Fire Sense 61541 Instructions / Assembly
Contents
1. RESULT IN SEVERE PROPERTY DAMAGE AND OR PERSONAL INJURY IN NO EVENT WILL WELL TRAVELED LIVING OR ITS DIRECTORS OFFICERS OR AGENTS BE LIABLE TO THE PURCHASER OR ANY THIRD PARTY WHETHER IN CONTRACT IN TORT OR ON ANY OTHER BASIS FOR ANY INDIRECT SPECIAL PUNITIVE EXEMPLARY CONSEQUENTIAL OR INCIDENTAL LOSS COST OR DAMAGE ARISING OUT OF OR IN CONNECTION WITH THE SALE MAINTENANCE USE OR INABILITY TO USE THE PRODUCT EVEN IF WELL TRAVELED LIVING OR ITS DIRECTORS OFFICERS OR AGENTS HAVE BEEN ADVISED OF THE POSSIBILITY OF SUCH LOSSES COSTS OR DAMAGES OR IF SUCH LOSSES COSTS OR DAMAGES ARE FORESEEABLE IN NO EVENT WILL WELL TRAVELED LIVING OR ITS OFFICERS DIRECTORS OR AGENTS BE LIABLE FOR ANY DIRECT LOSSES COSTS OR DAMAGES THAT EXCEED THE PURCHASE PRICE OF THE PRODUCT SOME JURISDICTIONS DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES SO THE ABOVE LIMITATION EXCLUSION MAY NOT APPLY TO THE PURCHASER This limited warranty gives you specific legal rights and you may also have other rights which vary from jurisdiction to jurisdiction The provisions of the United Nations Convention on Contracts for the Sales of Goods shall not apply to this limited warranty or the sale of products covered by this limited warranty IMPORTANT NOTICE Do NOT eturn to place of purchase For customer service and warranty issues contact our Customer Service Center at 866 985 7877 OR Email cservice wellt2. Burner makes popping noises during use Note A slight pop is normal when burner is extinguished e Carbon deposits may create a fire hazard Keep dome and emitter clean at all times e Do not clean heater with combustible or corrosive cleaners Use warm soapy water e Do not paint the burner the burner access panel or dome COMMERCIAL 61541 FOR YOUR SAFETY BEARE OF SPIDERS Spiders or small insects can get into the burner tube or other openings of your heater and spin webs or build nests These obstructions can lead to gas flow problems It is important to make frequent inspections of these areas and clean them when necessary Before operating your heater for the first time be sure to check for obstructions that may have occurred during shipment US 2 ASSEMBLY INSTRUCTIONS COMMERCIAL 61541 ZX 15 95 3 13x 0 18 M6 11x US To avoid cuts you have to wear safety gloves during installation Get help by a second person during the installation Remove the protective foil from all parts first COMMERCIAL 61541 US COMMERCIAL 61541 US COMMERCIAL 61541 Ba LEAK CHECKING see page 14 US 3 OPERATION Caution Do Not attempt to operate the heater until you have read and understood the warnings section in this manual MOUNT THE HEATER ON THE GROUND FIRST 3 1 TURNING THE GAS SUPPLY ON CONNECT THE GAS HOSE AND REGULATOR ASSEMBL
3. a Constructed an marked in accordance with the Specifications for LP gas cylinders of the U S Department of Transportation DOT or the Standard for Cylinders Spheres and Tubes for Transportation of Dangerous Goods and Commisiion CAN CSA B339 as applicable b Provided with a listed overfilling prevention device and c Provided with a cylinderconnection device compatible with the connection for the appliance Storage of an appliance indoors is permissible only if the cylinder is disconected and removed from the appliance A cylinder must be stored outdoors in a well ventilated area out of the reach of children A disconnected cylinder must have dust caps tightly installed and must not be stored in a building garage or any other enclosed area Do not store a spare LP gas cylinder under or near this appliance Never fill the cylinder beyond 80 percent full If the information above is not followed exacly a fire causing death or serious injury may occur Caution Liquid propane LP gas is flammable and hazardous if handled improperly Become aware of the characteristics before using any LP product e LP Characteristics Flammable explosive under pressure heavier than air settles in pools in low areas e In its natural state propane has no odor For your safety an odorant is added and has a bad smell e Contact with LP can cause freeze burns to skin e This heater is shipped from the factory for LP gas use only e Use only De
