Viking F20733EN User's Manual
Contents
1. Viking Use amp Care Manual Viking Range Corporation 111 Front Street Greenwood Mississippi 38930 USA 662 455 1200 For product information call 1 888 VIKING1 845 4641 or visit the Viking Web site at vikingrange com 15 W Undercounter Freestanding Ice Machine F20733EN 070110 17 3336 02 CONGRATULATIONS Congratulations and welcome to the elite world of Viking ownership We hope you will enjoy and appreciate the care and attention we have put into every detail of your new state of the art ice machine Your Viking appliance is designed to offer years of reliable service This Use and Care Guide will provide you with the information you need to become familiar with your ice machine care and operation Your complete satisfaction is our ultimate goal If you have any questions or comments about this product please contact the dealer from whom you purchased it or contact our Consumer Support Center at 1 888 VIKING1 We appreciate your choice of a Viking ice machine and hope that you will again select our products for your other major appliance needs For more information about the complete and growing selection of Viking products contact your dealer or visit us online at vikingrange com TABLE OF CONTENTS Important Safety Instructions Initial Start Up Use Maintenance Care and Cleaning Condenser Cleaning W2. cated in a well ventilated area e connected to the proper kind of outlet with the correct electric supply and grounding A 115V 60 Hz 15 amp fused electrical supply is required Note Time delay fuse or circuit breaker is recommended e not used by anyone unable to operate it properly e used only for its intended purpose properly maintained eSAVE THESE INSTRUCTIONS INITIAL START UP 1 Turn on the water supply 2 Switch on the electrical power 3 Push and release the On Off switch to start the machine The Ice Making light next to the On Off switch will glow Blue 4 Water will begin to flow into the unit When the reservoir is full water will start to drain from the machine After a few minutes the compressor water pump and fan motor will begin to operate and the first ice making cycle will have begun No adjustments are needed After about half an hour ice will fall into the ice storage bin The machine makes 24 cubes per batch It is normal for the first batches of ice to melt that continues until the bin has cooled It will take 8 to 10 hours of continuous run time to fill the ice bin When the bin is full of ice the ice machine will shut off It will automatically restart when the ice level falls either from use or normal meltage USE No special instructions are needed for use Just take as much ice as you need the machine will replace it A scoop is provided and it can be stored in the machine usin
3. ces of Ice Machine Scale Remover into the ice machine reservoir Pour scale remover here 5 Operate the machine for about Y hour 6 Push and release the On Off switch The Time to Clean light will stop blinking and remain on The machine will begin to flush out the cleaning solution 7 Operate the machine for another 1 2 hour 8 Push and release the On Off switch The machine will stop the cleaning process 9 Pour a gallon of hot 95 F 115 F water into the bin to flush out the drain 10 Clean the bin liner of mineral scale by mixing some ice machine scale remover and hot water and using that solution to scrub the scale off of the liner 11 Rinse the liner with hot water 12 Sanitize the bin interior 13 Replace the ice removed in step 1 14 Push and release the On Off button to restart ice making The ice scoop should be washed regularly wash it just like any other food container TROUBLESHOOTING GUIDE PROBLEM CORRECTION Ice cubes are incompletely e Clean the ice making system formed Low capacity Check for restricted drain or standing water in the bin Clean the air cooled condenser fins Check On Off switch Check electrical breaker If the Check Water light is flashing blue check water supply The control system checks for water every 20 minutes When the water supply is restored the machine will auto
4. e is objectionable an appliance grade timer can be added to the power supply Set the timer to turn the machine off at the time s of day when the noise is most objectionable Ice cubes Normal cubes are tapered cylinders If the cubes are ragged and mis shaped mineral scale must be removed from the ice making system WATER QUALITY All water including potable water supplied by municipalities contains some impurities or minerals Water absorbs impurities from the air as rain and or as it flows through the ground Some of the impurities are solid particles these are known as suspended solids and a fine particle filter will remove them Other impurities are chemically bonded to the water molecules and cannot be filtered out these are called dissolved solids Ice made by this machine will have a lower mineral content than the water it was made from This is due to the method of making ice Purer water will freeze first in the ice making molds The reason for this is that anything dissolved in water lowers the water s freezing temperature This concentrates most of the impurities in the ice machine water reservoir where they may form hard deposits known as scale The machine dilutes the concentration of minerals by over filling the reservoir during the harvest cycle with the excess water flowing down the drain s Between 2 and 4 pints of water flow into the unit each cycle Between 1 and 3 5 pints of that rinses the reservoir and goes dow
