Powermate PM0675700 Parts list
Contents
1. REF PART DESCRIPTION DESCRIPTION DESCRIPCI N QTY NO NO 1 0065251 Carrier assembly Ensemble transport Transportador conjunto 1 2 _ Note A Engine 10 hp Yamaha OHV Moteur Motor 1 3 0051094 Isolator Sectionneur Aislador 4 4 Note B Washer star external 1 4 Rondelle dents externa 1 4 Arandela estrella 1 4 2 5 0057512 Bolt whz 3 8 16 x 1 25 Boulon Perno 4 6 0062196 Connector panel Connecteur tableau Conector panel 2 T 0056716 Connector stator Connecteur stator Conector estator 1 8 Note B Bolt hex 5 16 18 x 2 75 Boulon Perno 2 9 Note B Washer lock 5 16 Contre crou 5 16 Arandela de cierre 5 16 10 10 Note B Bolt 3 8 16 x 4 75 Boulon Perno 2 11 0057578 Nut nvloc 3 8 16 Ecrous nvloc 3 8 16 Tuerca nvloc 3 8 16 2 12 0008854 Lug ground Oeillet de mise la terre Terminal tierra 1 13 0040832 Nut nvloc 1 4 20 crous nyloc 1 4 20 Tuerca nyloc 1 4 20 8 14 Note B Bolt 5 16 18 x 1 25 Boulon Perno 2 15 0048736 Nut nvloc 5 16 18 crous nyloc 5 16 18 Tuerca nyloc 5 16 18 2 16 0057254 Nut hex flg 5 16 18 crous 5 16 18 Tuerca 5 16 18 5 17 0049224 Assembly ground wire Ensemble fil de mise a la terre Conjunto c ble de tierra 1 18 Note B Washer star external 5 16 Rondelle dents externa 5 16 Arandela estrella 5 16 2 19 Note B Bolt hex 5 16 18 x 75 Boulon t te hex 5 16 18 x 3 4 Perno 5 16 18 x 3 4 1 20 0065274 Spacer 38 ID Entretoise Espa2. English LIMITED WARRANTV Warrantv Coverage Powermate Corporation the Companv warrants to the original retail customer in North America that it will repair or replace free of charge anv parts found bv the Companv or its authorized service representative to be defective in material or workmanship This warrantv covers the cost of replacement parts and labor for defects in material or workmanship Not Covered Transportation charges for sending the product to the Company or its authorized service representative for warranty service or for shipping repaired or replacement products back to the customer these charges must be borne by the customer Engine is covered exclusively by a separate warranty from the engine manufacturer included with the engine Manual Damages caused by abuse or accident and the effects of corrosion erosion and normal wear and tear Warranty is voided if the customer fails to install maintain and operate the product in accordance with the instructions and recommendations of the Company set forth in the owner s manual or if the product is used as rental equipment The Company will not pay for repairs or adjustments to the product or for any costs or labor performed without the Company s prior authorization Warranty Period Three 3 years from the date of purchase on products used solely for consumer applications if a product is used for business or commercial applications the warranty pe
3. 2 51K 0064527 Nut nyloc M5 crous nyloc Tuerca nyloc 2 51L 0064532 Cover end Couvercle Tapa 1 51M 0064636 Screw M5 x 12 Vis Tornillo 2 51N 0064637 Washer M5 Rondelle Arandela 2 510 0064536 Bearing Roulement Cojinete 1 51P 0064537 Stator harness Harnais de stator Arreos de estator 1 510 0058933 Washer 1 4 wide Rondelle 1 4 large Arandela 1 4 lejos 1 51R Note B Washer lock 5 16 Contre crou Arandela de cierre 1 51S 0046540 03 Bolt hex 5 16 24 x 9 00 Boulon t te hex Perno hexagonal 1 10
4. PORTABILITY KIT INSTALLATION TOOLS REQUIRED 7 16 1 2 and 9 16 sockets and ratchets block s of wood minimum of 6 tall Refer to the parts list on page 9 WHEEL INSTALLATION 1 Block up end of generator opposite the fuel tank cap to install wheel kit 2 Insert wheel spacer item 20 into the center of the wheel item 35 3 Slide 3 8 x 4 75 bolt item 10 through the 3 8 washer item 29 and wheel item 35 then through the wheel bracket on the carrier with the offset side of the wheel hub against the wheel bracket 4 Thread 3 8 nvloc nut item 11 onto the bolt and tighten to securelv clamp the wheel assembiv to the tubing 5 Repeat above instructions for the remaining wheel FOOT INSTALLATION 1 Blocking up the engine side of the generator place a spacer item 43 and a foot item 37 under the carrier channel Thread a 5 16 18 x 2 75 bolt item 8 through the mounting holes and thread a 5 16 washer item 40 and a 5 16 nvloc nut item 15 to the bolt to secure the foot to the carrier Caution Do not over tighten so that the foot material collapses 2 Repeat step 1 for the remaining foot HANDLE INSTALLATION 1 Place the handle item 31 onto the reduced portion of the upright tubes of the base as shown in the diagram 2 Install the 1 4 20 x 1 75 bolts item 32 through the tubes from the outside 3 Thread the 1 4 nyloc nuts item 13 onto the bolts and tighten NOTE Do not over tighten
