Fire Sense 60262 Instructions / Assembly
Contents
1. AWAY from heater when heater is not in use e Store heater upright in an area sheltered from direct contact with inclement weather such as rain sleet hail snow and debris lf desired cover heater to protect exterior surfaces and to help prevent build up in air passages 11 PROBLEM Pilot will not light Pilot will not stay on Burner will not light TROUBLESHOOTING PROBABLE CAUSE Fuel canister empty Opening blocked Air in supply system Loose connections Debris around pilot Loose connections Gas leak Lack of fuel pressure Pressure Is low Opening blocked Control not ON Pilot light assembly bent Not in correct location SOLUTION Replace fuel canister Clean opening Purge air from system Check all fittings Clean dirty area Tighten connections Check connections Canister near empty Replace fuel canister Canister near empty Replace fuel canister Remove and clean Turn knob to ON Place pilot properly Position properly and retry Distributed By Well Traveled Living 716 S 8 Street Amelia Island FL 32034 Toll Free 866 WTL SUPP Web www wtliving com Email cservice welltraveled net 1 YEAR LIMITED WARRANTY Customers in the Continental US All components are warranted for a period of 1 year after date of purchase by the original owner against defects in materials and workmanship under normal use This warranty does NOT cover normal wear and weathering assembly and or maintenance OR us2. pcs M6x15mm bolts to fix the tank housing to the base and cast iron weight Note weight is preassembled to base 2 2 Tighten the bolts as shown above 4 1 Fix the regulator to the tank housing with the M5x10mm bolt and M5 nut STEP5 P m F W 5 1 Fix 3 pcs pins of 60mm length to the emitter screen with 3 pcs flange 6 1 Put the emitter screen on the burner nuts then tighten them 6 2 Use 4 pcs 3 16 bolts to connect the emitter screen to the burner Tighten the bolts 7 1 Put the guard on the burner over the emitter screen 8 1 Put 3 pcs washers on each pin of the 7 2 Put the ends of the guards into the 60mm length holes of the burner 10 1 Fasten the reflector with 3 pcs M6 castle nuts 9 1 Put the reflector through the pins and on the washers STEP 11 STEP 12 11 1 Turn off the control Knob of the burner 11 2 Fix the 1 02 lbs gas tank not 12 1 Close the door plate and lock it included to the regulator rotate the gas with the handle rotate the handle 90 tank clockwise toward the regulator until degrees tightened SAFETY FIRST Read and become familiar with this entire manual especially the following precautions Caution This appliance is for outdoor use only outside any enclosure Always make sure there is fresh air ventilation Use only outdoors in a well ventilated soace Never use in a building garage or any other enclosed area Always maintain at least 1
3. will become bright red due to intense heat The color is more visible at night Burner will display tongues of blue flame These flames should not be yellow or produce thick black smoke indicating an obstruction of airflow through the burners lf yellow flame is detected turn off heater and gas supply and consult Troubleshooting on page 12 Re lighting Note For your safety control knob cannot be turned to Pilot without first depressing control knob in Off position and then rotating to Pilot 1 Turn gas control knob to Off 2 Wait 5 minutes to let gas dissipate before attempting to relight burner 3 Repeat the Lighting steps 2 and 3 To turn heater OFF 1 Rotate gas knob to Off position Normally burner will make a slight popping sound when extinguished 2 Remove door plate 3 Unscrew gas canister from regulator and store gas canister AWAY from heater when heater is not in use 4 Close door plate Note After use some discoloration of the emitter screen is normal 10 AFTER OPERATING Make sure Gas control is in OFF position Unscrew gas canister from regulator and store gas canister AWAY from heater when heater is not in use Store heater in an upright position in a secure location MAINTENANCE e To enjoy years of outstanding performance from your heater make sure you perform the following maintenance activities on a regular basis e Air flow must be unobstruct
