Poulan 530088412 User's Manual
Contents
1. Disconnect spark plug before performing maintenance except for carburetor adjust ments Use only recommended Poulan PRO re placement parts use of any other parts may void your warranty and cause damage to your unit Empty fuel tank before storing the unit Use up fuel left in carburetor by starting engine and letting it run until it stops Do not use any accessory or attachment other than those recommended by manufac turer for use with your unit Do not store the unit or fuel in a closed area where fuel vapors can reach sparks or an open flame from hot water heaters electric motors or switches furnaces etc e Store in a dry area out of reach of children SPECIAL NOTICE Your blower is equipped with a temperature limiting muffler and spark arresting screen which meets the requirements of California Codes 4442 and 4443 All U S forest land and the states of California Idaho Maine Minnesota New Jersey Oregon and Washington require by law that many internal combustion engines be equipped with a spark arrestor screen If you operate a blower in a state or locale where such regulations exist you are legally re sponsible for maintaining the operating condi tion of these parts Failure to do so is a viola tion of the law SAFETY NOTICE Exposure to vibrations through prolonged use of gasoline powered hand tools could cause blood vessel or nerve damage in the fingers hands and joints of people prone to circ2. 2 years Any warranted part which is scheduled for replacement as required maintenance shall be warrantedforthe period of time up to the first scheduled replacement point for that part DIAGNOSIS The owner shall not be charged for diagnostic labor which leads to the determination that a war ranted part is defective if the diagnostic work is oi atan approved ELECTROLUX HOME PRODUCTS INC servicing center CONSEQUENTIAL DAMAGES ELEC TROLUX HOME PRODUCTS INC may be liable for damages to other engine compo nents caused by the failure of a warranted part still under warranty WHAT IS NOT COVERED All failures caused by abuse ne glect or improper maintenance are not cov ered ADD ON OR MODIFIED PARTS The use of add on or modified parts can be grounds for disallowing a warranty claim ELECTROLUX HOME PRODUCTS INC is not liable to cover failures of warranted parts caused by the use of add on or modified parts HOW TO FILE A CLAIM If you have any questions regarding your warranty rights and responsibilities you should contact your nearest authorized service center or call ELECTROLUX HOME PRODUCTS INC at 1 800 554 6723 WHERE TO GET WAR RANTY SERVICE Warranty services or re pairs shall be provided at all ELECTROLUX HOME PRODUCTS INC service centers Call 1 800 554 6723 MAINTENANCE REPLACEMENT AND REPAIR OF EMIS SION RELATED PARTS Any ELECTRO LUX HOME PRODUCTS INC approved re placement part used in the performa
3. does not cover tune ups spark plugs filters starter ropes starter springs cut ting line or rotating head parts that will wear and require replacement with reasonable use during the warranty period This warranty does not U cover predelivery setup or normal adjustments explained in the instruction manual THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE NO CLAIMS FOR CONSEQUENTIAL OR OTHER DAMAGES WILL BE ALLOWED AND THERE ARE NO OTHER EXPRESS WARRANTIES EXCEPT THOSE EX PRESSLY STIPULATED HEREIN SOME STATES DO NOT ALLOW LIMITA TIONS ON HOW LONG AN IMPLIED WAR RANTY LASTS OR THE EXCLUSION OR LIMITATIONS OF INCIDENTAL OR CONSE QUENTIAL DAMAGES SO THE ABOVE LIMITATIONS OR EXCLUSION MAY NOT APPLY TO YOU The policy of ELECTROLUX HOME PROD UCTS INC is to continuously improve its products Therefore ELECTROLUX HOME PRODUCTS INC reserves the right to change modify or discontinue models de signs specifications and accessories of all products at any time without notice or obliga tion to any purchaser EMISSION CONTROL WARRANTY STATEMENT YOUR WARRANTY RIGHTS AND OB LIGATIONS The U S Environmental Protection Agency and ELECTROLUX HOME PRODUCTS INC are pleased to ex plain the emissions control system warranty on your year 2002 2004 small off road en gine ELECTROLUX HOME PRODUCTS INC must warrant the emission control sys tem