5. g the loop of tubing on the right side as a holder That tubing is also the ice level sensor ice will fill the storage bin until it is near to or on that tube and then the machine will shut off The machine can be shut off anytime by just pushing and releasing the On Off button The machine will shut off at the end of the next cycle To shut off immediately push and hold the On Off button in until the machine stops USE cont Never keep anything in the ice storage bin that is not ice Objects like wine or beer bottles are not only unsanitary but the labels can slip off and plug up the drain Never allow the machine to operate without regular cleaning The machine will last longer if it is kept clean Regular cleaning should happen at least once per year and preferably twice Some water conditions will dictate even more frequent cleaning of the ice making section and some carpets or pets will dictate more frequent cleaning of the condenser Note The Time to Clean light will switch ON after 6 months of use It will remain ON until the ice making system is cleaned using the process in the How to clean the condenser and winterize section Noise The ice machine is designed for quiet operation but will make some noise during the ice making cycle During a freezing cycle it is normal to hear the fan moving air and the water pump circulating water Ice hitting the bin or ice in the bin can be heard during harvest If ice making nois
6. geration system component as listed above which fails due to defective materials or workmanship in normal household use during the seventh through the twelfth year from the date of original retail purchase will be repaired or replaced free of charge for the part itself with the owner paying all other costs including labor NINETY 90 DAY RESIDENTIAL PLUS WARRANTY This warranty applies to applications where use of the product extends beyond normal residential use Examples are but not limited to bed and breakfasts fire stations private clubs churches etc This warranty excludes all commercial locations such as restaurants food service locations and institutional food service locations This warranty extends to the original purchaser of the product warranted hereunder and to each transferee owner of the product during the term of the warranty This warranty shall apply to products purchased and located in the United States and Canada Products must be purchased in the country where service is requested Warranty labor shall be performed by an authorized Viking Range Corporation service agency or representative Warranty shall not apply to damage resulting from abuse accident natural disaster loss of electrical power to the product for any reason alteration improper installation improper operation or repair or service to the product by anyone other than an authorized Viking Range Corporation service agency or representative Warranty shall
7. interizing Removing the Scale from the Ice Making System Troubleshooting Guide zz NOUMAOANA AR SR IMPORTANT PLEASE READ AND FOLLOW e Before beginning please read these instructions completely and carefully e DO NOT remove permanently affixed labels warnings or plates from the product This may void the warranty e Please observe all local and national codes and ordinances e Please ensure that this product is properly grounded e The installer should leave these instructions with the consumer who should retain for local inspector s use and for future reference A WARNING To reduce the risk of fire electric shock or injury when using your unit follow these basic precautions e Read all instructions before using the unit e Never allow children to operate play with or crawl inside the unit e Never clean unit parts with flammable fluids The fumes can create a fire hazard or explosion e Always turn the power on off switch located behind the air grille on top right side to the OFF position before attempting to change light bulbs clean or service the unit FOR YOUR SAFETY DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE THE FUMES CAN CREATE A FIRE HAZARD OR EXPLOSION It is your responsibility to be sure your ice machine is e located so the front is not blocked to restrict incoming or discharge air flow e properly leveled e lo
8. kickplate and front service panel 2 Locate the condenser surface Condenser surface CAUTION DO NOT dent the fins 4 Return the kickplate and front service panel to their original positions Fasten them to the cabinet using the original screws Winterizing 1 Clean the ice making system 2 Open the door and push and release the On Off switch to turn the machine off 3 Turn off the water supply CARE AND CLEANING cont 4 Drain the water reservoir by removing the rubber cap under the reservoir it s near the back wall of the ice storage bin 5 Disconnect the incoming water line at the inlet water valve 6 Open the door push and release the on off switch to turn the machine on 7 Blow air through the inlet water valve a tire pump could do the job 8 Drain pump models should have about 1 2 gallon of RV antifreeze propylene glycol poured into the ice storage bin drain Note Automotive antifreeze must NOT be used 9 Switch off and unplug the machine Removing scale from the ice making system 1 Scoop out all of the ice either discard it or save it in an ice chest or cooler 2 Press and HOLD the On off button in for 3 seconds until the Blue light goes out 3 Press and HOLD the both the Clean Reset and On Off buttons for 5 seconds The Time to Clean light will blink on and off 10 CARE AND CLEANING cont 4 Pour 8 oun