4. There 15 adequate fresh air ventilation Heater 15 away from gasoline or other flammable liquids or vapors Heater is away from windows air intake openings sprinklers and other water sources Heater is at least 36 clearance top and 24 clearance side of combustible materials Heater is on a hard and level surface There are no signs of spiders or insect nests All burner passages are clear All air circulation passages are clear Children pets clothing flammable materials and items that can be damaged from radiant heat are away from the heater Children and adults in the area have been alerted to the high temperature hazards especially burns and clothing fires Children and adults in the area have been warned not to touch the heater near the burner during operation and until unit has cooled AFTER OPERATION L L L L Gas control is in OFF position Gas tank valve is OFF Disconnect Gas Line Heater is upright in a secure location US 9 CLEANING AND MAINTENANCE Your heater has been produced from highly weather resistant materials and only minimum cleaning and maintenance 1 required Cleaning must be performed when the heater is cold Your patio heater will live longer if it is cleaned and maintained properly It is very important that the air required for the combustion process is not blocked going to the burner Vents and other openings must be kept free of dirt and spiders webs The burner lower part is one u
5. COMMERCIAL PATIO HEATER FIRESENSE 48 000 BTU COMMERCIAL PATIO HEATER WARNING For Outdoor Use Only WARNING Improper installation adjustment alteration service or maintenance can cause property damage injury or death Read the installation operation and maintenance instructions thoroughly before installing or servicing this equipment Save these instructions for future reference Please ensure the owner of the heater retains the manual for future reference 5167 ANS Z83 26 2007 CSA 2 37 2007 Sar Os Re Gas Fired Infrared Patio Heater jo lt CERTIFIED US ITEM 61541 US Portable Infra Red open air heater for non residental space heating Assembly and usage instructions Questions problems missing parts Before returning to your retailer call our customer service hotline at 1 866 985 7877 9 a m 6 p m EST Monday Friday or email at cservice welltraveled net US WARNING FOR YOUR SAFETY If you smell gas 1 Shut off the gas to the appliance 2 Extinguish any open flame 3 If odor continues keep away from the appliance and immediately call your gas supplier or fire de partment WARNING FOR YOUR SAFETY 1 Gas leaks may cause a fire or ex plosion which can cause serious bodily injury death or damage to property 2 You must follow all leak checking procedures as outlined in step 8 before operating this unit 3 Never use an open flame to check for lea
6. ERCIAL 61541 spoon several drops of solution onto the connections as illustrated if no bubbles appear then the connection is secure Reattach the regulator making sure that the connection is tight Repeat the leak checking procedure described above If you still see bubbles after several attempts DO NOT USE THE HEATER Contact service for assistance Your heater was designed and approved for Outdoor use only Do NOT use it inside an enclosure Make sure that all combustibles are maintained and that there are no flammable liquids or vapors in the vicinity of the heater Make sure there is no obstruction to air ventilation Be sure that all gas connections are tight and there are no leaks Any components removed during the assembly or servicing of the heater must be reinstalled 3 2 BEFORE LIGHTING The heater components should be thoroughly inspected before each use and at least every two years by a qualified service person Inspect the visible portion of the hose before each use of the appliance Portions that are located within the heater post inspect the entire hose assembly at least annually The hose assembly must be replaced prior to the appliance being put into operaton if there is evidence of excessive abrasion or wear or if the hose is damaged The replacement hose assembly shall be that specified by the manufacturer A LEAK CHECKING see page 14 US 3 3 LIGHTING 1 Push control knob IN and tu
7. Y TO THE TANK Note Use only a Department of Transportation DOT approved 20 pound cylinder with an Type 1 connection with Quick Connect Coupler safety valves When the Cylinder is empty it should wheight 18 pounds CHECK FOR LEAKS Make a solution of 2 3 oz of leak checking solution by mixing one part liquid dishwashing soap and three parts water Follow the procedure below LEAK CHECKING FUEL TUBE CONNECTION Step 1 Turn cylinder valve on by turning anti clockwise Step 2 Check fuel tube connection for leaks To check for leaks spoon several drops of solution onto the connections as illustrated Step 3 Inspect the solution for bubbles If no bubbles appear then the connection is secure If bubbles appear then there 1 a leak Turn OFF the cylinder valve Undo the connection and inspect the surface of the cone to make sure they are clean Reconnect by using two wrenches one on either side of the connection Repeat the leak checking procedure described above If you still see bubbles after several attempts i DO NOT USE THE HEATER Contact service for assistance LEAK CHECKING GAS LINE AND CYLINDER CONNECTIONS Step 1 Turn cylinder valve on by turning anti clockwise Step 2 Check connections and valve for leaks To check for leaks Step 3 Inspect the solution for bubbles If bubbles appear then there is a leak Turn OFF the cylinder valve Release the regulator connection to the cylinder COMM