4. or flame in cluding smoking open flames or work that can cause sparks in the areas where fuel is mixed poured or stored Mix and pour fuel in an outdoor area store fuel in a cool dry well ventilated place use an approved marked container for all fuel purposes Do not smoke while handling fuel or while operating the unit Make sure the unit is properly assembled and in good operating condition Do not fill fuel tank while engine is hot or running e Avoid spilling fuel or oil Wipe up fuel spills before starting engine e Move atleast 10 feet 3 meters away from fuel and fueling site before starting engine e Always store gasoline in a container ap proved for flammable liquids OPERATE YOUR UNIT SAFELY e Inspect unit before each use for worn loose missing or damaged parts Do not use until unit is in proper working order Keep outside surfaces free of oil and fuel Never start or run engine inside a closed room building or other unventilated area Breathing exhaust fumes can kill To avoid static electricity shock do not wear rubber gloves or any other insulated gloves while operating unit Do not set unit on any surface except a clean hard area while engine is running Debris such as gravel sand dust grass etc could be picked up by the air intake and thrown out through discharge opening damaging unit property or causing serious injury to bystanders or operator Avoid dangerous environments Do no
5. speed necessary to accom plish the task NOTE Always run the engine at idle speed for a few minutes to allow cooling before stop ping the engine SERVICE A WARNING Avoid touching muffler unless engine and muffler are cold A hot muffler can cause serious burns GENERAL RECOMMENDATIONS The warranty on this unit does not cover items that have been subjected to operator abuse or negligence To receive full value from the warranty the operator must maintain unit as instructed in this manual Various adjust ments will need to be made periodically to properly maintain your unit CHECK FOR LOOSE FASTENERS AND PARTS e Spark Plug Boot e Air Filter e Housing Screws CHECK FOR DAMAGED OR WORN PARTS Contact an authorized service dealer for re placement of damaged or worn parts ON STOP Switch Ensure ON STOP switch functions properly by moving the switch to the STOP position Make sure engine stops then restart engine and continue e Fuel Tank Do not use unit if fuel tank shows signs of damage or leaks INSPECT AND CLEAN UNIT AND DECALS e After each use inspect complete unit for loose or damaged parts Clean the unit and decals using a damp cloth with a mild deter gent e Wipe off unit with a clean dry cloth Cleaning the air filter A dirty air filter decreases engine perform ance and increases fuel consumption and harmful emissions Always clean or replace air filter after every 5 hours of oper
6. Instruction Manual Manual de Instrucciones Manuel d Instructions YU y The NS J IMPORTANT MANUAL Do not throw away MANUAL IMPORTANTE No lo descarte MANUEL IMPORTANT A Conserver WARNING Read the operator s manual and follow all warnings and safety instructions Failure to do so can result in serious injury Always wear eye protection ADVERTENCIA Lea el manual del operador y siga todas las advertencias e instruc ciones de seguridad El no hacerlo puede resultar en lesiones graves AVERTISSEMENT Lire le manuel de l utilisateur et bienrespecter tous les avertisse ments et toutes les instructions de s curit Tout d faut de le faire pourrait entra ner des blessures graves Electrolux Home Products Inc Electrolux Canada Corporation 250 Bobby Jones Expressway 6150 McLaughlin Road Augusta GA 30907 Mississauga ON L5R 4C2 Eg From the Electrolux Group The world s No 1 choice KITCHEN CLEANING AND OUTDOOR APPLIANCES COMBINED Copyright 02002 Electrolux Home Products Inc 530088412 12 3 02 HSITSNA 1 TONVdSA SIVONVHS SAFETY RULES WARNING Failure to follow all Safety Rules and Precautions can result in serious injury KNOW YOUR UNIT e Read your instruction manual carefully until you completely understand and can follow all warnings and safety rules before operat ing the unit e Restrict unit to users who understand and will follow all warnings and safety rules in
