American Standard 2470002.011 Installation Guide
Contents
1. 14 In 356mm FLOOR LOADING PROJECTED AREA PTS 18 9 CUBE FT3 _ LLL 88 7 WHIRLPOOL ELECTRICAL SPECIFICATIONS SYSTEM I PUMP 1 6 HP 9 7 AMPS 120V 55 Lbs Sq Ft 223 Kgs Sq m GENERAL INSTALLATION INFORM ATION THANK YOU for selecting an American Standard bath Your new bath is shipped to you after careful inspection The whirlpool version is completely assembled with pump motor and system piping All you need to finish the installation are your selected fittings and electrical connections for a whirlpool To insure maximum performance and pleasure from this product please follow the instructions and cautions List of Optional Components not included Safe T Heater 9075 120 Tile Bead Kit 751755 100 see your American Standard Distributor List of Required Components not included Drain 1583 470 Bath Filler see your American Standard Distributor List of Required Tools and Supplies Tools Supplies evel Nails e Tape Measure e Putty e Pipe Wrench e Caulking waterproof e Slip J oint Pliers 1 x3 or 2 x4 Screw Driver Stringers e Standard e Drop Cloth W oodworking Tools e 15 amp GFCI Personal Safety Outlet Equipment Cement Plaster Caulking Gun Grout Carefully uncrate and inspect your new bath for any shipping damage If such damage is found report it to your vendor immediately After inspection and during installation protect th2. legal rights You may have other statutory rights that vary from state to state or from province to province in which case this warranty does not affect such statutory rights For service under these warranties it is suggested that a claim be made through the contractor or dealer from or through whom the product was purchased or that a service request including a description of the product model and of the defect be sent to the following address In the United States AMERICAN STANDARD INC P O Box 6820 Piscataway New Jersey 08855 Attn Director of Consumer Affairs For residents of the United States warranty information may also be obtained by calling the following toll free number 800 442 1902 In Canada AMERICAN STANDARD INC 2480 Stanfield Road Mississauga Ontario Canada L4Y 182 Toll Free 800 387 0369 In Mexico IDEAL STANDARD S A de C V Customer Service Manager Planta Santa Clara Via Morelos 330 Santa Clara Coatitla Ecatepec de Morelos 55540 g D AMERICAST LIMITED LIFETIME WARRANTY If an American Standard Americast brand product is found to be defective in materials or workmanship after inspection by an authorized American Standard representative American Standard will repair or at its option exchange the product for a similar model This warranty extends for the lifetime of the product so long as it Estado de Mexico Mexico ri o E American Standard Inc 2002 Americast Bath Installation Instru
3. FINISH MATERIAL SUCH AS TILE OR WALLBOARD MUST BE SELF SUPPORTING IF IT CONTACTS THE RIM OF BATH TYPICAL RECESS INSTALLATION STRIP ADHESIVE ll LEVELING STRINGER 791031 100 Rev H LEVELING STRINGERS TILE BEAD SEALANT BATH WHIRLPOOL ONLY UNLESS AN ACCESS OPENING OF AT LEAST 12 X 24 305 X 610MM IS PROVIDED WARRANTY SERVICE WILL NOT BE PERFORMED TYPICAL PIER TYPE INSTALLATION AS DESIRED 775mm 30 1 2 CUTOUT 1638mm 64 1 2 DESIRED LEVELING SURFACE WATERPROOF SEALANT ACCESS PANEL BATH P d WHIRLPOOL ONLY UNLESS AN ACCESS OPENING OF AT LEAST 12 X 24 305 X 610MM IS PROVIDED WARRANTY SERVICE WILL NOT BE PERFORMED ELECTRICAL INSTALLATION INSTRUCTIONS All wiring must be performed by a licensed electrician in accordance with the national electrical code and all other applicable codes WARNING W hen using electrical products basic precautions should always be observed including the following 1 DANGER RISK OF ELECTRIC SHOCK Connect only to a circuit protected by a ground fault circuit interrupter 2 Grounding is required The unit should be installed by a licensed electrician and grounded 3 Install to permit access for servicing 4 All building materials and wiring should be routed away from the pump body and heater if equipped The whirlpool should be installed on a 120 vac 15 amp dedicated circuit The circuit should be hard wired from the electrica
