American Standard 9212.124.185 Installation Guide
Contents
1. Americam Standard Style That Works Better ASSEMBLY amp INSTALLATION INSTRUCTIONS Tropic 24 Vanity Zoe Marble Top and Orbit Undercounter Sink 0404 004 Tropic Grande Pedestal Sink Each Sold Separately Sold Separately VANITY TOP RECOMMENDED SINKS RECOMMENDED FAUCETS 9212124 Laminated 25 Marble Top 0630 000 Orbit Undercounter Sink 7038 801 Tropic 8 7010 801 Green Tea 8 0404 008 Tropic Grande Pedestal Sink 7038 801 Tropic 8 7010 801 Green Tea 8 MLL LM M No Marble Top Required No Marble Top Required 0404 004 Tropic Grande Pedestal Sink 7038 201 Tropic 4 7010 201 Green Tea 4 Thank you for selecting our products products which have been the benchmarks of fine quality for over 100 years To help ensure that the installation process will proceed smoothly please read these instructions carefully before you begin Also review the recommended tools and materials list carefully unpack and examine your new plumbing fixture To maintain the beauty of the finish avoid placing the furniture in direct sunlight as sunlight causes fading Also avoid extreme changes in temperature by arranging furniture away from radiators heat and air vents and air conditioning units Avoid placing furniture directly under windows Recommended Tools amp Materials NV Adjustable Wrench LA Channel Locks Pipe Wrench lt gt 7 Basin Wrench Phillips Screwdriver il2. Putty Knife g Plumbers Putty or T Dl ape ne Caulking ma 3 Measure Regular Screwdriver Tubing Cutter Roughing in Dimensions een tg 496mm 0404 004 0404 008 TROPIC GRANDE PEDESTAL SINK OPTION MARBLE TOP WITH ORBIT UNDERMOUNT SINK SUPPLIES FINISHED AS REQUIRED WALL 9212024 Tropic 24 Vanity FINISHED FLOOR Product names listed herein are trademarks of AS America Inc k AS America Inc 2009 Pee EE 770035 100 Rev A VANITY INSTALLATION Unpack unit carefully taking care that bottom shelf does not drop and damage front legs see Figure 2 Provide suitable reinforcement for anchoring the vanity to the wall Centerline of reinforcement should be 27 up from the floor see Figure 1 Rough in supply lines and waste per rough in dimensions The molding needs to be notched to seat the vanity flush against the wall Move the vanity into place and level with the adjustable glides on the bottom of the feet The glides can be adjusted outward up to 1 but it is recommended not to exceed 1 2 if possible Drill at least two 3 8 O D anchoring holes through the centerline of the rear stringer of the vessel stand located approximately 6 down from the top of vanity see Figure 2 Anchor the vanity to the wall through at least 2 of the anchoring holes in the rear of the vanity see Figure 2 Continue with inst
3. ade through the contractor or dealer from or through whom the product was purchased or that a service request including a description of the product model and of the defect be sent to the following address In the United States In Canada In Mexico American Standard Brands AS Canada ULC Customer Service Manager P O Box 6820 2480 Stanfield Rd AS Maauila S A de C V Piscataway New Jersey 08855 Mississauga Ontario Via Morelos 330 Attention Director of Consumer Affairs Canada L4Y 1S2 Col Santa Clara Ecatepec 55540 Edo Mexico For residents of the United States warranty Toll Free 800 387 0369 www americanstandard com mx information may also be obtained by calling www americanstandard ca the following toll free number 800 442 1902 www americanstandard us com 770035 100 Rev A
4. allation appropriate for top and sink options chosen FIGURE 1 C L of 2x6 Reinforcement SUPPLY LINES WASTE LINE FIGURE 2 19 12 REAR STRINGER TROPIC GRANDE 496mm WITH ANCHORING HOLES PEDESTAL SINK TO SECURE VANITY TO WALL ANCHOR VANITY 4 TO WALL USING REAR STRINGER 6 OPTION 150 MARBLE TOP WITH ORBIT UNDERMOUNT SINK WALL ADJUSTABLE ij SI LEVELLERS SS Under each Leg TAE 770035 100 Rev A TROPIC GRANDE PEDESTAL SINK 0404 004 or 0404 008 INSTALLATION onto VANITY Two people recommended for this installation Mount the drain assembly not included on the sink Be certain to apply a bead of sealing putty on the underside of the drain Part A in order to ensure a watertight seal between the sink and drain Remove excess putty after installing the drain on the sink Apply a bead of silicone adhesive to the rim of the vanity Place the top centered left to right on the vanity and with the back edge of the top even with the rear of the vanity Apply a bead of silicone along the top back edge of the vanity top and the wall Clean up any excess silicone Connect the trap to the drain assembly hand tight to check alignment It may be necessary to cut off part of the tailpiece area B or part horizontal leg of the trap area C Connect hot and cold supply lines to the shut off valves Tighten trap joints for water