4. 8 clearance top and 24 clearance side from combustible materials Always place heater on a hard and level surface Do not use if the wind velocity is greater than 10 miles per hour Unit will operate at decreased efficiency below 40 degrees F 5 degrees C Keep sprinklers and other water sources away from burner and controls Always use extreme caution when near heater Alert both children and adults to the hazards of high temperatures especially to avoid burns or clothing catching fire Young children and pets should be carefully supervised when they are in the area of heater Do not place clothing or other flammable materials on or near heater Any guard or other protective device removed for servicing the heater must be replaced prior to operating the heater Certain materials or items when stored under heater will be subjected to radiant heat and could be seriously damaged Do not alter heater in any manner Inspect heater before each use If a damaged part is detected do not operate until an original equipment replacement part has been properly installed Use of unauthorized parts will void warranty and create an unsafe condition Do not attempt to use this appliance without a functional factory supplied gas regulator in place If regulator becomes damaged use only a factory supplied replacement Prior to operating heater replace any guards or protective devices removed for servicing During operation do not touch bu
5. OWNER S MANUAL Tabletop Heater Safety First Read and become familiar with this entire manual Please retain this manual for reference B c us TABLE OF CONTENTS Read These Safety INStructions cceeeeeeeee eens Contents BreakCOwn ccccceeccecceccecceueeuueuueennnas Screw Packing LelSlicesesrcisacancentitanmuveadtenenadinednaahervaniawent Assembly Procedu Eieren PAS ODY rane a E E E TE SLY EE E I E TE E EATE EA Tabletop Heater Location ccceeeeeeeeeeeeeneeeeees Checking For LOAKS sa siatasvedownmndagarnentwinn teaninespehalanseurioncs DEIC OMe la UNG rrain EE ODETI cet tesscnce nese nceatanmrianeemecaccucanwaceieassescenaus Alter ODEN O eerren MaINtCQNANCE 0 ccc cece cece cece cc cececuacucucucuacucutuneucuuuuvanas Storage TVOUDIGSNOOTAG oic cec c cece caret wevneee sein vaca deavs eee eae weeseedt READ THESE SAFETY INSTRUCTIONS If you smell gas e Shut off gas to the appliance e Extinguish any open flame e f odor continues immediately call your gas supplier or your Fire Department WARNING Failure to comply with these instructions could result in a fire or explosion that could cause serious bodily injury death or property damage ATTENTION Only to be used outdoors Warning Accessible parts may be very hot Keep young children away Turn off the gas supply at the gas container after use Any modification of the app
6. SEVERE PROPERTY DAMAGE AND OR PERSONAL INJURY IN NO EVENT WILL WELL TRAVELED LIVING OR ITS DIRECTORS OFFICERS OR AGENTS BE LIABLE TO THE PURCHASER OR ANY THIRD PARTY WHETHER IN CONTRACT IN TORT OR ON ANY OTHER BASIS FOR ANY INDIRECT SPECIAL PUNITIVE EXEMPLARY CONSEQUENTIAL OR INCIDENTAL LOSS COST OR DAMAGE ARISING OUT OF OR IN CONNECTION WITH THE SALE MAINTENANCE USE OR INABILITY TO USE THE PRODUCT EVEN IF WELL TRAVELED LIVING OR ITS DIRECTORS OFFICERS OR AGENTS HAVE BEEN ADVISED OF THE POSSIBILITY OF SUCH LOSSES COSTS OR DAMAGES OR IF SUCH LOSSES COSTS OR DAMAGES ARE FORESEEABLE IN NO EVENT WILL WELL TRAVELED LIVING OR ITS OFFICERS DIRECTORS OR AGENTS BE LIABLE FOR ANY DIRECT LOSSES COSTS OR DAMAGES THAT EXCEED THE PURCHASE PRICE OF THE PRODUCT SOME JURISDICTIONS DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES SO THE ABOVE LIMITATION OR EXCLUSION MAY NOT APPLY TO THE PURCHASER This limited warranty gives you specific legal rights and you may also have other rights which vary from jurisdiction to jurisdiction The provisions of the United Nations Convention on Contracts for the Sales of Goods shall not apply to this limited warranty or the sale of products covered by this limited warranty 1IMIPORTANT NOTICE Do NOT return to place of purchase For customer service and warranty issues contact our Customer Service Center at 866 985 7877 OR Email cservice welltraveled net Cus