7. ation or yearly whichever comes first 1 Clean the cover and the area around it to keep debris from falling into the carbure tor chamber when the cover is removed 2 Remove parts as illustrated NOTE Donotclean filter in gasoline or other flammable solvent Doing so can create a fire hazard or produce harmful evaporative emis sions 3 Wash the filter in soap and water 4 Allow filter to dry 5 Apply a few drops of oil to the filter squeeze filter to distribute oil 6 Replace parts REPLACE SPARK PLUG Replace spark plug each year to ensure the engine starts easier and runs better Set spark plug gap at 0 020 inch Ignition timing is fixed nonadjustable 1 Twist then pull off spark plug boot 2 peeve spark plug from cylinder and dis card 3 Replace with Champion RCJ 6Y spark plug and tighten securely with a 3 4 inch socket wrench 4 Reinstall the spark plug boot CARBURETOR ADJUSTMENTS Your carburetor is equipped with limiter caps Carburetor adjustment is a complicated task We recommend that you take your unit to an authorized service dealer Damage may occur if you turn the needles beyond the limiter stops TROUBLESHOOTING TABLE A WARNING Always stop unit and disconnect spark plug before performing any of the recommended remedies below other than remedies that require operation of the unit TROUBLE CAUSE REMEDY Engine will not start 1 AON Engine flooded Fuel tank em
8. due to abuse neglect improper maintenance unapproved modifications or the use of parts not made or approved by the original equipment manufac turer You are responsible for presenting your small off road engine to a ELECTROLUX HOME PRODUCTS INC authorized repair center as soon as a problem exists Warranty repairs should be completed in a reasonable amount of time not to exceed 30 days Ifyou have any questions regarding your warranty rights andresponsibilities you should contact your nearest authorized service center or call ELECTROLUX HOME PRODUCTS INC at 1 800 554 6723 WARRANTY COM MENCEMENT DATE The warranty period begins on the date the small off road engine is purchased LENGTH OF COVERAGE This warranty shall be for a period of two years from the initial date of purchase WHAT IS COVERED REPAIR OR REPLACE MENT OF PARTS Repair or replacement of any warranted part will be performed at no charge to the owner at an approved ELEC TROLUX HOME PRODUCTS INC servic ing center If you have any questions regard ing your warranty rights and responsibilities you should contact your nearest authorized service center or call ELECTROLUX HOME PRODUCTS INC at 1 800 554 6723 8 WARRANTY PERIOD Any warranted part which is not scheduled for replacement as re quired maintenance or which is scheduled only for regular inspection to the effect of re pair or replace as necessary shall be war ranted for
9. e move the ON STOP switch to the STOP position Awarnine You MUST make sure the tubes are secure before using the unit A WARNING Try on the unit and adjust the shoulder straps for fit and comfort before starting the engine to avoid losing control of the unit Always start and run the unitin an up right position e Fuel engine Move at least 10 feet 3 me ters away from the fueling site e Hold the unit in the starting position as shown Make sure the blower end is di rected away from people animals glass and solid objects STARTING POSITION WARNING When starting engine hold the unit as illustrated Do not set unit on any surface except a clean hard area when starting engine or while engine is running Debris such as gravel sand dust grass etc could be picked up by the air intake and thrown out through the discharge opening damaging the unit or property or causing serious injury to by standers or the operator AA WARNING Avoid contact with the muffler A hot muffler can cause serious burns STARTING A COLD ENGINE or warm engine that has run out of fuel 1 Move ON STOP switch to the ON posi tion 2 Move the choke lever to the CLOSE posi tion 3 Slowly press the primer button located under the carburetor 6 times Choke Lever ri Primer Button 4 Squeeze throttle trigger and turn throttle adjuster clockwise until it stops Throttle a ON STOP Switch Throttl
10. e Tri Control rottle Trigger Handie 5 Pull starter rope sharply until engine runs NOTE Only shortpulls are necessary Nev er pull the starter cord to its fullest extension Never let go of the starter handle until it is at the fully returned position 6 Oncethe engine has started slowly move the choke lever to the OPEN position 5 7 Turn throttle adjuster counterclockwise to release throttle trigger and allow unit to idle STARTING A WARM ENGINE 1 Move the choke lever to the OPEN posi tion 2 Squeeze throttle trigger and turn throttle adjuster clockwise until it stops 3 Pull starter rope sharply until engine runs 4 Turnthrottle adjuster counterclockwise to allow unit to idle DIFFICULT STARTING or starting a flooded engine 1 Move the choke lever to the OPEN posi tion 2 Squeeze throttle trigger and turn throttle adjuster clockwise until it stops 3 Pull rope to clear engine of excess fuel This could require pulling the starter rope many times Continue to pull rope until engine starts 4 Turnthrottle adjuster counterclockwise to release throttle trigger and allow unit to idle If unit still doesn t start refer to the TROUBLE SHOOTING TABLE or call 1 800 554 6723 BLOWER OPERATION When the engine has warmed up the blower can be positioned on the back of the operator Once the blower is positioned and ready for operation utilize the throttle trigger to main tain an operating