8. and yellow flame These flames should not be yellow or produce thick black smoke indicating an obstruction of airflow through the burners The flame should be blue with straight yellow tops 3 5 RE LIGHTING Turn Control Knob to OFF Wait at least 5 minutes to let gas dissipate before attempting to relight Repeat the Lighting steps on prior page 3 6 SHUTDOWN AN WARNING 1 Turn the burner control knob clockwise to the igniting position FOR YOUR SAFETY 2 Depress the control knob and turn it clockwise to OFF Heater will be hot after use 3 Turn tank valve clockwise to OFF Disconnect the regulator when heater 1 not in use Handle with extreme care Place dust cap on cylinder valve outlet whenever the cylinder is not in use Only install the type of dust cap on the cylinder valve outlet that is provided by the cylinder valve Other types of caps or plugs may result in leakage of propane COMMERCIAL 61541 4 OPERATION CHECKLIST For a safe and pleasurable heating experience perform this check before each use BEFORE OPERATING El L L 0000000000 am familiar with entire owner s manual and understand all precautions noted in Safety First All components are properly assembled intact and operable No alterations have been made All gas connections are secure and do not leak Wind velocity is below 10 mph Outdoor temperature 1 greater than 40 degrees F Heater is outdoors outside any enclosure
9. ed to direct sunlight or excessive heat Note Wait until heater is cool before covering If using a cover ensure is is tightly fitted or secured support it during high winds COMMERCIAL 61541 7 SPECIFIACTIONS Certifications ANS Z83 26 CSA 2 37 2007 Gas Fired Outdoor Infrared Patio Heater Rating Maximum 48 000 BTU hr input Heat Range Up to 20 foot diameter Fuel Liquid Propane Gas LP Tank Size Nominal 20 5 Gallon Inlet gas supply pressure Maximum 150 PSI Minimum 5PSI Mainfold Pressure 11 00 in w c Safety Features 100 Burner shut off Tilt switch Manufacturer Enders Colsman AG Made in China 8 SERVICE ADDRESS Before returning to your retailer call our customer service hotline at 1 866 985 7877 9 a m 6 p m EST Monday Friday or email at cservice welltraveled net Well Traveled Living P O Box 4 Amelia Island FL 32035 Email cservice welltraveled net Distributed By Well Traveled Living 71658 Street Amelia Island FL 32034 Toll Free 866 WTL SUPP Web www wtliving com Email cservice welltraveled net 1 YEAR LIMITED WARRANTY Customers in the Continental US All components are warranted for a period of 1 year after date of purchase by the original owner against defects in materials and workmanship under normal use This warranty does NOT cover normal wear and weathering assembly and or maintenance OR use in a commercial application if
10. eum Gases ANSI NFPA 58 or CSA B149 1 Natural Gas and Propane Installation Code The installation must confirm with local building codes or in the absence of local codes with the current CAN 1 B149 installation codes THE CONVERSION SHALL BE CARRIED OUT BY AMANUFACTURE S AUTHORISED REPRESENTATIVE IN ACCORDANCE WITH THE REQUIREMENTS OF THE MANUFACTURER PROVINCAL OR TERRITORIAL AUTHORITIES HAVING JURISDICTION AND IN ACCORDANCE WITH THE REQUIREMENTS OF THE CAN CGA B149 1 OR CAN CGA B149 2 INSTALLATION CODES US 1 SAFETY FIRST A Read and become familiar with this entire manual especially the following precautions If you are unsure of anything in these instructions STOP and contact for assistance This application is for outdoor use only outside any enclosure Always make sure there 1 fresh air ventilation e Always maintain at least 36 clearance top and 24 clearance side from combustible materials Always place heater on a hard and level surface and mounted a Do not use if the wind velocity is greater than 10 miles per hour Ceiling e Unit will operate at reduced efficiency below 40 F 5 C e Keep sprinklers and other water sources away from burner and controls e Always use extreme caution when near heater Alert both children and adults to the hazards of high temperatures especially to avoid burns or clothing catching fire e Young children and pets should be carefully supervised