7. ak Wind velocity is below 10 mph Outdoor temperature is greater than 40 degrees F Heater is outdoors outside any enclosure There is adequate fresh air ventilation Heater is away from gasoline or other flammable liquids or vapors Heater is away from windows air intake openings sprinklers and other water sources e Heater is at least 18 clearance top and 24 clearance side from combustible materials Heater is on a hard and level surface There are no signs of spider or insect nests All burner passages are clear All air circulation passages are clear Children pets clothing flammable materials and items that can be damaged from radiant heat are away from the heater Children and adults in the area have been alerted to the high temperature hazards especially burns and clothing fires Children and adults in the area have been warned not to touch heater near emitter during operation and until unit has cooled completely OPERATION Inspect the heater before each operation Before Turning Gas Supply ON Your heater was designed and approved for OUTDOOR USE ONLY DO NOT use it inside a building garage or any other enclosed area Make sure surrounding areas are free of combustible materials gasoline and other flammable liquids Ensure that there is no obstruction to air ventilation Be sure all gas connections are tight and there are no leaks Be sure the access panel is clear of debris Be sure any com
8. e in a commercial application At Well Traveled Living s sole discretion products under warranty will be repaired and or replaced at no charge to the customer Any returns sent back to Well Traveled Living must be sent via prepaid freight and in the original retail packaging For warranty service contact Well Traveled Living at the address phone numbers or internet site and email listed in this owner s manual Be sure to have your sales receipt date of purchase and catalogue model numbers available when calling All warranty service will be coordinated by the Well Traveled Living s Amelia Island Florida service center This warranty is extended only to the original purchaser Proof of purchase will be required before warranty service is rendered The sales receipt is the only valid proof of purchase This warranty only covers failures due to defects in materials or workmanship which occur during normal use Failures and or damage which result from accident negligence misuse abuse neglect mishandling alteration or modification failure to maintain improper assembly or maintenance service by unauthorized agency or use of unauthorized components or damage that is attributable to acts of God are NOT covered THERE ARE NO EXPRESS WARRANTIES EXCEPT AS LISTED ABOVE PURCHASER ASSUMES ALL RISKS IN THE ASSEMBLY AND OPERATION OF THIS UNIT FAILURE TO FOLLOW WARNINGS AND OPERATIONAL INSTRUCTIONS CONTAINED IN THIS MANUAL CAN RESULT IN
9. ed Keep controls burner and circulating air passageways clean Signs of possible blockage include Gas odor with extreme yellow tipping of flame heater does NOT reach the desired temperature heater glow is excessively uneven e Spiders and insects can nest in burner or orifices This can cause the heater to make popping noises This dangerous condition can damage heater and render it unsafe for use Clean burner holes by using a heavy duty pipe cleaner e Compressed air may help clear away smaller particles e Carbon deposits may create a fire hazard Clean dome and emitter with warm soapy water if any carbon deposits develop Note In a salt air environment Such as near an ocean corrosion occurs more quickly than normal e Frequently check for corroded areas and repair them promptly e Keep exterior surfaces clean STORAGE Between uses e Turn control knob to OFF position e Unscrew gas canister from regulator and store gas canister AWAY from heater when heater is not in use e Store heater upright in an area sheltered from direct contact with inclement weather such as rain sleet hail snow and debris lf desired cover heater to protect exterior surfaces and to help prevent build up in air passages NOTE Wait until heater is completely cooled before covering During periods of extended inactivity or when transporting e Turn control knob to OFF position e Unscrew gas canister from regulator and store gas canister