5. d soil from being absorbed into the porous surface but it is NOT a guarantee against staining All spills should be cleaned immediately Avoid contact with all oils and petroleum based products Also avoid contact with all acid or caustic products such as vinegar citrus or fruit juices soda chlorine and nail polish remover If the marble is well sealed the warm water and non abrasive cloth should keep it clean REPLACEMENT PARTS LIST 9212024 Tropic 24 Vanity REPLACEMENT PART NO DESCRIPTION 730679 0070A Threaded Leveller 1 per pack for Vanity 730744 0070A Shelf Clips for Adjustable Shelf 4 per pack LAMINATED 25 MARBLE TOP AND ORBIT UNDERCOUNTER SINK EACH SOLD SEPARATELY TROPIC GRANDE PEDESTAL SINK 0404 004 0404 008 DOOR OPENS TO ACCESS STORAGE LLL TM MU m4 MM Me ELL MM ZL YMA OPTION MARBLE TOP with ORBIT UNDERCOUNTER SINK OPTION TROPIC GRANDE PEDESTAL SINK 4 770035 100 Rev A AS AMERICA INC BATH FURNITURE LIMITED WARRANTY If inspection of this AS America Inc American Standard plumbing product within one year after its initial purchase confirms that it is defective in materials or workmanship American Standard will repair or at its option exchange the product for a similar model Variations in actual wood color and finishes which may result from natural characteristics of the wood such as grain patterns mineral streak
6. mited warranty of any implied limited warranties including those of merchantability or fitness for an intended purpose Some states or provinces do not allow the exclusion or limitation of implied limited warranties so this exclusion may not apply to you This limited warranty gives you specific legal rights You may have other statutory rights that vary from state to state or province to province in which case this limited warranty does not affect such statutory rights AS AMERICA INC MARBLE GRANITE VANITY TABLE TOP LIMITED WARRANTY If inspection of this AS America Inc American Standard plumbing product within one year after its initial purchase confirms that it is defective in materials or workmanship American Standard will repair or at its option exchange the product for a similar model Variations in shading veining and texture which may result from natural characteristics of stone and as such are not defects and are not covered by this limited warranty This limited warranty applies only to the original purchaser and installation of these products In the event of a claim proof of purchase will be required save your receipt This limited limited warranty does not apply to local building code compliance Since local building codes vary considerably the purchaser of this product should check with a local building or plumbing contractor to insure local code compliance before installation This limited warranty is void if
7. rizontal leg of the trap area B Connect hot and cold supply lines to the shut off valves Tighten trap joints for watertight assembly 3 770035 100 Rev A Care and Cleaning of Vanity Clean the product by using soft slightly damp cloth Buff the product by using a soft dry cloth Avoid using silicone cleaners and waxes Clean up excess water and spills immediately Use a blotting rather than a wiping action Water left over a long period of time will cause white spots in the finish NOTE Please note that some chemicals may damage the finish Take care to avoid the following iodine hair dye after shave lotion shaving cream alcohol perfume Lestoil Lysol Tub and Tile Cleaner Lysol Spray Disinfectant Dow Disinfectant acetone paint remover Formula 409 Tile X and Nair Care and Cleaning of the Marble Vanity Top Marble is porous and easily stained Wipe off anything spilled on it immediately It should be washed or cleaned regularly with fresh warm water and a non abrasive clean cloth Also using a non abrasive neutral pH balanced cleaner will help remove dirt and grime but it is recommended to first try warm water only Marble should be sealed regularly with a good quality marble sealer Marble sealers are available at most retail home supply stores Follow the instructions on the sealer container for proper application and frequency of use The sealer acts as a stain inhibitor and prevents most stains an