11. ks WARNING FOR YOUR SAFETY Do not store or use gasoline or other flammable vapours and liquids in the vicinity of this or any other appliance An LP cylinder not connected for use shall not be stored in the vicinty of this or any other appliance WARNING California Proposition 65 Chemicals known to the state of California to cause cancer birth defects or other reproductive harm are created by the combustion of propane WARNING Purchaser assumes all risk in the assembly and operation of this unit Failure to follow this manual s WARNINGS and instructions can result in severe personal injury death or property damage Do not use in an explosive atmosphere Keep heater away from areas where flammable liquids gasoline vapours or explosives are stored or used WARNING Beware of sharp edges ensure gloves are worn on assembly COMMERCIAL 61541 TABLE OF CONTENTS Page 1 SAFETY FIRST 4 5 2 ASSEMBLY INSTRUCTIONS in 11 steps 6 13 3 OPERATION 14 3 1 BEFORE TURNING GAS SUPPLY 14 3 2 BEFORE LIGHTING 19 3 3 SINS 16 3 4 WHEN HEATER IS 16 35 RE LIGHTING 16 3 6 SHUTDOWN 16 4 OPERATION CHECKLIST 17 CLEANING amp MAINTENANCE 18 6 STORAGE 18 SPECIFICATIONS 19 8 SERVICE ADDRESS 19 9 WARRANTY 20 The use and installation of this product must conform to local codes In absence of local codes use the National Fuel and Gas Code ANSI Z223 1 NFPA 54 Storage and Handling of Liquid Petrol
12. model is not designated as a commercial model At Well Traveled Living s sole discretion products under warranty will be repaired and or replaced at no charge to the customer Any returns sent back to Well Traveled Living must be sent via prepaid freight and in the original retail packaging For warranty service contact Well Traveled Living at the address phone numbers or internet site and email listed in this owner s manual Be sure to have your sales receipt date of purchase and catalogue model numbers available when calling All warranty service will be coordinated by the Well Traveled Living s Amelia Island Florida service center This warranty is extended only to the original purchaser Proof of purchase will be required before warranty service is rendered The sales receipt is the only valid proof of purchase This warranty only covers failures due to defects in materials or workmanship which occur during normal use Failures and or damage which result from accident negligence misuse abuse neglect mishandling alteration or modification failure to maintain improper assembly or maintenance service by unauthorized agency or use of unauthorized components or damage that is attributable to acts of God are NOT covered THERE ARE NO EXPRESS WARRANTIES EXCEPT AS LISTED ABOVE PURCHASER ASSUMES ALL RISKS IN THE ASSEMBLY AND OPERATION OF THIS UNIT FAILURE TO FOLLOW WARNINGS AND OPERATIONAL INSTRUCTIONS CONTAINED IN THIS MANUAL
13. nit You can not clean it Stainless steel models Use a stainless steel cleaner product on the main components of the heater cylinder cover base and post Never use a cleaning agent that is flammable or corrosive Never spray any cleaning product on the emitter grid or burner area Painted models Wash all painted parts of the heater with a soapy solution and protect it with a coat of automobile car wax a couple of times per year or as required dependent upon your local weather and climate conditions If you need to touch up a painted heater only paint the post and base portions Never paint the emitter grid lighting instructions valve or control knob area or the LP cylinder The burner ports must also be kept clear so that the burner burns evenly and the flow of gas is not restricted If the heater is not performing adequately it will be necessary to check the burner In a salt air or ocean enviroment corrosion and rust occur at a far greater rate than in non ocean areas You will need to check more frequently for corrosion and replace parts as required 6 STORAGE Turn control knob OFF Disconnect LP source and move to secure well ventilated location outdoors Store heater upright in an area sheltered from direct contact with inclement weather such as rain sleet hail snow dust and debris If desired cover heater to protect exterior surfaces and to help prevent build up in air passages Never leave the LP cannister expos
