers and 5 16 18 hex nuts on the ends of the four 4 bolts protruding below the bottom of the spreader Repeat these steps for the other newspaper holder NEWSPAPER HOLDERS SPREADER NEWSPAPER HOLDERS SHOWN CUT AWAY FOR ILLUSTRATION PEDESTAL Mail Chest Installation to Newspaper Holders All hardware to attach the mail chests to the newspaper holders is included with the newspaper holders To attach a mail chest to a newspaper holder install four 4 5 16 18 X 3 4 long carriage bolts into 4 square holes in the floor of the mail chest and through the four 4 square holes on the top of the newspaper holder Install 5 16 flat washers and 5 16 18 hex nuts on the ends of the four 4 bolts protruding below the top of the newspaper holder Cover the hex nuts with cap plugs Repeat these steps for the other mail chest Installation is now complete Additional hardware provided is not needed and may be discarded MAIL CHESTS NEWSPAPER HOLDERS MAIL CHESTS SHOWN CUT AWAY FOR I
4. is now complete Additional hardware provided is not needed and may be discarded PEDESTAL MAIL CHEST SHOWN CUT AWAY FOR ILLUSTRATION SALSBURY INDUSTRIES 1010 East 62 Street Los Angeles CA 90001 1598 Phone 1 800 624 5269 Int l Phone 323 846 6700 Fax 1 800 624 5299 Int l Fax 323 846 6800 Installation instructions are provided as general guidelines It is advised that a professional installer be consulted Salsbury Industries assumes no product assembly or installation liability Copyright 2011 Salsbury Industries All rights reserved Rev 01 11 1 11 Mail Chest 4350 Wall or Column Mounted Installation Instructions U S P S APPROVED Installing Mail Chest in a Wall or Column Thank you for selecting Salsbury s 4350 mail chest mailbox This instruction sheet is for installing the 4350 mail chest in a hole in a wall or column Other installation instructions are available for installing the mail chest on a pedestal installing the mail chest on a deluxe post installing the mail chest on spreaders mounting a newspaper holder and mounting a pedestal in a concrete footing When you install a curbside or roadside mailbox make sure that it is easily accessible to the mail carrier By regulation a locked mailbox x 19 3 4 should be 41 to 45 from the ground or street surface up to the point 14 3 8 of mail entry The door should be set back 6 to 8 back from the front face of the c
5. LLUSTRATION SPREADER PEDESTAL SALSBURY INDUSTRIES 1010 East 62 Street Los Angeles CA 90001 1598 Phone 1 800 624 5269 Int l Phone 323 846 6700 Fax 1 800 624 5299 Int l Fax 323 846 6800 Installation instructions are provided as general guidelines It is advised that a professional installer be consulted Salsbury Industries assumes no product assembly or installation liability Copyright 2011 Salsbury Industries All rights reserved 11 1 11 Mail Chests 4350 3 Wide Spreader with Newspaper Holders on a Pedestal Installation Instructions Installing Mail Chests on 3 Wide Spreader with Newspaper Holders on Pedestal Thank you for selecting Salsbury s 4350 mail chest mailbox This instruction sheet is for installing 4350 mail chests on a 3 wide spreader with 4315 newspaper holders and a pedestal A different instruction sheet is available for installing 4350 mail chests on 2 wide spreaders with 4315 newspaper holders and a pedestal Other installation instructions are available for installing the mail chest on a pedestal or on a deluxe post installing the mail chest on a spreader and installing the pedestal in a concrete footing When you install a curbside or roadside mailbox make sure that it is easily accessible to the mail carrier By regulation a locked mailbox should be 41 to 45 from the ground or street surface up to the point of mail entry The door should be set back 6 to 8 ba
6. Mail Chests 4350 Pedestal Mounted Installation Instructions U S P S APPROVED Installing Mail Chest on a Pedestal Thank you for selecting Salsbury s 4350 mail chest mailbox This instruction sheet is for installing the 4350 mail chest on a pedestal Other installation instructions are available for installing the mail chest on spreaders mounting a newspaper holder and mounting the pedestal in a concrete footing When you install a curbside or roadside mailbox make sure that it is easily accessible to the mail carrier By regulation a locked mailbox should be 41 to 45 from the ground or street surface up to the point of mail entry The door should be set back 6 to 8 back from the front face of the curb or the road edge However you should check with your local postmaster to ensure that the mailbox is installed according to local regulations It is important to note that it is not the responsibility of mail carriers to open mailboxes that are locked accept keys for this purpose or lock mailboxes after delivery of the mail All hardware to install the mail chest is provided with the pedestal MAIL CHEST To install the mail chest unlock and open the front or rear door of the mail chest and install four 4 5 16 18 x 2 long pan head bolts through the four 4 square holes in the inside floor of the mail chest and through the four 4 tapped holes on the top plate of the pedestal Installation
