Home

Rust-Oleum Automotive 251576 Use and Care Manual

1. NANT WOMEN SHOULD ALSO AVOID EXPOSURE Wear a NIOSH approved respirator to control lead exposure Clean up carefully with a HEPA vacuum and a wet mop Before you start find out how to protect yourself and your family by contacting the National Lead Information Hotline at 1 800 424 LEAD or log onto www epa govilead PRODUCT APPLICATION cont PRIMING Use of a Rust Oleum Primer provides added corrosion protection on metal and promotes adhesion and hiding A primer is especially recommended for metal and wood surfaces Recommended primers include 249321 Primer Sealer or any of the sandable primers 249419 Red 252472 Light Gray or 249415 Gray APPLICATION Shake can vigorously for one minute after the mixing ball begins to rattle If mixing ball fails to rattle DO NOT STRIKE CAN Contact Rust Oleum Hold can at the top and swirl the bottom of the can in a circular stirring motion for at least 2 minutes so the mixing ball travels around the groove of the can Shake can up and down occasionally during use Hold can 8 12 from the surface and spray ina steady back and forth motion slightly overlapping each stroke Keep the can the same distance from the surface Keep the can in motion while spraying For best results apply 2 3 slightly heavy coats 5 minutes apart A fairly heavy film thickness is required for the product to wrinkle Do not use near open flame DRY amp RECOAT Dry and recoat times are based on 70 F and 50 r
2. elative humidity Allow more time at cooler temperatures A wrinkle finish will not appear immediately after product is sprayed Allow 2 hours to air dry If product does not wrinkle or wrinkles in an uneven pattern apply an additional coat to unwrinkled and uneven areas These areas will wrinkle within 15 minutes if force dried with a heat source such as a hair dryer CLEAN UP Wipe off tip when finished Clean up wet paint with xylene or mineral spirits Properly discard empty container Do not burn or place in home trash compactor CLOGGING If the valve clogs twist and pull off spray tip and rinse ina solvent such as mineral spirits Do not insert any object into can valve opening Form GDH 420 Rev 081814 TECHNICAL DATA AUTOMOTIVE WRINKLE FINISH PHYSICAL PROPERTIES WRINKLE FINISH Resin Type Tung Oil Solvents Acetone and aromatic hydrocarbons MIR 1 40 Max Fill Weight 12 ounces Recommended Dry Film 1 0 1 5 mils Thickness DFT Per Coat 20 37 51 Practical Coverage at Recommended DFT 15 18 sq ft can 1 7 2 0 m can Dry Times at 70 80 F Touch 2 hours 21 27 C and 50 Relative Humidity Recoat 2 hours Shelf Life 5 years Flash Point 156 F 104 C Safety Information For additional information see MSDS The technical data and suggestions for use contained herein are correct to the best of our knowledge and offered in good faith The sta
3. po TECHNICAL DATA ATO 03 AUTOMOTIVE WRINKLE FINISH DESCRIPTION AND USES Rust Oleum Wrinkle Finish is designed to provide the characteristics of a wrinkled surface Use this finish to give a new look and texture to automotive accessories metal and plastics Rust Oleum Wrinkle Finish features an advanced spray system that allows you to spray at any angle even upside down for those hard to reach areas A comfort spray tip with a wider finger pad reduces fatigue caused by continuous spraying PRODUCTS SKU Description 251576 Black PAINTING APPLICATION PAINTING CONDITIONS Use outdoors or in a well ventilated area such as an open garage Use when temperature is between 50 90 F 10 32 C and humidity is below 85 to ensure proper drying Do not apply to surfaces when heated exceed 200 F 93 C Avoid spraying in very windy and dusty conditions Cover surrounding area to protect from spray mist SURFACE PREPARATION Remove all dirt grease and wax with Rust Oleum Wax amp Tar Remover Wash area with a mild soap and water solution rinse with fresh water and dry with a clean cloth Remove loose paint with a wire brush or 320 grit sandpaper Lightly sand glossy surfaces Wipe the sanded surface clean when finished WARNING If you scrape sand or remove old paint you may release lead dust LEAD IS TOXIC EXPOSURE TO LEAD DUST CAN CAUSE SERIOUS ILLNESS SUCH AS BRAIN DAMAGE ESPECIALLY IN CHILDREN PREG
4. tements of this literature do not constitute a warranty express or implied as to the performance of these products As conditions and use of our materials are beyond our control we can guarantee these products only to conform to our standards of quality and our liability if any will be limited to replacement of defective materials All technical information is subject to change without notice ge RUST OLEUM BRANDS Rust Oleum Corporation Form GDH 420 11 Hawthorn Parkway Phone 877 385 8155 Rev 081814 Vernon Hills Illinois 60061 www rustoleum com An RPM Company

Rust-Oleum Automotive 251576 Use and Care Manual

Contents

Download Pdf Manuals

Related Search

Related Contents