8. s and the like are not defects and are not covered by this limited warranty This limited warranty applies only to the original purchaser and installation of these products In the event of a claim proof of purchase will be required save your receipt This limited limited warranty does not apply to local building code compliance Since local building codes vary considerably the purchaser of this product should check with a local building or plumbing contractor to insure local code compliance before installation This limited warranty is void if the product has been moved from its initial place of installation if it has been subjected to faulty maintenance abuse misuse accident or other damages if it was not installed in accordance with American Standard s instructions or if it has been modified in a manner inconsistent with the product as shipped by American Standard American Standard s option to repair or exchange the product under this limited warranty does not cover any labor or other costs of removal or installation nor shall American Standard be responsible for any other incidental or consequential damages attributable to a product defect or to the repair or exchange of a defective product all of which are expressly excluded from this limited warranty This limited warranty does not cover any liability for consequential or incidental damages all of which are hereby expressly disclaimed or the extension beyond the duration of this li
9. the product has been moved from its initial place of installation if it has been subjected to faulty maintenance abuse misuse accident or other damages if it was not installed in accordance with American Standard s instructions or if it has been modified in a manner inconsistent with the product as shipped by American Standard American Standard s option to repair or exchange the product under this limited warranty does not cover any labor or other costs of removal or installation nor shall American Standard be responsible for any other incidental or consequential damages attributable to a product defect or to the repair or exchange of a defective product all of which are expressly excluded from this limited warranty This limited warranty does not cover any liability for consequential or incidental damages all of which are hereby expressly disclaimed or the extension beyond the duration of this limited warranty of any implied limited warranties including those of merchantability or fitness for an intended purpose Some states or provinces do not allow the exclusion or limitation of implied limited warranties so this exclusion may not apply to you This limited warranty gives you specific legal rights You may have other statutory rights that vary from state to state or province to province in which case this limited warranty does not affect such statutory rights For service under these limited warranties it is suggested that a claim be m
10. tight assembly MARBLE TOP 9212124 WITH ORBIT 0630 UNDERCOUNTER SINK Two people recommended for this installation NOTE Marble top comes pre cut for the Orbit Undercounter Sink and 8 faucet spread Also it is strongly recommended that the marble top be sealed after installation and prior to use Mount the drain assembly not included on the sink Be certain to apply a bead of sealing putty on the underside of the drain Part A in order to ensure a watertight seal between the sink and drain Remove excess putty after installing the drain on the sink Turn the marble top upside down and place it on a clean scratch eee resistant surface Apply a bead of silicone adhesive to the rim of SS the sink Center the sink over the cutout and secure it to the top ATE TETE using the mounting kit provided ENOT ANAT NOTE Use the 4 brackets and screws supplied with the sink mounting kit to secure the sink to the underside of the marble top lt OVERFLOW TOWARDS FRONT OF MARBLE TOP MARBLE TOP Turn the top right side up and install the faucet per the manufacturer s instructions Apply a bead of silicone adhesive to the rim of the vanity Place the marble top centered left to right on the vanity and with the back edge of the top even with the rear of the vanity Clean up any excess silicone Connect the trap to the drain assembly hand tight to check alignment It may be necessary to cut off part of the tailpiece area A or part ho
Download Pdf Manuals
Related Search