7. ail chest to the newspaper holder is included with the newspaper holder To attach the mail chest to the newspaper holder unlock and open the front door or rear door of the mail chest and install four 4 5 16 18 X 3 4 long carriage bolts into 4 square holes in the floor of the mail chest and through the four 4 square holes shown on the top of the newspaper holder Install 5 16 flat washers and 5 16 18 hex nuts on the ends of the four 4 bolts protruding below the top of the newspaper holder Cover the hex nuts with cap plugs Installation is complete Additional hardware provided is not needed and may be discarded Oly amp amp S amp NEWSPAPER HOLDER i I l MAIL CHEST PEDESTAL NEWSPAPER NEWSPAPER HOLDER HOLDER SHOWN CUT AWAY FOR ILLUSTRATION MAIL CHEST SHOWN CUT AWAY FOR ILLUSTRATION PEDESTAL SALSBURY INDUSTRIES 1010 East 62 Street Los Angeles CA 90001 1598 Phone 1 800 624 5269 Int l Phone 323 846 6700 Fax 1 800 624 5299 Int l Fax 323 846 6800 Installation instructions are provided as general guidelines It is advised that a professional installer be consulted Salsbury Industries assumes no product assembly or installation liability Copyright 2011 Salsbury Industries All rights reserved Rev 01 11 1 11 Mail Chests 4350 Spreader amp Pedestal Installation Instructions U S P S APPROVED
8. ailbox This instruction sheet is for installing the 4350 mail chest along with a 4315 newspaper holder on a pedestal Other installation instructions are available for installing the mail chest on a pedestal or on a deluxe post installing the mail chest on spreaders and installing the pedestal in a concrete footing When you install a curbside or roadside mailbox make sure that it is easily accessible to the mail carrier By regulation a locked mailbox should be 41 to 45 from the ground or street surface up to the point of mail entry The door should be set back 6 to 8 back from the front face of the curb or the road edge However you should check with your local postmaster to ensure that the mailbox is installed according to local regulations It is important to note that it is not the responsibility of mail carriers to open mailboxes that are locked accept keys for this purpose or lock mailboxes after delivery of the mail Newspaper Holder to Pedestal Installation Install four 4 5 16 18 x 2 long pan head bolts provided with the pedestal through the four 4 square holes shown in the inside floor of the newspaper holder and through the four 4 tapped holes on the top plate of the pedestal Insert a Phillips head screw driver through each square hole directly above and in the top of the newspaper holder to tighten the pan head bolts Mail Chest Installation on a Newspaper Holder and Pedestal All hardware to attach the m
9. ck from the front face of the curb or the road edge However you should check with your local postmaster to ensure that the mailbox is installed according to local regulations It is important to note that it is not the responsibility of mail carriers to open mailboxes that are locked accept keys for this purpose or lock mailboxes after delivery of the mail Spreader and Newspaper Holders Installation to Pedestal Attaching the spreader to the pedestal requires simultaneously attaching the center newspaper holder to the spreader and to the pedestal Start by installing four 4 5 16 18 x 2 long pan head bolts provided with the pedestal through the four 4 square holes in the inside floor of the center newspaper holder through the four 4 center square holes in top of the spreader and through the four 4 tapped holes on the top plate of the pedestal Insert a Phillips head screw driver through each square hole directly above and in the top of the newspaper holder to tighten the pan head bolts All hardware to attach the remaining two newspaper holders to the spreader is included with the spreader To attach an additional newspaper holder install four 4 5 16 18 x 1 3 4 long carriage bolts through the four 4 square holes in the inside floor of the newspaper holder and through the four 4 corresponding square holes in top of the spreader Install 5 16 flat washers and 5 16 18 hex nuts on the ends of the four 4 bolts