5. ciador 2 21 0065185 Muffler Silencieux Silenciador 1 22 0063701 Gasket Joint Empaquetadura 1 23 Note B Bolt 5 16 18 x 1 50 Boulon Perno 2 24 0065264 Panel wired Tableau compl c bl Panel cabeado completo 1 24A 0049072 Circuit Protector 25 amp Protecteur de circuit 25 amp Protector de circuito 25 amp 2 25 0049268 Bolt M8 x 16mm Boulon M8 x 16mm Perno M8 x 16mm 3 26 0065278 Shield heat cran de chaleur Pantalla para el calor 1 27 NoteC Fuel tank assembly Assemb complet du r servoir Conjunto tanque 1 27A 0064057 Fuel Cap Capuchon Tapa de combustible 1 27B 0061756 Fuel shut off with filter Robinet de carburant V lvula combustible con filtro 1 27C 0062673 Fuel Bushing Bague d essence Buje de combustible 1 27D 0064306 Fuel connector Connecteur carburant Conector combustible 1 28 0064107 Module low oil Module bas niveau d huile M dulo nivel bajo de aceite 1 29 __NoteB Washer flat 3 8 Rondelle plates 5 16 Arandela plana 5 16 2 30 0063830 Bracket low oil Support bas niveau d huile Soporte nivel bajo de aceite 1 31 0065271 Handle Poign e Manija 1 32 Note B Bolt 1 4 20 x 1 75 Boulon Perno 6 39 0063876 Cordset 25 foot 30 amp Ensemble de cordons 25 pieds 30A__ Juego de cord n 25 pies 30 amperios l 34 Note B Bolt 1 4 20 x 75 Boulon Perno 1 35 0062058 Wheel Roue Rueda 2 36 0050298 Switch Rocker Interrupteur Interruptor 1 37 0055894 Foot rubber Pied Pie 2 38 0062020 Screw 6 19 x 50 Torx Vis Tornillo 4 39 0062093 Washer Nylon 25 ID R
6. ondelle en nylon Arandela del nilon 4 40 0049352 Washer flat 5 16 W Rondelle plates 5 16 large Arandela plana 5 16 lejos 2 41 Note B Bolt 1 4 20 x 1 25 Boulon Perno 1 42 0052931 J clamp Collier Pinza vin lica 1 43 0062932 Spacer foot Entretoise Espaciador 2 44 0064072 Oil warning light Huiler l Avertissement Allume La luz de la advertencia para el aceite 1 45 0062567 Nut M8 Ecrous M8 Tuerca M8 2 46 00065180 Plastic cover Couvercle en plastique Cubierta de plastico 1 47 0065216 Screw 6 19 x 1 Vis Tornillo 5 48 0065179 Plastic bezel Cadre en plastique Bisel de plastico 1 49 0065181 Gasket Joint Empaque 1 50 0055982 01 Cord Keeper Cord Keeper Cord Keeper 2 PARTS LIST LISTE DES PIECES LISTA DE PIEZAS Ref Part Description Description Descripci n Qty No No 51 0064680 Generator head Senci T te de la g n ratrice Cabezal del generador Senci 1 51A 0064681 Adapter engine Adaptateur pour moteur _ Adaptor motor 1 51B 0064518 Rotor Rotor Rotor 1 51C 0064519 Stator Stator Estator 1 51D 0064520 Band stator cover Bande Banda 1 51E 0064521 Bolt M6 x 180 Boulon Perno 4 51F 0064522 Support bearing Support roulement Soporte Cojinete 1 51G 0064523 Brush module Brosser le module Cepille modulo 1 51H 0064524 Screw flg M5 x 16mm Vis Tornillo 5 511 0064525 AVR module La tension automatique El regulador autom tico del voltaje r gulatrice 1 51J 0064526 Bolt M5 x 220 Boulon Perno
7. riod will be limited to one 1 year from the date of purchase For warranty service the customer must provide dated proof of purchase and must notify the Company within the warranty period For warranty service Call toll free 800 445 1805 or write to Powermate Corporation Product Services 4970 Airport Road P O Box 6001 Kearney NE 68848 EXCLUSIONS AND LIMITATIONS THE COMPANY MAKES NO OTHER WARRANTY OF ANY KIND EXPRESS OR IMPLIED IMPLIED WARRANTIES INCLUDING WARRANTIES OF MERCHANTABILITY AND OF FITNESS FOR A PARTICULAR PURPOSE ARE HEREBY DISCLAIMED THE WARRANTY SERVICE DESCRIBED ABOVE IS THE EXCLUSIVE REMEDY UNDER THIS WARRANTY LIABILITY FOR INCIDENTAL AND CONSEQUENTIAL DAMAGES IS EXCLUDED TO THE EXTENT PERMITTED BY LAW This warranty gives you specific legal rights and you may also have other rights which vary from state to state Some states do not allow a disclaimer of implied warranties or the exclusion or limitation of incidental and consequential damages so the above disclaimers and exclusions may not apply to you PARTS DRAWING SCHEMA DES PIECES DIAGRAMA DE PIEZAS 32 27A 27 39 26 TORQUE SERREZ TORSION 30 50 FT LB 40 7 67 8 Nem TORQUE SERREZ TORSION 5 9 FT LB 6 8 12 2 Nem TORQUE SERREZ TORSION 8 17 FT LB 10 8 23 Nem PM0675700 PARTS LIST LISTE DES PIECES LISTA DE PIEZAS
Download Pdf Manuals
Related Search