4. STRATFORD 2470 XXXW SERIES r Standard AMERICAST BRAND ENGINEERED MATERIAL WHIRLPOOL BATHING POOL INSTALLATION INSTRUCTIONS C L OF 1 2 167 SUPPLIES a f ey AS REQUIRED 235mm 9 1 4 76mm 3 WALL 64 1 2 X 30 1 2 CUTOUT ON OFF SWITCH 229 X 3 il 32mm 05mm PROVIDE ACCESS 1 1 4 9 X 12 FLOOR CUTOUT TO PUMP FO C L OF SHOWER 3 OF DRAIN SERVICING CURTAIN ROD OUTLET FINISHED INSTALLATIONS ALL 1930mm 76 P OPTIONAL TO FLOOR la Te 32mm 1 1 4 DIA HOLE 1 2 N P T SHOWER SAFE T HEATER SE te 203mm 44mm 1 3 4 DIA HOLES REMOVABLE BLANK 1 2 SUPPLIES 8 o CONTROL VALVES AS REQ D gt Ne 32mm 1 1 4 DIA HOLE FOR 4651 1982mm b q0omm i L 12 NPT SPOUT P T 65 78 azsa L9 Y 00 pe rm OPTIONAL n 1 1 4 s ATRA Af TU 70mm im X SUPPORT 20 2 3 4 d H STRINGER e H 476mm EUN ear l di B L 18 3 4 OVERFLOW TAL E E MIN U 117mm 4 5 8 1 1 2 N P T THREADS 7 1 1 2 O D TAILPIECE 70mm 2 3 4 GENERAL SPECIFICATIONS FOR 2470 WHIRLPOOL INSTALLED SIZE 66 x 32 x 20 In 1676 x 813 x 508mm WEIGHT 201 Lbs 90 Kg WEIGHT w WATER 1 1 1 701 Lbs 315 Kg GAL TO OVERFLOW___ 60QGal 2271 WHIRLPOOL MIN OPERATING VOL 40 Gal 152 L BATHING WELL AT SUMP 42 x 19 In 1067 x 483mm BATHING WELL AT RIM 60 x 27 In 1524 x 686mm WATER DEPTH TO OVERFLOW
5. ctions 791412 100 Rev A pg 8
6. e bath from construction damage After installation and before enclosing with wallboard tile etc water test the unit and check for leaks Do not make modifications to the whirlpool system or remove pump from factory mounting This could adversely affect the safety and performance of the whirlpool and void the warranty Do not handle or move the whirlpool by the pump motor or piping system Fittings bath filler shower arm etc are not provided with the bath and must be ordered separately Framing and enclosing materials are provided by others Check for availability of optional American Standard wall tiling bead required for recess installations Protect all finished surfaces of the whirlpool during construction and installation using a drop cloth WARNING Do not lift whirlpool by the piping harness at any time FOR AFTER SALES SERVICE CALL 1 800 442 1902 WEEKDAYS 791031 100 Rev H O American Standard Inc 2005 All product names listed herein are trademarks of American Standard Inc unless otherwise noted FRAMING AND INSTALLATION THE VARIETY OF INSTALLATIONS POSSIBLE FOR THIS BATH MAY REQUIRE FRAMING PROCEDURES OTHER THAN THOSE SHOWN LOCATE STUDS AS REQUIRED INSURE ROUGH DIMENSIONS ARE PROPER PLUMB AND SQUARE FOR WHIRLPOOLS PROVISION MUST BE MADE IN ALL INSTALLATIONS FOR AN ACCESS OPENING FOR SERVICING PUMP AND CONTROLS STRINGER OR PIER HEIGHT SHOULD BE AS INDICATED NO ADDITIONAL SUMP SUPPORT IS REQUIRED ANY
7. etal implement on bath surface Post installation clean up generally can be completed using warm water and liquid dishwashing detergent Stubborn dirt or stains may be removed using granular Spic and Span mixed with water Painter s naphtha can be used to remove excess adhesives and or wet oil base paint HARSH CHEMICALS SHOULD NEVER BE USED ON ENAMEL SURFACES Abrasive cleaners must not be used since they will scratch and dull the surface Dulled areas can be restored by rubbing with a white automotive type polishing compound and waxing with a liquid wax 791031 100 Rev H 4 SPIC AND SPAN IS A REGISTERED TRADEMARK OF PROCTER amp GAMBLE Ambri am Standard Americast Baths Models 2390 amp 2391 1 Prepare Proper Rough In Opening LEVELED SUPPORT STRINGER Americast Bath Installation Instructions 791412 100 Rev A pg 1 Ambri am Standard Americast Baths Models 2390 amp 2391 3 Do Not Cement Drain In Place 1 1 minimumsspace required from bottom of drainsee to floor Drain assembly well NOTE See STEP 12 4 Use The Proper Full Length Support Stringer 2 x4 1 p Uam 4 x4 Americast Bath Installation Instructions 791412 100 Rev A pg 2 Ambri am Standard Americast Baths Models 2390 amp 2391 5 Install Level Support Stringer At Proper Height 6 Securelv fasten the stringer to the studs Americast Bath Installation Instructions 791412 100 Rev A pg 3 f