10. e mail chests to the spreader is included with the spreader To attach a mail chest open the front door or rear door of the mail chest and install four 4 5 16 18 x 1 3 4 long carriage bolts through the four 4 square holes in the inside floor of the mail chest through the square spacer and through the four 4 corresponding square holes in top of the spreader Install 5 16 flat washers and 5 16 18 hex nuts on the ends of the four 4 bolts protruding below the bottom of the spreader Repeat these steps for the other mail chest Installation is now complete Additional hardware provided is not needed and may be discarded SQUARE SPACER SPREADER MAIL CHESTS SHOWN lt A gt CUT AWAY FOR ILLUSTRATION PEDESTAL 4383 3 Wide Spreader All hardware to attach the spreader to the pedestal is included with the pedestal To attach the spreader to the pedestal requires simultaneously attaching the center mail chest to the spreader and to the pedestal Start by opening the front door or rear door of the center mail chest and install four 4 5 16 18 X 2 long pan head bolts through the four 4 square holes in the inside floor of the center mail chest through the square spacer through the four 4 center square holes of the spreader and through the four 4 tapped holes on the top plate of the pedestal All hardware to attach the remaining two mail chests to the spreader is included with the spr
11. eader To attach an additional mail chest open the front door or rear door of the mail chest and install four 4 5 16 18 x 1 3 4 long carriage bolts through the four 4 square holes in the inside floor of the mail chest through the square spacer and through the four corresponding square holes in top of the spreader Install 5 16 flat washers and 5 16 18 hex nuts on the ends of the four 4 bolts protruding below the bottom of the spreader Repeat these steps for the other mail chest Installation is now complete MAIL CHESTS SQUARE SPACER MAIL CHESTS SHOWN CUT AWAY FOR ILLUSTRATION SPREADER PEDESTAL Phone 1 800 624 5269 Fax 1 800 624 5299 SALSBURY INDUSTRIES 1010 East 62 Street Los Angeles CA 90001 1598 Int l Phone 323 846 6700 Int l Fax 323 846 6800 Installation instructions are provided as general guidelines It is advised that a professional installer be consulted Salsbury Industries assumes no product assembly or installation liability Copyright 2011 Salsbury Industries All rights reserved Rev 01 11 1 11 Mail Chests 4350 2 Wide Spreader with Newspaper Holders on a Pedestal Installation Instructions Installing Mail Chests on 2 Wide Spreader with Newspaper Holders on a Pedestal Thank you for selecting Salsbury s 4350 mail chest mailbox This instruction sheet is for installing 4350 mail chests on 2 wide spreaders with 4315 newspaper h
12. include reinforcing steel and four 4 1 2 anchor studs protruding at least 1 above the concrete surface Place the anchor studs in a 4 x 10 pattern in the concrete to align with the holes in the pedestal base When the concrete has cured sufficiently install four 4 leveling nuts on the anchor studs Set the pedestal on the leveling nuts with the four 4 anchor studs protruding through the holes in the pedestal base plate Adjust the leveling nuts to square up the pedestal Install four 4 nuts and washers on the anchor studs and tighten securely SALSBURY INDUSTRIES 1010 East 62 Street Los Angeles CA 90001 1598 Phone 1 800 624 5269 Int l Phone 323 846 6700 Fax 1 800 624 5299 Int l Fax 323 846 6800 Installation instructions are provided as general guidelines It is advised that a professional installer be consulted Salsbury Industries assumes no product assembly or installation liability Copyright 2011 Salsbury Industries All rights reserved Rev 04 11 1 11
13. o promote drainage under the post The j top of the footing should be sloped for water runoff When digging the hole for the footing be careful to not puncture water sewer or gas lines l After digging the hole set the pedestal in the hole and fill the hole with the prepared concrete mix Prod the mix with a stick while filling to reduce any air pockets If you want to conceal the concrete pour it to within a few inches of the top of the hole and cover with soil after A the concrete has set Use a carpenter s level on the sides of the pedestal to ensure that the pedestal is aligned vertically Periodically check the vertical alignment of the pedestal as the concrete is curing SALSBURY INDUSTRIES 1010 East 62 Street Los Angeles CA 90001 1598 Phone 1 800 624 5269 Int l Phone 323 846 6700 Fax 1 800 624 5299 Int l Fax 323 846 6800 Installation instructions are provided as general guidelines It is advised that a professional installer be consulted Salsbury Industries assumes no product assembly or installation liability Copyright 2011 Salsbury Industries All rights reserved Rev 01 11 1 11 Mail Chests 4350 Bolt Mounted Pedestal Installation Instructions U S P S APPROVED Installing the Bolt Mounted Pedestal When you install a curbside or roadside mailbox make sure that it is easily accessible to the mail carrier By regulation a locked mailbox should be 41
