Razor XLR8R User's Manual
Contents
1. 4 Pull the XLR8R trigger switch DO NOT USE THE BRAKE AND TRIGGER AT THE SAME TIME 5 Using your other foot give a strong push so as to propel the scooter at a rate of 3 mph Note that the XLR8R motor will not engage until the scooter is traveling 3 mph This approach extends battery run time prolongs motor life and enables children to learn to start off on a XLR8R powered scooter more easily Note If the XLR8R does not turn on 1 Check to see that the battery is charged 2 Check to make sure the battery is connected inside the case 3 Check to make sure the power switch is in the on position fy WARNING Do not allow the XLR8R to run on if the drive system slips on the wheel and forward speed has slowed or stopped Release the trigger before you come to a stop when slowiing down DO NOT USE THE BRAKE AT THE SAME TIME AS THE TRIGGER i t5 WARNING Intermittent motor operation is an indication of low charge When this occurs turn the unit off and charge the battery Maintenance of Your XLR8R Motor Your XLR8R Motor contains no user serviceable parts Never attempt to service your XLR8R by yourself Servicing or modifying any of the XLR8R s internal components by yourself may damage the XLR8R and will void your warranty Service by anyone other than the XLR8R service center will void the warranty agreement fh WARNING Intermittent motor operation may be an indication of low charge When this occurs turn the unit2. IMPORTANT NOTICES i The Razor electric scooter must reach a speed of three miles per hour before the motor will engage Ny Ride only on smooth hard and dry surfaces The Razor was not intended for off road or hilly terrain Use caution when approaching curbs uneven pavement potholes or similar conditions Avoid water The tires are extremely slippery when wet You could lose traction and fall iN The Razor is designed for only one rider Do not attempt to ride with more than one person or attempt to tow anything behind your scooter fikt Not recommended for children under 16 without adult supervision M Maximum weight capacity on flat and level ground 120 pounds Fi WARNING Intermittent motor operation is an indication of low charge When this occurs turn the unit off and charge the battery Be sure to read and understand this manual thoroughly before operating your scooter Additional warnings enclosed To obtain service under this warranty you must within the warranty period contact Razor USA LLC directly by e mail at warranty razorusa com Razor will provide repair parts and or replacement at its sole discretion Authorized warranty service is ONLY available from Razor USA LLC or its authorized Repair Center s O 2002 Copyright Razor USA LLC All rights reserved Rev 7 15 02 RAH Specifications subject to change without notice Photos by Arthur Cambridge Razor USA LLC Cerritos California 90703 www razor com
3. ORrazor Owner s Manual Safety Handbook Read and understand this manual prior to use Make sure the XLR8R battery is fully charged DO NOT CHARGE FOR MORE THAN 15 HOURS Make sure the XLR8R is properly installed See the Attaching the XLR8R Motor to Your Scooter section in this manual Make sure the scooter is in good working condition and the rear wheel brake is functional Use only in accordance with local laws Never exceed the maximum weight of 120 pounds on a XLR8R powered scooter Never let more than one child at a time on a XLR8R powered scooter Never tow anything with a XLR8R powered scooter Never apply pressure to the rear brake while the XLR8R motor is engaged DO NOT use an XLR8R powered scooter in wet snowy or icy conditions Avoid spraying the XLR8R Motor with water to clean it Moisture inside the XLR8R case could cause electrical shorts and or corrosion to electrical components KEEP WHEELS FRESH IF WORN OUT REPLACE IMMEDIATELY Worn wheels directly affect the performance of your drive system Attaching the XLR8R Motor to Your Scooter Attaching the XLR8R Motor to your scooter involves two steps 1 installing the Mounting Bracket and 2 attaching the XLR8R Motor to the Mounting bracket Installing the Mounting Bracket To install the Mounting Bracket Use only with Scooters without shocks or suspension springs 1 Slip the Mounting Bracket s fork slot onto the front of the sco