8. l power supply panel The circuit must be a three 3 wire circuit from the electrical supply panel A grounded neutral wire and a third wire earth ground are essential ADDING THE SAFE T HEATER REQUIRES A SEPARATE 15 AMP MAXIMUM GFCI CIRCUIT ELECTRICAL INSTALLATION SEPARATE 15 AMP GFCI OUTLET 120 VAC WHIRLPOOL MOUNTED AIR SWITCH or WALL TIMER ELECTRICAL DIAGRAM READ AND FOLLOW ALL INSTRUCTIONS 791031 100 Rev H 3 WIRE SELECTION GUIDE Maximum distance from I I fusebox to motor The sizes shown on this l M otor chart are recommendations Rating only Always follow 120V Power Line local and national DRAIN CONNECTION AND SYSTEM TEST Using recommended drain opening connect whirlpool drain to waste line Tighten all drain joints securely Check the pump couplings and make sure they are hand tight Clean the whirlpool and fill with water to a point 2 above the top of the highest jet Recheck the pump couplings and make certain that they are not leaking Although the pump couplings are factory tightened and inspected some loosening may have occured during transit Make sure the whirlpool is connected to the electrical supply and turn the whirlpool on Check for leaks around all piping connections while the whirlpool is running POST INSTALLATION CLEAN UP Remove all construction debris from bath Tile grout can be removed with a wooden popsicle stick or tongue depressor Do not use wire brushes or any other m
9. mbricam Standard Americast Baths Models 2390 amp 2391 8 Inspect Tub Prior To Installation 9 Install Overflow And Drain Assembly Per Manufacturer s Instructions Use Plumber s Putty On Drain A To Ensure A Watertight Seal Americast Bath Installation Instructions 791412 100 Rev A pg 4 Ambri am Standard Americast Baths Models 2390 amp 2391 10 Do Not Use Bedding Material Or Try To Flow Skim Coat Under Tub 11 Make Sure Installed Tub Is Level 12 Tub Should NOT be Touching The Floor 1 minimum clearance from floor of drain well to bottom of Tee Americast Bath Installation Instructions 791412 100 Rev A pg 5 Ambricam Standard Americast Baths Models 2390 amp 2391 13 Properly Secure The Tub In Place O DRYWALL SCREW 51 x 102mm 2 x 4 EVERY STUD WOOD STRINGER FULL LENGTH Americast Bath Installation Instructions 791412 100 Rev A pg 6 YimerizaM Standard Americast Baths Models 2390 amp 2391 14 Protect The Tub From Damage 16 Use Approved Cleaners Americast Bath Installation Instructions 791412 100 Rev A pg 7 Americast Baths Models 2390 amp 2391 WARRANT Y remains in use in its original place of installation except that the warranty applies to a bathing vessel s slip resisting surface only for the first year after the product s initial installation This warranty applies only to the original purchaser and ins
10. tallation of these products This warranty does not apply to whirlpool components or to faucets drains mounting rims grab bars or other accessories If manufactured or supplied by American Standard such whirlpool components and accessories are covered under separate limited warranties This warranty does not apply to local building code compliance Since local building codes vary considerably the purchaser of this product should check with a local building or plumbing contractor to assure local code compliance before installation This warranty shall be void if the Americast brand product has been moved from its initial place of installation if it has been subjected to faulty maintenance abuse misuse accident or other damage if it was not installed in accordance with American Standard s instructions or if it was modified in a manner inconsistent with the product as shipped by American Standard American Standard s option to repair or exchange the product under this warranty does not cover any labor or other costs of removal or installation nor shall American Standard be responsible for any other incidental or consequential damages attributable to a product defect or to the repair or exchange of a defective product all of which are expressly excluded from this warranty Some states or provinces do not allow the exclusion or limitation of implied warranties so this exclusion may not apply to you This warranty gives you specific
Download Pdf Manuals
Related Search