11. g them until they lock in place 6 Remove throttle cable clamp from flexible tube Place throttle cable in clamp andre install on flexible tube OPERATION KNOW YOUR BLOWER READ THIS INSTRUCTION MANUAL AND SAFETY RULES BEFORE OPERATING YOUR UNIT Compare the illustrations with your unit to familiarize yourself with the location of the various controls and adjustments Save this manual for future reference Harness ON STOP Switch Throttle Throttle Control Handle Y Air Nozzle Muffler Primer Button ON STOP SWITCH CHOKE LEVER The ON STOP SWITCH is used to stop the en The CHOKE helps to supply fuel to the engine ine To stop the engine move the switch to the to aid in cold starting Activate the choke by TOP position moving the choke lever to the CLOSE position PRIMER BUTTON Once engine starts move choke lever to the The PRIMER BUTTON removes air from the OPEN position carburetor and fuel lines and fills them with fuel THROTTLE ADJUSTER This allows you to start the engine with fewer The THROTTLE ADJUSTER can be used to pulls on the starter rope Activate primer button select the speed of air flow To avoid holding by pressing it and allowing it to return to its origi your finger on the throttle trigger all the time nal position the required speed can be set with the throttle adjuster Full throttle is obtained by squeez ing the throttle trigger and moving the throttle adjuster clockwise until it stop
12. nce of any warranty maintenance or repair on emis sion related parts will be provided without charge to the owner if the part is under war ranty EMISSION CONTROL WARRANTY PARTS LIST Carburetor Ignition System Spark Plug covered up to maintenance schedule Ignition Module MAINTENANCE STATEMENT The owner is responsible for the performance of all required maintenance as defined in the instruction manual This engine is certified to be emissions compliant for the following use x Moderate 50 hours L Intermediate 125 hours L Extended 300 hours
13. on your small off road engine for the peri ods of time listed below provided there has been no abuse neglect or improper mainte nance of your small off road engine Your emission control system includes parts such as the carburetor and the ignition system Where a warrantable condition exists ELEC TROLUX HOME PRODUCTS INC will re pair your small off road engine at no cost to you Expenses covered under warranty in clude diagnosis parts andlabor MANUFAC TURER S WARRANTY COVERAGE If any emissions related part on your engine as listed under Emissions Control Warranty Parts List is defective or a defect in the mate rials or workmanship of the engine causes the failure of such an emission related part the part will be repaired or replaced by ELEC TROLUX HOME PRODUCTS INC OWN ER S WARRANTY RESPONSIBILITIES As the small off road engine owner you are responsible for the performance of the re quired maintenance listed in your instruction manual ELECTROLUX HOME PROD UCTS INC recommends that you retain all receipts covering maintenance on your small off road engine but ELECTROLUX HOME PRODUCTS INC cannot deny warranty solely for the lack of receipts or for your failure to ensure the performance of all scheduled maintenance As the small off road engine owner you should be aware that ELECTRO LUX HOME PRODUCTS INC may deny you warranty coverage if your small off road engine or a part of it has failed
14. pty Spark plug not firing Fuel not reaching carburetor Compression low AON al See Starting a Flooded Engine in Operation section Fill tank with correct fuel mixture Install new spark plug Check for dirty fuel filter replace Check for kinked or split fuel line repair or replace Contact an authorized service dealer Engine will not idle properly Engine will not accelerate lacks power or dies under a load ya AO N on a o Fuel not reaching carburetor Carburetor requires adjustment Crankshaft seals worn Compression low Air filter dirty Fuel not reaching carburetor Spark plug fouled Carburetor requires adjustment Carbon build up Compression low k M gt AUO NN Check for dirty fuel filter replace Check for kinked or split fuel line repair or replace See Carburetor Adjustment in Service and Adjustments section Contact an authorized service dealer Contact an authorized service dealer Clean or replace air filter Check for dirty fuel filter replace Check for kinked or split fuel line repair or replace Clean or replace spark plug and re gap See Carburetor Adjustment in Service and Adjustments section Contact an authorized service dealer Contact an authorized service dealer Engine smokes excessively Peo NS Choke partially on Fuel mixture inco