10. liance may be dangerous FOR YOUR SAFETY Gas leaks may cause a fire or explosion that can cause serious bodily injury or death or damage to property You must follow all leak checking procedures before operating this unit Never use an open flame to check for leaks WARNING Do not store or use gasoline or other flammable vapors or liquids in the vicinity of this or any other appliance Danger Carbon Monoxide hazard 1 This appliance can produce carbon monoxide which has no odor 2 Using it in an enclosed space can kill you 3 Never use this appliance in an enclosed space such as a camper tent car or home e Do NOT touch or move heater for at least 45 minutes after use e Dome ts hot to the touch e Allow dome to cool completely before touching CONTENTS BREAKDOWN M6 Castle nut 3 1 1 Emitter screen 1 14 1 Door Plate Base 17 Handle KACER SCREW PACKAGING LIST M6 Castle Nut M5x10mm bolt amp M5 nut e M6x15mm bolt M6 flange nut ASSEMBLY PROCEDURE Tools needed not included e Adjustable opening wrench 2 20 cm long e Slip joint pliers 23 cm long e Philips screwdriver w medium blade 1 1 Remove all parts of the heater from the packaging NOTE Plastic ring on tank housing should already be in place but if it is not slide the plastic ring over the bottom of tank housing 3 1 Put the burner on the tank housing then fix them with 4 pcs 3 16 bolts ASSEMBLY 2 1 Use 4
11. ponent removed during assembly or servicing is replaced prior to starting Before Lighting Heater should be thoroughly inspected before each use and by a qualified service person at least annually lf relighting a hot heater always wait at least 5 minutes for gas to dissipate Off Off O Lighting 1 Make sure control knob is in the Off position 2 Push in and rotate the gas control knob to Pilot position Depress gas control know for 30 seconds to allow air to purge Once gas reaches burner depress igniter button while holding gas control knob in 3 Once burner is lit hold control Knob in for at least 30 seconds and release 4 If burner does not stay lit turn control knob to Off position and wait 5 minutes and repeat 2 and 3 5 Once burner is lit rotate control knob to desired heating level LO low HI high lf you experience any ignition problem turn off the heater and gas supply and consult Troubleshooting on page 12 Caution Avoid inhaling fumes emitted from heater s first use Smoke and odor from the burning of oils used in manufacturing will appear Both smoke and odor will dissipate after approximately 30 minutes The heater should NOT produce think black smoke Note The burner may be noisy when initially turned on To eliminate excessive noise from the burner turn the control knob to LO position Then turn the knob to level of heat desired When heater is ON Emitter screen
12. rner assembly The surface of heater s emitter can reach temperatures approaching 1600 degrees F After shutdown do not touch burner assembly until heater has cooled completely approximately 45 minutes after use TABLETOP HEATER LOCATION CEILING The tabletop heater is for outdoor use only Always 24 ensure that adequate fresh air ventilation is provided Always maintain proper clearance to combustible materials i e top 18 and sides 24 minimum Tabletop heater must be located on a stable and strong surface Never operate heater in an explosive atmosphere SUS like in areas where gasoline or other flammable liquids or vapors are stored WALL CHECKING FOR LEAKS Make 1 2 oz of leak solution by mixing one part liquid dishwashing soap and 3 parts water Spoon several drops or use squirt bottle of the solution onto the regulator canister connections Inspect the connections and look for bubbles If NO bubbles appear the connection is safe lf bubbles appear there is a leak e Loosen and re tighten this connection e Re check for leak by repeating this procedure lf you continue to see bubbles after several attempts disconnect the propane source BEFORE OPERATING e lam familiar with entire owner s manual and understand all precautions noted in Safety First All components are properly assembled intact and operable No alterations have been made All gas connections are secure and do not le
13. tomer Service Hours Mon Fri 9 00 a m 6 00 p m EST Fire Sense Mojave Sun and Well Traveled Living are registered trademarks of Well Traveled Imports Inc All assembly instruction presentations are the property of Well Traveled Imports Inc and are protected by U S copyrights and trademarks All rights reserved
Download Pdf Manuals
Related Search