14. partment of Transportation DOT approved 20 Ib LP gas tanks Same as those commonly used on gas grills with Acme 1 safety valves These valves can be quickly identified because they have external and internal threads e Never use an LP tank with a damaged body valve collar or foot ring e Dented or rusted LP tanks may be hazardous and should be checked by your LP gas supplier e The tank supply system must be arranged for vapour withdrawal e The tank used must include a collar to protect the tank valve When heater is not in use turn LP tank OFF Always perform a leak test on gas connections whenever a tank is connected Never use a flame to test for leaks Do not smoke while performing a leak test Caution is essential to keep the heater s valve compartment burners and circulating air passages clean e Spiders and insects can create a dangerous condition that may damage the heater or make it unsafe Keep the burner area clean of all spiders webs or insects e Inspect the heater before each use e Have heater inspected annually and repairs should be made by a qualified service person e Check the heater immediately if any of the following conditions exist e The smell of gas in conjunction with extreme yellow tipping of burner flames e Heater does not reach the proper temperature Note At temperatures less than 40 F heat output will be reduced e Heater s glow is excessively uneven
15. raveled net Customer Service Hours Mon Fri 9 00 a m 6 00 p m EST Fire Sense Mojave Sun and Well Traveled Living are registered trademarks of Well Traveled Imports Inc All assembly instruction presentations are the property of Well Traveled Imports Inc and are protected by U S copyrights and trademarks All rights reserved
16. rn to OFF WARNING 2 Turn the gas tank valve ON FOR YOUR SAFETY 3 Depress the burner control knob and turn it anticlockwise to the igniting position careful when attempting to manually 4 Press the piezo ignition concurrently with your other hand and hold the pressed knob ignite this heater Holding in the control for about 10 seconds after ignition in order to activate the ignition safety switch Should knob for more than 5 seconds before igniting the gas fail to ignite after pressing the piezo ignition 3 or 4 times leave the appliance the gas will cause a ball of flame upon ignition for about 5 minutes that any gas to clear and then repeat the process Note It is possible to ignite the burner using other ignition devices gas lighters matches through the 0 73 inch aperture in the bottom of the burner Caution Avoid inhaling fumes emitted from the heater s first use Smoke and odour from the burning of oils used in manufacturing will appear Both smoke and odor will dissipate after approximately 30 minutes The heater should NOT produce thick black smoke Note The burner may be noisy when initially turned on To eliminate excessive noise from the burner turn the Control Knob to the small flame position Then turn the knob to the level of heat desired 3 4 WHEN HEATER IS ON Emitter screen will become bright red due to intense heat The colour is more visible at night Burner will display tongues of blue
17. when they are in the area of the heater e Do not hang clothing or other flammable materials either on or near the heater Any guard or other protective device removed for servicing the heater must be replaced prior to operating the heater Certain materials or items when stored under the heater will be subjected to radiant heat and could be seriously damaged Do not alter heater in any manner e The pressure regulator and hose assembly supplied with the appliance must be used and replacements must be those specified by the manufacturer regulator becomes damaged use only a factory supplied replacement e Inspect heater before each use If a damaged part is detected do not operate until an original equipment replacement part has been properly installed Use of unauthorized parts will void warranty and create an unsafe condition Please call 847 850 5335 for help e Prior to operating the heater replace any guards or protective devices removed for servicing e During operation do not touch the burner assembly The surface of the heater s emitter can reach temperatures approaching 1600 F e After shutdown do not touch the burner assembly until the heater has cooled approximately 45 minutes after use Wall Notice This product should not be used with any fuel other than liquid propane Use of other fuels will detract from the heaters performance and will void your warranty The used LP gas cylinder must be
Download Pdf Manuals
Related Search