15. rrect Air filter dirty Carburetor requires adjustment PO M gt 00 A O Adjust choke Empty fuel tank and refill with correct fuel mixture Clean or replace air filter See Carburetor Adjustment in Service and Adjustments section Engine runs hot Fuel mixture incorrect Spark plug incorrect Carburetor requires adjustment Carbon build up A wh See Fueling Engine in Operation section Replace with correct spark plug See Carburetor Adjustment in Service and Adjustments section Contact an authorized service dealer LIMITED WARRANTY ELECTROLUX HOME PRODUCTS INC warrants to the original purchaser that each new Poulan PRO brand gasoline tool or attach ment is free from defects in material and work manship and agrees to repair or replace under this warranty any defective gasoline product or attachment as follows from the original date of purchase 2 YEARS Parts and Labor when used for household purposes 90 DAYS Parts and Labor when used for commercial professional or income producing purposes 30 DAYS Parts and Labor if used for rental purposes This warranty is not transferable and does not cover damage or liability caused by improper handling improper maintenance or the use of accessories and or attachments not specifically recommended by ELECTROLUX HOME PRODUCTS INC for this tool Additionally this warranty
16. s OPERATING POSITION e Operate power equipment only at reasonable hours not early in the morning or late at night when people might be disturbed Comply with times listed in local ordinances Usual recom mendations are 9 00 a m to 5 00 p m Monday though Saturday To reduce noise levels limit the number of pieces of equipment used at any one time To reduce noise levels operate power blowers at the lowest possible throttle speed to do the job Use rakes and brooms to loosen debris be fore blowing In dusty conditions slightly dampen sur faces or use a mister attachment when wa OPERATING TIPS ter is available i e To reduce the risk of hearing loss Conserve water by using power blowers associated with sound level s hearing instead of hoses for many lawn and garden protection is required applications including areas such as gutters e To reduce the risk of injury associated with screens patios grills porches and gardens contacting rotating parts stop the engine be e Watch out for children pets open windows fore installing or removing attachments Do or freshly washed cars Blow debris away not operate without guard s in place safely A e Use the full blower nozzle extension so the air stream can work close to the ground e After using blowers and other equipment CLEAN UP Dispose of debris in trash re ceptacles BEFORE STARTING ENGINE WARNING Be sure to read the fuel information in the safet
17. this manual A WARNING Inspect area before start ing unit Remove all debris and hard objects such as rocks glass wire etc that can rico chet be thrown or otherwise cause injury or damage during operation Use your unit as a blower for e Sweeping debris or grass clippings from driveways sidewalks patios etc e Blowing grass clippings straw or leaves into piles around joints or between bricks PLAN AHEAD e Always wear eye protection when operating servicing or performing maintenance on unit Wearing eye protection will help to prevent rocks or debris from being blown or ricochet ing into eyes and face which can result in blindness and or serious injury Eye protec tion should be marked Z87 Always wear foot protection Do not go barefoot or wear sandals Always wear respirator or face mask when working with unit in dusty environments Secure hair above shoulder length Secure or remove jewelry loose clothing or cloth ing with loosely hanging straps ties tas sels etc They can be caught in moving parts Do not operate unit when you are tired ill up set or if you are under the influence of alco hol drugs or medication Keep children bystanders and animals away from work area a minimum of 30 feet 10 meters when starting or operating unit Do not point the blower nozzle in the direc tion of people or pets HANDLE FUEL WITH CAUTION IT IS HIGHLY FLAMMABLE Eliminate all sources of sparks