14. olders and a pedestal A different instruction sheet is available for installing 4350 mail chests on a 3 wide spreader with 4315 newspaper holders and a pedestal Other installation instructions are available for installing the mail chest on a pedestal or on a deluxe post installing the mail chest on a spreader and installing the pedestal in a concrete footing When you install a curbside or roadside mailbox make sure that it is easily accessible to the mail carrier By regulation a locked mailbox should be 41 to 45 from the ground or street surface up to the point of mail entry The door should be set back 6 to 8 back from the front face of the curb or the road edge However you should check with your local postmaster to ensure that the mailbox is installed according to local regulations It is important to note that it is not the responsibility of mail carriers to open mailboxes that are locked accept keys for this purpose or lock mailboxes after delivery of the mail Spreader Installation to Pedestal All hardware to attach the spreader to the pedestal is included with the spreader To attach the spreader to the pedestal install four 4 5 16 18 X 1 long hex flange head bolts through the four 4 center square holes of the spreader and through the four 4 tapped holes on the top plate of the pedestal Cover the hex flange head bolts with cap plugs Hy SPREADER PEDESTAL U S P S APPROVED
15. protruding below the bottom of the spreader Repeat these steps for the remaining newspaper holder U S P S APPROVED oo CG NEWSPAPER HOLDERS NEWSPAPER HOLDERS SHOWN CUT AWAY FOR ILLUSTRATION SPREADER PEDESTAL Mail Chest Installation to Newspaper Holders All hardware to attach the mail chests to the newspaper holders is included with the newspaper holders To attach a mail chest to a newspaper holder install four 4 5 16 18 X 3 4 long carriage bolts into 4 square holes in the floor of the mail chest and through the four 4 square holes on the top of the newspaper holder Install 5 16 flat washers and 5 16 18 hex nuts on the ends of the four 4 bolts protruding below the top of the newspaper holder Cover the hex nuts with cap plugs Repeat these steps for the other mail chests Installation is now complete Additional hardware provided is not needed and may be discarded MAIL CHESTS Ih SHOWN CUT AWAY Mt FOR ILLUSTRATION tH MAIL CHESTS NEWSPAPER HOLDERS SPREADER PEDESTAL Phone 1 800 624 5269 Fax 1 800 624 5299 SALSBURY INDUSTRIES 1010 East 62 Street Los Angeles CA 90001 1598 Int l Phone 323 846 6700 Int l Fax 323 846 6800 Installation instructions are provided as general guidelines It is advised that a professional installer be consulted Salsbury Industries assumes no product assembly or installa
16. tion liability Copyright 2011 Salsbury Industries All rights reserved 11 1 11 Mail Chests 4350 In Ground Mounted Pedestal Installation Instructions U S P S APPROVED Installing the In Ground Mounted Pedestal or Post When you install a curbside or roadside mailbox make sure that it is easily accessible to the mail carrier By regulation a locked mailbox should be 41 to 45 from the ground or street surface up to the point of mail entry The door should be set back 6 to 8 back from the front face of the curb or the road edge However you should check with your local postmaster to ensure that the mailbox is installed according to local regulations Itis important to note that it is not the responsibility of mail carriers to open mailboxes that are locked accept keys for this purpose or lock mailboxes after delivery of the mail To install the in ground mounted pedestal begin by digging a hole for the concrete footing and then prepare the concrete The top surface of the footing should be about 12 by 18 See the illustration for the relative position of the rectangular footing to the pedestal and mailbox The concrete should extend into the ground 24 or greater if your local frost line is deeper Installing the concrete below the frost line will prevent movement during ground freezing and thawing The bottom of the hole for the concrete footing should be filled with a depth of about 6 of gravel t
17. urb or the road edge However you should check with your local postmaster to ensure that the mailbox is installed 17 1 4 according to local regulations It is important to note that it is not the responsibility of mail carriers to open mailboxes that are locked accept keys for this purpose or lock mailboxes after delivery of the mail QL It is recommended to have the unit present before starting the wall or column construction to obtain the best possible installation The rough opening should be sized approximately 1 2 larger than the outside dimensions of the unit Due to construction variations and method of fastening the unit in the installation the fastening hardware is not included Choose fasteners that are appropriate for the construction method Note remove flag from mail chest before installing into column or wall SALSBURY INDUSTRIES 1010 East 62 Street Los Angeles CA 90001 1598 Phone 1 800 624 5269 Int l Phone 323 846 6700 Fax 1 800 624 5299 Int l Fax 323 846 6800 Installation instructions are provided as general guidelines It is advised that a professional installer be consulted Salsbury Industries assumes no product assembly or installation liability Copyright 2011 Salsbury Industries All rights reserved Rev 01 11 1 11 Mail Chests 4350 Newspaper Holder on Pedestal Installation Instructions U S P S APPROVED Thank you for selecting Salsbury s 4350 mail chest m
Download Pdf Manuals
Related Search