9. matically restart ice making Time to Clean light is on Clean the ice making system 12 FGIM FPIM UNDERCOUNTER FREESTANDING ICE MACHINE WARRANTY TWO YEAR FULL WARRANTY Undercounter freestanding ice machines and all of their components and accessories except as detailed below are warranted to be free from defects in material or workmanship under normal household use for a period of two 2 years from the date of original retail purchase Viking Range Corporation warrantor agrees to repair or replace at its option any part which fails or is found to be defective during the warranty period Painted and decorative items are warranted to be free from defective materials or workmanship for a period of ninety 90 days from the date of original retail purchase ANY DEFECTS MUST BE REPORTED TO THE SELLING DEALER WITHIN NINETY 90 DAYS FROM DATE OF ORIGINAL RETAIL PURCHASE SIX YEAR FULL WARRANTY Any sealed refrigeration system component as listed below is warranted to be free from defective materials or workmanship in normal household use during the third through the sixth year from the date of original retail purchase Viking Range Corporation warrantor agrees to repair or replace at its option any part which fails or is found to be defective during the warranty period Sealed Refrigeration System Components Compressor Evaporator Condenser Connecting Tubing Dryer Strainer TWELVE YEAR LIMITED WARRANTY Any sealed refri
10. n the drain Some impurities will inevitably remain and will stick to the parts in the machine and will cause malformed ice cubes Eventually built up mineral scale can shorten machine life To keep the machine operating properly these impurities or minerals will have to be regularly dissolved by an acid cleaning using Ice Machine Scale Remover Directions for this may be found in the section under care and cleaning MAINTENANCE There are 5 things to keep clean The outside cabinet amp door The ice storage bin The condenser The ice making system The ice scoop ame N How to clean the cabinet Wipe off any spills on the surface of the door and handle as they occur If anything spilled on the door or gasket dries onto the surface wash with soap and warm water to remove How to clean the ice storage bin The ice storage bin should be sanitized occasionally It is usually convenient to sanitize the bin after the ice making system has been cleaned and the storage bin is empty A sanitizing solution can be made of 1 ounce of household bleach and two gallons of hot 95 F 115 F water Use a clean cloth and wipe the interior of the ice storage bin with the sanitizing solution pour some of the solution down the drain Allow to air dry CARE AND CLEANING Condenser cleaning The condenser is like the radiator on a car it has fins and tubes that can become clogged with dirt and lint To clean 1 Remove the
11. not apply to damage resulting from indoor units being used in outdoor situations This warranty does not apply to commercial usage Warrantor is not responsible for consequential or incidental damage whether arising out of breach of warranty breach of contract or otherwise Some jurisdictions do not allow the exclusion or limitation of incidental or consequential damages so the above limitation or exclusion may not apply to you Owner shall be responsible for proper installation providing normal care and maintenance providing proof of purchase upon request and making the appliance reasonably accessible for service If the product or one of its component parts contains a defect or malfunction during the warranty period after a reasonable number of attempts by the warrantor to remedy the defects or malfunctions the owner is entitled to either a refund or replacement of the product or its component part or parts Replacement of a component part includes its free installation Warrantor s liability on any claim of any kind with respect to the goods or services covered hereunder shall in no case exceed the price of the goods or service or part there of which gives rise to the claim WARRANTY SERVICE Under the terms of this warranty service must be performed by a factory authorized Viking Range Corporation service agent or representative Service will be provided during normal business hours and labor performed at overtime or premium rates
12. shall not be covered by this warranty To obtain warranty service contact the dealer from whom the product was purchased an authorized Viking Range Corporation service agent or Viking Range Corporation Provide model and serial number and date of original purchase For the name of your nearest authorized Viking Range Corporation service agency call the dealer from whom the product was purchased or Viking Range Corporation IMPORTANT Retain proof of original purchase to establish warranty period The return of the Owner Registration Card is not a condition of warranty coverage You however should return the Owner Registration Card so that Viking Range Corporation can contact you should any question of safety arise which could affect you Any implied warranties of merchantability and fitness applicable to the above described undercounter ice machine are limited in duration to the period of coverage of the applicable express written limited warranties set forth above Some jurisdictions do not allow limitations on how long an implied warranty lasts so the above limitation may not apply to you This warranty gives you specific rights and you may also have other rights which may vary from jurisdiction to jurisdiction Notes Notes
Download Pdf Manuals
Related Search