18. tuse in unventilated areas or where explosive vapors or carbon monoxide build up could be present Do not overreach or use from unstable sur faces such as ladders trees steep slopes rooftops etc Keep firm footing and bal ance at all times Never place objects inside the blower tubes always direct the blowing debris away from people animals glass and solid objects such as trees automobiles walls etc The force of air can cause rocks dirt or sticks to be thrown or to ricochet which can hurt people or animals break glass or cause other damage Never run unit without the proper equip ment attached When using your unit as a blower always install blower tubes Check air intake opening and all blower tubes frequently always with engine stopped and spark plug disconnected Keep vents and discharge tubes free of de bris which can accumulate and restrict proper air flow Never place any object in the air intake open ing as this could restrict proper air flow and cause damage to the unit Never use for spreading chemicals fertiliz ers or other substances which may contain toxic materials To avoid spreading fire do not use near leaf or brush fires fireplaces barbecue pits ashtrays etc e Use only for jobs explained in this manual MAINTAIN YOUR UNIT PROPERLY e Have all maintenance other than the rec ommended procedures described in the in struction manual performed by an autho rized service dealer 2
19. ulation disorders or ab normal swelling Prolonged use in cold weather has been linked to blood vessel dam age in otherwise healthy people If symptoms occur such as numbness pain loss of strength change in skin color or texture or loss of feeling in the fingers hands or joints discontinue the use of this tool and seek medical attention An antivibration system does not guarantee the avoidance of these problems Users who operate power tools on a continual and regular basis must monitor closely their physical condition and the condi tion of this tool ASSEMBLY CARTON CONTENTS Outlet Tube Flexible Tube Hose Clamps Control Handle PTS oy Base Tube WARNING If you receive your unit assembled check each step to insure your unit is properly assembled and all fasteners are secure Follow all safety information in the manual and on the unit 1 Locate and identify all components 2 Connectthe flexible tube to the outlet tube on the engine Tighten the hose clamp 3 Remove bottom screw from control han dle Install the control handle against the flared area on the base tube with the ON STOP switch facing the engine Middle Tube Air Nozzle Throttle Cable Throttle Cable Clamp DONDARON 4 Connectthe base tube to the flexible tube Tighten the hose clamp 5 Assemble the air nozzle to the middle tube and connect the assembly to the base tube by pushing the tubes together and turnin
20. y rules before you be gin If you do not understandthe safety rules do not attempt to fuel your unit Contact your authorized service dealer or call 1 800 554 6723 FUELING ENGINE A WARNING Remove fuel cap slowly when refueling This engine is certified to operate on unleaded gasoline Before operation gasoline must be mixed with a good quality synthetic 2 cycle air cooled engine oil designed to be mixed at a ration of 50 1 A 50 1 ratio is obtained by mixing 2 6 ounces of oil with 1 gallon of unleaded gasoline DO NOT USE automotive oil or boat oil These oils will cause engine damage When mixing fuel follow the instructions printed on container Once oil is added to gasoline shake container momentarily to assure that the fuel is thoroughly mixed Always readand follow the safety rules relating to fuel before fueling your unit IMPORTANT Experience indicates that alcohol blended fuels called gasohol or using ethanol or methanol can attract moisture which leads to separation and formation of acids during storage Acidic gas can damage the fuel system of an engine while in storage To avoid engine problems empty the fuel system before storage for 30 days or longer Drainthe gas tank start the engine andlet it run until the fuel lines and carburetor are empty Use fresh fuel next season Never use engine or carburetor cleaner products in the fuel tank or permanent damage may occur TO STOP THE ENGINE e To stop the engin
Download Pdf Manuals
Related Search