4. he XLR8R Motor comes with a 12V battery The unit can be charged on the scooter or it can be removed from the scooter during the recharging process Charger port and on off switch The battery must be fully charged before initial use Initial charging time on the XLR8R battery may be a few minutes to up to 8 hours Only charge the battery indoors in a dry location fy WARNING The battery charger is not intended for use by children The XLR8R battery should always be charged by an adult Children should be kept away from the battery and charger during the charging process Only use XLR8R brand battery packs Do not disassemble incinerate or dispose of the battery in fire Dispose of used battery properly There is a danger of explosion if battery is incorrectly replaced The battery may present a risk of fire or chemical burn if mistreated a CAUTION Do not charge the XLR8R battery in wet conditions Only use the battery charger that accompanies your XLR8R Motor Use of any other charger voids the XLR8R warranty and may damage the battery or cause a fire hazard Do not use the XLR8R charger to charge anything other than the XLR8R battery Stop using the charger if its wires become worn or damaged in any way Replace the charger with a new XLR8R battery charger To operate the XLR8R motor 1 Turn the XLR8R s power switch to the On position 2 Grasp the scooter s handlebars firmly 3 Position one foot on the scooter s deck
5. off and charge the battery Removing the XLR8R PUSH THE RELEASE BUTTON AS SHOWN IN THE PHOTO BELOW TO RELEASE THE LATCH MECHANSIM FAILURE TO USE THE RELEASE BUTTON MAY DAMAGE THE LATCH LATCH DAMAGE DUE TO IMPROPER USE IS NOT COVERED UNDER THE XLR8 amp R WARRANTY Push button to release the lever arrow XLR8R Motor Limited Warranty General Terms Commencing on the date of purchase your XLR8R Motor has a 60 day the Warranty Period Limited Warranty which covers the XLR8R against defects in materials components and workmanship This Limited Warranty applies only to the original consumer and is not transferable to any other person This warranty gives you specific legal rights and you may also have other rights which may vary from state to state Exclusive Remedies This Limited Warranty is limited to the repair or replacement of any components of the XLR8R Motor found to be defective within the Warranty Period Some states do not allow limits on how long an implied warranty lasts so the above limit may not apply to you The manufacturer is not liable for incidental or consequential loss or damage due directly or indirectly from the use of this product Some states do not allow exclusions or limitations of incidental or consequential damages so the above limitation or exclusion may not apply to you This Limited Warranty is the only warranty for your XLR8R Motor No other warranties exist that extend beyond the descripti
6. on on the face hereof Limitations The XLR8R Motor is designed for recreational use only This warranty does not cover ordinary wear and tear or maintenance Any damage failure or loss caused by improper assembly maintenance use or storage of the XLR8R Motor by an party voids this Limited Warranty Failure to comply with the instructions and safety information in the owner s manual voids this Warranty Any evidence of consumer repair voids this Warranty Warranty Service If your XLR8R Motor requires service due to a defect in material or workmanship during the Limited Warranty period contact Razor USA via our website www razor com or via e mail customerservice razorusa com If you require Warranty service you will be responsible for paying for the entire cost of shipping your XLR8R to the service center You must include within the package your name address daytime telephone number and a receipt showing the date of purchase SB 1918 California declaration YOUR INSURANCE POLICIES MAY NOT PROVIDE COVERAGE FOR ACCIDENTS INVOLVING THE USE OF THIS SCOOTER TO DETERMINE IF COVERAGE IS PROVIDED YOU SHOULD CONTACT YOUR INSURANCE COMPANY OR AGENT
7. oter s fork Note If your scooter has a strap ring on the leading edge of its front fork you should be able to see the ring through the small window in the mounting bracket Aligning the fork to the bracket 2 Using the screws and plate provided securely fasten the Mounting Bracket to the scooter s steering tube Note that it is helpful to alternately tighten each screw a little at a time so that the plate is square with the bracket Installing the screws and tightening the clamps Attaching the XLR8R Motor To attach the XLR8R Motor to the Mounting bracket 1 Grasp the scooter s handle with one hand and the XLR8R s handle in the other hand and place one foot on the scooter s deck 2 Slip the peg slots which are located on either side of the XLR8R Motor onto the mounting pegs which are located on either side of the mounting bracket Attaching the motor 3 Insert the handle hooks into the mounting slots and press the handle downward until it comes in contact with the XLR8R Motor housing 4 Attach the Power Control to the scooter s handlebars by first placing the steerer tube clip around the steering tube and then sliding the Power Control up until the handlebar clip attaches onto the handlebar Then plug the power cord into the XLR8R Motor cord Make sure the plug is fully inserted A partially inserted plug may cause erratic operation Final connection of the wiring right Charging the Battery T
Download Pdf Manuals
Related Search